2004 SATURN ION Electrical Systemignition Problems

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE KEY FAILED TO RELEASE FROM THE IGNITION. THE FAILURE OCCURRED ON SEVERAL OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE IT WAS DIAGNOSED THAT THE KEY AND THE IGNITION NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED BUT THE FAILURE PERSISTED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 3,000. UPDATED 01/23/15*LJ UPDATED 9/8/2017*CN

TL* THE CONTACT THE OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE FAILED TO SHUT OFF AND THE KEY BECAME LODGED IN THE IGNITION. THE CONTACT HAD TO MAKE SEVERAL ATTEMPTS BEFORE THE VEHICLE SHUT OFF AND THE KEY RELEASED. THE VEHICLE HAD NOT BEEN DIAGNOSED OR REPAIRED. THE VEHICLE WAS INCLUDED IN RECALL NHTSA CAMPAIGN NUMBER: 14V047000 (ELECTRICAL SYSTEM). HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

I HAVE HAD THE IGNITION CHANGED DUE TO A RECALL. PRIOR TO THAT THE IGNITION KEY WOULD STICK AND WOULD NOT COME OUT. I HAD TO MOVE IT BACK AND FORTH AND AFTER SEVERAL TRIES IT WOULD COME OUT. I THOUGHT THAT THE RECALL WOULD CORRECT BUT IT DID NOT. I STILL HAVE THE SAME INTERMITTENT PROBLEM. ARE THERE MORE COMPLAINTS REGARDING THIS PROBLEM? THANK YOU VERY MUCH FOR ANY ADVICE YOU CAN GIVE ME REGARDING THIS PROBLEM. *TR

IGNITION RECALL. TOOK CAR TO KEYES GMC WOODLAND HILLS CA 2 TIMES AND THEY CHANGED IGNITION BUT DID NOT FIX PROBLEM. NOW THEY WANT $500 TO FIX "SHIFTER". I THINK IT IS STILL KEY IGNITION. MADE COMPLAINT TO GM #[XXX]. CALLED GM TWICE 866 790-5700 FOR DECISION AND NO RESPONSE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 14V153000 (STEERING) HOWEVER, THE PART TO PERFORM THE REPAIRS WAS UNAVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE DELAY. THE CONTACT HAD NOT EXPERIENCED A FAILURE. UPDATED 09/02/14*LJ UPDATED 09/17/2014 *JS

KEY AT TIMES DOES NOT COME OUT OF IGNITION SWITCH. EVEN THOUGH THE SWITCH WAS REPLACED TWICE.THIS HAS BEEN A ON GOING ISSUE AND STILL HAS PROBLEMS TODAY. *JS

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT SHE RECEIVED A RECALL NOTIFICATION LETTER FOR NHTSA CAMPAIGN ID NUMBER 14E021000 ( IGNITION SWITCH). THE DEALER INFORMED HER THAT THE PART WAS UNAVAILABLE. THE CONTACT REQUESTED A RENTAL VEHICLE HOWEVER, THE DEALER INFORMED THE CONTACT NOT TO DRIVE THE VEHICLE AFTER SHE DROVE IT TO HER RESIDENCE. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGTION SWITCH AND WAS UNABLE TO RELEASE. THE CONTACT MENTIONED THAT THE VEHICLE WAS REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER 14V171000 (ELECTRICAL SYSTEM); HOWEVER, THE REMEDY FAILED TO REPAIRED THE PROBLEM. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 126,184.

CAR WILL NOT START BECAUSE THE IGNITION WILL NOT READ THE KEY. IT TAKES 15 MINUTES JUST WAITING, WITH THE KEY OUT, THEN WHEN TRYING AGAIN IT DOES READ THE KEY AND THE CAR STARTS. THIS IS NOT THE FIRST TIME AS IT HAS BEEN GOING ON FOR THE LAST EIGHT (8) YEARS FOR ME WITH HUNDREDS OF OTHERS WITH THE SAME PROBLEM! I HAVE TAKEN THE CAR TO DEALERSHIPS AND GARAGE WORKERS. EACH PLACE SAYS THE CAR IS FINE, NOTHING WRONG. IT SEEMS THAT GM KNEW SOMETHING WAS WRONG SINCE 2003 AND GM LATER TOLD DEALERSHIPS SO DEALERSHIPS KNEW AND NO ONE DID ANYTHING. WELL, GM HAS FINALLY MADE THE STATEMENT THAT SOMETHING IS WRONG WITH THE IGNITION SYSTEM AND KEYS - FINALLY. ONE BIG QUESTION IS WHY DID IT TAKE SO LONG FROM NHTSA TOO! NHTSA IS TO MAKE SURE PEOPLE ARE SAFE BUT YOU HAVE BEEN VERY...

