2013 CHEVROLET VOLT Fuelpropulsion System Problems

I received the "Propulsion Power is Reduced" Alert engine light while driving in "Normal" mode on the freeway at around 60mph with 8-9 miles of Battery capacity, it showed 0 miles of Battery forcing the Gas Engine on and the vehicle hesitated upon applying the accelerator for the remainder of the drive. My safety and that was others was at risk because the acceleration dropped quickly and I was on a busy freeway at the time when the Alert happened causing further hesitation. Upon stopping I could not get the vehicle to take a charge nor would it start up until a mechanic arrived and was able to confirm the problem.

Propulsion power reduced error has happened many times but the recall lookup shows that there are no active recalls on our car. There was a recall on this problem in 2018 so I think it may have been done my the last owner but it is still having this problem.

Fuel leaking from fuel tank at filler inlet. Defect in fuel tank assembly. Large puddle of gasoline formed under car after refueling causing buildup of fumes in closed garage. Vehicle has not been inspected by anyone other than owner. There were no warning lamps prior to failure.

This is a reoccurring problem that is worsening. It is difficult to replicate (but becoming easier to replicate as the problem worsens). The problem conditions are as follows: -The car is fully charged The following drive conditions are required: - The beginning of a drive, with the car in the fully charged state, is driven in the “L” mode (aggressive regenerative braking), AND the beginning (first mile or two) of the trip includes some conditions that would NORMALLY engage regenerative breaking and redirect energy flow back to the high voltage battery. (E.g.: Beginning a drive by going up a small incline; then proceeding to drive down a decline.) OR - The beginning of a drive, with the car in the fully charged state, is driven in the “D” mode, AND the beginning (first mile or two) of the trip includes almost exclusively conditions that would NORMALLY trigger regenerative breaking and...

Vehicle went into reduced propulsion mode and then shut-off while driving down the highway. Same issue as recall 18V397000 that was not applied to my VIN number as part of that recall. Please apply recall 18V39000 to my vehicle VIN. Chevy Volt owners also need the NHTSA to issue an edict to GM/ that the reset codes for the ECM/HPCM2 being given to the OBD2 bi-directional scanner companies so owners don't have to pay a ransom to the dealerships and GM to get there cars back up and running.

Engine shuts off randomly...message "Engine not available". Car shut off on freeway at 60 mph. Got to shoulder, cycled start button...Engine started then resumed driving. Has now happened a few times since. Also code related to reduced propulsion... Used OBDII to clear codes but makes no difference. Sometimes the car starts and drives without problem. Other times, Engine rpm very erratic.

This report is in general for EV batteries and low propulsion, BMW also. When system moves to low propulsion the break lights do not eliminate so the vehicle slows very fast as if it is breaking but no break lights turn on, this creates a risk for other drivers, this occurs on steep mountain climbs when mountain mode was not engaged. What I want to happen is when low propulsion mode engages the break lights come on so that other drives can keep safe distance as I pull to the side for battery to recharge. This does not happen that often but when it does occur it creates a scary situation. A electric BMW also did this today. Please request a break light adaption for future EV batteries/Gas Powered vehicles. Keep in mind this is generally for electric cars that have a backup gas engine that powers after battery is...

When starting the vehicle, which had some charge on the batteries, the engine immediately started and a message appeared on the speedometer screen which stated, "Propulsion Power Reduced,” and another message said, “speed limited to 25mph.” I was in a very busy part of Hollywood running errands for my job when this happened. I felt very unsafe driving under these circumstances as I often need to drive above 25mph to keep up with traffic and cross busy streets to avoid other cars. The vehicle is available for inspection. It has not been taken to a dealership or anywhere else to have the issue looked at. The problem has occurred a few other times. The vehicle has not been inspected by the manufacturer, police, insurance representatives or others. There were no warnings or other symptoms whatsoever prior to this issue occurring.

