2003 FORD EXPEDITION Electrical System Problems

MY 2003 FORD EXPEDITION WILL BE DRIVING FINE, THEN ALL OF A SUDDEN IT WILL DIE IN TRAFFIC AND HAVE HAD SEVERAL CLOSE CALLS OF BEING REAR ENDED. ONE OTHER TIME IT DIED AND WHILE COASTING AFTER IT DIED, IT STARTED AGAIN CAUSING VEHICLE TO LUNGE AND MY WIFE ALMOST REAR ENDED SOMEONE ELSE. THE VEHICLE IS AT THE REPAIR SHOP AND IT IS DIAGNOSED AS A PCM THAT IS AND NOW HAS A HARD FAILURE. *TR

2003 FORD EXPEDITION WOULD NOT START AFTER LONG TOW TO MECHANIC IT WAS A BURNT RELAY SWITCH BUT NOW IT TURNS OFF WHILE DRIVING, CHANGE THE RELAY SWITCH AND PROBLEM IS TEMPORARILY FIXED NOW SINCE THE RELAY IS FOR THE FUEL PUMP AND PCM MY TRANSMISSION IS ACTING UP NOT SHIFTING 3RD OR OVER DRIVE NO ONE CAN FIGURE OUT THE PROBLEM BUT WE ARE SCARED TO DRIVE THE TRUCK! *TR

ONE OF MY SPARK PLUGS BLEW OUT OF THE HEAD WITH ONLY 47,000 MILES ON MY 2003 EXPEDITION. 4 HOURS TO FIX IT. NOW I HAVE TO GO BACK AND TORQUE THE OTHER 7 PLUGS AND HOPE THE PIECE OF CRAP DOESN'T SPIT OUT ANY OTHER PLUGS. THIS IS MY LAST FORD! *TR

I HAVE AN 2003 FORD EXPEDITION SUV, THE SPARK PLUG IN THE #3 CYLINDER HEAD POPS OUT EVERY 5-8K MILES. RESULTING IN A LOSS OF POWER, PER THE 3 DEALERSHIPS I HAVE SPOKEN TO AS WELL AS THE B.A.R FORD IS AWARE OF THIS PROBLEM AND REFUSES TO FIX IT. PER THE B.A.R. IT IS AN CASTING/MANUFACTURING DEFECT. IM WORRIED THAT I WILL BE ON THE FREEWAY AND LOOSE POWER, AND GET IN AN ACCIDENT DUE TO NOT BEING ABLE TO EXIT THE FREE WAY UNDER MY OWN POWER. THE PROBLEM GOES BACK TO THE 2000 MODEL YEAR. I HAVE HAD THE CAR WORKED ON AT THE FORD DEALERSHIP 2 TIMES TO CORRECT THIS ISSUE,AND IT IS CURRENTLY BROKEN AGAIN. THE DEALER SHIP REFUSES TO FIX IT AS AN WARRANTY ON THEIR REPAIR DONE ON 8/13/09 OR AS AN FACTORY DEFECT FROM FORD DIRECT. DON'T KNOW WHERE ELSE TO TURN,...

I WAS DRIVING DOWN THE FREEWAY WHEN MY EXPEDITION MADE A NOISE, THE INSIDE DASH LIGHTS FLICKERED AND THE TRANSMISSION STARTED ACTING UP. I PULLED OVER AT A HOTEL. I CALLED A TOW TRUCK WHO CAME TO PICK IT UP A FEW DAYS LATER. WHEN HE STARTED IT THE WIRING HARNESS CAUGHT UNFIRE. THE ENTIRE WIRING BURNED UP ON THE LIFT SIDE OF THE VEHICLE. THE MECHANIC TOLD US WE WERE LUCK TO HAVE STOPPED. IF WE CONTINUED DOWN THE HIGHWAY MY FAMILY AND I WOULD HAVE BEEN IN GREAT DANGER. I BELIEVE THE FIRE WAS THE FAULT OF BAD WIRING. I CHECK THE RECALL SITES AND MY VEHILCE WAS NOT PART OF THE FAULTY WIRING RECALL. *TR

