2008 VOLKSWAGEN PASSAT Electrical System Problems

There is a recall with the fuel pump and the manufacturer is claiming that I need to replace certain parts to be able to do the recall.

REFERENCE NTSA VEHICLE SAFETY RECALL NUMBER 08V235000. IT IDENTIFIES A ENGINE SURGE AND RESULTANT VEHICLE SURGE FOR VW PASSATS IN THE YEAR 2008. I RECENTLY PURCHASED A 2008 VW PASSAT LUX WAGON AND HAVE HAD THIS HAPPEN TO ME AT LEAST 6 TIMES SINCE THE END OF JUNE WHEN I BOUGHT THE CAR. MOST RECENTLY, A LADY WAS WALKING IN FRONT OF MY CAR IN A CROSSWALK, I HAD STOPPED FOR. AS I BEGAN TO LET OFF THE BRAKE, THE CAR LUNGED FORWARD ABOUT A FOOT, BEFORE I STOPPED IT AGAIN. WE WERE BOTH NOTICEABLY SHAKEN BY WHAT HAD JUST HAPPENED. I TRIED REPORTING THIS INCIDENT AND THE RECALL TO MY LOCAL DEALER, VW OF OLYMPIA< WA> ONLY TO BE TOLD IT DID NOT APPLY TO MY SPECIFIC VIN. I WENT ON TO CONTACT VW CARES ONLY TO BE TOLD THE SAME THING. I DID FILE A REPORT WITH THEIR...

TAKATA RECALL THE FUEL PUMP WATER PUMP AND POWER LOSS

THIS VEHICLE HAS A RECALL FOR KNOWN ELECTRICAL PROBLEMS WHICH MAY CAUSE A LOSS OF STEERING WHILE DRIVING. I HAVE ATTEMPTED TO CONTACT MY LOCAL VW DEALERSHIP TO HAVE THEM LOOK INTO THE ISSUE BUT THEY FAIL TO OFFER A SOLUTION. THE VEHICLE ALSO HAS KNOWN FAULTY ELECTRICAL COMPONENTS IN THE STEERING WHEEL WHICH CAUSE AIRBAG FAULTS.

WHEN I'VE BEEN DRIVING MY CAR IT COMPLETELY SHUTS OFF, I LOSE POWER STEERING, ACCELERATION, BRAKING & NEED TO ALLOW THE CAR TO COME TO A STOP & THEN STUT IF OFF & TURN IT BACK ON. I HAVE TAKEN MY PASTA IN AND THEY ARE UNABLE TO FIND ANYTHING WRONG WITH IT. I FOUND THAT THERE IS A RECALL FOR MY VIN BUT NO AVAILABLE PARTS FOR A FUEL PUMP REPLACEMENT THAT WOULD CAUSE THE CAR TO SUDDENLY SHUT OFF. WHAT CAN I DO TO GET THIS REPLACED I'M SCARED TO KEEP DRIVING IT BECAUSE AT SOME POINT I WILL NOT BE SO LUCKY TO NOT HIT SOMEONE.

TL* THE CONTACT OWNS A 2008 VOLKSWAGEN PASSAT. THE CONTACT STATED THAT THE VEHICLE EXPERIENCED EXCESSIVE ELECTRICAL POWER CONSUMPTION. THE CONTACT STATED THAT THE BATTERY HAD TO BE REPLACED THREE TIMES. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 17V509000 (FUEL SYSTEM, GASOLINE); HOWEVER, THE PARTS TO DO THE REPAIR WERE UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER WAS NOT CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT AVAILABLE FOR THE RECALL REMEDY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND WAS NOT ABLE TO CONFIRM WHEN THE PARTS WERE TO BECOME AVAILABLE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 80,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

