2004 HONDA PILOT Seats Problems

I heard a loud pop come from under my driver's seat and the seat started rocking backwards. I got out of my car and checked underneath the seat. The front-left bracket securing the seat to the seat frame had completely sheared in half and the seat was no longer securely attached to the seat frame. This is a significant safety issue. When the car accelerates the driver's seat rocks backwards by ~45 degrees, making it extremely difficult to stay in control of the vehicle and safely steer the vehicle. It is also extremely unsafe in the case of an accident because A) the seat would not hold the driver securely in place, B) the driver would not be properly in position and restrained for the air bags to deploy, C) the seat belt is attached to the seat base and would not be able to fully function properly, and D)...

Brakes seem to stop suddenly Must brake slowly to avoid a sudden stop Seatbelt locks up if I do not pull it forward and leave room in the belt so that it isn't completely holding me in Also the driver seat will only adjust sideways.

UPON ENTERING THE VEHICLE AND SITTING IN THE DRIVER'S SEAT, I HEARD A LOUD POP AND THEN NOTICED THAT THE SEAT WAS EXTREMELY LOOSE AND WOULD ROCK BACKWARDS AS IF SOMETHING WAS BROKEN. I REMOVED THE SIDE COVER AND FOUND THAT THERE WAS A FAILED SEAT MOUNT BRACKET THAT HAD BROKEN IN HALF. THE VEHICLE IS CURRENTLY UNDRIVEABLE UNTIL THE SEAT IS FIXED SINCE THE SEAT SWAYS BACKWARDS ON ACCELERATION WHICH COULD LEAD TO AN ACCIDENT. I AM NOT AWARE OF ANY ACTIVE RECALL FOR THIS ISSUE BUT I BELIEVE IT SHOULD BE INVESTIGATED AS IT IS A MAJOR SAFETY CONCERN!

WHEN ACCELERATING AWAY FROM A STOP LIGHT, I HEARD A "POP" SOUND AND MY DRIVER SEAT SUDDENLY HAD A "ROCKING" ISSUE. THE DRIVER SEAT NOW ROCKS BACKWARD WHEN ACCELERATING, AFTER RESEARCHING ONLINE AND DOING A VISUAL INSPECTION I FOUND THAT A METAL "L" SHAPED BRACKET THAT MOUNTS THE SEAT BOTTOM TO THE SEAT FRAME HAS SHEARED OFF AT THE RIVET POINTS. THIS CREATES A HAZARD WHEN DRIVING AND I FEAR IN A CRASH, THE SEAT COULD BECOME UNATTACHED FROM VEHICLE INTERIOR COMPLETELY PUTTING OCCUPANT AT INCREASED RISK OF INJURY OR DEATH FROM AIRBAG DEPLOYMENT OR EJECTION FROM VEHICLE! DURING AN ONLINE SEARCH, I FOUND SEVERAL OTHER REPORTS OF THE SAME ISSUE TO NHTSA...THOSE REPORT NUMBERS ARE 1058303; 10578612; 10567737; 10541789; 10505250; 10489089; 10488805; 10466947; 10455702. I CONTACTED HONDA AND WAS TOLD SINCE THE WARRANTY WAS EXPIRED, THERE WAS NOTHING THEY WOULD DO. THIS IS A SAFETY HAZARD!!! WHY DOES SOMEONE...

TL* THE CONTACT OWNS A 2004 HONDA PILOT. WHILE ACCELERATING AND BRAKING, THE DRIVER'S SEAT UNINTENTIONALLY MOVED FORWARD AND BACKWARDS. SPREEN HONDA (25050 REDLANDS BLVD, LOMA LINDA, CA 92354, (909) 799-7070) WAS CONTACTED, BUT NO ASSISTANCE WAS OFFERED. THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING OR REPAIRS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE MOUNTING BRACKET FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 150,000.

ON 06/21/2014, I WAS ENTERING MY VEHICLE WHEN A BRACKET CONNECTED TO THE ADJUSTER ASSEMBLY (PART# 81630-S3V-A30) BROKE. THIS OCCURRED ON THE DRIVERS SEAT. DUE TO THIS, THE SEAT WAS NO LONGER SECURE TO THE FLOORBOARD AND STARTED ROCKING BACK AND FORTH. I SEARCHED HONDA PART RECORDS AND I WAS UNABLE TO FIND A SPECIFIC PART NUMBER ASSIGNED TO THIS BRACKET. THE VEHICLE WAS PARKED AT THE TIME OF THE BREAK. BUT, WHILE DRIVING THE VEHICLE THE SEAT WAS UNSTABLE AND HARD TO KEEP IT STILL. A SEARCH OF NHTSA RECORDS FOUND THE FOLLOWING COMPLAINTS REGARDING THE SAME ISSUE - 10583003, 10578612, 10567737, 10541789, 10505250, 10489089, 10488805, 10466947, 10455702. I TOOK PICTURES OF THE BROKEN BRACKET. IT APPEARS METAL FATIGUE MAY BE AN ISSUE.

