2016 HONDA PILOT Engine Problems

On Friday, January 30th, I took my car into Bill Pearce Courtesy Honda in Reno NV, to get a pretty big service done for $3400. Basically the 100k service with new timing belt, spark plugs, etc. I wanted to make sure that this car would last 3-5 more years. A week later, my [XXX] old daughter took my car to the ski mountain for work and on the way, the car started making a loud knocking sound and started losing power. She called me in fear so I talked her through pulling off on the next exit. I met her up at the mountain and called a tow truck and had them tow to the Bill Pearce Courtesy Honda service department. The following day, which was Monday, I got a call from the service rep and he said they were going to figure out what was going on. At the...

The engine began sputtering and then shut off. I had it towed in to a third party mechanic we frequently use, and they confirmed that the engine had seized, and they could not ascertain the cause. It didn't seem to have anything to do with low oil. I wondered if it was an issue with the fuel pumps failing again, because they recently failed and we had to have them replaced. I checked our VIN number to see if there were any recalls for our 2016 Honda Pilot, and there weren't, but I did find recalls for 2016 Honda Pilots related to fuel pump failure (ID# 23V858000) and engine damage from connecting rod bearing wear (ID# 23V751000). I shared this information with the third party mechanic, and they suggested that this could very well be the cause of engine failure. I'm concerned that my Pilot has suffered related failures but...

Component or system that failed: The engine failed suddenly while driving. The suspected failure is an internal connecting-rod bearing or related bottom-end engine component. The vehicle is currently at a repair facility and the engine is available for inspection upon request. How safety was put at risk: The engine lost power suddenly and became inoperable while driving. This created a hazardous situation because the vehicle could no longer maintain speed or safely continue in traffic. Sudden engine failure without warning increases the risk of a crash, especially at highway speeds or in heavy traffic. Has the problem been reproduced or confirmed by a dealer or independent shop: An independent repair shop inspected the vehicle and confirmed that the engine has experienced a catastrophic internal failure and will not rotate. The timing belt was confirmed to be intact. The shop advised that the engine requires replacement. A dealer diagnostic is pending...

Mechanic at Lee Street Garage reported lower end noise issues with engine and told me they don't recommend fixing other issues until I have vehicle looked at by dealership (in case they can address potential engine failure issue linked below). I took vehicle to dealer and they reported $5000 in repairs (to fix other issues) - nothing about a potential recall - [XXX] for this issue. I understand this vehicle is not currently in any recall for this issue. I want to report as I do not want to pay for all the other repairs only to have the engine failure issue as noted above. I asked for trade-in value for vehicle and they said $2000 (blue book value, fair/lowest value estimate is - $6885) Link to maintenance advised by honda dealership. No mention of NHTSA article above nor any follow-up from Honda on the same as it is not...

The fuel injector failed which cause safety issues such as reduced speed, failing safety issues, and the car is misfiring and not running safely. When driving the car started to misfire and was not running correctly. It then reduced speed and the safety features were disabled. Yes this issue was confirmed by Ken Vance Honda in Eau Claire WI. There was a flashing check engine light, hill start assist problem, emissions system problem, power steering system problem, trailer stability assist problem, and vehicle stability assistance problem lights that came on. This is a known safety issue with 2016 Honda Pilot as Honda America did an extended warranty to cover the expense to replace the injectors. Unfortunately, our car missed the deadline by a few months to get this covered. Since this was a known defective part from the factory this should have been taken care of by Honda as a...

Complete engine failure, threw rod through block. Oil was changed in October, still has 2000 miles before needing changing again.

To Whom It May Concern, I am submitting this complaint to report ongoing engine and emissions system problems with my 2016 Honda Pilot that raise serious safety concerns and may be related to a broader defect currently under investigation. I purchased this vehicle from a dealership in April of 2024 and the issues began shortly afterward at approximately 67,000 miles. The vehicle currently has approximately 74,600 miles and has received regular oil changes and routine maintenance. The vehicle has repeatedly displayed emissions system warning messages and engine fault codes. It has experienced persistent engine misfiring even after a mechanic performed repairs on cylinder 1. In addition, the vehicle exhibits rough engine shaking during driving and idling, engine stalling, and rough or delayed gear changes continuously since 2024. Despite attempted repairs, the problems continue to occur to present. The stalling, misfiring, and unstable engine operation create a potential safety risk, particularly...

