2001 FORD F-250 SD Engine And Engine Coolingengine Problems

TL* THE CONTACT OWNS A 2001 FORD F-250 SD. THE CONTACT STATED THAT WHILE ACCELERATING FROM A STOP, SMOKE WAS SEEN COMING FROM UNDER THE FRONT HOOD OF THE VEHICLE. THE DEALER DIAGNOSED THAT THE SPARK PLUG HAD SEPARATED FROM THE ENGINE. THE DEALER REPLACED THE ENGINE NUMEROUS TIMES, BUT THE FAILURE CONTINUOUSLY RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ANY ASSISTANCE WITH REPAIRS TO THE VEHICLE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 98,000 AND THE CURRENT MILEAGE WAS 103,000. UPDATED 05/08/12*LJ UPDATED 05/14/12

ON VACATION IN MAINE WITH MY 2001 FORD F250 SUPER DUTY I WAS DRIVING DOWN A VERY NARROW, HEAVILY WOODED TWO LANE ROAD AT ABOUT 20 MPH, SUDDENLY AND WITHOUT WARNING A LOUD BANG UNDER THE HOOD OCCURRED. DIFFICULT TO PULL OVER SAFELY AND INVESTIGATE. I HAD TO DRIVE SEVERAL HUNDRED FEET TO TRY TO GET ON A STRAIGHT AWAY FOR SAFETY. THERE WERE SEVERAL LOG TRUCKS THAT HAD TO PASS AS WELL AS OTHER TRAFFIC. I DISCOVERED THAT THE #6 SPARK PLUG HAD "BLOWN OUT" OF ITS HOLE AND DESTROYED THE THREADS, COIL PACK, AND SPARK PLUG. AFTER GETTING THE TRUCK TO A REPAIR FACILITY THE OWNER/MECHANIC INFORMED ME THAT THIS 5.4L TRITON ENGINE DOES THIS ALL THE TIME. HE INFORMED ME THAT HE REPAIRS TWO OR THREE OF THESE A WEEK, IN FACT THERE IS A "REPAIR KIT" AVAILABLE FROM MOST AUTO PART STORES. DOING SOME RESEARCH AFTER...

WHILE DRIVING MY 2001 FORD F250 5.4 L V8 ENGINE POWERED TRUCK THE SECOND (2ND) SPARK PLUG ON THE PASSENGER SIDE OF THE ENGINE BLEW OUT (WAS EJECTED) FROM THE HEAD. THIS WAS AN ORIGINAL SPARK PLUG ON THE 2001 F250 TRUCK WITH 75300 ORIGINAL MILES ON IT. *KB

SPARK PLUG EJECTED FROM THE MOTOR WHILE DRIVING. BLEW OUT THE COIL AND STRIPPED THE THREADS. 5.4 LITER TRITON ENGINE WITH 122,000 MILES. *TR

TL*THE CONTACT OWNS A 2001 FORD F-250 SD. WHILE THE VEHICLE WAS PARKED, THE CONTACT NOTICED THAT THERE WAS A SIGNIFICANT AMOUNT OF OIL LEAKING FROM MULTIPLE LOCATIONS IN THE OIL PAN . THE DEALER WAS CONTACTED AND STATED THAT THE OIL PAN WAS COVERED WITH RUST AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED AT THE OWNERS EXPENSE. THE FAILURE MILEAGE WAS 157000 AND THE CURRENT MILEAGE WAS 157752.

I WAS IN MY FORD F250 V10 TRITON SITTING IDLE AT A RED LIGHT WHEN I HEARD A LOUD POP UNDER MY HOOD WHICH WAS FOLLOWED BY A STEAM ENGINE SOUND WHEN I ACCELERATED. HAD IT TOWED TO A MECHANIC AND FOUND THAT MY FACTORY SPARK PLUG HAD BLOWN OUT OF THE HEAD. THE MECHANIC TOLD ME THIS HAPPENS OFTEN WITH FORD TRITON MOTORS. THE MECHANIC USED A HELICOIL TYPE TOOLING TO RETAP THE HOLD AND FIT A COLLAR IN IT THAT WOULD ACCEPT A NEW SPARK PLUG. THE COST WAS ABOUT $300 BUT THE FACT THAT THIS HAPPENS SO OFTEN FOR THIS PARTICULAR MANUFACTURER SEEMS TO ME THAT THEY SHOULD BARE THE COST FOR EACH OCCURRENCE. *TR

MY 2001 F 250 SUPER DUTY PICK UP WITH A 5.4 MOTOR SPIT OUT THE NUMBER 3 SPARK PLUG. IT CAUSED ME TO HAVE MY VEHICLE TOWED, THE # 3 COIL PACT REPLACED ALONG WITH ALL THE SPARK PLUGS AND THE COIL PACT BOOTS. I HEARD A LOUD POP WHICH CAUSED ME TO PULL OVER IMMEDIATELY , IT SOUNDED LIKE A REAL BAD EXHAUST LEAK. I HAVE NEVER HAD ANYTHING LIKE THIS HAPPEN TO ME IN 28 YEARS OF DRIVING AND WORKING ON VEHICLES. THE DEALER HAVE TO PUT IN A HELI COIL AND REPLACE PARTS AS STATED.

