2001 FORD FOCUS Engine Problems

KEEPS SHUT OFF N OVER HEATING

KEEPS OVER HEATING. *TR

2001 FORD FOCUS ZX3 STALLS WHEN DRIVING AND ALMOST CAUSED SOMEONE TO REAR END MY CAR. NOW WONT STAY RUNNING WHEN IDLING. CAR CUTS OFF AT LIGHTS OR STOP SIGNS OR WHEN BREAKING OR ENGAGING CLUTCH.

CAR WAS DRIVING FINE RUNNING A FEW ERRANDS. STOPPED AT A STORE FOR ABOUT FIVE MINUTES , WHEN I GOT BACK IN AND STARTED THE ENGINE ALL I HEARD WAS A LOUD CLANKING NOISE AND THE IDLE WAS ROUGH. DID A LITTLE RESEARCH ABOUT THE CAR AND DISCOVERED ALL THE COMPLAINTS ABOUT ENGINE FAILURE . SO THATS WHAT HAPPENED TO MINE . DROPPED VALVE SEAT.

WAS ON MY WAY TO THE VA HOSPITAL 04/04/2018 STARTED CAR, IT WOULD SHAKE VIGOROUSLY. CHECK ENGINE LIGHT AND OIL FUEL LIGHT KEEP COMING ON AND OFF. HAD A COMPLETE TUNE UP. GOING TO THE VA HOSPITAL ON 4/16/2018 START CAR, CHECK ENGINE LIGHT CAME ON AND FUEL LIGHT CAME ON AGAIN. HAD INNER TIRE RODS REPLACED. GOING TO A VA APPT, ON 05/10/2018 START CAR CHECK ENGINE LIGHT CAM ON, CV VALVES REPLACED. 5/30/2018 ON MY WAY AGAIN TO THE VA HOSPITAL, START CAR CHECK ENGINE LIGHT CAME ON AGAIN. PLEASE ADVISE, SINCE IT VERY DIFFICULT TO MISS AND RESCHEDULE APPTS AT THE VA HOSPITAL. THANK YOU.

THIS CAR HAS ELECTRICAL ISSUES,THE DASH AND TAG LIGHTS FLICKER,THE CAR HAS BEEN TURNING OFF WHILE I'M DRIVING WITH MY SON IN THE CAR OVER 3 TIMES NOW,ON THE HIGHWAY AND ON MAIN STREET,ITS SO SCARY I'VE HAD PANIC ATTACKS AND GOT A STRESS RASH ON MY FACE. IM SO SCARED THAT I CAN'T DRIVE IT,I'VE HAD THE FUEL PUMP REPLACED,SPARK PLUGS,MOTOR FILTER.I JUST TRY TO KEEP GETTING IT REPAIRED COSTING ME MY BILLS MONEY BEING A SINGLE PARENT. I'M OVERWHELMED AND DON'T KNOW WHAT TO DO.

MY CAR IS 2001. I STARTED TO HAVE PROBLEMS WHEN TURNING ON. I THIUGHT IT WAS STARTER. BUT MINES THATS STILL GOOD. I THOUGHT ALTERNATOR OR BTTERY BUT THEY ARE NEW. SO THEY CHECKED WITH CAMERA AND VALVE PISTNS NOT WORKING. I LOOKED UP REVIEWS ABOUT CAR MAKE AND YEAR. MANY COMMENTS READ VALVE BENT. PISTONS GONE BAD. NOW IM ANOTHER OWNER WITH SAME PROBLEM. THIS CAR IN REVIEWS IS CONSIDERED A LEMON. GOOD THING IT DIDNT WANT TO TURN ON WHEN IT WAS PARKED ALREADY AT HOME. I READ OTHERS OCCURRED IN MOTION.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING 40 MPH, THE ENGINE STALLED WITHOUT WARNING. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND THE VEHICLE RESTARTED NORMALLY AFTER SOME TIME. THE FAILURE RECURRED SEVERAL OTHER TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 107,333.

NO DASH LIGHT TAIL LIGHTS OR MARKRR LIGHTS

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE TIMING BELT NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 105,000.

