2007 DODGE CALIBER Structurebody Problems

2007 DODGE CALIBER FRONT ENGINE CRADLE UNDERCARRIAGE CROSSMEMBER SUBFRAME IS A KNOWN ISSUE BUT INSTEAD OF DOING A RECALL, CHRYSLER/DODGE RELEASED AN EXTENDED WARRANTY FOR THE ITEM. MY SAFETY COMPLAINT IS WHEN I TOOK THE CAR FOR SERVICE BASED ON FRONT END NOISE I FOUND OUT THE FRAME HAD BEEN DANGEROUSLY RUSTED. THE MECHANIC (H&J AUTO REPAIR MILTON, WI), WOULD NOT LET ME DRIVE THE CAR HOME. MY 20 YEAR OLD SON HAD BEEN DRIVING THE CAR FOR THE LAST YEAR AND A HALF AND DRIVES 30 MILES TO AND FROM WORK 3-5 DAYS A WEEK DEPENDING ON HIS SCHEDULE. THE FRAME COULD HAVE LITERALLY BROKE IN HALF WHILE HE WAS DRIVING IT ON A MAJOR HIGHWAY. I BOUGHT THE CAR USED FROM JACK WOLF CHEVROLET IN 2009 AND SEEMED TO BE A PRETTY GOOD CAR EVEN THOUGH THE MODEL HAS SOME DOCUMENTED ISSUES WITH THE FRONT SUSPENSION. MY COMPLAINT...

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THE FRONT END OF THE VEHICLE WAS RUSTED AND REPAIRED PER AN UNKNOWN RECALL AT SHAPIRO CHRYSLER JEEP IN OSWEGO, NY. SIX MONTHS LATER, WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE SHOOK AND VIBRATED UNCONTROLLABLY. THE CONTACT REPLACED ALL FOUR TIRES, BUT THE FAILURE RECURRED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT GARAGE, JOE BROWN AUTO KING IN ZACHARY, LA WHERE IT WAS DIAGNOSED THAT THE REAR DRIVER SIDE FRAME WAS RUSTED AND FRACTURED. THE TECHNICIAN ADVISED NOT TO DRIVE THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THAT THE RECALL EXPIRED. THE CONTACT STATED THAT THE DEALER SHOULD HAVE REPAIRED THE ENTIRE FRAME DURING THE INITIAL REPAIR. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 140,000.

FRONT SUB FRAME RUSTED OUT,FOUND DURING INSPECTION DODGE CLAIMS X-58 EXTENDED WARRANTY IS EXPIRED.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THERE WAS A PREMATURE FAILURE WITH THE CROSS MEMBER BEING COMPLETED RUSTED WITHOUT WARNING. THE DEALER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS TO CHECK WITH THE MANUFACTURER TO DETERMINE IF THEY HAD A SERVICE CAMPAIGN OR A MANUFACTURER RECALL TO ADDRESS THE REPAIR. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

I HAVE PROBLEMS WITH SUSPENSION BAR FRONT WAS REPLACED UNDER A 10 YEAR MANUFACTURING WARRANTY BACK WAS RUSTING BUT THEY WERE UNABLE TO TOUCH WITHOUT A HOLE THE FOLLOWING YEAR I HAD TO PAY OUT OF POCKET AT CUNNINGHAM CHRYSLER IN NORTH EAST, PA THEY WILL HAVE DOCUMENTATION OF BOTH. NOW COIL SPRING ON LEFT FRONT SIDE HAS PIECES BREAKING OFF THEY ARE SOLID NOT RUSTED THROUGH AND I WILL HAVE TO REPLACE BOTH SIDES ON FRONT THIS SEEMS TO ALSO BE A DEFECT CAR WAS PULLED INTO DRIVEWAY NO BUMPS WHEN PIECE BROKE OFF

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE DRIVING VARIOUS SPEEDS, AN ABNORMAL NOISE WAS OBSERVED IN THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUBFRAME FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 88,000.

