2004 TOYOTA TACOMA Structurebody Problems

The frame broke

The vehicle has an open recall (NHTSA Recall #12V542) for the spare tire carrier lift plate. I brought the vehicle to a Toyota dealership to have the recall addressed, but the dealership refused to perform the repair, stating that the frame is too rusted to proceed safely. They recommended a full frame replacement due to severe rust damage, which includes holes and significant structural weakening. Toyota has refused to provide a replacement frame under any existing recall or warranty program. This means the recall cannot be completed, and the vehicle remains unsafe to drive. Additionally, I cannot locate a replacement frame for this vehicle through Toyota or the aftermarket, leaving no practical solution to address the safety risks. The refusal to honor the recall and the lack of available replacement parts put me and others at significant risk. The problem has been confirmed by the Toyota dealership during inspection, and...

Vehicle was taken to dealer with frame rust, crack and holes. Toyota refused to fix , repair or offer parts to repair.

Bought the vehicle in May 2022 from a dealer. By November of 2022 it was discovered that the frame was totally rusted. The dealer won't help so I paid $10,000 for a truck that lasted 6 months. I then found out this was a common problem that Toyota knew about so I called them for assistance. They would not help. I have been renting a vehicle at a cost of $800 a month because I don't have the money to buy another vehicle.

What component or system failed or malfunctioned, and is it available for inspection upon request? The whole frame, the chassis, it is rusty specially in the front How was your safety or the safety of others put at risk? when the rusty becomes worse, it will compromise the entire vehicle estructure, even the suspension and wheel parts. Has the problem been reproduced or confirmed by a dealer or independent service center? Yes, I can see Toyota run a recall process until 2019 Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? No, just regular shop service, on which they reported high damage for the suspension and frame parts. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear?. It is making bad noises and suspension parts are difficult to replace

Frame is badly rusted as a result truck is not driveable..

Excessive Corrison through out the frame.Was informed bu certified mechanic really it is unsafe to drive. What can I do I still owe money on this vehicle.

Financed a 2004 Toyota Tacoma and found that frame of truck is rusted out and not sure what to do, can't afford new frame and still owe a little over 9 grand for it....please advise what to do next. Thank u

The frame has rusted and broke behind the cab

FRAME RUST

This vehicles frame has rusted and broken. I feel lucky to have made it home just as the frame cracked wide open on one side making the truck un-drivable. Had this happened on the freeway or somewhere out in a rural setting I may have been killed, caused a problem for other drivers or been stranded away from any help. I have sent a photo of the damage to a frame shop but an independent inspection is not, in my opinion, needed since the rusted, broken member is clearly visible to any lay person. There were no warning lights or anything associated with this problem. What I did feel was some serious shaking and bumping as I moved down the road toward my house.

FRAME ROT ON THE MID CHASSIS UP TO THE FRONT CHASSIS WHERE THE FRAME BEGINS TO CURVE INWARD TOWARDS THE ENGINE. FRAME ROT IS ON LEFT AND RIGHT SIDE OF THE VEHICLES INNER FRAME. FAILED STATE INSPECTION.

CALLED TOYOTA 2 YEARS AGO ABOUT RUST ON MY TRUCKS FRAME NEAR THE REAR LEAF SPRING MOUNTING AREA. WAS BLOWN OFF BY TOYOTA CUSTOMER CARE. IN DECEMBER WAS DRIVING AND THE FRAME RAILS LITERALLY SNAPPED AN BOWED, THE ONLY THING THAT SAVED MY LIFE WHILE DRIVING 70MPH, ON THE INTERSTATE 70 BETWEEN HAGERSTOWN MD AND HANCOCK MD, HOME FROM WORK WAS THE BED CONTACTING THE CAB OF THE TRUCK AND MIRACULOUSLY HOLDING HOLDING IT UP AND ALLOWING ME TO GET IT SAFELY OFF THE ROAD AND CALL MY MECHANIC. THE SHEET METAL OF THE TRUCK IS RUST FREE AND IN GOOD CONDITION. THE FRAME IS A TOTAL LOSS. THE TRUCK WAS AT TOYOTA IN 2010 AND 2011 FOR FRAME INSPECTIONS. THIS IS A KNOWN ISSUE WITH THESE TRUCKS AND NOW IM TOLD THAT TOYOTA WONT DO ANYTHING ABOUT IT. IF THEY WOULD HAVE FIXED IT OR ADDRESSED MY CONCERNS IN...