DRIVING FORD FOCUS SLOWLY IN SNOW,A JEEP SPUN OUT OF CONTROL HIT THE DRIVERS SIDE FRONT OF CAR SPUN AROUND AND HIT US AGAIN FROM THE REAR.AIRBAG DEPLOYED AND IT MY PASSENGER FULL IN FACE. DAMAGED HER FACE WITH CHEMICAL BURNS AND CREATED A COROIDITAL TEAR IN HER EYE THAT IS PERMANENT AND PERMANENT VISION LOSS IN ONE EYE. THE IMPACT OF THE AIRBAG JARRED HER BRAIN AND SHE NOW HAS A BRAIN INJURY CALLED CHIARI MALFORMATION,

AFTER A 2~ HOUR DRIVE, ENGINE WAS TURNED OFF AND RESTARTED 5MIN LATER. AN INTAKE VALVE SEAT DROPPED AND IT INSTANTLY SMACKED THE PISTON ON THE FIRST TURN OF THE ENGINE, IT HIT HARD ENUF TO BLOW THE PISTON APART AND THE CONNECTING ROD PUT A HOLE THRU THE PISTON LINER. PUTTING COOLANT IN TO THE CRANK CASE, AS IT WAS NO LONGER CONNECTED TO THE PISTON ANY MORE. NEEDLESS TO SAY IT WAS NOT ABLE TO DRIVE. I REPAIRED THE AUTO WITH A AFTERMARKET HEAD FROM HTTP://CIFICINC.NET/ AND A SHORT BLOCK OUT OF A PARTS CAR. AFTER DOING SOME RESEARCH IM NOT THE ONLY PERSON TO HAVE THIS FAILURE, THERE ARE FOCUS ALL OVER THE NET THAT HAVE HAD THIS FAILURE. I SEEM TO BE LUCKY AS ITS MUCH MORE COMMON FOR IT TO HAPPEN AROUND 110/140K THEN 206K THE ESCORT ALSO HAS THE SAME ENGINE OR ONE OF...

TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STOP ACCELERATING AND RESPONDING WHEN DEPRESSING THE ACCELERATOR PEDAL.THE SPEED OF THE VEHICLE WOULD NOT INCREASE PAST 30 MPH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE SPARK PLUGS, BUT THE FAILURE CONTINUED TO OCCUR. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS 200,000.

TL* THE CONTACT OWNED A 2001 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 60 MPH, THE VEHICLE CAUGHT FIRE. THE VEHICLE WAS DESTROYED AND TOWED TO THE SALVAGE YARD. THE CAUSE OF THE FAILURE WAS UNKNOWN. THE MANUFACTURER WAS NOTIFIED. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 65 MPH, THE VEHICLE STARTED TO JERK AND THE CONTACT SMELLED SMOKE. THE BATTERY WARNING INDICATOR ILLUMINATED. THE CONTACT STATED THAT THE VEHICLE WAS STOPPED ON THE SIDE OF THE ROAD AND THE IGNITION WAS TURNED TO THE OFF POSITION AS THE CONTACT EXITED THE VEHICLE. THE CONTACT OBSERVED FLAMES UNDER THE HOOD OF THE VEHICLE. THE VEHICLE RESTARTED WITHOUT BEING PROMPTED AND STARTED ROLLING FORWARD. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. A POLICE REPORT WAS FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A TOW YARD WHERE IT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE AND THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 02V288000 (ELECTRICAL SYSTEM). THE FAILURE MILEAGE WAS APPROXIMATELY 130,000.

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THE TECHNICIAN WAS UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 50,000.

1.ENGINE FADES OR LOSES POWER RAPIDLY DURING EXECUTION OF FREEWAY- SPEED TURNS (OFF RAMPS FOR EXAMPLE) WITHOUT BRAKING; I HAVE GONE FROM 50 TO 20 MPH WITHIN 1-2 SECONDS WHILE IN FRONT OF ANOTHER VEHICLE AND SEMI (VERY DANGEROUS). THE VEHICLE WAS TUNED AND TYPICAL PARTS REPLACED FOR SMOG CHECK A FEW MONTHS AGO AND PASSED SMOG CHECK WITHOUT COMMENTS. THIS PROBLEM STARTED AROUND 100K AND HAS HAPPENED TO OTHER DRIVERS WHO BORROW MY CAR. THE FORD DEALERSHIP (SERRAMONTE FORD) WAS UNABLE TO RECREATE THE PROBLEM SO I PAID 150 DOLLARS FOR A CAN OF FUEL ADDITIVE AND LOST USE OF THE CAR FOR 8 HOUR EVEN THOUGH I WAS ASKED TO DROP IT OFF START OF MORNING. 2. NOW IT STUTTERS OR HESITATES DURING HIGH ACCELERATION (IE PASSING LANE OR GOING UPHILL) ON HIGHWAY; THE VEHICLE IS NO LONGER RELIABLE ESP. IF YOU SHOULD NEED TO RAPIDLY INCREASE POWER....