Engine noise, check engine light illuminating causing reduced engine power. Mechanic states rod bearing issue likely the cause

Driving the car the engine bearing went out and wrecked the engine which has caused the engine to be replaced.

Engine failure while on highway traffic in construction zone caused engine shut off, losing power steering and odd braking. I was driving on a split 4 lane highway (2 lanes each direction), with a large ditch median between the directional lanes. My direction had construction cones for several miles limiting traffic to 1 lane, still at a 65 MPH speed limit with heavy semi traffic. The right lane was closed for construction, so all traffic was lined in left lane, though maintaining the speed limit. A few hundred yards into the construction my check engine light came on, and then after a minute or so it started blinking but there was no place to pull over safely. I reduced speed and semi traffic was lining up behind me. Then the engine and rest of car shut off, losing power steering. I ended up weaving into the construction part and was...

We are being denied a repair that is exactly like the service recall Service Bulletin 24-001 Safety Recall: 2016 (&2018-19) Pilot Connecting Rod Bearing. They found metal shavings in the oil that are identical to vehicles that are covered. The dealership said they received 4 other 2016 Honda Pilots this week where the VIN wasn't in the range but the same issue. Honda is trying to avoid a recall when it is clear that all 2016 Honda Pilots are affected.

According to my mechanic there is the low end bearing noise and bearing chirp that indicates it lost oil pressure due to internal components and a damaged engine. recommends replacing the engine. He said because of the recall there are no remanufactured engines available. Computer diagnostics showed code P0303 #3 cylinder misfire. He believes this has to do with recall 23V-751or RQ24-013. No repairs have been done.

Most recently my engine started to have a clicking/knocking sound that was progressively getting worse. This happened within 1000 miles of replacing the timing belt. I now have a cylinder 2 failure and the dealer is recommending a $6000 plus complete used engine replacement with a warranty of only 12,000 miles. the knocking goes away if cylinder 2 plug is pulled. car has had multiple problems, 9-Speed Transmission Defect rough/delayed shifting, loud noises, harsh acceleration/deceleration, and sudden power loss, creating a safety risk. It has stopped at stoplights and failed to restart for 10-15 seconds. Auto Idle Stop (AIS) System: Claims that the engine doesn't always restart when the driver lifts their foot off the brake, a defect that has led to a class-action settlement.

Purchased my 2016 Honda pilot with 3.5 v6 engine at Baierl Honda in November 2024. In December 2025 my engine failed. Towed to dealer I purchased from . Mechanic said there is metal in the oil the motor is done and needs replaced. Many of these motors were recalled , but for some reason mine is not on the list. I still owe 12,000 on loan on this car. I contacted Honda said nothing they can do because it hasn't been recalled "yet". There were other recalls from Honda in the same motor. Why wasn't mine recalled?

I was driving and went through an intersection when all of a sudden the car automatically shifted into Neutral and lights started flashing and stalled. The engine ceased up. I checked to see if I had oil. I did. Prior to this event on multiple occasions while driving on the HWY and trying to accelerate the engine had problems getting into gear. This vehicle has made me feel unsafe multiple times while driving and shifting out of gear and now just stalling while driving. Honda has a huge problem with the engines.

My engine has failed at ~104K miles after regular and consistent maintenance. The failure (rod bearing) matches Recall 23V751 but my VIN was excluded.

