2002 CHEVROLET SUBURBAN 2500 Engine And Engine Cooling Problems

AFTER SO LONG IGNORING THE SMELL IN MY CAB, I DECIDED TO GET IT CHECKED OUT AT BENNY'S EXHAUST IN BRISTOL, TN, AND FOUND THAT EXHAUST MANIFOLD HEAD BOLTS BROKE OFF ON BOTH SIDES OF ENGINE. 1ST BOLT INITIALLY THEN SECOND BOLT NEXT TO IT BROKE AS WELL. NO WORK HAS BEEN DONE TO MOTOR OR AFTERMARKET PARTS ADDED THAT WOULD AFFECT THIS PART AND CREATE FAILURE. EXHAUST GAS ENTERS THE UNDERHOOD AREA SOMETIME CAN BE SMELLED INSIDE PASSENGER CAB AREA. THE EXHAUST MAKES A BLACK PLUME UP SIDE OF MOTOR ON BOTH SIDES. THIS VEHICLE CAN NOT BE REGISTERED IN ANY STATE THAT HAS EMISSIONS TESTING, BECAUSE IT WILL NOT PASS. I AM FORCED TO REGISTER IT TO NON-TESTING STATES. WHY ISN'T THERE A RECALL ON THIS MATTER. IT APPEARS THAT THIS AFFECTS ALL YEARS. WHAT IS WRONG WITH GM, WHY WON'T THEY TAKE CARE OF THIS MATTER. AFTER...

TL* THE CONTACT OWNS A 2002 CHEVROLET SUBURBAN 2500. THE CONTACT WAS DRIVING APPROXIMATELY 45 MPH WHEN THE ENGINE STALLED, FOLLOWED BY THE BATTERY WARNING LIGHT ILLUMINATION. THE FAILURE OCCURRED EIGHT MORE TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHO WAS UNABLE TO LOCATE A PROBLEM. IN ADDITION, THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR A DIAGNOSTIC TESTING WHICH DETECTED A TROUBLE CODE WITH THE CRANK POSITION SENSOR. THE VEHICLE WAS REPAIRED. THERE WAS A RECALL RELATED TO THE DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING). THE CONTACT NOTIFIED THE DEALER CONCERNING THE RECALL. THE MANUFACTURER WAS NOT MADE AWARE OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 70,000. UPDATED 09/21/11*LJ THE CONSUMER STATED AFTER WAITING 15-30 SECONDS, THE ENGINE WOULD START IMMEDIATELY AND RUN SMOOTHLY. UPDATED 10/26/11

TL* THE CONTACT OWNS A 2002 CHEVROLET SUBURBAN K2500. WHILE DRIVING AT ANY SPEED, THE CONTACT STATED THAT THE VEHICLE WOULD STALL AND SPORADICALLY FAIL TO START. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER: 07V521000 (ENGINE AND ENGINE COOLING) FOR THE 2001 MODEL SUBURBAN. THE DEALER ADVISED THE CONTACT THAT HIS VEHICLE WAS NOT INCLUDED IN THE RECALL BECAUSE THE RECALL WAS NOT FOR HIS MODEL YEAR VEHICLE. THE CONTACT DID NOT INFORM THE MANUFACTURER OF THE FAILURE NOR WAS THE VEHICLE REPAIRED. THE CURRENT MILEAGE WAS 71,000 AND THE FAILURE MILEAGE WAS 68,000.

A LOUD RATTLING NOISE WAS COMING FROM UNDER THE HOOD AND THE HAD NO A/C. AFTER LOOKING UNDER HOOD, FOUND THE BELT HAD SPLIT IN TWO. I REPLACED THE A/C BELT ON A 2002 CHEVY SUBURBAN AND AFTER DOING THIS, NOTICED THE BELT TENSIONER WAS RATTLING A GREAT DEAL SO REPLACED IT. WHEN I RECEIVED THE BELT TENSIONER FROM THE PARTS STORE, ENCLOSED WAS A WARNING/ALERT MESSAGE TO REFER TO GM TBS # 03-01-38-019A AFTER REVIEWING THIS INFORMATION, I DON'T UNDERSTAND WHY THE CUSTOMER SHOULD HAVE TO PAY TO REPLACE THE A/C COMPRESSOR WHEN THEY KNOW IT IS A DEFAULT ON 17 VEHICLES FROM THE YEARS 2002 TO 2004. I FEEL THIS SHOULD BE CHEVY AND GM'S RESPONSIBILITY AS I NOW WILL NEED TO PAY WELL OVER $1000.00 TO FIX SOMETHING THAT WAS A KNOWN PROBLEM, YET NOTHING WAS DONE ABOUT IT. I FEEL THIS IS A DANGER TO ANY...

2002 CHEVY SUBURBAN 2500. 42,000 MILES. ENGINE STALLS WITH NO WARNING. SOMETIMES WHILE STOPPED AT LIGHT OR WHEN DRIVING. AFTER WAITING A FEW MINUTES CAR STARTS AFTER READING OTHER POSTS HAD CRANK SENSOR REPLACED TODAY VERY STRESSING AND DANGEROUS. -- NO POWER STEERING OR POWER BRAKES. *TR

