2009 VOLKSWAGEN PASSAT Engine Problems

The check engine light and oil pressure light appeared on my dash screen as I was driving home from work. I pulled over to the nearest repair shop to have the vehicle diagnosed. Upon arriving, the mechanic noticed my oil was low and filled the car with oil. Once that was completed, the car would not start. I noticed it made unusual noises after several more failed attempts. I had the vehicle towed to an authorized dealership to further troubleshoot and they were able to confirm that the engine jumped time due to a failed timing chain tensioner, which requires a new engine since mine is an interference engine. Due to the timing chain tensioner failing, there was catastrophic damage done to the engine leaving the vehicle inoperable.

I put fuel in the car and about to start the car and it won’t start. Lights flickering.

I GOT 09 4 MOTION CC 3.6. I HAD READ SPENT CLOSE TO 6G AND NOBODY CAN FIX THE ACCELERATION WHEN START. VERY FRUSTRATED CHANGE CATALYTIC CONVERTERS CHANGE OTHER THINGS I BAD. *TR

LOUD SOUND WHEN VEHICLE IS IN IDLE. TOOK IT TO LOCAL MECHANIC AND THEY ARE SAYING IT NEEDS A TIMING CHAIN REPLACEMENT BECAUSE IT SKIPS.

RECALL UPDATE: CURRENTLY, INTAKE MANIFOLD NEEDS TO BE REPAIRED-ENGINE LIGHT ON-COST $1400.00. TOOK CAR TO DEALERSHIP FOR FUEL PUMP WAS TOLD IT WAS REPLACED BUT WOULD NOT GIVE EVIDENCE THAT IT WAS. SIDE FRONTAL AIR BAG NEVER REPLACED-WAS TOLD BY DEALERSHIP DID NOT NEED IT.

THE VEHICLE HAS ISSUES WITH THE FUEL PUMP , INTAKE & CYLINDERS . I WAS ABLE TO CHANGE THE FUEL PUMP BUT NOTICED ONLINE THE VEHICLE HAS BEEN RECALLED FOR THESE SAME ISSUES . WHEN TURNING THE CAR ON AND DRIVING IT TURNS OFF AND HARDENING THE STEERING WHEEL

TL* THE CONSUMER OWNS A 2009 VOLKSWAGEN PASSAT. THE CONSUMER STATED THAT THE ENGINE INTAKE MANIFOLD FAILED AND CAUSED THE VEHICLE NOT TO ACCELERATE IN A TIMELY MANNER. THE CONSUMER STATED THAT THE VEHICLE FAILED THE STATE INSPECTION DUE TO THE INTAKE MANIFOLD FAILURE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE INTAKE MANIFOLD SYSTEM REPAIR. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 115,000. *BF *AS

MY VW PASSAT 2009 SUSTAINED ENGINE FAILURE DUE TO FAILURE TIMING CHAIN/TIMING CHAIN TENSIONER AND NOW NEEDS VERY EXPENSIVE ENGINE REPAIR OR REPLACEMENT OF ENGINE. CAR DROVE OKAY FOR 15 MINUTES IN THE MORNING THEN IT WAS THEN PARKED FOR ABOUT 2 HOURS. WHEN TRYING TO RE-START THE CAR, THE CAR WOULD NOT START. MECHANIC NOTED ABSENT COMPRESSION IN 2 CYLINDERS AND DIAGNOSED IT TO BE DUE TO TIMING CHAIN SLIPPING. THIS HAPPENED AT 80,000MILES AND LESS THAN 10 YEARS (9 YEARS 9 MONTHS) OF PURCHASE OF THE VEHICLE. VW'S EXTENDED WARRANTY COVERS REPAIR/REPLACEMENT OF TIMING CHAIN BUT DOES NOT COVER REPAIR OF ENGINE DAMAGE RESULTED DUE TO TIMING CHAIN FAILURE. THE CAR WAS SERVICED AT VW DEALER REGULARLY AND THERE WAS NO WARNING OR INDICATION OF IMPENDING FAILURE OF THE TIMING CHAIN. OTHER OWNERS OF VW VEHICLES HAVE ALSO COMPLAINED OF HAVING IDENTICAL PROBLEMS ON ONLINE COMMUNITY WITH SOME...

TO WHOM IT MAY CONCERN: I WANTED TO FOLLOW-UP AND DISCUSS A RECENT INCIDENT. ON APRIL 19TH 2019 OUR 2009 VW PASSAT WAS IN OUR GARAGE AS THIS IS THE USUAL LOCATION WE PARK OUR CARS. ON THE 18TH WE COMPLETED YARD WORK AND NOTHING OUT OF THE NORM WAS NOTED AS WE COMPLETED THE YARD WORK AT AROUND 8PM AND NOTHING WAS NOTED TO BE ABNORMAL. AROUND 4 AM ON THE 19TH MY SPOUSE AND I WERE AWOKEN TO A LOUD POP SOUND. THIS SOUND WAS UNUSUAL TO US. SHORTLY AFTER THE POP SOUND THERE PANIC ALARM COULD BE HEARD THAT WANED OUT IN ABOUT 30 SECONDS. MY HUSBAND WENT TO THE GARAGE AND WAS MET WITH BLACK AND PRESSURE LIKE FORCE AGAINST THE GARAGE DOOR. WE IMMEDIATELY EVACUATED THE HOME AND CALLED THE FIRE DEPARTMENT. AT THE TIME WERE NOT SURE WHAT CAUSED THE SMOKE BUT ONCE THE...