Torque shutter, transmission oil burning quickly

Honda Pilot 2016 and 83K miles and original owner. The car was traveling at I-95 going to Vermont when the engine light come on the dashboard showing low pressure oil. The car was stopped in a safe place and called AAA and towed to nearest mechanic in Massachusetts. The mechanic diagnosed and said the engine is shut and needed to be replaced. I called American Honda and was being told to tow it to a Honda Service dealership nearby and we did. Confirmed by them that the engine was shut and they found a metal inside the engine which is caused by the rod bearing. The American Honda did nothing at all to address it. So frustrating. The car is still sitting on the Honda Service lot in Massachusetts. The cost to replace the engine with a used one is $7500.00

The contact owns a 2016 Honda Pilot. The contact stated that there was an abnormal engine knocking sound coming from the vehicle. There were recurring oil leaks and a misfire coming from the engine. The engine warning light was flashing. Additionally, the ESC, hill start assist, VSA, EPS, and steering low warning lights were illuminated. The vehicle was taken to an independent mechanic who confirmed the codes. The contact associated the failure with NHTSA Campaign Number: 23V751000 (Engine and Engine Cooling). The local dealer was not contacted, but the vehicle was not diagnosed or repaired. The manufacturer was not contacted. The failure mileage was approximately 160,000.

. We have owned our 2016 Pilot since 2023. We have never had a problem with it and have had the recommended maintenance performed on schedule. The incident of our engine failing, out of the blue, occurred when my husband drove from MN to Indiana and then he made it back to MN and the engine died literally at the exit to our hometown. Our Honda Pilot ran perfect when my husband drove from MN to IN with no problems at all. He made it all the way back to MN and when he took the exit to our town, a bunch of lights went off on the dashboard. There were several lights and I don't know exactly which ones unfortunately. He was able to get it into our driveway and it was unable to be started once he turned it off. We had to get it towed to the...

The vehicle experienced a sudden engine malfunction while being driven at highway speeds in the carpool lane under normal conditions. The engine began knocking and misfiring, followed by a significant loss of power. There were no warning lights, oil pressure alerts, or messages prior to the failure. The loss of power and engine knocking made it difficult to safely cross multiple highway lanes from the carpool lane to reach an exit, creating a serious safety hazard in active traffic. The driver exited the freeway as soon as safely possible, parked the vehicle, turned the engine off, and had it towed to prevent further damage or risk. The vehicle was towed home and then towed the following day to an authorized Honda dealership for inspection. The dealership confirmed the failure was caused by internal engine damage due to a connecting rod bearing failure, resulting in a misfire on cylinder 4. This...

FAILING ROD BEARING

This car was purchased new from Gustman Honda in Appleton WI. It was well maintained and never driven off road. On [XXX], my [XXX] old daughter was driving it to school. She was on [XXX] when the engine had a severe failure and several rods punctured the engine block. There were no warnings, no engine lights, etc. prior to this complete engine failure. Luckily she was going to school for an early morning class and there were few cars on the highway. She was able to get the car somewhat off the road and call called me for help. I had it towed to Jiggers Auto in Chilton WI where they determined the complete engine failure INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

warning engine light came on. Emission control system light came on too. Honda Pilot 2016 Milage 70,662. Vehicle operating normally. Had car parts store use OBD electronic scanner and it revealed a code P0328: "Knock Sensor voltage High". Code was deleted after scan. I was told by tech at car parts store that the sensor was detecting odd electronic signals and sent info to the cars computer, which intern made the computer to display the warning lights on the dash panel. Warning lights were then off, and then a day later, the engine warning lights came on again. There are no physical or audible signs that any mechanical errors are happening, The car/engine is operating as normal. next day; made appt with Honda dealership to check system with their equipment and the warning lights did not come on , prior to the trip to the dealership. Dealership scan (Dec 23,...

The car has 83K miles and the Honda Service said the engine needs to be replaced due to internal engine problem.

Rod bearing knocking noise.

