2001 FORD WINDSTAR Wheels Problems

THE AXLE WAS PART OF RECALL #11S16. AS PART OF THE RECALL THE AXLE WAS PATCHED, BUT THE AXLE IS NOW BROKEN BECAUSE THE "REPAIR" DID NOT CORRECT THE STRUCTURAL FLAWS IN THE AXLE.

MY VEHICLE WAS MANUFACTURED IN 2001. THERE WAS A RECALL PUT OUT FOR THE SUSPENSION:REAR:AXLE:NON-POWERED AXLE ASSEMBLY. IN 2011, ACCORDING TO SUNSET FORD DEALERSHIP (WHERE I TOOK IT FOR AXLE REPAIR AND WAS DENIED) THE RECALL WAS REMEDIED IN 2011. HOWEVER, AS STATED ALONG WITH THE RECALL NOTICE, THE TIME THAT THE BRACKETS WERE MIS INSTALLED CAUSED DAMAGE TO THE REAR AXLE, CORROSION AND FRACTURING. THIS IS EXACTLY WHAT IS HAPPENING TO MY VEHICLE RIGHT NOW AND THE DEALERSHIP ALONG WITH FORD CORPORATE IS SAYING THIS AXLE REPAIR WILL BE FULLY AT MY COST. ACCORDING TO THEIR AUTOMATED RECALL PHONE INFORMATION, UP UNTIL 2016 THEY WERE OFFERING TO REPLACE THE AXLE FOR $300 ( A DISCOUNTED RATE) FOR CUSTOMERS AFFECTED. I DO NOT AT ALL FEEL I SHOULD BE RESPONSIBLE FOR THIS REPAIR. I CONTACTED FORD CORPORATE A FEW TIMES NOW AND HAVE BEEN TOLD NO ITS NOT THEIR FAULT....

1. REAR AXLE FRACTURED SEVERELY & BROKE MAKING THE CAR UN-DRIVABLE ON 24 JAN 2019 WHILE IN MOTION DRIVING IN CITY TRAFFIC. FORD PUT BRACES ON THIS VEHICLE UNDER RECALL# 10S13, BUT THEY FAILED TO PREVENT FURTHER CORROSION AND METAL FATIGUE. THE AXLE WAS A BAD ENGINEERING DESIGN FROM THE DRAWING BOARD COMBINED WITH NOT E-COATING THE METAL DURING MANUFACTURING TO PREVENT CORROSION OF THE METAL DUE TO ROAD SALT. THE AXLE FRACTURED NEXT TO THE BRACE ON THE DRIVER SIDE AS SHOWN IN THE 4 IMAGES BELOW. I HAVE ONE TOW BILL (FLAT-BED) TO GET THE CAR OFF THE DOWNTOWN STREET TO MY HOME & WILL HAVE ANOTHER TOW BILL TO TRANSPORT IT TO WHERE I CAN REPLACE THE AXLE. 2. FRONT CRADLE FRAME'S MOUNT RUSTED OFF THAT ANCHORS THE STABILIZER BAR SO THE STABILIZER BAR HAD TO BE REMOVED. THIS HAPPENED SEVERAL YEARS AGO. THE CRADLE FRAME PROBABLE...

AXLE SNAPPED WHILE DRIVING ON HIGHWAY REAR WHEELS BENT INWARD.

REAR AXLE BREAK DUE TO CORROSION OF ACKNOWLEDGED INADEQUATELY DESIGNED AXLE. BREAK HAPPENED IN THE REINFORCEMENT BRACKET INSTALLED DO TO INITIAL AXLE RECALL FOR POTENTIAL BREAK DUE TO CORROSION.. CAR WAS ON CITY STREET IN MOTION TO FREEWAY ONRAMP FORTUNATELY THE AXLE BROKE PRIOR TO ENTERING FREEWAY. AXLE BREAK RESULTED IN SAGGING AXLE AND A WHEEL TILTED INWARD AT ABOUT 20 DEGREES AND WEDGED AGAINST THE INNER WHEEL WELL. TIRE STARTED TO SMOKE. CAR IS UNDRIVEABLE. THE REPAIR IS ESTIMATED TO $1400. FORD WILL NOT ACCEPT ANY FINANCIAL RESPONSIBILITY FOR THIS BREAK IN THE BRACKETS INSTALLED TO PREVENT THE BREAK. ADDITIONAL COMPONENTS ARE ALSO NEEDING REPAIR AND REPLACEMENT DUE TO THE BREAK OF THE AXLE.

