2001 FORD FOCUS Engine And Engine Cooling Problems

TL* THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STATED THAT THE FRONT DRIVER'S SIDE FLOOR MAT BECAME WET. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS DIAGNOSED THAT THE CONDENSER BOX TO THE AIR CONDITIONING UNIT WAS CRACKED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE AND CURRENT MILEAGE WAS UNKNOWN. *TR

ON 7/27/2012, THE CAR CAUGHT ON FIRE WHILE BEING DRIVEN. THE SMOKE STARTED COMING INTO THE INTERIOR THROUGH THE VENTS. WHEN ATTEMPTING TO PULL OVER,THERE WAS NO BRAKE (MY GUESS IS THAT THE BRAKE LINE HAD MELTED.). MY HUSBAND USED THE E BRAKE AND PARK TO STOP AND SOMEONE YELLED...GET OUT OF THE CAR.MY HUSBAND AND SON JUMPED OUT AND THE CAR BECAME ENGULFED. THERE IS NOTHING LEFT. HE TOLD ME THAT JUST BEFORE THAT IT STARTED HESITATING SOME,LIKE IT WAS GOING TO CUT OFF, BUT DIDN'T. FOR A MORE DETAILED STATEMENT PLEASE CONTACT HIM. I AM SO THANKFUL THAT THEY GOT OUT... THANK YOU, *TR

ENGINE SUDDENLY HAD NO OIL IN IT. IN TURN, THE ENGINE IS NOW BLOWN. *TR

MY MAIN COMPLAINTS ARE THE POWER WINDOWS, AIR CONDITIONING, FUEL SYSTEM ISSUE 3 OF THE 4 POWER WINDOW MECHANISM IN MY CAR HAVE BROKEN AND TWO ARE WEDGED UP, WHICH WASN'T A HUGE SAFETY CONCERN TO ME BECAUSE I RARELY HAVE PEOPLE IN THE REAR SEATS. NOW, I HAVE TO DECIDE IF I SHOULD FIX MY DRIVER WINDOW OR WEDGE IT. IT IS A SAFETY CONCERN FOR ME BECAUSE IF I GET INTO AN ACCIDENT AND CANNOT OPEN MY WINDOW THEN I MIGHT MAKE IT OUT ALIVE. MY A/C IS BROKEN AS WELL SO IN THE SUMMER MONTHS, I NEED TO CHOOSE TO EITHER FIX MY A/C OR FIX MY POWER WINDOW SO THAT I CAN HAVE VENTILATION. ALSO, I HAVE BEEN TRYING TO GET AN ISSUE FIXED WITH THE FUEL SYSTEM AS IT SOMETIMES LURCHES IN THE MIDDLE OF DRIVING. IT HASN'T STALLED ON ME YET IN THE MIDDLE...

I'VE HAD NUMEROUS PROBLEMS WITH MY FORD FOCUS AND DESPITE REGULAR MAINTENANCE I'VE BEEN STRANDED ON THE SIDE OF A HIGHWAY COUNTLESS TIMES.THUS FAR I'VE REPLACED THE ENGINE TWICE. TWICE I'VE HAD TO REPLACE THE ALTERNATOR. MY THROTTLE DOES NOT RETURN TO IDLE AND HAS UNEXPECTED MOMENTS OF ACCELERATION AND I'VE HAD TO REPLACE THE ENGINE THROTTLE SENSOR. BOTH OF MY FRONT COIL SPRINGS HAVE BROKEN AND WERE VERY CLOSE TO PUNCTURING MY TIRES. AFTER TAKING MY VEHICLE TO NUMEROUS MECHANICS NONE OF THEM HAVE BEEN ABLE TO DIAGNOSE WHY MY CAR SHAKES SO BADLY. I HAVE VERY POOR VISIBILITY AT NIGHT WITH THE EXTERIOR LIGHTING WHICH IS SIGNIFICANTLY LESS COMPARED TO OTHER VEHICLES. MY FAN HAS HAD TO BE REPLACED SINCE IT WAS MALFUNCTIONING AND MY CAR WAS HAVING PROBLEMS OVERHEATING AS WELL. DURING THE COURSE OF ALL OF THESE CAR MALFUNCTIONS, I'VE BEEN IN DANGEROUS SITUATIONS ON THE...