When driving on highway, heard loud engine cranking sound, followed by sudden jolts of the car. Stopped the car in the road median and then noticed smoke coming out from under the hood. Passengers got out of the car and noticed fire under the engine; called 911 immediately, then police and fire engine arrived to extinguish fire. Towed the car to Local Honda Service center. Diagnosis from the service center mentions: "A CONNECTING ROD BROKE AND EXITED THROUGH THE ENGINE BLOCK/OIL PAN AREA ON BACK OF ENGINE. .... and ENGINE ASSEMBLY NEED TO BE REPLACED along with other fire damaged and water damaged parts/sections...." This looks to be related 2016 Honda Pilot Connecting Rod recall ( NHTSA recall# 23V-751 ). Car maintenance has always been done on-time at the Honda Service center (records available for inspection). There were no warning lights before the incidence. Insurance company has inspected the car...

Was at a complete stop and my car turned off and all my dash lights came on. ON THE FREEWAY

We had road issues recently and the care stalled on Thanksgiving. We ended up having it towed to 2 mechanics, the final mechanic determined that this issue is a recall for other Hondas. Ours is not listed. I called the recall hotline and they will not fix the car under the recall because they did not add our VIN number to the recall. They informed us we could pay for the repair and keep our receipt for reimbursement if/when the VIN number is added. I was not happy with this outcome as if it's a problem with other vehicles why are we not being added. The recall is "a manufacturing defect in the connecting rod bearing that could cause the engine to seize and fail, leading to stalling while driving."

Engine seized up and died. Towed to shop and needs to be replaced. There has been a recall on this model year due to an issue with rods in the engine, but I am being told my particular car does not qualify. Researching showed me that if any kind of claim was denied, to file a complaint with NHTSA.gov.

My check engine light come on and started flashing on 11/24/25 and came along with a knocking sound. Got it to the shop, and they confirmed that the vehicle has a rod bearing knocking in the engine. I see that this has been a frequent known issue with this specific car and believe my car should be apart of this recall

While driving home the car started making loud noises and lost power. I pulled over as quickly as possible and had the vehicle towed to a Honda dealer where they they reported: "New engine assembly (long block with heads) due to internal engine failure. Found metal shavings in engine oil when strained through filter and magnet ran across bottom of pan. includes engine replacement, gaskets and fluids" When researching my repair options I found that there were known issues with the 2016 Honda Pilot, but my vehicle was on included in the initial vin list.

Yes available for inspection. Was driving on highway when my engine lost power. Almost crashed and almost got rear ended on the highway. Mechanic said something about piston rod bearings? Very loud knocking noise when car is started now . Not able to use. Only 100k miles. Fully maintained. Has to be part of recall soon? Recall is for piston rod bearings. Same issue my pilot has.

Vehicle has approximately 145K miles and regularly maintained at the dealership. With no prior warnings, the low fuel pressure light came on, started jerking, and making noises, and was unable to start. The vehicle was towed to the nearest mechanic where they said the engine has failed. The car was driven up to that point with no warning signs.

What component or system failed or malfunctioned, and is it available for inspection upon request? The Engine failed in a matter of seconds on the Interstate to where the vehicle was inoperable making a loud knocking sound and every system light on the dashboard turned on. We were able to take it to a local Oil Shop that was within a few miles and had them check on the car. The mechanic stated the oil looked brand new even though we just had it changed 2 months ago and he couldn't service the inside of the vehicles engine. We had to have it towed over 100 miles to Chicago. To a Honda Dealership that stated the engine looked like it was starved of Oil. How was your safety or the safety of others put at risk? Vehicle violent started shaking while myself, my wife, and our three kids were in...

All engine rod bearings had to be replaced due to engine knocking. Vehicle had 61,379 miles when repair was performed 10/02/25. Repair was performed by the manufacturer's dealership.

Incident happened on November/22/2025 was driving on a major highway with 2 other persons in the vehicle the check engine light began to flash and all the power form the engine was lost immediately pulled over. Called the Honda dealer when they opened took it to them to look at engine was knocking was told at the dealer there was metal in the oil and the knock is coming from the bottom of the engine. The engine is in non repairable shape and needs an engine replacement

Following all repair/recall/warranty work recommended by Honda, the Auto Stop/Start feature is again failing. This results in the vehicle not restarting after the auto idle engine stop is engaged while in traffic, stop lights, stop signs etc. This is a random occurrence, but results in a significant safety hazard as a stopped vehicle in a lane of travel. This is a recurring issue, no specific date of incident.

