2004 SATURN ION Exterior Lighting Problems

TOOK MY VEHICLE FOR INSPECTION IT PASSED SAFETY AND FAILED EMISSIONS ! THERE IS NO ENGINE CHECK LIGHT ON

STRONG GAS SMELL & STARTED NOTICING POOR GAS MILEAGE AND IT GOT WORSE. THEN NOTICE IT IS LEAKING GAS BY THE REAR DRIVER SIDE TIRE. ALSO THE RUNNING LIGHTS AUTOMATICALLY COME ON DURING THE DAY BUT NOT AT NIGHT.

THE FRONT DRIVERS SIDE EXTERIOR TURN SIGNAL LIGHT STOP FUNCTIONING ABOUT 2 MONTHS OR SO AFTER THE BULB WAS REPLACED, NOW IT DOESN'T WORK AT ALL. THE PANEL INSIDE THE CAR HAD SHOWN ME THAT SAME TURN SIGNAL LIGHT HAD BEEN MALFUNCTIONING FOR SOME TIME BLINKING EXTREMELY FAST BACK TO NORMAL UNTIL IT FINALLY NEEDED TO BE REPLACED. I CAN'T GET MY SAFETY CHECK DONE BECAUSE THE TURN SIGNAL LAMP IS INOPERATIVE. I WONDER IF A DRL JUMPER KIT NEEDS TO BE ADDED, CAN YOU PLEASE DIRECT ME? THE CAR WAS IN MOTION MAKING A LEFT TURN ON THE HIGHWAY.

WHILE DRIVING IN PRE-DAWN HOURS (HEADLIGHTS & DEFROSTERS ON), STARTED SMELLING SOMETHING MELTING OR BURNING. THEN INSTRUMENT PANEL LIGHTS WENT OUT FOR A FEW SECONDS. INSTRUMENT PANEL LIGHTS THEN CAME BACK ON & STARTED FLASHING ON & OFF REALLY FAST. AT THAT SAME TIME, DOOR LOCKS STARTED LOCKING & UNLOCKING REPEATEDLY ON THEIR OWN. BURNING & MELTING SMELL WAS GETTING STRONGER. AS I WAS PULLING OVER, I ENTERED A MORE WELL-LIT AREA AND SAW SMOKE ACCUMULATING INSIDE CAR NEAR ROOF & TOP OF WINDSHIELD. SHUT CAR OFF IMMEDIATELY. *TR

WHEN I START MY CAR I GET A MESSAGE THAT DAYS POWER STEERING SERVICE VEHICLE. THAT I LOOSE ALL DASH LIGHTS OCCASIONALLY RADIO AND AIR I DO NOT REGAIN POWER STEERING OR LIGHTS FOR ABOUT 5-10 MINUTES. I CAN HEAR A CHANGE IN THE ENGINE WHEN IT IS REGAINED. ONCE IT'S DONE I CAN DRIVE PERFECTLY NORMAL. MY CHECK ENGINE LIGHT IS ON AND OFF. WHEN I TURN MY CAR OFF THE LIGHTS ARE THERE DURING THE FIT AND OFF WHEN THE CAR IS ON. ALL THE CODES THROWN ARE ELECTRICAL. HELP! *TR

I WAS DRIVING AT NIGHT ON A COUNTRY ROAD WHEN A DEER RAN OUT IN FRONT OF ME AND THE CAR STRUCK IT. THE CAR SUSTAINED SOME FRONT END DAMAGE AND THE CABIN FILLED WITH SMOKE. THE SEAT-BELTS LOCKED UP BUT THE AIRBAGS NEVER DEPLOYED. NOW THE AIRBAG LIGHT IS ON AND THE SEAT-BELTS ARE LOCKED UP. IT CONCERNS ME THAT WITH EVERYTHING THAT HAPPENED THAT THE AIRBAG SHOULD HAVE WHEN OFF. *TR