I HAVE HAD A FORD FOCUS 2001 FOR TWO YEARS AND IN THOSE YEARS I HAVE HAD TO REPLACE THE ENGINE AND ENGINE MOUNTS. I HAVE FOUND OUT THAT THIS I COMMON PLACE IN ALMOST ALL FORD FOCUS'S. I FEAR THAT THIS CAR MIGHT LEAVE ME ANYWHERE, NOW ONE WEEK AGO THE IGNITION CYLINDER HAS BROKEN. THIS IS NOT WEAR AND TEAR. I DEMAND THAT THESE CARS OF 1998 THREW 2003 BE LABELED AS LEMONS AND HAVE FORD ISSUE A RECALL OR REIMBURSEMENTS ON THEM. *TR

TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 15 MPH, THE VEHICLE SUDDENLY STALLED. THE CONTACT PULLED OVER AND WHEN HE RESTARTED IT, THE VEHICLE FUNCTIONED PROPERLY. THE DEALER, WHEN CONTACTED, STATED THAT THEY WERE UNAWARE OF SUCH A PROBLEM. THE FAILURE CONTINUED TO OCCUR INTERMITTENTLY. THE MANUFACTURER STATED THAT THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS RELATED TO THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 129,000. THE CURRENT MILEAGE WAS 130,275.

TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING AT APPROXIMATELY 10 MPH, THE ENGINE STALLED. THE CONTACT TRIED TO RESTART THE VEHICLE AFTER A MINUTE IT WOULD NOT START UP. THE CONTACT THEN NOTICED SMOKE EMITTING FROM THE HOOD WHICH SOON BECAME A FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE AND A FIRE REPORT WAS FILED. THE VEHICLE WAS TOTALED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 93,000. UPDATED 6/21/10 *CN UPDATED 06/24/10.*JB

IGNITION STICKS AND MOVES AROUND, HORN FELL COMPLETELY OUT FROM UNDER THE CAR AND HIT SOMEONE'S CAR, THE FAN BOX AND ALL FELL COMPLETELY OFF AND DOWN, BACKFIRING STALLING RATTLING VIBRATES FRONT RIGHT SIDE AROUND TIRE AREA RATTLES HORRIBLY, CHECK ENG. LIGHT STAYS ON MASS AIR FLOW SENSOR IS BAD TRANSMISSION SENSOR IS BAD LIGHTER STOPPED WORKING CAR COMPLETELY GOES DEAD SPITS SPUTTERS, MANIFOLD PIPE BROKE SO NOW ITS LOUD. ITS ALL DAY LONG NON STOP PERIOD WE HAVE REPLACE SEVERAL SENSORS AND TUBES AND WIRES FOR IT DOESN'T WORK NOT GETTING THE GAS MILEAGE I SHOULD AND I HAVE HAD IT 11 MONTHS BUT HARDLY DOVE IT 3 TOTAL ALL TOGETHER I CANT AFFORD ANY THING ELSE TO FIX THESE PROBLEMS 3 DAYS AFTER I BOUGHT IT ITS BEEN PURE ?!@#$%. *TR

THE CONNECTING ROD BROKE IN THE ENGINE. OUR MECHANIC SAID THAT ALMOST ALL 2001 FORD FOCUS HAS THIS PROBLEM. I KNOW I HAVE 130,000 MILES ON THE VEHICLE BUT I KEPT UP WITH ALL RECALLS AND MAINTENANCE. JUST LUCKY WE MADE IT HOME SAFE. IF THERE IS SUCH A PROBLEM WITH MOST FOCUS WHY WASN'T IT FIXED BY FORD BEFORE A BREAK DOWN AND LOST OF MY VEHICLE. *TFR

OUR DAUGHTERS 2001 FORD FOCUS CAUGHT ON FIRE FROM THE ENGINE, BURNED INTO THE CABIN. THE CAR WAS OFF AND PARKED IN A LOT. WE PURCHASED THE CAR FROM A FORD DEALERSHIP WHEN IT WAS 3 YEARS OLD, AND HAVE NEVER BEEN TOLD OF THIS PROBLEM. THE CAR HAS BEEN TOTALED. WE ARE SO FORTUNATE THAT OUR DAUGHTER WAS NOT INJURED, NOR THAT ANYONE ELSE OR PROPERTY WAS DAMAGED. SHE HAD ONLY BEEN OUT OF THE CAR FOR ABOUT 4-6 MINUTES BEFORE IT ERUPTED IN FLAMES. PRIOR TO THAT THE CAR APPEARED TO DRIVE FINE. NO SMELLS, NO WARNING LIGHTS. VERY SCARY. I FELT THAT I NEED TO TELL SOMEONE, AS THE INSURANCE COMPANY, APPEARS TO WANT TO JUST SETTLE THE CLAIM, WITH NO INVESTIGATION. HOW ARE WE TO MAKE CARS SAFER, IF THE INSURANCE COMPANIES, THE LAST LINE OF DEFENSE, DON'T NOTIFY ANYONE? *TR

TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING APPROXIMATELY 35 MPH ON NORMAL ROAD CONDITIONS, THE ENGINE BEGAN TO IDLE EXCESSIVELY HIGH. ON A SEPARATE OCCASION, THE VEHICLE STALLED WITHOUT WARNING AND LOST POWER STEERING. THE DRIVER EXPERIENCED EXTREME DIFFICULTY STEERING THE VEHICLE AND HAD TO USE EXCESSIVE FORCE TO TURN THE STEERING WHEEL. THE VEHICLE WAS ABLE TO RESUME NORMAL OPERATION. THE FAILURES OCCURRED INTERMITTENTLY. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THEY WANTED TO CHARGE THE CONTACT FOR A DIAGNOSTIC; HOWEVER, THE CONTACT REFUSED DUE TO THE COST. THE TECHNICIAN REFUSED TO REPAIR THE VEHICLE UNLESS THE AFTERMARKET PARTS WERE REPLACED BY THE MANUFACTURER. THE PARTS CONSISTED OF THE PCV VALVE AND FUEL FILTER. THE VEHICLE HAS NOT BEEN REPAIRED. THE MANUFACTURER CONDUCTED A CAMPAIGN (03V-482) TO ADDRESS THE STALLING IN THE VEHICLES. THE CONTACT EXPERIENCED THE IDENTICAL FAILURES MENTIONED IN THE CAMPAIGN, BUT THE...

THE ENGINE SNAPED AND NOW THE CAR IS NO LONGER WORKING. HOWEVER PRIOR TO THAT IT WOULD IDLE ACTING AS IF IT WAS STALLING OUT AND MAKING NOISES. *TR

TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE PURCHASING THE VEHICLE, THE CONTACT WAS INFORMED THAT THE MOTOR MOUNTS, WHICH HOLD THE ENGINE IN PLACE, NEEDED TO BE REPLACED. SHE WAS INSTRUCTED TO BRING THE VEHICLE TO THE DEALER THE FOLLOWING DAY FOR REPAIR. WHEN SHE ARRIVED AT THE DEALER, SHE WAS INFORMED TO LEAVE THE VEHICLE. WHEN THE CONTACT ARRIVED TO RETRIEVE THE VEHICLE TWO DAYS LATER, THE DEALER REFUSED TO PROVIDE PAPERWORK STATING THAT THE VEHICLE WAS REPAIRED. ONE WEEK LATER, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED AND A LOUD RATTLING SOUND WAS HEARD COMING FROM THE ENGINE. SHE CALLED THE DEALER TO RETURN THE VEHICLE FOR REPAIR, BUT THEY REFUSED TO TAKE HER CALLS. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP AND A MECHANIC STATED THAT THE MOTOR MOUNTS WERE NEVER REPLACED AND WOULD COST $3,000. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS...

ON HOT DAYS AFTER THE CAR HAS BEEN BROUGHT UP TO OPERATING TEMPERATURE AND IS RESTARTED IT GOES INTO A MODE WHERE IT CONSISTENTLY STALLS AT IDLE AND LOW RPM. IT HAS A MANUAL TRANSMISSION. THIS IS AN INTERMITTENT PROBLEM AND ONLY OCCURS SOME OF THE TIME. NETHER FORD OR INDEPENDENT MECHANICS HAVE BEEN ABLE TO DIAGNOSE AND FIX THE PROBLEM. INTERMITTENT AND UNEXPECTED STALLING IS A SIGNIFICANT SAFETY PROBLEM. *TR

THERMOSTAT HOUSING HAS STARTED LEAKING COOLANT. THIS IS REPORTEDLY A COMMON FAILURE ON FOCUS WITH 2.0L DOHC ENGINE (ZETEC). THE THERMOSTAT HOUSING FAILURE MAY OR MAY NOT BE A CONNECTION TO THE VALVE COVER LEAKING OIL ONTO THE THERMOSTAT HOUSING AND HOT EXHAUST MANIFOLD WHICH PRODUCES A FAINTLY NOTICEABLE BURNING SMELL WHEN DRIVING. *TR

WAS DRIVING HOME AND ENGINE BEGAN KNOCKING AND GOT LOUDER AND WHEN I RETURNED HOME HAD MY HUSBAND LOOK AT IT AND FOUND 3 MOTOR MOUNTS WERE RUSTED OFF. DEALERSHIP REPLACED MOTOR MOUNTS A WEEK LATER AT MY COST AND DIDN'T GIVE ME A RENTAL CAR. *TR

THE VALVE COVER GASKET LEAKS PREMATURELY, WHICH CAUSES OIL TO DRIP ONTO THE EXHAUST MANIFOLD. THE BURNING OIL CREATES FUMES. THE POORLY DESIGNED SEALS AROUND INTAKE AIR BOX ALLOW FUMES FROM THE ENGINE COMPARTMENT TO ENTER THE PASSENGER COMPARTMENT. THESE TWO DESIGN FAILURES COMBINE WITH EACH OTHER TO EXPOSE PASSENGERS TO BURNING OIL FUMES. NOW, I HAVE TO REPLACE THE VALVE COVER GASKET TO AVOID EXPOSING MYSELF TO BURNING OIL FUMES. *TR

TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE CONTACT STARTED THE IGNITION AND THE VEHICLE MADE A STRANGE NOISE. THE ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE COULD NOT BE DRIVEN. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER FOR A DIAGNOSTIC. THE CURRENT AND FAILURE MILEAGES WERE 125,000.