REAR AXLE SNAPPED WHILE DRIVING ON NORMAL ROADS. *TR

TL* THE CONTACT OWNS A 2001 FORD WINDSTAR. THE CONTACT STATED THAT THE FRONT SUBFRAME WAS SEVERELY CORRODED AND AN ABNORMAL NOISE WAS HEARD FROM THE FRONT PASSENGER WHEEL. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE VEHICLE WAS SEVERELY CORRODED AND WAS PREVIOUSLY INSPECTED PER NHTSA CAMPAIGN NUMBER: 11V030000 (STRUCTURE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 146,000.

TL* THE CONTACT OWNS A 2001 FORD WINDSTAR. WHILE REVERSING AT APPROXIMATELY 1 MPH, THERE WAS AN EXPLOSION ON THE REAR PASSENGER SIDE NEAR THE REAR TIRE. IN ADDITION, THERE WAS AN ABNORMAL NOISE COMING FROM THE REAR PASSENGER SIDE AFTER THE TIRE WAS REPAIRED. THE TIRE HAD FRACTURED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE REAR AXLE HAD FRACTURED AND THAT THE VEHICLE NEEDED TO BE TOWED TO A DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 179,000.

WHILE DRIVING THE VEHICLE AT HIGHWAY SPEEDS, I HEARD A CRUNCHING SOUND IN THE REAR OF THE VEHICLE. THE VEHICLE THEN BEGAN TO SWAY ON THE ROAD. I HAD TO SLOW MY SPEEDS AND PULL OVER AT A SAFE SPOT, WHICH WAS A PARKING LOT TO INSPECT WHAT THE ISSUE WAS. AFTER INSPECTION, I NOTED THE PASSENGER REAR TIRE WAS AT AN ANGLE WITH THE TOP OF THE TIRE INWARD TOUCHING THE FRAME. I TOOK THE VEHICLE TO THE CLOSEST REPAIR SHOP WHERE I FOUND FROM THEIR INSPECTION THAT THE AXLE WAS BROKE AND THE VEHICLE WAS NOT DRIVEABLE. MY VEHICLE WAS PART OF THE FORD WINDSTAR AXLE RECALL, WHICH WAS SERVICED BY THE LOCAL FORD DEALER IN 2012. THIS VEHICLE HAD THE REINFORCEMENTS ADDED TO THE AXLE IN 2012. THE AXLE BROKE BETWEEN THE REINFORCED PLATES WELDED TO THE AXLE DURING THE RECALL CHECK. NOW AFTER TOWING THE VEHICLE...

TL* THE CONTACT OWNS A 2001 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE RIGHT PASSENGER SIDE TIRE FAILED AND NOTICED THAT THE SUB FRAME ROTTED OUT WHILE INSTALLING THE SPARE TIRE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 177,000.

THE REAR AXLE BROKE IN THE PLACE THAT WAS "FIXED" BY THE RECALL WORK IN 2010. NOTICED SQUEAKING NOISES (TIRE WAS RUBBING) AND A LARGE CLUNK AND WIGGLE WHEN TURNING INTO A PARKING LOT. TOOK A PHOTO WHEN I GOT TO THE PARKING LOT. MY REAR DRIVER'S SIDE TIRE WAS AT AN ANGLE TO THE VEHICLE AND THE REAR AXLE WAS BROKEN UNDER THE COLLAR THAT HAD BEEN ATTACHED BY A DEALER FOR THE RECALL. THE WELD HELD UP, BUT THE AXLE SNAPPED UNDERNEATH THE FIX-UP JOB. APPARENTLY THE RECALL FIX WASN'T REALLY A FIX. TOWED IT INTO A DEALER, WHO TOOK PHOTOS AND TALKED TO FORD. FORD SAID THEY WOULDN'T DO ANYTHING. COST ME $$ TO TOW IT TO THE DEALER AND BACK HOME AGAIN. DON'T HAVE $1,000 TO PAY THE DEALER FOR A NEW REAR AXLE. VERY DISAPPOINTED THAT THEY DIDN'T STAND BY THEIR WORK. VERY THANKFUL THAT...