ON JUNE 19 2009, RETURNING HOME FROM A SHORT TRIP, THICK SMOKE ERUPTED WITH STRONG RUBBER SMELL FROM UNDERNEATH THE DRIVER SEAT. I IMMEDIATELY TURNED OFF THE IGNITION AND EXITED THE CAR. THE FOLLOWING DAY I CONTACTED FORD MOTOR CO. AND INFORM THEM OF THE SAFETY ISSUE, AFTER GOING BACK AND FORTH, FORD GENERAL CONSUL OFFICE MADE DECISION THAT THE ISSUE IS NOT SAFETY HAZARDS AND WILL NOT REPAIR THE VEHICLE. PAT MILLIKEN FORD HAS THE VEHICLE, AND INSPECTED THE DAMAGE, WHICH DECLARED TO BE VERY EXTENSIVE THE REPAIR COST MAY EXCEED $2000.00. FORD GENERAL CONSUL WAS INFORMED OF THE DAMAGE AND STILL WILL NOT CONSIDER IT AS SAFETY ISSUE BECAUSE THE VEHICLE DID NOT BURST ON FIRE. MY SMART AND QUICK REACTION TO TURN OFF THE VEHICLE AND CUT THE POWER OFF PREVENTED A DISASTER TO HAPPEN, AND YET AS A CONSUMER I'M LEFT WITH HEFTY REPAIR BILLS FOR...

2003 FORD EXPEDITION- AFTER IT RAINS I AM HAVING MANY DIFFERENT THINGS HAPPENING WITHIN THE ELECTRICAL SYSTEM. THE DOORS WON'T LOCK, THE RADIO WON'T LIGHT UP ANY MORE, THE INTERIOR LIGHTS WON'T SHUT OFF, THE FRONT WINDOWS WON'T WORK, MILDEW SMELL IN THE CAR. THE ELECTRICAL PROBLEMS ALONE CAN CAUSE A FIRE BUT WITH THE DOORS NOT BEING ABLE TO BE LOCKED IS A COMPLETELY DIFFERENT STORY AND I AM CONCERNED FOR MY FAMILIES SAFETY. I HEARD FROM THE DEALER AND OTHERS THAT FORD WILL NOT ISSUE A RECALL FOR THIS ONGOING PROBLEM. *TR

LOSS OF BRAKE LIGHTS TO 2003 FORD EXPEDITION, TOOK IT INTO DEALERSHIP THEY FOUND A FIRE IN OVERHEAD WIRING HARNESS. FORD CLAIMS TO HAVE NO PROBLEMS WITH HARNESS. NONE OF THESE WIRES WERE VISIBLE TO US , BUT HAD MELTED THE UNDERSIDE OF OVERHEAD COMPARTMENT. VISIBLE BURN MARKS ON METAL INTERIOR OF ROOF. ALL OVERHEAD WIRING HAS TO BE REPLACED. *TR

TL*THE CONTACT OWNS A 2003 FORD EXPEDITION. THE CONTACT TOOK THE VEHICLE TO THE DEALER BECAUSE ALL OF THE INSTRUMENT PANEL INDICATORS ILLUMINATED, EXCEPT FOR THE BRAKE LIGHT. THE INTERIOR OF THE VEHICLE WAS TORN APART AND THERE WAS AN ELECTRICAL FIRE. THE DEALER IS ORDERING A NEW WIRING HARNESS. THE VEHICLE WAS INITIALLY TAKEN TO THE DEALER FOR THE ILLUMINATED INDICATORS; HOWEVER, ANOTHER FAILURE WAS FOUND WITHOUT THE CONTACT'S KNOWLEDGE. THE FAILURE AND CURRENT MILEAGES WERE 83,000. UPDATED 12-02-08 *BF THE CONSUMER ALSO HAD A PROBLEM WITH THE BRAKE LIGHTS AND THE CRUISE CONTROL HAD TO BE REPAIRED AS WELL. THE CONSUMER STATED HE NEVER REEIVED A RECALL LETTER FOR THE CRUISE CONTROL. UPDATED 12/02/08 *JB