I OWN A 2001 FORD F250 SUPER DUTY WITH A 5.4L TRITON V-8 ENGINE, AUTOMATIC TRANSMISSION, 2WD, 137 INCH WHEELBASE, STANDARD EMISSION, WITH NO AFTERMARKET MODIFICATIONS AND APPROXIMATELY 114,000 MILES. I WAS DRIVING AT APPROXIMATELY 60MPH WHEN I HEARD A LOUD BANG FROM UNDER THE HOOD, THE ENGINE LOST POWER AND SOUNDED LIKE THE EXHAUST HAD COME OFF THE ENGINE. UPON INSPECTION, I DISCOVERED THAT THE NUMBER 8 SPARK PLUG HAD BLOWN COMPLETELY OUT OF THE ENGINE AND DAMAGED THE IGNITION COIL. THE THREADS WHERE THE SPARK PLUG SCREW INTO THE HEAD WERE DAMAGED, BUT REPAIRABLE. I REPLACED THE SPARK PLUG AND COIL. EVEN THOUGH THERE WAS NO FIRE OR INJURY IN MY PARTICULAR CASE, THE POSSIBILITY FOR SUCH IS LIKELY IF THIS PROBLEM IS SYSTEMIC. WHEN THE SPARK PLUG BLOWS OUT OF THE CYLINDER HEAD, IT CAN BE DONE WITH A LOT OF FORCE, WHICH COULD CAUSE INJURY/DEATH, DEPENDING...

THE ENGINE BLEW OUT ANOTHER SPARK PLUG! THIS IS A MAJOR DESIGN DEFECT! FORD SAID THE PLUGS BLOW OUT DUE TO IMPROPER TORQUE OF THE SPARK PLUGS. WHICH IS IMPOSSIBLE SINCE I USED THE FORD REQUIRED TORQUE ON MY SPARK PLUGS AND I USED ANTI SEIZE ON THE PLUGS THREADS! THIS IS A ONGOING PROBLEM! I KNOW A PERSON THAT HAS ONLY 50K ON THERE 5.4 ENGINE AND THE FACTORY INSTALLED PLUGS AND THOSE BLEW OUT TOO!! FORD NEEDS TO RECALL THESE ENGINES AND CORRECT THE PROBLEM. I PULLED BOTH OF THE HEADS OFF MY F-250 AND HAD STAINLESS STEEL THREADED SLEEVES INSTALLED AT THE MACHINE SHOP ! HOPE THIS TAKES CARE OF THE PROBLEM! I DON'T TRUST THE TRUCKS ENGINE DESIGN FOR A LONG TRIP OR EVEN TAKE IT ON VACATION! I AM WORRIED THE SPARK PLUGS WILL BLOW OUT WHILE I AM ON THE HIGHWAY OR OUT OFF...

I WAS ON A DELIVERY WITH MY 2001 FORD F 250 V10 WITH 8 THOUSAND MILES, WHEN I HEARD WHAT I THOUGHT WAS TAPPET NOISE THEN I HEARD A POP AND THEN REALY LOUD EXHAUST NOISE LIKE I LOST A EXHAUST MANIFOLD SEAL, I PULLED OVER TO FIND I HAD A SUDDDEN SPARK PLUG BLOW OUT, I WAS ON A DELIVERY AND WORK IN THE HOLLYWOOD ANDTHE PRODUCTION NEEDED ME AT LOCATION ON TIME, SO I DROVE IT THERE AFTER I ISOLATED T HE SPARK PLUG WIRE FROM GROUNDING BY FLOATING IT IN AIR BY PURRING IT THREW THE OIL DIP STICK, I DROVE ON WITH THE 9 REMAINING CYLINDERS AND MADE MY DELIVERY, I WAS OUT 250 MILES AND HAD TO RETURN TO LA FOR A CHILD CUSTODY HEARING SO I DROVE IT BACK THE WHOLE WAY SOUNDING LIKE A TUG BOAT, IT WAS LIKE I WAS LINDBERG CROSSING...