THIS AFTERNOON AS I ENTERED MY CITY STREET PARKED, 2004 HONDA PILOT, FROM THE DRIVER'S SIDE, I HEARD A LOUD SNAPPING SOUND AS I SAT DOWN. THE DRIVER'S SEAT, SIMULTANEOUSLY WITH THE SOUND, ROCKED BACK, OBVIOUSLY NO LONGER SECURELY MOUNTED. UPON INSPECTION I FOUND THE FRONT LEFT 'L' SHAPED SEAT MOUNTING BRACKET HAD SHEARED IN TWO, IN LINE WITH THE TWO HOLES THAT THE SECURING RIVETS PASS THROUGH. THE BRACKET FAILED AND TORE, APPARENTLY THE METAL IS NOT THICK ENOUGH TO RESIST THE FORCES PLACED ON THE SEAT. PERHAPS RELATED TO THE SIZE OF THE RIVET HOLES.

LEANED BACK AND TURNED AROUND TO BACK OUT OF PARKING SPACE AND LEFT FRONT SEAT BRACKET ON THE DRIVER'S SIDE FRONT BROKE. HAVE TO BRACE MYSELF WHILE ACCELERATING FORWARD SOMETHING NEEDS TO BE DONE HAVE READ MULTIPLE OCCASIONS OF THIS HAPPENING TO OTHER PEOPLE. AFRAID THE OTHER BRACKETS WILL BREAK SHORTLY AFTER. I HAVE NOT BEEN ABLE TO FIND ANYTHING TO FIX THIS PROBLEM.

WHILE DRIVING APPROXIMATELY 35 MPH DOWN A CITY STREET, THE DRIVERS SEAT BEGAN TO MOVE- SPECIFICALLY BEGAN TO SHIFT BACKWARDS UPON ACCELERATION. UPON ACCELERATION, THE SEAT LEANS BACK AWAY FROM THE STEERING WHEEL SIGNIFICANTLY. INSPECTION BY MECHANIC SHOWED THE SEAT BRACKETS HAVE SHEERED OFF DETACHING THE FRONT LEFT CORNER FROM THE SEAT FRAME.

I AM THE ORIGINAL OWNER OF THE 2004 PILOT. VEHICLE HAS ALWAYS BEEN WELL KEPT AND MAINTAINED WITH HONDA DEALER. WIFE WAS DRIVING WHEN DRIVERS SEAT STARTED FEELING HOT LIKE A BURN ON HER BACK. STARTED SMELLING SOMETHING BURNING. SHE PULLED OVER AND GOT OUT OF VEHICLE.THE BACK PART OF THE SEAT WAS SMOKING AND SMOLDERING SO IMMEDIATELY TURNED OFF THE SEAT HEATER. GOT THE FIRE OUT AND BACK PART OF LEATHER HAS A BROWN SCORCH MARK AND LEATHER CRACKED. THE SMELL LASTED FOR HOURS. LEFT THE WINDOWS OPENED ALL NIGHT AND LEFT VEHICLE PARKED OUTSIDE OF THE GARAGE FOR FEAR OF FIRE AGAIN. HONDA NEEDS TO LOOK INTO THIS. I SEARCHED ON THE INTERNET TO FIND THIS IS NOT AN ISOLATED INCIDENT. THIS IS DANGEROUS TO THINK WHAT COULD HAPPEN IF NOT ABLE TO GET OUT OF THE VEHICLE SO QUICKLY.

DRIVERS SIDE SEAT MOUNTING BRACKET HAS CRACKED AND IS NOW SPLIT OPEN. VEHICLE WAS STATIONARY AND DRIVER HAD TURNED AROUND AND LEANED BACK TO BACK OUT OF A PARKING SPOT WHEN SEAT BRACKET CRACKED. DRIVERS SIDE SEAT NOW IS LOOSE AND ROCKS BACK AND FORTH. VERY UNSAFE TO DRIVE. AFRAID ENTIRE SEAT WILL BREAK LOOSE FROM MOUNTING POINTS. NOTE: MULTIPLE INSTANCES OF THIS SAME DEFECT HAVE BEEN SUBMITTED ON THE INTERNET, ACROSS MULTIPLE HONDA PILOT YEARS.