1)A diagnostic inspection performed by Terry Labonte Chevrolet in Greensboro, N.C., during the week of Feb. 5-9 found that the car’s propulsion system suffered “catastrophic failure” and was a “total loss.” 2)My wife and I were in convoy when we drove off the used-car lot in Pittsboro, N.C., on [XXX], heading for my sister’s home in Greensboro. By the time we reached [XXX], the Volt would not reach highway speeds as heavy traffic sped past. As NHTSA has reported in another Volt investigation, “the problem could pose a safety risk if vehicles can’t move with the flow of surrounding traffic and is more serious if a stalled vehicle is unable to restart.” 3) On Tuesday, [XXX], a Terry Labonte Chevrolet service representative in Greensboro reported that the main battery had experienced “catastrophic” failure and the “major malfunction” represented a “total loss." 4) Factory dealer Terry Labonte Chevrolet in Greensboro performed...

My 2013 Volt will not charge or start. This happened suddenly. It has been working fine.

I was driving my plugin hybrid Volt on a highway when the engine stalled and the engine light turned on. I tap the throttle a few times to get it to stay on. It worked, but I had to continue to tap the throttle to keep it going. It also revved up sharply when it was in low gear. The vehicle was out of battery, so it was as running on engine.

I received a notification on the dashboard that the engine is not in service and propulsion has been reduced. The car is available for inspection upon request. The safety and myself has been deeply compromised because the issues cause the car to suddenly not accelerate without warning. The issue happened to me on a freeway and could have caused an accident due to the engine and propulsion systems stop functioning without warning. The vehicle has been inspected. There were no warnings on why the car was doing what it was doing. The only warning I received was that the engine and propulsion system has now stopped functioning.

We purchased this car used in January 2023. Several times throughout 2023 we have gotten a Propoulsion Power Reduced warning. When this happens the car’s ability to accelerate drops and we have also had problems getting it to charge. Following one incident, we let the car sit for 4 days. While the car still would not charge using our at home level 2 charger, the warning went away and I was able to drive it to a dealership. They ran a software update which they said should resolve the issue. Three times since then, when turning the car on from parked it in parking lots away from home, it has given the warning. While driving the car to get it home, the warning has spontaneously resolved.

1. Propulsion Power Reduced -AGAIN. We have had this repaired recently & it’s back. Apparently it’s “not a problem” as long as check engine light is not on. Unfortunately, the engine light is on AGAIN - despite being reset. The car is not accelerating when needed. 2. “Brake Assist” light is on AGAIN- and I do not have power brakes. It is hard to stop. Could we at minimum get accurate warning systems & repairs that work? 2.

Car suddenly lost ability to accelerate normally while driving. It could only accelerate extremely slowly, seemingly with great effort. It displayed “PROPULSION POWER REDUCED SERVICE ENGINE SOON” and ENGINE NOT AVAILABLE” messages on the dashboard, and a check engine light came on. It sounds like it may be related to current GM recall 18215/ NHTSA Campaign Number: 18V397000, but nothing comes up when I search for this VIN.

The car’s hybrid battery shut down the car in the middle of the road. I was unable to turn it back on safely.

I was driving through the grapevine and my car was losing propulsion. I had to drive in the slow lane with the semi-trucks. The semi trucks had to go around me. I am nervous about driving my car on a road trip to North Cal. I am not sure if that is normal, but I don't think so. The airbag light just went on. I am not sure why. My car has also on several occasions lost traction. Has anyone reported these problems before?

When Im driving on the hi way, it sounds like it keeps accelerating, sounds like its going to explode. The pulsation warning comes on, then the pulsation warning will go away and the sound goes away.

There is a bearing that fails in the motor which is a safety issue and should be recalled. It causes the engine/transmission to lock up and become inoperable which can result in a crash. They even issued a bulletin regarding it (PIP5081), yet they have been refusing to cover it under warranty for me as well. This needs to be recalled and all affected owners should be reimbursed for any expenses they paid regarding this issue. General Motors must be held accountable for this safety issue. This has been confirmed by the dealer and all of these vehicles are experiencing the issue.

My 2013 Volt has turned off while driving on multiple occasions, usually while on the highway. I have taken it to the Chevy dealer on several occasions and they are unable to find the problem. The vehicle "Propulsion System" warning has come on when the car suddenly decelerated while on the highway and eventually turned off. The vehicle is at the Chevy dealer who tells me they cells were not balanced and is no longer functioning. They are unable to replace the battery because Chevy is not releasing them so now the car is a paperweight in their parkinglot. Stopping on the highway is a serious problem.

