2018 FORD ESCAPE Engine Problems

Engine overheating due to coolant loss into cylinder through internal leak. Engine and vehicle are available for inspection. Engine overheating due to coolant loss into cylinders can be a risk for vehicle fire. Overheating affected my engine longevity and function and caused my vehicle to stop in an unsafe location (i.e. the highway). This is a serious safety concern for my family since we also live in Arizona where we are highly susceptible to extreme heat. I took the Ford vehicle to a Ford dealer to inspect and they verified that the engine block was warped due to an internal leak of coolant into the engine cylinders through a known recall issue Ford Vehicle has been inspected by the Ford dealership by certified Ford mechanics. Overheating had no warning since internal coolant leaks are not detectable through external means. When car overheated, I took the vehicle to Ford for inspection.

Cylinder 2 misfire. Fixed twice in one month. Coolant entering engine and engine needs replacing.

There was a coolant intrusion into engine and mixing with oil causing check engine light to come on. There is a memo from Ford that if this happens the only repair would be to replace the engine motor assembly with all hardware (for the cost of $9, 467.88). The safety of myself and others was put at risk because the engine experienced sudden performance issues due to coolant mixing with the oil. These symptoms could have led to a complete engine failure, especially at highway speeds or in heavy traffic, which creates a serious risk of accidents. Additionally, the potential for internal engine damage raises the risk of a fire, as documented in similar cases involving EcoBoost engines. I was driving a vehicle that could unpredictably stall or become inoperable, putting both me and other drivers in dangerous situations. The Willowbrook Ford Dealer diagnosed the problem on 6/13/25 after running...

the check-engine light started coming on just over mile 100k, codes came back as a cylinder misfire. Due to faulty coolant supply systems, the coolant would be used up very quickly, which could cause the engine to overheat and become dead in the water, effectively endangering anyone driving it. The vehicle has had several repairs to the engine, all for the light to come on several times more.

At approximately 53000, our 2018 Ford Escape began experiencing engine misfires, rough idling, and visible white smoke from the exhaust. After inspection, the dealer confirmed that coolant was leaking into the combustion chamber due to a known design flaw in the 1.5L EcoBoost engine — a condition widely reported by other Escape and Fusion owners. This issue was previously covered under Ford’s Customer Satisfaction Program (CSP 21N12), which extended short block replacement for this exact problem. However, Ford has denied coverage, citing that the vehicle is now just outside the 7-year eligibility window, despite the low mileage and the fact that this is a documented manufacturing defect, not normal wear and tear. Coolant intrusion into the engine is a critical safety risk, as it can cause sudden engine failure, stalling, and loss of power — all of which create dangerous driving conditions, especially at highway speeds. Thousands of owners are...

The contact owns a 2018 Ford Escape. The contact stated that when the vehicle was started, the check engine warning light illuminated. The vehicle was parked for several hours and then started, and the check engine warning light was no longer illuminated. The contact stated that while driving at an undisclosed speed, the vehicle started shaking, lost motive power, and the engine warning light started flashing. The contact pulled over to the side of the road, restated the vehicle and the check engine warning light became illuminated. The vehicle was taken to the residence. The vehicle was then taken to a dealer where it was diagnosed and determined that the spark plugs needed to be replaced. Additionally, the mechanic observed coolant leaking into the engine and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was...

Check engine light first appeared early May 2025 days after the car started running very roughly, then bucking upon startup; local mechanic said may need engine but should go to dealer; dealer towed a couple of days later as engine light had begun to blink and said it couldn't be driven; a few days later dealer reported coolant leaking into combustion chamber and would need a new engine at $12,860. Apparently a known failure as reported in Technical Service Bulletin 22-2229, date 6/9/2022 for vehicles including my 2018 Ford Escape Titanium 2.0 L Ecoboost with only 44k miles, final assembly Louisville KY. Reported danger of engine failure while driving, possible fire.