I WAS DRIVING ON INTERSTATE 5 IN PORTLAND OR. MY ENGINE JUST STOPPED!! RIGHT IN THE MIDDLE LANE OF TRAFFIC. LUCKILY IT WAS EARLY RUSH HOUR SO IT WAS STOP AND GO TRAFFIC. BUT, WAS VERY SCARY AND DIFFICULT TO GET MY CAR OFF THE FREEWAY. I WAS TOLD THAT 2001 FORD FOCUS'S HAVE A FUEL LINE PROBLEM THAT HAS BEEN RECALLED. I PURCHASED THIS CAR IN 2008. THERE WAS ONLY 1 PREVIOUS OWNER. THIS RECALL WAS NOT REPAIRED ON THIS CAR. PLEASE HELP. THANKS *TR

AS I WAS DRIVING HOME AFTER DROPPING MY DAUGHTER OFF THE CAR JUST STOPPED. I LET IT ROLL TO A COMPLETE STOP AND THEN PUT IT IN PARK. I TRIED TO CRANK THE CAR AND I GOT NOTHING. ALL THE LIGHTS, HORN, AND ALL STILL WORKS BY THE ENGINE DOES NOTHING. *TR

WAS DRIVING MY CAR AT 55 MPH AT 11:20 PM ON WAY HOME FROM WORK CAR MADE JERK LOST ALL POWER NO BRAKES NO STEERING BLACK SMOKE COMING THROUGH VENTS TO INSIDE OF CAR AND FLAMES COMING FROM UNDER HOOD CAR FULLY ENGULFED IN FLAMES BLEW UP. *TR

SUNDAY 05 JAN 2014 I HAD RECENTLY PARKED MY CAR, TURNED IT OFF, AND WAS OUTSIDE OF MY VEHICLE (2001 FORD FOCUS) WHEN I BEGAN TO NOTICE SMOKE COMING FROM THE HOOD OF THE VEHICLE. I WAS CONFUSED AT FIRST, AS THE CAR WAS COMPLETELY OFF FOR A FEW MINUTES BEFORE ANY PROBLEMS BEGAN. WITHIN A MATTER OF TWO MINUTES THE SMOKE HAD INCREASED, THICKENED, AND BEGAN TO SMELL. MY FRIEND WAS NEARBY AND HAD NOTICED THAT SOMETHING WAS NOT RIGHT. HE CAME OVER AND WE BOTH TOOK A COUPLE STEPS TOWARD THE FRONT OF THE CAR TO FIGURE OUT WHAT WAS GOING ON. IMMEDIATELY FLAMES BURST UP FROM THE HOOD. AT THIS POINT WE INSTANTLY RAN FROM THE VEHICLE, DIALING 911. THE FLAMES GOT WORSE AS WE WAITED FROM A DISTANCE FOR THE FIRE DEPARTMENT TO ARRIVE. AT THIS POINT I WAS UNSURE AS TO WHETHER THE CAR WOULD...

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE PARKED, SHE HEARD A LOUD GRINDING NOISE AS OIL AND RADIATOR FLUID LEAKED FROM UNDER THE VEHICLE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSIS. THE MECHANIC STATED THAT THE ENGINE WOULD HAVE TO BE REPLACED BECAUSE THE VALVE STEM HAD FRACTURED, CAUSING THE PISTON TO DETACH FROM THE ENGINE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000. *TR

I WAS AT THE GAS STATION FILLING UP THE CAR WHEN I WAS FINISHED I WENT TO START THE CAR ONLY TO HEAR A SOUND THAT REMINDED ME OF RUNNING OVER COINS WITH A VACUUM AND THEN ALL OF A SUDDEN THE VEHICLE TURNED OFF AND WOULD NOT RESTART. I HAD THE CAR TOWED TO MY PLACE OF RESIDENCE AND MY FATHER-IN-LAW LATER ON HAD IT TOWED TO A MECHANIC SHOP. THE MECHANIC THERE SAID THAT THE VALVE SEAT BROKE OFF AND MESSED UP THE HEAD AND CANNOT BE REPAIRED IT HAS TO BE REPLACED. I HAVE SINCE BEEN WITHOUT A VEHICLE. I ALSO HAVE BEEN DOING SOME RESEARCH ON THIS MATTER AND HAVE FOUND THAT THIS HAS BEEN AN ONGOING PROBLEM WITH OTHERS AND THEIR FORD FOCUS. *TR