Before battery ran out went to gas, I got the Propulsion Power Limited warning on the dash slowed gradually to a halt, next day car is dead, it won't start or change, nothing. Code P0AFA and P1E00. All recalls were done a year before

VEHICLE HAS STOPED IN THE MIDDLE OF THE STREET ON SEVERAL OCCASIONS. DURING THIS TIME THE VEHICLE WILL POST AN ERROR ON THE DASH SCREEN. THIS ISSUE HAPPENS WHEN THE VEHICLE TRANSITIONS FROM ELECTRIC FUEL TO GASOLINE, WHEN THE ELECTRIC FUEL IS DEPLETED. CHEVY REFUSES TO REPAIR OR WARRANTY THE VEHICLE, ALSO THE DEALER REFUSES TO COMPLETE THE NECESSARY RECALLS ON THE VEHICLE. THE VEHICLE DOES NOT RETURN TO NORMAL UNTIL YOU TURN THE VEHICLE ON AND OFF MULTIPLE TIMES.

PLEASE SEE ATTACHED DOCUMENT FOR FULL DESCRIPTION OF THE UN-COMMANDED SELF ACCELERATION ISSUES IN MY 2013 CHEVY VOLT INCLUDING MY CONTACT INFORMATION. THANK YOU!

THREE TIMES THE VEHICLE HAS LOST PROPULSION POWER RESULTING IN REDUCED ACCELERATION AND NO LONGER STARTING. IT IS AT A DEALERSHIP FOR THE THIRD TIME FOR REPAIRS. THE RECALL INSTRUCTIONS WERE COMPLETED IN 2019; HOWEVER, I CONTINUE TO HAVE THE SAME PROBLEM. THE DEALER IS NOW JUST CHARGING ME FOR REPLACEMENT ITEMS (112 VOLT BATTERY, CLUSTER) INSTEAD OF DEALING WITH THE ACTUAL PROBLEM WITH THE VOLTEC BATTERY THAT IS UNDER WARRANTY.

THE VEHICLE AIRBAG SERVICE CONTINUALLY GOES ON WHILE DRIVING AND IN PARK. THERE HAS BEEN NO SPILLS OR RELATED ISSUES WITH THE SEAT BUT THE SENSOR HAS OBVIOUSLY MALFUNCTIONED.

TL* THE CONTACT OWNS A 2013 CHEVROLET VOLT. THE CONTACT STATED WHILE DRIVING AT 75 MPH, THE VEHICLE DECELERATED INDEPENDENTLY. THE CONTACT PULLED OVER TO THE SIDE OF ROADWAY. PROPULSION POWER REDUCED WAS DISPLAYED ON THE INSTRUMENT PANEL BEFORE THE VEHICLE STALLED. AFTER WAITING FOR TEN MINUTES, THE VEHICLE STARTED AND OPERATED AS INTENDED HOWEVER, THE MESSAGE REMAINED DISPLAYED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO PARADISE CHEVROLET CADILLAC (27360 YNEZ RD, TEMECULA, CA 92591) HOWEVER, NO ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A CASE NUMBER WAS PROVIDED. THE FAILURE MILEAGE WAS APPROXIMATELY 107,000. *LN*JB*DT THE CONSUMER HAS STATED THAT THE ISSUE OCCURED ONCE MORE ON JULY 11 AND JULY 12 OF 2020. *AS

THIS VEHICLE SUDDENLY LOOSES PROPULSION WHILE DRIVING AND IT SWITCHES FROM ELECTRIC TO GAS. IT HAS HAPPENED MORE THAN ONCE, BUT THIS LAST TIME I WAS ON THE HIGHWAY AND ALMOST CAUSED AN ACCIDENT. I TOOK IT TO A DEALER TO BE REPAIRED BUT THE PROBLEM HAS PERSISTED.

