2021 CHEVROLET TAHOE Engine Problems

[XXX] # [XXX] VIN = [XXX] MAKE ; Chevrolet Tahoe 2021 RE : I received a recall affects certain 2021-2024 models equipped with the 6.2L V8 L87 engine. The defect involves the connecting rod and/or crankshaft engine components, potentially leading to engine damage or failure. On March 2025, My Tohoe completely stopped while I was driving. My SUV was towed to Bomnin Chevrolet in Manassas Virginia. They diagnois was crank shaft damage leading to engine failure. My SUV was in the dealership for 2 weeks while the engine was replaced. I spent a total of $ 15,027.20 to fix my car for that problem. I called GM recall about this problem. I was informed that the recall was for only certain vehicles. Not my SUV. I am concerned that my SUV was affected by faulty crank chaft. I had to replace the engine. Thanks, [XXX] INFORMATION REDACTED PURSUANT TO THE...

several issues with certain popups regarding various indicators on dash and engine not getting enough psi

Unknown - engine is driving hard and somethings wrong. No one will service my car because they say it’s on a recall, but then when they look up the VIN number it’s not on a recall however there are major issues going on.

On April 25th, 2025 while traveling on Interstate 20 at 70+mph speeds with my children in my vehicle and 30 weeks pregnant, with no indication of an issue my 2021 Chevrolet Tahoe suffered catastrophic engine failure. There was zero warning from the vehicle including noises/electronic display warnings that this was fixing to occur. In the middle of going 70+mph surrounded by traffic on a busy interstate the vehicle just shut off completely. I was able to use what momentum I had from my speed to get on to the shoulder. However, the failure prevented me from being able to turn on my signal to alert other drivers of my merging and prevented the use of my emergency flashers to signal once on the shoulder immobile. The vehicle would not start up again after that, and I had to call a tow truck to take my vehicle to the nearest certified...

While starting from a stop the engine stuttered and resulted in a major loss of power. Luckily this occurred pulling out of our driveway on to a quiet neighborhood street. Several warning lights and messages went off including the engine and transmission system warning, “service ESC”, “Service Traction Control”, and the emission system warning. After driving it to the dealership at 30mph since the shaking and banging noise was so bad, the dealer diagnosed it as a cylinder 6 caused by a failed lifter and lifter rod. Resulting repair involved lifters and rods in that same bank at a $3500 repair. The vehicle was just over 4 years old with 79,250 miles.Repair invoice available upon request.

The contact owns a 2021 Chevrolet Tahoe. The contact stated that upon coming to a complete stop, the vehicle suddenly jolted forward independently. The vehicle returned to normal functionality, but the failure became a regular occurrence. No warning lights were illuminated. The vehicle was taken to the dealer, who diagnosed a failure with the valve body. The vehicle was not repaired due to part availability. The manufacturer was notified of the failure but provided no assistance. The failure mileage was 57,000.

“Catastrophic engine failure” as stated by Chevrolet dealership service department. Loud rattling noise prompted service visit. Not 6.2 liter engine, but almost identical issue.

Check Engine Light Came On. Upon Diagnosis', the engine is misfiring, lifters are not performing correctly and there are critical engine alerts and an estimate of 11,000 to fix. 2021 - 83,000 miles v8 - 5.3 NOT the 6.2 and no one will help me bc my power train expires. I am the only owner. Second brand new Tahoe ai bought from this dealership and they are doing nothing to help.

On April 25th, 2025 we were taking our kids to their after school activities when the SUV started to shake, and accelerate very fast by barely pushing the gas pedal, the ETS light along with the forward collision warning also appeared on the dashboard along with the check engine light. This prompted my husband to get our vehicle towed to the nearest shop close to the street where our vehicle started having problems. After several days of diagnostics the shop let us know our vehicle needed the following repairs: Bank One lifters replacement, head gasket service, and a water pump replacement, we ok'd the repairs. Although these components were replaced, we were informed on May 15, 2025, that the vehicle continues to misfire and now requires a camshaft replacement as well. The total cost of the repair has now risen from $5,182.16 to $13,549.79, which is a significant financial burden...

While traveling on the highway one day, my 2021 Chevrolet Tahoe began warning lights on the dashboard. Shortly after, it running roughly,, and jerking, so I pulled over to investigate. There no visible smoke, so I drove to the nearest auto parts store, where they ran a diagnostic test that returned a code of P0306. I then took vehicle back to the dealership where have always received oil changes and repairs. I have never visited any other dealership, relying on certified GM/Chevrolet dealerships. After inspecting the vehicle, they informed me that the lifters needed replacement advised that it would be best to replace the engine entirely. Upon further research, I discovered that issue has been affecting many people in our area and across the United States. This needs to be addressed, as the vehicle is only three years old, purchased brand new with zero miles, and I have not done...

