2014 BMW 328D Unknown Or Other Problems

[XXX] - Purchase vehicle, odometer 109,803. 11/2019 - Car went into limp mode while driving on highway. Towed to BMW dealership and was advised needed new engine, at the time it only had 123,661 miles on it. Towed to EurAuto Shop for installation of replacement engine. 02/2020- The shop replaced the ceased OEM engine with a 2015 engine, with only 60,000 miles on it. EurAuto Shop tore down OEM engine and confirmed the timing chain guide broke, resulting in jumped timing and caused valve to hit piston. Total cost for engine replacement $6,641.49. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

12/2023 - Sewell BMW replaced EGR, all H/P fuel lines at injectors due to corrosion, injector harness due to heat damage to the wire jackets, cracked coolant pipe. At 145,976 that's an additional 22,315 miles on the 60,000 mile 2015 replacement engine. Total repair costs $3,939.45. 08/23/2024 - Passed inspection, odometer 149,701. 09/09/2024- Only 2 weeks later an estimate of 4,000 miles after replacing injector harness and H/P fuel lines, engine went up in flames, reason unknown. Pictures attached, vehicle was a total loss.

The driver side door lock mechanism failed completely while the driver was in the vehicle, making it impossible to open the driver side door or exit the vehicle normally. Neither the interior door handle, nor the central power lock/unlock control, nor the remote key fob, nor the physical key inserted into the door lock from the outside can unlock the door. The driver was forced to exit the vehicle by moving the driver seat to an extreme aft position, then climbing over the center console into the passenger seat, to exit via the passenger door. If the power seat adjustment had been inoperable, egress would have bee significantly more difficult. If the driver had been involved in a collision, or otherwise needed to exit the vehicle very quickly, they would have been severely hindered from doing so. Inability to operate the driver side door represents a safety hazard to the...

Have been waiting since March to get Safety Recall No. 21V-907:EGR Cooler completed. BMW of Henderson is the dealership. I called BMW customer relations and they told me each dealer is independently owned and they can’t do anything for me. This dealership is notorious for poor service.

Diesel Emissions System is producing an error code due to incorrect coding by the manufacturer for US grade Diesel fuel. Check engine light has come on. There are warranties out for the model years just slightly older than mine. I have read many threads with people talking about having the same issue.

I was driving down the Massachusetts Turnpike with my 2 year old grandson and I experienced a power loss in the car. I immediately pulled over and opened the hood to find a fire starting in the engine compartment. I got my grandson out of the car and within minutes it was engulfed in flames. This in my opinion is a direct result of the BMW recall 21V-907 and I am really shocked drivers falling under this recall are still driving these vehicles. Action needs to happen before serious injury or death occurs.

Exhaust smell from engine bay area comes into car since I bought the car. I reported this problem to the dealer and no solution was found. EGR cooler was not replaced even though I get the recall since 2018 and it states that the exhaust smell could possibly comes from EGR. Problem needs to be addressed by BMW since I use this car to drive my infant. Please advise!

UNKNOWN- NOT SAFETY RELATED ISSUE: VEHICLE CAN NO LONGER PROVIDE NAVIGATION RELATED FEATURES REASON: BMW NORTH AMERICA DECLINED TO UPGARE CELLULAR 3G COMMUNICATION CAPABILITY TO 4G (SIM CARD INTERFACE) REASON: NORTH AMERICAN CELLULAR NETWORKS ARE DISCONTINUING THEIR 3G NETWORKS AND AND ARE UPGRADING TO 4G NETWORKS. MANY CANY MANUFACTURERS PROVIDE VEHICLE RELATED FEATURES THAT REQUIRE THE VEHICLE TO COMMUNICATE VIA THE CELLULAR NETWORKS. IMPACT:CERTAIN BMW VECHICLES SOLD WITH MANUFATURER PURCHASED FEATURES FOR NAVIGATION WITH THE LIVE TRAFFIC CAPABILITY SOLD ON A SUBSRIPTION BASIS AFTER THE INTIAL WARRANTY PERIOD STOPPED FUNCTIONING BMW CUSTOMER INTERACTION RELATED INFO: - Attempted to use the live traffic info and contacted BMW customer service - Response was that this feature is no loger available because it uses 3G and 3G is being discontinued. I was directed to the local Dealer for upgrade - Local Delar confirmed that do not have information for this upgrade and directed...

I WAS DRIVING THIS VEHICLE OVER THE WEEKEND, THE CAR STOPS ON THE ROAD ABRUPTLY. THE CAR SLOWS DOWN AND AUTOMATICALLY SWITCHES THE GEAR TO NEUTRAL AND COMES TO A HALT ON THE MIDDLE OF THE ROAD. THE CAR'S DASHBOARD INDICATED A WARNING "CHASSIS STABILIZATION" ERROR. I WAS ABLE TO RESTART THE CAR AGAIN AND WAS ABLE TO PROCEED MAYBE 2 MILES AND THIS TIME, IT STOPPED AT THE MIDDLE OF THE ROAD AGAIN. THIS TIME THERE WAS TRAFFIC BEHIND ME, I WAS REALLY FRIGHTENED SINCE THERE WAS TRAFFIC BEHIND ME! IT WAS A VERY NARROW MISS! I AM HAVING THE CAR TOWED TO A BMW DEALER TO INSPECT IT. I ALSO REPORTED THIS INCIDENT TO BMW CONSUMER AFFAIRS, I WAS ASKED TO CONTACT THE DEALER TO CHECK THE VEHICLE OUT.