DURING NORMAL OPERATION OF VEHICLE AT POSTED DRIVING SPEED LIMITS THE VEHICLES ABS, BRAKE WARNING LIGHTS HAVE CONTINUOUSLY COME ON AFTER DRIVING BEGINS. IT HAS BEEN ALSO NOTED THAT AFTER SEVERAL BRAKE SERVICE INSPECTIONS AND REPAIRS AT MAJOR AUTO REPAIR SHOPS, SUCH AS MIDAS, CARX , AND PEP BOYS. TECHNICIANS HAVE OBSERVED THAT THE BRAKE SYSTEMS MAJOR COMPONENTS AND HARDWARE APPEARED TO HAVE FAILED DUE TO HIGH LEVELS OF CORROSION AND EASILY RUSTING PARTS SUCH AS BRAKE SHOES, PADS, WHEEL CYLINDERS, BRAKE DRUMS, BRAKE LINE HOSES AND CONNECTORS. EACH OF THESE REPAIR SHOPS HAVE INFORMED ME THAT THE REPAIR/ REPLACEMENT OF MANY OF THESE VITAL COMPONENTS WOULD BE EXTREMELY COSTLY TO REPAIR AND COULD RESULT IN SERIOUS INJURIES OR CREATE A HAZARDOUS SITUATION FOR THE VEHICLE'S OPERATOR AND OTHER DRIVERS IF NOT REPAIRED IMMEDIATELY. THE VEHICLES BRAKES AND HARDWARE HAVE BEEN REPLACED MORE THAN THREE TIMES BY ASAE CERTIFIED /QUALIFIED...

WE HAD OUR LEFT REAR TIRE BLOW OUT AND IT TORE OFF OUR FUEL FILLER PIPE. I IMAGINE THIS COULD BE EXTREMELY DANGEROUS IF THE RIM HAD SPARKED IT COULD HAVE CAUGHT FIRE. *TR

WE LEFT THE HOUSE AND WAS DRIVING AND THE VAN FELT LIKE IT WAS SLIDING BACK AND FORTH. I STOPPED AND CHECKED AND THE BACK WHEEL WAS SETTING CROOKED. I CHECKED THE LUGS AND THE WERE TIGHT. WE TURNED AROUND WENT BACK HOME. I LOOKED UNDER IT AND FOUND THE AXLE CRACKED AND BROKE. WE CALLED FORD AND THEY HAD A RECALL ON THAT BUT SAID THEY WERE NO LONGER REPAIRING THEM. *TR

VEHICLE HAD VOLUNTARY RECALL DONE TO IT IN 2011. IT HAS NOW BROKEN IN SAME PLACE AS OTHERS HAVE EXPLAINED. RECALL IS A SHAM AND FORD IS GETTING AWAY WITH CONTINUING TO REPLACE WITH DEFECTIVE PARTS. PLEASE INVESTIGATE. *TR

INTERIOR LIGHTS FLASH ON AND OFF INCLUDING DASH LIGHTS TAKEN IN ON NUMEROUS OCCASIONS BUT PROBLEM STILL EXISTS TO THIS DAY. ABS AND BRAKE LIGHTS COME ON CONSTANTLY UP TO AND INCLUDING TODAY. NOISE THAT SOUNDS LIKE BONES CRUNCHING FROM STEERING WHEEL OR UNDER FOOT? AND BUZZING FROM RIGHT FRONT TIRE ON LEFT TURNS. TOOK INTO FORD DEALER FOR ALL COMPLAINTS, NEVER FIXED. *TR

ON 01/06/2011 I TOOK MY MINIVAN IN FOR THE RECALL ON THE AXLE. THEY TOLD ME IT WAS FINE AND SENT ME HOME. ON FRIDAY WHILE DRIVING ON NORTHLINE ROAD IN SOUTHGATE MICHIGAN, MY AXLE SNAPPED. I TOOK IT TO THE TAYLOR FORD AND THEY SAID IT WOULD BE FIXED BY FORD. I WAS TOLD TODAY 05/28/2013THAT THEY WOULD NOT COVER THE REPAIR DUE TO THE FACT THEY PUT BRACKETS ON IT IN 2011. I WAS NOT INFORMED OF THE FACT THEY PUT BRACKETS ON IT IN 2011. I WAS DRIVING A VEHICLE THAT WAS DANGEROUS ON THE FREEWAY. *TR

