2004 SATURN ION Electrical System Problems

TOOK MY SATURN IN YESTERDAY FOR THE RECALL ON THE IGNITION SWITCH-GOT A PHONE CALL FROM THE DEALER SAYING THAT THE HOUSING FOR THE SWITCH ALSO NEEDS REPLACING, BUT GM WILL NOT COVER IT AND I NEED TO PAY FOR THAT PART AND THE LABOR. THE SWITCH CAN NOT BE REPLACED UNLESS THIS HOUSING IS REPLACED, BUT NOW THEY WANT ME TO PAY FOR IT EVEN THOUGH THE RECALL SAYS THIS SHOULD BE AT NO COST TO ME. I CALLED GM AND THEY ARE SAYING THAT THE HOUSING IS NOT COVERED IN THE RECALL. ACCORDING TO THE RECALL INFORMATION, I SHOULD BE ABLE TO GET REIMBURSED FOR HAVING TO REPLACE THE SWITCH, BUT FIRST I HAD TO REPLACE IT AGAIN, WHICH IS WHAT I WAS TRYING TO DO. WHAT CAN I DO ABOUT THIS? IT DOES NOT MAKE SINCE TO ME. HAVE ME DO THE RECALL AND THEN ATTACH A...

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED SHE HAD HER VEHICLE SERVICED UNDER NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM) AND NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE CONTACT MENTIONED THAT WHEN SHE CAME TO PICK UP THE VEHICLE THE EXHAUST PIPE WAS VISIBLY ON THE FLOOR. THE CONTACT IMMEDIATELY INFORMED THE SERVICE MANAGER SINCE THE VEHICLE WAS NOT IN THAT CONDITION PRIOR TO THE REPAIRS. THE SERVICE MANAGER AGREED TO REPAIR THE FAILURE BY REATTACHING ONE SIDE OF THE EXHAUST PIPE WITH A WIRE HANGER. THE CONTACT RELUCTANTLY TOOK THE VEHICLE HOME AND WHILE ON THE WAY HOME THE AIR BAG, ALTERNATOR AND BATTERY LIGHT ILLUMINATED ON THE INSTRUMENTAL PANEL. SHORTLY AFTER THE LIGHTS ILLUMINATED, THE VEHICLE STALLED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 127,000.

LETTER FROM SENATOR NELSON ON BEHALF OF CONSTITUENT RE HIS MOTHER'S SATURN ION THAT HAS BEEN RECALLED, DUE TO IGNITION SWITCH DEFAULT. *SMD THE CONSUMER WAS INFORMED, THE PARTS WERE NOT AVAILABLE. THE CONSUMER WAS GETTING THE RUN-AROUND REGARDING THE AVAILABILITY OF PARTS. *JB

2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE INFORMATION. *SMD THE CONSUMER WAS INFORMED, THE PARTS WERE NOT AVAILABLE. *JB

2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE AND REQUESTS REIMBURSEMENT FOR REPAIRS. *SMD THE CONSUMER STATED HE/SHE EXPERIENCED ISSUES WITH THE VEHICLE, PRIOR TO THE RECALL BEING ISSUED, BUT WAS ALWAYS TOLD THE VEHICLE WAS NOT UNDER WARRANTY. THE CONSUMER WAS ALMOST INVOLVED IN SEVERAL ACCIDENTS, DUE TO THE DEFECT. THE IGNITION SWITCH WAS EVENTUALLY REPLACED. *JB

2004 SATURN ION. CONSUMER REQUESTS REIMBURSEMENT FOR REPAIRS. *SMD ACCORDING TO THE INVOICE, THE IGNITION CYLINDER WAS REPLACED. *JB

I AM VERY FRUSTRATED AT THE PACE OF THE RECALL FOR THE SATURN ION, RECALLS 14V047 AND 14V171. I'VE CONTACTED THE LOCAL DEALER SEVERAL TIMES AND CALLED THE GM CUSTOMER ASSISTANCE LINE WITH NO SATISFACTION. THERE HAVE BEEN NO PARTS AVAILABLE FOR MONTHS AND I'VE BEEN TOLD THAT THERE IS A POSSIBILITY THAT SOME MIGHT BE AVAILABLE IN 4 WEEKS. THIS IS NOT SATISFACTORY. *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT RECEIVED THE RECALL NOTIFICATION RELATED TO NHTSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE CONTACT STATED THAT THE REPAIR WAS NOT TAKEN CARE OF IN A REASONABLE AMOUNT OF TIME. THE DEALER INDICATED THAT THE PARTS WERE NOT AVAILABLE. CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER HAD NOT BEEN CONTACTED.