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE ENGINE EXPLODED WHILE SITTING IDLE AT A TRAFFIC STOP. THERE WERE NO INJURIES. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO DETERMINE THE CAUSE OF THE FAILURE. THE FAILURE AND THE CURRENT MILEAGES WERE 197,000. *TR

FORD MOTOR COMPANY KNEW AND HAS KNOW FOR YEARS ABOUT BAD VALVE SEATS IN THEIR 2000-2004 FOCUS'S WITH 2.0L SPLIT PORT INJECTION ENGINE. WHERE EVER THESE HEADS WERE MADE , THE QUALITY CONTROL FOR THIS PART WAS NOT EVALUATED PROPERLY. THE ENGINE DROPS A 'PRESSED IN' STEEL VALVE SEAT THAT FALLS INTO THE CYLINDER AND PUTS TOO MUCH STRESS ON THE PISTON, BORE, AND CONNECTING RODS OF THE ENGINE. UNDER THIS STRESS IT GENERALLY WILL CAUSE RODS TO BREAK, WARP OR COME THROUGH THE BLOCK WALL. (WHICH IS WHAT HAPPENED TO MY ENGINE). IT MAY BE A COOLING PROBLEM, IT MAY BE FAULTY DESIGN OR POOR CRAFTSMANSHIP. REGARDLESS, IF THIS CAR WON SO MANY AWARDS OVER IT'S LIFETIME FROM MOTOR TREND OR OTHER INSTITUTIONS....THEN THEY SHOULD BE BACKING THE MANY PEOPLE WHO HAVE HAD TO FORK OUT THOUSANDS IN ENGINE REPAIRS AND PARTS TO FIX THIS PROBLEM. IT SEEMS TO...

I HAVE A 2001 FORD FOCUS LX WITH 199,871 MILES ON IT AND ITS MY FIRST FORD CAR. I HAVE OWNED MANY OF FORD TRUCKS IN MY LIFE AND ALWAYS FIXED PROBLEMS WITH THEM MYSELF. BUT WITH MY FOCUS, EVERY TIME IN THE PAST 4 YEARS WHEN I TURN A CORNER ROUGHLY AROUND 15 MPH OR OVER, IT CUTS OUT AND THE CAR BOGS OUT AND JUMPS LIKE THE ENGINE IS GOING TO JUMP OUT THEN I GET A BAD SMELL ALMOST LIKE SULFUR COMING FROM THE CAR. ALL FLUID LEVELS ARE GOOD WITH A FULL GAS TANK. THIS HAPPENS WHETHER THE CAR IS HOT OR COLD. USUALLY I CAN JUST PUNCH THE GAS PEDAL TO THE FLOOR AND IT WILL EVENTUALLY GAIN RPM'S AGAIN AND GO WITH NO PROBLEMS UNTIL I TURN SHARP AGAIN. I HAVE RECENTLY REPLACED SPARK PLUGS AND CABLES, ALTERNATOR, TRANSMISSION AND CLUTCH PLATE, FUEL PUMP...

SATURDAY MAY 04/2013 MY CAR KILLED OVER 30 TIMES DRIVING ABOUT 5 MILES. THIS HAPPENED LAST YEAR DOING 60MPH ON THE FREEWAY. IT IS IMPOSSIBLE TO RESTART A MANUAL TRANSMISSION AT THIS SPEED. IN THIS CASE, I DROVE INTO THE SERVICE DEPARTMENT OF FORD OF BELLEVUE AND IT CONTINUED TO KILL WHILE THERE TRYING TO MOVE IT. THE SERVICE PERSON BLEW ME OFF WOULDN'T EVEN TAKE THE TIME CHECK IT OUT OR EVEN LISTEN. AS I WAS DRIVING OUT IT KILLED TOO MANY TIMES TO COUNT. THE SALES MANAGER SAID TO BRING IT IN MONDAY. SUNDAY IT STOPPED KILLING. WHEN I BROUGHT IT IN MONDAY, I ASKED FOR THE SERVICE MANAGER, THE SERVICE EMPLOYEE WENT TO FIND HIM & IT TOOK ABOUT 10 MINUTES, THAT WAS CURIOS AS THE PLACE WAS DESERTED. WHEN THE SERVICE MANAGER ARRIVED, HE REFUSED TO DISCUSS THE MATTER ONLY SAYING WE WERE BUSY. I HAD...

