2012 DODGE RAM 1500 Engine Problems

The contact owns a 2012 Dodge Ram 1500. The contact stated that while driving at an undisclosed speed, the vehicle stalled. The contact was able to coast to the side of the road. No warning lights were illuminated. After several attempts, the vehicle restarted. The contact stated that the failure persisted. The contact stated that on a separate occasion, while starting the vehicle, after releasing the key fob, the vehicle stalled. The contact taped the key to the side of the vehicle to start. The contact stated that once the key fob was taped, the windows failed to roll up, the indicators failed to function as intended, the heater and A/C failed to operate as needed, and the hazard lights were inoperable. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was not made aware of the failure. The approximate failure mileage was 140,000.

The vehicle finally became inoperable at 119,000 miles due to lifter failure. Lifter issues started when the vehicle had about 106,000 miles on it. There were multiple misfire and gas mileage became worse. There was a loud ticking noise coming from the engine as well. Vehicle has been well maintained and only 1 owner, purchased new. With the lifter failure, this caused damage to the camshaft and which led to an excess amount of metal shavings to be spread throughout the engine. The vehicle ultimately had to get a engine replacement because of the excess metal shavings in the engine.

Unknown this truck was not involved in an accident however it came close with steering /brakes the Engine Faulty Wiring Harness caused major issues it wasn’t until recently I saw a video of how to fix the problem you can view these videos online I will say Dodge is Responsible they did have buybacks this too I had No Knowledge of no recalls either however I recently address it to the dealership who sold me this truck the Service Manager told me it’s my issue not theirs they took care of it years ago this is the reason I am sending my complaint I was informed your department will look into this matter to get a resolution on this serious matter thank you. I have some photos the video would not download you can see it if you put 2012 Dodge Ram Engine Faulty Wire issues . Yes I spent...

The engine has lifters ticking when cold and a loss of power during operation. The engine hesitates during driving at different times and runs rough. There is no warning before this happens and no warning lights/sensors activated. The truck only has 76k miles on it.

The engine has this ticking sound that has progressively gotten louder and now the engine shakes. My truck has turned off multiple times in traffic at a random and I would presume it’s from a failing engine.

The contact owns a 2012 Ram 1500. The contact stated while the vehicle was stationary at a red light, upon starting to drive and attempting to make a right turn, the vehicle inadvertently lost motive power. The contact was able to immediately restart the vehicle. After restarting the vehicle, the vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 160,000.

Warning light came on suddenly. Vehicle lost power. Smoking out of the tail pipe. Very dangerous for other drivers. Took the vehicle to a mechanic, said I have problems with the lifters, and need to replace the engine. I don’t know why Chrysler doesn’t issue a recall for this issue, it seems to happen often. Thank you very much.

Catalytic converter, sensors, knocking loss of power, bogging , hot and cold engine , was on a road trip back home passing a 18 wheeler and it starts to lose power Boggs down and then takes off , steering wheel was iffy, fumes are stong in and out of truck. Threw my suitcase and dog in floor . I have replaced sensors , knock sensor , coils, sparks plugs - no fix muffler shop said catalytic is not plugged up . Sent me to mechanic said ram / dodge designed these years messed up common problem ,one mechanic telling me new engine parts might fix won’t pass inspection so now it just sits and drys up that’s not right for what it has cost my insurance said there nothing they can help with it only has 84k miles please emission and knock common problem that is mana factory defect surely...

The exhaust manifold bolts Broken causing it to leak ,tick.

2012 Dodge Ram 1500 5.7 liter HEMI Completely shut down turned off losing ALL power I was 9n the freeway with my kids that was the first time my power steering doesn't work at all when this happens happens about 8 to 12 times a week and to make things better if I hit a bump truck shuts down also I t'' can be driving along and all my indicator light come on everything starts beeping and my wipers go crazy it's like my truck is possessed it's unbelievably dangerous and a major inconvenience I'm late for work kids late for school

I am experiencing a loud exhaust manifold leak for the third time now in this vehicle. The previous mechanic told me the bolts were broken and this is a known problem with these Rams. I can't afford to keep fixing this issue. This isn't an inexpensive fix. Please help

-Wireless Ignition Node (WIN) malfunctioned while driving and randomly shut the engine off. The component is available for inspection. -The vehicle immediately loses power and power steering. At high speeds or an intersection could cause a crash. -Research online has indicated that these are known to cause issues after a period of time where the contacts wear out. -The vehicle or component has not been inspected by the manufacturer, police, insurance representatives or others. -There were no warning lamps or messages. The only other symptoms of the problem prior was an immediate shutdown of the engine after starting at random instances.