I BOUGHT THIS CAR IN JUL07. IN DEC07 STARTED HAVING PROBLEMS WITH CAR SURGING/JOLTING WHILE DRIVING ON HIGHWAY (55-65 MPH) THEN CAR WOULD JUST STALL, COMPLETELY DIE. ENGINE LIGHT WOULD COME ON, NO POWER STEERING NO LIGHTS. I WOULD MANAGE TO GET IT OVER TO THE SIDE OF THE ROAD NARROWLY AVOIDING ACCIDENT AND CAR WOULD NOT START. AFTER SAT FOR ABOUT 10 MINS IT WOULD START. IT WOULD DRIVE OK FOR ABOUT 10-20 MILES AND THEN SURGE AND DIE. IT HAPPENS PERIODICALLY AND IN BETWEEN THE CAR MAY DRIVE FINE FOR WEEKS. SERVICE CENTER CAN'T FIND ANYTHING WRONG WITH IT. IT JUST HAPPENED AGAIN 3-18-08 WHILE I WAS DRIVING ON INTERSTATE AT 65MPH, JOLTED TWICE AND COMPLETELY DIED. I WAS NEARLY KILLED AS A SEMI WAS BEHIND ME AND ANOTHER BESIDE ME. I HAD TO FIGHT THE CAR TO GET IT OFF THE SIDE OF THE ROAD AND NARROWLY...

TL*THE CONTACT OWNS A 2001 FORD FOCUS. WHILE DRIVING APPROXIMATELY 25 MPH AND APPROACHING A TRAFFIC LIGHT, THE BATTERY LIGHT ILLUMINATED. THE CONTACT NOTICED SMOKE COMING FROM THE HOOD AND THEN FLAMES APPEARED. SHE STOPPED AND EXITED THE VEHICLE WHEN IT BECAME COMPLETELY ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENTS ARRIVED AND A REPORT WAS FILED. THE VIN, ENGINE SIZE, AND POWERTRAIN WERE UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 52,899. UPDATED 04/11/08 *BF THE DEALER STATED CONSUMER HAD VEHICLE IN A PINCH BOLT TORQUED AND A ZETEC ENGINE CABLE ROUTING. THE DEALER ALSO REPLACED BOTH FRONT COIL SPRINGS. UPDATED 04/11/08 *TR

TL*THE CONTACT OWNS A 2001 FORD FOCUS. THE ENGINE LIGHT WOULD ILLUMINATE AND THE VEHICLE WOULD STALL, STUTTER, SKIP, AND NOT RUN WHEN THE TANK REACHED A QUARTER TANK. INITIALLY, THE CONTACT WAS INFORMED THAT THE CYLINDER HEAD NEEDED TO BE REPLACED. THEN SHE WAS INFORMED THAT THE TIMING BELT, GEAR, PULLEY, AND TENSIONER NEEDED TO BE REPLACED. THE COMPONENTS WERE REPLACED. FINALLY, THE CONTACT WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. FORD STATED THAT THE VEHICLE WAS MANUFACTURED TOO LATE TO BE INCLUDED IN NHTSA CAMPAIGN ID NUMBER 03V482000 (FUEL SYSTEM, GASOLINE). THE PURCHASE DATE AND SPEED WERE UNKNOWN. THE CURRENT MILEAGE WAS 88,000 AND FAILURE MILEAGE WAS 83,073. UPDATED 03-04-08 *BF\THE FUEL PUMP WAS REPLACED.

I AM THE SECOND OWNER OF THIS VEHICLE THE DAY AFTER I PURCHASED THE 2001 FORD FOCUS THE ENGINE LIGHT CAME ON AND I HAD LOSS OF POWER. I TOOK IT BACK TO THE DEALERSHIP AND THEY REPLACED SOME PARTS AND ALSO HAD REPLACED A FEW RECALLED PARTS. THE ENGINE AT THAT TIME HAD 78,000 MILES ON IT. I HAVE OWNED THE CAR FOR A YEAR AND A HALF IT CURRENTLY HAS 128,000 MILES ON IT NOW AND HAD TO REPLACE SERVERAL PARTS WHICH ARE OXYGEN SENSORS CATALYC CONVERTER, STRUTS, SHOCKS AND IDLE PULLEY. I GET MY OIL CHANGES AND TUNE UPS ON A REGULAR BASIS. ONE MORNING WENT TO START MY CAR TO GO TO WORK AND IT WOULD NOT START. IT WAS ACTING AS IF IT HAD RUN OUT OF GAS BUT I HAD OVER A HALF OF TANK OF GAS IN IT. AFTER TRYING TO START IT...