THE DRIVERS SEAT HAS BEEN SO HOT THAT IT FEELS LIKE IT CAN BURN YOUR SKIN. TODAY ON THE WAY TO WORK MY DAUGHTER SAID SHE SMELLED SOMETHING BURNING. SHE LOOKED DOWN ON HER SEAT AND IT WAS SMOKING AND BURNED THE LEATHER. THE SEAT WAS ACTUALLY CATCHING ON FIRE. I HAVE LOOKED THIS UP AND SEE NUMEROUS COMPLAINTS ON THIS AND PEOPLE HAVE REPORTED THIS TO YOU. I DON'T SEE WHAT YOU ARE REPORTING NO COMPLAINTS OR RECALLS. WE WERE ON THE HIGHWAY WHEN THE INCIDENT HAPPENED.

THE DRIVERS SEAT HAS A BRACKET THAT BROKE WHEN I WAS DRIVING AND I ALMOST CONTROL OF THE VEHICLE BECAUSE IT CAUSED ME TO LEAN BACK VERY FAR IN THE SEAT AND MY STEERING AND ACCELERATION WAS AFFECTED. I WAS EXITING ONTO A FREEWAY AND ALMOST COLLIDED WITH OTHER VEHICLES. THIS BRACKET IS LOCATED ON THE DRIVES SIDE THAT HOLDS A MOTOR THAT MOVES THE SEAT UP AND DOWN; IN CLOSE PROXIMITY TO THE LEFT SIDE PANEL FOR THE SEAT CONTROLS. BRACKET HAS TWO RIVETS HOLDING IN PLACE. WAS HOPING THEIR WAS A RECALL ON THIS DEFECT BECAUSE I FOUND LOTS OF INCIDENTS REPORTED ON VARIOUS WEBSITES. THANK YOU.

THE VEHICLE WAS STATIONARY, NOT IN ANY ACCIDENTS OR DRIVING OFF-ROAD. SAT DOWN AND FOUND DRIVER'S SEAT UNEXPECTEDLY WILL NOW TILT BACK, RAISING THE LEFT FRONT OF THE SEAT. THE SEAT IS OBVIOUSLY NOT SECURE, NOR WOULD IT BE SAFE IN AN ACCIDENT. TOOK IT TO THE DEALER, AND THEY SAID THE SEAT FRAME IS BROKEN INEXPLICABLY (PART 81660-S3V-A30). THIS DOES NOT APPEAR TO BE A WEAR PART - ONE OF THE METAL BRACKET PIECES HOLDING THE SEAT BOTTOM TO THE BODY I GUESS JUST SHEARED OFF ALONG THE RIVET LINE. A BRIEF WEB SEARCH FOUND THIS IS A COMMON PROBLEM, SO I'M SURPRISED THERE HAS NOT BEEN A RECALL BY HONDA. THE DEALER QUOTED A REPAIR PRICE OF APPROXIMATELY $1,850.

FRONT LEFT BRACKET THAT HOLDS THE DRIVERS SEAT TO THE FRAME OF THE VEHICLE SNAPPED. THIS IS A COMMON, KNOWN DEFECT AND IS A SAFETY ISSUE.

MY HUSBAND (195 LBS) REACHED IN HIS POCKET TO GET HIS WALLET AND THE METAL BRACE HOLDING THE SEAT BROKE. THE SEAT IS NOW NOT STILL WHEN DRIVING. WHAT WORRIES ME IS, WHAT IF I HAD BEEN IN AN ACCIDENT? THE AFOREMENTIONED BRACE SHOULD HOLD UNDER MUCH MORE RIGOROUS SITUATIONS. THERE APPEARS TO BE A LOT OF 2004 HONDA PILOTS WHO HAVE EXPERIENCED THIS EXACT SAME BREAK, AS NOTED ONLINE. THIS IS A VERY SERIOUS FLAW AND SHOULD BE FIXED BY THE MANUFACTURER AT THEIR EXPENSE. PER ONLINE COMMENTS, THE DEALERSHIP IS CHARGING $1200 TO FIX A PROBLEM THAT SHOULD NEVER HAVE FAILED. I AM BRINGING MY CAR IN FOR ASSESSMENT ON MONDAY, JUNE 12, 2017, AT 1:00P.

TL* THE CONTACT OWNS A 2004 HONDA PILOT. UPON ENTERING THE VEHICLE, THE FRONT DRIVER SIDE OF THE VEHICLE WAS LEANING. UPON INSPECTION, THE CONTACT NOTICED THAT THE WELD WAS FRACTURED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE DRIVER'S SEAT BRACKET WAS FRACTURED AND THE SEAT WOULD NEED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS NOT PROVIDED.