Driving the car the engine bearing went out and wrecked the engine. I had to replace the engine.

Car engine developed a knock in the lower end We took it to the dealerships service department and they accessed it to have connecting rod bearing failure It is not safe drive with this issue as major engine failure is very possible We have owned this car for 8 years and done all recommended maintenance and repairs

Engine light came on when driving and started running bad. Engine now making a knocking noise. Connecting rod knocking sound. Had to tow the vehicle home on a trailer.

The contact owns a 2016 Honda Pilot. The contact stated that while driving at 40 MPH, the check engine warning light illuminated. The contact pulled over to the right side of the road and waited for towing assistance. A dealer was contacted. The vehicle was towed to the dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 144,000.

The V6 3.5L engine in the 2016 Honda Pilot EX-L sounds horrible when shifting. It sounds like it is sticking, and in a way lurches. It is especially noticeable around 40mph, but you can audibly hear it shift at all gears. I am concerned that this vehicle should have been part of the previous 2023 recall, or should be looked at for the current 2025 investigation of the connecting rod bearing failures. I am almost afraid to drive the vehicle. The engine sounds awful.

The engine started to knock. Upon taking it to an independent inspection it was determined to be the rod bearings and crankshaft. We find it to be consistent with the sympthoms described in the investigation RE25008 opened in August 20, 2025.

My wife was driving our pilot on the highway. It suddenly started to get a flashing check engine light and the car immediately and abruptly slowed down, and was not able to accelerator or keep speed with traffic around her. Then the car would lurch when trying to hold it stopped at a stop light or sign when idling. We took it straight to a mechanic and they ran a scan on the Pilot and said that the flashing check engine light was due to a severe engine warning and when they investigated they found that I had rod knocking in the engine and the engine would need to be replaced due to faulty rod bearings.

Engine locked up and honda says that my vin is not part of the recall

On Wednesday, October 22, 2025, my friend was driving my 2016 Honda Pilot on Interstate 10 in New Orleans when all the dashboard warning lights came on and the engine started clicking/ticking. He was on a bridge and had to pull to the side of the bridge during rush hour traffic. He said it was very unsafe and was afraid to stay with the car due to the high volume of traffic. The car was towed to the nearest Honda dealership. The dealership ran diagnostics on it and told me that it needs a new engine. The dealership checked to see if the vehicle was part of the connecting rod recall and confirmed the vehicle is not. Prior to this event, the car was running great. My brothers, who are retired mechanics, towed the car back home. They said a connecting rod is knocking and the car does not need...

We have owned our 2016 Pilot since 2023. We have never had a problem with it and have had the recommended maintenance performed on schedule. The incident of our engine failing, out of the blue, occurred when my husband drove from MN to Indiana and then he made it back to MN and the engine died literally at the exit to our hometown. Our Honda Pilot ran perfect when my husband drove from MN to IN with no problems at all. He made it all the way back to MN and when he took the exit to our town, a bunch of lights went off on the dashboard. There were several lights and I don't know exactly which ones unfortunately. He was able to get it into our driveway and it was unable to be started once he turned it off. We had to get it towed to the dealer...

The start/stop function caused the engine to shut off. At times we have to shake the battery to get the engine to go back on. We have replaced the battery and that didnt fix the issue. The dealership said they couldn't recreate the problem. The issue hasn't been inspected by anyone but the dealership and there were no warning messages or lights.

Started hearing rattling sound on acceleration yesterday. Today heard it again. Engine light came on and a lot of other safety lights came on and noted less power with hitting accelerator. Took it to dealer. They are investigating but say it is the connecting rod bearing failure that so many Hondas have. My car currently is not in the recall list by Honda. It is a 2016 Pilot, 105,000 miles