2001 FORD FOCUS. ORIGINAL OWNER. MAINTAINED. SPARK PLUG BLEW OUT OF CYLINDER. DEALER SUGGESTED MOST EXPENSIVE FIX - NEW CYLINDER HEAD AND SPARK PLUGS. NOT COVERED BY WARRANTY. WILL INSTEAD JUST GET SPARK PLUGS RETHREADED AND TRADE IN CAR ASAP BEFORE ANY OTHER MAJOR ISSUES. CAR LOST POWER. WAS AT A STOP LIGHT AND THEN MADE A RIGHT TURN. LOST POWER AND LOUD EXPLOSIVE NOISES RESULTED ON FREEWAY ACCESS ROAD. POLICE HAD TO COME OUT UNTIL TOW. DANGEROUS SITUATION. *TR

BOUGHT NEW IN '01 FORD FOCUS. NOTICED RIGHT OFF BRAKES WOULD MAKE A GRINDING NOISE AND SQUEAK. TIRES WERE WORN REAL BAD ON INSIDE ON ONE FRONT SIZE SINCE WE BOUGHT IT. REPEATED ALIGNMENTS WITH NO IMPROVEMENT. STILL EXPERIENCE THIS PROBLEM. STARTED EXPERIENCING PROBLEMS WITH IT MISSING DURING ACCELERATION. CHECK ENGINE LIGHT CAME ON IN FEBRUARY 2005 AND TOOK IT TO THE DEALERSHIP. THEY REPLACED SENSORS THAT HAD RECALL,WAS RECALL CODE P0401. ENGINE LIGHT STAYED ON. THEY SAID THAT WE WERE USING GAS THAT WAS DIRTY AND WAITING TOO LATE TO PUT GAS INTO THE CAR AND THAT WAS WHY IT WAS STALLING. WE PAID $272.98 FOR THEM TO REPLACE THIS WHOLE SECTION THAT HAD TO DO WITH THE FUEL BEING FILTERED. CAR LOSES POWER AND STUTTERS GOING AROUND CURVES WITH EVEN OVER A HALF A TANK OF GAS. STALLING TO THE POINT WE MUST PULL OVER INTO THE EMERGENCY...

TL* - THE CONTACT OWNS A 2001 FORD FOCUS WITH A CURRENT AND FAILURE MILEAGE OF 140,000. THE CONTACT STATED THAT SHE WAS DRIVING 55 MPH ON A HOT DAY AND THE VEHICLE WOULD SPUTTER AND LOSE ACCELERATION , THEN LOST POWER. THE CONTACT STATED THAT THE ENGINE WOULD STALL, BUT THE CAR WOULD STILL BE DRIVING UNTIL THE CONTACT APPLIED THE BRAKES. THE CONTACT HAD THE MECHANIC CHANGED THE SPARK PLUGS, WIRES, AND FUEL FILTER, BUT THE PROBLEM PERSISTED. THE CONTACT CALLED THE MANUFACTURER, AND THEY TOLD HIM TO TAKE IT TO THE FORD DEALER TO GET IT DIAGNOSED. THE MECHANIC STATED THAT IT WAS A FAILURE IN THE FUEL DISTRIBUTION SYSTEM, BUT THE PARTS WERE ON NATIONWIDE BACK ORDER. *AK

TL* - THE CONTACT OWNS A 2001 FORD FOCUS ZX3. THE CONTACT PURCHASED THE VEHICLE ,AND TWO WEEKS LATER THE HEAT STOPPED WORKING. THE CONTACT STATED THAT SHE TOOK THE VEHICLE TO THE DEALER FOR REPAIRS, AND THEY DID AN INCOMPLETE REPAIR JOB. THE DEALER GOT THE HEAT TO WORK BUT IT ONLY WORKED WHEN THE CONTACT TURNED THE HEAT ON HIGH. THE CONTACT STATED THAT ON A REALLY BAD SNOW DAY SHE SMELLED RUBBER BURNING AND TURNED THE HEAT OFF AND OPENED THE WINDOW. SHE HAD TO SHUT THE WINDOW AND TURN THE HEAT BACK ON, AND WHEN SHE DID FUMES BEGAN TO GATHER IN THE VEHICLE, AND THE ENTIRE VEHICL WAS FILLED WITH SMOKE. THE CONTACT CONTINUED TO DRIVE HOME WHEN THE CAR SHUT DOWN ENTIRELY. FORD AND TOYOTA GAVE HER THE RUN AROUND CONCERNING REPLACING THE VEHICLE AND A TRADE IN. THE CONTACT WAS INSTRUCTED TO CONTINUE...