TL * THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE WOULD MAKE A LOUD NOISE WHENEVER SHE MADE A TURN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE RACK AND PINION NEEDED TO BE REPLACED. IN ADDITION, THE CONTACT STATED THAT THE WINDSHIELD WIPER MALFUNCTIONED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 89,000 AND THE CURRENT MILEAGE WAS 89,447. UPDATED 08/19/14*LJ THE CONSUMER STATED SHORTLY AFTER PICKING THE VEHICLE UP FROM THE DEALER, THEY KEY BECAME STUCK IN THE IGNITION AND THE VEHICLE WOULD NOT TURN OFF ALL OF THE ELECTRICAL SWITCHES STARTED GOING HAYWIRE , ALONG WITH DIFFERENT WARNING SIGNS.. THE CONSUMER RETURNED TO THE DEALER, WHERE AN INSPECTION REVEALED THE SOLENOID WAS DAMAGED. A MONTH PRIOR, THE IGNITION SWITCH WAS REPLACED. ALSO, WHEN THE CONSUMERS SON ATTEMPTED TO...

AROUND '06, THE KEY STARTED STICKING AND YOU COULD NOT EITHER START THE CAR (I'VE HAD SEVERAL TOWS), OR COULD NOT GET THE KEY OUT OF THE CAR (IT WAS STUCK ON LOCKED). I GOT IT FIXED ON 2/13 07 WITH A NEW IGNITION SWITCH AT A SATURN DEALER. IT NEVER REALLY WORKED CORRECTLY. IT KEPT DOING THE SAME THING, SO I TOOK IT INTO THE DEALER IN MAY OF 2012. THEY PUT IN A "BCM"?? AND REPROGRAMMED. STILL DID THE SAME THING. THEN A FEW MONTHS AGO, I HEARD ABOUT THE RECALL PROGRAM. I GOT MY CAR FIXED FOR THE RECALL ON 4/15/14. MY CLAIM FOR PAYING $700 IN MAY OF 2012 WAS DENIED. MY CAR STILL STICKS WHEN TRYING TO START, OR TRYING TO GET THE KEY OUT OF THE IGNITION. I THINK THIS WHOLE THING IS YOUR FAULT. I WANT TO BE REIMBURSED FOR THE $700 I...

MY SATURN HAS HAD PROBLEMS WITH THE A/C UNIT THE DIAL HAS GOTTEN TO WERE IT WON'T WORK AND THE DEFROST DOESN'T WORK. IT HAS BEEN LIKE THAT FOR ABOUT 7 YRS. MY HAS CAR HAS CUT OFF ON ME TWICE. ONCE THIS YEAR AND LAST YEAR. NOW THE MOST RECENT ONE WAS ON APRIL 25 2014. IT WAS AROUND 3:30 PM. HERE IN RICHMOND VA IT WAS A REALLY BAD THUNDER AND LIGHTING STORM. I STARTED TO SMELL A BURNING SMELL, THE BRAKES WERE ACTING STRANGE I WAS ABLE TO STOP AT STOP LIGHT AND WHILE I WAS A RED LIGHT I HEARD A HIGH PITCHED BEEPING SOUND AND THE WARNING LIGHTS CAME ON. MY CAR WAS TOWED. AND THE HENRICO COUNTY BEAT AAA TO PULL IT TO ROYAL CHEVY. THE COPS HAD MY PLACED AT IMPOUND LOT. AND I FINALLY DID IT TOWED TO ROYAL CHEVY ON APRIL...

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT AFTER HAVING REPAIRS PERFORMED FOR NHTSA CAMPAIGN NUMBER: 14V171000 (ELECTRICAL SYSTEM), THE VEHICLE FAILED TO START AND AFTER NUMEROUS ATTEMPTS, THE VEHICLE WAS ABLE TO START. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE VEHICLE STALLED THREE TIMES AND THE BATTERY LIGHT, THE OIL PRESSURE, THE AIR BAG AND THE POWER STEERING WARNING LIGHT ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS UNKNOWN.

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE KEY BECAME LODGED IN THE IGTION SWITCH AND WAS UNABLE TO RELEASE. THE CONTACT MENTIONED THAT THE VEHICLE WAS REPAIRED UNDER RECALL NHTSA CAMPAIGN NUMBER 14V171000 (ELECTRICAL SYSTEM); HOWEVER, THE REMEDY FAILED TO REPAIRED THE PROBLEM. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 126,184.