LIVE IN CHICAGO IL. (20 MINUTES OUTSIDE) AND MY EXPEDITION WAS LEFT OUTSIDE. IT GOT COLD (48 OUTSIDE) OVER NIGHT, AND MY FORD WAS DEAD IN THE MORNING, (DOME LIGHTS WOULDN'T EVEN TURN ON). I JUMPED IT, AND NOTICED THAT THE CLIMATE CONTROL WAS INOPERABLE (DOESN'T EVEN LIGHT UP). I TOOK IT TO FORD, AND THEY HAD THOUGHT THAT THE UNIT BURNED OUT. COOL, I CAN BUY ONE ON E-BAY FOR ABOUT $40.00 INSTEAD OF 326.00 THAT THEY QUOTED ME... I LEFT FEELING A LITTLE BETTER, KNOWING WHAT THE PROBLEM WAS....THEN SOMETHING STRANGE STARTED HAPPENING... THE 4WD HIGH/LOW IS FLASHING IN 1 MINUTE INTERVALS AT THE SAME TIME. THE DRIVER SEAT IS ADJUSTING ON IT'S OWN, WHILE I AM DRIVING, AND CANNOT BE STOPPED, LEAVING ME CRAMMED INTO THE DASH/STEERING WHEEL, THE BACK UP AID IS NOT WORKING, WHEN I EXIT THE VEHICLE THE RADIO STAYS ON, I HAVE TO...

MY HUSBAND'S 2003 FORD EXPEDITION CAUGHT ON FIRE. HE HAD BEEN OUT OF THE CAR FOR ABOUT 30 MINUTES. WE HEARD A LOUD POPPING NOISE AND THOUGHT NOTHING OF IT. WE HEARD ANOTHER LOUD POPPING NOISE, AND WENT TO SEE WHAT IT WAS. WHEN WE GOT OUTSIDE THERE WAS SMOKE COMING FROM UNDER THE HOOD. THEN WE SAW FLAMES COMING FROM THE DASHBOARD. AT THAT POINT WE CALLED 911. THE FIRE DEPARTMENT CAME AND PUT THE FIRE OUT, AND SAID IT WAS CAUSED BY SOMETHING ELECTRICAL. THERE WAS SOME SORT OF SHORT IN THE WIRING. HE HAD TAKEN THE CAR IN FOR REPAIR BECAUSE THE DOOR AJAR LIGHT STAYED ON, ALTHOUGH THERE WERE NO DOORS OPEN. THIS PROBLEM WAS SUPPOSEDLY FIXED BY CAR MAX. THERE HAVE BEEN NO MODIFICATIONS TO THE VEHICLE. *TR

FIRST, THE DOOR AJAR LIGHT CAME ON AND STAYED ON. I CONTINUED TO GO AROUND THE VEHICLE OPENING AND SHUTTING THE DOORS AND THE LIGHT REMAINED ON. CONSUMER COULD NOT START THE VEHICLE SINCE THE LIGHT CAME ON, AND HAD TO GET A JUMP TO START IT. AFTER A FEW DAYS OF THIS THE BATTERY WAS FINALLY RUINED, AND I WAS FORCED TO BUY A NEW ONE. I USED LUBRICANTS TO TRY AND CLEAR DEBRIS FROM THE DOOR SENSORS AND THIS WORKED FOR 3 MONTHS. NOW IT WILL NOT WORK AT ALL. TALKED TO DEALER AND THEY WANT TO CHARGE 600 DOLLARS PER SENSORS. NOTHING WRONG WITH SENSOR ITS JUST DIRTY. SECOND, THE REAR AC IS MAKING A CLICKING NOISE AND WILL NOT CONTROL TEMPERATURE. I SENT IT UNDER WARRANTY TO THE DEALERSHIP AND REPLACED THE AC MECHANISM, STATED "THIS WAS A COMMON DEFECT WITH THE VEHICLE". 5 MONTHS LATER...