TIMING BELT TENSIONER FAILURE. ENGINE REQUIRES MAJOR REPAIRS

STOPPED RUNNING AT TRAFFIC LIGHT- TOWED TO DEALERSHIP -TIMING CHAIN/TENSIONER ISSUE

3 DIFFERENT OCCASIONS MY CAR WOULD LOOSE POWER AND SHUT DOWN ON THE HIGHWAY. I HAD IT TOWED AND ALL THREE TIMES THEY STATED IT WAS DIFFERENT THINGS AND THAT THEY HAD TO TAKE STEPS IN REPLACING GOOD PARTS TO FIND THE BAD ONES. JUST TO FIND OUT THAT IT WAS THE FUEL PUMP CONTROL MODULE THAT THEY THOUGHT IT WAS THE WHOLE TIME. NOW THERE IS A RECALL ON IT. WHICH I HAVE SUMMITTED THE PAPER WORK AND THEY CONVENIENTLY CANNOT FIND. THIS PAST WEEKEND MY CAR WOULDN'T TURN OVER AT ALL WHEN I TRIED TO START IT IN A PARKING LOT SO I HAD IT TOWED FOR THE 4TH TIME IN 2.5YEARS. THEY ARE CLAIMING THAT THE ENGINE MOTOR IS BAD AND IT WOULD COST $7500.00 TO REPLACE. THE TECHNICIAN CANNOT FIND ANY OIL LEAKS ND CLAIM THERE WAS ONLY ABOUT A HALF OF COURT OF OIL IN...

REAR MAIN SEAL AND BREATHER UNIT BLEW OUT @ 74K MILES. MY VEHICLE WAS LEAKING OIL AND VACUUM PRESSURE. COST ME $1800 TO REPAIR. IT CAUSED MY VEHICLE TO STALL OUT SEVERAL TIMES WHILE DRIVING/RESTING AT STOP LIGHTS.

BAD TENSIONER BELT LED TO BLOWN ENGINE.

BEGAN TO DRIVE VEHICLE YESTERDAY TO FUEL UP. "OIL CONSUMPTION: STOP ENGINE" WARNING MESSAGE CAME ON. WENT OFF AFTER A FEW SECONDS AND THEN CAME BACK ON AND WOULDN'T GO OFF. DROVE 6 BLOCKS BACK HOME. DID NOT FEEL IT WAS SAFE TO DRIVE CAR ANY FURTHER. VW DEALER DOES NOT KNOW WHY THAT WARNING MESSAGE CAME ON. THEY DON'T KNOW WHAT TO DO OR WHAT TO FIX. THEY SAID FUEL PUMP RECALL MAY FIX THE PROBLEM. THAT RECALL IS NOW 10 MONTHS OLD WITH NO SIGN OF PARTS BEING READY.

DRIVING CAR WHEN SUDDENLY A WARNING MESSAGE IS DISPLAYED "STOP ENGINE IMMEDIATELY." THE CAR WAS IN FORWARD MOTION AS I WAS DRIVING ON A 4 LANE HIGHWAY. THIS HAS HAPPENED SEVERAL TIMES. NOT TURNING, NOT BRAKING, NOT BACKING UP. WE DISCUSSED IT WITH A VW DEALER. THEY SAID THE CAR HAS A RECALL ON THE FUEL PUMP 10 MONTHS AGO BUT AS OF YET, NO PARTS AND NO ETA. ONLINE REPORTS SUGGEST THE ENGINE MAY OVERHEAT AND SEIZE OR CAUSE ENGINE FIRE.

MY SON DROVE THE VEHICLE TO SCHOOL THIS MORNING. AS HE NEARED THE SCHOOL DRIVEWAY GOING ABOUT 25 MILES PER HOUR, THE ENGINE WARNING LIGHT CAME ON "STOP ENGINE IMMEDIATELY." HE DROVE THE VEHICLE 1 CITY BLOCK TO PARK IN THE SCHOOL PARKING LOT. THE ENGINE DID NOT JOLT WHEN THE WARNING CAME ON BUT IT CAME ON NONE-THE-LESS.