I RECEIVED RECALLS BEGINNING IN APRIL 2014 REGARDING THE IGNITION SWITCH, THEN ONE REGARDING THE IGNITION CYLINDER. BOTH RECALLS HAVE CAUSED INJURY OR DEATH. I NOW UNDERSTAND THAT THERE IS ALSO A RECALL ON THE POWER STEERING. (3 OPEN RECALLS IN ALL) I CONTACTED MY LOCAL CHEVROLET DEALER AS INSTRUCTED ON APRIL 18TH AND HAVE BEEN BACK AND FORTH WITH BOTH THE DEALERSHIP AND SATURN CUSTOMER ASSISTANCE @ 800-553-6000. I WAS ISSUED A CASE# 71-1300074576 BUT MY FAMILY IS STILL DRIVING THE CAR. WE DON'T FEEL SAFE DRIVING THE CAR BUT WAS TOLD THAT THERE WAS NO ROOM TO LEAVE IT AT THE DEALERSHIP SO I HAVE TO WAIT UNTIL JUNE. THIS IS UNACCEPTABLE! I UNDERSTAND THAT A LOANER CAN BE PROVIDED. I WANT TO DROP THE CAR OFF SOMEWHERE AND PICK UP A SAFE VEHICLE FOR MY FAMILY TO DRIVE UNTIL THE REPAIRS CAN BE MADE. *TR

WHEN I START MY CAR I GET A MESSAGE THAT DAYS POWER STEERING SERVICE VEHICLE. THAT I LOOSE ALL DASH LIGHTS OCCASIONALLY RADIO AND AIR I DO NOT REGAIN POWER STEERING OR LIGHTS FOR ABOUT 5-10 MINUTES. I CAN HEAR A CHANGE IN THE ENGINE WHEN IT IS REGAINED. ONCE IT'S DONE I CAN DRIVE PERFECTLY NORMAL. MY CHECK ENGINE LIGHT IS ON AND OFF. WHEN I TURN MY CAR OFF THE LIGHTS ARE THERE DURING THE FIT AND OFF WHEN THE CAR IS ON. ALL THE CODES THROWN ARE ELECTRICAL. HELP! *TR

DRIVING ON THE FLORIDA TURNPIKE NORTHBOUND ON MY WAY TO WORK ON MAY 6, 2014, GOING ABOUT 55 MPH, WHEN THE CAR TURNED OFF WHILE IN THE CENTER LANE. I HAD FOLLOWED ALL THE PROCEDURES THAT GM INSTRUCTED FOR RECALL #14V-047 USING THE KEY WITHOUT RING OUR ADDITIONAL KEYS. I HAVE BEEN DEALING WITH THIS ISSUE SINCE THE DAY OF PURCHASE BACK IN 2007. I HAVE PRESENTED THIS ISSUE TO THE DEALER NUMEROUS TIMES. FORTUNATELY, I WAS ABLE TO STOP THE CAR SAFELY, REMOVE THE KEY, PLACED IT BACK IN THE IGNITION AND THE CAR STARTED.

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBER: 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND STATED THAT THE REPAIR WAS NOT TAKEN CARE OF IN A REASONABLE AMOUNT OF TIME. THE DEALER INDICATED THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER HAD NOT BEEN CONTACTED. KMJ

2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH PROBLEMS. *SMD THE CONSUMER STATED HIS VEHICLE FLIPPED TWO TIMES AND SLID SEVERAL FEET. THE KEY WAS TOWED A JUNK YARD, WHERE THE KEY WAS STILL STUCK IN THE IGNITION. THE VEHICLE WAS TOTALED. THE CONSUMER SUFFERED SERIOUS INJURIES. *JB

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT RECEIVED A NOTICE FOR NHTSA CAMPAIGN NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM) AND WAS INFORMED THAT THE PARTS WERE NOT AVAILABLE. THE CONTACT FELT THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE TIME FOR REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. THE MANUFACTURER WAS NOT CONTACTED.

2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE. *SMD THE CONSUMER STATED AFTER SEVERAL YEARS OF EXPERIENCING PROBLEMS WITH THE VEHICLE. SHE WAS FORCED TO FIGURE OUT AND PAY FOR THE PROBLEM ON HER OWN. *JB

SHORTLY AFTER STARTING ON A VERY COLD WINTER DAY, AT LOW SPEED AND WITH THE BATTERY LIKELY LOW FROM STARTING THE CAR THE POWER STEERING WARNING CHIMED AND THE CAR BECAME VERY DIFFICULT TO CONTROL. THE PROBLEM HAS NOT RECURRED SINCE THEN (EVEN A FEW HOURS LATER WITH THE CAR WARMED UP AND BATTERY FULLY CHARGED), BUT THE TEMPERATURE HAS BEEN SIGNIFICANTLY HIGHER AND I REPLACED THE BATTERY WITH A BETTER ONE. THE BATTERY HAD TESTED GOOD AT THE LAST OIL CHANGE/SERVICE/INSPECTION, BUT WAS NEAR THE END OF ITS LIFE EXPECTANCY. *TR

I WAS DRIVING ON DRY ROADS DURING THE DAYTIME BELOW THE SPEED LIMIT, WHEN THE POWER STEERING LIGHT CAME ON. THE WHEEL LOCKED, AND I WAS UNABLE TO STEER THE CAR. I PULLED TO THE SIDE OF THE ROAD AND TURNED THE CAR OFF AND BACK ON. IT RESTARTED WITHOUT INCIDENT. 3 YEARS LATER, THE SAME EVENT OCCURRED WITHOUT CAUSING AN ACCIDENT. *TR

