2022 HYUNDAI KONA Engine Problems

The vehicle displayed a warning lamp indicating a Cooling System Performance failure. The specific defect relates to the Integrated Thermal-Management Module (ITM) and the thermostat opening prematurely, corresponding to Diagnostic Trouble Code (DTC) P218100. This issue requires a repair outlined in Technical Service Bulletin 25-EM-007H, involving a spring installation and ECU update. This failure creates a serious safety concern because improper thermal management can cause the engine to overheat or force the vehicle into a reduced-power 'limp mode' without warning. A sudden loss of acceleration or engine stall while driving in traffic significantly increases the risk of a crash.

When I purchased the car with in 2 weeks epb , auto hold and auto stop all 3 lights on dashboard came on orange. Took to dealership and they fixed the problem. 4 months later now the lights are back on. The vehicle does not feel safe at pulls to the right , I have problems with my ac as well as my transmission is slipping. The car loses power when I accelerate. I believe was sold a lemon car I purchased from carmax.

On Saturday, [XXX], while driving on the highway, the oil plug on my vehicle suddenly fell out, causing all the oil to drain rapidly. This created an extreme safety hazard not only for myself but also for other drivers on the road. I did not notice the oil spillage until the oil light on the dash appeared. At the time, I was in the leftmost lane traveling at highway speeds, so I could not stop immediately. I had to carefully veer across five lanes of traffic and navigate out of a construction zone before I was able to pull over safely. The engine lost lubrication during this process, and I was forced to have the vehicle towed to Ed Napleton Hyundai in Hazelwood, the same dealership where I purchased and serviced the car, for inspection and repairs. This incident occurred just three weeks after I had an oil change performed...

The contact owns a 2022 Hyundai Kona. The contact stated while driving at an undisclosed speed, the vehicle lost motive power with the check engine warning light illuminated. The vehicle was able to be restarted. The vehicle was taken to the dealer but was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 80,000.

I believe it’s a barring in the engine but it is like a knocking.

Radiator is failing between 60k and 70k miles with no check engine lights. Leaking an entire reservoir of coolant within a 24hr time period. Even when the temperature gage went above the middle mark and to the 3/4 mark the check engine light never came on.

Car will stop running and not start back up when stopped at a light or stop sign sometimes. I have started driving with the auto start stop off because I will be stuck at a light or stop sign because it will power off but not come back on again. This has occurred several times. The dealership told me there was no issue 11/22/24 but were willing to sell me another battery if I wanted to just replace the battery. The battery would test fine and then not and then fine again. I did price battery’s and they tested my battery at auto zone when pricing them and it tested fine with them also. They did not feel like it was a battery issue. I don’t either now since it stays on no problem when I turn off the auto start stop. There is something honestly wrong because if I...

While accelerating onto the highway, the engine backfired and suddenly lost speed, violently shaking.

The vehicle has lose of acceleration while driving.. On Freeway the gas pedal loses acceleration. Lift off gas it accelerates then loses acceleration again. (4 times in a row) It was a big safety issue. There was no where to pull off. I made it to the nearest exit and took backroads home. Took it to Dealership they couldn't replicate the issue. I contacted Hyundai and they had the car sent back to dealership and so far they can't replicate it. It has done this numerous times, at different times and speeds. The car is now at the dealership for the second time (since the 17 of December) There were NO WARNING LIGHTS so dealership says hard to diagnose the issues.

On 10/4/2024 I was driving my 2022 Hyundai Kona SEL (61, 492 miles on odometer) with a cruise control set at 75 mph for my morning commute into work. I was approx 15 miles away from my house and at least 7 miles away from my place of employement. Suddenly and without warning the engine revved to beyond 4500 RPM and shut off. The lights on the dashboard all lit up and a message flashed on the screen stating engine cut off, turn off car and restart. I was surrounded by several cars at this time. I was able to navigate to the shoulder of the 2 lane road I was on and bring the car to a stop. When I tried to turn the car back on it would not. I had the car towed to the dealership. First they had to replace the battery as they stated there...