OUTSIDE MIRROR LIGHTS AND INTERIOR LIGHTS WOULD NOT GO OFF AFTER GETTING OUT OF VEHICLE AND PRESSING REMOTE LOCK BUTTON. THEY EVENTUALLY RAN THE BATTERY DOWN. THIS WAS AFTER A HARD RAIN. A FEW WEEKS LATER THE SAME THING HAPPENED ONLY THIS TIME, THE RADIO WOULD NOT TURN OFF (KEY OUT OF IGNITION AND DOORS OPEN) THE CHIME KEPT GOING OFF AND THE BATTERY WENT DEAD BECAUSE I DID NOT DISCONNECT IT. I RESEARCHED ONLINE AND FOUND THIS IS NOT UNCOMMON BECAUSE THE WINDSHIELD LEAKS, FROM THE FACTORY, AND WATER DRIPS DOWN ONTO THE COMPUTER MODULE AND FUSE BOX. I CHECKED MY FUSE BOX AND I DID HAVE DRIPPING WATER IN IT ALONG WITH CORRODED CONNECTORS, INSIDE THE VEHICLE, INDICATION LONG TERM INTRUSION OF WATER. THIS CAUSES ALL KINDS OF PROBLEMS. OTHER OWNERS HAVE REPORTED COMPLETE LOSS OF POWER WHILE DRIVING. UPON INSPECTING MY OEM WINDSHIELD I FOUND IT COMPLETELY...

FOR THE PAST FEW MONTHS I HAVE BEEN HAVING PROBLEMS WITH THE MIRRORS AND WINDOWS ON MY FORD SUV. I TOOK IT TO THE DEALER THEY CLAIM THEY COULD NOT FIND OUT WHAT THE PROBLEM WAS. THEY WERE ABLE TO FIX THE BROKEN GEAR SHIFT AND JAM RADIO. ONE MONTH LATER I WAKE UP TO MY TRUCK ON FIRE AFTER SITTING FOR SEVEN HOURS. *TR

MY 2003 FORD EXPEDITION IS SHUTTING OFF WHILE I AM DRIVING, NEARLY CAUSING ME TO LOSE CONTROL AND BE REAR ENDED. IT HAPPENS WHEN I LEAST EXPECT IT AND THE DEALERSHIP IS BAFFLED. ALL THEIR EXPENSIVE DIAGNOSTIC EQUIPMENT CAN'T EVEN TRACK DOWN THE ISSUE. SO FAR THEY HAVE REPLACED SOME FUEL PARTS AND MY FUSE BOX BUT IT STILL SHUTS DOWN UNEXPECTEDLY. I AM $900. IN THE HOLE ALREADY, LET ALONE I AM GOING TO HAVE MY FIRST GRANDCHILD WITHIN A WEEK, AND I HAVE THIS TANK THAT SHUTS DOWN ON THE MIDDLE OF THE HIGHWAY. IT SOUNDS ELECTRICAL AND I AM IN FEAR OF CATCHING FIRE. *TR

REAR VIEW MIRRORS FAIL TO RETURN TO CORRECT POSITION AFTER BACKING UP CAUSING A DRIVING HAZARD. THIS HAS BEEN AN ON-GOING PROBLEMS SINCE PURCHASING THIS VEHICLE - NEW IN 2003. DEALER HAS LOOKED AT IT AND STATED THEY COULD NOT DUPLICATE THE PROBLEM AND NO SERVICE BULLETINS EXISTED AS OF MARCH 2006. OTHER INTERMITTENT ELECTRICAL PROBLEMS EXIST - 1. PASSENGER SIDE REAR DOOR - AUTOMATIC LOCK DOESN'T ALWAYS OPERATE. 2. INTERIOR LIGHTS STAY ON AS IF A DOOR HAS BEEN LEFT OPEN, EVEN WHEN ALL DOORS AND HATCHES HAVE BEEN CHECKED TO ENSURE THEY ARE COMPLETELY CLOSED. *NM