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT AFTER POWERING OFF THE VEHICLE, THE KEY WAS UNABLE TO BE REMOVED FROM THE IGNITION. THE CONTACT MENTIONED THAT THE FAILURE RECURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO A DEALER WHERE THE FAILURE WAS UNABLE TO BE REPLICATE AND TWO NEW KEYS WERE PROVIDED TO THE CONTACT. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 1,000 AND THE CURRENT MILEAGE WAS 28,000. UPDATED 9/24/13 *CN

2004 SATURN ION. CONSUMER STATES PROBLEM WITH FAULTY IGNITION. *TGW THE CONSUMER STATED THE DASHBOARD LIGHTS WOULD ILLUMINATE, WHEN THE KEY WAS TURNED, BUT THE VEHICLE WOULD NOT START. THE CONSUMER STATED SHE WOULD HAVE TO WAIT TEN MINUTES OR LONGER, BEFORE THE VEHICLE WOULD START. *JB THE CONSUMER WAS INFORMED AN IGNITION HOUSING PROBLEM WAS COMMON WITH HER VEHICLE. UPDATED 06/23/11

THE KEY IN THE IGNITION OF THE SATURN ION 2004 WILL NOT COME OUT AND THE CAR CAN NOT BE SHUT OFF . JUST LAST MONTH THE KEY WOULD NOT FO INTO THE IGNITION OR START THE CAR. BROUGHT IT TO THE GM DEALERSHIP HAD TO HAVE A NEW IGNITION CYLINDER PUT IN A MONTH AGO. TODAY I HAD TO HAVE THE IGNITION HOUSING. THIS IS NOT JUST MY CAR. 90 % OF THE 2004 AND 2006 HAVE THIS SAME PROBLEM. THIS SHOULD BE A SAFETY ISSUE SINCE IF NO ONE KNOWS HOW TO DISCONNECT THE BATTERY THE CAR COULD OVERHEAT .AND EVEN CATCH ON FIRE. *TR

I DRIVE A 2004 SATURN ION 2. WHEN THE TEMPERATURE IS 32 DEGREES OR LOWER MY CAR WILL NOT START IF IT HAS BEEN SITTING FOR MORE THAN 4 OR 5 HOURS. I HAVE BEEN LEFT STRANDED ON MULTIPLE OCCASIONS WITH THIS PROBLEM. I BELIEVE IT IS SOMETHING IN THE IGNITION SWITCH. DURING THE WINTER MONTHS THIS WILL HAPPEN EVERY MORNING AND OCCASIONALLY AFTER WORK IF THE TEMPERATURE IS TOO COLD. I HAVE NOT DONE ANYTHING TO FIX THE PROBLEM BECAUSE IT WILL COST AROUND $200.00 TO FIX. *TR

TL*THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED WHEN THE TEMPERATURE DROPPED BELOW 30 DEGREES THE VEHICLE WOULD NOT START DUE TO THE IGNITION SWITCH FAILURE. THE FAILURE WAS CAUSED BY THE PASS LOCK CIRCUIT THAT WAS INSIDE THE IGNITION SWITCH AND THE RESISTANCE VALUE WITHIN THE PASS LOCK SYSTEM. THE VEHICLE WAS TOWED TO THE DEALER WHERE THEY REPLACED THE IGNITION SWITCH. THE VEHICLE WAS UNDER WARRANTY AND THERE WERE NO RECALLS. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 45,000.

I HAVE A 2004 SATURN ION THAT WILL NOT START WHEN THE WEATHER IS COLD. THIS PROBLEM HAPPENS ONLY IN THE WINTER. I HAVE READ MANY REVIEWS ABOUT OTHER CUSTOMERS HAVING THE SAME PROBLEM WITH THEIR IONS AND MOST OF THEM SAY IT HAS SOMETHING TO DO WITH THE IGNITION SWITCH. I THINK I WILL PROBABLY HAVE IT REPLACED. *TR

2004 SATURN ION- IGNITION FAILS TO RELEASE THE KEY, CANNOT REMOVE THE KEY FROM IGNITION WITHOUT STRUGGLING. HAVE RESEARCHED THE CONSUMER AFFAIRS WEBSITE AND THERE ARE SO MANY COMPLAINTS ABOUT THIS OCCURRING, THAT IS UNREAL. FORTUNATELY WE HAVE NOT HAD TO LEAVE THE CAR RUNNING YET... AS SO MANY OTHER CUSTOMERS AND SOME HAVE HAD TO REMOVE A FUSE TO GET THE CAR TO TURN OFF. SATURN NEEDS TO DO A VOLUNTARY RECALL ON THIS AND REPLACE ALL OF THE IGNITION SWITCHES BEFORE A TRAGEDY OCCURS. *TR