MY CAR HAD THE EXACT ISSUES THAT ARE DOCUMENTED IN NHTSA CAMPAIGN NUMBER 18V397000 WHILE DRIVING ON THE FREEWAY, I GOT A LOW PROPULSION WARNING WHEN THE LITHIUM BATTERY WAS DEPLETED AND SWITCHED TO ENGINE. ENGINE WAS REVVING VERY HIGH AND ALMOST NO ACCELERATION WAS AVAILABLE. I MADE IT HOME AND CAR WOULDN'T RESTART. 12V BATTERY WAS DEAD SO I REPLACED IT BUT STILL COULD NOT START THE CAR.

REDUCED PROPULSION WARNING. CAUSES CAR TO NOT GO OVER 40 MPH WHILE DRIVING. COVERED UNDER VOLTECH WARRANTY BUT DEALERS WANT TO CHARGE FOR THE DIAGNOSIS. UNFAIR, AS THIS IS A SAFETY CONCERN. I REFUSE TO PAY FOR A WARRANTY DIAGNOSIS.

I WAS DRIVING MY 2013 CHEVROLET VOLT AND I RECEIVED A LOSS OF PROPULSION MESSAGE ON MY DASHBOARD AND IMMEDIATELY FOLLOWED BY A CHECK ENGINE LIGHT. MY CAR SHUT DOWN AND SLOWED DOWN ON THE FREEWAY AS I WAS DRIVING. IT WAS VERY DANGEROUS BECAUSE IT WAS ALSO DARK. I WAS ABLE TO GLIDE TO EXIT THE FREEWAY. MY CAR CAME TO A COMPLETE STOP IN THE EXIT LANE OF THE FREEWAY. I PRESSED THE POWER BUTTON TO TURN OFF THE CAR AND THEN I WAITED ABOUT 30 SECONDS AND I TURNED THE POWER BUTTON BACK ON AND THE CAR CAME ON AS ONLY POWER MODE. I WAS ABLE TO MOVE THE CAR VERY SLOWLY SOMEWHERE MORE SAFE. I CALLED TOW TRUCK AND I TOWED IT TO DEALERSHIP. THE VOLT WAS STILL ABLE TO MOVE SLOWLY UP THE TOW TRUCK AND WHEN I ARRIVED AT THE DEALERSHIP, IT WAS STILL...

CAR SLOWED DOWN AND THEN CAME TO A FULL STOP ON SIDE OF RESIDENTIAL STREET. TRIED TO TURN OFF AND RESTART ENGINE TO NO AVAIL. NO POWER COMING FROM MOTOR

OVERALL BATTERY LIFE APPEARS TO HAVE BEEN REDUCED FROM AVERAGE 38 MILES AT FULL CHARGE TO 31 MILES.

I HAVE HAD MY CAR FOR 2 YEARS AND HAVE NOT EXPERIENCED ANY ISSUES WITH THE BATTERY OR PROPULSION CONTROL SYSTEM. I GOT A RECALL NOTICE TO FIX "LOSS OF PROPULSION DUE TO LOW CELL VOLTAGE". THE SERVICE TEAM WAS VERY NICE, I SAT IN THEIR WAITING ROOM FOR ABOUT TWO HOURS. THEY SAID IT WAS DONE SO I THEN WENT TO WORK FOR A COUPLE HOURS. WHEN DRIVING HOME I GET TO THE POINT WHERE THE INITIAL ELECTRICAL BATTERY IS DEPLETED AND THEN IT TURNS ON THE GAS GENERATOR. I IMMEDIATELY GET AN ALERT "LOSS OF PROPULSION" AND THE CAR STOPS ACCELERATING AND DRIVES VERY DIFFERENT. LOW ACCELERATION, AC TURNS OFF. I MAKE IT HOME AND THEN THE CHARGING SYSTEM SAYS IT IS NOT WORKING. I TRY TO TURN THE CAR BACK ON AND IT DOESN'T LET ME PUT IT IN GEAR. I CALLED ON STAR AND THEY SCHEDULED...