WHEN I TURN MY CAR ON THE PARKING LIGHTS AND FRONT TURN SIGNALS STARTING BLINKING REALLY QUICK LIKE STROBING. I CAN TURN MY LEFT TURN SIGNAL ON AND IT WILL BLINK INSIDE HEARING THE NORMAL TICKING. IF I TURN MY RIGHT TURN SIGNAL ON IT THE ARROW ON THE INSIDE BLINKS SLOWER AND MAKES NO TICKING SOUND.IF I PUSH ON MY BRAKE THE LIGHT WORK PROBABLY AND THE TICKING SOUND ON THE RIGHT TURN SIGNAL INSIDE STARTS. IF I PUT MY EMERGENCY BRAKE ON IT WORKS PROPERLY. THE STROBING OF THE FRONT OUTSIDE PARKING LIGHTS STOP. IF I TURN MY PARKING LIGHT ON AND DRIVE WITH THEM ON EVERYTHING WORKS PROPERLY. I KNOW THIS HAS SOMETHING TO DO WITH THE RECALL. IT IS EFFECTING MY CAR SO BAD THAT MY RADIO DISPLAY LIGHT BLINKS ALSO. SO IT IS GETTING FEEDBACK FROM THIS PROBLEM BEFORE I HAVE A WRECK. I AM...

PASSENGER SIDE FRONT TURN SIGNAL STOPS WORKING FOR A WEEK, THEN WORKS, THEN QUITS AGAIN FOR A FEW DAYS AND THEN WORKS AGAIN. SATURN DEALER SAYS THIS VEHICLE IS NOT INCLUDED ON THE RECALL - IT APPEARS TO BE THE SAME PROBLEM AS RECALL CAMPAIGN 04V657000 - NHTSA ACTION NUMBER PE04061. THEY SAID ANY REVIEW/REPAIR WOULD BE AT MY EXPENSE. *TR

IN 2005 A RECALL WAS ISSUED FOR THE 2004 SATURN ION FRONT HEADLAMPS. I HAD THE RECALLED PARTS REPLACED. FOR THE PAST FEW MONTHS MY LEFT BLINKER HAS GONE OUT ABOUT FIVE TIMES. I HAVE REPLACED BULBS, HAD THE DEALER REPLACE THE SOCKETS, AND AM NOW ABOUT TO HAVE THE WIRING HARNESS REPLACED. THE DEALER SAID THAT NO ONE ELSE HAS HAD THIS PROBLEM. HOWEVER, I HAVE BEEN RESEARCHING THE PROBLEM AND HAVE FOUND HUNDREDS OF THE SAME OCCURRENCES ONLINE AND HAVE SEEN OTHER SATURN IONS AROUND TOWN WITH THE SAME BLINKER OUT. I BELIEVE THIS PROBLEM IS NOT NORMAL WEAR AND TEAR. I BELIEVE IT IS DIRECTLY RELATED TO THE 2005 RECALL. *TR

BY 3500 MILES (AFTER 1500MI WHEN WE COULD HAVE RETURNED IT), THE FRONT PASSENGER TURN SIGNAL BURNT OUT. THE CAR WAS ALSO SPUTTERING WHEN WE STARTED THE ENGINE. THE MECHANIC FOUND A CRACKED HEAD, THAT WE WERE TOLD WAS PROBABLY PRESENT WHEN WE PURCHASED THE CAR; HAD WE KNOWN WE WOULD'VE RETURNED THE CAR. WE WERE GIVEN A RENTAL CAR, BUT HAD TO DRIVE 45 MIN ONE WAY TO GET TO SATURN OF GREEN BAY. WITHIN A MONTH, THE FRONT DRIVER TURN SIGNAL HAD BURNT OUT. THE WIRING WAS REPLACED WHILE WE WAITED 2 HRS WITH OUR 3 YEAR OLD. WE HAD TO DRIVE 1 HR 1WAY TO SATURN OF APPLETON FOR REPAIRS. IN AUG 2004, THE CAR WAS MAKING A NOISE WHEN WE TURNED ONTO A STEEP GRADE. IN MI FOR VACATION, WE HAD TO DRIVE OVER 1 HR 1WAY TO SATURN OF TROY; THE SWAYBAR AND MOUNTING BRACKETS...