REAR MAIN OIL SEAL NEEDED TO BE REPLACED. IT WAS COMPROMISED BY EXCESSIVE PRESSURE IN CRANKCASE BECAUSE PCV BREATHER WAS NOT FUNCTIONING. THERE WAS NO CHECK ENGINE CONDITION PRIOR TO THE REAR SEAL BEING COMPROMISED. REAR MAIN SEAL REPLACEMENT COSTS $1146, PARTS AND LABOR. PCV VALVE WAS ALSO REPLACED. I NOTICED AN OIL LEAK ON GARAGE FLOOR, WHICH LED ME TO BRING IT INTO SERVICE FOR A TECHNICIAN TO INSPECT. I WOULD LIKE VW TO COMPENSATE FOR SOME OF THE COSTS FOR THIS REPAIR.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED AND FAILED TO RESTART. IN ADDITION, THE ENGINE WARNING INDICATOR FAILED TO ILLUMINATE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT MANAGED TO RESTART THE VEHICLE AND DROVE TO DARCARS VOLKSWAGEN (12511 PROSPERITY DR., SILVER SPRING, MD 20904, (301) 622-7000) WHERE IT STALLED AGAIN. THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM: GASOLINE); HOWEVER, THE CONTACT HAD NOT RECEIVED A RECALL NOTICE. THE SAME DEALER DIAGNOSED THAT THE FUEL PUMP NEEDED TO BE REPLACED, BUT THE RECALL WAS ON HOLD. THE VEHICLE WAS REPAIRED BY AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE FAILURE MILEAGE WAS 111,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

THIS VEHICLE HAD CATASTROPHIC ENGINE FAILURE DUE TO A FAULTY CAM CHAIN TENSIONER. THIS IS BEEN KNOWN BY VOLKSWAGEN AS A SERVICE BULLETIN WAS ISSUED IN 2011. I WAS DRIVING ON A CITY ST. AND HAD TO PUSH THE VEHICLE TO THE SIDE. THE FUEL PUMP AND SENDING UNITS HAVE ALSO FAILED IN THIS VEHICLE ALONG WITH THE TURBOCHARGER DIVERTER VALVE WHICH WAS A DEFECTIVE ITEM. ALL THESE ITEMS HAVE BEEN KNOWN BY VOLKSWAGEN FOR SOME TIME. THE COST OF REPAIR ON THE VEHICLE HAS BEEN OVER $5,000. I BELIEVE ALL THESE ISSUES SHOULD HAVE BEEN A RECALL ITEM. FAILURES ON SOME OF THEM HAVE BEEN HAPPENING AT 20,000 MILES. THEY COULD POSE A SAFETY HAZARD DEPENDING ON WHERE YOU WERE DRIVING. VOLKSWAGEN HAS DENIED ANY REIMBURSEMENT ON MOST OF THESE ITEMS. HAD CONSUMERS KNOWN OF THESE ISSUES THE COST WOULD HAVE BEEN SIGNIFICANTLY LESS IF THE DEFECTIVE PARTS HAVE...

THERE IS AN INTERRUPTION IN ELECTRICAL POWER TO THE FUEL PUMP CONTROL MODULE. THIS RESULTING IN THE FUEL PUMP RUNNING CONTINUOUSLY, RESULTING IN A DRAINED BATTERY AND CAUSE A LOSS OF MOTIVE POWER WHILE THE VEHICLE IS IN MOTION, THIS HAPPENED TODAY ON HIGHWAY AND ALMOST I WAS GOING TO HAVE A FATAL ACCIDENT. US. VW AND THE DELAR ARE NOT TAKING ANY ACTION AT THAT REGARD, THEY STATED TODAY THAT I PAY TO THE REPAIR AND THEY WILL EMBERSE ME LATER. PLEAS NOTE THAT THERE IS A RECALL ON THE FUEL PUMP CONTROL MODULE TO SOLVE THAT ISSUE. SAFETY RISK

DEFECTIVE TIMING CHAIN TENSIONER IN 2.0 TSI ENGINE DAMAGE THE CAR AND ENGINE NOT GETTING STARTED. MECHANIC ASKED FOR $3500 APPROXIMATE ESTIMATE FOR REPAIR WHICH IS KNOWN DEFECT OF VW 2.0 TSI ENGINE. VEHICLE WAS IN MOTION WHEN I WAS PARKING THE CAR IN MALL PARKING AREA.

MY 2009 VOLKSWAGEN STOPED STARTING, SO I HAD IT TOWED INTO A DEALERSHIP WHERE THEY RAN A FEW TESTS AND DETERMINED THAT MY TIMING CHAIN TENSIONER FAILED WHICH RESULTED IN THE FAILURE OF MY ENGINE. AS A RESULT, I NEEDED TO PAY AROUND $7000-$8000 IN ORDER TO REPLACE. GIVEN I COULD NOT AFFORD, IVE BEEN MAKING MY MONTHLY PAYMENT AS I AM FINANCIALLY OBLIGATED TO DO SO. THE CAR ONLY HAD 70,000 MILES, THEREFORE I AM SURPRISED THAT THE ENGINE ALREADY WENT AND FEEL THIS IS SOMETHING VW SHOULD REPLACE.

