2015 FORD EXPLORER Fuelpropulsion System Problems

While driving with the ac on you can smell exhaust fumes in the cabin and it's worse towards the rear carbin of the vehicle. I've gotten nauseated and sleepy from the fumes and have had several headaches in addition to the other symptoms. Ford needs to recall this issue. Also I have an active recall for the window pillars and the dealership says they still dont have the parts to fix it, and it's been over a year, what's the hold up Ford??!!

When vehicle is on and either in park or at a stop, RPMs will idle at about 800-1000 RPM then randomly shoot up between 2000-2500 RPMs then drop to below 500 RPMs before returning to idle. It’ll do this randomly.

On [XXX] while driving to work my car just shut off and the brakes locked up. This scenario happened again several other times even after being worked on at a Ford dealership. Please see attachment for specific dates & details. Fuel pump driver module was replaced first time then the fuel pump the last time. Explorer was inspected by the Sandy Sansing Ford Dealership in Daphne, Alabama. Only time warnings/codes appeared was when it shut off. I attached a screen shot of what the dash showed. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car would not accelerate after leaving a light. I had just exited the freeway and the gas pedal would not respond and I was stuck in the middle of a 4 lane highway. A yellow warning wrench appeared on the dash and then a check engine light. The error code is P2111 stating the throttle body stuck open.

Throttle Body --- I have ask the dealer to provide the defective part for my inspection. Driving on the 15 Freeway in Southern California. My wife was driving and had just picked up speed and merged into the fast land. There was a sudden pop or clunk and the SUV immediately lost power and would not accelerate. She had to exit to the right of the freeway while losing power and no acceleration. She was traveling at less than 5 miles an hour in 60 plus traffic. There was only a narrow strip of shoulder with a "K" rail that was on the shoulder above a deep drop off on the side of the freeway. She was able to avoid getting hit and make it to the exit with enough of a shoulder for her to pullover safely. The SUV was taken to the Ford dealer where the Throttle Body...

Upon driving, my vehicle just started randomly cutting out. I was told that it had to do with the throttle body. I did further research, and I noticed that I haven't been the only Explorer owner that has had this issue, so I'm not sure why there isn't a recall already established. Not only does it put me and my kids at risk, but it also puts drivers around me at risk. My car shuts down, which could cause the drivers behind me to rear end my vehicle. There has been some sort of warning light that comes on, that looks like a wrench, but only after my car shuts off, which is followed by the check engine light coming on. There were no warning signs prior to this happening.

When driving the vehicle, I can smell gas fumes which caused nausea. I didn’t know it was worse in the back of the cabin where my children sit until I sat back there for a 3 hour trip. The smell was stronger there which led to headache, nausea and fatigue. It doesn’t seem to come from the vent, it seems from the entire body of the vehicle. This puts my children’s health at risk. And all of our lives because if we travel far enough breathing this in, it can lead to exhaustion which can cause a crash and put others’ safety at risk. I’m surprised to see there is no recall, yet, it’s been reported that there have been 1.5 million complaints. We are having the issue fixed next Wednesday, but we will be without a car (ford is not providing a loan vehicle) and the bill is extremely...

Upon excellerated take off the exhaust fumes fill the cabin. There has been a prior recall for such issues. This has happened multiple times over the entire time that I have owned it. It is getting increasingly worse and I worry for myself, my family and others. My local Ford dealership dismissed me every time I brought it up.

My 2015 Ford Explorer is having fumes in the car. The dealership has charged me for an oil leak, cracked exhaust and now wants me to pay for a muffler. There is still exhaust fumes coming into the car making it hard to drive in the cold.

VEHICLE HAS APX 78000 MILES WITH A BROKEN WATER PUMP. THEY ARE SUPPOSED TO BE GOOD FOR 100K MILES. MANY PEOPLE HAVE GOTTEN THEM REPLACED TO HAVE THEM BREAK AGAIN WITH IN A YEAR.

merging northbound 280 on the freeway, lost all power to vehicle.

EXHAUST FUMES INSIDE INTERIOR-This seems to only occur on road trips where fast and hard acceleration is needed for highway driving which is not something we normally due. Since we have owned the vehicle, on every occasion of strong hard acceleration there is a strong exhaust / spent fuel smell being brought into the cars interior. We have reached out to the local Ford Dealer several times but without satisfactory results. The exhaust fumes continue to exist in the cars interior upon hard and fast acceleration. My wife just returned from a interstate road trip with signs of exhaust fume poisoning with an extreme headache and very lethargic.What is it going to take for Ford to fix this problem or for a recall to be issued. Will it take fatalities or long term respiratory issues before anything is done to solace this issue. Besides the huge concern about the car...