WHILE STARTING VEHICLE FOR COMMUTE BACK HOME, THE ON BOARD DIAGNOSTIC WARNING POPES UP SAYING THAT PROFUSION PEER WAS REDUCED. THE GASOLINE ENGINE THEN TURNED ON EVEN THOUGH BATTERY WAS APPROXIMATELY 75% CHARGED. WHILE DRIVING I NOTICED THAT THE VEHICLE HAD DIFFICULTY WITH ACCELERATION AS WELL AS DECELERATION; AS A RESULT, I ELECTED TO TAKE THE SIDE STREETS INSTEAD OF THE INTERSTATE

WHILE ON THE HIGHWAY AND THE MAIN HIGH VOLTAGE BATTERY IS DEPLETED, I HAVE A SUDDEN REDUCTION IN SPEED AND ZERO ACCELERATION. I GET A DASHBOARD ALERT "PROPULSION POWER REDUCED". "REDUCED" IS AN UNDERSTATEMENT! THE GAS ENGINE TRIES TO KEEP UP WITH SPEED BY RAMPING UP THE RMPS. THE SUDDEN LOSS OF SPEED FORCES OTHER CARS TO AVOID ME AND I CANNOT INCREASE MY SPEED IF NEEDED. I EXPECT I WILL BE REAR ENDED OR LOSE CONTROL WHEN THIS HAPPENS AGAIN. ENGINE REVS EXTREMELY HIGH. I USUALLY PULL OVER AND TURN OFF VEHICLE- SOMETIMES A RESTARTS FIXES IT. I HAVE ALSO WAITED (5 MINS?) WITH THE ENGINE RUNNING AT HIGH RMPS HOPING THE BATTERY WOULD RECOVER, BUT NO. I ALSO FEAR THE GAS ENGINE WILL OVERHEAT. THE CAR CAN NO LONGER DRIVE AT HIGHWAY SPEEDS SAFELY AFTER DEPLETION AND CANNOT ACCELERATE SUFFICIENTLY EVEN IN A 30MPH ZONE. THIS IS A...

2013 CHEVY VOLT STOPPED ACCELERATING AND RECEIVED A LOW PROPULSION WHILE DRIVING ON A STATE ROUTE IN OHIO. OUR SON WAS DRIVING THE VEHICLE AND COULD HAVE BEEN KILLED IF THIS WAS ON A HIGHWAY. THE VOLT WOULD NOT MOVE AND HE HAD TO TRY TO GLIDE OFF THE ROAD SINCE IT HAD NO POWER. HE PUSHED THE CAR OFF THE ROAD SO IT WOULD NOT BE HIT. IF THIS SITUATION WOULD HAVE OCCURRED WHILE DRIVING ON THE HIGHWAY, OUR SON COULD HAVE BEEN KILLED. THIS PROBLEM HAS OCCURRED TO OTHER VOLT OWNERS IF YOU LOOK THIS ISSUE UP ON THE INTERNET. WHY HASN'T GM FIXED THIS ISSUE SO PEOPLE ARE SAFE WHEN DRIVING THIS VEHICLE? WE BROUGHT OUR VOLT INTO THE SERVICE DEPARTMENT, THIS CAR IS NOW GOING ON 3 WEEKS AND WE STILL DO NOT HAVE OUR CAR BACK. THEY FIRST SAID IT WAS A SHORT IN THE...

VOLT HAS MINIMAL PROPULSION WHEN STOMPING ON THE ACCELERATOR IN ELECTRIC OR HYBRID MODE. IT HAS LOST 60-70 PERCENT OF ITS POWER SINCE NEW. IT IS A SAFETY HAZARD WHEN PULLING ONTO A HIGHWAY OR NEEDING TO ACCELERATE TO AVOID A ACCIDENT. CHEVROLET SAYS NOTHING IS WRONG AND REFUSES TO ACKNOWLEDGE THE ISSUE NOT WANTING TO HONOR ELECTRIC WARRANTY.