WHERE DO I START! FROM DAY ONE WE HAVE HAD ISSUES WITH THIS CAR. CRUSE CONTROL DIDN'T WORK, BROUGHT BACK TO DEALER THE FIRST WEEK TO BE FIXED. ONE MONTH LATER, FRONT SPEAKER WENT OUT, ANOTHER TRIP TO THE DEALER SPEAKER WAS REPLACED. AT 34,611 MILES, CAR WAS STUCK IN PARK, WOULD NOT SHIFT AT ALL. TOWED TO DEALER, REPLACED STOP LAMP. AT 35,031 MILES, FRONT END MAKING LOUD KNOCKING NOISE, YOU GUESSED IT, ANOTHER TRIP TO DODGE, LOWER CONTROL ARMS REPLACED. SKIPPING TO JANUARY OF 2017, CAR NOW HAS 124,000 MILES LOUD CRUNCHING SOUND COMING FROM FRONT DRIVER SIDE. THOUGHT OH, ANOTHER BALL JOINT NEEDS REPLACING, WHICH HAS BEEN REPLACED IN JANUARY OF 2016, ALONG WITH MORE CONTROL ARMS, SWAY BAR LINK, AND STRUTS, ABOUT $1200.00 IN ALL. TOOK THIS PILE OF CRAP TO LOCAL MERLIN'S SHOP, SHOWED ME THE ROTTED CROSS MEMBER WITH LARGE HOLES IN IT, COMPLETELY...

CROSSMEMBERS FRONT AND REAR SUBFRAME ARE RUSTED THROUGH AND PERFORATED. DAMAGING FRONT END PARTS BY INSTABILITY...CAR UNSAFE TO DRIVE. CAR JUST PURCHASED FROM UNSAVORY CAR DEALER...

MY HUSBAND WAS DRIVING AND I WAS THE PASSENGER. 12/23/15. THE CAR WAS A 2007 DODGE CALIBER. APPROX 80,000 MILES ON IT. NO PRIOR ACCIDENTS. A CAR TURNED INTO DRIVER SIDE. MY HUSBAND WAS NOT HURT. BOTH CARS GOING APPROX 10 MILES AN HOUR. I WAS HIT WITH AIR BAG. I RECEIVED A BROKEN RIB, NEW BRIDGE COMPLETELY KNOCKED OUT(OR SHOULD I SAY IN.). MY BACK, NECK, ANKLE STILL GIVE ME A LOT OF PAIN TODAY. MY BODY BRUISED HEAD TO TOE. CONCUSSION.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THE FRONT SUB-FRAME HAD EXPERIENCED SEVERE CORROSION. THE CONTACT STATED THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME WAS CORRODED AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 85,000.

THE CROSSMEMBER IS RUSTED AND HAS A HUGE WHOLE IN IT. I GET REGULAR OIL CHANGES AT THE DODGE DEALER, WITH NO MENTION OF THE CROSSMEMBER ISSUE. STARTED HEARING NOISE IN FRONT END TOOK TO MECHANIC AND INFORMED OF ISSUE. AFTER SOME RESEARCH FOUND 10 YEAR EXTENSION OF WARRENTY ON THIS PART. WENT TO GET REPLACED AND FOUND OTHER SUSPENSION ISSUES CAUSED BY THE SEVERE RUST, WHICH THEY WILL NOT COVER. VEHICLE NOT SAFE TO DRIVE AND THE COST FOR US TO FIX IS MORE THAN THE WORTH OF THE CAR!! AT THIS POINT HAVE NO TRADE IN VALUE FOR CAR...

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE DRIVING 40 MPH, THE SUBFRAME FRACTURED ON THE VEHICLE. IN ADDITION, THE CONTACT REPLACED THE TIRES ON THREE OCCASIONS AND THE REAR WHEEL BEARINGS WERE REPLACED THREE TIMES. FURTHERMORE, THE IGNITION SWITCH CAUGHT FIRE. THE CONTACT EXTINGUISHED THE FIRE. THE VEHICLE WAS TOWED AND REPAIRED BY A DEALER AND AN INDEPENDENT MECHANIC. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS 162,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THE K FRAME PREMATURELY RUSTED WITH EXTENSIVE CORROSION AND THERE WAS A NOISE WHEN TURNING COMING FROM THE LOWER FRONT OF THE VEHICLE. THE CONTACT STATED THAT THERE WAS RUST ON THE WHEEL FRAME NEAR THE DRIVERS SIDE TIRE WHEEL FRAMING AS WELL. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 124,680.

EXTENSIVE CORROSION FRONT AND REAR CROSS FRAME MEMBRANE. MAKING VEHICLE DANGEROUS TO DRIVE. DODGE KNEW OF THE PROBLEM AND EXTENDED THE WARRANTY BUT DID NOT INFORM ALL OWNERS.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, AN ABNORMAL NOISE EMITTED FROM THE FRONT OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUB FRAME HAD CORRODED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 90,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE DRIVING APPROXIMATELY 35 MPH, THERE WAS AN ABNORMAL CLICKING NOISE COMING FROM THE FRONT OF THE VEHICLE. THE CONTACT OBSERVED THAT THE SUBFRAME WAS SEVERELY CORRODED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 117,000.

