2006 FORD F-250 SD Engine Problems

HEADS WENT BAD NOW I HAVE TO REPLACE THE HEADS AND NEW HEAD STUDS BECAUSE THE OLD HEAD STUDS STRETCHED AND THE HEADS WARPED , ALSO HAD TO DO AN EGR DELETE . I WAS TOLD IT WAS BUILT PROOFING AND IT HAS TO BE DONE TO ALL 6.0 LTRS.

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 5 MPH, SMOKE EMITTED FROM THE EXHAUST PIPE. THE VEHICLE WAS MOVED TO THE SHOULDER WHERE IT WAS SHUT OFF AND TOWED TO THE DEALER. THE TECHNICIANS DETERMINED THAT THE EGR VALVE, EGR COOLER AND OIL COOLER HAD FAILED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS 117,624.

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 65 MPH, SMOKE EMITTED FROM THE EXHAUST PIPE AND THERE WAS A SUDDEN LOSS OF ACCELERATION POWER. THE VEHICLE WAS MOVED TO THE SHOULDER AND TOWED TO THE DEALER WHERE IT WAS DETERMINED THAT THE FUEL INJECTORS AND TURBO HAD FAILED. THE VEHICLE WAS REPAIRED BUT THE FAILURE RECURRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 40,000.

ANY TIME I GET ON THE INTERSTATE PULLING MY 7000 GVW TRAILER, THE CHECK ENGINE LIGHT COMES ON. THE CODE IS ALWAYS THE SAME, UNDER/OVER BOOST AND THEN YOU LIMP ALONG FOR A FEW MILES AND IT WILL START WORKING AGAIN. DURING THIS TIME IT'S HARD TO MAINTAIN A CONSTANT SPEED. THE CHECK ENGINE LIGHT WILL COME ON WITHIN 10-15 MILES OF HIGHWAY USE AT AROUND 60 - 65 MPH. EVERY OWNER THAT I TALK TO THAT HAS THE 6.0 LITRE DIESEL TELLS ME THAT THEY ALL DO THIS AND THE ONLY WAY TO FIX IT IS TO INSTALL A EGR DELETE KIT AT AROUND $1,200.00. THIS WILL CURE THE PROBLEM BUT WILL POLLUTE THE AIR MORE. IT'S JUST A BAD DESIGN AND FORD'S NOT GOING TO DO ANYTHING ABOUT IT UNLESS THE NHTSA STEPS IN. *TR

TL* THE CONTACT OWNS A 2006 FORD F-250 SD. THE CONTACT STATED THAT AFTER CHECKING THE COOLANT RESERVOIR, HE NOTICED THAT THERE WAS A COOLANT LEAK. THE VEHICLE WAS INSPECTED AT A PRIVATE REPAIR SHOP, WHO DETERMINED THAT THE HEAD GASKETS WERE DEFECTIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND OFFERED NO FURTHER ASSISTANCE. THE FAILURE MILEAGE WAS 75,000. THE CURRENT MILEAGE WAS 84,000.

TL* THE CONTACT OWNS A 2006 FORD F-250. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE WAS TOWED TO A LOCAL MECHANIC. THE CONTACT WAS NOT AWARE OF THE REPAIR PERFORMED HOWEVER, THE FAILURE PERSISTED AFTER REPAIRS. THE FAILURE WAS NOT REMEDIED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. *TR

TL* THE CONTACT OWNS A 2006 FORD F250 SUPER DUTY. THE CONTACT STATED THAT THE VEHICLE STALLED NUMEROUS WITHOUT WARNING AND WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE HEAD GASKET, EGR VALVE, AND THE GO PLUG BOX WERE REPLACED. THE FAILURE WAS NOT CORRECTED. THE VEHICLE CONTINUED TO STALL WITHOUT WARNING AND THE ENGINE COULD NO LONGER BE STARTED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND DENIED ASSISTANCE WITH THE REPAIR. THE FAILURE MILEAGE WAS 130,000 AND THE CURRENT MILEAGE WAS 140,000.