MY VEHICLE WAS IN MOTION ON A CITY STREET AND SUDDENLY IT STARTED SHAKING WHILE DRIVING AND WHEN I BRAKED, IT SHAKED EVEN MORE VIGOROUSLY. I TOOK IT TO A LOCAL MECHANIC WHO SAID THERE IS AN ISSUE WITH THE ENGINE AND THE DEALERSHIP WILL HAVE TO LOOK AT IT. THEY RECOMMENDED THAT I TOW THE CAR TO THE DEALERSHIP AND ADVISED AGAINST DRIVING IT. I TOWED THE CAR TO THE DEALERSHIP. AFTER TWO DAYS THE DEALERSHIP CALLS ME STATING THAT THE TIMING CHAIN HAS JUMPED AND THERE IS NO COMPRESSION. THEY WOULD HAVE TO REPAIR OR REPLACE THE ENGINE. THE DEARLSHIP TECHNICIAN SAID THAT THEY HAVE HAD SEVERAL VW VEHICLES BROUGHT IN WITH SIMILAR ISSUES BUT VW HAS REFUSED TO ISSUE A RECALL OR TAKE ANY ACTION TO CORRECT THIS ISSUE. THIS IS A DANGEROUS SAFETLY HAZARD. IF I WAS DRIVING ON A HIGHWAY AND THIS HAPPENED, I COULD...

FOUND OUT THERE WAS A TIMING CHAIN ISSUE WITH THE VEHICLE WHERE IT JUMPED 22 DEGREES. AFTER RESEARCH HAVE FOUND ON A NUMBER OF FORUMS THAT THIS IS A WIDESPREAD ISSUE WITH THIS ENGINE IN BOTH VW AND AUDI VEHICLES. VW WILL NOT ISSUE A RECALL, THE CLAIM IS, DUE TO IT BEING TOO WIDESPREAD AND EXTREMELY EXPENSIVE. UNDER MOST CIRCUMSTANCES FROM WHAT I HAVE READ, IT CAUSES CATASTROPHIC ENGINE FAILURE. LUCKILY, MINE DID NOT JUMP THAT FAR, BUT IT STILL WAS AN EXPENSIVE REPAIR THAT SHOULDN'T HAVE HAD TO HAPPEN. WELL NOW I HAVE HAD $4200 IN REPAIRS MADE TO MY ENGINE DUE TO THIS ISSUE AND I THINK VW SHOULD HAVE PAID FOR IT.

SUDDEN LOSS OF ENGINE OIL CAUSING ENGINE FAILURE

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD SUDDENLY STALL. MOMENTS LATER, THE VEHICLE COULD BE RESTARTED. THE VEHICLE WAS TAKEN TO THE DEALER (SUNTRUP VOLKSWAGEN IN ST. LOUIS, MO), BUT THE CAUSE OF THE FAILURE COULD NOT BE DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT NO ASSISTANCE WAS OFFERED. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS 80,000.

CAR WAS PARKED AND WOULD NOT START. HAD TOWED TO MECHANIC--CASTASTROPIC ENGINE FAILURE DUE TO BROKEN TIMING BELT TENSIONER. 105K MILES--MAINTENANCE UPKEPT. OBVIOUSLY THERE IS A LATENT DEFECT IN THE TENSIONER SYSTEM OF THE TIMING CHAIN THAT CAN CAUSE THE CHAIN TO “JUMP A TOOTH” IN THE VEHICLE’S CAMSHAFT, WHICH CAUSES SERIOUS AND SOMETIMES FATAL DAMAGE TO THE ENGINE. UNFORTUNATELY THE DEFECT IS IMPOSSIBLE FOR CAR OWNERS TO DISCOVER, BUT AUDI AND VOLKSWAGEN KNEW OF THE TENSIONER SYSTEM PROBLEM SINCE AT LEAST JUNE 2010. NORMALLY, THE TIMING CHAIN IS MEANT TO FUNCTION PERFECTLY FOR AT LEAST 120,000 MILES. BECAUSE THE SYSTEM IS NOT ON THE SCHEDULE FOR RECOMMENDED MAINTENANCE FROM THE MANUFACTURERS. HOWEVER, WITH THE DEFECTIVE TENSIONER, THE TIMING CHAIN FREQUENTLY FAILS WELL BEFORE THAT MARK, BUT OFTEN AFTER THE WARRANTY HAS EXPIRED. THIS ISSUE CAUSED MY ENGINE TO HAVE CATASTROPHIC ENGINE FAILURE. WHY HAS THE VW OWNERS NOT BEEN...

CAM CHAIN TENSIONER FAILURE. DRIVING DOWN ROAD ENGINE STARTED TO RUN ROUGH THEN STOPPED GOT CAR BACK TO HOUSE (75 YARDS) HAD CAR TOWED TO VW DEALER PAID $140.00 FOR DIAG.L MAJOR ENGINE DAMAGE FROM CAM CHAIN TENSIONER FAILURE VALVES AND PISTON DAMAGED COULD HAVE BEEN MAJOR SAFETY PROBLEM IF ON MAJOR ROAD ( DANGEROUS UNSAFE )

THE CAR HAD BEEN DRIVEN A SHORT DISTANCE AND PARKED. SHORTLY AFTER THAT IT CAUGHT ON FIRE AND WAS DESTROYED.

