2005 DODGE DURANGO Fuelpropulsion System Problems

UPON FILLING THE GAS TANK SINCE THE FIRST TIME ON JUNE 15, 2017, AND EVERY TIME SINCE THEN, THE FUEL ALWAYS SPITS BACK, AND ALL OVER THE PLACE, INCLUDING ON THE GAS ATTENDANT, UPON ANY ONE WALKING BY, ON THE CAR, AND OF COURSE, ON THE GROUND. IT MAY OR MAY NOT BE THE FUEL TANK INLET CHECK VALVE (FUEL FILLER TUBE), BUT THE DANGEROUS SAFETY ISSUE REMAINS. I HAVE READ THAT 20,000 DURANGOS HAVE BEEN RECALLED FROM 2005 FOR THIS ISSUE, BUT FOR REASONS UNKNOWN, EVEN THOUGH MY 2005 DURANGO ALSO HAS THIS DANGEROUS SAFETY PROBLEM, I AM TOLD BY THE DEALER THAT MY 2005 DURANGO HAS NOT BEEN RECALLED. IF FOR SOME REASON IT HAS NOT BEEN RECALLED, IT OBVIOUSLY SHOULD BE RECALLED BECAUSE IT HAS THE SAME EXACT ISSUE THAT THE OTHER 2005 DURANGOS HAVE BEEN RECALLED FOR. SO WHY NOT MINE?

MY 05 DODGE DURANGO, WHICH I AM THE ONLY OWNER OF, OVERFLOWS GAS WHILE FILLING UP THE TANK. I WAS TOLD IT IS A RECALL, I CALLED THE LOCAL DEALERSHIP TO SCHEDULE AN APPOINTMENT TO FIX IT, I WAS TREATED WITH ABSOLUTE DISRESPECT AND WAS TOLD MY CAR WAS ALREADY FIXED THROUGH THE WARRANTY, I ASSURED THEM I WAS THE ONLY OWNER AND IT WAS NEVER FIXED, THEY AGAIN TOLD ME IT WAS AND THEY WOULD NOT PAY FOR IT TO GET FIXED AGAIN EVEN IF IT IS THE SAME ISSUE THAT THE RECALL WAS FOR. I HAVE HAD THE GAS OVERFLOW AND SPRAY ALL OVER ME MULTIPLE TIMES, INCLUDING ONE TIME WHILE I WAS HOLDING MY INFANT CHILD. THIS IS NOT OK AND SO BEYOND UNSAFE!!! IT CLEARLY WASN'T FIXED AND I WOULD LIKE IT FIXED BEFORE SOMEONE GETS HURT! THE VEHICLE WAS OFF AND PARKED. I ALSO KNOW...

AFTER FUELING, WHEN TANK IS FULL, IT WILL BEGIN DUMPING (SPITTING) FUEL FROM GAS FILLER TUBE. VEHILE IS TURNED OFF AND STATIONARY WHEN THIS OCCURS. THIS OCCURS AT EVERY FILL UP.

A RECALL THAT SUPPOSEDLY HAPPENED BEFORE I PURCHASED THE VEHICLE IS SHOWING THE SYMPTOMS OF WHY IT WAS RECALLED TO BEGIN WITH. THE RECALL #E01, NHTSA #05V-034 WHICH INVOLVES THE FUEL FILLER TUBE INLET CHECK VALVE. EVERY SINGLE TIME I TRY TO PUT GAS IN MY DURANGO, THE FUEL SPURTS OUT AT ME... EVEN WHEN I GO SUPER SLOW IN FILLING IT UP. THIS HAS BEEN GOING ON FOR AT LEAST 2 YEARS NOW. THE AREA AROUND AND UNDER THE GAS CAP IS NOW ALL CORRODED AND RUSTED. I RECENTLY TOOK SOME PICTURES DURING THE FILL TO SHOW ALL THE GAS ON THE GROUND AND ON THE CAR. I TOOK THIS TO DODGE CITY IN BROOKFIELD, WI AND THEY COULD NOT FIX THE PROBLEM WITHOUT CHARGING ME FOR THE WORK (ALMOST $600). IN RESEARCHING THIS PROBLEM, I SEE MANY PEOPLE WITH THESE DURANGOS HAVE THIS ISSUE BUT CHRYSLER WILL NOT...