WHILE LEANING BACK IN THE DRIVER'S SEAT TO REMOVE MY WALLET TO PURCHASE GASOLINE I HEARD "POP" AND THEN THE SEAT SEEMED TO BECOME DISLODGED FROM THE BODY OF THE VEHICLE. THE FRONT LEFT OF THE SEAT WAS NO LONGER CONNECTED TO THE BODY OF THE VEHICLE. UPON FURTHER INSPECTION IT WAS REVEALED THAT THE STEEL BRACKET HOLDING THE TOP ASSEMBLY OF THE SEAT TO THE BOTTOM ASSEMBLY OF THE SEAT TORE CLEAN THROUGH.

TL* THE CONTACT OWNS A 2004 HONDA PILOT. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE DRIVER SEAT WOULD MOVE INDEPENDENTLY. THE CONTACT STATED THAT THE SEAT FELT AS THOUGH IT WOULD DISLODGE FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SEAT BOLT HAD FRACTURED AND THAT DRIVERS SEAT WOULD HAVE TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 150,000.

THE DRIVERS SEAT LOWER METAL BRACKET BROKE CAUSING THE DRIVERS SEAT TO BE UNSTABLE WHEN SITTING IN THE SUV AND WHEN ACCELERATING. I HAVE SEEN AT SEVERAL OTHER COMPLAINTS BOTH ON THIS WEB SITE AND IN THE HONDA PILOT FORUM. I CALLED THE DEALER ABOUT ASKING FOR A REPAIR WHO REFERRED ME TO HONDA USA. I CALLED AND REPORTED THE PROBLEM TO HONDA AND THEY ARE UNWILLING TO FIX THIS SAFETY ISSUE WHICH IS A SAFETY DEFECT BECAUSE THERE IS NO RECALL ISSUED FOR THIS PROBLEM. IF THIS VEHICLE WERE TO BE IN AN ACCIDENT THE SEAT WOULD LIKELY BREAK LOOSE AND THROW THE DRIVER AND THE SEAT OUT OF THE VEHICLE. I JUST NOTICED THIS PROBLEM WHILE DRIVING THE VEHICLE .

I AM THE ORIGINAL OWNER OF A 2004 HONDA PILOT EX-L AND HAVE HAD ONLY VERY MINOR ISSUES UP UNTIL NOW. YESTERDAY, WHILE ENTERING THE VEHICLE, I NOTICED A GREAT DEAL OF PLAY IN THE DRIVER'S SEAT BACK. ASSUMING AN ANCHOR BOLT WAS LOOSE, I CHECKED THE LEFT FRONT SEAT AREA WHERE THE MOVEMENT WAS THE GREATEST AND DISCOVERED THE LEFT ADJUSTER ASSEMBLY ARM ALMOST COMPLETED SHEARED FROM THE MAIN ADJUSTER ASSEMBLY. THE STRUCTURAL INTEGRITY OF THE SEAT IS NOW SEVERELY COMPROMISED AND IS A SAFETY HAZARD AS THE SEAT WILL BECOME DETACHED IN ANY ACCIDENT. I'VE NOTED NUMEROUS COMPLAINTS OF THIS EXACT SAME PIECE ON THIS AND OTHER WEBSITES.

BRACKET ON LEFT FRONT POWER SEAT BROKE; IT HOLDS THE SEAT TO THE FLOOR; AND SEAT ROCKS BACK AND IS NOT FASTENED AT LEFT FRONT TO THE CAR. VERY DANGEROUS AND MUST BE FIXED.

THE HEATING ELEMENT ON THE DRIVER SIDE SEAT GETS SO HOT YOU HAVE TO TURN IT OFF TO KEEP FROM GETTING BURNT. IT GETS SO HOT YOU CAN'T STAND IT. IT HAPPENS ON BOTH THE HI AND LO SETTINGS. IT DOESN'T HAPPEN ALL OF THE TIME BUT WHEN IT DOES IT CONTINUES UNTIL THE HEATER IS TURNED OFF. AS MANY PEOPLE WHO HAVE HAD THIS PROBLEM, I'D THINK SOMETHING SHOULD BE DONE TO FIX THE PROBLEM BEFORE IT CAUSE A MORE SERIOUS PROBLEM. WHEN IT HAPPENS IT GETS HOT FAST. ONE TIME WHEN I NOTICED IT WAS GETTING HOT BEFORE I COULD GET IT TURNED OF IT GOT SO HOT I COULD HARDLY STAND IT. FORTUNATELY I WAS NOT IN HEAVY TRAFFIC OR THE REACTION TO IT COULD HAVE CAUSED AN ACCIDENT. THIS HAS HAPPENED BOTH WHILE THE VEHICLE WAS STATIONARY AND WHILE DRIVING DOWN THE ROAD. IT HAS HAPPENED...