I AM THE OWNER OF A 2004 SATURN ION2 SEDAN. AS OF THE PAST WINTER WITH UNSEASONABLE COLD TEMPS I BEGAN HAVING AN ISSUE WITH THE IGNITION OF MY CAR. THE CAR WOULD NOT TURN OVER AT ALL SOMETIMES FOR HOURS AT A TIME. THE IGNITION HAS BEEN REPLACED AND DID NOT FIX THE PROBLEM. I LIVE IN WESTERN NY WHERE WE DO SEE COLD TEMPS DURING THE WINTER MONTHS. I HAVE A CHILD I MUST GET TO SCHOOL BEFORE I GO TO WORK EVERY DAY. I HAVE BEEN A TRUE ADVOCATE OF SATURNS VEHICLES UP UNTIL THE PURCHASE OF THIS ONE. I HAVE BEEN RESEARCHING THE PROBLEM AND FOUND SEVERAL OTHERS WITH THE EXACT SAME PROBLEM AND NO RESOLUTION. I REALLY HOPE THAT THEE HAVE BEEN ENOUGH COMPLAINTS ABOUT THIS PROBLEM FOR GM TO ACTUALLY STEP UP AND ISSUE A RECALL. I REALLY DO NOT WANT TO SELL MY...

MY CAR HAS PROBLEMS STARTING WHEN THE TEMP. GETS BELOW 30 DEGREES. I HAVE HAD THIS "FIXED" TWICE, AND I WAS TOLD THIS WAS BECAUSE I NEEDED A NEW IGNITION SWITCH. I HAVE FOUND SEVERAL SITES WHERE OTHERS HAVE HAD THE SAME ISSUE. I HAVE CONCLUDED THAT THERE IS SOMETHING WRONG WITH THE SENSOR IN THE PASSLOCK PART OF THE IGNITION SWITCH THAT CAUSES IT TO NOT WORK PROPERLY WHEN TEMP. GETS BELOW 30 DEGREES. SATURN IS WELL AWARE OF THIS I BELIEVE AND THEY HAVE YET TO DO ANYTHING ABOUT IT. IT IS VERY DANGEROUS BECAUSE IT CAN CAUSE SOMEONE TO BE STRANDED SOMEWHERE IN THE COLD WEATHER. IT HAS ALSO CAUSED ME TO BE LATE FOR WORK SEVERAL TIMES AND HAS ALMOST COST ME MY JOB. *TR

MY CAR DOES NOT START IN THE COLD. (AT OR BELOW FREEZING.) I HAVE HAD THIS PROBLEM MANY TIMES SO FAR!! AFTER DOING SOME ONLINE "RESEARCH" I HAVE FOUND HUNDREDS OF OTHER PEOPLE WHO HAVE THE EXACT SAME PROBLEM WITH THIS CAR ON DIFFERENT FORUMS AND CONSUMER COMPLAINT WEBSITES. WHAT IS GM DOING TO REMEDY THIS, AND WHY ISN'T THERE A RECALL ON THE IGNITION SWITCH OR WHATEVER PART IS AT FAULT? I WAS STUCK OUTSIDE IN THE COLD TODAY WITH MY TWO SMALL CHILDREN WHILE WAITING FOR SOMEONE TO HELP ME...!!! *TR

I PURCHASED MY VEHICLE IN MARCH OF 2004 AND HAVE HAD NUMEROUS PROBLEMS SINCE. I HAVE HAD THE IGNITION SWITCH REPLACED PREVIOUSLY AND NOW JUST PAID $630 TO HAVE THE BODY MODULE REPLACED BECAUSE THE ANTI-THEFT SYSTEM LOCKS THE WHOLE CAR DOWN MAKING IT IMPOSSIBLE TO START IT. INITIALLY IT WAS THOUGHT TO BE A COLD WEATHER PROBLEM BACK WHEN I FIRST HAD THE CAR IGNITION SWITCH REPLACED. THIS RECENT INCIDENT IS STILL NOT YET RESOLVED BECAUSE I HAVE BEEN HAVING DIFFICULTY GETTING THE KEYS OUT OF THE IGNITION ONCE THE CAR IS TURNED OFF. IT APPEARS THAT THE BODY MODULE IS STILL NOT REGISTERING THAT THE KEY IS IN OFF POSITION BECAUSE THE IGNITION SWITCH IS STILL FAULTY. I AM AT A LOSS FOR WHAT TO DO NEXT BECAUSE I DON'T HAVE MONEY FOR THESE KIND OF REPAIRS ESPECIALLY ONCE EVERY WEEK. *TR