The contact owns a 2018 Ford Escape. The contact stated that upon start the vehicle, the check engine warning light illuminated. The vehicle was taken to a local independent mechanic where the vehicle was diagnosed with a cylinder #2 misfire. The local dealer was contacted; however, the vehicle was not diagnosed because the VIN was not under recall. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 96,000.

The gasket cracked and coolant leaked into the #2 cylinder.

Engine is shaking car. Appearing to misfire. Car was on highway when this occurred.

Ford EcoBoost 1.5l block has design flaws, causing coolant to enter into the block which causes the car to studder and reduce speed due to a misfire happening in the engine. Inspection upon request approved. Car acted completely fine, as we entered onto the highway we started to pick up speed as traffic is very fast, about 100 yards after entering the highway the vehicle failed causing sudden reduce engine performance. Traffic caught up to us as we veered to the far right shoulder, almost getting rear ended and causing a multiple car pileup. Car was towed to the Ford dealership for diagnosis, that was when ford told us this is a common issue on 1.5l EcoBoost's and common on all of the EcoBoost. There was a recall for this issue, but it does not pertain to this VIN due to the build location? There were no warning signs, no...

Blown engine, misfire cylinder 3 coolant leaking into cylinder 3, block cracked...smuttering. problem has been identified by our mechanic, and Ford has been called for a replacement engine. Check engine light was on.

Check engine light came on and coolant tank was nearly empty after refilling it days before. Mechanic confirmed engine failure.

Experiencing coolant intrusion with a 2018 Ford Escape. Ford is charging $8,000 for the repair. This is known issue with the vehicle. They instituted a temporary program to fix the vehicle free of charge but has expired in 2022. Ford should have recalled the vehicle for this issue. It is unacceptable they can charge so much for a known issue, that they acknowledge is their own fault.

Bought a used car from Marsh Auto Sales in Ortonville Michigan in April, the very next day the check engine light came on and car would not start. It kept saying “Engine Fault.” Finally got the car to start, drove it for the rest of the month, scheduled a service appointment but the car overheated, we were stuck on the side of the road, it would not run and the coolant was low. Looked on Ford’s website and there was a “Customer Satisfaction Recall or program - 19B37, Campaign number 21N12“ that issued a recall for a the exact problem and the engine needed to be replaced. They issued the recall during Covid, and Im sure it was hard for the original owner to submit it for service as getting appointments was extremely hard. I called Ford, and Marsh Auto Sales and neither were willing to help.

Check engine light came on and engine running rough. Shop found coolant leaking into cylinders due to issue with the make of the engine. Needs a new engine before it can be drivable. This is a known problem with these engines that Ford is aware of but a formal recall has not been issued.

HAD TO TAKE THE VEHICLE INTO THE DEALER THE END OF APRIL 2025 FOR OIL LEAK THAT THEY DISCOVERED. IT WAS FIXED. THEN ON MAY 8 2025 CHECK ENGINE LIGHT CAME ON SO HAD IT TOWED TO FORD DEALER. THEY COULDN'T FIND ANY THING WRONG. CAR HAD WHITE SMOKE, SHAKING WHEN STARTING AND SMELLED LIKE OIL. THEY HAD IT 6 DAYS BEFORE RETURNING IT. THEY SAID THE WHITE SMOKE WAS NORMAL FOR AN OLDER CAR BECAUSE THE EXHAUST STSTEM IS OLDER. HUH??? SO THEN ON MAY 29 2025 THE CAR STILL HAD THE WHITE SMOKE WHEN STARTED. MOVED CAR DOWN THE DRIVEWAY INTO THE STREET AND IT DIED. IT WOULD NOT MOVE AND WAS SITTING IN THE MIDDLE OF THE STREET. LET IT SIT FOR A WHILE AND WAS ABLE TO MOVE IT BACK INTO THE DRIVEWAY. CALLED DEALER AGAIN AND ASKED THEM TO TOW IT AGAIN. DEALER SAID THE...

Coolant intrusion. Engine fault light came on and then the engine overheating light came on. Coolant was empty. Added coolant. Coolant emptied. No puddles on ground. No visible leaks. Problem confirmed by dealership. Owned vehicle for a week before the issue appeared. Outside the 21N12 customer satisfaction program by a month.