MY 2021 TAHOE ENGINE LIGHT CAME ON 4/26/2025 AS WELL AS IT BEGAN RIDING ROUGH. SCHEDULED SERVICE ON 5/01/2025 WHICH I WAS INFORMED COST OF FAILURE ENGINE DIAGNOSIS REPAIR WOULD COST ME $5,000 UP TO $15,000 TO REPAIR. MY VEHICLE IS BASICALLY NEW AND WHY IS MY VEHICLE NOT INCLUDED IN THE ENGINE FAILURE RECALL? HOPEFULLY IT IS AN OVERSIGHT. AS A VALUED CUSTOMER PLEASE ADVISE, THANKING YOU IN ADVANCE.

On May 14, 2023 I was on a trip driving the Tahoe (midnight blue Tahoe in the pictures) about 60 mph, on highway 41 (middle of nowhere, no cell reception) south of kettleman city, CA when, without any warning or symptoms of any problem whatsoever, the engine lost propulsion and died. I was able to coast onto the shoulder and tried starting it. It started again and I continued driving and about 35 minutes later I stopped at a red light on Highway 41 in Lemoore, CA. Again the Tahoe engine died without warning and would not restart. When I tried starting it I could smell a burning smell. The engine cranked but wouldn’t start, and then the check engine light came on. I was at a stoplight on a major highway and was unable to move the vehicle, and was scared to sit in it, so I put on...

Sudden engine failure while driving. Was able to pull to the side of the road with a few hundred feet. Repair required full engine replacement. Have to other friends that drive similar gm products that also experience engine failure with 3 weeks of our incident.

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed, there was a loud revving and knocking sound coming from the engine compartment. The contact stated that later after starting the vehicle, the check engine warning light illuminated with the knocking sound coming from the engine. The vehicle was driven to the local dealer who diagnosed that the engine was faulty and needed to be replaced. The engine was replaced, and the vehicle was repaired. The manufacturer was notified of the failure. The contact was informed that the VIN was not included in NHTSA Campaign Number: 25V274000 (ENGINE AND ENGINE COOLING). The contact stated that the vehicle had experienced the failure listed in the recall. The failure mileage was 70,000.

We had a failed lifter that caused bent rods which caused scratches on the crank shaft which caused us to have to replace the engine. After a simple internet search I have found the lifter failure is very common with gms 5.3 v8. We were told oil needs to be changed at least every 5000 miles although the vehicle prompts you around 7000.

Engine burning through oil excessively. Has been noted on multiple occasions and requires early changes and top off. Is also happening with 3 friends with the same make and model with the 6.2L. No warnings but was informed it is common at shop.

Traction control light came on and the vehicle felt like it was going to die/low idle. I took to dealership on 9/13/22 (5months after getting vehicle) and the codes P03000 00 which is an engine misfire, P050D 00 which is cold start rough idle and it was noted by service tech that engine making a clunk and ticking noise. There was a misfire on cylinder 6. They removed the valve cover and the intake valve rocker arm was not moving at all and when the rocker arm was removed they noticed the push rod was also bent. They verified the DFM lifter was collapsed.

I was driving along the highway at 11pm when I the vehicle started shaking and I heard strange sounds coming from outside the vehicle. I pulled over to inspect and realized it was coming from the engine bay. The engine was making knocking, rattling, and belt slipping noises and the entire vehicle was shaking and the engine also stuttering. I was able to drive the vehicle to a nearby plaza where I had it towed the following morning. There were no warning signs, the vehicle ran properly up until this occurred. The dealership inspected it and told me the engine needs to be replaced and it was likely that a rod bearing that went bad. This happened nearly 2 months ago and I am still waiting for a new engine.

2nd glow plug failure

After I washed my 2021 Chevrolet Tahoe, I went to run some errands. As I pushed the start button, the car would try to start but did not. I tried several times without success. I had the truck towed to Ed Morse Chevrolet in Sunrise, Florida. My odometer is at approximately 43,000 miles. About 3-4 months ago, at 42,000 miles, I had the same situation. I had to have the truck towed to Ed Morse. At the time, the Service Writer told me it was probably the fuel cell module and that Chevy has been a problem with them. The Service Writer surprisingly admitted that this issue could cause the truck to stop in the middle of your commute! I told him that an issue this serious needs a recall. So, today, when AAA picked up my truck, he said that this happens frequently and he towed many Chevrolet Tahoes...