THE HIGHWAY WHILE ON THE HIGHWAY. I WAS DRIVING. AND THE CAR SUDDENLY HAD NO WAS ON EVERYTHI PULL OVER BUT I HAD TO PULL OVER. BECAUSE. THE CAR DIDN'T SHUT OFF, BUT I STEPPED ON THE PEDAL AND THERE WAS NO POWER. SO I PUL THE ROAD TO THE SIDE OF THE ROAD. AND TURNED THE CAR OFF. I STARTED IT BACK UP AND DID FINE AND WENT HOME. BUT THIS WAS DANGEROUS. IT HAPPENED AGAIN. WHEN I WAS AT A RED LIGHT, IT TURNED GREEN. I STEPPED ON THE PEDAL AND THE CAR DID NOT MOVE. I THINK IT'S SOMETHING IN ELECTRICAL OR THROTTLEL NOT SURE.

SUDDEN FAILURE OF THE POWER STEERING SYSTEM REQUIRING COMPLETE REPLACEMENT OF THE POWER STEERING SYSTEM. ALSO DISABLES THE FORD ADVANCE TRAC SYSTEM. OCCURRED WHILE IN MOTION AT SLOW SPEED W/ MAX SPEED OF 20 MPH. THE DEALER INDICATED THAT THE COMPUTER MODULE FAILED AND REQUIRED THE WHOLE SYSTEM TO BE REPLACED. OCCURRED IN THE PARKING LOT. NOT THE FIRST INSTANCE OF SUDDEN FAILURE, BUT USUALLY STOPPING AND RESTARTING THE CAR CLEARED SIMILAR ERROR, NO OBVIOUS SIGNS OF WAR OR LEAKS/OTHER DAMAGE. PREVIOUS CORRECTABLE INSTANCES OCCURRED IN SIMILAR CONDITIONS.

WHILE DRIVING ON THE HIGHWAY AND TOWING A TRAILER THE VEHICLE SUDDENLY LOST POWER AND DRAMATICALLY SLOWED DOWN. IT WAS ALMOST LIKE SLAMMING ON THE BRAKES. THE INFORMATION WINDOW SHOWED "TERRAIN MANAGEMENT FAULT". THE ENGINE WAS BARELY RUNNING AND WAS RUNNING ERRATICALLY. I WAS ABLE TO GET PULLED OVER AND STOPPED THE ENGINE. WHEN I TRIED TO RESTART IT THE "TERRAIN MANAGEMENT FAULT". APPEARED AGAIN AND THE ENGINE WAS AGAIN BARELY RUNNING. AFTER A FEW STOPS AND STARTS THE MESSAGE CLEARED AND THE ENGINE BEGAN TO RUN NORMALLY. THE FORD DEALER FOUND A BAD THROTTLE BODY ASSEMBLY WAS FAULTY. THE REPAIR WAS NOT COVERED UNDER WARRANTY.

SLOWLY PULLING OUT OF NARROW PARKING LOT EXIT LANE, THROUGH OPENED GATE. RAPID UNEXPLAINED ACCELERATION, SEEMED TO LAUNCH CAR ACROSS ONE WAY CITY STREET INTO RESTAURANT BUILDING. PASSENGER SEAT BELT (FASTENED, LEFT BRUISES) RELEASED UPON IMPACT; PASSENGER DASH BOARD AIRBAG DID NOT DEPLOY; DRIVERS' AIRBAG WEAK. PASSENGER HOSPITALIZED FROM LOWER AIRBAG, BROKEN LEG, SEVERE LACERATION.

WHILE DRIVING AT ANY SPEED, THE CAR WILL SUDDENLY STOP ACCELERATING. ONCE YOU ARE ABLE TO GET COMPLETELY STOPPED AND TURN THE CAR OFF AND RESTART IT, IT WILL DO OK UNTIL THE SAME THING HAPPENS AGAIN WITH NO WARNING. WHEN IN TRAFFIC OR WITH NO PLACE TO PULL OFF OR COAST TO, THIS IS EXTREMELY DANGEROUS. HAS HAPPENED TO ME ABOUT 10-20 IN THE PAST 2 -3 YEARS. AFTER RESEARCHING ONLINE, I READ MANY OF THE SAME SITUATIONS. TOOK TO LOCAL DEALER AND THEY DIAGNOSED IT AS THE THROTTLE BODY AND SAID THERE WERE NUMEROUS EXPLORERS WITH THE SAME PROBLEM.

THE FUEL GAUGE ON THE INSTRUMENT PANEL IS READING THAT THE FUEL TANK IS ALMOST FULL, HOWEVER WHILE DRIVING THE LOW FUEL WARNING SENSOR CAME ON AND WE NEARLY RAN OUT OF FUEL. THE GAUGE WAS STILL READING ALMOST FULL. WE BARELY MADE IT TO A GAS STATION. AFTER PUTTING IN A FULL TANK OF GAS, THE FUEL GAUGE WAS SHOWING A COMPLETELY FULL TANK. SINCE THEN, THE GAUGE IS ALWAYS SHOWING ALMOST COMPLETELY FULL AND WILL GO DOWN ONLY TO ALMOST FULL, NOT QUITE AS LOW AS 3/4 FULL TANK, EVEN IF YOU HAVE DRIVEN OVER 300 MILES. NOW WE HAVE TO RE-SET THE TRIP ODOMETER EVERY TIME WE GET GAS, SO WE CAN CALCULATE APPROXIMATELY HOW MANY MILES WE HAVE DRIVEN SINCE THE FUEL GAUGE ONLY GOES DOWN SLIGHTLY BELOW FULL. THIS OCCURRED AROUND 50,000 MILES.