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

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN ID NUMBERS: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM) AND14V171000 (ELECTRICAL SYSTEM) BUT WAS ADVISED BY THE DEALER THAT THE PART NEEDED TO COMPLETE THE REPAIR WAS NOT AVAILABLE. THE CONTACT RECEIVED TWO SEPARATE RECALL NOTICES AND HAD STILL BEEN WAITING FOR THE RECALL REPAIRS. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE A REASONABLE TIME FRAME FOR WHEN THE VEHICLE WOULD RECEIVE THE RECALL REPAIRS. THE CONTACT HAD NOT EXPERIENCED A FAILURE.

2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE ISSUES, AIR BAG MALFUNCTION AND SEVERAL OTHER VEHICLE PROBLEMS. *SMD THE CONSUMER STATED HER DAUGHTER WAS INVOLVED IN 3 ACCIDENTS. HER DAUGHTER LOST POWER AND THE VEHICLE STALLED. WHEN HER DAUGHTER HIT THE OTHER VEHICLE, THE AIR BAGS DID NOT DEPLOY. HER DAUGHTER WAS INJURED. ALSO, THE CONSUMER HAD DIFFICULTY STEERING THE VEHICLE. *JB

2004 SATURN ION. CONSUMER WRITES IN REGARDS TO FAULTY IGNITION PROBLEMS. *SMD THE CONSUMER STATED HE EXPERIENCED NUMEROUS PROBLEMS WITH THE IGNITION, IN THE 3 YEARS HE HAS OWNED THE VEHICLE. ON SEVERAL OCCASIONS, THE VEHICLE WOULD NOT START. THE DEALER WOULD ALWAYS CLAIM, THERE WAS NOTHING WRONG WITH THE PASSLOCK SYSTEM. *JB

2004 SATURN ION. CONSUMER WRITES IN REGARDS TO IGNITION SWITCH RECALL NOTICE ISSUES. *SMD THE CONSUMER STATED THE VEHICLE WOULD NOT START. THE PROBLEM HAS BEEN GOING ON FOR YEARS. ACCORDING TO THE LATEST INVOICE, THE TECHNICIAN FOUND THE KEY BINDING IN THE HOUSING. THE IGNITION CYLINDER WAS REPLACED. THE BATTERY WAS REPLACED 3 TIMES. *JB

IN DEC. 2011, THE CAR WOULD NOT TURN ON AND I PAID $280 FOR A REPLACEMENT IGNITION SWITCH. I HAVE NO IDEA IF THEY USED ANOTHER FAULTY SWITCH THAT IS NOW THE SUBJECT OF THE CURRENT RECALL. IN CONCERN FOR MY SAFETY, I AM USING A SINGLE KEY, AS GM INSTRUCTED, AND WAITING FOR THE DEALER TO GET THE PART TO REPLACE THE IGNITION SWITCH. SUPPOSEDLY, IT WILL HAPPEN THIS MONTH - APRIL. ALSO IN 2011 (OR MAYBE THE BEGINNING OF 2012) I EXPERIENCED THE INTERMITTENT LOSS OF THE POWER STEERING. THAT WAS PAID FOR BY GM BUT, AGAIN, NOW I HAVE NO IDEA IF THEY PUT IN ANOTHER FAULTY POWER STEERING COLUMN THAT IS THE SUBJECT OF TODAY'S RECALL. WHEN I CALLED GM TODAY, THEY SAID THAT LAST POWER STEERING REPLACEMENT WAS NOT A RECALL, IT WAS A SPECIAL SAFETY ISSUE #10187. I ASKED IF THE INCENTIVE TO TRADE...

MY CAR STARTED NOT STARTING UP AT ALL. IT WOULD TAKE ABOUT 20 MINUTES TO START MY CAR AND THE IGNITION WOULD BE HARD TO TURN, AND A JUMP WOULD NOT WORK. I WOULD HAVE TO GO OUT AND START MY CAR 30 MINUTES BEFORE I HAD TO LEAVE FOR WORK AND LET IT RUN. I TOOK MY CAR TO A MECHANIC TO CHANGE MY OIL AND IT WOULD NOT START. THEY TRIED TO GIVE ME A JUMP AND I TOLD THEM THAT DO NOT WORK AND EXPLAIN WHAT IT DOES ALL THE TIME AND THE OWNER CHECK HIS COMPUTER UNDER THE SAFETY RECALLS AND HE TOLD ME THAT IT WAS A RECALL ON MY IGNITION, SO I TOOK MY CAR TO A SATURN DEALER "THIS WAS IN 2010" AND I TOLD THEM WHAT WAS TOLD TO ME AND THEY TOLD ME THAT THERE WAS NOT ANY RECALLS FOR MY...