2003 FORD EXPEDITION LOST ALL POWER AND ALMOST GOT REAR ENDED. *KB ***NAR*** THE VEHICLE CROSSED INTO ONCOMING TRAFFIC AND WAS ALMOST INVOLVED IN A HEAD ON COLLISION. THE VEHICLE FINALLY STOPPED AND WAS ABLE TO BE RESTARTED AND DRIVEN TO THE CONSUMER'S HOME. THE NEXT DAY THE VEHICLE WAS TAKEN TO A DEALER. THE DEALER WAS UNABLE TO DUPLICATE THE PROBLEM AND RETURNED THE VEHICLE TO THE CONSUMER. ABOUT A WEEK LATER THE VEHICLE STALLED AGAIN WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER A LEFT FOR A FEW DAYS SO THEY COULD TRY TO DUPLICATE THE PROBLEM. UNFORTUNATELY THEY WERE UNABLE TO AND THE VEHICLE WAS AGAIN RETURNED TO THE CONSUMER. THE PRIMARY DRIVER OF THE VEHICLE NO LONGER FELT SAFE DRIVING THE CAR ESPECIALLY SINCE SHE TRANSPORTED HER CHILDREN IN IT. THE CONSUMER READ SOMEWHERE THAT THE WIRING HARNESS WAS THE CAUSED OF THE PROBLEM. THE...

2003 EXPEDITION RELAY JUNCTION BOX BURNED. *TS ***NAR*** THE VEHICLE STALLED WHILE BEING DRIVEN. THE PROBLEM WAS DIAGNOSED AS A RELAY PROBLEM AND REPLACED THE RELAY. AFTER REPAIR THE VEHICLE WOULD NOT SHIFT INTO OVERDRIVE. THE DEALER PERFORMED DIAGNOSTIC TEST WHICH DETERMINED THAT THE JUNCTION HAD MELTED. THE JUNCTION BOX WAS REPLACED BUT THE VEHICLE STILL HAD NO OVERDRIVE NOR THIRD GEAR. THE DEALER REMOVED THE TRANSMISSION PAN AND FOUND INTERNAL TRANSMISSION DAMAGE. THE CONSUMER FEELS THAT THE TRANSMISSION WAS DESTROY WHEN THE JUNCTION BOX BURNED OUT. THE CONSUMER HAS THE BURNED JUNCTION BOX IN HIS POSSESSION. PRIOR TO THIS FAILED THE VEHICLE ALTERNATOR HAD TO BE REPLACED. *NM

CONSUMER IS HAVING PROBLEMS WITH AIR CONDITION MAKING NOISE, POWER WINDOWS ONLY LOWER, RADIO VOLUME GETS LOUDER WHEN ACCELERATING SEAT CONTROL BUTTONS ARE INOPERABLE. *TS WATER LEAKED FROM THE SUNROOF, EVEN THOUGH IT WAS CLOSED. THE VEHICLE WAS TAKEN TO THE DEALER ON 3 SEPARATE OCCASIONS DUE TO BRAKE AND ROTOR NOISE. THE CONSUMER EXPERIENCED LACK OF POWER WHEN ATTEMPTING TO ACCELERATE. THE CONSUMER WAS UNABLE TO HEAR THE RADIO SEPARATELY WHEN THE DVD WAS PLAYING. *JB

DT: ORANGE WIRE UNDER THE THIRD ROW SEAT, THIS WIRE STARTED SMOKING. WE LEFT THE CAR. THIS WIRE BURNED INTO. FLAMES WERE COMING OUT FROM UNDER THE SEAT, AND IT SMOKED UP THE VEHICLE. PARKED THE CAR, AND THE CAR HAD NOT BEEN MOVED SINCE. THIS HAPPENED 6:30 PM, AND ALL THE DEALERSHIPS WERE CLOSED. *AK