THERE IS A TERRIBLE EXHAUST SMELL THAT COMES INTO THE INTERIOR CABIN. THE SMELL IS EVEN WORSE UPON EXTENDED HARD ACCELERATION. IN ADDITION, THERE IS BUBBLING IN MY HOOD DUE TO FAULTY HOODS BEING PRODUCED ON FORD EXPLORERS. FORD HAS ACKNOWLEDGED BOTH ISSUES - AS THERE IS A TSB. FORD'S "FIX" TSB-16016 IS NOT A FIX AT ALL. IT MERELY IS A BANDAGE FOR THE PROBLEM AS MY FAMILY STILL SMELLS EXHAUST IN THE VEHICLE. MY 3 YEAR OLD SON IS INHALING THIS TOXIC SMELL.

WHILE DRIVING MY 2015 FORD EXPLORER (46K MILES) AT ABOUT 50MPH, THE EXPLORER UNEXPECTEDLY BECAME COMPLETELY UNRESPONSIVE. LUCKILY, I WAS ABLE TO GET TO THE SIDE OF THE ROAD. TURNED THE ENGINE OFF AND THEN BACK ON. THE WRENCH LIGHT WENT OFF AND IT SEEMED TO BE FINE. I DROVE ANOTHER 2 OR 3 MILES AND IT DID IT AGAIN! I WAS EXTREMELY LUCKY TO FIND A PLACE TO PULL OFF THRU THE CONSTRUCTION SITE I WAS IN. TURNED THE ENGINE OFF AGAIN AND THEN BACK ON WHICH RESET EVERYTHING AGAIN. I FINALLY GOT THE EXPLORER HOME ABOUT 4 MILES WITHOUT ANY MORE ISSUES. THE NEXT DAY TOOK I TOOK IT TO MY AUTO REPAIR SHOP. THEY SAID IT WAS THE THROTTLE BODY WHICH SHOULD BE COVERED UNDER THE EMISSIONS WARRANTY. (THERE WERE NO PROBLEM CODES SAVED BY THE CAR'S COMPUTER BUT THEY WERE GOING BY EXPERIENCE). I TOOK IT...

ON 6/6/19 VEHICLE LOST ENGINE THROTTLE POWER WHEN "WRENCH" LIGHT INDICATOR APPEARED ON DASHBOARD WHILE DRIVING ON INTERSTATE (AT LEAST 65MPH). WRENCH NOTED TERRAIN MANAGEMENT SYSTEM ERROR. ENGINE DID NOT SHUT OFF. VIBRATED VERY BADLY WHEN COMING TO STOP. HAPPENED AGAIN ON 6/12 ON CITY STREET DRIVING APPROX 35MPH. BOTH TIMES STOPPED VEHICLE, TURNED OFF, AND RESTARTED AND OPERATED NORMALLY. FORD DEALERSHIPS CANNOT DETERMINE PROBLEM BECAUSE THERE COMPUTER SYSTEMS CANNOT SEE ERROR CODE(S) IN DIAGNOSTICS.. ADDITIONALLY, FORD MOTOR COMPANY WILL NOT RESPOND UNTIL "ERROR CODE" IDENTIFIED BY FORD SERVICE DEALERSHIP. READ ONLINE AND YOUTUBE EXACT ISSUES BUT NOT DISCUSSION ON RESOLUTION(S). SEE URL ADDRESS FOR EXAMPLE OF ISSUE THAT OCCURRED WITH OUR VEHICLE: HTTPS://WWW.YOUTUBE.COM/WATCH?V=ASRDPLP4_QE&T=1S. VERY DANGEROUS TO LOSE POWER ON HIGHWAY AND LITTLE CONTROL OF VEHICLE. BELIEVE THIS IS A SYSTEMIC ISSUE WITH FORD EXPLORERS

HAVING A FEELING OF NAUSEA WHEN DRIVING EXOLORER. YESTERDAY AND TODAY WE HAVE BEEN RUNNING THE AC DUE TO HOTTER TEMPS. AFTER LETTING CAR IDLE FOR 5-10 MINUTES WHILE USING REMOTE START I START TO FEEL LIGHT HEADED AFTER ABOUT 20 MINUTES OF DRIVING. AFTER FEELING FINE ALL DAY. SEEMS TO BE ONLY WHEN THE CAR USES AC. TODAY I WAS IN THE DRIVE THRU FOR MY SON WHILE IDLING WHEN I STARTED TO FEEL LIGHT HEADED. NOTICED THE RECIRCULATION MODE TURNS ITSELF ON AFTER I TURNED IT OFF. THIS ISSUE IS QUITE CONCERNING. WAS SLATED TO HAVE RECALL FIX DONE AT CAPITOL FORD BUT ADVISOR SAID IT WASNT ATTACHED TO THE VIN SO THEY DIDNT DO IT.