I BOUGHT THIS CAR UNAWARE OF A CARBONIZATION ISSUE ON THE VALVES\. THE CARBON BUILD UP CAUSES A MISSFIRE READ AND A LEAN FAULT IN LEFT BANK. THE MISSFIRE ISSUE MAKES THE VEHICLE VIRTUALLY UNDRIVABLE WHICH PUT ME AND MY FAMILY IN DANGER AT THE TIME THIS OCCURD. ACCORDINGLY AFTER PLENTY OF RESEARCH THIS APPARENTLY IS A VERY COMMON ISSUE AND IS A MANUFACTURE ISSUE SINCE THE ISSUE COULD BE SOLVED BY PLACING THE FUEL INJECTORS BEHIND THE VALVES TO CLEAN THEM INSTEAD THEY ARE COSTING CONSUMERS OBSCENE AMOUNTS OF MONEY AND PUTTING THEIR LIVES AT RISK FOR NO OTHER REASON THEN TO NOT FIX THIS ISSUE.

VEHICLE STARTED ROUGH AND WAS VIBRATING. SHUT OFF AND VEHICLE WOULD NOT RESTART. TOWED TO DEALER WHO INFORMED THAT AN INTERNAL FAILURE OCCURRED CAUSING THE TIMING CHAIN TO SLIP AND THAT THE ENGINE WOULD NEED TO BE REPLACED. DEALER INFORMED ME THAT, "THESE THINGS JUST HAPPEN SOMETIMES". HOWEVER, AN INTERNET SEARCH REVEALED THAT THIS IS AN ONGOING AND REPEATED ISSUED FOR MANY VW AND AUDIT OWNERS AND THAT THERE ARE THREE CLASS ACTION LAWSUITS FILED FOR TIMING CHAIN TENSIONER PROBLEMS. VW OF AMERICA WAS NOT HELPFUL. WHY SHOULD THE CONSUMER BE OUT THOUSANDS OF DOLLARS FOR ENGINE REPLACEMENT FOR WHAT SHOULD BE A KNOWN DEFECT. THE VEHICLE ONLY HAS 105,000 MILES.

THERE IS A LATENT DEFECT IN THE TENSIONER SYSTEM OF THE TIMING CHAIN THAT CAN CAUSE THE CHAIN TO 'JUMP A TOOTH' IN THE VEHICLE'S CAMSHAFT, WHICH CAUSES SERIOUS AND SOMETIMES FATAL DAMAGE TO THE ENGINE. UNFORTUNATELY THE DEFECT IS IMPOSSIBLE FOR CAR OWNERS TO DISCOVER, BUT AUDI AND VOLKSWAGEN KNEW OF THE TENSIONER SYSTEM PROBLEM SINCE AT LEAST JUNE 2010. NORMALLY, THE TIMING CHAIN IS MEANT TO FUNCTION PERFECTLY FOR AT LEAST 120,000 MILES. BECAUSE THE SYSTEM IS NOT ON THE SCHEDULE FOR RECOMMENDED MAINTENANCE FROM THE MANUFACTURERS. HOWEVER, WITH THE DEFECTIVE TENSIONER, THE TIMING CHAIN FREQUENTLY FAILS WELL BEFORE THAT MARK, BUT OFTEN AFTER THE WARRANTY HAS EXPIRED. THIS ISSUE CAUSED MY ENGINE TO HAVE CATASTROPHIC ENGINE FAILURE.

2009 VOLKSWAGEN PASSAT TIMING BELT/CHAIN TENSIONER PROBLEM IN JULY 2016 MY MOTHER-IN-LAW WAS LEAVING WORK, WHEN SHE TRIED STARTING THE CAR IT DIDN'T STARTED. SOMEONE IN THE PARKING VOLUNTEERED TO HELP HER. THEY DECIDED TO JUMP START THE CAR WITH A JUMP BOX, THE CAR STARTED AND SHE MADE IT HOME. ONCE SHE GOT HOME SHE TRIED TO START THE CAR AND IT DID NOT START. SHE IS A SINGLE MOTHER AND DO NOT MAKE A LOT OF MONEY TO FIX HER CAR, AFTER A MONTH AND HALF OF THE CAR BEEN PARK AT HOME AND TAKING RIDES FROM WHOEVER CAN TAKE HER, WE DECIDED TO GET A MECHANIC THAT WORKS FOR VW DEALERSHIP. HE CAME AND FULLY CHECKED THE CAR AND TOLD US THAT THE TIMING CHAIN/BELT JUMPED AND THAT ENGINE IT'S OUT OF TIME, WHICH IT COULD HAVE BEEN CAUSED FROM A BAD TENSIONER. HE SAID THIS IS...

MY WIFE WAS DRIVING THE CAR TO THE AIRPORT AND STOPPED AT THE CELL PHONE WAITING AREA. TRIED TO START AGAIN AND CAR DIDN'T START. CHANGED THE BATTERY WITH AAA AND STILL DIDN'T START. TOWED IT TO DEALER. THEY SAID THE TIMING CHAIN TENSIONER FAILED AND IT COMPLETELY DAMAGED THE ENGINE. ENGINE NEEDS TO BE REPLACED WHICH COSTS ABOUT $7K. I HAVE CHECKED ABOUT THIS PROBLEM IN INTERNET AND MANY PEOPLE ARE COMPLAINING ABOUT THE SAME ISSUE AND VW KNOWS ABOUT THIS ISSUE FOR SOME TIME. AS THIS CAN HAPPEN IN MIDDLE OF THE TRAFFIC AND CAN CAUSE A FATAL ACCIDENT, WE REQUEST YOU TO INVESTIGATE AND MAKE VOLKSWAGEN RECALL AND REPLACE THIS PART. ALSO, VW SHOULD TAKE RESPONSIBILITY FOR THE FAILED PART AND THE REPAIRS CAUSED DUE TO THIS PART AS IT KNOWS ABOUT THIS AND IGNORED. I ALSO SEE THERE IS A LAWSUIT GOING ON THIS ISSUE. CHECK...