The engine is "Ticking". Ticks real bad when first started cold. After it warms up the ticking diminishes. Vehicle has just over 50,000 miles on it

The exhaust manifold bolts have broken off inside the block 3 times in 7 years. I have fixed them every time. Most recently, I was advised by service manager at Lithia Chrysler Dodge that 4 manifold bolts were broken and the repair cost $1490. This is a very common issue that needs a recall.

Engine "tick" - exhaust bolts are broken and according to dealer cylinder head needs to be extracted

The vehicle is making a loud clicking noise coming from the engine area. . it gets louder when accelerating. It is unknown to me if it could be manifold issues or camshaft issues. It feels unsafe to drive.

Complete engine failure caused by lifters sticking due to lack of lubrication which is a well known problem with the hemi engines. It occurred in my case at approximately 140,000 kilometres despite being maintained religiously with all oil changes done at 5000 kilometre intervals using synthetic oil. Only fix possible because of the damage was to purchase a new long block at a cost of approximately $8000.

My 2012 Dodge Ram shuts off or stalls for no apparent reason. Sometimes upon starting, while going down the freeway (at freeway speeds), as well as speeds in between, This has happened with my family in the vehicle and even when we are towing our stock trailer with animals inside. This is very scary for all of us and dangerous for all those on the round around us. While we have not been involved in any accidents, its just a matter of time. There is never any warning when this happens and it not only shuts off it looses power to everything. So times it catches its self and restarts, other times we have to manually restart the engine.

Exhaust manifold failed (warped and broke bolts) for second time since owning my 2012 Ram 1500 causing dangerous exhaust leak that then enters the cabin of the vehicle causing dangerous conditions for the occupants.

Issue is that the exhaust manifold studs/bolts break off in cylinder head(s) on 5.7L Hemi engines causing exhaust leak in engine compartment in which could allow carbon monoxide to be drawn into passenger compartment. I personally replaced all the bolts/ studs along with new gaskets each time. Even once replacing exhaust manifolds only to have this issue continue to happen repeatedly.

Intermittent fault from the TIPM module. When slowing to a stop, or slowing to make a turn, the engine dies without warning resulting in loss of power steering and operability while in traffic. The only indication that the engine has died is the tachometer reads 0 RPM, loss of power steering, and the excelerator becomes inoperable. The radio, headlights, and A/C stay on during this. Coming to a complete stop and putting the truck into park (P) and turning the ignition to OFF and then restarting the truck resolves the problem, but on the highway this is EXTREMELY DANGEROUS. This has been diagnosed as an intermittent fault derived from a faulty TIPM module and involves multiple RAM 1500, 2500, 3500 owners. Various issues of similar nature reported to dealerships and on forums.

Failure of fuel pump relay on above listed 2012 Ram 1500 at 69,999 miles. Current repair requires replacement of entire TIPM module (at a cost of $1,000 to 2,000) as this relay is soldered to the circuit board deep inside the module, making it nearly impossible to cost effectively replace this critical $10.00 part. Of note, the TIPM installed in this vehicle has 10 slots (9 relays installed and 1 open slots) for "replaceable" relays under the cover. Of these replaceable relays at least 2 (blower motor and park lamp) are less critical with one empty slot available. Further a safety recall was issued in December of 2014 (Safety Recall P54/14V530 Fuel Pump Relay) for 2011 models of the Dodge Durango and Jeep Grand Cherokee, but no other models despite that the same or very similar designed TIPM's are used in virtually all Chrysler, Dodge, Ram and Jeep vehicles along...

I believe there should be a recall by Dodge on their Dodge 1500 Laramie Longhorn with the 5.7 Hemi engines. It's really the Hemi exhaust manifold that is the problem. I have this ticking noise which hundreds if not thousands of others also have. Copied from the Internet ** (Broken or loose exhaust manifold bolts (this is the most common answer). I've had my truck diagnosed and this is what they say is bad. They will not fix it for no charge. The fix is close to and/or over $1,000. Good reason for the to not admit it's their problem. There should definitely be a Class Action Lawsuit against Dodge. This is a very common problem and because hundreds if not thousands of engines have this issue it should be a RECALL issue. I would hope your organization could do something about this. I don't think it's fair that their...

Engine ticking heavily and diminishes some when engine warms up. Vehicle dies randomly while driving and loss of power steering and assisted breaking. Almost had an accident while turning a corner and vehicle died.

2012 DODGE RAM. CONSUMER WRITES IN REGARDS TO ENGINE FAILURE. THE CONSUMER STATED THE VEHICLE SHUT OFF WHILE BEING DRIVEN. THE CONSUMER STATED WHEN THE FAILURE OCCURS THE STEERING WHEEL LOCKS.