Vehicle has a known issue with the coolant leaking into the engine and causing the engine block to fail. This has been documented thousands of times with almost 100 complaints on this site. Our vehicle has 34,000 miles on it and the engine had catastrophic failure while driving, which could have caused a fatal accident. Thankfully, it didn't cause any damage or injuries. The engine is going to cost $10,500 to replace and Ford is not assisting with any of the cost. The Ford repair shop has confirmed that this is what occurred.

The contact owns a 2018 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated and the engine overheated. The vehicle was taken to the dealer where it was diagnosed with a coolant intrusion and engine failure. The contact was informed that the engine needed to be replaced; however, the vehicle was not repaired. The contact stated that the failure had previously occurred, and the engine was replaced at 18,000. The manufacturer was made aware of the failure and a case was filed. The contact referenced an unknown recall; however, the VIN was not included. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 97,000.

From what I understand, the engine malfunctioned in a way that caused the cylinder compression to fail in several cylinders, but not all. This caused the car to stutter, shake, and slow down significantly in traffic on the highway. A warning popped up on the dashboard that said to shut the car down as soon as possible. We pulled over right away, which left us on a bridge on the highway. This endangered us as well as passing traffic, and then the tow truck person as well. We had to have the entire engine replaced in the car, which then after about 25 miles of driving, had the exact same problem (thankfully, in a 25 mph neighborhood this time). The problem has been replicated by the service center several times. They have now installed a total of three replacement engines that were all defective.

At 46000 miles mileage cylinder 3 misfired. This led to sudden engine slowdown on a busy street. Headgasket broke and coolant intruded into engine causing total engine failure.

Coolant intrusion

Engine coolant intrusion into Cylinder head. Vehicle is a 2018 with 95k miles on it. This is causing cylinder 1 misfiring and FORD is saying it requires a new engine block.

My car was working fine. Two weeks ago, the check engine light came on, so I took it to a local repair shop. They said it had a misfire code and the car needed new spark plugs and a new ignition coil. My Escape has 86,000 miles on it. The check engine light went off, but a week later, the dashboard lit up like a Christmas tree and said engine was overheating, stop car immediately. I was about 1 block from my house. The car stalled and would not run at all. After about five minutes, I was able to start the car and limp back home. I called AAA and they towed it to a AAA repair center. Three days later, the repair center called and said that I needed a new engine. They told me that there was a known problem with these engines and that Ford would...

All of a sudden, right around 108,000 miles, the check engine light came on. Upon several mechanic visits, and replacing ignition coils, and spark plugs, and even doing a system engine oil flush, the check engine light keeps coming back on. The same code is displayed, a cylinder 2 and 3 misfire. Upon further investigation, I've found that this is a common issue that happens with the same model as my vehicle and instances occur with various mileage on the vehicle, some reported from 15,000 and up to 240,000 miles on the vehicle. During my research, I found that Ford realized that this was the engine type itself being at fault and changed from a short block engine to a better one going forward. I've also read reports that Ford has corrected the issue by replacing the engine retroactively. I feel that this is a major safety concern, as I...

Purchased 2018 Escape at 64,xxx miles and was doing well. At around 86,xxx miles noticed a misfire and white smoke out of the exhaust. Took it to a shop and they did tests. They confirmed that it had coolant intrusion on cylinders 2 & 3. Since it is 2,000 miles over the 21N12 FoMoCo said we are basically on our own for repairs. Thank for being so stand up for your products Ford!!

Ford is trying to say that my engine is blown, my check engine light came on at 105,000 miles and it said that my cylinder too was misfiring. I brought it to my mechanic and he replaced the coils and the spark plugs and the check engine light kept coming back on within a few hours I took the vehicle to my mechanic five times in three days the last time I took it to my mechanic the vehicle started overheat, there was no power, the vehicle is shaking, and it left me pretty much stuck on the side of the road with a child in my car.