CROSSMEMBER DETACHED FROM VEHICLE WHILE DRIVING CAUSING LOSS OF STEERING DUE TO FRONT DRIVERS WHEEL AND AXLE BECOMING DETACHED. TOOK OUT CONTROL ARM,CV JOINTS , TRANSMISSION COOLING LINES. IT LEFT SKID MARKS IN PAVEMENT WHERE THE TIRE DUG IN. ACTUALLY RIPPED THE TREAD ON NEW TIRE. COME TO FIND OUT THIS IS AN EXTENDED WARRANTY THROUGH DODGE. HOWEVER IF YOUR NOT THE ORIGINAL OWNER OF THE VEHICLE YOU MAY NOT BE NOTIFIED BECAUSE IT IS NOT A RECALL.

YESTERDAY I HAD MY CAR CHECKED FOR A LEAK. THIS WAS FIXED AND THE MECHANIC TOLD ME THAT MY ENGINE CRADLE IS RUSTED THROUGH. THEY HAD ME LOOK AT THE UNDERCARRIAGE AND I COULD NOT BELIEVE WHAT I SAW. I TAKE GOOD CARE OF THIS CAR, IT HAS ALWAYS BEEN GARAGE KEPT WITH SUGGESTED MAINTENANCE CHECKS TAKEN. THIS IS ALSO VERY FRUSTRATING TO ME AS I JUST HAD MY CAR FIXED (NEW MANIFOLD ALONG WITH VALVES, GASKETS, O-RINGS, OIL CHANGE, RADIATOR CAP AND RADIATOR FLUSHED AND RE-FILLED) BY A DODGE MECHANIC AND WAS NOT INFORMED ABOUT THIS. THE CAR WAS SEEN AT DODGE IN FEBRUARY (RE-CHECKED IN MARCH AND APRIL) THEN TAKEN TO ANOTHER MECHANIC IN JUNE. THANKFULLY I TOOK THE CAR SOMEWHERE ELSE OR I MIGHT HAVE HAD AN ACCIDENT, MALFUNCTION OR OTHER ISSUE. HOW DO I GET THIS ISSUE TAKEN CARE OF...IT SHOULD NOT HAVE RUSTED OUT LIKE...

MY 2007 CALIBER IS PARKED I WILL NOT DRIVE IT BECAUSE THE FRAME IS RUSTED OUT SO BAD IT IS NOT SAFE FOR ME AND MY KIDS. MY MECHANIC TOLD ME TO NOT DRIVE. THIS CAR IS NOT EVEN 10 YEARS OLD IT DEFINITELY SHOULD NOT BE RUSTED LIKE THAT! VERY DISAPPOINTING.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE DRIVING AT AN UNKNOWN SPEED, THE FRAME OF THE VEHICLE FRACTURED. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 87,476.

REAR SUBFRAME IS ROTTING AND UNSAFE TO DRIVE. LICENSE MECHANIC INSPECTED THE VEHICLE.

THE FRONT CROSS MEMBER ON THIS CAR HAS SIGNIFICANT CORROSION CAUSING A LARGE HOLE AND LOSS OF INTEGRITY BASED ON A DEALER INSPECTION. IT HAS NOT ACTUALLY FAILED AT THIS TIME. THE ESTIMATED REPAIR COST FROM THE DEALER IS $1209 INCLUDING $665 FOR A REPLACEMENT CROSS MEMBER. THE MANUFACTURER HAS STATED TO ME THAT THIS IS NOT COVERED UNDER WARRANTY BECAUSE THE VEHICLE WAS ORIGINALLY SOLD IN CANADA. I OWN ANOTHER 2007 CALIBER AND THIS SAME PROBLEM WAS ACKNOWLEDGED TO BE A DEFECTIVE PART. A LETTER WAS SENT REQUESTING THAT I TAKE IT TO THE DEALER FOR INSPECTION AND POSSIBLE REPAIR. THE DEALER RECENTLY COMPLETED THE REPAIR ON THAT VEHICLE AT NO COST TO ME.