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE ATTEMPTING TO FUEL THE VEHICLE, THE CONTACT WAS UNABLE TO INSERT THE ENTIRE FUEL PUMP NOZZLE INTO THE FUEL FILLER NECK. THE FUEL FILLER NECK WOULD ONLY ALLOW A CERTAIN AMOUNT OF FUEL TO ENTER AT A TIME. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL FILLER NECK AND FUEL TANK PARTS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 129,494.

FUEL TANK OVERFLOWS EVERY TIME WHEN FUELING. I TRY TO PUMP AS SLOWLY AS POSSIBLE BUT FUEL STILL RUNS DOWN SIDE OF TRUCK WHEN ABOUT 3/4 FULL EVERY SINGLE FILL-UP. LAST HAPPENED PREVIOUS SATURDAY. THIS HAS BEEN OCCURRING LAST 15,000 MILES. LOCAL DEALER CLAIMS NOTHING IS WRONG.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT THERE WAS A RECALL REGARDING THE FUEL TANK FILLER INLET CHECK VALVE. THE CONTACT'S VEHICLE WAS NOT INCLUDED. THE CONTACT STATED THAT FUEL LEAKED OUT OF THE FUEL TANK AFTER FILLING THE TANK. THE CONTACT NOTICED A STRONG ODOR OF FUEL WHILE DRIVING. THE CONTACT TOOK THE VEHICLE TO A DEALER. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS 156,000.

ENGINE CUTS OFF AT ANY SPEED, BUT ESPECIALLY AT LOW IDLE, WHEN NEARING AN INTERSECTION, OR TURNING THE VEHICLE AT A LOWER, SAFER SPEED. THIS HAPPENS ON HIGHWAY, RESIDENTIAL STREETS, STOPLIGHTS, BASICALLY ANYWHERE AT ANYTIME.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE ATTEMPTING TO REFUEL THE VEHICLE, THERE WAS EVIDENCE OF A FUEL LEAKAGE COMING FROM THE FILLER NECK OF THE FUEL TANK. THE CONTACT STATED THAT THE FAILURE RECURRED ON EVERY FUEL FILL UP. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V003000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 238,990.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT WHEN ATTEMPTING TO REFUEL THE VEHICLE, FUEL LEAKED FROM THE GASKET ONCE THE FUEL LEVEL REACHED HALF A TANK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 24,000.

EVERYTIME I FILL THE TANK UP IT SPITS FUEL BACK OUT AT ME.

REASON FOR FILING A VEHICLE SAFETY COMPLAINT IS AS FOLLOWS; EVERY TIME I HAVE TRIED TO FILL-UP MY GAS TANK ON MY 2005 DODGE DURANGO, THE GAS NOT ONLY STARTS TO SHOOT OUT OF THE TANK ITSELF, BUT ALSO ALL OVER MY TRUCK, MYSELF AND ALL OVER THE FLOOR. THIS HAPPENS EACH TIME I FILL MY SUV REGARDLESS OF THE GAS STATION I GO TO.

FUEL TANK OVERFLOWS WHEN BEING FILLED- DOESN'T AUTO STOP THE PUMP LIKE IT SHOULD. THIS HAPPENS WHENEVER THE CAR'S GAS TANK IS FILLED UNLESS THE AMOUNT OF GAS NEEDED IS ESTIMATED LOWER AND THE PUMP IS STOPPED MANUALLY.

WHEN YOU FILL THE VEHICLE WITH GAS, THE PUMP WILL NOT SHUT OFF. THIS IS RESULTING IN GASOLINE SPRAYING OUT OF THE OPENING. THIS SPRAYS GAS ALL OVER THE PERSON FILLING THE VEHICLE, DOWN THE SIDE OF THE VEHICLE AND THE GROUND.