The contact owns a 2022 Hyundai Kona. The contact stated that while at a stop light, the accelerator pedal was depressed while starting to make a left turn and the vehicle shut off. The vehicle rolled to the shoulder. The shift to park or neutral message was displayed. The vehicle was shifted to neutral and restarted. The vehicle was taken to the local dealer who failed to retrieve a fault code. The manufacturer was not contacted. The approximate failure mileage was 43,000. The VIN was not available.

While driving on a freeway, the drain plug fell out, dumping all of the oil onto the road. The vehicle had been serviced by just one facility and I had only had this brand new vehicle for 7 months when this occurred. This incident put the driver, any passengers, and anyone on the road nearby at risk. The drain plug loss was verified by a Hyundai certified service facility and then I was asked to tow it to the Hyundai certified facility that performed all of the services. I was told that Hyundai Motor America sent representatives to inspect the vehicle at both facilities along with the service staff at each facility. I have not been informed of anyone else inspecting the vehicle such as law enforcement or insurance representatives. There were no warning lamps or messages or symptoms prior to the drain plug falling out. There was no evidence...

The contact owns a 2022 Hyundai Kona. The contact stated that the vehicle stalled while at a complete stop and would restart independently while shifting into park(P). There was no warning light illuminated. Additionally, the contact stated that while driving 65 MPH, a chime sounded, and the message "Think About Taking a Rest" was displayed. The dealer was notified of the failure via email. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 19,842.

My Check Engine light came on and stayed steady (not blinking). The Cause for it is Unknown to me. I took it to the Dealership and they scheduled me to bring it in 3 days later, 3/12/24, to determine if it was something simple or if would take up to a couple days to fix. They assured me that if the light remained steady, I would be fine to drive the car. If it began blinking, then bring it back in. If the fix would take a day or more, they don't do loaner cars so I'd have to rent one (no cars to borrow and Ubers don't take wheelchairs). Approximately an hour after I arrived on 3/12 (I had to wait for my car), they gave me my car back. They had to order a part that was on back order that could take weeks or months to arrive....

Coolant Leak. Integrated Thermal Management started Leaking at around 16,000 Miles. Part replaced 12/14/23. Leaks continues

Check engine light- sensor, rear trunk won't lock - sensor

My daughter left our house in our 2022 Hyundai Kona on Friday, 1/13/23, to head back to college which is 5 hours from home. A little more than an hour down the road after leaving our house, she said that the car started sounding strange, so she called her mother. At this time, she was on a two lane country road with no safe options or areas to pull over. My wife advised my daughter to continue driving until she found a safe place to pull over. As she continued onwards, she came to a stop sign in the countryside and the car died on her. She restarted it and was able to continue her trip. Several miles later a light came on, but she was still not to a safe area. By the time she got to a safe place, other lights had come on, and the car died...

Around 8,000 miles, mid-drive my check engine light came on and immediately the ability to speed up became very shotty. I have a 2022 kona n-line. I could put my foot on the floor and it would take forever to get up to speed if at all. It was very here and there and seemed to have a mind of its own when it would do this. I’ve had it into the shop 5-6 different times since then to have it addressed and I’m still having issues with it. They replaced some valance, the solanoid, and just recently completely replaced the entire turbo system to try and fix the problem. It seems to have helped, but I still have this ongoing clicking sound since this started when the car downshifts it seems like, that has yet to be diagnosed. It’s not a normal car sound at all and nobody seems...

The contact owns a 2022 Hyundai Kona. The contact stated that the check engine warning light was illuminated. The vehicle was taken to the dealer and the contact was informed that there was bad fuel in the vehicle. The failure reoccurred and the vehicle was taken back to the same dealer who reset the codes. The failure persisted. The vehicle was taken to the dealer and diagnosed with a cylinder misfire. The vehicle was not repaired. The manufacturer was not contacted. The approximate failure mileage was 5,500.