2 incidents of complete engine power loss while driving. Luckily was able to roll off road safely to curb. Dashboard glitch/flashing multiple/various message, including check engine, conditions not ideal to shift, etc. Would not re-start/shift when attempted. Tried disconnecting battery cable completely and re-connecting and that seemed to 're-set' the system and engine re-started. Incidents were about 30 days apart. "This battery reset" was tried because approx 1 year prior after leaving Tahoe parked at airport for a 7 day trip, it would not start, completely dead. Battery charge/jump would not work...watched youtube videos and someone said to try disconnect/reconnect cable and it worked to start it up at that time & did take it into Dealership after that incident and no-cost repairs were made for that issue. Called Chevy 3/25/25 on this power loss while driving issue to ask for information/assistance, they advised to take to dealership for diagnostic...

Driving on a highway to Dallas and vehicle loss power and locked up in the middle of the highway.Was stranded on the highway for 4 hours. Vehicle would not start up and had to get towed to local dealership. Dealership diagnose the problem and stated that the engine has failed. I got the vehicle towed back home to my local dealership and they confirmed that the engine has failed. The vehicle showed no signs of engine issues. GM needs to recall this vehicle.

Approximately 4/14/24 while I was driving home from being out of town with my child the check engine light came on with a message “Reduced acceleration drive with care.” The car was not shifting and I couldn’t go over 45 mph and the rpm’s were about 3000 at that speed. The light went off and the car seemed to be driving normally. While on the interstate traveling at approximately 70 mph the car did a hard shift and drastically slowed while the rpm’s spiked. I took it to the dealership who determined the valve body needed to be replaced. Approximately August 2024 it happened again but the light went off. December 2024 same issues with the check engine light, reduced acceleration and not shifting happened. Took the car back 12/9/24 where a wire was replaced. Picked the car up 12/12/24 and 12/18/24 while driving in the car rider line picking...

Engine failed while driving down the road. There was not prior warning signs to this issue. Vehicle was unable to accelerate. The safety of myself and husband were put a risk as we were traveling on an Interstate 12 in Baton Rouge, LA. The vehicle was inspected by Pine Belt Chevy and the cause identified as Camshaft and lifters failed in the engine causing a sudden deacceleration.

Engine knocking while accelerating. Told by Chevy dealership that a thruster is broken. Car is only 4 years old with 60k miles. Unfortunately, not under warranty. Quoted $5,000 for fix. No errors on dash or visuals of the problem.

At 35,000 miles, my 2021 Chevrolet Tahoe started to misfire. When I pressed the accelerator, the truck started hesitating and the check engine light started flashing. I was able to get the truck to the dealer I purchased it at. The technician "claimed" it was a bad fuel injector. The dealer replaced the spark plug and injector. The vehicle was never test driven. I picked up the truck and drove it on the road. Within 1 mile, the truck started to misfire again with the check engine light started flashing. The dealer claimed that the lifter or lifters in one engine bank were bad. The dealer replaced the lifters on the one side of the engine.

2021 Chevrolet Tahoe Engine began misfiring and check engine light and ESC warning indicators displayed as I was driving. I pulled over and shut off vehicle, read manual and restarted engine. Same problems occurred, so I drove to Chevrolet dealer which was a mile away. The advisors said I shouldn’t drive it on the expressway or any further since engine had known problems that GM was aware of and it would blow up. Scans showed P0300 & P0305 for Cylinder 5 misfire. Major Repair included replacement of all lifters and push rods on both banks and the camshaft taking 17 days. This engine should have a GM Recall due to its severity. I was told the engine usually blows up before the warranty period is over and GM would just fix it. Unfortunately for me, my engine failed after full warranty and while I was traveling out of state to...

This is a fairly new vehicle, so to be told we need a new engine when we’ve had the car for only 4 years is ridiculous! We were driving one day and heard a knocking sound coming from the front of the car. We made it home, but when we tried to leave the next time, we only made it halfway down our driveway when we heard a loud knocking noise from the front and the car suddenly stopped. We were dead in the water and needed to get the car towed back to our house. The gear shift was also stuck in drive and we couldn’t turn the car on. The engine had completely seized up. The tow truck driver had to get underneath the vehicle in order to disengage the gear shift and allow us to shift into neutral so that we could get it back home. When...