The contact owns a 2018 Ford Escape. The contact stated that while driving at 20 MPH and approaching a red traffic light, the vehicle began to jerk then suddenly lost motive power. The contact was able to pull over to the shoulder of the roadway, where the vehicle was able to be restarted. After restarting the vehicle, the vehicle returned to normal functionality, but the contact stated that upon reaching her destination, the vehicle stalled and had since not been able to restart. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 127,000.

The contact owns a 2018 Ford Escape. The contact stated that when the vehicle was started, there was an abnormal rumbling sound coming from the engine compartment, and the check engine warning light was illuminated. The contact stated that the vehicle accelerated normally, but while the vehicle was idling, the contact observed a rumbling sound coming from the engine compartment. The vehicle was taken to an independent mechanic where it was diagnosed that the spark plugs needed to be replaced. The vehicle was repaired but the failure reoccurred three days later. The vehicle was taken to the same independent mechanic where it was diagnosed that the cylinders needed to be interchanged. The vehicle was repaired but the failure reoccurred five days later. The manufacturer was notified of the failure. The failure mileage was approximately 45,000.

Ecoboost 1.8l engine failure due to coolant leaking into the cylinders. Looks to be a very common issue that Ford is very aware.

My coolant is leaking into the motor. Shop gave me a quote for a whole new engine. I’ve seen so many posts on forums and many friends who own the same car having the same problem. Please please make Ford issue a recall as this is my only vehicle and I got it hoping to finally not have to worry about car problems for a while. It’s been 2 months since I bought it.

I purchased this car new [XXX]. It was running rough for some time but now has 90,000 miles on it. I took it in for the shifter cable recall. I told them it was running rough. The Ford dealership here in Arkansas said it was coolant leaking into cylinder #2. By researching, I found that Ford issued a Customer Satisfaction Program 21N12 in June 2022 for this specific issue. I never got a notice in the mail. Ford Motor company says this program stops at 84,000 miles or June 19, 2025 for me so I am out of luck since I have more than 84,000. This is wrong. It should apply to all mileage for such an issue. This should be a recall. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I have a coolant intrusion in the 1.5L engine and now I have to have the entire engine replaced, and it will cost me more than the car is worth. This is a widely known problem and Ford refuses to include all year/make/models with this issue. I have no way to get my car fixed and it's been down for over a year now because I can't afford to get it fixed.

Check engine light came on at 103k miles with a P0302 error code. Replaced spark plugs and check engine light went away. 2 weeks later high engine temperature warning came on. Had it towed to a mechanic. Diagnosis was a cracked engine block with coolant leaking into cylinder number 3. Complete engine and turbo replacement is needed quoted at $11k.

The contact owns a 2018 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The contact stated that an unknown error message related to the coolant was displayed on the instrument panel. The vehicle was taken to a local service center, where it was diagnosed with a blown head gasket due to coolant intrusion into the cylinders. The local dealer was contacted; however, the vehicle was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.

The vehicle was shaking really bad when started. I took the vehicle to a mechanic since it seemed like it was mis-firing. I was told the vehicle was leaking coolant into the 2nd cylinder causing damage to my engine. I was told I needed a whole engine replacement. I called Ford Customer care and was told there is no service programs for my VIN number. I also purchased the extended warranty when purchasing this vehicle which just expired in NOV 2024. I can't believe Ford will not honor this engine replacement when I just saw online this was an ongoing issue and my vehicle was was in the time frame of 96 months or $150,000 mile time frame.

The coolant leaked, causing the need for a total engine replacement at only 68,000 miles. This has essentially totaled my vehicle, with the cost of repair exceeding the value of the car. It also placed my family and me at risk if the car had overheated. The vehicle has been inspected and the issue confirmed by my Ford dealer.

The car hit 101,000 miles, and the check engine light came on. I do not remember having the spark plugs replaces, so I took the car in to the dealership to have those done thinking that was the problem. They have the car for two days. The dealership replaced the spark plugs and the crank case. The day after the car came back it did not start. Then the next time I drove it, I made it half a mile down the road and it started smoking. After the car was towed to the dealership at 9:57 am, this is the first message I received from the dealership at 4:48pm on Tuesday. "I wanted to inform you the tech did take a look at the vehicle and found a bunch of codes to different parts of the system. The shop foreman, my manager, and my director are all involved to...

