1999 FORD F-250 SD Engine And Engine Coolingexhaust System Problems
2 NHTSA complaints on file
Engine And Engine Coolingexhaust System Issues in the 1999 FORD F-250 SD
2 engine and engine coolingexhaust system complaints have been filed with NHTSA for the 1999 FORD F-250 SD. Of these, 0 involved a crash, 0 involved a fire, and 0 resulted in injury.
2
Complaints
0
Crashes
0
Fires
0
Injuries
0
Deaths
All Engine And Engine Coolingexhaust System Complaints
I PURCHASED A NEW 1999 F250 SD 4X4 ON 4/2000. AT ABOUT 11-5 -2006 WITH ONLY 116,000 MILES ON THE SPEEDO, I NOTICED 9 EXHAUST MANIFOLD STUDS BROKEN OFF .TOOK TO DEALER AND AUTHORIZED THEM TO REPLACE 20 STUDS AND 20 NUTS ,WITH GENUINE FORD PARTS. REPAIR COST ME $833.00. CAME WITH 12 MO/12,000 MILE WARRANTY. ON 10-5-2009 NOTICED 2 STUDS WERE BROKEN AGAIN, 25,000 MILES LATER. TOOK TO DEALER, THEY STATED COULD NOT FIND THE CAUSE AND WOULD DEDUCT 10% OFF THE BILL IF I GET IT REPAIRED. TOLD ME OK TO DRIVE IT, NOT LEAKING. FOR ONE THING, IF BOLTS ARE MISSING IT WILL LEAK RAW EXHAUST INTO THE ATMOSPHERE AND POTENTIALLY INTO THE PASSENGER COMPARTMENT CAUSING THE DRIVER TO FALL ASLEEP AND CRASH. NOT TO MENTION POLLUTING THE ENVIRONMENT. THE EPA WOULD LIKE TO KNOW ABOUT IT I'M SURE. SO BASICALLY, THE FACTORY INSTALLED STUDS LASTED 116,000...
TL*THE CONTACT DOES NOT OWN A 1999 FORD F-250 SUPERDUTY. WHEN TEST DRIVING THE VEHICLE, THE CONTACT HEARD A NOISE AND TOOK IT IN FOR A DIAGNOSIS. AN EXHAUST LEAK WAS DISCOVERED AT THE MANIFOLD AND THE STUDS WERE DETACHING NEAR THE MANIFOLD. THE MANUFACTURER WOULD NOT ASSIST. THE FAILURE AND CURRENT MILEAGES WERE 141,000. UPDATED 03/27/09 *BF UPDATED 03/31/09. *JB
Other 1999 FORD F-250 SD Problem Areas
Engine And Engine Coolingengine
32 complaints
Electrical System
24 complaints
Engine And Engine Cooling
24 complaints
Engine And Engine Coolingenginediesel
23 complaints
Tirestreadbelt
16 complaints
Tires
10 complaints
Engine And Engine Coolingenginegasoline
8 complaints
Power Trainautomatic Transmission
8 complaints
Service Brakes Hydraulicfoundation Componentshoses Linespiping And Fittings
8 complaints
Vehicle Speed Control
7 complaints
Engine And Engine Coolingexhaust Systemmanifoldheadermufflertail Pipe
6 complaints
Fuel System Gasoline
6 complaints
Parking Brakeconventionalmechanicallinkage And Cable
6 complaints
Service Brakes Hydraulicfoundation Componentsdiscrotor
6 complaints
Air Bags
5 complaints
Power Trainclutch Assembly
5 complaints
Service Brakes Hydraulic
5 complaints
Electrical Systemignition
4 complaints
Service Brakes Hydraulicantilocktraction Controlelectronic Limited Slip
4 complaints
Fuel System Diesel
3 complaints
Power Trainaxle Hubs
3 complaints
Power Trainmanual Transmission
3 complaints
Service Brakes Hydraulicfoundation Componentsdiscpads
3 complaints
Steering
3 complaints
Suspensionfront
3 complaints
Suspensionfrontcontrol Armlower Ball Joint
3 complaints
Suspensionfrontcontrol Armupper Ball Joint
3 complaints
Air Bagsfrontal
2 complaints
Electrical Systemhorn
2 complaints
Electrical Systemignitionmodule
2 complaints
Electronic Stability Control Esc
2 complaints
Engine
2 complaints
Exterior Lightingheadlights
2 complaints
Fuel System Otherfuel Injection System
2 complaints
Fuelpropulsion System
2 complaints
Parking Brake
2 complaints
Power Trainautomatic Transmissiontorque Converter
2 complaints
Seat Belts
2 complaints
Service Brakes Hydraulicpower Assisthydraulichoses Linespiping And Fittings
2 complaints
Steering Steering Wheelhandle Bar
2 complaints
Steeringgear Boxshaft Pitman
2 complaints
Steeringgear Boxshaft Sector
2 complaints
Steeringhydraulic Power Assist System
2 complaints
Tiressidewall
2 complaints
Tirestemporaryemergency Spare Tire
2 complaints
Unknown Or Other
2 complaints
Electrical Systemwiring
1 complaint
Electrical Systemwiringfront Underhood
1 complaint
Engine And Engine Coolingcooling System
1 complaint
Engine And Engine Coolingengineother Fuel Typesturbosupercharger
1 complaint
Engine And Engine Coolingexhaust Systememission Control
1 complaint
Engine And Engine Coolingexhaust Systememission Controlcatalytic Convertor
1 complaint
Equipment
1 complaint
Equipmentrecreational Vehicletrailerlpg Systems
1 complaint
Fuel System Gasolinedelivery
1 complaint
Interior Lighting
1 complaint
Latcheslockslinkagesdoorslatch
1 complaint
Parking Brakeconventional
1 complaint
Parking Brakedrivelinehydraulichoses Linespiping And Fittings
1 complaint
Power Train
1 complaint
Power Trainautomatic Transmissionlever And Linkagecolumn Shift
1 complaint
Power Trainclutch Assemblypedalhand Levermotorcycle
1 complaint
Seat Beltsfrontbuckle Assembly
1 complaint
Steeringgear Box Other Than Rack And Pinion
1 complaint
Steeringhydraulic Power Assisthose Piping And Connections
1 complaint
Steeringhydraulic Power Assistpump
1 complaint
Steeringlinkages
1 complaint
Steeringlinkagesarmidler And Attachment
1 complaint
Steeringlinkagesdraglinkconnection
1 complaint
Steeringlinkagestie Rod Assembly
1 complaint
Suspensionfronthub
1 complaint
Suspensionfrontshock Absorber
1 complaint
Suspensionfrontwheel Bearing
1 complaint
Suspensionrear
1 complaint
Suspensionrearsprings
1 complaint
Vehicle Speed Controlcruise Control
1 complaint
Visibility
1 complaint
Visibilityrearview Mirrorsdevices
1 complaint
Wheels
1 complaint