THE CAR WOULD NOT TURN OVER, I CALLED ROAD SIDE IN HOPES THAT THE BATTERY JUST NEEDED A JUMP, BUT WHEN THEY ARRIVED I FOUND OUT THAT THE CAR WAS NOT TURNING OVER BECAUSE OF ANOTHER REASON. MY FRIENDS CAME OVER AND WE POPPED THE CLUTCH AND DROVE IT TO A CAR REPAIR SHOP TO HAVE THEM TAKE A LOOK, I WAS THINKING EITHER THE STARTER OR THE ALTERNATOR. HE CALLED ME LAST NIGHT TO TELL ME TO CONTACT GM ABOUT THE RECALL ON THE IGNITION. THE IGNITION IS BAD AND WILL NOT TURN THE CAR OVER. *TR

THEY KEY GETS STUCK IN THE IGNITION AND SOMETIMES I CANT PUT THE KEY IN THE IGNITION. MANY TIMES IF I CAN GET THE KEY IN AND TRY TO START IT THEN IT DOES NOTHING. I HAD THE CAR TOWED HOME AND THAT IS WHERE IT IS STILL SITTING IN MY DRIVEWAY UNABLE TO START?? I WOULD LIKE TO KNOW WHERE TO TAKE MY CAR FOR THE RECALL REPAIRS, IS TOWING ALSO INCLUDED I DON'T HAVE THE MONEY TO KEEP PAYING TO HAVE THE CAR TOWED. *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE VEHICLE HAD MULTIPLE FAILURES. THE STEERING WAS ROUGH AND THE TRANSMISSION WAS CAUSING THE VEHICLE TO MAKE LOUD NOISES WHEN THE WHEELS WERE TURNED LEFT OR RIGHT. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER:14V047000 (AIR BAGS, ELECTRICAL SYSTEM) HOWEVER THE DEALER STATED THAT THE PARTS WOULD BECOME AVAILABLE MID APRIL. THE MANUFACTURER WAS ALSO CONTACTED AND COULD NOT PROVIDE AN ESTIMATED DATE FOR WHEN THE CONTACT'S VEHICLE WOULD RECEIVE THE RECALL REPAIRS. AN AUTHORIZED DEALER WILL INSPECT THE TRANSMISSION AND STEERING FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 175. THE MILEAGE OF 175 WAS REAFFIRMED BY THE CONTACT. UPDATED 05/28/14 MA THE CONSUMER STATED THE VEHICLE BEGAN HAVING ISSUES 2 WEEKS AFTER IT WAS PURCHASED. THE VEHICLE WOULDNT START, IT HAD HIGH IDLING PROBLEMS, AND MOST RECENTLY THE STEERING COLUMN FAILURE....

CAMPAIGN ID #14V-047 GM CASE#[XXX] RE: IGNITION SWITCH RECALL I WAS OFFERED A RENTAL CAR BUT GM IS NOT REIMBURSING THE COST OF INSURANCE FOR THE RENTAL. I CANNOT AFFORD NOR HAVE THE TIME TO ARGUE MY CASE WITH GM. THIS IS GM'S FAULT, THEY SHOULD BE REIMBURSING ALL COSTS INCURRED BY THIS RECALL. PLEASE ASSIST ME. I DO NOT WANT TO HAVE TO RETAIN AN ATTORNEY FOR THIS. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

THIS ISSUE HAS BEEN A LONG ONGOING PROBLEM FOR ME, WITH THIS CAR. I DO NOT KNOW THE ACTUAL DATES OF THE OCCURRENCES BUT IT HAS BEEN FREQUENT ENOUGH THAT I HAVE DEVELOPED A METHOD FOR STARTING MY CAR THAT IF I DO NOT FEEL RUSHED, I CAN GET THE CAR TO START MOST EVERY TIME. IF THE KEY IS INSERTED INTO THE IGNITION AND IMMEDIATELY TURNED TO THE FULL ON POSITING IN AN ATTEMPT TO START THE CAR, IT WILL, ON OCCASION, TURN OVER ONCE AND THEN GO COMPLETELY DEAD. IF THE ATTEMPT IS REPEATED, THE AUXILIARY LIGHTS WILL COME ON BUT THE ENGINE WILL NOT TURN OVER. I HAD MY CAR TOWED TO A GARAGE AND REPLACED THE BATTERY, TWO DIFFERENT TIMES BEFORE READING ABOUT A POTENTIAL PASSLOCK ISSUE WITH SATURNS. WHEN I DO HAVE THE PROBLEM NOW, I HAVE FOUND THAT WAITING ROUGHLY 8 MINUTES(10 MINUTES TO...