HAD THE RECALL DONE FOR (FSA 17N03) AFTER THE SERVICE WAS DONE, WE HAVE NOTICED WHEN PASSING ON THE FREEWAY OR GOING UP HILL, HOT AIR BLOWS OUT THE VENTS THEN A HEAVY ODOR OF EXHAUST. MY VEHICLE ALSO USES E85, SO WE HAVE RULED OUT MAYBE A CAR IN FRONT OF US. WHEN USING E85 WE GET A STRONG SMELL OF ALCOHOL TYPE. WE HAVE BEEN TO THE DEALERSHIP FOR THE SMELL, EACH TIME THEY WANT THE WINDOWS DONE OR HAVE THE A/C ON. I TELL THEM WE DON'T DRIVE WITH IT ON ALL THE TIME OR HAVE THE WINDOWS DOWN ON THE FREEWAY. EVERY 4-6 MONTHS MORE STORIES IN THE NEWS HAVE BEEN COMING UP WITH CONCERNS ABOUT EXHAUST SMELLS IN THE EXPLORER AND NOW FORD IS REDESIGNED THE VEHICLE. THIS SHOULD BE LOOKED AT MORE AND MAYBE WITH THIRD PARTY ENGINEER.

VEHICLE EMITS CARBON MONOXIDE WHEN EXCELERATING. WHEN VEHICLE WAS PURCHASED WE COMPLAINED ABOUT THIS SMELL INSIDE OF THE VEHICLE. THE DEALERSHIP SUPPOSEDLY FIXED THIS ISSUE HOWEVER THE PROBLEM REMAINED. WHEN WE CALLED AGAIN TO VOICE FRUSTRATION, DEALERSHIP SAID THERE WAS NOTHING ELSE THEY COULD DO ABOUT THIS. RECEIVED NOTICE FROM FORD MOTOR CORP JANUARY 2019 INDICATING THEY ARE AWARE THAT SOME OWNERS HAVE CONCERNS ABOUT EXHAUST OR CARBON MONOXIDE AND THAT THESE VEHICLES ARE SAFE HOWEVER FORD IS OFFERING A NO CHARGE SERVICE THAT REDUCES THE POTENTIAL FOR EXHAUST TO ENTER THE VEHICLE. WE HAVE SINCE TAKEN THE VEHICLE IN FOR THIS SERVICE HOWEVER, THE EXHAUST FUMES INSIDE STILL EXIST. MY WIFE DRIVES THIS VEHICLE DAILY TO WORK 25 MILES EACH WAY AND HAS BECOME FREQUENTLY ILL DUE TO THIS VEHICLE. HEADACHES AND NAUSEA AND AN INCREASE OF HER BLOOD PRESSURE. PLEASE ADVISE IF THERE ARE ANY REMEDIES GOING FORWARD...

EXHAUST FUMES IN CAR WHILE DRIVING

WHEN I ACCELERATE MY VEHICLE YOU CAN SMELL TGE EXHAUST FUMES AND I INSTANTLY CAN'T BREATHE, GET A HEADACHE, NAUSEATED, AND AFTER A FEW MINUTES I GET VERY SLEEPY. I HAVE TO ROLL MY WINDOW DOWN AND STICK MY HEAD OUT TO BE ABLE TO BREATHE. IT DOESN'T DO IT EVERY TIME BUT IN A 3 HOUR TRIP, IT HAPPENS AT LEAST 4 TIMES DEPENDING ON HOW MUCH ACCELERATING IS HAPPENING. IF MY AC UNIT IS ON HIGH THEN IT WILL AUTOMATICALLY GO TO BARELY BLOWING AND AS I LET OFF THE ACCLERATOR THEN IT WILL EVENTUALLY CYCLE BACK TO HIGH EVEN THOUGH IT IS ON HIGH. IT IS MAKING ME VERY SICK BECAUSE I'M IN MY CAR SO MUCH. I HAVE TAKEN TO FORD REPEATEDLY, TWO DIFFERENT DEALERSHIPS, AND THEY CAN'T GET IT FIXED. SOMETIMES TO GET THE AC TO GO BACK TO NORMAL, I HAVE TO STOP SOMEWHERE...