WHILE CHANGING THE PASSENGER-SIDE LOW-BEAM BULB, I FOUND WIRING TO ALL THREE BULB HOLDERS MISSING INSULATION, HAVING EXPOSED WIRES. EVEN THE INTACT INSULATION IS VERY BRITTLE WHERE THE MINIMAL MOVEMENT OF THE WIRES, NECESSARY TO REPLACE ANY OF THE BULBS, CAUSES MORE INSULATION TO BREAK AWAY FROM THE BULB WIRING. THERE IS NO WIRE WRAP, ELECTRICAL TAPE, NOR HEAT SHIELDING ON ANY OF THE WIRES WITHIN THE HEADLIGHT ASSEMBLY, LIKE WHAT I SEE ELSEWHERE WITHIN THE WIRING LOOM UNDER THE HOOD. WHETHER THE DAMAGE TO THE WIRES IS INITIALLY FROM HEAT BUILD-UP WITHIN THE HOUSING OR ABRASION AGAINST ANY OF SEVERAL STAMPED METAL PIECES INTERNAL TO THE HOUSING, THE RESULT IS UNSAFE. IF EACH LIGHT WERE INDIVIDUALLY FUSED, THEN THE WIRE GAUGE USED WOULD BE SUFFICIENT FOR A 55-WATT (HALOGEN) BULB. HOWEVER, THE WIRE GAUGE IS NOT ENOUGH TO SURVIVE ANY SHORTING OF THESE WIRES, EITHER DIRECTLY AGAINST EACH OTHER...

MANY TIMES THE CAR WON'T START. AFTER MANY TRIES, IT MAY START, BUT I HAVE BEEN LEFT IN VERY COLD AND UNSAFE PLACES WITHOUT THE ABILITY TO START THE CAR. I FEEL LIKE THIS IS AN ONGOING ISSUE FOR THESE CARS AND VW SHOULD OFFER AN INEXPENSIVE OR FREE FIX FOR THIS.

ENGINE STALLS SOMETIMES WHILE DRIVING--JUST A MOMENTARY HICKUP

MY VEHICLE (2008 VW PASSAT) STARTED HAVING ACCELERATION ISSUES AND WOULD ONLY GO UP TO 40 MPH AS WELL AS ALSO HAVING A ROUGH START UP WHEN TURNING MY CAR ON. I PROCEEDED TO TAKE IT INTO THE DEALERSHIP TO HAVE THIS LOOKED AT AND AT FIRST THEY CLAIMED THAT I NEEDED A NEW HIGH PRESSURE FUEL PUMP WHICH WOULD COST ME AROUND $700. LATER IN THE DAY, I RECEIVED A CALL BACK TELLING ME THAT MY INTAKE CAMSHAFT WAS BROKEN AND THAT THEY COULD NOT MAKE THE REPAIR WITHOUT REPLACING THIS AS WELL. NOW MY TOTAL WAS UP TO $2000. AFTER DOING SOME RESEARCH AND CALLING AROUND TO COMPARE PRICES, I TALKED TO A REPAIRMAN THAT HAD TO REPLACE HIS CAMSHAFT IN THE SAME YEAR VW CAR BECAUSE OF SIMILAR ISSUES. I FOUND THAT MY MODEL 2008 VW PASSAT WAS BUILT WITH A FAULTY INTAKE CAMSHAFT REVISION B WHICH...

WHILE DRIVING ON THE HIGHWAY IN THE RAIN THE CAR WOULD STALL WHICH CAUSED US TO HAVE TO PULL TO THE SIDE OF THE ROAD. AN ENGINE CODE INDICATED A FAULTY PART. THE PART WAS REPLACED, THEN THE SAME ISSUE OCCURRED AFTER A CAR WASH. IT WAS DISCOVERED THAT WATER HAD GOTTEN INTO THE WIRING HARNESS AT AN AREA AT THE BASE OF THE WINDSHIELD AND CAUSED A SHORT. IN THIS AREA OF THE WIRING HARNESS THERE IS A JUNCTION THAT WE WERE TOLD WAS NOT WATER PROOF OR SEAL AGAINST WATER. THIS SHORT DAMAGED THE ELECTRONIC CONTROL MODULE WHICH MADE THE CAR UNDRIVEABLE.

WHILE TRAVELING AT APPROXIMATELY 50 MILES PER HOUR ON STATE HIGHWAY CAR SUDDENLY LOST ALL POWER. STEERING BECAME DIFFICULT BUT WAS ABLE TO PULL OFF TO SIDE OF ROAD AND COAST INTO PARKING LOT. CAR WOULD NOT START FOR 24 HOURS TO MOVE TO REPAIR SHOP. AFTER DIFFICULTY DIAGNOSING DUE TO LOSS OF ALL POWER, IT WAS DETERMINED THAT THE POWER SUPPLY RELAY WAS APPARENTLY BAD. COULD FIND NO RECALL OR EXTENDED WARRANTY FOR THIS ISSUE. SHOULD NOT HAPPEN ON A CAR WITH SO FEW MILES WHICH HAS BEEN WELL MAINTAINED. VERY DANGEROUS AND SCARY ISSUE! WAS VERY LUCKY TO BE ABLE TO PULL OVER IN TIME TO AVOID TRAFFIC. *TR