2001 FORD F-250 SD 6.8L V-10, SPARK PLUG ON THE NUMBER EIGHT CYLINDER BLEW OUT OF THE HEAD WHILE DRIVING AT APPROX. 15-20 MPH. THE THREADS ON THE CYLINDER HEAD ARE NON-EXISTENT AT THIS POINT, THE COIL WAS DESTROYED, AND THE VEHICLE IS UNDRIVABLE. AFTER RESEARCHING, I HAVE FOUND THIS TO BE A KNOWN PROBLEM ON SEVERAL MODELS FROM FORD. THE VEHICLE IS CURRENTLY AWAITING INSPECTION AND REPAIR BY A LOCAL FORD DEALERSHIP. I HAVE BEEN TOLD BY THE SERVICE WRITER THAT IT IS A KNOWN PROBLEM, BUT THAT FORD WILL NOT PROVIDE A COVERED REPAIR. I HAVE BEEN TOLD THAT IF THE HEAD IS REPAIRABLE WITHOUT REMOVAL FROM THE VEHICLE, THE COST WILL BE APPROX. $750.00 WITH NO GUARANTEE THAT IT WILL NOT RE-OCCUR. IF THE CYLINDER HEAD MUST BE REMOVED, THE COST IS BETWEEN THREE AND FOUR THOUSAND DOLLARS. I WILL BE RETAINING THE OLD PARTS. *TR

FORD F250 TRYTON V-8 BLOWN PLUGS ON INTERSTATE 80 MILES FROM HOME. FORD DEALER SAYS THE JUST ISSUED A SERVICE BULLETIN CONCERNING THIS BUT ARE OF NO HELP. THE HEADS MUST BE REMOVED AND REPAIRED WITH HELICOIL KITS @ UPWARDS OF 800.00 OR MORE. PLEASE REQUIRE A RECALL !!!!! *TR

I OWN A 2001 FORD F-250 PICK UP WITH A 5.4 LITER ENGINE. THE SPARK PLUG BLEW OUT THE FIRST TIME IN THE SUMMER OF 2008. THEN AGAIN IN AUGUST OF 2009. THE FIRST TIME IT WAS REPAIRED WITH THE HELICOIL REPAIR KIT AS SUGGESTED BY FORD. THIS TIME, THERE WAS NO OPTION BUT REPLACING THE HEAD OR THE ENTIRE ENGINE. THIS IS A SERIOUS AND VERY EXPENSIVE PROBLEM. AND SEEMS TO BE TOO COMMON. AFTER SOME RESEARCH OVER 17,000 VEHICLES HAVE HAD THIS SAME PROBLEM, I BELIEVE THIS IS A GOOD REASON TO RECALL THESE VEHICLES. THIS IS RIDICULOUS. FORD IS OF NO HELP ON WHAT TO DO THE SECOND TIME THIS HAPPENS BUT THEY WILL THROW A $3000.00 REPAIR BILL AT YOU. *TR

TL*THE CONTACT OWNS A 2001 FORD F250 SUPER DUTY. THE CONTACT STATED THAT THE MODULE THAT CONTROLS THE FUEL INJECTORS HAS FAILED. THE MANUFACTURER STATED THAT THEY NEEDED TO BE REPLACED. THE VEHICLE HAS EXPERIENCED MAJOR ISSUES WITH THE CAMSHAFT SENSOR AND THE MANUFACTURER WILL NOT ASSIST. THE FAILURE MILEAGE WAS 60,174.

MY 2001 F250 WITH 5.4L TRITON ENGINE HAS BLOWN OUT 4 SPARK PLUGS OVER THE LAST YEAR. EACH REPAIR HAS BEEN AROUND $600. THIS HAS TO BE A DEFECT. FORD DIDN'T ADVISE ME THAT THIS WAS A COMMON ISSUE. HAD I KNOWN, I WOULD HAVE PUT IN A DIFFERENT MOTOR OR HEADS AS I HAVE SPENT THAT MUCH IN REPAIRS AND TOWING. *TR

SPARK PLUG BLEW OUT OF MY 6.8L V-10 FORD F-250. CAUSED EXTENSIVE DAMAGE AND SMALL FIRE. *TR

I HAVE A 2001 FORD F250 SUPER DUTY TRUCK WITH THE 7.3L DIESEL ENGINE, I HAD TO HAVE THE CAMSHAFT SENSOR REPLACED AT MY OWN EXPENSE AT THE LOCAL FORD DEALERSHIP AT A COST OF NEARLY $1,100.00. WHEN THE RECALL NOTICE CAME IN THE MAIL, I CALLED AND MADE APPOINTMENT TO HAVE IT CHECKED AND SURE ENOUGH THE NEW CAMSHAFT SENSOR WAS THE CORRECT ONE. THE FORD MOTOR COMPANY DEALER ONLY ISSUED ME A $300.00 REFUND. WHAT IS RIGHT ABOUT THAT. *TR