'TAKATA RECAL' WHEN MY CAR HAS BEEN SITTING IN THE DRIVEWAY FOR A FULL DAY WITHOUT BEING DRIVEN OR STARTED. THE FOLLOWING DAY YOU GO TO START THE CAR. IT STARTS NO PROBLEM, ONCE YOUR IN REVERSE THE BATTERY LIGHT WILL COME ON AND AS SOON AS YOU PUT IT IN DRIVE I LOSE ALL POWER AND FUNCTION TO STEER. IF I HIT THE GAS PETAL IT WILL REGAIN POWER. THE LIGHT WILL DISAPPEAR ONLY IF I HIT OK. THIS HAPPENS EVERY TIME WITHOUT FAIL. I ALSO SMELL CARBON DIOXIDE OR GAS FUMES FROM TIME TO TIME

LOSS OF POWER: WHILE DRIVING MY 2015 FORD EXPLORER XLT WITH 3.5L V-6 ENGINE ON THE HIGHWAY (10/04/18), THE WRENCH LIGHT CAME ON AND THE CAR STARTED TO SHUDDER AND LOSE SPEED. PUSHING DOWN ON THE ACCELERATOR HAD NO AFFECT AND THE CAR RAPIDLY DECELERATED. THE ENGINE WAS RUNNING VERY ROUGH WITH HEAVY VIBRATION. THIS WAS A TERRIFYING AND NEARLY FATAL EXPERIENCE AS FASTER MOVING TRAFFIC STARTED PASSING ME ON BOTH SIDES AS I TRIED TO MOVE OFF THE HIGHWAY. I WAS ABLE TO MOVE THE CAR TO THE SIDE OF THE HIGHWAY AND LIMPED OFF THE NEAREST EXIT. ONCE OFF THE EXIT I SHUT THE CAR OFF AND SAT FOR 20 MINUTES WHILE I RE-GAINED MY COMPOSURE AND CALLED MY HUSBAND. WHEN HE ARRIVED HE STARTED THE EXPLORER AND THE WRENCH LIGHT WAS CLEARED. MY HUSBAND DRIVE THE CAR HOME USING ONLY BACK ROADS WHILE I FOLLOWED IN HIS...

WHEN AT IDLE, EITHER IN PARK OR DRIVE, THE ENGINE RPMS WILL FLUCTUATE AND GO DOWN TO A POINT WHERE THE ENGINEER STALLS OR ALMOST STALLS.

DURING ACCELERATION INTO INTERSTATE THERE IS A "BURNT MATCH" TYPE SMELL IN THE INTERIOR OF THE VEHICLE. ONCE SPEED LEVELS OUT THE SMELL DISAPPEARS. I FIRST NOTICED THIS ABOUT A MONTH AGO BUT I PURCHASED THE VEHICLE USED AND THIS WAS ONLY THE SECOND OR THIRD TIME TO HAVE IT ON THE INTERSTATE SINCE I PURCHASED IT.

WE BEGAN TO SMELL EXHAUST FUMES IN THE CABIN OF OUR VEHICLE. IT GOT STRONGER THE LONGER THE VEHICLE WAS RUNNING, AND ESPECIALLY WHEN IDLING AT A STOP LIGHT OR SIMILAR. IT BEGAN TO CAUSE HEADACHES WHILE DRIVING AND WE HAD TO DRIVE WITH WINDOWS DOWN NO MATTER THE TEMPERATURE OR SPEED. BECAUSE OF THE KNOWN RECALL, WE TOOK IT TO THE DEALER WHERE WE BOUGHT THE VEHICLE (MALLOY FORD IN WINCHESTER, VA) TO REPAIR. THEY CLAIMED TO HAVE FIXED THE ISSUE BUT IT STILL PERSISTS SO NOW WE WILL HAVE TO TAKE IT BACK. I AM NOT SURE AN ACTUAL FIX EXISTS.

THIS PARTICULAR CAR WAS IN RECALL FOR CARBON MONOXIDE, ABOUT TWO MONTHS AFTER POSSIBLY FIXED FROM A DEALER, STRONG SMELL COMING FROM CABIN LEFT ME WITH A HEAD ACHE, STIFF NOISE, I'M REALLY WORRIED THIS MIGHT COST ME A FORTUNE, I CALLED DEALER THEY ASKED TO BRING IT THEY INFORMED ME THEY WILL CHARGE ME $138 FOR DIAGNOSING AND WHO KNOWS HOW MUCH FROM THERE.

SINCE WE HAVE HAD OUR CAR 2016 YOU CAN ALWAYS SMELL A GAS LIKE ODOR TYPE FUMES. IF THE CAR IS DRIVEN FOR A LONG PERIOD OF TIME YOU GET A HEADACHE AND DIZZY. THE FORD DEALERSHIP SAID THAT THEY HAVE NO ISSUES WITH CARBON MONOXIDE IN THE FUMES. WE WOULD LIKE THIS LOOKED INTO FURTHER AS IT IS A CONCERN. AT FIRST, WE THOUGHT MAYBE YOU CAN JUST SMELL IT WHEN THE CAR IS FIRST WARMING UP, MAYBE ITS THE HEATED SEATS TRYING TO RULE EVERYTHING OUT. UNFORTUNATELY, I THINK WE ARE NOW USE TO THE SMELL WHICH IS ALSO SO BAD BY IGNORING A ISSUE.