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT WHEN ATTEMPTING TO DRIVE THE VEHICLE, IT WOULD NOT START ON MULTIPLE OCCASIONS. THE CONTACT WAITED FOR A BRIEF MOMENT AND THE VEHICLE WAS ABLE TO RESTART. THE VEHICLE WOULD NOT START AT RANDOM. THE BATTERY WAS REPLACED DUE TO THE IGNITION PROBLEM WITH THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO A DEALER TO DIAGNOSE THE PROBLEM. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT WAS INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 14V047000 (AIR BAGS AND ELECTRICAL SYSTEM) AFTER THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 55000.

AS I WAS COMING UP TO A TRAFFIC CIRCLE, MY GEARS LOCKED UP AND POWER STEERING WENT OUT, RESULTING IN A CRASH INTO THE TRAFFIC CIRCLE MEDIAN, TOTALING THE FRONT OF MY VEHICLE. VEHICLE IS STILL IN THE SHOP AWAITING MAINTENANCE. *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED WHILE DRIVING 65 MPH, THE STEERING WHEEL BECAME DIFFICULT TO MOVE AND THE VEHICLE STALLED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE DEALER ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 14V047000 (AIR BAGS , ELECTRICAL SYSTEM). THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 3,000 AND THE CURRENT MILEAGE WAS 50,000. *TR

WHILE DRIVING IN HEAVY TRAFFIC ON RT 95 CAR STALLED AND IT TOOK A FEW MINUTES TO RESTART. HAVE A TERRIBLE TIME STARTING THE CAR IN MORNING AND ITS NOT THE BATTERY AS ITS ABOUT YEAR OLD. I THOUGHT IT MIGHT BE THE COLD WEATHER BUT SOMETIMES IT STARTS SOMETIMES IT DOESN'T. I NEVER KNOW WHETHER ITS GOING TO START. WHEN THIS HAPPENS IT SOUNDS DEAD. I THINK THERE IS A PROBLEM WITH THE IGNITION SWITCH. HAVE TALKED TO OTHER SATURN OWNERS WHO HAVE SAME PROBLEM AND THEY SAID A RELAY SWITCH CURED THE PROBLEM. *TR

MY 2004 SATURN ION INTERMITTENTLY WILL NOT RELEASE THE KEY FROM THE ACC POSITION AS WELL AS WHEN TRYING TO START IT THE SECURITY SYSTEM WILL INTERMITTENTLY KEEP THE CAR FROM STARTING, I WILL GO TO START THE VEHICLE AND THEN IT WILL START TO CRANK THEN SHUT DOWN, I HAVE TO WAIT 10 MIN THEN THE CAR WILL START. IT IS STARTING TO HAPPEN MORE FREQUENTLY AND I SEEN THE JUST DID A RECALL ON 2/25/2014 ON IGNITION SWITCHES FOR MY YEAR AND MODEL OF SATURN BUT MY VIN WAS NOT INCLUDED AND I CAN SEE THAT SEVERAL COMPLAINTS HAVE BEEN PUT IN AND THIS IN MANY CASES WAS JUST A START TO WHAT OTHER PEOPLE HAVE INCURRED @ SOME POINT MOST OTHER PEOPLE COMPLAIN EVENTUALLY THEN CANNOT GET THE ENGINE TO STOP RUNNING. I AM TRYING TO FIND OUT WHY MY VIN IS NOT INCLUDED IN THIS RECALL...

IT TURNS OUT SATURN ION IGNITION SWITCHES CAME WITH A FLAW FROM THE FACTORY, EXCESSIVE GREASE WITH POOR COLD WEATHER PERFORMANCE.THE PASSLOCK ISSUE PRESENTS ITSELF AS YOUR CAR SUDDENLY NOT STARTING. SUFFICE IT TO SAY IF THERE'S NO OBVIOUS REASON FOR YOUR VEHICLE TO NOT START, IT'S PROBABLY PASSLOCK RELATED. IF YOU'VE NOTICED THAT WAITING A FEW MINUTES SEEMS TO HELP, THAT'S THE CLINCHER. TEN MINUTES IS THE MAGIC NUMBER, THAT'S WHEN THE COMPUTER RESETS. IF YOU WERE CHARGED FOR A NEW BATTERY, STARTER, IGNITION SWITCH OR A TOW I SUGGEST YOU NOT LET THE ISSUE DROP, IT WASN'T YOUR FAULT OR RESPONSIBILITY. GM SHOULD TAKE RESPONSIBILITY. FORGETTING THE UNPLEASANTNESS OF BEING STRANDED IN 10 MINUTE INCREMENTS (ALSO, THE CAR FAILS TO START SEVERAL TIMES IN A ROW, AS LONG AS 40 MINUTES BEFORE) THIS IS A SAFETY ISSUE THAT SHOULD BE DEALT WITH ACCORDINGLY. CALLING THE PROBLEM A SAFETY...