THE DOOR AJAR LIGHT CAME ON AND STAYED ON. COULD CONTINUE TO GO AROUND THE VEHICLE OPENING AND SHUTTING THE DOORS AND THE LIGHT REMAINED ON. CONSUMER COULD NOT START THE VEHICLE SINCE THE LIGHT CAME ON, AND HAD TO GET A JUMP TO START IT.*AK

#1 NOTHING OUT OF THE ORDINARY #2 CAR HAD BE PARKED FOR ALMOST AN HOUR WHEN A PASSERBY KNOCKED ON THE DOOR TO SAY THAT THE CAR WAS ON FIRE AND SHE HAD ALREADY CALLED THE FIRE DEPARTMENT. #3 FIRE WAS PUT OUT. CAR WAS A TOTAL LOSS. ALSO, THE CAR PARKED IN FRONT OF MINE WAS BURNED WHEN THE FIRE SPREAD AND THAT CAR WAS TOTALLED AS WELL. IT BELONGED TO MY FRIEND, OLIVIA JACKSON OKE, WHOM I WAS VISITING AND MY CAR WAS PARKED DIRECTLY BEHIND HERS IN HER DRIVEWAY. I FILED A CLAIM WITH MY INSURANCE AND SO DID OLIVIA.

WHILE MAKING A STOP, THE CHECK ENGINE LIGHT APPEARED ON THE DASHBOARD AND REMAINED ON. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION NUMEROUS TIMES, BUT THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. WHILE APPLYING THE BRAKE PEDAL, THE VEHICLE FAILED TO STOP COMPLETELY. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND THE MECHANIC DETERMINED THAT THE BRAKE ROTORS NEEDED TO BE REPLACED. *AK WHEN STOPPING, THE MOTOR STARTS SHAKING AND THE VEHICLE WOULD SHUT OFF. WHEN TURNING THE VEHICLE, IT WOULD NOT RESPOND UNTIL ATTEMPTING 2 OR 3 TIMES, THEN FINALLY A LOT OF SMOKE APPEARS. THE SUSPENSION APPEARED TO BE LOOSE AND ONE SENSOR ON THE WHEELS DID NOT RESPOND. *SC

WHILE DRIVING 30 MPH, THE VEHICLE VIBRATED UNCONTROLLABLY. SUDDENLY, THE VEHICLE STALLED. THE DRIVER TRIED TO RESTART THE VEHICLE AND WAS NOT ABLE TO DO SO. THE VEHICLE WAS TOWED TO THE DEALER FOR INSPECTION. THE MECHANIC INFORMED THE DRIVER THAT THE ALTERNATOR AND BATTERY NEEDED TO BE REPLACED. WHILE UNLOCKING THE DRIVER'S DOOR WITH THE AUTOMATIC SWITCH BOTH SIDE REAR VIEW MIRRORS WOULD AUTOMATICALLY MOVE UP AND DOWN. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION. THE MECHANIC REPLACED BOTH SIDE REAR VIEW MIRROR MOTORS. PLEASE PROVIDE FURTHER DETAILS. *JB CONSUMER ADDS BOTH SIDE VIEW MIRRORS MOTORS REPLACED 2 TO 3 MORE TIMES. THE FOG LIGHT HOUSING REPLACED, REAR LIGHT COVERS REPLACED DUE TO MOISTURE, HEATER CORE SWITCH REPLACED FROM DASH. BRAKES SQUEALING WHEN APPLIED. TRANSMISSION SLIPPING AND POWER STEERING PUMP WINDING. *TT