22’ Kona N DCT Base US spec. 5,600 miles est (2nd Kona) Fuel used: Shell Premium Outside Temp: 76F/Dry-Clear Sky. This is my 2nd Kona N, this is the 4th experience I’ve had with my Kona N’s. Towed the first on Vin# [XXX] to dealer, engine stalled after refueling during a road trip. 6/7k miles. Misfire. No replaced parts, car started acting normal. Then I traded it in for another Kona N in June 22’. The vehicle in normal mode is fine. I believe. Switching from N Mode is where the engine starts misfiring and runs on 3,2cyl puffing out white smoke. Leaving me stranded. The codes all show via car touch screen, and OBD reader/history. All electronics perform properly, including active safety features. I am Hyundai affiliated but I do not know how to relay the message. All of the Kona N/Elantra N/Veloster N DCT. Need software updates. It’s...

While on the highway the transmission completely stopped shifting and stayed in first gear and would only rev up the engine when the accelerator was applied. I was able to get up to 50mph and slowly make my way to the dealership where I bought it 2 months ago. I turned the vehicle off went inside to talk to the service center where I was told that it'd take 2 to 3 days to even get my car in to get looked at and they did not have any loaners to give me. I still had to work and couldn't take time off so I went back to my car and restarted it after a few minutes and it drove regularly.

While at a stop light, the engine of my 2022 Kona died. No warning lights came on prior. It just died in the middle of the street. Then took several minutes and several tries to get the car to restart. Accelerator didn’t work at first either. Driving on highway warning light for tire pressure came on. Diagnostics said everything was fine. Then the warning light turned off. More and more frequent trouble accelerating onto highway. Car-play does not stay connected. Often doesn’t connect at all. Car dying in the middle of the street, not accelerating onto the highway was extremely frightening and I felt very lucky that it didn’t cause an accident, or worse. I have contacted my dealership about the issues and was told that I could have an appointment in 2 months! They don’t care about the safety of the people driving their cars and, clearly, they no...

While at a complete stop at and intersection the idle stop and go system shut the engine down. When I took my foot off the break the engine started but as soon as I stepped on the gas pedal, the engine shut down. The cluster gage told me out the vehicle in neutral and restart. This issues has happened numerous times. Most times were while stopped in traffic and could have been a factor in a car rear ending me. I have taken the vehicle to the dealership. They are very helpful and were able to replicate the issue. After conferring with a Hyundai Motors tech line, who said this has been a problem with other 2022 Konas, the dealership did replace a solenoid but the issue remains. The were no warning or check engine light at all.

Engine began knocking/shaking suddenly while highway driving, service engine light came on. Pulled over, turned off ignition. Tried restarting and would not start. Towed to dealership and diagnosed as engine failure, possible timing chain failure. Complete engine replacement recommended by dealer service dept. Dealer service dept. will replace engine free of charge as vehicle is well under warranty from Hyundai. The vehicle had less than 4000 miles on it. Safety of myself and others was put at risk due to failure happening while highway driving, fortunately I was able to pull over on shoulder before the engine completely seized.

I went to use the horn at a car that blew through a stop sign and there was no horn sound. This was my first time using the horn since I bought it brand new. No warning lights no nothing.

My vehicle keeps shutting off with no warning and has almost killed me on multiple occasions The dealership keeps placating me about getting it fixed, saying that a repair is months out Meanwhile, I am driving a very dangerous vehicle that shuts off and shakes like it’s going to explode

12-3-21, with only 103 miles on my new car, the check engine light came on. I drove back to the dealer where I purchased the car - Fitzgerald, and spoke to Maurice the manager, and Garret in the service department. Garret informed me he "wiggled the wires" and the check engine light went off. On 12-5-21, with 129 miles on the car the check engine light came on again. I went back to Fitzgerald and spoke to Frank, who works in sales. Frank told me the service department was closed on Sunday and I have to comeback Monday 12-6-21.

The contact owns a 2022 Hyundai Kona. The contact stated while driving 5 MPH, the vehicle inadvertently shut off due to the idle STOP/START feature. The contact stated that there was no warning light illuminated. The vehicle was taken to a local dealer where but was not diagnosed or repaired. The manufacturer was informed of the failure and referred the contact to NHTSA to file a complaint. The failure mileage was approximately 5.