HAVE TO HAVE MY IGNITION CYLINDER AND HOUSING REPLACED IN MY SATURN ION 3. KEY WILL NOT TURN TO START VEHICLE. A NEW KEY WILL START THE CAR BUT ONLY WORKS FOR 2 WEEKS. I AM ON MY 5TH KEY IN A LITTLE OVER 2 MONTHS. TOOK CAR TO DEALERSHIP YESTERDAY, HOPE TO GET IT BACK TOMORROW. CHARGE WAS $523, COMPLAINED TO SATURN CUSTOMER CARE AND THEY BROUGHT IT DOWN TO $230. SO I AM PAYING $230 TO TURN THE KEY IN THE IGNITION OF MY 4 YEAR OLD CAR. *TR

WHENEVER THE TEMPERATURE IS AT 30 DEGREES F OR BELOW MY 2004 SATURN ION WILL NOT START DUE TO THE PASSLOCK SYSTEM. THIS IS A KNOWN PROBLEM AND COULD LEAD TO A VERY DANGEROUS STRANDED SITUATION. *TR

CAR OFTEN WILL NOT START. SEEMS TO BE IGNITION SWITCH, AND/ OR RELATED CIRCUITS. LEAVES MOTORIST STRANDED, USUALLY IN BAD WEATHER. REPLACED BATTERY AT 18 MOS., WHICH WAS NOT PROBLEM. REQUIRED 'RESCUE' FROM OTHER FAMILY MEMBERS MANY TIMES, IN LIEU OF TOW SERVICE. *TR

ON SEVERAL OCCASSION WHILE IT HAS BEEN COLD OUT, MY VEHICLE WOULD NOT START. AS A MATTER OF FACT THE VEHICLE WOULD NOT EVEN ATTEMPT TO ROLL OVER. THE ONLY WAY I COULD SEEM TO RESOLVE THE SITUATION WAS BY "JUMP STARTING" MY SATURN WITH ANOTHER VEHICLE. THIS HAS HAPPENED SO MANY TIMES IN THE WINTER THAT I FINALLY GOT SICK OF IT AND PARKED THE SATURN AND DROVE A DIFFERENT VEHICLE. I AM SO SICK OF MY CAR THAT I AM READY TO SELL IT. I RECENTLY FOUND OUT ABOUT THIS SITE. AFTER READING THE FIRST 20 SOME RESULTS AND SEEN THAT EVERYONE WAS HAVING THE SAME ISSUE I WAS. I CAN NOT BELIEVE THAT THERE IS NOT A RECALL ON THIS PART. I READ OTHER COMPLAINTS TOO AND AM GLAD THAT I HAVE NOT RAN INTO THEIR PROBLEM YET. IF SATURN DOES NOT FIX THIS PROBLEM REALLY SOON,...

MY 2004 SATURN ION2 WILL NOT START IN VERY COLD WEATHER (SUB-ZERO AIR TEMPERATURES). AFTER SEVERAL ATTEMPTS ARE MADE - WITH APPROX. 10-15 MINUTES BETWEEN EACH ATTEMPT - THE CAR STARTS RIGHT UP. THE IGNITION WILL NOT CRANK THE CAR, CAUSING IT TO NOT ROLL OVER. WHEN THIS HAPPENS, THE DISPLAY ON THE DASH READS "SERVICE VEHICLE". AFTER DOING SOME RESEARCH, I'VE LEARNED THIS IS AN ON-GOING PROBLEM WITH THESE VEHICLES. I AM TOLD I MUST REPLACE THE IGNITION SWITCH TO REMEDY THE PROBLEM, BUT ALSO THAT THIS MAY NOT EVEN BE A PERMANENT FIX. I AM APPALLED BY SUCH FAULTY WORKMANSHIP IN AN AMERICAN-MADE CAR. *TR

2004 SATURN ION I'M HAVING STARTING PROBLEMS. ON COLD DAYS THE CAR WON'T START SOMETIMES, BUT IF YOU WAIT A FEW MINUTES IT WILL START RIGHT UP. SOMETIMES IT TAKES SO LONG THAT I HAVE TO LEAVE IT AND GET A RIDE. *TR