I HAVE A 2005 DODGE DURANGO WITH THE 5.7 HEMI ENGINE.. IT HAS 80,000 MILES AND JUST RECENTLY THE ENGINE STARTED SHUTTING OFF AT RANDOM TIMES WHEN DRIVING, MOSTLY WHEN I HIT A BUMP IN THE ROAD.. I HAVE RESEARCHED THIS WITH THE NATIONAL HIGHWAY SAFETY BOARD WEBSITE AND SEE THERE IS A HUNDREDS OF COMPLAINTS FROM FEBURARY 2005 THRU PRESENT .. THERE WAS AN INVESTIGATION OPENED IN 2005 PE05-027 THEN IT WAS TRANSFERRED TO AN ENGINEERING ANALYSIS ( EA05-018) AND THEN NOTHING.. I WOULD LIKE TO KNOW IF THE NHTSA DROPPED THE BALL ON THIS?? THERE IS NO FURTHER ANSWERS TO THE COMPLAINT.. PLEASE ADVISE ME WHAT DO I HAVE TO DO TO GET A N ANSWER TO THIS PROBLEM, WHICH IS A MANUFACTURES ERROR THAT IS GOING TO GET ME KILLED OR SOMEONE ELSE.

WHEN FUELING VEHICLE THE FUEL WILL UNPREDICTABLE OVERFLOW AND CAUSE GASOLINE TO POUR ON VEHICLE AND UNTO THE GROUND. ENOUGH FUELS OVERFLOWS TO CAUSE PUDDLES OF GASOLINE TO FORM ON THE GROUND. IF YOU ARE STANDING CLOSE TO INTAKE IT WILL SPRAY FUEL ON PERSON OPERATING THE PUMB. THE PROBLEM IS CAUSING RUSTING ON VEHICLE.

GAS COMES SPEWING OUT OF THE TANK WHEN I'M FILLING UP AT THE GAS STATION. THIS ONLY HAPPENS WITH I'M TRYING TO "FILL" THE TANK, AT THE END OF THE FILLING WHEN THE PUMP SHOULD STOP DUE TO THE TANK BEING FULL. IT DOES NOT SPEW OUT IF I'M JUST PUTTING "SOME" GAS IN THE TANK. THIS HAPPENS AT ALL GAS STATIONS SO IT SEEMS AS THOUGH THIS IS AN ISSUE WITH THE VEHICLE AND NOT THE PUMP. I'VE HAD THIS PROBLEM FOR SEVERAL YEARS AND JUST FOUND INFORMATION ON THE NHTSA CAMPAIGN NUMBER 09V003000 REPORT RECEIPT DATE 01/08/2009. THIS SEEMS TO BE THE SAME ISSUE I'M HAVING HOWEVER I WAS TOLD, TODAY, THAT MY VIN # IS NOT INCLUDED IN THE 2005 DODGE DURANGO VEHICLES LISTED IN THE RECALL. SAFETY RECALL NUMBER H45 - FUEL TANK INLET CHECK VALVE. HOW DO I GO ABOUT POSSIBLY GETTING MY VEHICLE ADDED...

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE REFUELING THE VEHICLE, FUEL SPEWED OUT OF THE FILLER NECK ONTO THE GROUND EVEN THOUGH THE FUEL TANK LEVEL WAS NOT TO THE FULL CAPACITY. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 115,000.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT WHEN FILLING THE TANK WITH FUEL, THE FUEL PUMP WOULD NOT AUTOMATICALLY STOP AS INTENDED. AS A RESULT, FUEL OVERFLOWED AND LEAKED FROM THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SHUT OFF VALVE WAS FAULTY AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 99,000.

FUEL KEEPS SPITTING BACK UP THE SPOUT..

WHEN PUTTING GAS IN THE VEHICLE IT DOES NOT STOP ONCE FULL IT WILL SPLASH GAS ON THE VEHICLE, PERSON PUTTING THE GAS IN AND WILL CONTINUE TO SPILL ONTO THE PAVEMENT. THIS HAPPENS EVERY TIME YOU PUT GAS IN THE VEHICLE.