RE: DEFECTIVE FRAME ON 2004 TOYOTA TACOMA EXTEND CAB DEAR SIR OR MADAM: I AM REACHING OUT TO YOU FOR ASSISTANCE REGARDING THE DEFECTIVE FRAME ON MY 2004 TOYOTA TACOMA EXTENDED CAB. I PURCHASED THIS VEHICLE USED IN 2012 FROM A PRIVATE OWNER. I DID NOT KNOW AT THE TIME, NOR DID THE PREVIOUS OWNER ADVISE ME THAT HE RECEIVED A MANUFACTURER'S RECALL ON THE TRUCK FROM TOYOTA IN 2010 REGARDING A CRACKED FRAME BECAUSE THE VEHICLE WAS NOT TREATED DURING MANUFACTURING TO PROHIBIT RUST CORROSION. PLEASE SEE ATTACHED LETTER.

2004 TACOMA FRAME SO ROTTED THAT UPON HITTING A LARGE HOLE WOULD FINISH OFF THE RUSTED FRAME. THIS TYPE OF RUST AND EROSION IS NOT FROM NORMAL WEAR.. THIS IS DUE TO THE MANUFACTURING OF THE VEHICLE AND THEY WILL NOT REPLACE. THEY SAY THEY ARE AWARE OF IT.. BUT TIME LAPSED TO GET IT FIXED?? SO WHAT NOW I AM OUT $15K ON A 16 YEAR OLD TRUCK. SINCE WHEN DID RECALLS HAVE AN EXPERATION DATE??

PURCHASED 2004 TACOMA IN 2016. DEALERSHIP OF PURCHASE SAID VEHICLE WAS NOT AFFECTED BY FRAME RECALL AND DID NOT INFORM ME THAT IT WAS UNDER WARRANTY FOR FRAME RELATED ISSUES. SINCE PURCHASING VEHICLE I'VE ENCOUNTERED COUNTLESS FRAME RELATED ISSUES AND HAVE PUT THOUSANDS INTO FRAME RELATED REPAIRS. I CONTACTED TOYOTA IN 2018 ON SEVERAL OCCASIONS TO ASK ABOUT FRAME WARRANTY. TOYOTA SAID VEHICLE WAS NOT COVERED. DID NOT LOOK UP VIN OR ANY OTHER INFORMATION RELATED TO VEHICLE. I CONTACTED TOYOTA AGAIN THIS YEAR TO SEE IF THERE'S ANYTHING THAT CAN BE DONE AS FRAME ISSUES WERE BECOMING SIGNIFICANT AND BEYOND MY FINANCIAL MEANS TO KEEP FIXING. TOYOTA NOTIFIED ME AT THIS TIME THAT THE VEHICLE HAD IN FACT BEEN UNDER WARRANTY BUT THAT NOW THE WARRANTY HAD EXPIRED 6 MONTHS PRIOR (WHICH WAS WITHIN THE TIMEFRAME THAT I HAD INITIALLY CONTACTED TOYOTA). TOYOTA TOLD ME THAT FRAME HAD BEEN...

TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT APPROXIMATELY 12 YEARS THE VEHICLE WAS TREATED WITH A RUST INHIBITOR HOWEVER, THE SUBFRAME WAS SEVERELY RUSTED. ADDITIONALLY, THERE WERE SEVERAL RUST HOLES TO THE SUBFRAME. THE CONTACT CONTACTED TOYOTA OF VINELAND (650 N DELSEA DR, VINELAND, NJ 08360, (856) 559-7690) WHO STATED THAT THEY WERE UNABLE TO PROVIDE THE REPAIR UNDER A RECALL. THE DEALER ALSO STATED THAT THE SUBFRAME NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND OPENED A CASE. THE APPROXIMATE FAILURE MILEAGE WAS 120,165. *LN THE CONSUMER SUBMITTED PHOTOS. *TR