ON SEPT. 5TH 2018 I HIT THE CENTER ISLAND WHILE TURNING ON THE CITY STREET AT ABOUT 15MPH. THE IMPACT WAS SO SLIGHT THAT THE AIR BAGS DIDN'T EVEN DEPLOY. I WAS ABLE TO GET IT TO THE DEALERS ON IT'S OWN POWER. MY INSURANCE COMPANY SENT THEIR APPRAISER ,JEREMY , TO INSPECT THE DAMAGE. I HAD TO GET SOME ITEMS OUT OF MY CAR BEFORE THAT. THE MECHANIC HAD THE CAR ON THE RACK SO HE COULD SHOW ME. THE ONLY DAMAGE I READILY NOTICED WAS THE RADIATORS WERE CRUSHED, A 2 1/2" SQUARE FRAME CROSS MEMBER HAD A 1 1/2" DENT WHERE IT HAD IMPACTED THE ISLAND , AND SOME PANELS- NOTICEABLY THE FRONT UNDERSIDE AND DRIVER SIDE FRONT WHEEL WELL WERE DAMAGED. LATER JEREMY CALLED ME AND TOLD ME THE CAR WAS A TOTAL LOSS.HE SAID THE ENTIRE FRAME WAS BENT OUT OF SHAPE. I COULDN'T BELIEVE...

THE CAR REDUCES SPEED WITHOUT ADVANCE WARNING ON HWY AND DECREASES TO 30-40 MPH IN A 65-70 MPH ZONE. THE AIR CONDITIONING STOPPED WORKING, SOME SAFETY ELECTRICAL COMPONENTS MALFUNCTION MID DRIVE AND RESUME WORKING

I'VE BROUGHT MY 2013 CHEVY VOLT TO THE DEALERSHIP 4 TIMES BECAUSE IT DIES SUDDENLY WHILE DRIVING. IT HAS PUT MY FAMILY IN DANGER MULTIPLE TIMES. ONE OF THE "FIXES" WAS A SOFTWARE UPDATE THAT ENDED UP AS A RECALL BECAUSE IT CAUSES THE ENGINE TO DIE SUDDENLY (IT'S RECALL #N172130460, WHICH CAME OUT TWO DAYS BEFORE MY LATEST INCIDENT, BUT I DIDN'T RECEIVE THE RECALL NOTICE IN THE MAIL UNTIL 7/28/18...6 WEEKS AFTER MY LAST INCIDENT). THE MOST RECENT TIME THE CAR DIED (6/16/18), I WAS ON A MOUNTAIN HIGHWAY AND I WAS LUCKY ENOUGH TO NOT GET HIT AS I PULLED THE CAR TO THE SIDE. THERE WAS NO SIGNAGE THERE EXCEPT FOR THE "CAUTION BEAR XING" SIGN. AFTER TOWING MY CAR TO THE NEAREST DEALERSHIP (IN CARSON CITY, NV, AN 8 HOUR ORDEAL), I HAD EXPENSES FOR LODGING AND TRANSPORTATION (INCLUDING LYFT TO SOUTH LAKE TAHOE TO...

DRIVING IN TRAFFIC, MULTIPLE LANES.." REDUCED POWER" MESSAGE APPEARS ON DASH..CAR SHUTS DOWN IMMEDIATELY...NO STEERING ASSIST...BRAKES OKAY...STUCK IN MIDDLE LANES WITH NO PROPULSION...LUCKILY A FIRETRUCK HAPPENED BY AND WAS PUSHED OFF THE ROAD...CAR TOWED TO DEALER. INFORMED MULTIPLE VOLTS TOWED IN FOR SAME ISSUE. ALSO INFORMED EXTREME BACKORDER FOR REPAIR BATTERY ACROSS U. S. TOLD APPROX 2 MONTH WAIT FOR BATTERY SECTION...ONCE THIS BATTERY FAILS WHILE YOU ARE DRIVING, YOU ARE DEAD IN THE WATER...NO POWER STEERING AND UNABLE TO MOVE IN OR OUT OF TRAFFIC...IF THIS DEALER HAS 3 CARS, HOW MANY UNSAFE CARS ARE THERE ACROSS THE COUNTRY?

LOST POWER WHILE DRIVING DOWN THE ROAD!

