NHTSA Complaint #11674336 — 2020 MERCEDES-BENZ SPRINTER 2500

repeated EGR clogging and malfunction: bucking or stumbling behavior, inability to accelerate properly, disabled shifting affecting ability to slow or stop without excessive use of brakes, Limp Home Mode suddenly without warning including inability to maintain a safe speed on highway and speed minimums that the vehicle cannot keep up (20 mph max while climbing moderately), unable to downshift when going downhill - relying solely on braking to keep speed below safe limit or speed limits. EGR failed again after cleaning, in as little as 3 months. No repair seems possible, only repeated cleanings. Since this happened so much, we have been in several unsafe situations due to the sudden and unheralded degradation of performance and safe use of the vehicle. Once repaired, the condition can come back immediately due to the computer still guessing that it is still in failure (limp home mode returned suddenly without warning as we merged onto an interstate with no exit for 7 miles uphill… and only made 20mph). Check Engine light could come on, and did, but never during the actual degradation of performance - and went often after a few run cycles. Mercedes dealers have confirmed and performed all services on the EGR and related issues (malfunction once caused the aircleaner element to be sucked in and that caused a MAF to be destroyed by contaminants): 1) first signs of issue before 43,000 miles (when check engine light and/or LHM happened -repaired 18sep2023, 51,871 miles, MB service code: LI14.20-N-073867); 2) 26 DEC 2023 - EGR failure diagnosed and replaced by MB dealer. Cleaning had not fixed the issue or failure was final as found by driving by technician and not by codes! 3) 09/jul/2024 - MAF replaced, EGR codes noted - but functioning, fix by MB/Canada 4) 07/24/2024 - 70,547 miles - EGR Clean by MB Missoula MT - failed upon highway same day 5) 07/25/2025 - 70,600 miles - MB Missoula MT cleared computer 6) 88,340 MB cleaned EGR - runs ok again