TL* THE CONTACT OWNS A 2004 HONDA PILOT. WHILE THE CONTACT WAS SEATED IN THE DRIVER SEAT, AN ABNORMAL SOUND EMITTED FROM THE VEHICLE WITHOUT WARNING. THE CONTACT DISCOVERED THAT THE SEAT BOLT WAS FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BOLT BETWEEN THE SEAT AND SEAT FRAME ASSEMBLY WAS FRACTURED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 210,000.

I AM THE ORIGINAL OWNER OF MY 2004 HONDA PILOT. OVERALL, GOOD VEHICLE BUT HAS ALWAYS BEEN A PROBLEM WITH THE DRIVER SIDE HEATED SEAT. IT GETS TOO HOT AND FELT LIKE A BURN TO YOUR SKIN. I MENTIONED TO THE DEALER EARLY ON AND WAS TOLD TO DECREASE THE USE. SO, I HAVE DECREASED THE USE OF THE HEATED SEATS OR USED ON LOW FOR A SHORT TIME UNTIL THE SUV WAS WARM AND COMPLETELY TURNED OFF. THE SEAT IS NOT HEATING AT ALL NOW. IT HAS APPROX. 175,000MILES AND HAS BEEN WELL MAINTAINED. I FEEL THAT THERE HAS BEEN TOO MANY COMPLAINTS AND THIS ISSUE NEVER ADDRESSED OR A RECALL DONE.

THE DRIVER'S SEAT POPPED AND NOW TILTS BACKWARDS FROM THE LEFT. UPON INVESTIGATION I FOUND THE EXACT PROBLEM OTHERS HAVE REPORTED TO NHTSA REGARDING THIS YEAR MODEL: THE LEFT SIDE BRACKET THAT HOLDS THE MOTOR FOR THE POWER SEAT BACK BROKE ALONG THE RIVET LINE. THIS HOLDS THE SEAT BOTTOM TO BODY OF THE SEAT. THIS WAS PERFECTLY DESCRIBED IN A COMPLAINT LODGED 4/25/2015 FROM TAMPA, FL. THIS APPEARS

WHILE DRIVING TO WORK THIS MORNING (COLD MORNING, ON CITY STREET) I TURNED MY DRIVER SEAT HEATER ON HIGH. THE DRIVER SIDE SEAT HEATER WAS ON FOR ABOUT 20 MINUTES WHEN SUDDENLY THE BACK BECAME VERY HOT. IT STARTED TO SMELL AND MY BACK WAS SLIGHTLY SCALDED BEFORE I REALIZED WHAT WAS HAPPENING. I QUICKLY TURNED MY SEAT HEATER OFF AND SOON AFTER TURNED MY CAR OFF TO INVESTIGATE. THE BACK PORTION OF THE SEAT (MIDDLE SPOT) WAS STILL VERY HOT TO TOUCH AND REMAINED THAT WAY FOR AT LEAST 15 MINUTES IN 35 DEGREE WEATHER! MY CAR AND ESPECIALLY THE DRIVER SIDE SEAT HAS A BURNT RUBBER ODOR. I TRULY FEEL THAT IF I HAD NOT TURNED MY SEAT HEATER OFF WHEN I DID, THAT IT WOULD HAVE CAUGHT FIRE WITH ME DRIVING! NO I'M AFRAID TO UTILIZE THE SEAT HEATER. HONDA NEEDS TO DO SOMETHING ABOUT THIS VIA...

LEFT FRONT BRACKET ON DRIVER SEAT HAS BROKEN ON ITS OWN WITHOUT ANY OUTSIDE INFLUENCE. WIFE PARKED IN DRIVE WAY LEANED BACK TO EXIT VEHICLE AND THE BRACKET BROKE.

THE SEAT BEGAN MOVING EARLIER TODAY AND THEN WHEN MY HUSBAND WAS GETTING OUT OF THE CAR THERE WAS A LOUD POP AND THE SEAT STARTED ROCKING. IT SEEMS TO HAVE BECOME DETACHED FROM THE CAR ON THE FRONT LEFT. WHEN ACCELERATING IT ROCKS BACK AND WHEN BREAKING IT ROCKS FORWARD. MY HUSBAND LOOKED AND THE METAL BRACKET HAS BROKEN COMPLETELY. IT SEEMS VERY UNSAFE AND WOULD BE EXTREMLY WORRIED THAT IN AN ACCIDENT THE AIR BAG WOULD CAUSE SERIOUS INJURY WHEN YOU ARE THRUST EVEN FARTHER INTO IT OR IF THE OTHER SIDE WERE TO BREAK AND YOU BE THROWN OUT REGARDLESS OF HAVING A SEATBELT.