I NOTICED THAT MY CAR WAS MAKING CRUNCHING AND POPPING NOISES WHEN I TURNED SO I TOOK IT TO MY MECHANIC, WHO TOLD ME THAT MY CROSSMEMBER UNDERNEATH THE VEHICLE WAS SEVERELY CORRODED AND NEEDED REPLACED. AND TO NOT DRIVE IT UNLESS ABSOLUTELY NECESSARY.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE THE VEHICLE WAS UNDERGOING SCHEDULED MAINTENANCE, THE MECHANIC INFORMED THE CONTACT THAT THE FRAME WAS SEVERELY RUSTED AND THE STRUTS COULD NOT BE CHANGED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN UNRELATED REPAIR AND IT WAS DISCOVERED THAT THE ENTIRE SUBFRAME WAS SEVERELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MECHANIC RECOMMENDED THE VEHICLE BE DRIVEN ONLY SHORT DISTANCES DUE TO A POTENTIAL SAFETY RISK. IN ADDITION, THE FRONT PASSENGER AND DRIVER SIDE CONTROL ARMS WERE REPLACED ON A SEPARATE OCCASSION. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 45,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE DRIVING 45 MPH, THE CONTACT NOTICED THAT THE ANTI SKID AND ABS WARNING LIGHTS ILLUMINATED WITHOUT WARNING. ALL OF THE INSTRUMENT PANEL LIGHTS ALSO ILLUMINATED. THE CONTACT DROVE THE VEHICLE TO A DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT AND REAR ENDS OF THE VEHICLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT SPOKE WITH THE MANUFACTURER WHO APPROVED THE REPAIRS PERFORMED BY ANOTHER DEALER. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000. UPDATED 02/12/16*LJ *TR

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT NOTICED THAT THE SUBFRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 160,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE DRIVING APPROXIMATELY 35 MPH, A LOUD ABNORMAL NOISE EMITTED UNDERNEATH THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE FRONT FRAME WAS COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 111,000.

HAD THE CAR INSPECTED BY LOCAL MECHANIC AND FOUND THE FRONT SUBFRAME WAS ROTTED.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE HAVING ROUTINE MAINTENANCE PERFORMED ON THE VEHICLE BY AN INDEPENDENT MECHANIC, IT WAS BROUGHT TO THE ATTENTION OF THE CONTACT THAT THE VEHICLE'S CROSS MEMBER HAD RUST HOLES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FRONT LOWER CONTROL ARMS, INNER AND OUTER TIE RODS, AND CROSS MEMBER FAILED AND NEEDED TO BE REPAIRED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 76,092.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT WHILE AT AN INDEPENDENT MECHANIC FOR A ROUTINE SERVICE, THE MECHANIC DIAGNOSED THAT THE SUBFRAME CORRODED AND BOTH FRONT BALL JOINTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THERE WAS AN ABNORMAL NOISE UNDER THE FRONT AND REAR OF THE VEHICLE. THE CONTACT DISCOVERED THAT THE UNDERCARRIAGE WAS SEVERELY RUSTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE REAR SUSPENSION AND THE FRONT UNDER CARRIAGE NEEDED REPLACEMENT FOR RUST DAMAGE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 170,000. THE VIN WAS NOT AVAILABLE.

TL* THE CONTACTS OWNS A 2007 DODGE CALIBER. WHILE DRIVING APPROXIMATELY 45 MPH, THE FRAME OF THE VEHICLE FRACTURED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE FRAME WAS RUSTED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. WHILE DRIVING APPROXIMATELY 20 MPH, THE FRONT SUBFRAME FRACTURED DUE TO RUST. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSTIC TESTING. THE TECHNICIAN STATED THAT THE SUBFRAME AND SWAY BAR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 99,900.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. AFTER THE VEHICLE WAS TAKEN TO HAVE A FRONT WHEEL ALIGNMENT, THE TECHNICIAN INFORMED THAT THE FRAME OF THE VEHICLE WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 170,000.

2007 DODGE CALIBER. WHILE DRIVING APPROXIMATELY 35 MPH, CROSS MEMBER AND THE SUBFRAME FRACTURED CAUSING THE FRONT DRIVE SIDE TIRE TO FRACTURE AND TURN INWARD. DUE TO THE FAILURE, THE VEHICLES STEERING AND DRIVEABLITY WERE COMPRISIED. THE VEHICLE WAS INSPECTED BY A MECHANIC AND COMMENTED THE SUBFRAME AND THE CROSS MEMBER HAD RUST THROUGH RENDERING THE VEHICLE UNDRIVEABLE. I WILL BE CONTACTING DOGE REQUESTING RECALL STATUS. LOCAL DODGE DEALERS - SERVICE DEPARTMENTS CONTACTED, THE REPAIR IS COVERED UNDER A "MEMO" UNTIL MARCH, 2017 AND UNLIMITED MILEAGE BUT IS NOT LISTED AS A RECALL.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE REAR OF THE VEHICLE VEERED TO THE LEFT AND RIGHT UNCONTROLLABLY. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO DIAGNOSED THAT THE ENTIRE UNDER CARRIAGE WAS CORRODED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 145,000.

