2001 FORD F-250 SD Engine And Engine Coolingenginediesel Problems

1.1 MILLION FORD 7.3L TURBO DIESELS RECALLED UNDER FORD RECALL 07S57 FOR MODEL YEARS 1997-2003 FOR CAMSHAFT POSITION SENSOR PROBLEM WHICH CAUSES ENGINE TO CUT OFF WHILE RUNNING; HOWEVER WHEN I TAKE MY 2001 F250 DIESEL IN WITH SAME ENGINE EXHIBITS SAME PROBLEMS; FORD DEALER TOLD ME MY TRUCK WASN'T COVERED BY THE RECALL BECAUSE OF THE "COLOR" OF THE SENSOR THAT WAS IN MY TRUCK. I HAD IT REPAIRED ANYHOW BECAUSE I HAVE BEEN EXPERIENCING THE PROBLEM FOR 8-10 MONTHS AND HAVE BEEN EXTREMELY CAUTIOUS WHEN USING THE TRUCK CROSSING INTERSECTIONS AND THE LIKE DUE TO THE ENGINE CUTTING OUT. I THINK IT RIDICULOUS THAT THEY RESTRICT THE RECALL EVEN THOUGH MINE EXHIBITS THE IDENTICAL SYMPTOMS. WHILE AN INEXPENSIVE REPAIR, I DOUBT I SHALL BUY ANOTHER FORD TRUCK NOW AFTER HAVING OWNED 3 OF THEM IN THE PAST. *TR

CAM POSITION SENSOR FAILED ON MY 2001 FORD F-250 7.3L DIESEL WHILE DRIVING ON I-495 IN VA. FAILURE WAS WITHOUT WARNING WHICH CAUSED THE ENGINE TO IMMEDIATELY SHUT DOWN, THUS CAUSING SEVERELY REDUCED STEERING AND BRAKING. *TR

HAVING JUST REPLACED THE CPS ON MY 2001 FORD F-250 PSD AT THE FORD DEALER AT AROUND 29,000 MILES, THE FAMILY AND I DEPARTED ON VACATION TO A LAKE IN CENTRAL OREGON PULLING A 24FT TRAVEL TRAILER (7000 LBS). ARRIVING TO THE LAKE REQUIRES A STEEP DECENT INTO A CANYON, ROCK WALL ON ONE SIDE AND SHEAR DROPOFF ON THE OTHER. AT THE BEGINNING OF THE DECENT MY TRUCK JUST DIED, BRAKES AND STEERING BEGAN TO FAIL (NO PRESSURES), WHITE KNUCKLE IS PUTTING IT LIGHTLY, I ENDED UP TURNING OVER THE STATER FREQUENTLY TO GET PRESSURES BACK TO THE PUMPS TO KEEP THE TRUCK UNDER CONTOL. ONCE AT THE BOTTOM OF THE CANYON WE STOPPED AND I CYCLED THE IGNITION SWITCH IT STATED RIGHT UP, NO PROBLEMS FOR THE REST OF THE TRIP. I HAD NUMEROUS FAILURES SINCE THEN AND HAVE REPLACED THE CPS MYSELF WITH GOOD RESULTS UNTIL JUST...

CONCERNING: 2001 FORD F-250 7.3 DIESEL. FORD HAS PATTERN CAM POSITION SENSOR FAILURE THAT CAUSES ENGINE TO SHUT OFF WHILE TRAVELING AT SPEED. THIS RESULTS IN LOSS OF BRAKES AND STEERING. THE CAM POSITION SENSOR IN MY TRUCK FAILED WITH 75,00 MILES. FORD IS AWARE OF THIS PROBLEM BUT HAS DONE NOTHING TO RECTIFY THE CAUSE OF THE FAILURE. WHEN THE ENGINE SHUTS DOWN WITHOUT WARNING. IT'S VERY UNNERVING AND UNSAFE. DRIVING ON A CROWDED ROADWAY/FREEWAY WITH SUDDEN ENGINE SHUTDOWN AND LOSS OF POWER, BRAKES, AND STEERING IS FLAT OUT SCARY AND DANGEROUS. *TR