TL* THE CONTACT OWNS A 2013 CHEVROLET VOLT. WHILE DRIVING FOR MORE THAN TWO HOURS OVER 75 MPH, THE "PROPULSION POWER LOW DECREASE SPEED" MESSAGE DISPLAYED AND THE SPEED DECREASED TO 55 MPH. WHEN THE FAILURE OCCURRED, SMOKE WAS PRESENT INSIDE AND OUTSIDE THE VEHICLE AND THE ODOR OF FUEL WAS PRESENT. THE CONTACT INDICATED THAT THE FAILURE OCCURRED ON MULTIPLE OCCASIONS. THE CAUSE OF THE FAILURE WAS NOT DIAGNOSED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 30,000.

WHILE DRIVING DOWN A ROAD IN INDIANAPOLIS AT 35 MILES PER HOUR, MY CAR SUDDENLY SLOWED DOWN AND A MESSAGE READING " ENGINE NOT AVAILABLE - SERVICE SOON" APPEARED ON MY HUD. MY CAR ONLY HAS 32,800 MILES ON IT AND A CLEAN TITLE. NOTHING ABOUT MY DRIVING CHANGED TO CAUSE THIS ISSUE, IT WAS SUDDEN AND WITHOUT APPARENT CAUSE. I HAD THE CAR TAKEN TO THE MECHANIC, AND GM JUST RESET THE CODES. IT IS DRIVING OK FOR NOW, BUT A RESET OF CODES IS A TEMPORARY FIX TO THE ISSUE, AND I'VE READ EXTENSIVELY ABOUT MANY, MANY OTHER VOLT OWNERS WITH THE SAME ISSUE. IT IS EXTREMELY DANGEROUS TO HAVE YOUR ENGINE SHUT OFF WHILE DRIVING, ESPECIALLY IF I HAD BEEN ON THE HIGH WAY DURING RUSH HOUR. THIS IS SOMETHING THAT NEEDS LOOKED INTO, AND I FEEL THAT GM IS TRYING TO BURY IT WITH RESETS WHICH...

WHILE ENTERING IN THE HIGHWAY THE CAR STARTED TO DECELERATE REGARDLESS THE FACT THE GAS PEDAL WAS PUSHED SEVERAL TIMES. THE CAR DECELERATED AND THEN STALLED. THE CAR HAS BEEN REAR ENDED BY THE CAR BEHIND. THIS COULD HAVE BEEN A MUCH MORE SERIOUS ACCIDENT AND IT WAS A VEHICLE FAILURE.

A WARNING MESSAGE APPEARED ON THE DASH, WHICH SAID "PROPULSION POWER IS REDUCED," FOLLOWED BY, "ENGINE NOT AVAILABLE. SERVICE SOON," AS WELL AS A CHECK ENGINE LIGHT. I PRESSED THE ONSTAR BUTTON TO FIND OUT WHAT WAS WRONG BUT THEY HAD NEVER HEARD OF THE ERROR MESSAGE AND COULD NOT ESTABLISH COMMUNICATION WITH THE VEHICLE TO PERFORM DIAGNOSTICS. WHILE ON HOLD WITH ONSTAR, THE VEHICLE BEGAN TO SPONTANEOUSLY DECELERATE VERY RAPIDLY DESPITE MY ATTEMPTS TO ACCELERATE, IN THE MIDDLE OF FAST HIGHWAY TRAFFIC. I MADE IT OVER TO THE SIDE OF THE ROAD SAFELY, LIMPING ALONG AT 3-10 MPH, WITH THE HELP OF A GOOD SAMARITAN WHO BLOCKED TRAFFIC FOR ME. THIS IS A SPONTANEOUS OCCURRENCE, WITH NO MAINTENANCE NEGLIGENCE TO EXPLAIN THE EVENT. THE CAR WAS TOWED TO A DEALER, WHICH HAS YET TO DETERMINE THE SOURCE OF THE ISSUE. *TR