I JUST HAVE BECOME AWARE THE GROWING CONCERN ABOUT FORD EXPLORER EXHAUST/ROTTEN EGG SMELL. MY 2015 EXPERIENCES THIS CONDITION ON A DAILY BASIS. I HAVE ASKED THE FORD DEALERSHIPS ON NUMEROUS OCCASIONS TO LOOK INTO THIS BUT THEY HAVE ALWAYS TOLD ME "NO PROBLEM FOUND". MY SON CAME HOME TONIGHT AND TOLD US A NEIGHBOR HAVING THE SAME COMPLAINTS AND NOW THAT I HAVE RESEARCHED IT ON THE INTERNET IT APPEARS TO BE A WIDE SPREAD PROBLEM. IT DOES GET SO BAD THAT I HAVE TO ROLL WINDOWS DOWN BECAUSE OF HEADACHES.

WHILE DRIVING ON THE HIGHWAY AN ERROR MESSAGE APPEARED ON MY DASH, STATING THE "CHECK FUEL FILL INLET " AND ENGINE LIGHT ON. HAD IT REPAIRED 9/28/17, FUEL TANK FILLER PIPE AND CANISTER PURGE SOLENOID. ON 10/25/17 BACK IN THE REPAIR SHOP FOR SAME ERROR MESSAGE. THEY REPLACED THE SOLENOID ASSY AND VALVE ASSY. NOW, ONCE AGAIN, I HAVE THE SAME ERROR (11/2/17). GOES BACK IN THE GARAGE TO REPAIR ON 11/8/17. WE'LL SEE WHAT HAPPENS.

FORCE FORD TO BUY BACK, NO RECALL, ALL OF THE 2011 TO 2017 FORD EXPLORERS. STOP PROTECTING THEM FROM THE CARBON MONOXIDE PROBLEMS, BECAUSE OF THE CRACKED EXHAUST MANIFOLDS THAT ARE LEAKING CARBON MONOXIDE INTO THE CABINS OF ALL THESE VEHICLES. FORD KNOWS WHAT IS WRONG WITH THESE DEFECTIVE VEHICLES BUT DOES NOT WANT TO BE HELD ACCOUNTABLE. SOMEONE NEEDS TO DO THE RIGHT THING. FORD NEEDS TO STOP STEALING MONEY FROM EVERYONE WHO IS BUYING THESE VEHICLES AND YOU CAN'T EVEN DRIVE THEM. WE ARE GETTING NOTHING IN RETURN FOR OUR MONEY AND NOW WE CAN'T EVEN GIVE THEM AWAY BECAUSE THEY HAVE NO VALUE! WHAT A CIRCUS THIS HAS BECOME, EVEN WITH ALL OF THE PUBLICITY, FORD IS STILL LYING TO THEIR CUSTOMERS. FORD SHOULD NOT BE ABLE TO GET AWAY WITH DOING THIS TO PEOPLE! WE ARE COMPLAINING AND NOBODY IS DOING ANYTHING. COME ON PEOPLE. ANOTHER...

PLEASE RECALL THE 2011-2017 FORD EXPLORER. AS I AM SITTING HERE WATCHING THE WORLD NEWS, I JUST SAW THE NEWS PIECE ABOUT FORD WANTING TRY TO NOW REPAIR THEIR UNSAFE VEHICLES FOR CARBON MONOXIDE. FORD KNOWS THAT THESE VEHICLES CANNOT BE REPAIRED. THESE VEHICLES HAVE A TREMENDOUS AMOUNT OF ENTRY POINTS, THE ENTIRE VEHICLE WOULD HAVE TO BE DISASSEMBLED. I THEN SEE A COMMERCIAL FOR A LOCAL FORD DEALER ADVERTISING A NEW 2017 FORD EXPLORER FOR SALE. ARE YOU KIDDING ME, FORD IS STILL TRYING TO SELL THESE ROLLING GAS CHAMBERS TO UNSUSPECTING PEOPLE. WHAT HAPPENED TO THE ENGINEERING ANALYSIS THAT THE NHTSA WAS DOING? WHAT ARE THE RESULTS FROM THOSE FINDINGS? CRACKED EXHAUST MANIFOLDS! BUY YOURSELF A LOW LEVEL CARBON MONOXIDE DETECTOR AND TEST IT YOURSELF! FORD IS SAYING THEY HAVE NO PROOF CARBON MONOXIDE IS ENTERING CIVILIAN FORD EXPLORERS, I HAVE PROOF! (64PPM) THE CARBON MONOXIDE IS ENTERING...

TODAY IS OCTOBER 16, 2017 AND FORD IS SAYING THEY WILL DO COMPLIMENTARY REPAIRS TO OUR SUV. WELL IT MIGHT HELP IF THEY WOULD FIX THE RIGHT PART! FORD KNOWS THAT THE CARBON MONOXIDE AND EXHAUST FUMES ARE BEING RELEASED FROM THE CRACKED EXHAUST MANIFOLDS ON THESE VEHICLES BUT STILL ARE LYING TO THE CONSUMERS. FORD EXPLORERS HAVE OVER 80 ENTRY POINTS WHERE THESE EXHAUST FUMES ARE ENTERING THESE VEHICLES MAKING PEOPLE SICK! SO FORD CONTINUES TO LIE ABOUT WHAT IS REALLY GOING ON WITH THERE UNSAFE VEHICLES! SHAME ON YOU FORD MOTOR COMPANY FOR ALL OF YOUR COVER UPS. NO MORE FORD PRODUCTS. THEY SHOULD HAVE TO FILE BANKRUPTCY! PEOPLE NEED TO WAKE UP AND GOOGLE FORD EXPLORER CARBON MONOXIDE ON THE INTERNET. YOU WILL BE SHOCKED TO LEARN THE TRUTH ABOUT FORD AND THESE VEHICLES!