Wireless ignition module fails to maintain connection with key fob inserted. Looses power on highway if I hit a bump. Dealer will not address the issue. Door locks are also now not functioning. Am assuming it is the trash TIPM in this 2012 ram 1500 chrysler installed. This whole 2012 ram should be recalled totally unsafe vehicle to have my 5 year old and 5 month old in.

Exiting the freeway the truck vibrated and shut off going 55 mph, no brakes, no power steering going into a curve. I managed to keep it on the road and had it Towed to nearest dealership where they were able to diagnose the problem immediately and I was told that this is a know problem with this truck. $6000 to fix, contacted Ram customer service and a very rude woman put the dealership on the line and berated them for claiming there was an issue while explaining that it is completely normal for an engine to blow at 130k miles regardless of maintenance and as it’s out of warranty they were not responsible. “Normal” for an engine to blow, absolutely ridiculous and someone could have died. There are now 533 cases of this happening and Ram refuses to address it.

Camshaft lobe warn down from, from faulty rocker arm roller (needle bearing) (there is no to very little compression in cylinder 5), apparently engine is lubricated "by splash oil design" and people smarter then me have diagnosed that it is a design flaw.(having to do with the well and the height of the bores that accept the rocker arms) The engine only had 118,000 miles when the engine light came on, resulted in a severe knocking sound and misfiring. I expected a well taken care of motor with regular oil changes would last 200,000 miles. My choices are to rebuild the motor and or replace, both are costly. Thanks for taking the time to read my complaint. [XXX] INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

TIPM is sending intermittent signal to fuel pump relay cause truck to stall at highway speeds.

THE TRUCK STALLED OUT ON THE HIGHWAY DOING 60 MILES PER HOUR ALMOST GOT IN SERIOUS ACCIDENT. NO STEERING OR BRAKES. (COULD BE DEADLY). THIS ALSO HAPPENED AGAIN MAKING A RIGHT TURN THRU AN INTERSECTION. WAS TOLD IT IS SOMETHING TO DO WITH FUSE BOX TIPM TOTAL INTEGRATED POWER MODULE

SEEMS LIKE THIS IS NOT NEW, OTHERS THAT OWN THE SAME 1500 MODEL HAVE ISSUES WITH LIFTS AND CAMSHAFT CAUSING A MISS FIRE, P030SOMETHING (MINES IS P0303). THE SPARK PLUS/ FUEL INJECTORS/ AND COIL PACKS HAVE BEEN CHANGED. OUT OF NOWHERE I GET A CODE WHILE DRIVING OUT OF TOWN. THE TRUCK HAS ALWAYS HAD A RUNNING TICK TO IT. I HAVE MY VECHILE SERVICED BY DODGE THEMSELVES. THEY NEVER STATED IT WAS AN ISSUE. THIS IS A BIG ISSUE IN HEMI 5.7 ENGINES MANUFACTURED AFTER THE REDESIGNED FROM THE MAGNUM PLATFORM.

2012 RAM 1500 HEMI TICK ISSUE. SUPPOSED TO BE A LIFTER. REPLACED ALL LIFTERS AND NOW MY TRUCK WONT START. TOOK IT TO A SHOP AND WAS TOLD I NEED A NEW ENGINE.

TL* THE CONTACT OWNS A 2012 RAM 1500. THE CONTACT STATED THAT THE VEHICLE FAILED TO ACCELERATE FORWARD DRIVING AT VARIOUS SPEEDS. THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE BEGAN TO MISFIRE AND SHUDDER. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE ENGINE COILS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. NO DEALER WAS CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 129,000.

ALONG WITH MANY OTHER PEOPLE WHO OWN THE SAME MODEL OF TRUCK I HAVE EVERYONE HAS SEEMED TO COME ACROSS THE SAME PROBLEM WITH THE CAMSHAFT AND LIFTERS CAUSING EVERY CAR PLACE IN MY STATE TO BE OUT OF THE PARTS TO FIX IT. I NOTICED THE TRUCK WAS HAVING A HARD TIME SHIFTING AND ACTING WEIRD SO I BROUGHT IT IN TO GET CODED AND WHEN IT WAS GETTING CODED I WAS TOLD BY THE TECH THAT THE 7TH CYLINDER WAS OUT ALONG WITH ISSUES WITH THE CAMSHAFT AND HE HAS SEEN IT IN AN ALARMING AMOUNT OF TRUCKS. SO MUCH THAT THEY COULDN'T GET HANDS ON THE PARTS TO CORRECT THIS ISSUE. UPON LOOKING ONLINE THIS IS INDEED A HUGE ISSUE IN HEMI 5.7 ENGINES MANUFACTURED AFTER 2010.