PROBLEM DISCOVERED UPON INSPECTION FOR RECALL 18V-755 EXHAUST GAS RECIRCULATION COOLER, AFTER OVER SEVEN MONTHS NO PARTS, NO ACTION. *TR

WHEN TURNING LEFT OR RIGHT, THE POWER TO THE WHEELS IS NOT ENGAGED. HOWEVER, WHEN THE TIRE IS STRAIGHT, THE POWER ENGAGES. THIS ACTION PREVENTS YOU FROM DRIVING NORMALLY. TO DRIVE, YOU HAVE TO STRAIGHTEN OUT THE WHEEL STRAIGHT. THEN AS YOU INCREASE VELOCITY, YOU MAKE YOUR TURN. CAN BE VERY UNSAFE AS YOU ARE DRIVING IF THIS HAPPENS (BREAKS) ON THE ROAD. *TR

BLOWER MOTOR WHICH CONTROLS AIR FLOW FOR HEATING AND A/C SYSTEM , THE CONNECTION BETWEEN THE WIRING AND THE BLOWER MOTOR IS DETERIORATED ,THIS IS LEADING THE BLOWER TO ONLY BLOW HOT AIR AT ALL TIMES EVEN WHEN THE A/C IS ON ALSO MIGHT BE OVERHEATING THE CAR. PLEASE LOOK INTO THIS MATTER

MY VEHICLE CURRENTLY HAS AN EGR PROBLEM BUT FOR SOME REASON ISN'T COVERED UNDER THE RECALL... SOMETIMES MY FRONT PASSENGER DOOR WILL NOT OPEN! LIKE AT ALL! I WILL HAVE TO HIT THE UNLOCK BUTTON MULTIPLE TIMES BEFORE I CAN OPEN THE DOOR. MY DEF WAS FILLED WITH THE CORRECT FLUID AT THE APPROPRIATE TIME ABOUT 1K MILES AGO. SUDDENLY AS I'M DRIVING DOWN THE ROAD A LIGHT APPEARED THAT SAYS INCORRECT FLUID ADDED NO START AFTER XXX MILES. NOW VEHICLE WILL NO LONGER START. AFTER SEARCHING THE WEB OTHERS HAVE HAD THIS ISSUE CONNECTED TO NOX SENSOR. TAKING TO SHOP HOPEFULLY COVERED SINCE NOX SENSOR WAS JUST REPLACED FROM A RECALL.

IT'S UNDER RECALL AND THEY CALLED ME ONCE AND SAID PARTS NOT AVAILABLE AND IT'S BEEN 8 MONTH SINCE RECALL AND ISSUE HAS NOT BEEN RESOLVED

CAR HAS GONE THRU NUMEROUS SERVICE CALLS FOR COOLANT LEAK, PRESSURE TESTING & BURNT OIL SMELL & VAPOR FUME COMING INSIDE THE CAB WHEN ENGINE REACHES THE OPERATING TEMPERATURE!! MAKES THE CAR NOT DRIVABLE!! AFTER OIL FILTER HOUSING, CYLINDER COVER & GASKET CHANGE, THERE IS STILL A VISIBLE BURNT OIL SMOKE COMING FROM REAR & SIDES OF THE ENGINE AREA, BEST SEEN UNDER A FLASH LIGHT AFTER DUSK! THIS IS BEEN GOING ON SINCE JUNE 2018 & PRESENTLY CAR IS IN THE SHOP FOR REPAIR AGAIN!!

CARBON MONOXIDE INSIDE THE CAR IS WAY TOO HIGH WITH THE EGR COOLER LEAKING ISSUE NOT BEING FIXED YET. IT'S BEEN 3 MONTHS NOW AND THE AIR QUALITY INSIDE THE CAR IS SOO BAD THAT I AM GETTING HEADACHE FROM THE SOOT AND CO GAS COMING OUT OF AC VENT. I DID A SERVICE TODAY AND EVEN AFTER REPLACING THE MICROFILTER AND ANOTHER FILTER, THE PROBLEM STILL PERSISTS. THE DEGRADED AIR QUALITY CONTAINS HAZARDOUS GAS AND CAN CAUSE DIZZINESS WHICH COULD LEAD TO FATAL ACCIDENTS AT HIGHER SPEED. I KINDLY REQUEST THAT BMW REPURCHASE THIS VEHICLE FROM ME AS SOON AS POSSIBLE, BEFORE I COULD GET INTO ANY SORT OF ACCIDENT. THE EGR COOLER ISSUE COULD ALSO LEAD TO CAR FIRE (WHICH IS DEFINITELY SOMETHING I DON'T WANT TO HAPPEN.) THANK YOU. REGARDS, [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THE SUNROOF EXPLODED. ON JUNE 29TH, 2018 AT APPROXIMATELY 4:00 PM I WAS STOP AT AN INTERSECTION WAITIN FOR AN ON COMING CAR TO PASS SO I COULD MAKE A LEFT TURN. AS SOON AS I STARTED TO GO I HEARD WHAT SOUNDED LIKE AN EXPLOSION/LOINS GUN SHOT COMING FROM THE INSIDE OF THE CAR. I WAS EXTREMELY STARTLED, I AM LITERALLY SHAKING NOW JUST THINKING ABOUT HOW SCARY THIS WAS. IT ONLY TOOK A FEW SECONDS TO REALIZE THE SUNROOF WAS SHATTERING ABOVE ME. I WAS ONLY A FEW MILES FROM HOME. I CALLED THE DEALERSHIP TO ADVISE THEM WHAT HAD HAPPED AND SCHEDULE A REPAIR. I TOLD THEM THIS IS DEFECTIVE SUNROOF AND IT SHOULD BE COVERED UNDER THE WARRANTY. HE COULDN'T CONFIRM THIS FOR ME I ASKED FOR SOMEONE TO CALL ME BACK TO CONFIRM, NO ONE CALLED BACK BUT I WAS LATER IN THE DAY ON...