2010 FORD FLEX — Problems, Recalls & Safety Data

Leaving home to go to the grocery store and as I exited my street a dash warning came on stating "Power Steering Assist" fault Steering wheel locked up making it impossible for me to steer. Fortunately this happened in a spot where there was no other traffic and I was able to just turn off the car and restart and the message was gone and my steering was restored. I am now terrified to drive my car because if this had happened in traffic there could have been a serious accident because steering capability was non existent. . In reading online this is a very common problem with my make and model and apparently there was a recall by Ford for 2011 and later cars but not 2010 even though it is a "known problem" at dealerships. For me this now seems intermittent but in calling the dealership they know of the issue. It would cost me about $2200 to fix. I am happy to provide my vehicle for inspection. Thank you so much for your help ... greatly appreciated

On the road and power steering went out and was super hard to turn

Water ingress into rear side door latch - froze - door opened while car was in motion

The contact owns a 2010 Ford Flex. The contact stated while driving at an undisclosed speed, there was a metal clicking and scraping sound coming from underneath the vehicle. In addition, the contact stated that the wheels felt loose. The contact stated that a nearby driver informed her that sparks were coming from underneath the vehicle. The contact drove the vehicle to the shoulder of the road. The contact stated that a nearby driver identified that the rack and pinion had detached. In addition, the power steering fluid had leaked out onto the ground. The contact was driving on a busy highway during the failure occurred. The contact stated that her grandchildren were in the vehicle when the failure occurred. The vehicle was towed to the residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was made aware of the failure but provided no assistance. The contact was advised to contact the NHTSA Hotline to report the failure. The failure mileage was approximately 119,000.

While traveling at highway speeds 75+ a loud bang and then control of vehicle was hard to keep on road, swerved left then right, left rear quarter panel hit guard rail and caused car to spin around and went sideways and backwards down a 30 ft embankment. Fortunately did not roll. left side tires came off of rims and damage to driver side door was done. Highway Patrol had car towed to holding lot, where I then got car towed to my mechanic. The left side Lateral stabilizer Rod had broken due to rusted part, causing left rear wheel to go out of alignment. The rubber boot on the rod was attached, rust was internal would never had known about a problem. Had both lateral rods replaced tires re-balanced and alignment done.