VEHICLE HAS APPROX ONE YEAR OF DIFFICULT STARTS REQUIRING MULTIPLE ATTEMPTS. ON 7/20/14 WHILE DRIVING IN PARKING LOT VEHICLE STALLED AND REFUSED TO RESTART DESPITE NUMEROUS ATTEMPTS. TOWED HOME. DTC SHOWED CONTROL MODULE FOR ELECTRONIC STEERING COLUMN LOCK LEAKING. VEHICLE REFUSING TO START DESPITE ALL OTHER ELECTRICAL COMPONENTS CHECKING OUT. CHECK ENGINE LIGHT NOT ON. *TR

THE CAR WAS PARKED AND WOULD NOT START EVEN AFTER A CHECK OF THE BATTERY. THE CAR HAD NO POWER WHATSOEVER AND COULD NOT BE PLACED INTO NEUTRAL TO TOW-THE ELECTRONIC EMERGENCY BRAKE WAS ALSO LOCKED.THE VEHICLE SAT TWO NIGHTS IN A SHOPPING CENTER PARKING LOT BEFORE A TOWING COMPANY COULD FIGURE SOMETHING OUT. THE TOW WAS $106.00 TO THE VW DEALERSHIP.THE DEALER WANTED $107 LABOR CHARGE FOR EACH PROBLEM. I ALREADY LOOKING AT A $214.00 BILL FOR THE STARTING ISSUE AND BRAKE.I TOLD THE TECHNICIAN IF THE CAR STARTS THE BRAKE SHOULD RELEASE ACCORDING THE OPERATORS MANUAL-ITS ELECTRONIC.HOW THIS HAPPENED IS A COMPLETE MYSTERY AS THERE HAD NEVER BEEN EVEN THE SLIGHTEST INDICATION.I HAVE SEEN MANY, MANY REPORTS OF THIS SAME ISSUE WITH THIS CAR ON THE INTERNET AS I DID SOME RESEARCH AFTER THIS HAPPENED. I RECEIVED A CALL FROM THE DEALERSHIP- THE STEERING WHEEL MODULE WAS $565...

WE CAME HOME FROM A 30 MILE TRIP AND PARKED THE CAR IN THE DRIVEWAY. WENT IN THE HOUSE AND ABOUT 5 MINUTES LATER HEARD A BIG POP SOUND. I THINK IS WAS A TIRE EXPLODING AND FOUND THE ENTIRE ENGINE ON FIRE. ANOTHER POPPING SOUND OCCURRED AND ANOTHER TIRE BLEW. ON THE DRIVE HOME THERE WERE NO PROBLEMS NOTED ON THE DASH BOARD. WHEN WE GOT OUT OF THE CAR THERE WERE NO ODORS OR INDICATION OF A FIRE. MY KEYS WERE IN THE HOUSE AT THE TIME OF THE FIRE. OTHER ISSUES THAT MIGHT BE RELATED. THIS PAST WEEK MY CHARGER GOT EXTREMELY HOT TO TOUCH AND I STOPPED USING IT. I ALSO FELT THE CAR TRY TO START AFTER I TURNED IT OFF. *TR

ALL CONTROLS LOCATED ON THE STEERING WHEEL WENT DEAD, AND AIRBAG FAILURE INDICATOR CAME ON. TURNING VEHICLE OFF AND RESTARTING IT DID NOT SOLVE THE PROBLEM. DRIVERS SIDE AIRBAG SEEMS NOT TO BE FUNCTIONAL. *TR