DT: THE CONTACT STATED WHILE DRIVING 35 - 40 MPH, THE CHECK ENGINE LIGHT AND BATTERY LIGHT ILLUMINATED. WHILE PULLING THE VEHICLE INTO A PARKING LOT ALL THE DASHBOARD LIGHTS DARKENED AND THE VEHICLE HESITATED AS IF IT WAS GOING TO STALL. IT WAS PARKED FOR ABOUT 3 MINUTES AND THE VEHICLE WOULD NOT RESTART. THE VEHICLE WAS OBSERVED BY AN INDEPENDENT MECHANIC WHO DETERMINED THAT A BARREN CAME OUT OF ONE OF THE PULLEYS HOWEVER THAT WOULD NOT CAUSE THE VEHICLE TO STALL. THE VEHICLE WAS LEFT AT THE SCENE OF THE INCIDENT. TWO DAYS LATER THE CONTACT RETURNED TO THE VEHICLE AND THE VEHICLE WAS BURNED. THE INSURANCE INVESTIGATOR OBSERVED A SECURITY VIDEO WHICH IDENTIFIED THE VEHICLE SMOKING AND A WINDOW HAD FALLEN.

EVENTS LEADING UP TO THE FAILURE: CHECK ENGINE LIGHT CAME ON HAS NEVER GONE OFF SINCE, HIGHLY INCREASED RUNNING NOISE, ENGINE HESITATION THAT AT HIGHWAY SPEED IT CAUSES THE WHOLE CAR TO JERK FAILURE: I TOOK THE CAR IN AND THEY TOLD ME I NEEDED A NEW HEAD THAT FORD HAD REDESIGNED A NEW ONE AND IT WOULD COST $1000. THE ONE I CURRENTLY HAVE DEPOSITS CARBON AND WILL KEEP DOING SO UNTIL IT EVENTUALLY GIVES OUT. THE THING THAT IRKS ME IS FORD OBVIOUSLY KNEW THERE WAS A DESIGN FLAW IF THEY DESIGNED A NEW ONE, THEREFORE I FEEL THEY SHOULD BE COVERING THIS. CORRECTIONS: NONE, CANNOT AFFORD. WILL HAVE TO DRIVE IT UNTIL THE CAR GIVES OUT.

2001 FORD FOCUS IGNITION CYLINDER BROKE, PROBLEMS WITH THE TIRE EQUIPMENT, ENGINE LIGHT ILLUMINATED AND THE SWAY BAR BUSHING NEEDS TO BE REPLACED.*MR THE IGNITION CYLINDER HAD BEEN REPLACED THREE TIMES. THE STEEL BELTS WERE SHOWING THROUGH THE FRONT TIRES AT 54000 MILES. THE SENSOR WHICH CAUSED THE ENGINE LIGHT TO ILLUMINATED WAS REPLACED THREE TIMES. THE FRONT BRAKES WERE REPLACED TWICE. THE BATTERY, RADIATOR, THERMOSTAT AND FUEL PUMP ALSO FAILED. *NM

THE DRIVER HEARD A HUMMING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE NOISE ESCALATED WHILE THE VEHICLE ACCELERATED. CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD, AND REMAINED ON. THEN, VEHICLE STALLED. DRIVER WAS UNABLE TO RESTART VEHICLE, AND HAD IT TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT DRIVER'S SIDE WHEEL BEARING NEEDED TO BE REPLACED DUE TO CORROSION. ALSO, THE ENGINE NEEDED A SENSOR. *AK

THE VEHICLE TENDS TO STALL UNEXPECTEDLY AT VARIOUS SPEEDS. TAKEN TO DEALER FOR CHECK UP, AND THE COMPUTER WAS RESET. THE STALLING STILL PERSISTS, AND THE DEALER HAS NOT DETERMINED A CAUSE.*AK

MY 2001 FORD FOCUS HAS STALLED AGAIN. THIS IS ABOUT THE 4TH TIME. LOCAL MECHANIC FOUND PROBLEM TO BE FUEL INJECTOR PUMP. DEALERSHIP CLAIMS THAT IS ONLY BATTERY REPLACEMENT. I HAVE ALL OLD PARTS FROM RECENT SERVICE AT DEALERSHIP. I WOULD LIKE TO SEE THIS VEHICLE RECALLED. FOUND INTERNET ARTICLE THAT STATES THAT THIS IS NOT AN UNCOMMON PROBLEM WITH THIS MAKE/MODEL. HTTP://WWW.THEAUTOCHANNEL.COM/F/MANIA/REPAIR/NEWS.HTML?MANIA. *JB

DIRVE THE CAR FOR 30 MINUTES OR LONGER (ENGINE IS HOT). STOP, AND RESTART IT FROM 15 TO 30 MINUTES LATER, AND THE CAR WILL CONTINUALLY STALL SO LONG AS THE CLUTCH IS COMPLETELY DEPRESSED. THIS WILL HAPPEN VERY PREDICTABLY UNDER THESE CONDITIONS. IT IS CLEARLY TEMPERATURE RELATED, AS RESTARTING THE CAR JUST 5 MINUTES LATER WHEN STILL VERY HOT, OR AN HOUR LATER WHEN COOLED DOWN, AND THERE IS NO STALLING. DEALER (ATHOL FORD) BELIEVES IT IS RELATED TO THE IDLE AIR CONTROL VALVE, BUT REFUSES TO FIX IT, EVEN THOUGH IT WAS TAKEN IN WHILE STILL UNDER WARRANTY. DEALER ALSO CLAIMS TO HAVE NO KNOWLEDGE OF ANY TSB RELATED TO THIS ISSUE.*AK

CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD. VEHICLE STALLED. CONSUMER WAS UNABLE TO RESTART VEHICLE, AND HAD IT TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC DETERMINED THAT THE FUEL PUMP NEEDED TO BE REPLACED. *AK

CONSUMER COMPLAINED ABOUT AN ONGOING HESITATION PROBLEM. VEHICLE HAD BEEN TO DEALER ON SEVERAL OCCASIONS, BUT PROBLEM RECURRED. *AK

WHILE DRIVING VEHICLE STALLED INTERMITTENTLY. CONSUMER PULLED OVER AND RESTARTED THE VEHICLE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

THE VEHICLE STALLED ON TWO SEPARATE OCCASIONS. *JB THE SPEEDOMETER IN THE VEHICLE ALWAYS READS ZERO. THE MILAGE ERASE ON THEIR OWN AND POP UP AGAIN DAYS LATER THEN DISAPPEAR AGAIN. THE CONSUMER STATED THAT HE HAS TO TURN THE VEHICLE OFF AND TURN IT ON AGAIN TO READ THE GAS GAUGE. AUTOMATIC LOCKS ENGAGE 20 MINUTES AFTER THE CONSUMER HAS STARTED DRIVING. THE VEHICLE STEERING WHEEL BECAME HARD TO MOVE AS THE VEHICLE LOSS POWER AND SHUT DOWN ON SEVERAL OCCASIONS. *TC

VEHICLE WAS TAKEN TO THE DEALERSHIP FOR A ROUTINE GENERAL MAINTENANCE, AND MECHANIC DETERMINE THAT ENGINE WAS LEAKING OIL. SERVICE MANAGER INDICATED TO THE CONSUMER THEY WILL FIX THE PROBLEM FOR $100.00. BUT HE HAD TO SIGN AN AGREEMENT IF THE JOB WAS NOT SATISFACTORY DEALERSHIP WAS NOT RESPONSIBLE. THE SETTLEMENT HAD TO BE RESOLVED BY A LOCAL ARBITRATOR. VEHICLE WAS STILL LEAKING OIL.*AK

WHILE AT A STOP SIGN OR DRIVING VEHICLE STALLED. CONSUMER RESTARTED VEHICLE. DEALERSHIP WAS NOTIFIED, BUT DID NOT RESOLVE THE PROBLEM. *AK

WHILE DRIVING AT ANY SPEED ENGINE HESITATED INTERMITTENTLY. AS A RESULT, VEHICLE WAS ALMOST REAR ENDED. A RECALL WAS ISSUED FOR THE ENGINE STALLING, HOWEVER THIS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *AK

MY CAR JUST STARTED TO STALL OUT.. I HAD FORD REPLACE THEW FUEL FILTER AND PUMP STILL HAS THAT PROBLEM.

AFTER THREE UNSECCESSFUL ATTEMPTS TO HAVE MY FORD FOCUS REPAIRED FOR ENGINE STALLS(WHILE ON THE HIGHWAY WITH THE KIDS IN THE BACK SEAT,WITH 18-WHEELER BEHIND ME).IIONCE AGAIN TOOK MY CAR TO FORD FOR WARRANTY WORK.THEY FOUND THAT THE FUEL PUMP WAS NOT SUPPLING ENOUGH PRESSURE AND FIXED IT I THOUGHT,WHEN AT WORK WITH THE CAR RUNNING AND THE EXHAUST AT RUNNING TEMPERATURE,ALL THE FUEL LEAKED OUT AND COULD OF VERY EASILY CAUSED A FIRE WHICH COULD OF CAUSED A GREAT LOSE OF LIFE NOT ONLY FOR MYSELF BUT ALSO FOR MY WIFE AND KIDS WHO ALWAYS DRIVE THE CAR

WE SUED FORD VIA THE MAGNUSON MOSS WARRANTY ACT. THE FOCUS HAD BEEN SOLD PRIOR TO THE FILING OF THE LAW SUIT. WE REACHED AN OUT OF COURT SETTLEMENT OF $3500. THE PROBLEM WITH THE CAR WAS INTERMITTENT STALLING. THE LOCAL FORD DEALER WAS UNABLE TO DETERMINE THE CAUSE OF THE PROBLEM.