GAS SPILLING AND SQUIRTING OUT WHEN REFUELING. THIS HAPPENS EACH AND EVERY TIME I REFUEL. I JUST BOUGHT THIS 2005 DODGE DURANGO 2 MONTHS AGO. GAS SPILLS AND SQUIRTS ON MY CLOTHES AND FEET. THIS IS DANGEROUS! PLEASE HELP ME GET THIS RESOLVED BEFORE I CATCH ON FIRE OR SET FIRE TO SOMEONE ELSE NEARBY. I JUST BOUGHT THIS VEHICLE AT JRS AUTO SALES IN TACOMA, WA I BOUGHT THIS 2005 DODGE DURANGO ON JANUARY 9, 2016 AND GAS HAS SPITTED OUT FROM DAY ONE SINCE I BOUGHT IT EACH AND EVERY TIME AT VARIOUS GAS STATIONS. IT HAS STREAM OUT AND SQUIRTED VIOLENTLY WHILE I WAS BENDING DOWN AND GOT INTO MY FACE AND EYE. HELP PLEASE!

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE ADDING FUEL TO THE VEHICLE, IT SPEWED OUT OF THE TANK. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 56,000.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT THE FUEL TANK FILLER TUBE INLET CHECK VALVE WAS NOT CLOSED AS INTENDED. AS A RESULT, FUEL SPILLED OUT WHILE REFUELING THE VEHICLE. THE FAILURE OCCURRED CONSTANTLY. THE VEHICLE WAS SERVICED UNDER NHTSA CAMPAIGN NUMBER: 09V003000 (FUEL SYSTEM, GASOLINE), BUT THE REMEDY FAILED TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

WHEN FILLING THE GAS TANK (AT ANY STATION) THE CHECK VALVE ENGAGES TOO EARLY CAUSING FUEL TO SHOOT OUT OF THE FILLER TUBE. SUPPOSEDLY THIS WAS FIXED BUT EITHER A FAULTY ONE WAS INSTALLED OR THE WORK WAS NEVER DONE (PREVIOUS OWNER). VEHICLE WAS ALSO SUPPOSEDLY NOT COVERED UNDER RECALL BASED ON THE VIN BUT MATCHED THE MANUFACTURE DATE BUT NOT SERIAL NUMBER. NO ONE HAS AN ANSWER WHY IT IS STILL DOING THIS?

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE REFUELING THE VEHICLE, FUEL SPEWED OUT OF THE FILLER NECK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE TECHNICIAN DIAGNOSED THAT THE FUEL PUMP MODULE SEAL FRACTURED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 60,000.

WHEN FUELING, THERE IS NO SHUTOFF SO FUEL GOES EVERYWHERE. DEALERSHIP SAYS PROBLEM WAS FIXED BUT IT IS NOT FIXED. IT HAS BEEN DOING THIS SINCE I PURCHASED THE VEHICLE. IT IS VERY UNSAFE AND CAUSES A WET SLIPPERY SURFACE AT GAS PUMP, ALONG WITH GAS LEAKAGE DOWN THE SIDE OF VEHICLE, WHICH HAS CREATED RUST NOW.