CARBON MONOXIDE LIKE LEAK INTO THE CABIN FORD DID NOT FIX WHEN WE WENT TO THE DEALERSHIP

OCTOBER 1, 2017. HERE WE GO AGAIN! HOW MANY FORD CUSTOMERS HAVE TO CONTINUE TO MAKE COMPLAINTS ON THE NHTSA WEBSITE BEFORE THE NHTSA FORCES FORD TO RECALL THE FORD EXPLORERS THAT OBVIOUSLY CANNOT BE FIXED! WHAT ARE YALL DOING? WHY IS THERE NO RECALL FOR THIS TRASH VEHICLE THAT FORD IS CONTINUING TO BUILD AND SELL TO UNKNOWINGLY INNOCENT VICTIMS. AND I SAY VICTIMS BECAUSE THEY ARE COMMITTING FRAUD BY SELLING THIS TRASH! AND YES I AM PISSED! YOU SAY YOU HAVE NO MEDICAL EVIDENCE TO SUPPORT THE CARBON MONOXIDE CLAIMS. THAT IS A LIE! WHAT ABOUT THE HENDERSON, LA POLICE OFFICER THAT SUBMITTED THE BLOOD TEST RESULTS TO CBS NEWS AND SHE IS NOT THE ONLY ONE. . REALLY PEOPLE, ALOT OF GOOD IT IS DOING TO MAKE ALL THESE COMPLAINTS. DO YOUR JOB, RECALL THIS VEHICLE AND HOLD FORD ACCOUNTABLE FOR THIS S---! MAYBE NEXT TIME THEY...

10AUG2017 - WHEN GETTING IN MY CAR AFTER WORK IT WAS EXTREMELY HOT. MY CAR HAD BEEN PARKED IN THE PARKING LOT ALL DAY WITHOUT ANY SHADE - SO THE TEMPERATURE INSIDE THE CAR WAS SOARING. I TURNED THE AIR CONDITIONING ON TO FULL BLAST TO KEEP FROM SWEATING AND LEFT THE PARKING LOT. WHILE DRIVING THE 7 MILES FROM MY OFFICE TO THE PALM BAY FORD DEALERSHIP I OPENED THE SUNROOF IN HOPES THAT THE CAR WOULD COOL DOWN QUICKER. IMMEDIATELY I BEGAN FEELING LIGHT HEADED. MY HEAD BEGAN SPINNING AND I STARTED FEELING SICK TO MY STOMACH. IN ONLY A FEW SHORT MINUTES I STARTED LOSING VISION IN MY RIGHT EYE. I NEVER SMELLED ANYTHING THROUGH THE VENTILATION SYSTEM SO I OPENED THE WINDOW TO TRY AND GET MORE AIR THINKING IT WOULD HELP CALM ME. IT MADE IT EVEN WORSE. I WAS TERRIFIED - I COULDN'T SEE...

I HAVE BEEN EXPERIENCING PROBLEMS WITH THE EXHAUST ON MY 2015 FORD EXPLORER. EVER SINCE I BOUGHT THE CAR THERE'S A STRONG EXHAUST SMELL IN THE CAB OF THE CAR WHEN YOU ACCELERATE ENOUGH TO MAKE THE CAR DOWNSHIFT TO PICK UP SPEED. WE TOOK THE CAR INTO THE DEALERSHIP SHORTLY AFTER BUYING THE CAR AND IT SEEMED TO BE OK. WHEN TAKING THE CAR ON VACATION IN AUG 2017 TO THE MOUNTAINS WE ONCE AGAIN BEGAN SMELLING THE EXHAUST FUMES AGAIN. AS THE MAIN DRIVER, I HAVE BEEN EXPERIENCING TERRIBLE HEADACHES WHEN DRIVING THE CAR - FINE BEFORE I GET IN, HEADACHE WITHIN MINUTES, AND THEN FINE AFTER BEING OUT OF THE VEHICLE FOR ABOUT 30 MINUTES OR MORE. WE TOOK THE CAR TO A DIFFERENT DEALERSHIP WHO KEPT IT FOR A WEEK STATING THEY INSTALLED A COMPLETELY NEW EXHAUST SYSTEM FROM THE CATALYTIC CONVERTER TO THE BACK OF...

EXHAUST SMELL ENTERS CABIN OF VEHICLE AFTER HARD ACCELERATION.