I WAS DRIVING INTO PARKING LOT AND ELECTRIC POWER STEERING WARNING WITH ALARM CAME ON THE READOUT ON THE DASH. AT THAT TIME IT HAD BECOME NEARLY IMPOSSIBLE TO TURN THE STEERING WHEEL IN ANY DIRECTION. IF ANYONE HAD BEEN CLOSE ENOUGH TO ME THERE WOULD HAVE BEEN A COLLISION. I TURNED THE IGNITION OFF AND THEN ON AGAIN AND THE ELECTRIC STEERING RETURNED. I AM THE ORIGINAL OWNER OF THE VEHICLE AND THIS INCIDENT PUT ME IN A PANIC MODE BECAUSE I AM PHYSICALLY DISABLED WITH DISABILITIES THAT AFFECT MY ARMS AND LEGS. TRYING TO TURN THE STEERING WHEEL WHEN THE ELECTRIC STEERING FAILED CAUSED ME GREAT PAIN. I FEAR THAT IF THIS HAPPENS AGAIN THERE COULD BE A SERIOUS ACCIDENT WITH OTHER VEHICLES OR EVEN SERIOUS INJURIES TO PEDESTRIANS. THERE WAS NO WAY I COULD CONTROL THAT VEHICLE WITHOUT A FULLY FUNCTIONAL ELECTRIC STEERING. I CONSIDER MYSELF LUCKY...

DRIVING ON THE FREEWAY, AT APPROXIMATELY 65 MPH, WHEN A CHIME WENT OFF. STEERING IMMEDIATELY BECAME DIFFICULT AND I NOTICED THAT THE POWER STEERING INDICATOR LIGHT WAS ON. I EXITED THE FREEWAY CAREFULLY AND PULLED OVER, TURNED OFF THE CAR, THEN RESTARTED IT AND THE POWER STEERING CAME BACK ON. SINCE THIS INITIAL INCIDENT THE PROBLEM HAS BECOME MORE FREQUENT. I AM UNABLE TO SAFELY DRIVE THE CAR AND HAVE BEEN TOLD IT WILL COST OVER $1,000.00 TO REPLACE A POWER STEERING MOTOR IN THE STEERING COLUMN. ALSO I HAVE DISCOVERED THIS TO BE A FREQUENT ISSUE FOR THIS MODEL VEHICLE. WITH THE DANGER INVOLVED SHOULDN'T A RECALL BE IN ORDER? *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT STATED THAT THE IGNITION SWITCH KEY WAS ENGAGED REPEATEDLY AND THE ENGINE WOULD NOT OPERATE. THE FAILURE OCCURRED TEN TIMES. THE VEHICLE WAS TOWED TO THE AUTHORIZED DEALER FOR DIAGNOSTIC TESTING WHICH DETECTED A TROUBLE CODE RELATED TO A MODULE. THE CONTACT WAS UNCERTAIN OF THE PART THAT WAS REPLACED. THE PROBLEM CONTINUED AND THE VEHICLE REMAINED AT THE DEALER FOR FURTHER INVESTIGATION. THE MANUFACTURER WAS NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 34,000.

THE IGNITION WOULD NOT ENGAGE COULD NOT START THE CAR AND REPLACED THE ENTIRE SYSTEM AT 400.00 COST. LESS THAN A YEAR LATER, THE KEY NOW WILL NOT COME OUT OF THE IGNITION AND THE CAR WILL NOT TURN OFF. I DISCONNECTED THE BATTERY AND IT STILL WOULD NOT TURN OFF. AFTER MORE THAN 30 MINUTES, AND THE ENGINE OVERHEATING WE WERE ABLE TO PULL ENOUGH FUSES TO SHUT THE ENGINE OFF. THEY SAY I HAVE TO REPLACE THE SAME SYSTEM AGAIN. I HAVE HEARD THAT THIS IS A RECURRING PROBLEM WITH THIS CAR AND I CAN'T GET ANY ANSWERS FROM GM. I CAN NOT AFFORD TO REPLACE THIS SYSTEM AGAIN AT A COST OF 400.00 PLEASE HELP ME WITH. *TR

OUR CAR, 2004, SATURN ION3, CAUGHT ON FIRE IN THE DRIVEWAY ON IT'S OWN ABOUT 2 HOURS AFTER IT WAS DRIVEN HOME ON 4 NOV 2011. NO DRIVER - NO KEY IN THE VEHICLE WHEN IT CAUGHT FIRE. I SUBMITTED AN INITIAL REQUEST FOR REVIEW TO GM CLAIMS ALONG WITH ALL DOCUMENTATION THAT WE HAD VIA EMAILS AND OUR CLAIM WAS DENIED. *TR