THE INCIDENT OCCURRED ON 8/27/14, AND RESULTED IN MY WIFE ME TAKEN TO THE HOSPITAL AND TREATED FOR CARBON MONOXIDE POISONING. THE INCIDENT OCCURRED AT OUR HOME. THE VOLT WAS PARKED IN THE ENCLOSED GARAGE ON 8/26 AROUND 7PM. THE 240 VOLT CHARGER WAS PLUGGED IN AS USUAL. I DID NOT NOTICE ANYTHING UNUSUAL AFTER PLUGGING IN THE CHARGER, AND THE VOLT WAS LEFT UNATTENDED UNTIL THE EMS ARRIVED AROUND 11AM THE FOLLOWING DAY. THE EMS PERSONNEL FOUND THE ENGINE RUNNING, VERY HIGH LEVELS OF CO UPON ENTERING THE GARAGE AND EVEN HIGHER LEVELS INSIDE THE CAR. THE INSIDE OF THE PASSAGE COMPARTMENT WAS DESCRIBED AS HOT. THE FRONT EXTERIOR OF THE CAR WAS TO HOT TO TOUCH AND THE CAR REAR WARM. THE TEMPERATURE UNDER THE CAR HOOD WAS DESCRIBED AS "RED HOT". THE ENGINE HAD CONSUMED AROUND 5 GALLONS OF GAS DURING THIS TIME PERIOD. DISTRIBUTION OF THE...

I RECEIVED THE FOLLOWING MESSAGE ON THE CAR DASH DISPLAY: PROPULSION REDUCED-ENGINE NOT AVAILABLE. THIS MESSAGE CAME ON WHILE I WAS DRIVING IN THE CARPOOL LANE. I CALLED GM THRU ON STAR AND WAS TOLD THAT I HAD A CATASTROPHIC ERROR AND NEEDED TO GET MY CAR INTO REPAIR WITH 24 HOURS. WITH ONLY 6 MILES LEFT ON THE BATTERY, I TOLD THE GM REP THAT I BETTER GET THE CAR TO A CHEVY DEALER. I IMMEDIATELY DROVE TO THE DEALERSHIP IN CULVER CITY. THE MINUTE I PULLED INTO THE DRIVEWAY OF THE DEALERSHIP, MY CAR STOPPED AND WOULD NOT RESTART. THIS COULD HAVE BEEN A DISASTER IF THE CAR HAD STOPPED IN THE CARPOOL LANE. I HAVE READ OF OTHER COMPLAINTS ON GOOGLE AND YAHOO. I WAS TOLD BY THE DEALERSHIP THAT THEY WERE GOING TO REPLACE THE ENGINE MODULE, WHICH THEY SAID WOULD TAKE 8 HOURS TO REPAIR,...

THE VEHICLE HAS REPEATEDLY SHUT DOWN WHILE DRIVING/FAILED TO START SINCE JUNE 2013. THE VEHICLE HAS BEEN IN SERVICE DUE TO REPAIRS = 42 DAYS IN THE LAST 10 MONTHS. GM CONTINUES TO REPLACE/RECALL PARTS ON THE HYBRID BATTERY AS WELL AS OTHER PARTS CONCERNING SECONDARY PROBLEMS. I AM AFRAID THIS VEHICLE WILL SHUT DOWN AGAIN WHILE I AM DRIVING CAUSING AN ACCIDENT HURTING ME OR OTHERS ON THE ROAD. CLEARLY, IT IS A POTENTIAL DEATH TRAP. *TR

MY CHEVY VOLT WAS AT A CAR WASH AND THE ATTENDANT WAS ABLE TO TURN THE CAR OFF WHILE STILL IN "D" GEAR. THE CAR IS ABLE TO ROLL AND MOVE WHILE IN THIS GEAR. I WAS SURPRISED SO I TESTED IT FOR MYSELF, AND SURE ENOUGH YOU'RE ABLE TO TURN THE POWER OFF AND EXIT THE VEHICLE WHILE STILL IN 'D'. EVERY CAR I'VE OWNED (AUTOMATIC) FORCES YOU TO SHIFT INTO P OR N BEFORE ALLOWING THE KEY TO REMOVE. THIS IS A GREAT CONCERN FOR ME, SO I CALLED MY VOLT ADVISOR TODAY AND WAS INFORMED THAT OTHER CUSTOMERS ROLLED INTO THEIR GARAGE, AND THE BEHAVIOR WAS BY DESIGN AND NORMAL. *TR