SATURN 1ON 2004 BAD IGNITION SWITCH... *CN

PRIOR TO PURCHASING MY '04 SATURN ION I READ ALL THE REVIEWS AND CUSTOMER COMPLAINTS. ONE OF THE BIGGEST COMPLAINTS I CAME ACROSS WAS THAT THE VEHICLE WOULD NOT START IN COLD WEATHER. I ASSUMED THAT SINCE I LIVED IN FLORIDA AND IT SEEMED MOST OF THE COMPLAINTS WHERE FROM OTHER STATES WHERE THEY GET FREEZING TEMPERATURES, THAT I WOULD NOT HAVE THIS PROBLEM. HOW WRONG I WAS, I HAVE HAD THIS PROBLEMS SEVERAL TIMES NOW WHEN THE TEMPERATURE DROPS BELOW 40 DEGREES. I CONTACTED SATURN AND ASKED THEM IF THERE WAS ANYTHING THEY COULD DO ABOUT IT AND WAS TOLD THAT SINCE THERE WASN'T A RECALL I'D HAVE TO PAY FOR ANY REPAIRS TO FIX THIS PROBLEM. I HAVE READ SEVERAL COMPLAINTS WHERE NOT EVEN THEM ATTEMPTING TO FIX IT HAS RESOLVED IT, I GUESS I'LL JUST LIVE WITH THE HEADACHE OF TRYING TO GET IT STARTED ON THE...

THE SATURN ION WILL NOT START IN COLD WEATHER. SATURN KNOWS OF THE PROBLEM BUT WILL NOT FIX MANY POSTS ON LINE OF THIS ISSUE. IT IS A MAJOR PROBLEM AS I NEED TO MOVE AT A MOMENTS NOTICE FOR WORK. *TR

WHEN THE WEATHER REACHES FREEZING AND CAR HAS BEEN LEFT OFF FOR ABOUT 6 TO 8 HOURS IT WILL NOT START AGAIN. I HAD THE PROBLEM TWO YEARS AGO AND SATURN REPLACED THE STARTER ON THE CAR AND NOW THE PROBLEM IS BACK AGAIN THIS WINTER. I HAVE CHECKED SEVERAL SITES AND THIS APPEARS TO BE A BIG PROBLEM THAT SHOULD BE ADDRESS. REPLACING THE STARTER EVERY OTHER WINTER IS NOT AN ACCEPTABLE SOLUTION. *TR

I LIVE IN MINNESOTA. I PURCHASED A NEW 2004 SATURN ION COUPE, WITH ONLY 84 MILES AND DROVE OFF THE SHOW ROOM FLOOR. I HAD NUMEROUS PROBLEMS WITH THE CAR STARTING IN COLD WEATHER. I TOOK THE CAR TO A SATURN DEALERSHIP ONCE IT STARTED , AND THEY SAID IT WAS THE PASS LOCK SYSTEM IN THE CAR. THE SATURN HAS CONTINUED TO DO THE SAME THING OVER THE LAST COUPLE WINTERS. THIS PAST WINTER IT WAS EXTREMELY BAD. 2 OUT OF 7 DAYS THE CAR WOULDN'T START RIGHT AWAY ,BUT THEN I WOULD TRY AGAIN IN 20 MINUTES AND IT WOULD START. I TOOK THE SATURN REMOTE CONTROLS OFF THE KEY CHAIN THINKING IT WAS THE PROBLEM. BUT IT WASN'T . ALSO, I HAD THE BATTERY TESTED AND IT WAS FINE. THERE NEEDS TO BE A RECALL ON THIS VEHICLE. CAN SOMEONE PLEASE HELP. IT SEEMED MANY WERE HAVING...

AT THE BEGINING OF MAY I TOOK THE CAR INTO THE DEALER BECAUSE I COULD REMOVE THE KEY FROM THE IGNITION WHILE THE CAR WAS STILL ON. THEY REPLACED THE IGNITION LOCK CYLNDER. I THOUGHT ALL WAS WELL. *AK ON MAY,29 2007, I WAS TAKING MY WIFE OUT TO DINNER FOR HER BIRTHDAY. WHEN I PARKED THE CAR I TRIED TO TURN THE CAR OFF AND FOUND OUT THAT I COULD NOT PULL THE KEY OUT NOR COULD I TURN THE CAR OFF. I CALLED SATURN AND WAS TOLD TO TRY TO DISCONNECT THE BATTERY TO TURN OFF THE CAR. THIS DID NOT WORK. I INSTEAD HAD TO REMOVE THE CARS FUSE FOR THE FUEL RELAY PUMP. I TOOK THE CAR INTO THE SHOP THE NEXT MORNING. AFTER SITTING AT THE DEALER FOR OVER 4 HOURS I WAS TOLD THE ANTI THEFT DEVICE AND IGNITION COLUMN COULDNT BE REPROGRAMED BECAUSE...