WHEN THE VEHICLE IS RUNNING AND AT SPEED ON THE HIGHWAY, INTERSTATE, OR STREET OCCASIONALLY THE VEHICLE WILL SHUT OFF CAUSING NO LIGHTS IF OPERATING AT NIGHT TIME AND NO POWER STEERING AND GAUGE CLUSTER IS ALSO OFF. AFTER PULLING OVER AS SAFE AS POSSIBLE AND JIGGLING THE IGNITION KEY AND TURNING IGNITION KEY TO START THE VEHICLE THEN IT WILL START AND RUN NORMALLY UNTIL THE NEXT INCIDENT ACCRUES. I HAVE FOUND THAT THE IGNITION ON THESE PARTICULAR VEHICLES GO BAD FOR WHATEVER REASON AND LOSE CONTACT WHICH TURNS THE VEHICLE OFF WHILE DRIVING AT ANYTIME. ON MY VEHICLE IT DOESN'T ACCRUE ALL THE TIME BUT ENOUGH TO MAKE IT VERY UNSAFE. MY VEHICLE JUST TURNED 59,000 MILES AND HAVEN'T HAD ANY ISSUES UNTIL NOW.

EXHAUST MANIFOLD STUD/BOLT FAILURE CAUSING EXHAUST LEAK AND TICKING NOISE. PASSENGER SIDE.

POWER WINDOWS WORKED WEN THEY WANTED TO . WHILE DRIVING ALL WARNING LIGHTS WOULD FLASH ON IN THE CLUSTER LIKE I TURNED THE KEY OFF THEN ON . TRUCK KEPT RUNNING . STARTED GETTING HARD TO START . ONCE LOST POWER WHILE DRIVING LIKE IT WAS RUNNING OUT OF GAS . NOW IT DOESN'T START AT ALL . HAD IT TOWED TO DEALER THEY TOLD ME IT WAS THE TIPM . I UNDERSTAND THIS IS A COMMON PROBLEM WITH THE RAM TRUCKS .

WITH THE COLD WEATHER, IT'S NOT CRANKING. I HAD A NEW BATTERY AND STARTER INSTALLED AND IT STILL DOESN'T CRANK UNLESS IT'S IN NEUTRAL AND I PRESS THE FUEL PEDDLE. IF IT SETS FOR TOO LONG IN COLD, I HAVE TO REPEAT THE PROCESS AND NO LONGER AM ABLE TO USE REMOTE START AND SOMETIMES HAVE TO BE JUMPED OFF.

THE ENGINE COOLING HAS A BAD DESIGN FOR THE EXHAUST MANIFOLDS SO 2 BOLTS ON EACH SIDE BROKE OFF IN THE ENGINE BLOCK AND NOW THERE IS LARGE EXHAUST LEAKS ON BOTH SIDES OF THE ENGINE. THIS IS THE MOST COMMON DEFECT I HAVE SEEN BY TALKING TO PEOPLE AND ON ANY FORUM AND AM VERY SURPRISED THIS ISN'T A RECALL ALREADY

MY 2012 RAM 1500 IS EXPERIENCING ISSUES WITH THE WIN MODULE AND WILL SHUT OFF AT ANY GIVEN TIME. IT WILL SOMETIMES NOT START AND IT HAS DIED ON ME ON THE INTERSTATE RUNNING 55MPH+. THE WIN MODULE HAS BEEN RECALLED ON OTHER MODELS OF CHRYSLER DODGE MODELS BUT NOT THE RAM. IT IS A SERIOUS SAFETY CONCERN BECAUSE OFTEN TIMES I HAVE MY CHILDREN IN THIS VEHICLE AND I LOOSE STEERING WHEN IT SHUTS OFF. I'VE READ IN NUMEROUS FORUMS AND TALKED WITH OTHER WHO ARE EXPERIENCING THE SAME ISSUE AND HAVE GOTTEN NO WHERE WITH GETTING IT FIXED. I WOULD LIKE THIS SAFETY ISSUE TO BE INVESTIGATED BEFORE ME AND MY CHILDREN OR SOMEONE ELSE IS SEVERELY INJURED OR KILLED BECAUSE OF THIS SIMPLE YET VERY EXPENSIVE FIX AT OWNERS COST.

ELECTRICAL COMPONENTS STARTED TO MALFUNCTION OR NOT WORK. DRIVER SIDE LOCK, RADIO, POWER TO ENGINE STALLING. VEHICLE WAS STATIONARY BELIEVE THE PROBLEM IS THE RELAY FUSE COMPARTMENT UNDER THE HOOD.