EXHAUST ODOR ENTERS THE VEHICLE WHEN ACCELERATING. THE FUMES SEEM TO BE GETTING WORSE. ALSO THE LEFT FRONT DOOR PANEL IS WARPED AND COMING APART. FORD HAS NOT FIXED EITHER PROBLEM. SERVICE DEPARTMENT BLOWS THESE COMPLAINTS OFF IN HOPING I DON'T KEEP CALLING.

YOU CAN SMELL THE EXHAUST INSIDE THE CABIN WHILE DRIVING. IT IS NOTICEABLE WHEN YOU HAVE TO HIT THE GAS TO SPEED UP TO GO AROUND A VEHICLE OR GETTING ONTO THE INTERSTATE. AFTER HEARING ON THE NEWS ABOUT THE POLICE HAVING THE SAME ISSUE, I WANTED TO MAKE SURE THAT MY COMPLAINT HAS BEEN NOTED. I WILL BE PURCHASING A CO2 DETECTOR AND PLACING IT INSIDE MY VEHICLE WHERE MY 3 YEAR OLD AND 7 MONTH OLD SIT. THERE SAFETY IS TOP PRIORITY AND HOPE A RECALL IS COMING SOON. I NOTICED THE SMELL WHEN I PURCHASED THE VEHICLE NEW IN MARCH OF 2015

INTENSE EXHAUST ODOR, ESPECIALLY WHEN ACCELERATING. WINDOWS MUST BE ROLLED DOWN TO BE ABLE TO BREATHE.

WE WOULD GET EXTREME HEADACHES AND NAUSEA WHILE DRIVING THIS VEHICLE. AS SOON AS WE WOULD GET OUT FOR A PERIOD OF TIME ALL SYMPTOMS WOULD GO AWAY. WE TOOK IT BACK TO THE DEALER SEVERAL TIMES AND IT WAS IN THE SHOP LONGER THEN WE ACTUALLY HAD THE CAR AND THE FORD DEALERSHIP NEVER BELIEVED US ABOUT THE PROBLEM.

TAKATA RECALL - I FREQUENTLY COME CLOSE TO BLACKING OUT WHILE DRIVING THE VEHICLE. ON A NUMBER OF OCCASIONS, I HAVE ALMOST CRASHED THE VEHICLE WHILE DRIVING ON THE HIGHWAY. I WORK IN A CONGESTED DOWNTOWN AREA AND SIT IN STAND STILL TRAFFIC FOR CLOSE TO 30 MINUTES TWICE A DAY, 5 DAYS A WEEK. I HAVE BEEN TO A SPECIALIST TRYING TO FIGURE OUT WHY I AM HAVING EPISODES OF WHAT I THOUGHT WERE "EXTREME SLEEPINESS". IT NEVER OCCURRED TO ME THAT THE SUDDEN ONSET OF TIREDNESS COULD BE LINKED TO THE AIR IN MY VEHICLE, HOWEVER, NOW THAT I AM AWARE OF THE SITUATION, MY SYMPTOMS MAKE PERFECT SENSE. I AM ALSO HAVING FREQUENT HEADACHES AND DIFFICULTY CONCENTRATING AND FOCUSING WHILE WORKING. I AM THE CFO OF A REAL ESTATE COMPANY AND I HAVE NOTICED MY ABILITY TO FOCUS HAS CLEARLY DIMINISHED. THE CONCENTRATION LEVEL AND WORK ETHIC...

EXHAUST FUMES FILL CABIN UNDER HARD ACCELERATION. IT HAS HAPPENED MANY TIMES OVER THE PAST FEW YEARS, WE PURCHASED CAR NEW IN ~ MAY 2015. TYPICALLY WE CAN LIMIT BY ACCELERATING SLOWER THAN DESIRED, WHICH CAN BE UNSAFE WHEN ENTERING THE HIGHWAY. AFTER HARD ACCELERATION HAS ENDED AND YOU MAINTAIN STEADY SPEED THE FUMES NO LONGER SEEM TO ENTER THE CABIN. FUMES CAN BE VERY STRONG AND ROLLING DOWN WINDOWS IS THE ONLY WAY TO CLEAR. IT SEEMS TO MOSTLY HAPPEN WITH REAR AIR CONDITIONING IN TURNED ON, BUT NOT SURE. I PUT TODAYS DATE BELOW, BUT THIS HAPPENS OFTEN. I HAVE READ ONLINE AND SPOKEN TO DEALERS IN THE PAST AND NO FIX SEEMS TO BE AVAILABLE SO WE HAVE DONE ARE BEST TO AVOID WITH SLOW ACCELERATION, BUT WE CAN NOT BE CERTAIN THAT NO FUMES ARE ENTERING CAR. BOTH MY WIFE AND I SEEM TO GET MORE...

WHEN THE THROTTLE IS DEPRESSED FULLY DURING PASSING OR INCREASING SPEED THERE IS A ODOR INSIDE THE CABIN OF VEHICLE. IT HAPPENS EVERY TIME THE THROTTLE IS FULLY DEPRESSED.