SATURN ION WILL NOT START DUE TO COLD ISSUES AND IS CAUSED BY AN ISSUE IN THE STARTING MECHANISM. SOMETHING ABOUT THERE BEING A SECURITY FEATURE THAT CUTS THE CAR OFF FROM STARTING. CAR LEAVES YOU PRETTY MUCH STRANDED IN THE BITTER COLD WHEN IT WILL NOT START.*JB

TL*- THE CONTACT STATED THAT THE 2004 SATURN ION DID NOT CRANK OR START WHEN THE OUTSIDE TEMPERATURE WAS BELOW 35 DEGREES. THE CONTACT CALLED THE DEALERSHIP, AND THEY STATED THAT THE PASSLOCK SWITCH WOULD NEED TO BE REPLACED. THE FAILURE WITH THE VEHICLEWAS A COMMON PROBLEM WITH THE 2004 SATURN ION. THE FAILURE MILEAGE WAS 36000 AND THE CURRENT MILEAGE WAS 42000.*AK

2004 ION II INTERMITTENTLY WON'T START - MAKES A SHORT CRANKING SOUND AND THEN - NOTHING. AFTER WAITING FOR A WHILE (20-30 MINUTES OR S) IT WILL TURN OVER - ESPECIALLY IN COLD WEATHER - HAD THE SAME PROBLEM LAST YEAR AND WAS SOLD A NEW STARTER BY THE DEALERSHIP. A MONTH LATER I HAD A STARTING PROBLEM AGAIN, BUT IT DID NOT REPEAT UNTIL TODAY. *NM

MY 2004 ION HAS THE INTERMITTENT STARTING ISSUE AS WELL. IT FIRST HAPPENED WHEN THE CAR HAD 42000 MILES (CURRENTLY AT 80000). THE DISPLAY ON THE DASH READS "SERVICE ENGINE" AND TURNING THE KEY RESULTS IN NOTHING. REPEAT ATTEMPTS IN 10 MINUTE INCREMENTS USUALLY FIXES IT RIGHT UP, AFTER 2 OR 3 TRIES. SATURN SHOULD REALLY BE HELD ACCOUNTABLE AS THIS SEEMS TO BE THE RULE MORE SO THAN THE EXCEPTION WITH THESE IONS. *NM

I HAD A PROBLEM WITH MY 2004 SATURN ION NOT STARTING A FEW TIMES LAST WINTER I THOUGHT IT WAS RELATED TO WATER IN THE FUEL OR A BATTERY PROBLEM AND AFTER TAKING STEPS TO FIX ANY DEFECTS WITH EITHER I HAD NO FURTHER PROBLEM WITH MY CAR UNTIL THE FIRST COLD DAY THIS WINTER. IT HAS IN THE LAST MONTH FAILED TO START AT LEAST 6 TIMES, ALL ON COLD MORNINGS. IT WILL EVENTUALLY START AFTER TRYING FOR ABOUT 10 MINUTES. I AM NO LONGER UNDER WARRANTY SO I DID SOME RESEARCH BEFORE CALLING THE DEALER AND FOUND OTHER OWNERS WITH THE EXACT SAME PROBLEM. I THEN CALLED THE DEALERSHIP WHERE I PURCHASED THE CAR AND ALTHOUGH THEY KNEW OF THE PROBLEM, THEY WERE STILL GOING TO CHARGE ME DIAGNOSTIC FEES IF I BROUGHT IN MY CAR. I CONTACTED THE SATURN CORPORATION TO FIND OUT WHY THAT HAVE NOT...

I HAVE HAD MY 04 ION FOR ONE AND HALF YEARS NOW, AND LAST YEAR WHEN THE WEATHER STARTED TO GET COLD, IT WOULD NOT START. I CALLED THE DEALER AND THEY TOLD ME THAT THE GREASE AROUND THE IGNITION COULD NOT TOLERATE THE COLD WEATHER HERE IN NEVADA. SO I HAD IT REPLACED. PROBLEM SOLVED, UNTIL THIS YEAR. JUST TODAY, FOR THE FIRST TIME THIS YEAR, IT DIDN'T START. NOW THE WEATHER HERE HAS BEEN IN THE TEENS FOR THE PAST WEEK, THIS TELLS ME THAT IT'S NOT JUST THE TEMPERATURE, THERE HAS TO BE SOMETHING ELSE. BUT NO ONE CAN TELL WHAT. SOMETHING NEEDS TO BE DONE. *JB