THE VEHICLE HAD DEAD BATTERY AND REQUIRED JUMP START. THE ATTEMPT WAS SUCCESSFUL HOW EVER I BEGAN HAVING ELECTRICAL PROBLEMS ALMOST IMMEDIATELY. THE INSTRUMENT PANEL LIGHTS AND ODOMETER DISPLAY MALFUNCTIONED ON SEVERAL OCCASIONS, INCLUDING JUMPS IN MILEAGE OR NO CHANGE AFTER A TRIP, RADIO WOULD GO OFF OR CHANGE STATIONS BY ITS SELF, DOOR LOCKS WOULD UNLOCK AND LOCK BYSELF,AND INSTRUMENTS NOT WORKING. THE CIGARETTE LIGHTER MOUNTED NEXT TO THE ASHTRAY IN THE DASH SOME HOW BECAME WELDED IN PLACE. ON OCCASION WHEN STARTING THE VEHICLE AS YOU PUT KEY IN IGNITION YOU WOULD HEAR THE DOOR CHIME AS NORMAL THEN WHEN YOU TURN KEY TO START POSITION CHIME WOULD DIE AND NOTHING HAPPENED THEN RETURN THE KEY TO OFF AND BACK TO START AND IT WOULD START FINE ON THE SECOND ATTEMPT. I TOOK THE VEHICLE IN TO MY DEALERSHIP AND THEY REPLACED THE RADIO BUT THIS DID NOT...

CAR STOPS RUNNING WHILE DRIVING A SPEED. THIS HAS HAPPENED 4 TIMES IN THE LAST 9 MONTHS. THE DEALER CANNOT CORRECT PROBLEM UNTIL IT IS REPRODUCED. *AK

DURING A RECENT TRIP TO DENVER, THE TEMPERATURE DROPPED BELOW 20 DEGREES AND THE BACK-UP WARNING BEGAN MALFUNCTIONING. AT THE SAME TIME, THE ADVANCE TRAC LIGHT ILLUMINATED AND ALTHOUGH I CYCLED THE SWITCH, THE SYSTEM WOULD NOT COME ONLINE. THE BACK-UP WARNING SYSTEM EITHER EMITTED A CONSTANT TONE, EVEN THOUGH NOTHING WAS BEHIND ME OR I COULD GET RIGHT NEXT TO SOMETHING AND IT FAILED TO ALARM. I TOOK THE VEHICLE INTO THE DEALER WHERE I PURCHASED THE VEHICLE AND WAS TOLD THAT SINCE IT IS AN INTERMITTANT PROBLEM THAT ONLY OCCURS WHEN IT IS COLD, THAT THERE IS NOTHING THAT THEY COULD DO, AS THEIR SHOPS ARE HEATED TO ABOUT 68 DEGREES. THIS VEHICLE ALSO EXPERIENCES PROBLEMS WITH THE SIDE MIRRORS MOVING OF THEIR OWN ACCORD. THE DIRECTION IS NOT ISOLATED TO A SINGLE DIRECTION. SOMETIMES THEY MOVE UP AND OTHER TIMES DOWN. MOSTLY WITH THE PASSENGER SIDE, BUT...

WITHIN 1,000 MILES THE BACK UP SENSOR RANG WHEN EVER YOU PUT THE CAR INTO RESERVE - HAS BEEN SERVICED THREE TIMES STILL DOES IT TODAY. WITHIN 5,000 THE MIRRORS WOULD TILT TOO FAR TO THE OUTSIDE THEN POP AS THEY TRIED TO CONTINUE TO MOVE FURTHER OUTSIDE. WITHIN 18,000 1)ADVANCETRAC LIGHT CAME CAUSE THE RIGHT FRONT BRAKE TO LOCK UP WHEN TURNING LEFT AND THE LEFT FRONT BRAKE TO LOCK UP WHEN TURNING RIGHT. ENGINE WAS SHUTTING DOWN GOING TRAVELING AT 70 MPH. TRANSMISSION WOULD NOT CHANGE OUT TO NEXT GEAR UNTIL VERY HIGH RPM. POP AND CLICKING NOISES FROM UNDER THE DASH (FRONT PASSANGER AND DRIVE SIDE). ENGINE WOULD NOT START. - AUTHORIZED FORD BLUE OVAL REPAIR CENTER HAS REPLACED 2 ABS MODULES, THE BATTERY, MADE REPAIRS TO THE WIRING HARNESS, REPLACED TWO OTHER COMPUTER MODULES. CAR WAS IN THE SHOP FOR THREE WEEKS AND RETURNED THREE TIMES....