2001 7.3 POWERSTROKE INTERMITTENTLY STALLS. THIS GOING TO GET SOMEONE KILLED. I HAVE BEEN TOLD THAT THIS IS A PROBLEM WITH THE CPS. WHEN THE ENGINE STALL I HAVE NO CONTROL OVER THE F250 SD CREWCAB CAN'T TURN CAN'T STOP UNTIL I RESTART THE ENGINE. I REPLACE THE CPS AND THIS HAS STOPPED FOR NOW UNTIL THIS CPS FAILS. *TR

I HAVE HAD TO REPLACE 4 CAM POSITION SENSORS IN MY 2001 FORD F250. ALL OF THE SENSORS FAILED WHILE DRIVING WHICH CREATED A DANGEROUS SITUATION BECAUSE WHEN THEY DIE THE VEHICLE ACTS AS IF THE KEY HAS BEEN TURNED OFF WHICH MEANS YOU LOSE EVERYTHING INCLUDING POWER STEERING AND POWER BRAKES. I FEEL VERY LUCKY THAT NOBODY WAS INJURED AND ALSO LUCKY THAT I WAS NOT PULLING A TRAILER AT THE TIME. *TR

THE "CAM POSITION SENSOR" ( CPS ) ON 2001 FORD 7.3L DIESEL FAILED. THIS CAN CAUSE LOSS OF CONTROL AS THE ENGINE DIES THUS LEAVING NO POWER STEERING OR BRAKES. *TR

I RECENTLY BOUGHT A USED 2001 FORD F-250 WITH THE 7.3 DIESEL FROM THE LOCAL FORD DEALER. IT HAD A RECENT COMPUTER REFLASH, SHOULD HAVE TOLD ME SOMETHING. ANYWAY THE CPS WAS BAD IN IT. IT WOULD SHUT DOWN, SOMETIMES STARTING RIGHT BACK, SOMETIMES AFTER A FEW MINUTES. I GOT TIRED OF THE RUN AROUND SO I PUT A NEW CPS IN IT MYSELF. I HAVE HAD NO MORE PROBLEMS, NO THANKS TO FORD. *JB

CAM SHAFT POSITION SENSOR HAS FAILED 2 DIFFERENT TIMES ON A 2001 POWERSTROKE FORD F250. FIRST TIME WHILE DRIVING THROUGH A PARKING LOT. SECOND TIME ON THE ROAD AT HIGHWAY SPEEDS. VEHICLE WAS DIFFICULT TO STOP AND STEER DUE TO LOSS OF POWER STEERING AND POWER BRAKES. *TR

CAM POSITION SENSOR FAILURE, INTERMITTENT STALLING LOSS OF STEERING AND BRAKES. *NM

TRAVELING AT NORMAL SPEED. THE ENGINE WOULD SHUT OFF, AS IF IT HAD RUN OUT OF FUEL.. AFTER DOING THIS THREE TIMES, I REPLACED THE CAM SHAFT SENSOR. I HAVE HAD NO PROBLEM SINCE. *JB

MY 2001 F-250 DIESEL WILL SOMETIMES STALL AT TRAFFIC SIGNALS WITH THE LEFT TURN SIGNAL ON. IT DID IT 3 TIMES TODAY (JUNE 22, 2006) IT HAS APPROX 106,000 MILES ON IT. *NM

DRIVE A 2001 FORD F250 4WD STRETCH CAB PICKUP WITH A 7.3L DIESEL ENGINE. IT IS USED PRIMARILY FOR TOWING A TRAVEL TRAILER. THE TRUCK IS WELL MAINTAINED AND HAS JUST OVER 55,000 MILES ON IT. RECENTLY ON A TRIP TO NEVADA, WITHOUT OUR TRAVEL TRAILER, THE TRUCK ACTED AS IF IT WERE NOT GETTING ADEQUATE FUEL 3 TIMES AND THE ENGINE SHUT OFF COMPLETELY TWICE. ALL OF THIS ON A BUSY INTERSTATE HIGHWAY. FORTUNATELY, WHEN IT SHUT OFF I WAS ABLE TO KICK IT INTO NEUTRAL AND RESTART THE ENGINE. WHEN I TOOK THE TRUCK TO MY DEALER A PART WAS REPLACED AND I WAS TOLD THAT MY PROBLEM WAS NOT UNCOMMON WITH THIS DIESEL ENGINE. PART REPLACED WAS A CAMSHAFT SENSOR. DON'T KNOW WHAT HAPPENED TO THE DEFECTIVE PART. COST OF REPAIR - PARTS AND LABOR - $261.71 - PARTLY COVERED BY AN EXTENDED WARRANTY THAT I HAD...