I HAVE A 2007 DODGE CALIBER AND THE SUB FRAME IS SO RUSTED THROUGH THAT IT CRACKED WHILE MY SON WAS DRIVING IT. THANKFULLY HE WAS COMING HOME AND IT HAPPENED COUPLE MINUTES FROM HOME. I CANNOT BELIEVE A CAR, THAT IS ONLY 7 YEARS OLD, CAN RUST SO SEVERELY IN SUCH A SHORT PERIOD OF TIME. I CANNOT BELIEVE DODGE HAS NOT ISSUED A RECALL ON THIS. WHAT ARE THEY WAITING FOR? ARE THEY WAITING FOR ENOUGH PEOPLE TO GET INTO ACCIDENTS AND POSSIBLY KILL SOMEBODY, BEFORE THE RECALL THIS MANUFACTURE DEFECT? THEY MUST HAVE SOME REALLY GOOD BEAN COUNTERS. WHEN I STARTED LOOKING ON THE INTERNET, I WAS SHOCKED TO SEE SO MANY COMPLAINTS FROM PEOPLE WITH THE EXACT SAME PROBLEM AS I AM HAVING, AND THEIR CARS WERE YOUNGER THEN MINE. I WAS SHOCKED TO FIND OUT THAT THERE HAVE NOT BEEN ANY RECALLS ISSUED FOR THIS....

JUST FILING A COMPLAINT ABOUT SUBSTANDARD MANUFACTURING OF MY VEHICLE CROSS MEMBER PARTS. SUBSTANDARD MATERIAL WAS USED AND SEVERE CORROSION IS A RESULT. CHRYSLER HAS A RECALL FOR REPAIR. COULD POSE SAFETY ISSUES IF PARTS RUST COMPLETELY THROUGH. *TR

WHEN I WAS DRIVING IN TOWN AT SPEEDS AROUND 25-40 MPH I KEPT HEARING A CLICKING NOISE BENEATH THE DRIVERS SEAT, ESPECIALLY WHEN I MADE TURNS. I TOOK IT TO A SHOP AND THEY LIFTED IT UP. TURNS OUT THE ENTIRE SUSPENSION CARRIAGE WAS RUSTING AND ROTTING. THE CLICKING NOISE I WAS HEARING WAS RUSTY PIECES OF METAL RUBBING AGAINST ONE ANOTHER. WE TOOK IT TO A DEALERSHIP AND THEY SAID THAT THE AC CONDENSATE LINE WAS DIRECTED TO THE SUBFRAME/UNDERCARRIAGE OF THE CALIBER. THE WATER WAS POOLING AND CAUSING IT TO RUST. I'M GRATEFUL WE FOUND OUT ABOUT IT WHEN WE DID INSTEAD OF HAVING THE WHOLE BOTTOM OF THE CAR FALL OUT FROM UNDER US WHEN WE WERE GOING AT A HIGH SPEED. THIS SEEMS TO BE HAPPENING TO MANY OF THE DODGE CALIBERS RIGHT AROUND 7 YEARS. WE HAVE PHOTOS OF THE DAMAGE. UNBELIEVABLE. *TR

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR AN UNRELATED REPAIR WHEN HE NOTICED THAT THE ENTIRE SUB FRAME WAS COMPLETELY CORRODED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 88,595.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT WHILE HAVING MAINTENANCE PERFORMED, HE WAS NOTIFIED THAT THE ENGINE CRADLE WAS COMPLETELY CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 153,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT THE FRONT AND REAR OF THE SUB FRAME WAS RUSTED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO CONFIRMED THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE APPROXIMATE FAILURE MILEAGE WAS 100,000.

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT WHILE HAVING MAINTENANCE PERFORMED, HE WAS NOTIFIED THAT THE ENGINE CRADLE WAS COMPLETELY CORRODED. THE VEHICLE WAS NOT TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGE WAS 85,000.