2001 FORD FOCUS. CONSUMER REQUEST REIMBURSEMENT FOR REPAIRS AND INVESTIGATION FOR POSSIBLE RECALL. *SMD THE CONSUMER IS REQUESTING AN INVESTIGATION INTO THE COMMON PROBLEM OF VALVE SEAT BREAKAGE IN FORDS OLDER ENGINES. THE BREAKAGE WAS DUE TO INTAKE VALVE SEATS THAT WERE MADE OF A POWERED METAL THAT SHATTERED EASILY. THE CONSUMER WROTE TO FORD REQUESTING REIMBURSEMENT FOR THE DAMAGE CAUSED TO HER ENGINE. ON SEPTEMBER 17, 2012, ROUGHLY TWO MILES AFTER EXITING THE HIGHWAY, THE CONSUMER CAME TO A COMPLETE STOP AT A RED LIGHT. WHEN THE LIGHT TURNED GREEN, SHE ENGAGED THE GAS PEDAL, AND THE VEHICLE BEGAN TO MAKE AN UNUSUAL NOISE AND JERKED LOUDLY AND VIOLENTLY. SHE WAS ABLE TO DRIVE THE VEHICLE ABUT TWO MORE FEET, BEFORE THE STEERING SEIZED. THE VEHICLE WOULD NOT GO INTO NEUTRAL AND IT DIED COMPLETELY AND HAD TO BE PUSHED TO A PARKING LOT ON THE SIDE OF THE...

I WAS STOPPED AT A RED LIGHT, WHEN THE LIGHT TURNED GREEN AND I ENGAGED THE GAS PEDAL THE CAR BEGAN TO CLANK AND JERK LOUDLY AND VIOLENTLY. I DROVE' THE CAR ABOUT TWO FEET BEFORE THE STEERING SEIZED UP, THE CAR COULD NOT BE PUT INTO NEUTRAL, DIED COMPLETELY, AND HAD TO BE PUSHED TO THE SIDE OF THE ROAD. ONE OF THE PISTONS, CYLINDER # 1, WAS EXTENSIVELY DAMAGED, DUE TO THE VALVE SEAT FAILURE WHICH SHATTERED THE PISTON, BROKE OFF PIECES OF THE PISTON SKIRT, AND BENT THE CONNECTING ROD. NO DAMAGE WAS DONE TO THE CYLINDER WALL, BUT PIECES OF THE PISTON SKIRT WERE FOUND IN THE OIL PAN, AND PIECES OF THE PISTON CROWN WERE FOUND IN THE BOTTOM OF INTAKE MANIFOLD. VALVE SEAT BREAKAGE IN THE OLDER MODEL FOCUS, IS SO COMMON THAT AERA ENGINE REBUILDERS ASSOCIATION ISSUED TWO BULLETINS (TB 1725 & TB...

DRIVING ON 4 LANE HIGHWAY, CAR SPUTTERS AND STALLS AS IF OUT OF GAS. COASTED OFF ROAD, AND AFTER A FEW MINUTES CAR STARTED AND RAN FINE. CAR HAS BEEN DOING THIS EVERY FEW WEEKS. CHANGED COIL, PLUGS, PLUG WIRES, OXYGEN SENSOR, FUEL FILTER, CAT CONVERTER AND STILL STALLS. THIS CAR IS DANGEROUS WHEN IT STALLS IN FAST TRAFFIC. WE ONLY DRIVE IT NOW DURING DAYLIGHT AND SHORT TRIPS BECAUSE IT IS NOT DEPENDABLE. *TR

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS THE VEHICLE OVERHEATED WITHOUT ANY WARNING. THE VEHICLE WAS TAKEN TO A DEALER MULTIPLE TIMES WHO WAS UNABLE TO DIAGNOSE THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 92,000 AND THE CURRENT MILEAGE WAS 93,000.

MY LAST OIL CHANGE I WAS INFORM THE FRONT SUBFRAME IS BADLY RUSTED, TO THE POINT THE MECHANIC COULD PUSH A SCREW DRIVER THROUGH IT IN SPOTS. HE INFORMED ME THAT DRIVING IT WAS A MAJOR SAFETY RISK, AS THE FRAME COULD FAIL, CAUSING AN ACCIDENT. HE SAID FORD HAS NOT ISSUED A RECALL. THEY MUST BE WAITING FOR A HIGHER BODY COUNT WHEN THE FRONT END OF THE CAR FAILS WHILE GOING DOWN THE INTERSTATE. *TR