THERE IS A RATTLING NOISE IN PASSENGER SIDE DOOR. AND AT TIME IT IS HARD TO CLOSE. WHEN THE VEHICLE REACHED 43 MPH A HUMMING NOISE COULD BE HEARD. THE HUMMING CONTINUED WHEN THE VEHICLE REACHED 59-72 MPH. THE TECHNICIANS REPLACED THE DRIVE SHAFT TWICE BUT THE NOISE CONTINUED. THERE WAS A ROARING NOISE WHICH CAME FROM THE WHEEL AREA. THE DEALER ADJUSTED THE PARK BRAKE SHOES. THE WAS NOISE THE STEERING WHEEL WAS TURN RIGHT OR LEFT. THE TECHNICIAN ADDED A WHEEL ADDITIVE. THE PASSENGER DOOR WAS DIFFICULT TO CLOSE. THE DEALER ADJUSTED THE STRIKER. THE FRONT WINDSHIELD WEATHER STRIP WAS LOOSE. THE DEALER RESEALED IT. THE WAS RATTLING IN THE CENTER OF THE DASH. THE DEALER REMOVED AND REINSTALLED A CLUSTER AND REINSTALLED THE INSULATION. THE DRIVER SIDE SEAT BELT TWISTED. *NLM

THE SEATS, MIRRORS & GAUGES ALL WILL READJUST WHILE YOU ARE DRIVING DOWN THE ROAD. MY WIFE ALREADY HAD A NEAR MISS ON THE INTERSTATE WHEN THIS HAPPENED. THE FORD DEALER. ANDY MOHR FORD SAYS HE CAN DO NOTHING AND THE ENGINEERS ARE WORKING ON A FIX. I HAVE CALLED THE FORD CUSTOMER SERVICE AND WROTE THEM 2 LETTERS. IT HAS BEEN GOING ON FOR 5 MONTHS NOW AND NO ONE WILL ADDRESS THE PROBLEM. THEY SAY IT IS A PROBLEM WITH ALL 2003 EXPEDITIONS SO I WOULD THINK IT WOULD BE A PRIORITY TO FIX. *JB

CONSUMER COMPLAINED ABOUT ELECTRICAL SYSTEM PROBLEMS. EVERY TIME VEHICLE PASSED BY RADAR WEATHER STATION THAT WAS LOCATED NEAR THE AIRPORT DRIVER'S SEAT WOULD RECLINE BACK TO THE FURTHEST POSITION. *AK

THE DRIVER AND REAR VIEW MIRRORS ERRATICALLY REPOSITIONED EACH TIME THE DOORS WERE UNLOCKED OR IF THE VEHICLE WAS PUT INTO REVERSE *AK *CB. ALSO THE DRIVER SEAT REPOSITIONED ON ITS OWN, AND BECAME STUCK IN THAT POSITION. *JB

THE VEHICLE HAD AN ALL-INCLUSIVE COMPUTER CONSOLE ON DASHBOARD WHICH CONTROLLED THE FUNCTIONS OF REAR/SIDE VIEW MIRRORS AND MEMORY SEATS, ETC. THE CONSOLE DID NOT FUNCTION PROPERLY, WHICH CAUSED THE SIDE VIEW MIRRORS TO BE INCORRECTLY POSITIONED WHILE DRIVING. DEALER DIAGNOSED DEFECT WITH SYSTEM, BUT ADVISED THERE WAS NO REMEDY OR PARTS WHICH EXISTED TO CORRECT. *JB

WHILE DRIVING AT HIGHWAY SPEEDS ADVANCE TRACK SYSTEM LIGHT ILLUMINATED, THEN ALL ELECTRICAL COMPONENTS STARTED TO FLASH. HEARD A RATTLING NOISE, PULLED OVER, TURNED OFF ENGINE TO SEE WHAT PROBLEM WAS, AND VEHICLE WOULD NOT RESTART. TOOK VEHICLE TO DEALER, AND THEY STATED IT WAS THE ALTERNATOR. *AK