MY 2002 K2500 SUBURBAN ENGINE DIES ABRUPTLY WHILE DRIVING, WITH NO WARNING (NEITHER SPUTTERING NOR MESSAGES ON THE DASH). AFTER PULLING OVER TO THE SHOULDER AND WAITING BETWEEN A FEW SECONDS AND A FEW MINUTES, THE ENGINE WILL START. THIS HAPPENS AT RANDOM TIMES AT ANY SPEED. NEEDLESS TO SAY, THIS IS AN EXTREME SAFETY HAZARD, AS ALL POWER TO STEERING AND BRAKES IS LOST WHEN THE ENGINE DIES. THESE RANDOM STALLS HAVE BEEN INCREASING IN FREQUENCY OVER THE LAST COUPLE YEARS. MY CAR ONLY HAS 36,000 MILES - MOSTLY HIGHWAY DRIVING. APPARENTLY LOTS OF PEOPLE HAVE EXPERIENCED THIS POTENTIALLY DEADLY CONDITION. IS GM JUST GOING TO WAIT FOR PEOPLE TO GET KILLED BEFORE THEY ISSUE A RECALL ON THIS? *TR

I RECENTLY PURCHASED A 2002 CHEVROLET 2500 SUBURBAN WITH AN 8.1L ENGINE. AFTER ONLY A WEEK IT WOULD SUDDENLY STALL AT DIFFERENT HIGHWAY SPEEDS. IT DID THIS 3 TIMES IN ONE WEEK. I THEN DISCOVERED THE PROBLEM WAS THE CRANKSHAFT POSITIONING SENSOR, WHICH HAS BEEN RECALLED ON 2001 MODELS. WHY HAS THIS PART NOT BEEN RECALLED ON THE 2002 MODEL IT HAS THE EXACT SAME DEFECTIVE SENSOR FROM THE FACTORY AS THE 2001 HAD. THIS FAILURE CREATES A VERY DANGEROUS SITUATION IN AN SUV OF SUCH SIZE. WHEN THE ENGINE STALLS THERE IS NO POWER BRAKES OR POWER STEERING, AND HOPEFULLY YOU HAVE ENOUGH MOMENTUM TO GET OUT OF THE WAY OF TRAFFIC. *TR

TL*THE CONTACT OWNS A 2002 CHEVROLET SUBURBAN 2500. WHILE DRIVING, THE VEHICLE STALLED. A RED WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL PRIOR TO THE FAILURE. OCCASIONALLY, THE VEHICLE LOSES POWER STEERING AND BRAKING ABILITY. THE VEHICLE HAS BEEN TO NUMEROUS DEALERS, BUT NO ONE COULD DUPLICATE THE FAILURE. THE MANUFACTURER WOULD NOT ASSIST. THE FAILURE MILEAGE WAS 92,000. UPDATED 6/9/08 *CN

TL*THE CONTACT OWNS A 2002 CHEVROLET SUBURBAN 2500. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE SPORADICALLY STALLED WITHOUT WARNING. THE DEALER STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER 07V521000 (ENGINE AND ENGINE COOLING), ALTHOUGH THE FAILURES WERE IDENTICAL. HE IS IN THE PROCESS OF HAVING THE VEHICLE REPAIRED. THE FAILURE MILEAGE WAS 81,000.

I DRIVE A 2002 CHEVROLET SUBURBAN. FREQUENTLY, WHILE I WAS DRIVING AND WITH NO WARNING THE VEHICLE JUST SHUTS OFF. WHEN THE VEHICLE SHUT OFF, IT DID NOT HAVE POWER BRAKES OR POWER STEERING. AFTER STOPPING AND TURNING THE KEY OFF FOR A COUPLE OF MINUTES I COULD START UP THE VEHICLE AND CONTINUE DRIVING. THIS SITUATION FIRST STARTED LAST FALL. I TOOK THE VEHICLE TO A LOCAL GARAGE WHICH COULD FIND ANY PROBLEM. THE VEHICLE CONTINUED TO EXPERIENCE THESE UNPREDICTABLE SHUT OFFS ,AND I TOOK VEHICLE TO THE CHEVROLET DEALER FOR DIAGNOSIS AND REPAIR. THE DEALER COULD NOT DUPLICATE THE PROBLEM. THE TRUCK CONTINUED TO SHUT OFF ON THE HIGHWAY AND IN THE CITY AT HIGHWAY AND CITY SPEEDS, WHILE SLOWING DOWN AND WHILE ACCELERATING. THIS WAS A DANGEROUS SITUATION AS IT HDS SHUT OFF WHILE TOWING A TRAILER. THE SHUT OFFS DID NOT CORRELATE WITH WEATHER, TIME OF...

I DRIVE A 2002 CHEVY SUBURBAN. FREQUENTLY, WHILE I AM DRIVING AND WITH NO WARNING, THE VEHICLE JUST SHUTS OFF. WHEN THE VEHICLE SHUTS OFF, I DO NOT HAVE POWER BRAKES OR POWER STEERING. AFTER A FEW MINUTES, I CAN TYPICALLY START UP THE VEHICLE AND CONTINUE DRIVING. THIS SITUATION FIRST STARTED LAST OCTOBER. I TOOK THE VEHICLE TO A LOCAL GARAGE AFTER THE THIRD INCIDENT BECAUSE THE CHEVY DEALER WAS BOOKED. THE GARAGE COULD FIND NO PROBLEM. THE VEHICLE CONTINUED TO EXPERIENCE THESE UNPREDICTABLE SHUT OFFS AND I TOOK IT IN TO THE CHEVY DEALER FOR DIAGNOSIS AND REPAIR. THE DEALER KEPT THE TRUCK FOR NEARLY A MONTH AND COULD NOT DUPLICATE THE PROBLEM. THE TRUCK CONTINUED TO SHUT OFF, ON THE HIGHWAY AND IN THE CITY. I TOOK IT TO A DIFFERENT DEALER AND EXPLAINED THE PROBLEM AND SHARED THE RESULTS OF THE DIAGNOSTICS. THE SECOND DEALER ALSO...