WE NOTICED THAT THE PLASTIC PANEL COVERING THE DRIVER'S SEAT CONTROLS CAME DETACHED. SHORTLY AFTER THE SEAT BEGAN ROCKING SLIGHTLY. FINALLY, THERE WAS A LOUD POP AND THE SEAT NOW ROCKS FREELY. IT IS SCARY AND DANGEROUS TO HAVE TO DRIVE A VEHICLE WHILE THE SEAT RESPONDS TO ALL MOVEMENT. IT WILL NO LONGER ALLOW YOU TO INCREASE THE INCLINE OF IT, SO IT'S RECLINED AT THE SAME TIME. WHAT STARTED AS TWO SCREWS BREAKING FREE FROM THE DECORATIVE LEVER COVER QUICKLY TURNED INTO A MAJOR STRUCTURAL ISSUE.

WHEN SITTING DOWN IN MY VEHICLE THIS MORNING, THERE WAS A SNAPPING NOISE AND THE SEAT ROCKED BACK TOWARD THE RIGHT REAR. REMOVING THE PLASTIC COVER, IT WAS PLAINLY VISIBLE THAT A METAL PART THAT HOLDS THE UPPER SEAT TO THE LOWER SEAT ASSEMBLY HAS SNAPPED WHERE IT ATTACHES WITH TWO INDUSTRIAL RIVETS. SEAT NOW TIPS BACKWARD RATHER EASILY, AND DOES SO WHEN I CLIMB IN OR OUT OF THE VEHICLE, AND UPON ACCELERATION. CLEARLY THE STRUCTURAL INTEGRITY OF THIS SEAT IS DESTROYED UNTIL I CAN HAVE IT FIXED/REPLACED. I AM FEARFUL THAT IF I WERE TO HAVE AN ACCIDENT, THE SEAT WILL COME COMPLETELY DETACHED. IN A 5 MIN WEB SEARCH I HAVE FOUND DOZENS OF OTHER INSTANCES OF THIS OCCURRING; THIS IS NOT A RARE PROBLEM AND NEEDS TO BE FIXED! COMPOUNDING MY PROBLEM, I AM IN THE USAF STATIONED IN THE UK, AND GETTING THIS FIXED WILL...

FRONT LEFT STRUCTURAL BRACKET ON DRIVER'S SEAT FAILED, ALLOWING SEAT TO TIP BACKWARD. BRACKET FAILED ALONG A LINE WITH TWO RIVET/FASTENERS, DETACHING SEAT TRAY FROM POWER FORE/AFT POSITIONER RAILS. APPARENTLY DESIGN DEFECT, AS THERE ARE 12 OTHER ESSENTIALLY IDENTICAL NHTSA COMPLAINTS ON FILE FOR THIS MAKE/MODEL/YEAR. *TR

THE DRIVERS SIDE SEAT BRACKET, 81630-S3V-A30, HAS BROKEN AT A WEAK POINT IN THE METAL WHERE THE SEAT MOTOR ATTACHES. THE BREAK CAUSED THE SEAT TO ROCK BACK AND FORTH FREELY. THIS IS THE SECOND TIME THIS BRACKET HAS BROKEN. THE FIRST TIME WAS IN JULY, 2011; MOST RECENTLY FEBRUARY 2015. EACH TIME I PURCHASED A NEW BRACKET ARM AT THE EXPENSE OF ALMOST $300. BOTH BRACKETS BROKE AT THE SAME SPOT, WHERE THE SEAT MOTOR MOUNTS. THE SUDDEN METAL BREAK ALMOST CAUSED US TO HAVE AN ACCIDENT ON TWO SEPARATE OCCASIONS. IN EACH CASE, NORM REEVES HONDA IN HUNTINGTON BEACH REFUSED TO REPLACE THE DEFECTIVE BRACKET AT THEIR COST BUT OFFERED, INSTEAD, TO ORDER THE PART AND INSTALL IT FOR A COST OF $1200. *TR

NOTICED AN EXTREME HOT SPOT ON DRIVERS SIDE LOWER SEAT CUSHION WHEN HEATED SEATS ARE ON HI OR LO. SPOT IS SO HOT THAT YOU CANNOT LET IT TOUCH YOUR PANTS WITHOUT BURNING YOU. I HAVE READ MANY ACCOUNTS OF THIS SAME ISSUE WITH OTHER HONDA OWNERS THAT ULTIMATELY RESULTED IN A FIRE. NOW DRIVERS SIDE LOWER SEAT CUSHION HEATING ELEMENT NO LONGER WORKS. DRIVERS SIDE BACK AND PASSENGER SIDE HEATING ELEMENTS STILL WORK. *JS