I BOUGHT THIS CAR USED AND FROM THE MOMENT I TOOK IT OF THE LOT 13 MONTHS AGO I HAVE BEEN HAVING PROBLEMS. THE CARE WILL STOP, SHAKE. I HAVE ALREADY HAD IT CHECK 3 TIMES AND REPAIRED TWICE. FUEL PUMP HAS BEEN CHANGED TWICE AND I AM HAVING THE SAME PROBLEM AGAIN. THIS IS A HUGE SAFETY HAZARD IF I AM ON THE EXPRESSWAY AND NO WARNING TAKE PLACE WHICH COULD LEAD TO A MAJOR ACCIDENT. ACCORDING TO WHAT I HAVE READ THIS MAKE AND MODEL HAVE HAD MANY ISSUES AND VOLKSWAGON HAS NOT RESOLVED THE SITUATION. HELP!

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE THE VEHICLE WAS PARKED AND WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE ACCELERATED INDEPENDENTLY WITHOUT THE ACCELERATOR PEDAL BEING DEPRESSED. IN ADDITION, THE CONTACT NOTICED ENGINE OIL LEAKING FROM UNDERNEATH THE VEHICLE. THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE REAR MAIN ENGINE SEAL NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,000.

MY CAR HAS 76000 MILES AND IS OTHERWISE IN EXCELLENT CONDITION. I JUST GOT A CHECK ENGINE LIGHT, AND AFTER REPLACING THE PCV VALVE, AND I WAS TOLD BY MY MECHANIC THAT THE REAR MAIN ENGINE SEAL IS LEAKING. THE CAR IS OUT OF WARRANTY AT THIS POINT AND NOW I HAVE TO SPEND ALMOST $1000 IN REPAIRS. THIS IS SOMETHING THAT SHOULD BE COVERED BY VW WARRANTY, AS THERE ARE SO MANY CASES OF THIS EXACT FAILURE AT THE SAME AMOUNT OF MILES.

TL* THE CONTACT OWNS A 2009 VOLKSWAGEN PASSAT. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED. THE VEHICLE WAS ABLE TO BE RESTARTED, BUT THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VIN WAS UNAVAILABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

PURCHASED THIS VEHICLE USED. I HAVE HAD IT FOR TWO YEARS NOW. PROBLEMS ENCOUNTERED: BURNING SMELL, DRIVER SIDE FLOOD LIGHT BLEW OUT OR CAME OFF; SHAKING MOMENTARILY WHILE DRIVING, DRIVER SIDE MIRROR FLEW OFF WHILE MAKING A LEFT TURN; NOTICED WHEN I HAD AN OIL CHANGE LAST OF JANUARY OR FIRST PART OF FEBRUARY THE VEHICLE WAS USING QUITE A BIT OF OIL. I PUT ABOUT FIVE OR MORE QUARTS IN BY MAY. THE LATTER PART OF MAY IT USED TWO QUARTS IN TWO WEEKS. WENT SHOPPING SATURDAY BEFORE MOTHER'S DAY, PARKED THE CAR AT FOOD LION WHEN I CAME BACK OUT, I TRIED TO START THE CAR AND IT STALLED. WHEN IT DID START, THE VEHICLE WAS SHAKING. I TOOK THE CAR HOME, CHECKED THE OIL ALONG WITH MY BROTHER AND IT NEEDED MORE OIL. I PUT TWO MORE QUARTS IN. ON MONDAY I WAS AT THE DEALERSHIP AT...

MAIN REAR BEARING SEAL FAILURE, SUDDEN LOSS OF POWER, BURNING SMELL FROM UNDER CAR, $1,700 REPAIR. *TR

2009 VW PASSAT 2.0T. OIL LEAKING FROM REAR MAIN SEAL. REAR MAIN SEAL FAILED AT ABOUT 75,000 MILES, NOT COVERED UNDER WARRANTY. FIRST INDICATION WAS OIL SPOT ON DRIVEWAY AND THEN CHECK ENGINE LIGHT CAME ON. INSPECTED BOTTOM OF ENGINE AND IT WAS COATED WITH OIL. THE PCV VALVE FAILED AND CAUSED REAR MAIN SEAL TO RUPTURE AND SHOOT OIL (AND POSSIBLY GAS VAPORS) ALL OVER BOTTOM OF HOT ENGINE. ALTHOUGH NOTHING IGNITED IN THIS CASE, BEGAN TO QUESTION IF SOME OF THE OTHER FIRE INCIDENTS LISTED ON NHTSA SITE WERE POSSIBLY CAUSED BY SIMILAR CONDITION. FAILURE OF APPROX. $40 PART CAUSED APPROX. $1700 IN DAMAGE- ALL OUT OF WARRANTY. WARRANTY IS FOR 5 YEARS/60,000 MILES. NO MAINTENANCE DATA AVAILABLE TO OWNER INDICATED THAT PCV VALVE SHOULD BE CHECKED AS PART OF SCHEDULED MAINTENANCE. VW LEADERSHIP DECLINED TO ACCEPT ANY RESPONIBILITY FOR SITUATION. *JS