TL*THE CONTACT OWNS A 2001 FORD F-250 SD. WHILE DRIVING 50 MPH, THE VEHICLE POWERED DOWN AND STOPPED OPERATING WITHOUT WARNING. THE DEALER STATED THAT THE CAM SENSOR FAILED (PART #: F71Z-12K073-A). THE DEALER INSTALLED A NEW CAM SENSOR. THE COMPONENT FAILED FOUR MORE TIMES. THERE WAS A NHTSA INVESTIGATION (ACTION #: PE06011) THAT WAS CLOSED WITH NO RECALL. THE CURRENT MILEAGE WAS 98,000 AND FAILURE MILEAGE WAS 300.

I HAVE A 2001 F250 7.3 DIESEL THAT HAS STALLED OR DIED USUALLY AT LOW SPEEDS WHILE TRYING TO STOP OR TURN A CORNER. RESULTING IN A LOSS OF POWER STEERING AND POWER BRAKES. THE CHECK ENGINE LIGHT HAS NEVER COME ON. I HAVE TAKEN IT TO A MECHANIC AND WAS TOLD IF THE CHECK ENGINE LIGHT WAS NOT ON HE COULD NOT CHECK FOR A TROUBLE CODE. HE ALSO SAID IT MOST LIKELY IS A CAMSHAFT POSITION SENSOR. I CHECKED WITH FORD,THEY WANT OVER $500.00 TO REPLACE IT. THE TRUCK IS NOW OUT OF WARRANTY AND I DON'T WANT TO SPEND $500.00 AND THAT NOT FIX THE PROBLEM. *NM

SPARK PLUG POPPED OUT OF ENGINE. ONCE I CHECKED THE ENGINE I FOUND THAT THE SAME THING HAD OCCURRED ON THE DIRECT OPPOSITE CYLINDER BEFORE. *NM

SPARK PLUGS BLOWING OUT OF CYCLINDER HEAD. *NM

I TOO HAVE A 2001 F-250 WITH THE TRITON V-10 THAT HAD A PLUG BLOW FROM THE CYLINDER. IT DESTROYED THE CYLINDER THREADS AS WELL AS THE SOLENOID. FORD IS OBVIOUSLY AWARE OF THIS PROBLEM AS THEY HAVE AVAILABLE A REPAIR KIT. *NM

SPARK PLUG BLEW OUT OF ENGINE 5.4 TRITON FORD SD 250 200. *NM

I OWN A FORD F 250 SUPER DUTY PICKUP WITH THE 5.4L MOTOR AND WHILE DRIVING, THE SPARK PLUG ON THE PASSENGER SIDE, #3, BLEW OUT OF THE SOCKET AREA. I WAS FORCED TO HAVE A FORD DEALERSHIP REPAIR THE PROBLEM AND NOW HAVE HAD A SECOND, FOLLOW UP INCIDENT, WITH THE SAME CYLINDER, RESULTING FROM THE ORIGINAL REPAIR. I UNDERSTAND THAT THIS HAS BEEN AN ONGOING PROBLEM WITH THESE MOTORS (AMONG OTHER CHRONIC PROBLEMS) AND NOTICED THAT CALIFORNIA IS NOW PAVING THEY WAY TO SOME SORT OF COMPENSATION. THE DEALER EVEN TOLD ME THAT THIS HAS HAPPENED IN OTHER TRUCKS. AFTER RESEARCHING THE ISSUE, I HAVE FOUND THAT IT IS FAIRLY WIDESPREAD. I WOULD LIKE TO BE INCLUDED IN ANY ACTION ON BEHALF OF VEHICLE OWNERS THAT WOULD ELIMINATE THE ISSUE AND REFUND MONIES SPENT ON REPAIRS. *JB

