2010 FORD FLEX Fuel System Gasoline Problems

THIS IS A HUGE SAFETY ISSUE WE HAVE RUN OUT OF GAS ON THE FREEWAY TWO TIMES THE GAUGE WILL SAY 70 MILES TO EMPTY AND 30 SECONDS LATER GOES TO ZERO THE CAR RUNS OUT IF GAS IN THE CAR SHUT DOWN ON THE FREEWAY WITH MY CHILDREN IN THE CAR I HAVE ALSO RUN OUT OF GAS ON THE STREET I TOOK IT AND PAY $200 TO A MECHANIC WHO IS NOT ABLE TO FIX IT THE FORD DEALER SAID THEY CAN'T FIGURE OUT WHAT'S WRONG WITH IT BUT RECOMMENDED A $700 FUEL SENDING UNIT HOWEVER THEY WERE UNSURE IF THIS WOULD FIX THE PROBLEM THIS IS A MAJOR SAFETY ISSUE A TIME HASSLE AND VERY STRESSFUL ON A FOUR-YEAR-OLD CAR THAT I'VE TAKEN VERY GOOD CARE OF. WHEN THIS HAPPENS AND I GO TO FILL UP THE TANK THE GAS TANK ISN'T ACTUALLY EMPTY EVEN THOUGH IT...

ORIGINAL OWNER 2010 FORD FLEX, ECOBOOST ENGINE: SUDDEN LOSS OF ENGINE POWER WITH SHUDDERING AND STALL IN FAST LANE; UP HILL WHILE PASSING AT SPEED, 60MPH TO 20MPH IN SECONDS CAUSING NEAR COLLISION FROM BEHIND. ENGINE WOULD NOT RECOVER, 20MPH IN FAST LANE WITH SEMI'S AND SPEEDING TRAFFIC, NO PULL-OFF AREA. CLEAR DRY DAY, TEMPERATURE AROUND 55 DEGREE. NOT THE FIRST TIME ENGINE SHUDDERING EXPERIENCED, BUT THE MOST DANGEROUS. ALWAYS OCCURS DURING ACCELERATION (PULLING OUT IN TRAFFIC OR PASSING, ETC.). BEGAN TO NOTICE LOSS OF POWER, WHINING AND GRINDING NOISES FROM TURBOS ABOUT TWO WEEKS AGO; SUBSEQUENT CATASTROPHIC FAILURE OF BOTH TURBO CHARGERS WITH BILLOWING BLACK SMOKE AND OIL DRIPPING FROM EXHAUSTS. 38K MILES, GARAGE KEPT, ALL SERVICE POINTS MAINTAINED, DRIVEN LIKE GRANDMOTHER SINCE NEW. FIST THE REAR BRAKES LOCKED UP WHILE DRIVING AT 18K MILES, NOW ENGINE FAILURE AT 38K. DO SOMETHING NTSB BEFORE THESE VEHICLES KILL SOMEONE! *TR

2010 FORD FLEX 2000 MILES. WHILE DRIVING @ 35 MILES PER HOUR , CHECK ENGINE LIGHT CAME ON AND CAR STALLED. GAS ACCELERATOR WAS INOPERABLE. OPERATOR WAS ABLE TO DRIVE INTO A PARKING LOT CLOSE BY AND BRING CAR TO A COMPLETE STOP WITHOUT ANY INCIDENT. CAR TURNED ON AFTER THE 5TH ATTEMPT. THE CHECK ENGINE LIGHT DISAPPEARED. THE 1ST OCCURRENCE, THE VEHICLE WAS ABLE TO BE STARTED RIGHT AWAY. THIS 2ND OCCURRENCE IT TOOK AWHILE. THEREFORE, VEHICLE WAS TAKEN TO THE DEALERSHIP ( NORTH PARK LINCOLN FORD IN SAN ANTONIO, TX )ON 06/09/10 AND OBD CAME BACK WITH NO DIAGNOSTIC CODES. DEALERSHIP STATED THAT FORD ENGINEER WAS ON PROPERTY AND COULD NOT FIND THE SOLUTION TO THE PROBLEM.. CAR IS STILL AT THE DEALERSHIP AND THEY HAVE NO IDEA WHAT TO DO. *TR

POST RE: FLEX DIED WHILE DRIVING DOWN THE ROAD THURS JUN 11, 2009 6:07 PM THE SAME THING HAPPENED TO MY MOM WHEN SHE WAS DRIVING HERS THROUGH A PARKING LOT, IT JUST STALLED OUT! SHE TOOK IT TO THE DEALER THE SAME DAY AND THEY SAID THEY DIDN'T FIND ANYTHING WRONG WITH IT. THIS WAS ABOUT A MONTH AGO AND SINCE THEN IT HAS NOT HAPPENED AGAIN. I HOPE YOU HAVE BETTER LUCK WITH YOUR DEALER FINDING THE PROBLEM. !@#$%!!!!!!!! IT HAPPENED TO ME TODAY!!!!!!! I WAS ON MY WAY TO A MEETING THIS MORNING AND AS I WAS GOING INTO A CURVE THE CAR DIED!!! KAPUT! DEAD! NO BRAKES, NO POWER STEERING!!!! THANK GOD THERE WAS NO ONCOMING TRAFFIC BECAUSE I WENT STRAIGHT INTO THE OTHER LANE. AND, THANK GOODNESS I HAD READ THIS POST A WHILE AGO SO I KNEW IMMEDIATELY WHAT HAD HAPPENED. I TWISTED THE...