2009 VW PASSAT 2.0T. OIL LEAKING FROM REAR MAIN SEAL. REAR MAIN SEAL FAILED AT ABOUT 70,000 MILES, NOT COVERED UNDER WARRANTY. FIRST INDICATION WAS SMELL OF BURNING. SHORTLY BEFORE THIS FAILED, THE PCV VALVE FAILED - ALSO OUT OF WARRANTY. WARRANTY IS FOR 5 YEARS/60,000 MILES. *TR

INITIAL FAILURE OCCURRED WHILE ACCELERATING ONTO MAIN THOROUGHFARE. VEHICLE LOST ALL ENGINE POWER AND STALLED OUT. VEHICLE WAS SEND TO VW DEALER FOR REPAIR WHERE SOME WARRANTY REPAIRS WERE MADE AS WELL AS PREVENTATIVE MAINTENANCE THAT WAS ADVISED. THE CAR WAS RETURNED AS "REPAIRED" AND AFTER DRIVING HOME EXPERIENCED THE EXACT SAME FAILURE WHILE THE CAR WAS IDLING IN THE DRIVEWAY. CAR WAS RETURNED AGAIN AND EXPERIENCED THE SAME FAILURE A SECOND TIME WHILE I WAS TRAVELING ON I275 IN DETROIT. THE CAR STALLED OUT AND I AGAIN LOST ALL POWER. I WAS FORCED TO THE SIDE OF THE ROAD WHERE THE CAR THEN FAILED TO START. I WAS FORCED TO SIT FOR THREE HOURS IN 20 DEGREE WEATHER WITH A TWICE IN 2 WEEKS REPAIRED ISSUE AS MY CAR WAS BURIED IN SNOW ON THE INTERSTATE. THIS IS A MAJOR SAFETY HAZARD! *TR

AFTER BEING DRIVEN FOR A SHORT TIME OUR 2009 VW PASSAT WAS PARKED IN OUR GARAGE. NO SIGNS OF ANY PROBLEMS WHEN DRIVER WENT INSIDE THE HOUSE. ABOUT 15-20 MINUTES AFTER BEING PARKED NOISE WAS HEARD FROM GARAGE AND AT THAT TIME INTENSE SMOKE AND FIRE FROM FRONT OF VEHICLE WAS DISCOVERED. BEFORE HELP COULD ARRIVE FRONT OF CAR WAS COMPLETELY ON FIRE AND NEARBY MATERIALS IN GARAGE WERE IGNITED. CAR WAS CONSIDERED TOTAL LOSS ALONG WITH EXTENSIVE DAMAGE TO INSIDE OF GARAGE. FIRE DEPARTMENT ATTRIBUTED THE CAUSE OF FIRE AS "CAR ENGINE/ELECTRICAL". FORTUNATELY, ,THERE WERE NO PERSONAL INJURIES BUT SIGNIFICANT PROPERTY DAMAGE.. *TR

I WAS STOPPED AT A RED LIGHT AND SMOKE WITH THE DISTINCT FIRE SMELL STARTED POURING OUT OF MY HOOD. I HAD TO RUN THE RED LIGHT TO GET OFF OF THE STREET WHERE I ENDED UP IN A BIG PARKING LOT. I RAISED THE HOOD AND SAW HEAVY SMOKE AND SMALL FLAMES. I GRABBED MY PHONE AND TOOK A PICTURE AND THEN RAN AND GOT WATER TO PUT THE FIRE OUT. THIS WILL COST ME A 500 DOLLAR DEDUCTIBLE AND THE POTENTIAL FOR MY INSURANCE COMPANY TO RAISE MY RATES. I AM SO PISSED TO FIND OUT THIS IS A RECURRING ISSUE! I AM GLAD I WAS DRIVING INSTEAD OF MY WIFE WITH OUR KIDS IN THE CAR! VW THE FIGHT IS NOW ON! I WAS WONDERING WHY MY SERVICE ADVISER NEW EXACTLY WHAT CAUSED THE FIRE. A 27 DOLLAR PART FAILED AND CAUSED A COUPLE OF GRAND IN...