THE TIRE AND THE BRAKES WENT OUT AND THE CAR STATED SLIDING. AFTER THE CRASH THERE WERE BOLTS THAT WERE FOUND ON THE GRASS WHERE THE CRASH HAPPENED

ENGINE LIGHT ON. JERKY GEAR ENGAGING. CHOPPY ACCELERATION. 8/02 REPLACED ALTERNATOR 8/02 REPLACED V BELT 10/02 BLINKERS OUT & ELECTRIC WINDOWS BROKE 10/02 BATTERY LIGHT ON "CORROSION ON WIRES" 1/03 WOULDN'T START, BATTERY LIGHT ON, "WIRE FELL OFF ALTERNATOR" AIRBAG LIGHT ON THEN OFF

MY 2001 FOCUS ZX3 WILL SPUTTER, LOSE POWER, AND THREATEN TO STALL. THIS OCCURS AT ANY SPEED. IT HAS STALLED AND LEFT ME STRANDED ONCE. WHEN TOWED TO THE DEALERSHIP, NOTHING COULD BE FOUND WRONG WITH IT AND SO I WAS CHARGED NOTHING. IT STARTED UP AGAIN JUST FINE, BUT PERIODICALLY THREATENS TO STALL AGAIN. ALSO, THE PAINT OVER THE DRIVER SIDE REAR WHEEL IS BUBBLING UP AND COMING OFF.

THE REASON SOME OF THESE ARE NOT DATED IS BECAUSE THE PROBLEMS KEEP ON PERSISTING THEY SAY THEY CAN NOT FIND OUT WHAT THE PROBLEM IS. MY CAR DIES ON ME AND THE CAN NOT FIND THE CAUSE. IT MAKES A WINDING SOUND WHEN I TAKE OFF AND STILL THEY CAN NOT FIND THE CAUSE. MY GEARS ALWAYS WIND AND AS SOON AS I GET IT OUT OF THE SHOP ABOUT ONE TO TWO WEEKS LATER IT IS DOING IT AGAIN, WHEN I AM DRIVING IT JERKS LIKE IT WANTS TO DIE OR GO OUT OF GEAR(KEEP IN MIND I HAVE HAD THESE PROBLEMS A COUPLE OF MONTHS AFTER I BOUGHT IT). I HAVE HAD TO REPLACE THE TIRES TWO TIMES I AM ON MY THIRD SET OF TIRES AND THEY ARE MESSED UP NOW. I AM NOT A BAD DRIVER I KNOW IT IS NOT ME I HAVE A...

THERE IS JUST TO MUCH PAPERWORK TO COPY OUT, BUT WOULD LIKE TO MAIL COPIES. I AM GOING TO PICK UP CAR THIS AFTERNOON JUST HAD SECOND FUEL PUMP FITTED AND NEW GAS TANK. TO DATE NO RECALL INFO RECEIVED BY POST. HOWEVER I HAVE BEEN DRENCHED WITH GAS ON MORE THAN ONE OCCASSION WHILE FILLING CAR. I HAVE NEARLY BEEN KILLED WHEN CAR CUT OUT AT 55MPH ON HIGHWAY NARROWLY MISSED BY TWO OTHER MOTORISTS. VEHICLE HAS 38,000 MILES & HAS HAD THE FOLLOWING REPAIRS. 1/COUNTLESS ENGINE SENSORS 2/FOUR NEW TYRES 3/NEW FRONT BRAKE PADS 4/NEW FRONT BRAKE ROTAS 5/NEW FRONT WHEEL BEARINGS 6/TWO FUEL PUMPS 7/ONE FUEL TANK 8/WAITING FOR THIRD SET OF A FRAME PLASTIC COVERS 9/THREE STEREO PLAYERS 10/TRACKLINK RESET THREE TIMES 11/STILL HAVE REALY NOISY BRAKES 12/ENGINE SOUNDS LIKE 10 YEAR OLD CAR 13/REAR PASSENGER WINDOW WORKS WHEN FEELS LIKE IT 14/RIGHT HAND DOOR SPEAKER...

I HAVE HAD NUMEROUS PROBLEMS WITH MY FOCUS. ABOUT 3MO AFTER I BOUGHT IT, THE TRANSMISSION BEGAN TO FEEL LIKE IT WAS SLIPPING, AND MAKING A NOISE. I TOOK IT TO THE PURCHASING DEALERSHIP, AND A MECHANIC TOLD ME IT WAS THE TORQUE CONVERTER. THEY DIDN'T HAVE A LOANER CAR FOR ME, SO I MADE AN AN APPOINTMENT FOR THE FOLLOWING WEEK. THE NEXT DAY ON MY WAY HOME FROM WORK, THE CAR SHUT DOWN. I CALLED A TOW TRUCK, THEY TOOK IT TO THE CLOSEST DEALERSHIP. WHEN I CALLED THE DEALERSHIP THE NEXT DAY, THEY SAID THE FUEL PUMP WENT OUT. THEY TOLD ME THAT THE STUTTER I WAS FEELING IN MY CAR WAS PROBABLY THAT. A FEW DAYS LATER, THE SAME PROBLEM. TOOK IT BACK TO THE SELLING DEALERSHIP, AND THE SHOP SUPERVISOR WENT OUT WITH ME. HE SAID I WAS DRIVING THE CAR OUT OF CONTEXT. WHAT...