Check engine light came on and car would produce shaking and bumping feeling up on startup Took vehicle to AAA tire and auto Sylvania, Ohio. Service shop performed diagnostic. Used scope to visualize coolant in the third cylinder of the engine. Tech said that the cylinder was almost completely full of coolant and engine would fail soon and would need replaced. A few days later the car is now producing smoke from the exhaust and is now undrivable due to safety concerns from smoke and potential failure while driving.

Vehicle acts like it wants to stall when it starts. I had it checked and it has coolant intrusion on cylinder 3 from engine block. Ford dealer says it does not fall under a replacement campaign. I called Ford consumer support and was told that if the vehicle had been manufactured in building A versus B, it would be fixed by Ford. So, all the same parts are used to manufacture the vehicles................they all will have the same issue. The 21N12 campaign needs to be expanded to cover all vehicles since they have the same motor which results in the same issue. This vehicle has 43,932 miles on it so it hasn't even lasted the 60,000 miles that one would expect the engine to last. I am requesting that the NHTSA assist in getting this engine replaced since it is a known issue. Ford needs to replace all faculty engines.

This vehicle has a known issue with coolant intrusion into the engine, while driving down the highway this caused my car to instantly send an engine overheating message and send the car into limp mode. While driving in the left lane i quickly lost all power and was limited to roughly 10mph to try and merge across 3 lanes of traffic. There was a customer satisfaction program to fix this but i am 6k miles beyond qualifiying.

Ford Customer Satisfaction Program 21n12. Coolant intrusion into one or more cylinders for the 1.5L Ecoboost motor. Ford will not repair this motor under the 21n12 code beyond 7 years or 84,000 miles. CSP 19b37 is required prerequisite prior to performing the 21n12 repair, so the 21n12 repair timeline therefore should start at the date of the 19b37 repair. My vehicle is just 4 months out of the 7 years (in service date) and Ford won’t cover the repair. Vehicle is inoperable and the repair cost will exceed the cars value after repairs are made. The vehicle currently has 79,xxx miles which is unacceptable by today’s vehicle life standards.

Coolant intrusion in engine block for the second time.

Recall 21n12 Was sold this car from ford dealership without them disclosing this recall that has been in affect for years Now being told that my engine failed due to this recall but that ford isn’t going to cover it due to it being past the recall date now and I was quoted $14,000 which is more than what the car was even worth in the first place

I purchased a 2018 Ford escape from a dealership in 2023. Has know recall issue/ issues dealership should have notified me of. Also manufacturer warranty should cover but warranty is limited to time I didn't own the vehicle. Was not notified as required by statute.

Short Block Coolant Intrusion as described in Customer Satisfaction Program 21N12 dated June 9, 2022.

The contact owns a 2018 Ford Escape. The contact stated that while attempting to start the vehicle, the engine failed to turn over. The check warning light was illuminated. The vehicle was towed to a local dealer, where it was diagnosed with coolant intrusion into the engine which caused the #4 spark plug to be rusted, and a failure with the long block. Upon further investigation, the contact related the failure to an unknown NHTSA Campaign Number; however, the VIN was not included. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 137,000.

Coolant leaking into cylinders caused engine failure at approx 113,000 miles. I took it to a dealership and they said the engine had to be replaced. I did so and had it replaced at $8464.12 This is a known problem with this Ecoboost engine

What component or system failed or malfunctioned, and is it available for inspection upon request?: The engine - coolant leaked and is leaking into one of the piston heads - this is in line with what has happend to several others regarding their Ford Escape. How was your safety or the safety of others put at risk?: The engine was miss-firing - luckly I took it in before anything serious happened, but when I press the gas, it didn't always accelerate. Has the problem been reproduced or confirmed by a dealer or independent service center?: Yes, both Ford HQ and the dealership have confirmed this problem. Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others?: Yes Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?: Engine light was flashing.