WE HAVE A 2001 FORD F-250 SD TRUCK THAT HAS HAD 3-4 TRANSMISSION FAILURES SINCE WE HAVE OWNED IT. THE TRANSMISSION DETERIORATES 3-4 MONTHS AFTER THE WARRANTY EXPIRES. ON MONDAY, MAY 29, 2006 WE WERE IN A HAY FIELD PICKING UP HAY WHEN THE TRANSMISSION EXPLODED AND CAUGHT FIRE WITH NO WARNING. *JB

2001 FORD SUPER DUTY PICKUP WITH 7.3 DIESEL, WHILE DRIVING DOWN HIGHWAY THE MOTOR WILL STOP RUNNING,WHICH WILL EFFECT THE POWER STEERING AS WELL AS THE BRAKES. I HAD THE FORD COMPANY CHECK FOR THE PROBLEM, IT WAS THE CAMSHAFT POSITION SENSOR, AFTER CHECKING WITH OTHER SOURCES, THIS IS A COMMON OCCURRENCE WHICH SHOULD BE CORRECTED. *JB

2001 F250 DIESEL STALLED WITHOUT WARNING TODAY. IT DID RESTART, THEN STALLED AGAIN. THEN RESTARTED AND STALLED A THIRD TIME. I'M ATTEMPTING TO DRIVE IT TO THE FORD DEALERSHIP TOMORROW. I UNDERSTAND THERE HAS BEEN SIMILAR RECALL ON A LATER MODEL. THE VEHICLE DID SEEM TO HESITATE SEVERAL TIMES YESTERDAY BUT DID NOT STALL. *NM

DRIVING ALONG BUSY ROAD WAY RUNNING FINE, THEN THE MOTOR JUST SHUT DOWN. LEFT STRANDED RIGHT IN THE MIDDLE OF THE ROAD. COULD NOT BE RESTARTED, TRUCK WAS TOWED TO GARAGE. CAM SHAFT SENOR REPLACED. *JB

I HAVE A 2001 FORD F250 SUPER DUTY WITH A 7.3L POWERSTROKE DIESEL ENGINE. OVER THE LAST 18 MONTHS I HAVE HAD NO LESS THAN 4 CAM POSITIONING SENSORS FAIL. ON TWO OF THESE OCCASIONS THE PART FAILED SLOWLY CAUSING INTERMITTENT ENGINE PROBLEMS. THE TRUCK WOULD RUN ROUGH AND LOOSE ALL POWER. ON THE TWO REMAINING OCCASIONS THE PART FAILED IMMEDIATELY AND PUT MY LIFE IN IMMEDIATE DANGER. ON ONE OF THESE FAILURES I WAS TOWING A 12,000 LB FIFTH WHEEL TRAILER, ON THE INTERSTATE AT 65 MPH. MY ENGINE STALLED (STOPPED RUNNING COMPLETELY) WITH NO WARNING AND LEFT ME WITH NO POWER BRAKES AND NO POWER STEERING. THE ONLY THING THAT SAVED ME WAS THE LOCATION OF THE INCIDENT. IT HAPPENED ON A LONG STRAIGHT AWAY. IF IT HAD HAPPENED IN THE MOUNTAINS, ON A HILL OR ON A CURVE I WOULD HAVE SURELY CRASHED. THE SECOND FAILURE OCCURRED...

DIESEL EMISSIONS GETTING INTO CABIN AT TOXIC LEVELS. WHILE CLEANING OUT THE INSIDE OF MY DECEASED FATHERS F250 SUPER DUTY DIESEL, I NOTICED A BROWN HAZE COVERING THE THE FRONT SEAT AND NOTICED AT THE BOTTOM OF THE SEATBELTS, THEY WERE COVERED HEAVILY WITH DIESEL SOOT. I SENT OFF TO LAB FOR ANALYSIS AND THE RESULTS OF THE FIRST TEST WERE AS FOLLOWS: DIESEL RANGE ORGANIC GC/CARBON DISTRIBUTION 508MG/L. *AK