EXHAUSTED MANIFOLD ON DRIVER SIDE MAKING LOUD NOISE, TOTALLY DEFECTIVE COMPONENT

ENGINE MAKING TICKING NOISE ON PASSENGER SIDE OF ENGINE. TICKING GOES AWAY AFTER IT WARMS UP.

RAM 1500S HAVE AN ISSUE WHERE IMPROPER MATERIALS WERE USED IN THE EXHAUST MANIFOLD RESULTING IN BOLTS BREAKING OFF AND CAUSING HAZARDOUS EXHAUST LEAKS. MINE CURRENTLY HAS THE SAME ISSUE AND UPON SEARCHING THE INTERNET, IT IS AN EXTREMELY COMMON PROBLEM THAT SOMEONE NEEDS TO DO SOMETHING ABOUT. THE LEAK IS DIAGNOSABLE BY A TICKING COMING FROM THE ENGINE BAY AT START UP FROM WHERE THE HEAT SHIELD ON THE MANIFOLD VIBRATE DUE TO THE BROKEN BOLTS, OFTEN CAUSING AN EXHAUST LEAK AT THE SITE OF THE BROKEN BOLT.

VEHICLE HAS 138,358 MILES AND HAS HAD REGULAR MAINTENANCE. HOWEVER, THE CAM SHAFT HAS WORN AND ROCKER ARM HAS BECOME LOOSE AND IS CAUSING CYLINDER 5 TO MISFIRE (P0305). THIS FAILURE HAS CAUSED THE TRUCK TO LOSE POWER WHILE DRIVING ON FREEWAY OR TIMES OF ACCELERATION TO CROSS TRAFFIC OR CLIMB STEEP ROAD GRADES. INITIAL INVESTIGATION BY AUTO MECHANIC STATES THAT CAM SHAFT AND ROCKER ARM NEED REPLACING. ADDITIONAL INVESTIGATION IS NEEDED TO SEE IF VALVLES ARE DETERIORATING AND NEED REPLACING.

LIFTERS ON TRUCKAND CAMSHAFT FAILED CAUSING LOSS OF POWER AND MISFIRE.TRICK HAS ABOUT 115,000 MILES ON THERE NOW. HAD NO POWER OFF THE LINE ON THE HIGHWAY.

DRIVING ALONG AND TRUCK TURNS OFF BY ITSELF 3-5 SECONDS THEN ENGINE RESTARTS BY ITSELF. I'M WORRIED IT'S GONNA CAUSE ME TO GET INTO AND ACCIDENT. DODGE HAS HAD THIS PROBLEM ACROSS A LOT OF YEARS WITH NO RECALL FOR MY TRUCK.

DISCOVER COOLANT SOAKED INTERIOR FLOORBOARD ON PASSENGER SIDE. TRUCK BEGAN OVER HEATING WHILE DRIVING SHORT DISTANCE (I.E., 5-10 MILES DOWN THE ROAD) AND UPON ACCELERATION TO HIGHWAY REGULATION SPEEDS. BELIEVED TO BE PROBLEM WITH HEATER CORE IN ENGINE.

Y'ALL MANIFOLDS ARE FAULTY. I JUST REPLACED MY MANIFOLD AND SCREW TWO YEARS AGO AND AGIN THE SAME ISSUE THIS COST 800-900 DOLLARS. THIS IS FAULTY ON MANUFACTURER PART.

IN THE MORNING WHILE STARTING TRUCK NO PROBLEM, ALL OF A SUDDEN WHILE DRIVING ON STREET THE TRUCK JUST TURNED OFF. IT HAD HAPPENED BEFORE ON 3 OTHER OCCASIONS BUT THE FIRST ONE WAS FAR APART THEN THE OTHER 2 IN THE LAST 2 WEEKS. WHEN I GOT ON THE FREEWAY I NOTICED A HAD TO PUSH HARDER ON THE GAS PEDAL TO GAIN SPEED BUT IT FELT LIKE IT WAS HARD TO PRESS ON AND I WASN'T GETTING TO THE SPEED (60MPH) SO I JUST TOOK IT SLOWLY TO GAIN SPEED. THAT LASTED ABOUT A WEEK. THE FOLLOWING WEEK AFTER TRYING TO GAIN SPEED AT ABOUT 45-50 MPH THE TRUCK STARTED SHAKING REALLY BAD SO I LET GO OF THE GAS PEDAL AND TOOK IT SLOW AGAIN. SO I TOOK IT TO MY MECHANIC TO GET A BASIC TUNE UP SINCE I HAD JUST GOTTEN AN OIL CHANGE HE...