WHEN I TURN MY CAR ON THE PARKING LIGHTS AND FRONT TURN SIGNALS STARTING BLINKING REALLY QUICK LIKE STROBING. I CAN TURN MY LEFT TURN SIGNAL ON AND IT WILL BLINK INSIDE HEARING THE NORMAL TICKING. IF I TURN MY RIGHT TURN SIGNAL ON IT THE ARROW ON THE INSIDE BLINKS SLOWER AND MAKES NO TICKING SOUND.IF I PUSH ON MY BRAKE THE LIGHT WORK PROBABLY AND THE TICKING SOUND ON THE RIGHT TURN SIGNAL INSIDE STARTS. IF I PUT MY EMERGENCY BRAKE ON IT WORKS PROPERLY. THE STROBING OF THE FRONT OUTSIDE PARKING LIGHTS STOP. IF I TURN MY PARKING LIGHT ON AND DRIVE WITH THEM ON EVERYTHING WORKS PROPERLY. I KNOW THIS HAS SOMETHING TO DO WITH THE RECALL. IT IS EFFECTING MY CAR SO BAD THAT MY RADIO DISPLAY LIGHT BLINKS ALSO. SO IT IS GETTING FEEDBACK FROM THIS PROBLEM BEFORE I HAVE A WRECK. I AM...

FOR THE SECOND TIME THE IGNITION LOCK CYLINDER BROKE. TODAY WE UNABLE TO TURN OFF THE ENGINE. WE HAD TO REMOVE FUSES TO KILL THE ENGINE AND DISCONNECT THE BATTERY. THE FIRST TIME IT HAPPENED WE WERE STUCK IN THE GROCERY STORE PARKING LOT BECAUSE THE KEY WOULD NOT TURN TO START. IN BOTH CASES WE HAD TO BREAK THE IGNITION LOCK IN ORDER TO REMOVE THE LOCK CYLINDER. WITH THE CYLINDER REMOVED WE CAN USE A SCREW DRIVER TO START THE CAR. THE SCREW IS MUCH MORE RELIABLE. *TR

TL* THE CONTACT OWNS A 2004 SATURN ION. THE CONTACT WAS DRIVING 20 MPH WHEN SHE BEGAN TO SMELL BURNING RUBBER AND PLASTIC. THE CONTACT STOPPED THE VEHICLE AND AT DISCOVERED THAT THE POWER WINDOWS AND POWER LOCKS HAD BECOME INOPERABLE. THE FUSE WAS REPLACED FOR THE WINDOWS AND THEY BEGAN TO FUNCTION PROPERLY. A PERSONAL MECHANIC ADVISED THE CONTACT THAT THE NEW FUSE WOULD NEED TO BE REMOVED TO ENSURE THAT NO ELECTRICAL FIRES OCCURRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 94,500.

MULTIPLE FAILURES OF ELECTRICAL SYSTEM. GAUGES DROP TO ZERO, THE ENGINE MAY OR MAY NOT STOP RUNNING, THEN THE DASH WARNING LIGHTS ( IE OIL WARNING LIGHT, ECT ) COME ON, AND THEN DASH RETURNS TO NORMAL. IF THE CAR IS MOVING THE ENGINE STARTS RUNNING AGAIN. ONE STEERING WARNING MESSAGE DURING A LEFT HAND TURN. THE CAR WAS DIFFICULT TO STEER INTO AND OUT OF THE CORNER. I AM WILLING TO TURN MY CAR OVER TO HAVE THE STEERING AND ELECTRICAL SYSTEM CHECKED OUT. SATURN HAS BEEN UNABLE TO REPAIR THE ELECTRICAL SYSTEM SINCE THE CAR WAS NEW. THE FACTORY EXTENDED WARRANTY WAS USED TO CHECK THIS ISSUE OUT AS WELL. *TR

WHEN STARTING THE SATURN ON A COLD MORNING, THE IGNITION FAILS TO START THE CAR. I GET A SERVICE MESSAGE. AFTER WAITING ABOUT 10 MINUTES THE CAR WILL START AS IF THE SECURITY WAS RESETTING ITSELF. I'VE READ SEVERAL COMPLAINTS OF THIS PROBLEM ON THE INTERNET. GM WILL NOT OWN UP TO A FAULTY PRODUCT THAT LEAVES 100S OF PEOPLE STRANDED. AS TIME GOES BY THIS PROBLEM OCCURS AT RANDOM TIMES, EVEN ON WARM DAYS. I WOULD LIKE A RECALL APPROVED FOR THIS MASSIVE SAFETY PROBLEM. IT'S A SAFETY CONCERN BECAUSE IN AN EMERGENCY OUR CARS SHOULDN'T HAVE TO SIT FOR AN ADDITIONAL TEN MINUTES OR STALL US IN A POTENTIALLY BAD NEIGHBORHOOD. THE PROBLEM SEEMS TO CORRECT ITSELF AFTER THIS IGNITION SWITCH INSIDE OF THE STEERING COLUMN HAS BEEN REPLACED BASED ON HUNDREDS OF TESTAMENTS. I WANT TO ADD THAT MY SATURN WHEN IT WAS NEW HAD OTHER RECALL...