THE CAR WAS PARKED AND WOULD NOT START EVEN AFTER A CHECK OF THE BATTERY. THE CAR HAD NO POWER WHATSOEVER AND COULD NOT BE PLACED INTO NEUTRAL TO TOW. AFTER 4 DAYS IN THE SHOP, IT WAS DETERMINED THAT THE ENTIRE ANTI-THEFT SYSTEM HAD BURNED OUT AND FRIED THE IGNITION AS WELL. HOW THIS HAPPENED IS A COMPLETE MYSTERY AS THERE HAD NEVER BEEN EVEN THE SLIGHTEST INDICATION THAT SOMETHING WAS WRONG BEFORE THIS INCIDENT.THE ENTIRE STEERING COLUMN HAD TO BE PULLED OUT OF THE VEHICLE AND THE MODULE HAD TO BE REPLACED. I HAVE SEEN MANY, MANY REPORTS OF THIS SAME ISSUE WITH THIS CAR ON THE INTERNET AS I DID SOME RESEARCH AFTER THIS HAPPENED. THE PRICE TO REPAIR THE CAR WAS $895.00,,,WHICH SEEMS RIDICULOUS TO ME GIVEN THAT THE CAR ONLY HAS 45K MILES. I TRIED TO GET SOME HELP FROM VW CUSTOMER CARE GIVEN THAT...

I GOT HOME AFTER WORK SATURDAY NIGHT AROUND 7PM AND PARK MY 2008 VW PASSAT IN FRONT OF MY HOUSE AND TWO MINUTES AFTER SMOKE START COMING OUT THROUGH FRONT GRILLE I OPEN THE HOOD AND IT SMALL LIKE BURNED PLASTIC. I SOW COIL AND WIRE WHERE IS CONNECTED ALL MELTED. I WAS LUCKY THAT THIS DID NOT HAPPENED WHILE I WAS DRIVING. *TR

OWNED THE CAR FOR 9 MONTHS, AND HAVE HAD DOCUMENTED PROBLEMS FOR 8 MONTHS INCLUDING A COMPLETE FAILURE THAT REQUIRED TOWING. THE PRIMARY PROBLEMS ARE: 1. STEERING COLUMN WARNING LIGHT ON - THE COMFORT MODULE AND STEERING ELECTRONICS WERE REPLACED 7 WEEKS AFTER PURCHASING THE CAR 2. ONGOING INTERMITTENT PROBLEMS STARTING THE CAR. THE CAR DIED ON 6/15/10, WAS TOWED, AND THE IGNITION COIL WAS REPLACED. CURRENT: CAR DID NOT START ON FIRST ATTEMPT ON 7/4/10, WHICH IS LESS THAN 3 WEEKS LATER! 3. CAR BURNS EXCESSIVE OIL. NEED TO ADD OIL BETWEEN SCHEDULED OIL CHANGES. IN APRIL 2010, OIL PRESSURE LIGHT CAME ON. DEALER ADDED 2 QTS OF OIL AND TANK WAS STILL NOT FULL. STILL HAD 1,000 MILES TO GO BEFORE NEXT SCHEDULED OIL CHANGE. HAVE HAD OIL ADDED ON TWO OTHER OCCASIONS BETWEEN OIL CHANGES. 4. CAR IS SLUGGISH, ESPECIALLY WHEN GOING UP HILLS. NO RESPONSE OR...

2008 VW PASSAT WAGON. THIS CAR WHILE PARKED, RUNNING AND OCCUPIED, IN A GARAGE HAD A FIRE WHOSE POINT OF ORIGIN WAS THE AREA OF THE DRIVER'S SEAT. THE FIRE INVESTIGATION DETERMINED THE CAUSE TO BE ACCIDENTAL MECHANICAL. THE FIRE CAUSED SIGNIFICANT DAMAGE TO A SINGLE FAMILY HOME, DAMAGE ESTIMATED AT ABOUT $200,000 ALSO ONE OCCUPANT OF THE HOME HAD TO BE TRANSPORTED BY EMS FOR SMOKE INHALATION. THE DRIVER OF THE CAR STATED SHE TO LEAVE. SHE PLACED THE 5 YEAR OLD IN THE CHILD SEAT OF THE VOLKSWAGEN AND OPENED THE GARAGE DOOR. SHE STARTED THE CAR AND SMELT SMOKE. IMMEDIATELY SHUT THE CAR OFF AND CALLED THE HUSBAND. THE HUSBAND SAID THAT IT WAS PROBABLY THE SEAT HEATER, HAD HER TURN OFF THE SEAT HEATER AND RESTART THE CAR. SHE RESTARTED THE CAR SMELT AND OBSERVED SMOKE AGAIN, TURNED OFF THE CAR, GOT OUT AND SAW FLAME...