UPON FILLING UP THE TANK THE FUEL WILL SPRAY OUT ALL OVER THE PLACE. I TOOK IT TO THE DEALER AND THEY STATED THERE WAS A RECALL FOR THIS ISSUE BUT IT HAD ALREADY BEEN DONE AND EVEN THOUGH IT FAILED AGAIN IT IS MY PROBLEM. I SEE 2006 AND ON HAVE A UNLIMITED TIME AND MILEAGE WARRANTY FOR THIS ISSUE. NUMBER: 14-001-12 GROUP: FUEL SYSTEM DATE: JANUARY 20, 2012 SUBJECT: FUEL SPIT BACK DURING REFUELING DUE TO FAULTY INLET CHECK VALVE X39 (UNLIMITED TIME AND MILEAGE WARRANTY EXTENSION) OVERVIEW: THIS BULLETIN INVOLVES REPLACING THE FUEL FILLER TUBE IF THE CONDITION OCCURS. MODELS: 2006 - 2008 (HB) DURANGO 2007 - 2008 (HG) ASPEN NOTE: THIS EXTENDED WARRANTY BULLETIN APPLIES TO VEHICLES EQUIPPED WITH A NATURALLY ASPIRATED GASOLINE ENGINES. SYMPTOM/CONDITION: SOME CUSTOMERS MAY EXPERIENCE A FUEL SPIT BACK CONDITION DURING A REFUELING EVENT. DIAGNOSIS: IF THE CUSTOMER EXPERIENCES THE SYMPTOM/CONDITION, PROCEED...

I AM MAKING A COMPLAINT THAT CHRYSLER DID NOT ISSUE A RECALL BASED ON NHTSA RECALL CAMPAIGN NUMBER : 09V003000. I HAVE A 2005 DODGE DURANGO THAT HAS HAD A DEFECTIVE INLET CHECK VALVE IN THE FUEL TANK THAT HAS ALLOWED GAS TO FLOW BACK UP THE FILL LINE DURING FILLING OF THE TANK. I HAD QUESTIONED THE LOCAL DEALERSHIP IN THE PASSED THAT THERE WAS A RECALL FOR THIS ISSUE IN VEHICLES OF THE YEAR OF MY VEHICLE, BUT I WAS TOLD THIS ISSUE DID NOT PERTAIN TO MY VEHICLE SINCE THIS ISSUE WAS REMEDIED ON VEHICLES MADE AFTER 01 OCTOBER OF THAT YEAR. I TOLD THEM MINE WAS STILL HAVING THE PROBLEMS LISTED. ACCORDING TO THE RECALL NUMBER 09V003000, CHRYSLER WAS SUPPOSED TO RECALL THE VEHICLES BUILT UP TO 11/30 OF THAT YEAR. ACCORDING TO WHAT I HAVE FOUND OUT TODAY THIS DID NOT OCCUR, THEY PLACED AN...

VEHICLE SPITS GAS FROM FUEL TANK INLET & SMELLS OF FUEL OUTSIDE OF THE VEHICLE.

WHEN FILLING THE GAS TANK, A LARGE AMOUNT OF FUEL ALWAYS SHOOTS OUT OF THE FILLER NECK AND SPILLS ONTO VEHICLE, GROUND, AND OBJECTS AROUND VEHICLE. ALSO THE VEHICLE DOES NOT COME WITH TPMS, HOWEVER THE TPMS WARNING LIGHT ON THE INSTRUMENT PANEL STAYS ON ALL THE TIME. ALSO IF THE REAR LIFT GATE IS OPENED THE CARGO LIGHT INDICATOR ON THE INSTRUMENT PANEL STAYS ON UNTIL YOU OPEN AND CLOSE THE LIFT GATE A TOTAL OF TWO TIMES.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE REFUELING THE VEHICLE, FUEL SUDDENLY OVERFLOWED FROM THE FUEL INTAKE HOLE. THE MANUFACTURER WAS NOTIFIED. THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 09V003000 (FUEL SYSTEM). THE CONTACT ALSO INDICATED THAT THE WINDSHIELD WIPER MOTOR WAS INOPERABLE. THE CAUSE OF THE FAILURES WERE NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 75,000.

WHEN FILLING CAR WITH GAS IT SHOOTS OUT FILLER TUBE SPILLING GAS ON THE SIDE OF THE CAR AND GROUND.

CONSTANT FUEL SMELL WHILE DRIVING AND SITTING STILL. FUEL SPITS BACK OUT FILLER WHEN FUELING. RUST THROUGH IN LEFT REAR QUARTER PANEL. PROBLEM HAS BEEN ONGOING FOR A COUPLE OF YEARS. GETTING WORSE.THERE IS A RECALL FOR THIS PROBLEM BUT DOES NOT COVER MY VIN.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. WHILE ATTEMPTING TO REFUEL THE VEHICLE, FUEL SPEWED BACK OUT OF THE TANK. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL FILLER NECK BECAME INOPERABLE AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 60,000.