REAR AXEL BROKE. *TR

GOVERNMENT HAS NEVER ANSWERED ODO 10252007 (LIFE THREATENING FORD 2001 WINDSTAR AXLE DEFECT. *TR

OCCURRENCE: 12 OCTOBER 2010. TRAVELING I-95 WASHINGTON,DC/SUITLAND, MD. VEHICLE: FORD WINDSTAR, 2001. SPEED : 60-65 MPH. TRAFFIC : DENSE. FAILURE OF DEFECTIVE PART : REAR AXLE SNAPPED IN TWO PARTS WHILE TRAVELING ON SMOOTH HIGHWAY, NORTHBOUND. EXPLOSIVE SOUND , LOTS OF SMOKE, EXTREME CONSTERNATION/FEAR OF HEART ATTACK EXPERIENCED BY MY WIFE AND I ( MY WIFE HAS A DANGEROUS HEART CONDITION "IHSS") AT OCCURRENCE. I IMMEDIATELY TURNED ON HAZARD FLASHERS. MANAGED TO MANEUVER ACROSS SEVERAL LANES OF TRAFFIC TO GET TO HIGHWAY SHOULDER SAFELY!! THANK GOD FOR THE ALERT FELLOW TRAVELERS BEHIND US!!! IF WE WERE HIT BY ANY 18-WHEELERS ON THE HIGHWAY, I WOULDN'T BE WRITING THIS COMPLAINT NOW!!! CONCERN FOR OUR SAFETY WAS SHOWN TO US BY FELLOW TRAVELERS; PARTICULARLY, MD TRAFFIC SAFETY PERSON, WHO SHOULD BE COMMENDED BY HIS SUPERIORS FOR HIS PROFESSIONAL AND UNDERSTANDING ACTIONS!! HE LOOKED AT THE DAMAGE AND SAID THAT HE HAD NEVER...

REAR AXLE SNAPPED ON 2001 FORD WINDSTAR LX VAN WHILE DRIVING AT HIGHWAY SPEED. *TR

NORMAL DRIVING OF 2001 FORD WINDSTAR. REAR AXLE BROKE AND CAR WAS NON DRIVE ABLE. REAR AXLE DESIGN IS OBVIOUSLY BAD AND CAN CREATE A LIFE THREATENING CONDITION AS THE REAR WHEEL ASSEMBLIES WOULD FALL OFF. AT HIGHWAY CONDITIONS THIS WOULD BE CATASTROPHIC AND WOULD BE LIFE THREATENING. VERY POOR DESIGN THAT DOES NOT ALLOW ROAD CONDITIONS FOR A FACTORY AUTO WITH 8 SEATS. VERY BAD ESTIMATES OF PASSENGER WEIGHT AND SAFETY FACTORS. VEHICLE NEVER IN A HARD CRASH OR HARD DAMAGE. NEVER USED TO CARRY HEAVY EQUIPMENT OR NON ORDINARY FAMILY TRAVEL. DESIGN OF BACK WHEEL ASSEMBLY IS A FORMED METAL AND NOT A SOLID STRUCTURE TO MEET NORMAL HIGHWAY CONDITIONS. METAL SHEARED MOST OF THE WAY THROUGH. OBVIOUS DESIGN LIMITATIONS THAT WILL NOT MEET MULTIPLE PASSENGER OPERATIONS ON LOCAL ROADS AND HIGHWAYS. VERY-VERY DANGEROUS DESIGN AND FABRICATION SPECIFICATIONS. AXLE WAS WELDED TO MAKE IT SLOW ROAD WORTHY TO...

TL*THE CONTACT OWNS A 2001 FORD WINDSTAR. THE CONTACT NOTICED THAT THE TOP OF THE WHEEL WAS LEANING INWARD AND THE BOTTOM WAS LEANING OUTWARD. HE ALSO NOTICED THAT THE LINKAGE BETWEEN THE TWO WHEELS WAS CRACKED. THE CONTACT DROVE THE VEHICLE TO HIS RESIDENCE. THE DEALER AND MANUFACTURER HAVE NOT BEEN NOTIFIED. THE VEHICLE HAS NOT BEEN REPAIRED. THE VIN WAS UNKNOWN. THE CURRENT MILEAGE WAS 75,500 AND FAILURE MILEAGE WAS 75,000.

NO SUMMMARY LISTED FOR ABOVE VEHICLE. *AK