NOTICED RUSTED SUBFRAME WITH BIG HOLE. WE KNEW IT NEEDED TO BE REPLACED. NO PARTICULAR REASON FOR THE EROSION OTHER THAN THE WAY THE VEHICLE IS DESIGNED. VEHICLE IS ONLY 6-7 YEARS OLD. THIS TYPE OF EROSION IS USUALLY ONLY SEEN ON OLD VINTAGE VEHICLES. A FEW DAYS AGO, WE RAN OVER A HIDDEN POT HOLE AND THE SUBFRAME IS COMPLETELY BROKEN APART. NOW CAR IS COMPLETELY UNSAFE TO DRIVE. THIS CAR WAS POORLY DESIGNED IN THIS AREA. THE COMPANY SHOULD RECALL THE SUBFRAME TO REPLACE AND INSTALL A REROUTING PIECE FOR THE AC TO DRIP ON AND BYPASS DRIPPING ON THE FRAME. *TR

WENT TO GET CAR INSPECTED AND THE MECHANIC FOUND OUR CROSSMEMBER FRAME WAS RUSTED OUT. IT IS ONLY 5 YRS OLD AND HAS 63000 MILES, UNHEARD OF. NEXT STEP CONTACT DODGE SEE WHAT THEY CAN DO TO HELP US GET THIS REPAIRED, RIGHT NOW CAR IS UNSAFE TO DRIVE. *TR

MY 2007 DODGE CALIBER WAS TAKEN TO MY MECHANIC WHERE IT WAS FOUND THAT THE MAIN SUBFRAME HAD RUSTED THROUGH IN MULTIPLE PLACES. THE CAR IS ONLY 6 YEARS OLD AND HAS APPROXIMATELY 76,150 MILES. I CALLED CHRYSLER AND MENTIONED IT. CUSTOMER SERVICE STATED THAT THEY WOULD ONLY PROVIDE COST ASSISTANCE IF I HAD THE WORK DONE AT A CHRYSLER DEALERSHIP. THE CAR WAS TAKEN APART AND ON THE LIFT AT MY PREFERRED MECHANIC. I HAD MY MECHANIC PROVIDE THE SERVICE. I DID RECEIVE A QUOTE FROM A LOCAL CHRYSLER DEALERSHIP IT WOULD HAVE COST ME $ 850.00. MY MECHANIC DID THE SERVICE FOR $ 650.00. CHRYSLER HAS REFUSED PAYMENT. THIS SUBFRAME COMPONENTS IS RUSTED THROUGH IN THREE LOCATIONS. AFTER ONLY 6 YEARS, THIS DOESN'T SEEM ACCEPTABLE ON A MAJOR FRONT END COMPONENT. *TR

WHEN DOING A BRAKE JOB I NOTICED THE FRONT K MEMBER HAD A CORROSION HOLE IN THE BACK OF IT, THIS IS THE FRONT SUB FRAME THAT HOLDS THE POWERTRAIN AND FRONT SUSPENSION. *TR

WHILE UNDER MY DODGE I NOTICED THAT THERE IS A LARGE AMOUNT OF RUST. AFTER FURTHER INSPECTION I SAW THAT THEY DESIGNED THE AC CONDENSATION TO DRIP DIRECTLY ONTO THE FRAME. THIS BAFFLES ME SINCE ALL THEY HAD TOO DO IS DESIGN A TUBE TO DIRECT THE WATER ONTO THE GROUND. I AM NOT SURE EXACTLY HOW THIS HAS EFFECTED THE STRENGTH OF THE FRAME BUT FROM THE AMOUNT OF RUST ON THE SPOT WHERE THE WATER DRIPS I DON'T HAVE A WARM AND FUZZY THAT THE FRAME WILL LAST THE LIFE OF THE CAR OR THAT THE FRAME WON'T JUST SNAP WHILE DRIVING AND CAUSE AN ACCIDENT. VERY UNSAFE PRACTICE AND WITH SUCH AN EASY FIX DON'T UNDERSTAND IT AT ALL. *TR

TL* THE CONTACT OWNS A 2007 DODGE CALIBER. THE CONTACT STATED THAT VEHICLE MADE A LOUD NOISE WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO TWO INDEPENDENT MECHANICS FOR INSPECTION. THE FAILURE WAS LOCATED AT THE SUB FRAME, WHICH WAS SEVERELY CORRODED AND FRACTURED. THE CONTACT WAS ADVISED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGE WAS 124,000.