GM has a known issue with engine lifters on this model engine that fail around 60,000 miles. Customer service managers even stated so themselves and GM has a TSB related to this. Repair bill is $5K-$6K if it doesn’t bend the cam shaft and upwards of $10K if cam is bent. This is a huge safety issue because vehicle fails while in motion, shakes violently, and numerous safety features the driver relies on turn off.

My wife was driving the vehicle when all of a sudden the engine started knocking and throwing a bunch of codes. The engine has a bottom end knock and it seems this is a known problem with these engines.

Vehicle has no warning of issues. Regular maintenance had been performed and had 80k miles. Driving down a 4 lane the engine locked up and lost power. We have been waiting on it to be repaired for 4 months now. The engine is back ordered from GM and no one can find used ones. We found a refurbished one but it also locked up within 30 minutes of being installed. I was warrantied so now we are having ours rebuilt but is costing us $14k.

I am getting heavy oil consumption and the dealer just keeps on wanting to run tests and not fix the actual issue

On [XXX] I was driving in the [XXX] in El Paso Texas at about [XXX] I was about to enter [XXX} and the vehicle suddenly stopped with no warning! I was able to pull to the side and put the blinkers because the traffic was heavy and could of had a vehicle crash into me if I had not maneuver the vehicle quickly(My two daughters where with me in the vehicle). The vehicle prompted to start the vehicle, which I did so and continued my way. As soon as I was able to get into the [XXX] the check engine light turned on, and the forward collision warning message on the display. I stopped to my nearest Autozone to get some help as the vehicle started to make a noise too. They connected their computer and told me that the vehicle was given a message of a faulty cylinder, they...

I have taken this vehicle two times to the dealers that sell Chevrolet. The first time it was there for 5 hours and nothing was done and the second time the service agent said there was no recall on this vehicle when obviously there is one.

The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving 5 MPH in the driveway, the vehicle stopped and stalled. The vehicle failed to restart. The vehicle was towed to an independent mechanic who determined that the fuel pump control module needed to be replaced. The vehicle was repaired. The contact called the local dealer and was informed that there were no associated recalls. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed that the vehicle was not included in NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline). The failure mileage was approximately 30,000.

Driving on the I-95 I abruptly lost power driving in the left lane, RPM dropped all the way down and speed was rapidly decreasing. I had to pull over on the shoulder in the most safe manner possible for myself and other drivers on the road; but it was not without any risk. The body of the car was rattling on my way to the shoulder and the car shut off before I could put the car in Park in a safe place. With my hazard lights on I tried restarting the car but the enging would not turnover, the starter would run and the car would rattle about all whilst creating a traffic jam. Once i noticed the engine light and yielded to the car's inabiltiy to start up, we got the attention of a FHP State trooper who called in a Tow truck for us. Getting te car...

Stopped for gas, then proceeded to leave store, the check engine light came on, and car immediately shut off while on the highway going ~25mph. Car would not turn back on, and then lights for fuel machine error started coming on. Car sat there trying to turn on, lights off, and then would say push start button, but nothing happened. Car began to shake and continued to try to turn on, yet nothing happened. Car was towed to home, sat for an hour and then started again, check engine light remains on.

The contact owns a 2021 Chevrolet Tahoe. The contact stated while driving at various speeds on several occasions, there was a banging sound coming from the engine compartment. The vehicle was taken to a dealer where it was diagnosed and determined that the cam lifters needed to be replaced. The contact stated that the failure reoccurred two weeks later. The manufacturer was notified of the failure. The failure mileage was approximately 11,400.

I am experiencing loss of power just like the recall shows for campaign 22V036000 powertrain. Engine stall in the middle of the street just like it shows for the fuel system 21V73 9000. I have stalled in the middle of the street including today four times and a month. The dealership can’t seem to find what’s wrong. Nor other places. I don’t think they are looking hard enough at the dealership. I almost got killed by another car going at least 65 mph while I was stuck in the middle of the street at a stoplight. These are all different days. While working and people in my car.

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving 35–40 MPH, the vehicle abruptly shut off. The contact continued to pump the brake pedal to alert oncoming traffic. There were no warning lights illuminated. The contact called the Police, and the vehicle was towed to an impound lot. The vehicle was towed to the local dealer, where it was diagnosed that the fuel pump control drive module needed to be replaced. The vehicle was repaired. The manufacturer was contacted, and a case was opened. The contact stated that the failure was related to NHTSA Campaign Number: 21V739000 (Fuel System, Gasoline). The failure mileage was approximately 38,000.