WHILE STOPPED AT A STOP SIGN, I BEGAN TO ACCELERATE WHEN I HEARD A 'POP' AND THE SEAT TILTED BACK, STARTLING ME. A METAL BRACKET ON THE FRONT-LEFT SIDE OF THE DRIVER'S SEAT HAS BROKEN AND THE SEAT NOW SHIFTS BACK AND FORTH! *TR

WHEN WE TURN ON THE SEAT WARMER IN THE FRONT PASSENGER SEAT OF OUR HONDA PILOT 2004, WE SMELL A STRONG ODOR OF RUBBER OR FOAM BURNING. NOW OUR SEAT WARMER WILL NOT WORK AT ALL. WE'VE STOPPED USING THE SEAT WARMER DUE TO CONCERNS OF A FIRE STARTING. *TR

TL* THE CONTACT OWNS A 2004 HONDA PILOT. THE CONTACT STATED THAT THE DRIVERS SIDE SEAT WARMER WAS ACTIVATED AND BECAME EXTREMELY HOT. IN ADDITION, THERE WAS A BURNING ODOR THROUGHOUT THE VEHICLE. AS A RESULT, THE DRIVER SUSTAINED A BURN. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000. THE VIN WAS NOT AVAILABLE.

WHEN THE DRIVER SIDE HEATED SEAT IS TURNED ON THE SEAT GETS SO HOT THAT IT LITERALLY BURNS THE SKIN ON ANYONE SITTING IN THE SEAT. IT HAPPENS ON BOTH LOW OR HIGH SETTING. THE SEAT THEN BEGINS TO EMIT SMOKE. *JS

HUSBAND PARKED CAR LEANED FORWARD TO GET WIFI OFF DASH AND LEFT FRONT OF DRIVER SEAT DETACHED FROM THE ADJUSTER. SEAT NOW LEANS TO FRONT LEFT AND ROCKS AROUND. UPDATED 2/27/2015 *JS

WE WERE ON ANOTHER SUMMER TRIP AND THE AIRBAG WARNING LIGHT CAME ON. THIS IS THE BIG RED LIGHT TO THE FAR LEFT OF THE PANEL. CALLING HONDA IN FRANKLIN TN THEY HAD NO IDEA WHAT COULD HAPPEN WHILE CONTINUING TO DRIVE THE VEHICLE. CALLING ANOTHER DEALERSHIP THEY ASSURED ME THAT IT WAS MOST LIKELY A SENSOR AND THE AIRBAGS WOULD SIMPLY NOT DEPLOY. HONDA AS RECALLS NOW FOR BAD AIRBAGS. 1- OUR 2004 DOES NOT FALL INTO THE RECALL PERIOD 2 - HONDA SHOULD PAY FOR ANY ISSUE RELATED TO BAD AIRBAG TECHNOLOGY REGARDLESS OF HOW OLD THE CAR IS, JUST LIKE THEY DO WITH SEAT BELTS. IF WE WOULD HAVE BEEN IN A WRECK DURING THE TIME THAT LIGHT WAS ON, THE AIRBAG WOULD NOT HAVE DEPLOYED. 3- ANY PART OF THE AIRBAG/SENSOR/ SEATBELT SYSTEM SHOULD NOT BE MERELY COVERED UNDER A LIMITED WARRANTY. IT SHOULD BE COVERED...

LOWER SEAT SUPPORT/BRACKET ON FRONT LEFT OF DRIVERS SIDE SEAT HAS BROKEN, MAKING SEAT LOOSE, UNSAFE. SAME PROBLEM CAN BE SEEN REPEATEDLY IN 2004 HONDA PILOTS AND APPARENTLY 2003-2006 MODELS. OTHER NHTSA COMPLAINT CASE NUMBERS WITH EXACTLY THE SAME PROBLEM IN 2004 HONDA PILOT MODELS ARE 10583003, 10578612, 10567737, 10541789, 10505250, 10489089, 10488805, 10466947, 10455702 *JS

A BRACKET THAT CONNECTS THE DRIVERS SET TO THE SEAT ADJUSTER ASSEMBLY FAILED CATASTROPHICALLY. THIS BRACKET IS ON THE FRONT LEFT SIDE APPROXIMATELY BEHIND THE POWER SEAT CONTROLS. THE SEAT IS NOW UNATTACHED FROM THE ADJUSTER ASSEMBLY AND QUITE UNSAFE. THIS HAPPENED WHILE GETTING IN THE VEHICLE. THE BROKEN BRACKET MAY BE PART OF ADJUSTER ASSY., L. RECLINING, 81630-S3V-A30, BUT IT IS HARD FOR ME TO TELL SINCE THE EXPLODED PARTS DIAGRAM THAT I HAVE ACCESS TO DOES NOT SEEM TO MATCH, QUITE, WHAT I SEE. BASED ON PARTS AND LABOR, I ESTIMATE THE COST TO REPAIR THIS DEFECT TO BE IN THE $800-1200 RANGE. *TT