FORD NEEDS TO DO A RECALL ON THE CAM POSITION SENSOR. IF THIS PART FAILS ON THE SUPER DUTY DIESEL AT HIGHWAYS SPEEDS, A CRASH COULD OCCUR RESULTING IN SERIOUS INJURY OR DEATH TO THE OCCUPANTS OF THE VEHICLE OR ANY OTHER VEHICLE THAT THE SUPER DUTY MAY COME IN CONTACT WITH. I WAS DRIVING AT 75 MPH WHEN THE ENGINE SUDDENLY DIED DUE TO CPS FAILURE. THE TRUCK SLOWED SO FAST I ALMOST HIT THE WINDSHIELD. THE ENGINE WOULDN'T RESTART. OTHER MOTORIST SAW ME IN TROUBLE AND LET ME PULL TO THE RIGHT SHOULDER. STEERING THE TRUCK REQUIRED "SUPERMAN" STRENGTH. I SCRAPPED MY TRUCK AGAINST THE GUARD RAIL. FORTUNATELY I WASN'T TOWING 6,000 LB LIKE I NORMALLY DO AT THAT TIME. NOW I KEEP A SPARE CPS AND A 10 MM SOCKET IN MY TRUCK.

WHILE DRIVING HOME WITH 4 KIDS IN OUR FAMILY F250 FORD PICK UP TRUCK A LOUD NOISE, WHICH SOUNDED LIKE GUNFIRE, CAME FROM THE TRUCK. I STOPPED AS FAST AS I COULD AND HAD ALL OF MY KIDS RUN FOR SAFETY. I CALLED MY BROTHER N LAW AND WAS SCREAMING HYSTERICALLY THAT I THOUGHT SOMEONE HAD BEEN SHOOTING AT ME. HE STARTED LAUGHING AT ME AND WAS QUITE FAMILIAR WITH WHAT WAS GOING ON BECAUSE THIS WAS A COMMON THING WITH FORD. THE SPARK PLUG ACTUALLY BLEW OUT OF THE HEAD. I CONTACTED FORD AND THEY JUST BRUSHED ME OFF, THIS IS A VERY SERIOUS PROBLEM THAT SPARK PLUG COULD OF CAME THROUGH THE WINDSHIELD AND KILLED ONE OF MY KIDS SOMETHING NEEDS TO BE DONE. *JB

MY HUSBAND AND I HAVE A FORD F-250 V10 2001. AT 62000 MILES, THE ENGINE BEGAN TO MAKE AN INCREDIBLE NOISE IN THE LOWER END. WE IMMEDIATELY WENT TO THE FORD DEALERSHIP AND WERE TOLD THAT WE NEED TO REPLACE THE LONG BLOCK. SINCE WE ARE 12000 MILES OVER WARRANTY, WE WOULD NEED TO COME UP WITH $5700 PLUS LABOR. I HAVE SEEN NUMEROUS SITES WHERE PEOPLE ARE HAVING PROBLEMS WITH THEIR V10 AND FORD WILL REPLACE THE ENTIRE ENGINE, IF UNDER WARRANTY. FORD RECALLED AND REPLACED OUR TRANSMISSION LAST YEAR, BUT IT DID NOT HELP WITH THE ENGINE. PLEASE HELP US, I KNOW 10 OTHER PEOPLE WITH THE SAME PROBLEM, WE ARE ALL FRUSTRATED AND UNABLE TO DRIVE OUR VEHICLES. *LA

ENGINE HAS BEGUN TO IDLE AT VERY LOW RPM'S, TO THE POINT WHERE IT HAS TO BE DRIVEN WITH BRAKE AND GAS PEDAL BOTH BEING DEPRESSED TO STOP OR SLOWING DOWN. THE RPM'S HAVE DROPPED TO 400 AT IDLE SPEED. THE VEHICLE WORKS PERFECTLY FINE AT 600 AND ABOVE WITHOUT MISSING OR HESITATION, BUT WHEN COMING TO A STOP OR SLOWING DOWN, AND THE RPM'S DROP BELOW 600, THE ENGINE WILL SHUT OFF. THE PROBLEM OR POTENTIAL HAZARD IS THAT THE POWER STEERING DISABLES AND BRAKES ARE VERY HARD AND THIS BEING A VERY BIG AND HEAVY TRUCK, IT TURNS INTO A MOVING HEADACHE. MY VEHICLE IS A 2001 F-250 SUPER DUTY, CREW CAB, LONG WHEELBASE, V-10. IT CURRENTLY HAS 48,000 MILES ON IT. THE PROBLEM FIRST OCCURRED AT ABOUT 38,000 MILES AT WOULD DO IT ON OCCASION, BUT SINCE ACHIEVING 43,000 MILE MARK, IT APPEARS TO BE HAPPENING WITH...

SERVICE LIGHT COMES ON INDICATING A FAILURE IN THE ENGINE WHEN A LOAD IS BEING PULLED BY THE TRUCK. MANUFACTURER IS AWARE OF THE FAILURE, BUT DOSEN'T HAVE A SOLUTION AT THIS TIME. *AK