THE CAR SUDDENLY HAS 50% OR LESS POWER AND BEGINS STUMBLING VERY BADLY. ACCELERATION IS SO POOR THAT IT'S QUITE DANGEROUS IN HEAVY TRAFFIC AND THE ABILITY TO PULL OFF THE ROAD IS SEVERELY HAMPERED. THE ONLY WAY I'M ABLE TO KEEP THE CAR MOVING AND RUNNING IS TO USE THE MANUAL FEATURE OF THE AUTOMATIC TRANSMISSION AND KEEP THE RPM'S VERY HIGH. THE FOUR COIL PACKS IN THE CAR WERE REPLACED THIS SPRING. SUDDENLY, THE SAME EXACT PROBLEM IS BACK AGAIN 4 MONTHS LATER. CODES WERE RANDOM MISIFRE AND MULTIPLE MISFIRES AT VARIOUS CYLINDERS. STRANGE THAT ALL FOUR PACKS GO OUT AT THE SAME TIME....? THAT'S NOT LOGICAL UNLESS IS SOMETHING OTHER THAN NORMAL WEAR CAUSING THE ISSUE. THIS PROBLEM HAS OCCURRED TWICE AND BOTH TIME IT BEGINS IN THE MIDDLE OF HEAVY TRAFFIC WHERE THE SITUATION IS VERY DANGEROUS AS THE POWER LOSS IS NEARLY COMPLETE. BOTH TIMES...

I STOPPED AT A STOP SIGN, THE CAR ACCELERATED NORMALLY AND AFTER A FEW MINUTES THE ENGINE SPUTTERED, THE CHECK ENGINE LIGHT ILLUMINATED, AND THE BATTERY LIGHT ILLUMINATED. THE ENGINE QUIT. ATTEMPTS TO RESTART THE ENGINE FAILED. I WAS LOCATED AT AN INTERSECTION AND PUSHED THE CAR OFF TO THE SIDE OF THE ROAD. I ATTEMPTED TO RESTART THE ENGINE AND NOTICED AN AROMA OF BURNING PLASTIC. I OPENED THE HOOD AND THERE WAS SMOKE EMANATING UNDER THE TOP ENGINE COVER, TOP LH SIDE VIEWED FROM THE FRONT TO THE REAR. UPON FURTHER INVESTIGATION I NOTICED THAT THERE WAS A FIRE UNDER THE COVER. I REMOVED THE COVER AND EXTINGUISHED THE FIRE. THE #1 IGNITION COIL HARNESS WAS MELTED FROM THE FIRE AND ASSOCIATED FIRE DAMAGE WAS NOTED ON THE INSIDE OF THE ENGINE COVER ABOVE THE ENGINE COIL LOCATION. I HAD THE VEHICLE TOWED TO THE LOCAL DEALERSHIP AND...

MY VEHICLE'S CHECK ENGINE LIGHT CAME ON AND STAYED ON FOR SEVERAL DAYS, AND THE ENGINE STARTED RUNNING ABNORMALLY, SO I TOOK IT TO A MECHANIC. THE MECHANIC DISCOVERED THAT THE INTAKE MANIFOLD NEEDED TO BE REPLACED, IN ADDITION TO OTHER WORK ON THE ENGINE AND FUEL SYSTEM. I FOUND OUT THAT VOLKSWAGEN HAD ISSUED AN EXTENDED WARRANTY FOR THE INTAKE MANIFOLD AND FUEL INJECTORS OF MY VEHICLE'S ENGINE. HOWEVER, ALTHOUGH MY ENGINE WAS OF THE EXACT SAME TYPE INCLUDED IN THE EXTENDED WARRANTY, VOLKSWAGEN CLAIMED I WAS NOT ELIGIBLE FOR WARRANTY REPLACEMENT SINCE MY VEHICLE'S VIN WAS NOT INCLUDED ON THE EXTENDED WARRANTY LIST. CONSIDERING THAT MY VEHICLE HAS BEEN WELL MAINTAINED AND IS ONLY ABOUT 5 YEARS OLD, I BELIEVE THAT THE INTAKE MANIFOLD PROBLEM IS RELATED TO THE PROBLEM THAT RESULTED IN THE WARRANTY EXTENSION, AND MY VEHICLE SHOULD BE INCLUDED IN THE WARRANTY EXTENSION. UPDATED 02/12/15...

FOR THE LAST 4 YEARS, I'VE BEEN DEALING WITH MAJOR MECHANICAL AND NON-MECHANICAL ISSUES WITH MY VOLKSWAGEN (VW) PASSAT 2009, WHICH I BOUGHT BRAND NEW IN 2008. VW'S MECHANICS FOUND THAT MY CAR HAD DEFECTIVE PARTS IN IT, WHICH WERE THERE FROM THE TIME I BOUGHT IT. I HAVE HAD SO MANY PROBLEMS WITH THE CAR THAT I DON'T TRUST IT, EVEN THOUGH VW'S MECHANICS SAID THEY'VE EITHER FIXED OR REPLACED THE BAD PARTS, BUT EACH TIME I'VE TAKEN IT IN FOR REPAIRS IN THE PAST, I'VE HAD THE SAME PARTS REPAIRED OR REPLACED OVER AND OVER. A SUMMARY OF THESE ISSUES: - REAR SIDE WINDOW SUNSCREEN HOOK - REPLACED DUE TO FALLING OUT ? YEAR 2009 - REAR WINDSHIELD SUNSCREEN - REPLACED BECAUSE IT HAD BROKEN ? YEAR 2011 - ENGINE FAULT - CAR DIED AND RUNNING ROUGHLY EVER SINCE ? YEAR 2011 - ENGINE LIGHT COMING ON 4...