DRIVER'S POWER SEAT ASSEMBLY PART BROKE, WHICH SEPARATED THE SEAT FROM THE POWER MOVEMENT ASSEMBLY. SEAT ROCKS BACK AND FEELS LIKE SLIGHT PRESSURE COULD COMPLETELY DISENGAGE THE SEAT FROM THE CAR. SEAT ROCKING WHILE DRIVING IS VERY DANGEROUS. *TR

EXTREME HOT SPOT IN DRIVER'S SIDE FRONT SEAT WHEN THE SEAT HEATER IS TURNED ON FOR MORE THAT 3 MINUTES. *TR

A LOWER SEAT SUPPORT ON DRIVERS SEAT HAS FAILED. CAUSING THE FRONT OF THE DRIVES SEAT TO NOT BE HELD IN PLACE. ON ACCELERATION THE FRONT OF DRIVERS SEAT LIFTS UP CAUSING THE SEAT TO LAY BACK IN A MORE RECLINED POSITION. *TR

FRONT, DRIVER SEAT, SEAT WARMER WAS ON HIGH. SEAT WAS GETTING VERY WARM. SEAT BEGAN TO SMOKE, LEATHER WAS MELTING. THIS OCCURRED UNDER THE DRIVER'S RIGHT LEG. THE SEAT GETTING VERY WARM HAS BEEN ONGOING FOR SOME TIME NOW ON BOTH LOW AND HIGH, BUT I TURN THE SEAT WARMER OFF. THIS IS THE FIRST TIME IT HAS STARTED SMOKING. CONTACTED DEALERSHIP. WAS TOLD TO JUST NOT USE SEAT WARMER. WILL NO LONGER USE SEAT WARMER AS IT IS A FIRE HAZARD. *TR

DRIVER'S SIDE SEAT HAS FELT EXTREMELY HOT IN THE LAST FEW TIMES THAT I USED SEAT HEATER. PULLED INTO WORK AND AS I STARTED TO EXIT SMOKE WAS COMING OUT OF THE SEAT. NEVER CAUGHT FIRE AS I IMMEDIATELY TURNED OFF THE SWITCH AND POUNDED THE SEAT CUSHION. *TR

I TURNED THE DRIVER SEAT HEATER TO HI DURING MY DRIVE HOME YESTERDAY, THE HEATER GOT EXTREMELY HOT AND FELT IT WAS BURNING MY BACK EVEN WITH A HEAVY COAT ON, ALSO SMELLED LIKE SOMETHING IS BURNING. I TURNED THE HEATER OFF BECAUSE OF SAFETY CONCERNS. THE SEAT STILL HAS BURNED SMELL TO IT NEXT DAY. *TR

THE DRIVER'S SEAT HEATER GOT BURNING HOT, AND IT BURNT THE LEG AT A SPOT, THE INJURY WAS MINOR; WHEN THE HEATER WAS OFF THE PROBLEM DISAPPEARED. I AM NOT USING THE HEATER NOW AS IT IS INTOLERABLY HOT AND MIGHT CREATE FIRE HAZARD. *TR

DRIVER'S POWER SEAT ASSEMBLY PART BROKE, WHICH SEPARATED THE SEAT FROM THE POWER MOVEMENT ASSEMBLY. SEAT ROCKS BACK AND FEELS LIKE SLIGHT PRESSURE COULD COMPLETELY DISENGAGE THE SEAT FROM THE CAR. SEAT ROCKING WHILE DRIVING IS VERY DANGEROUS. IT APPEARS TO BE A SMALL METAL BAR WHICH RUNS FROM THE SEAT ASSEMBLY TO THE "SLIDE ADJUSTMENT ASSEMBLY". IT IS A VERY SMALL COMPONENT OF ITEM REFERENCE NUMBER 14 (P/N: 81660-S3V-A30) OF THE "FRONT SEAT COMPONENTS (L.) (POWER)" FOR THE 2004 HONDA PILOT 5DR EX - KA5AT. SPECIFICALLY, THE METAL BAR SEEMS TO ATTACH TO THE ROD WHICH ROTATES WHEN THE SEAT IS TILTED FORWARD OR BACKWARD. THE BAR IS DESIGNED TO BE FIXED TO THE ROD, WHICH WHEN ROTATING, PUSHES THE OTHER END OF THE BAR (ATTACHED TO THE FRONT END OF THE SEAT BOTTOM) UP OR DOWN, RESULTING IN THE SEAT TILTING BACK OR FORWARD. IT IS THE ONLY...