MY 2004 TOYOTA TACOMA HAS FRAME DAMAGE UNDERNEATH (PICTURE ENCLOSED) I LEARNED OF A 15 YEAR MANUFACTURER EXTENDED WARRANTY ON THE FRAME OF MY TRUCK WITHIN THE LAST FEW MONTHS. I PUT IN A COMPLAINT TO TOYOTA (I LOST CLAIM NUMBER) AND WAS TOLD THE WARRANTY HAD EXPIRED IN MAY OF 2019 AND WAS OUT OF LUCK, HE ALSO SAID THAT 15 YEAR WARRANTY EXTENSION WERE MAILED OUT IN THE PAST BUT ,TROUBLE IS MY WIFE AND I DO NOT RECALL SEEING THIS INFORMATION DO TO THIS I WAS UNABLE TO GET MY FRAME FIXED UNDER THE WARRANTY AND I CANNOT AFFORD OUT OF POCKET FEE TO FIX MYSELF. WHAT ISSUE I DO HAVE IS I HAD MY VEHICLE AT A TOYOTA DEALERSHIP BEING WORKED ON FOR A "SAFETY RECALL " JULY OF 2018 AND I WAS WONDERING AT LEAST AS A CUSTOMER COURTESY WHY I WASN'T MADE AWARE OF...

TACOMA PURCHASED FEB.2019 WITH SOME RUST FOUND ON FRAME.TRUCK SENT TO BODY SHOP APR. 2020 TO ADDRESS RUST.TRUCK HAD BECOME UNREPAIRABLE DUE TO "SEVERE RUST IN MULTIPLE LOCATIONS ON FRAME","RUST HOLES AND CRACKING BAD ON DRIVER SIDE FRAME NEAR FUEL TANK" AND "FRAME IS RUSTING BAD FROM INSIDE OUT"(QUOTES FROM MECHANIC). TRUCK WILL NOT PASS INSPECTION.

TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT WHILE IN FOR INSPECTION IT WAS DISCOVERED THAT THE FRONT DRIVER SIDE SUB FRAME OF THE VEHICLE HAD SUSTAINED SEVERE RUSTING AND CORROSION. THE VEHICLE WAS DEEMED UNSAFE TO DRIVE AND FAILED THE STATE INSPECTION. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE LOCAL DEALER WAS NOT NOTIFIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE BUT NO ASSISTANCE WAS OFFERED. THE FAILURE MILEAGE WAS 150,000.

TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT UPON INSPECTION OF THE VEHICLE, IT WAS DISCOVERED THAT THE UNDERCARRIAGE SHOWED EXTENSIVE CORROSION TO THE SUB FRAME OF THE VEHICLE. THE VEHICLE WAS TAKEN TO TWO INDEPENDENT MECHANICS WHO INFORMED THE CONTACT THAT THEY WERE UNABLE TO FIX THE SUB FRAME OF THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND THE CONTACT WAS INFORMED THAT THE PRIOR OWNER DECLINED TO HAVE THE CORROSION REPAIRED ON THE VEHICLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 141,000.

FRAME AND SOME ASSOCIATED COMPONENTS ARE RUSTED ALMOST THRU. TRUCK APPEARS TO BE VERY UNSAFE. TOYOTA DOES NOT SHOW IT IN RECALL LIST. PLEASE HELP.

2004 TOYOTA TACOMA FRAME ISSUE FRAME WAS INSPECTED AND PASSED THEY SAID THEY WOULD CONTACT ME WHEN IT WAS TIME TO SEAL IT BUT NEVER DID WHEN I WENT BACK THEY SAID I WAS TOO LATE AND ONLY FIXED TIRE CARRIER RECALL. NOW FRAME IS RUSTING OUT HAD TO BE REPAIRED AND TOYOTA SAID IT'S MY PROBLEM AND THEY WON'T GIVE ME THE EXTENDED 15 YEAR WARRANTY I CONTACTED THEM LAST YEAR AND AGAIN THIS YEAR

THROUGH NO FAULT OF OUR OWN, THE FRAME ON OUR TOYOTA TRUCK HAS BEEN DISCOVERED BY OUR MECHANIC AS RUSTED OR CORRODED TO AN EXTEND OF UNSAFE DRIVING CONDITIONS. TOYOTA IN RESPONSE TO MY COMPLAINT REPLACED THE SPARE TIRE CARRIER AS A SAFETY RECALL THAT NEVER EXPIRES, HOWEVER, THEY ARE TELLING ME THE FRAME IS NO LONGER UNDER A WARRANTY AND IS NOT A SAFETY RECALL ISSUE. THE SUGGESTED I LODGE A COMPLAINT WITH THE NHTSA AS THEY ARE UNABLE AND UNWILLING TO DO SOMETHING FOR US. I UPLOADED 5 PICTURES, NOT SURE IF THEY ARE ALL THERE

TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 12V542000(SUSPENSION). THE CONTACT TOOK THE VEHICLE TO CUMBERLAND TOYOTA (1540 INTERSTATE DR, COOKEVILLE, TN 38501, (931) 272-3719) AND WAS INFORMED THAT HER VEHICLE DID NOT NEED A REMEDY AND WAS SAFE TO OPERATE. THE CONTACT TOOK THE VEHICLE BACK TO THE SAME DEALER A FEW YEARS LATER AND WAS INFORMED THAT THE VEHICLE WOULD NOT BE SERVICED DUE TO THE CORROSION THAT HAD ACCUMULATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND INFORMED HER THAT THEY COULD NOT ASSIST. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS UNKNOWN. *PM*JB

EXTREME RUST ON LEFT SIDE OF THE FRAME WITH EXTENSIVE LOSS OF METAL. CONTACTED TWO TOYOTA DEALERSHIPS AND TOYOTA CORPORATION. THEY REFUSE TO FIX THE PROBLEM. ALL DOCUMENTED HERE: HTTPS://WWW.FACEBOOK.COM/GROUPS/1637547983201647/

THE FRAME HAS MANY HOLES IN IT. WAS JUST TOLD BY MECHANIC WHEN WENT IN FOR REAR DIFFERENTIAL WORK. THEY AS I WERE SURPRISED AS THE BODY SHOWS NO SIGNS OF RUST. THEY DID NOT COMPLETE WORK AS THEY SAID FRAME SO BAD IT IS UNSAFE. I HAVE OWNED OTHER 2003 AND 2004 TACOMA'S OVER THE YEARS WHICH HAD FRAMES RECALLED. THIS ONE DOES NOT HAVE THE FRAME RECALL AND I AM WONDERING IS THIS A MISTAKE OR WHY NOT?

FRAME IS RUSTY BEYOND USAGE. AS I ACCELERATE THE BED OF THE TRUCK FLEXES SO I CAN SEE IT IN THE REARVIEW MIRROR

THE FRAME IS RUSTING OUT

I HAD TIRES ROTATED,TECHNICIAN TOLD ME FRAME IS EXTREMELY RUSTED(TACOMA PROBLEM) BIG SAFETY PROBLEM.TOYOTA TOLD ME THEY WOULD CHECK IT OUT FOR 98,-- DOLLARS. I DON'T THINK THAT'S RIGHT. TOYOTA PROBLEM

THE DEALER DISCOVERED HOLES IN THE FRAME ON 3/26/19. ACTUALLY IT WAS IN FOR REPAIR OF A GAS TANK STRAP AND I BELIEVE THEY USED A HAMMER ON THE FRAME TO MAKE THE HOLES. THEY WROTE IT UP AS MY TRUCK WAS UNSAFE TO DRIVE. IT ONLY HAS 81,000 MILES ON IT AND OTHER WISE IN GREAT SHAPE. I HAD IT IN FOR A RECALLED RUSTED SPARE TIRE HOLDER ON 2/11/15 AND THE SERVICE MANAGER TOLD ME THAT THE FRAME LOOKED OK AND IF THE FRAME DEVELOPS HOLES THEY CAN RECOMMEND A GOOD WELDER.

TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. WHILE THE VEHICLE WAS UNDERGOING AN OIL CHANGE, THE CONTACT WAS INFORMED THAT THE FRAME WAS RUSTED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO AUTOLAND (170 US-22, SPRINGFIELD TOWNSHIP, NJ 07081, (800) 288-6526) WHERE IT WAS CONFIRMED THAT THE FRAME WAS RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND PROVIDED CASE NUMBER: 1904301385. NO FURTHER ASSISTANCE WAS PROVIDED. THE FAILURE MILEAGE WAS 67,000. *BF