MORE THAN A GALLON OF FUEL SPILLS OUT IF YOU FILL UP THE GAS TANK

WHEN FILLING THE FUEL TANK, GASOLINE SHOOTS OUT OF THE TANK ONCE THE TANK IS FULL AND AFTER THE PUMP HANDLE HAS DETECTED THE TANK BEING FULL AND HAS SHUT OFF. I UNDERSTAND FROM TALKING TO THE LOCAL DEALER, CHRYSLER CUSTOMER SERVICE AND MANY COMMENTS ON THE INTERNET THAT CHRYSLER RECALLED CERTAIN 2005 DURANGO'S MADE IN SPECIFIC PLANTS WITH SPECIFIC PARTS. I WAS TOLD BY THE DEALER AND BY CHRYSLER CUSTOMER SERVICE THAT OUR DURANGO WAS NOT RECALLED. I DON'T UNDERSTAND WHY ONLY CERTAIN VEHICLES WERE RECALLED WHEN OTHERS WITH THE SAME ISSUE WERE NOT RECALLED. THIS IS A REAL SAFETY CONCERN FOR US. GASOLINE GETS ON US AND OUR CLOTHES OUR SKIN AND ON THE GROUND. COULD START FIRE IF A SPARK WAS NEARBY. A NEW TANK COST $1300 PLUS LABOR WHICH WE CAN'T AFFORD. PLEASE HELP US STAY SAFE.

WHEN I FILL THE GAS TANK UP GAS COMES BACK OUT THE GAS TANK AND GOES ON THE GROUND AND GETS ON THE VEHICLE AND ON CLOTHING. I HAVE TRIED NUMEROUS GAS STATIONS AND IT HAPPENS ALL THE TIME. I CHECKED TO SEE IF THERE IS A RECALL ON MY VEHICLE AND THERE IS NOT, BUT THEY HAVE RECALLS ON THE SAME YEAR AND MODEL AS MINE. THIS IS A BIG SAFETY ISSUE AND HEALTH ISSUE BECAUSE THE GAS COMES IN CONTACT WITH YOUR SKIN AND RISK OF FIRE AND ENVIRONMENTAL CONCERNS WHEN THE GAS GOES ON THE GROUND.

LARGE EVAP LEAK - CODE P0455: INLET & OUTLET FUEL TANK RINGS HAVE RUSTED OUT. PREVIOUS RECALL E01 REPAIRED IN 2010 COMPLETE. AFTER EFFECTS FROM PREVIOUS FUEL LEAKAGE HAS CAUSED RUST DAMAGE TO THE FUEL TANK CONNECTOR RINGS. THE SAFETY OF THE VEHICLE IS A HUGE CONCERN AS THIS CAN CAUSE THE VEHICLE TO CATCH ON FIRE AT ANY TIME. SOLUTION RECOMMENDED: REPLACE FUEL TANK & FUEL PUMP.

WHEN FUELING MY DURANGO APPROACHING THE 90% CAPACITY, GAS GUSHES OUT OF THE FUEL TANK CAUSING FUEL SPRAY ALSO ADDITIONAL RUST DAMAGE ON MY FENDER UNDER THE FUEL DOOR.