STARTER FAILURE SATURN ION IN COLD WEATHER. HALF HOUR TO 45 MINUTES TO CRANK - BACKFIRING IN A CLOSED SYSTEM WITH FUEL INJECTION OCCASIONALLY, TWICE BLOWING LID OFF OF AIR-FILTER COMPARTMENT - NOT A JOY. "SERVICE ENGINE" LIGHT GOES ON - LATE TO WORK - COMMON PROBLEM - LOTS OF ONLINE COMPLAINTS. REPLACED BATTERIES BELIEVING THIS TO BE PROBLEM. NEW BATTERIES WITH HIGHER CRANKING AMPS DOES NOT SOLVE. NOT A BATTERY PROBLEM. DATE GIVEN IS MOST RECENT OCCURRENCE, WITH ONLY ONE EVENT ON THAT DATE. IT ALSO OCCURRED ON 2/19/06, MANY TIMES IN 01/06, A FEW TIMES IN 12/05, AND SEVERAL TIMES IN 12/04, 01/05, AND 02/05. IT DID NOT HAPPEN WHEN I BOUGHT THE CAR IN 02/04 - BUT THAT WAS A MUCH MILDER WINTER THAN YEARS THAT FOLLOWED. TREATMENT OF GASOLINE WITH "HEAT" DOES NOT SOLVE. CAR RUNS LIKE A DREAM WHEN WARMER WEATHER - UTTERLY INCONVENIENT AND...

2004 SATURN ION NO CRANK AND NO START WHEN THE OUTSIDE TEMPERATURE IS COLD. LOTS OF COMPLAINTS ON THE WEB. LOTS OF IONS HAVE THIS ISSUE. *JB

DT: THE TURN SIGNALS WORKED INTERMITTENTLY. ALSO, THEE CAR WOULD NOT START. THE VEHICLE STARTED AFTER MULTIPLE ATTEMPTS OF TURNING THE KEY IN THE IGNITION. THE VEHICLE WAS TAKEN TO A DEALER, WHO REPAIRED THE PROBLEM. THEY WERE AWARE OF AN ONGOING ISSUE WITH THE IGNITION. THE TURN SIGNALS WERE REPAIRED UNDER A RECALL. SINCE THEN THERE WAS ONE INCIDENT WHERE THEY DID NOT WORK PROPERLY. THE CONSUMER FELT THEY DID NOT COMPLETE THE REPAIR. THERE WAS A TSB ON THE ISSUE THAT THE DEALER USED TO CORRECT IT. THESE PROBLEMS BEGAN IN DECEMBER 2004, AND WERE THOUGHT TO BE CORRECTED BY THE DEALER. LAST WEEK AFTER FILLING THE GAS TANK UP THE VEHICLE WOULD NOT START. THE CONTACT MADE SEVERAL ATTEMPTS TO START THE VEHICLE AND WAS UNSUCCESSFUL. THE CONTACT'S HUSBAND CAME AND TURNED THE KEY IN THE IGNITION AND THE VEHICLE STARTED. THE VEHICLE WAS NOT RETURNED TO...

2004 SATURN ION SUDDENLY STALLED WHILE DRIVING WITH MY FAMILY. THIS HAPPENED ON 8/5/05 AND 8/20/05. EVERYTHING DIED FOR NO APPARENT REASON, WHICH MADE IT DIFFICULT TO MANEUVER THE VEHICLE WITHOUT POWER STEERING IN TRAFFIC. WHEN I CAME TO A SAFE STOP WITH THE STALLED VEHICLE I PULLED OUT THE IGNITION KEY AND RE-ENTERED IT. THE CAR THEN STARTED JUST FINE AND THERE WERE NO STALLING ISSUES SINCE THEN. THE PROBLEM I FORESEE IS THE FACT THAT SOMEONE COULD GET HURT AND GET IN A SERIOUS ACCIDENT WHILE TRYING TO CONTROL A VEHICLE WITHOUT POWER IN TRAFFIC. ALSO, AS A REACTION TO THE ENGINE STALL, SOMEONE MIGHT TRY TO REMOVE THE IGNITION KEY WHILE IN MOTION AND ACCIDENTALLY LOCK THE STEERING WHEEL, WHICH COULD BE LETHAL. I ALSO FIND IT IRRITATING THAT YOU WOULD NOT EXPECT A 10 MONTH OLD CAR WITH APPROX. 8000 MILES ON THE ODOMETER TO STALL...