TAKATA RECALL, I OWN A 2004 TOYOTA TACOMA THAT CAME FROM WEST VIRGINIA WHEN ORIGINALLY PURCHASED, THIS TRUCKS LEAF SPRINGS HAVE NOW BROKE LOSE AND IS VERY UNSAFE TO DRIVE FOR MY 17 YEAR OLD SON, WE HAVE CONTACTED TOYOTA AND THEY WERE VERY RUDE SO I HAVE NOW CAME TO THIS, THERE IS RUST HOLES IN THE FRAME OF HIS TRUCK THE SIZE OF BASEBALLS AND SCARES ME FOR HIM TO EVER DRIVE IT AT ALL PLEASE HELP US FIGURE OUT WHAT WE CAN DO, HIS UNCLE THAT OWNED THE TRUCK BEFORE WE GOT IT WAS VERY SICK HE LIVED IN WEST VIRGINIA AND WAS NEVER TOLD OR CALLED ABOUT A RECALL FOR THE FRAME MY SON JUST RECENTLY GOT THE TRUCK PAINTED AND WAS TOLD THAT HE NEEDS A NEW FRAME VERY BADLY.

TAMARA RECALL, MY 2004 TOYOTA TACOMA 4 WHEEL DRIVE CHASSIS HAS BROKEN ON ME TWICE SENSE I BOUGHT THE TRUCK FROM A USED DEALERSHIP, AND THE CHASSIS IS ALSO CRACKED AGAIN ON MY BACK DRIVERS SIDE, WHEN I BOUGHT THE TRUCK I WASN'T TOLD THAT THE CHASSIS WAS RUSTED AND THEY HAD COVERED IT UP. I NEED TO KNOW IF IT'S STILL UNDER WARRANTY TO GET IT REPLACED OR WHAT I NEED TO DO, MY ODOMETER IS SHOWING ONLY 118686 ON IT RIGHT NOW. I'M CONCERNED IF I WERE TO BE IN A WRECK THAT THERE WOULD BE A WORSE OUTCOME VERSES THE CHASSIS NOT BEING RUSTED. WHEN THE CHASSIS BROKE ON THE PASSENGER SIDE BOTH TIMES I WAS DRIVING, THE EXHAUST HAS BROKEN OFF AS WELL BECAUSE OF RUST. NOW THE TRUCK SQUEAKS REALLY BAD AND MY SPARE TIRE IS ABOUT TO BREAK OFF AS WELL I BELIEVE. I...

2004 TOYOTA TACOMA, TOOK TRUCK IN TO BE PAINTED WAS INFORMED THAT THERE ARE MULTIPLE BASEBALL SIZE HOLES IN THE FRAME AND THE LEAF SPRING MOUNTS ARE RUSTED AND LEAF SPRINGS ARE ABOUT TO POP OFF. I HAVE CALLED TOYOTA CORP, AND WAS TOLD BECAUSE TRUCK WAS NOT SPRAYED THEY WILL NOT HONOR THE FRAME. I RECENTLY ACQUIRED THIS VEHICLE AND WAS NOT AWARE OF THE RECALL THAT HAD BEEN ISSUED ON THIS TRUCK. TOYOTA AT THIS POINT IS REFUSING TO REPLACE OR REPAIR THE FRAME EVEN THOUGH THIS TRUCK ORIGINATED AND REMAINED IN A COLD CLIMATE STATE FOR MOST OF ITS EXISTENCE. PLEASE ADVISE IF THERE ARE ANY OPTIONS AVAILABLE TO HAVE TOYOTA HONOR THIS VEHICLE. THANK YO U

FRAME RUSTING OUT EVEN AFTER HAVING UNDERCOAT SPRAYED IN PREVIOUS RECALL, AFTER LOOKING ONLINE I HAVE FOUND NUMEROUS PEOPLE WITH THE SAME YEAR AND MODEL HAVING THEIR FRAME REPLACED BY TOYOTA UNDER A RECALL, BUT I HAVE BEEN TOLD REPEATEDLY THAT THERE IS NOT RECALL AND TOYOTA WILL DO NOTHING.

TOOK TRUCK IN FOR INSPECTION AND THE FRAME IS DETERIORATING TO THE POINT THE BED IS BECOMING DETACHED FROM THE FRAME AND SEPARATING FROM THE CAB. THE SUSPENSION IS COMING LOOSE FROM THE MOUNTS. THIS IS NOT THE ONLY ONE THE MECHANIC HAS SEEN WITH DETERIORATION. THESE TRUCKS ARE NOT SAFE TO DRIVE!!