As a traffic crash reconstructionist, the issue is a MAJOR SAFETY ISSUE. My wife was exiting a residential driveway when the vehicle started to stutter and immediately shut down with no power or any capability to get the vehicle off the road. The shutdown caused the blockage of a residential street on a Friday afternoon, until the correct tow truck arrived. This was due to the fact the vehicle could not be moved due to not being able to start the engine nor the ability to place the vehicle into neutral, without starting the engine or crawling un der it with tools. It was determined the fuel module went bad. There was no warning of the failure of the component. Luckily the shut down of all components of the vehicle did not occur on a high speed or highly traveled road since I did not have any control of the...

Third time engine only cranks and will not start. I was forced to disconnect the battery and reconnect after a short while to get the vehicle to start.

The contact owns a 2021 Chevrolet Tahoe. The contact stated that while driving at an undisclosed speed and making a left turn, the vehicle lost motive power and stalled in the middle of the road. The contact was unable to restart the vehicle. The contact stated that the gear shifter had seized in park. The vehicle was towed to the dealer. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure. The failure mileage was approximately 16,000.

This is the second engine I’ve had replaced since I bought the vehicle in December 21, 2023. The first engine failed in August of 2022 while I was driving on the highway. The vehicle began to smoke and shut down while I was driving on the highway. The vehicle shut down and I had to use the current momentum of the vehicle to pull over to the shoulder. The vehicle would not come out of gear and would not restart. I complained of transmission problems ever since the engine was replaced. The service department escalated the concerns to the GM engineers who never gave directions to check the transmission fluid or physically check the transmission. January 24 of this year I was on the highway driving to work when the vehicle again shut down. The dash stated restart the vehicle. While in motion the vehicle was trying to shift to...

The failed component was reported to be the Coolant Surge Tank. This component cracked and begin to leak engine coolant causing the vehicle to overheat and become undrivable. This failure also lead the inoperability of the heating system inside the cabin of the vehicle. The failure of this component is widespread knowledge in the Chevrolet Tahoe/Suburban and GMC Yukon ownership community. In some cases dealerships are purposely marking up the cost of replacement components due to the scarcity caused by this failure and production issue within GM. The only symptoms of this issue were overheating and inoperable cabin heater. No warning lights or messages were displayed.

My truck is a2021 Chevy Tahoe Z71 and my motor knocking real loud I was told it’s a problem with the lifters My car is not old enough to habe lifter problems It started knocking a year ago I was told change the oil but I always change my oil on time now it’s way louder than a year ago

Vehicle is sputtering and jerking while driving When slowing to a stop vehicles engine will shut off. I do know that the 2021 Tahoe has recalls on the fuel pump issues but not sure why my vin number isn’t covered under this recall. This is a 2 year old vehicle and already has recalls on this year model on its fuel pump. At this point it is barely driveable and is a danger for myself and my family to drive.

On Wednesday,Sept20 2023 I was traveling eastbound in the passing Lane on interstate 90 in New York when my Chevy tahoes motor began shaking violently, chugging, and losing power. The check engine light illuminated. The engine stalled as I frantically tried to move to the berm. There is a lot of large semi traffic on that road and I had a difficult time maneuvering safely without power to get onto the side of the road. I was unable to move completely into what I felt to be a safe area. I continued to try to start the motor after about 10 minutes I was finally able to get it started and move it to an exit where it was towed to community Chevrolet in Meadville Pennsylvania. The Chevy dealer at this point has told me it is a fuel pump problem and they are on back order and there is...

Wife was driving home from work, vehicle started with no issues and she did not notice anything abnormal as she started her commute home, roughly 20 minute commute. She noticed the vehicle was vibrating, mildly at first and progressively getting worse. When she came to a stop at red light, she noticed the vibrating was worse at idle. She did not note any warning or cautions, she contacted me, i advised her to attempt to make it home. Once the light turned green, she accelerated and noticed the vehicle smoking, she pulled over into a parking lot, parked and shut it off. By this time all the warning in vehicle were flashing, battery and oil pressure gauges were fluctuating, check engine light was flashing, traction control, and other adaptive sensors i.e. blind spot, HUD where signals were displayed as off or not functioning. I was able to drive the vehicle...

We were driving down the road and as I tried to accelerate the car would not go. Then I realized the car said push to start. My husband tried to push the neutral button and told me to restart it but I said you have to push the brake. All this is happening as we are coasting down a main road with speed limits of 55mph and my family is in the vehicle (including 2 toddlers in the back seat). Once we coast to a gravel area off the road I push the brakes and try to restart. My dash goes all black and I try to restart. It tells me battery low push to start. The starter engages and stays engaged until I push the start button again to turn off. The screen tells me it is shutting down functions to save battery. The check engine light is on....