WHILE FILLING THE FUEL TANK, WHEN THE PUMP KICKS OFF FUEL SPITS BACK OUT OF THE FUEL TANK ON THE GROUND, THE VEHICLE, AND ME (IF I AM STANDING CLOSE). I HAVE FOUND NUMEROUS COMPLAINTS AND CONVERSATIONS ON THE INTERNET REGARDING THIS PROBLEM. SOME ARE REFERENCED BELOW: NHTSA INVESTIGATION #RQ08005 LED TO RECALL #09V003000 NHTSA REFERENCE #10051769: TSB #SB-14-002-13; CUSTOMER SATISFACTION CAMPAIGN #CSC-10051769-3696 WARRANTY BULLETIN #D-13-09: SUBJECT: (X48) FUEL TANK INLET CHECK VALVE (FUEL FILLER TUBE) PURPOSE OF BULLETIN: TO ANNOUNCE AN EXTENDED WARRANTY ON THE FUEL TANK INLET CHECK VALVE ON 2005-2006 DODGE DURANGO VEHICLES STATING: "THIS WARRANTY EXTENSION COVERAGE IS UNLIMITED TIME AND MILES." I TOOK MY VEHICLE TO BENCHMARK-CHRYSLER-DODGE-JEEP-RAM, 1313 GRANTS MILL WAY, BIRMINGHAM, ALABAMA 35210, (205) 957-1313 FOR THIS PROBLEM. THEY ADVISED ME UP FRONT THAT I WOULD BE CHARGED $105 TO DIAGNOSE THE VEHICLE, BUT THAT I WOULD BE REIMBURSED IF THE PROBLEM WAS COVERED...

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT THE VEHICLE WAS REPAIRED ACCORDING TO NHTSA CAMPAIGN NUMBER: 09V003000 (FUEL SYSTEM, GASOLINE), BUT THE FAILURE RECURRED. UPON RE-FUELING THE VEHICLE, THE FUEL TANK FILLER TUBE INLET CHECK VALVE WOULD NOT FULLY CLOSE OR THE FILLER NECK MAY HAVE FRACTURED AND CAUSED A LEAKAGE. THE DEALER STATED THAT THE CONTACT WAS TO RE-FUEL THE VEHICLE TO TEST THE FAILURE, AND THAT THE CONTACT DID NOT COMPLY WITH WHAT THE DEALER STATED. THE DEALER PERFORMED A SMOKE TEST, BUT FOUND NO FAILURE. THE DEALER REFUSED TO REMEDY THE FAILURE. THE MANUFACTURER REFERRED THE CONTACT TO ANOTHER DEALER. THE VEHICLE WAS ALSO INCLUDED IN NHTSA CAMPAIGN NUMBER: 15V313000 (AIR BAGS). THE DEALER WAS UNABLE TO DETERMINE WHEN THE PART WOULD BECOME AVAILABLE TO SCHEDULE THE RECALL REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 55,000.

I HAVE NOT HAD A ACCIDENT THANK GOD. I BROUGHT MY 2005 DODGE DURANGO FEBRUARY2, 2015. MAKE A LONG STORY SHORT WITH IN THE PAST 2 MONTH I HAVE HAD TO HAVE MY TANK DROPPED 3 TIMES NOW I HAVE TO HAVE IT DROPPED AGAIN SO THIS WILL BE THE FORTH TIME &MY TRUCK WIL NOT START &THE PUMP IS NOT COMING ON. I GOT A LETTER ABOUT THE AIRBAGS RECALLS, MY QUESTION IS HAVE IT EVER BEEN A RECALL ON THE COMPUTER OR THE ELECTRICAL SYSTEM FOR THIS SUV? I THINK MY WHOLE FUEL SYSTEM IS MESSED UP CAUSE WHEN I GO TO FILL IT UP GAS COME SHOTTING BACK OUT THE TANK AT ME & I SEE IT WAS A RECALL ON THAT & I HAVE NOT RECIEVED MY LETTER TO GO HAVE IT CHECKED OUT. PLEASE PLEASE PLEASE HELP

VEHICLE THROTTLE STUCK IN DRIVE AS DRIVER WAS PULLING FORWARD TO BACK UP INTO GARAGE. VEHICLE PLUNGED FORWARD 20 FEET, HIT AN OVERHEAD DOOR AND BUMPER GUARD CAUSING THE AIRBAG TO DEPLOY. AIRBAG LACERATED, ABRAISED AND BRUISED LEFT FOREARM OF DRIVER,[XXX], REQUIRING EMERGENCY ROOM TREATMENT AT MERCY MEDICAL 301 ST. PAUL STREET, BALTIMORE, MD 21202. VEHICLE WAS TOTALED AND CLAIM FILED WITH GEICO CLAIM # [XXX]. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