WHILE DRIVING MY 2004 SATURN ION, IT DIES FOR NO REASON. THERE ARE NO CONSISTENCIES TO THE PROBLEM. IT HAS HAPPEN APPROXIMATELY 25 TIMES OVER THE LAST 6 MONTHS. I WILL BE TAKING IT BACK TO THE DEALERSHIP FOR THE 4TH TIME THIS EVENING. THE DEALERSHIP CLAIMS THAT THEY CANNOT DUPLICATE THE PROBLEM AND CANNOT FIND THE SOURCE OF THE PROBLEM TO FIX IT. THE PROBLEM HAS OCCURRED ON THE HIGHWAY IN TRAFFIC. I COULD BE IN A SERIOUS ACCIDENT AND HAVE INDICATED TO THE DEALERSHIP AND SATURN CORPORATION THAT I FEEL I AM DRIVING AN UNSAFE CAR. THEY HAVE NO SOLUTION FOR THE PROBLEM. *NM

DT: CAR STALLS WITHOUT WARNING WHILE DRIVING AND WHEN TURN THE CAR OFF, IT WILL NOT TURN BACK ON. DEALER SAID THEY COULD NOT FIND THE CAUSE OF THE PROBLEM. MANUFACTURER SAID THEY CANT HELP CALLER.*AK

3 DAYS IN A ROW 2004 SATURN ION 2 WON'T START. AFTER WAITING 10 MIN I TRIED AGAIN AND IT STARTED. THIS ONLY HAPPENS WHEN IT IS COLD OUR TEMP.HAVE BEEN AVERAGING -4 TO 13 DEGRESS.WILL BE GOING INTO THE DEALERS TUES.THERE SHOULD BE A RECALL ON THE PASS LOCK SENSOR SINCE I HAVE READ ON ANOTHER SITE ABOUT ALL THE PROBLEMS THIS IS CAUSING WITH SATURN NOT STARTING. *JB

I LIVE IN THE PITTSBURGH AREA AND HAVE HAD MY ION FOR ALMOST A YEAR AND HAVE NEVER HAD A PROBLEM WITH. THAT IS UNTIL THIS WINTER. 4 TIMES I HAVE CAME OUT OF WORK AT NIGHT ON COLD NIGHTS TO START MY CAR ONLY TO HAVE IT NOT START. AFTER ABOUT 15 - 25 MINUTES OF TRYING MY CAR FINALLY STARTS UP. AFTER I HAVE SAT IN THE COLD. I CAN'T WAIT FOR THE DAY IT DECIDES NOT TO START. ANYWAY I NEVER LEFT ANYTHING ON , NO DOORS WERE LEFT OPEN,NOTHING. I DON'T KNOW IF THIS HAS SOMETHING TO DO WITH THE BATTERY BEING LOCATED IN THE TRUNK OF THE CAR OR NOT. EVERYTHING ELSE IS FINE AND IT RUNS FINE AFTER I DO GET IT TO START. WE ARE EXPECTING SOME COLD DAYS AHEAD WERE IN LIVE IN THE NEXT FEW WEEKS, SO I CAN'T WAIT TO...

THIS HAS HAPPENED TWICE. MY PARENTS BOUGHT A SATURN ION 2, IT IS ONLY ABOUT 6 MONTHS OLD. AFTER DRIVING THE CAR TO THEIR LOCATION AND TURNING IT OFF, THEY CAME BACK TO THE CAR (MAYBE 2 HOURS LATER), TO START THE CAR AND NOTHING WOULD HAPPEN. THE FIRST TIME THIS HAPPENED, THEY CALLED THE DEALERSHIP AND WAS TOLD TO PUSH THE UNLOCK BUTTON SEVERAL TIMES ON THE REMOTE. AFTER ABOUT 20 PUSHES THE CAR WAS FINIALLY ABLE TO BE STARTED. THEY BROUGHT THE CAR TO THE PLACE WHERE IT WAS PURCHASED ONLY TO HAVE SOMEONE TELL THEM THEY DON'T SEE ANYTHING WRONG AND DON'T KNOW WHY IT DID NOT START. ABOUT 1 MONTH LATER THE SAME THING HAPPENED AGAIN, THEY CALLED THE DEALERSHIP, SPOKE WITH SOMEONE IN THE SHOP AREA AND WAS TOLD THEY COULDN'T HELP THEM OUT BUT IF THEY BROUGHT THE CAR INTO THE SHOP, IT WOULD...