WHEN YOU GO TO PUT GAS IN IT THE GAS WONT SHUT OFF AND I HAVE AN INSIDE LIGHT THAT SAYS GAS CAP EVEN THOUGH WE HAVE REPLACED THE GAS CAP AND I HAVE RUST WHERE THE GAS HAS RUN DOWN THE CAR. IM ALSO HAVING TROUBLE WITH MY GAUGES IN THE VEHICLE AND IT TAKES SPELLS THAT IT DOESN'T WANT TO TAKE GAS. *TR

THE GAS WILL NOT SHUT OFF WHEN REFUELING THE VEHICLE. GAS RUNS OUT ON THE GROUND. I HAVE A LIGHT THAT COMES ON SAYING GAS CAP EVEN THOUGH I BOUGHT A NEW ONE. AND I HAVE RUST ON THE SIDE WHERE GAS HAS RUN DOWN THE VEHICLE. I HAVE ALSO HAD AN INCIDENT WHERE EVERYTHING ELECTRICAL IN MY VEHICLE HAS WENT CRAZY. LIGHTS FLASHING GAUGES MALFUCTIONING AND AT THIS TIME IT WOULD NOT TAKE ANY FUEL YOU COULD PUSH ON THE ACCELERATOR ALL YOU WANTED BUT IT WOULD NOT TAKE FUEL. I HAVE READ WHERE OTHER PEOPLE HAVE HAD PROBLEMS WITH THEIR GAS REFUELING TO. THIS IS A VERY SERIOUS AND DANGEROUS PROBLEM. I WOULD LIKE AN INVESTIGATION INTO THIS AND I WOULD LIKE A RESPONSE PLEASE. I THINK THE MANUFACTURE SHOULD BE HELD RESPONSIBLE FOR THEIR MISTAKES AND THIS IS CLEARLY THEIR MISTAKE. *TR

AFTER FILLING UP VEHICLE, A QUANTITY OF GASOLINE FLUSHED OUT OF THE FUEL FILLER NECK CAUSING A DISTINCT FIRE HAZARD. THIS HAS OCCURRED FOR EACH FILL UP. *TR

WAS DRIVING AND ALL OF A SUDDEN I SMELT SOMETHING BURNING IN THE DASH BOARD AND ALL INSTRUMENT LIGHTS STARTED TO GET DIM AND DIMMER AND THEN I NOTICE SMOKE COMING FROM THE DASHBOARD AND ALL MOST IMMEDIATELY THE DOOR LOCKS AND WINDOWS STOP WORKING, THE CAR WOULD LOCK ITSELF AND THE WINDOWS STOP WORKING AT ALL AND AT THIS POINT THE REAR DOOR DO NOT OPEN AT ALL. I ASK THE DEALER AT THE LOT THAT I BOUGHT IT FROM AT THE TIME OF PURCHASE IF THE VEHICLE HAD BEEN IN A ACCIDENT OR WAS THERE ANY RECALLS ON THIS VEHICLE AND HE SAID NO AND THAT I BOUGHT THE VAN AS IS AND TO THIS DAY I CANT GET THIS DEALER TO SEE THAT THIS CAR IS UNSAFE TO OPERATE AND THAT I AM NOT GOING TO RISK MINE NOR MY KIDS LIFE TO DRIVE IT AND HE...

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. AFTER REFUELING THE VEHICLE, FUEL SPEWED OUT OF THE FILLER NECK. THE FAILURE RECURRED MULTIPLE TIMES. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

TL* THE CONTACT OWNS A 2005 DODGE DURANGO. THE CONTACT STATED THAT WHEN ATTEMPTING TO REFUEL THE VEHICLE, FUEL WOULD SPEW OUT OF THE FILLER NECK. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.