TAKATA RECALL FRAME IS RUSTED

I HAVE A 2004 TOYOTA TACOMA WITH SEVERE CORROSION UNDERNEATH THE FRAME. IT IS NOT SAFE AND COULD CRACK AT ANYTIME. ESPECIALLY WHERE THE LEAF SPRING MEETS THE FRAME, I CAN LOOSE THE REAR END.

ABOUT TWO WEEKS AGO IVE TAKEN MY TRUCK TO PRICE TOYOTA IN NEW CASTLE DE FOR A FRAME INSPECTION. THEY TOLD ME THAT THEY WERE GOING TO CALL THE TOYOTA MANUFACTURE ABOUT THE FRAME RECALL ISSUE BUT THEY NEVER GOT BACK TO ME AND JUST RECENTLY IVE HEARD A KNOCKING SOUND ON THE REAR DRIVER SIDE AND FOUND A CRACK IN THE FRAME.

FRAME NEEDS TO BE REPLACED. REQUESTED TOYOTA REPLACE FRAME WITHIN A TEN YEARS OF MFG. TOYOTA SAID I WAS TO LATE ON THE FRAME REPLACEMENT RECALL . TRUCK BODY IS LIKE NEW. TRUCK ONLY HAS 64000 MILES ON IT. I MISPLACED FRAME REPLACEMENT RECALL NOTICE. CAN YOU REQUEST / REQUIRE TOYOTA REPLACE MY FRAME ?

VERY RUSTED FRAME

BOUGHT A 2004 TACOMA NOT KNOWING ABOUT THE FRAME RECALL. THE DEALER I BOUGHT THE VEHICLE FROM HAD PUDDIED THE FRAME TO MAKE IT LOOK SOLID. NOW I'VE GOT AN UNSAFE VEHICLE. SOMETHING THAT COULD KILL PEOPLE SHOULDN'T EXPIRE.OR TOYOTA SHOULD BUY IT BACK SINCE WHOEVER OWNED IT BEFORE NEVER TOOK CARE OF THE PROBLEM. THERE ARE PROBABLY HUNDREDS OF THESE ON OUR STREETS TODAY LIKE THIS!

DRIVERS SIDE DOOR HANDLE FELL OFF, WHILE STATIONARY. I GRABBED HANDLE TO OPEN DOOR LIKE NORMAL, AND PART OF IT CRUMBLED IM MY HAND AND THEN FELL TO THE GROUND. IT COULD NOT BE PUT BACK ON DUE TO EXCESSIVE CORROSION. THIS IS A HUGE SAFTY RISK OF SOMEONE GETTING TRAPPED IN THE VEHICLE IF SOMETHING HAPPENED AND THE HANDLE FELL OFF AT THE MOST IMPORTUNED TIME, IT COULD EASILY CAUSE FATALITIES. WHILE SEARCHING FOR A REPLACEMET PART I MET SEVERAL OTHERS WITH THIS SAME PROBLEM. THE FACT THAT TOYOTA IS CHARGING AND EXUBERANT ABOUT FOR THE HANDLE ASSEMBLY'S ($4251

WHILE DRIVING I HEARD AN UNUSUAL NOISE COMING FROM UNDERNEATH THE VEHICLE. UPON SELF INSPECTION I DISCOVERED THE FUEL TANK STRAP HAD BROKE. I NOTICED ALSO THAT THE FUEL TANK SHIELD LOOKED LIKE SWISS CHEESE FROM CORROSION. I HAD A TIE DOWN STRAP THAT I WAS ABLE TO USE TO STRAP THE SHIELD AND TANK UP WITH. I AM IN THE PROCESS OF LOOKING TO REPAIR IT. I FEEL SINCE IT IS A SAFETY ISSUE TOYOTA SHOULD FIX IT FREE OF CHARGE. A FUEL TANK STRAP SHOULD NEVER FAIL LIKE THIS.

MY TOYOTA TACOMA FRAME BROKE DUE TO RUST. THE LEAF SPRING MOUNTING BRACKET BROKE LOOSE FROM THE FRAME AND HE FRAME ITSELF BROKE DUE TO SEVERE RUST. THE TRUCK IS NOW INOPERABLE. THERE AS A RECALL ON SOME TOYOTA FRAMES, BUT APPARENTLY THE RECALL ONLY APPLIES TO "COLD" STATES, NOT HAWAII. MANY OF MY FRIENDS HAVE TACOMAS AND THEY ALL HAVE RUST ISSUES. I ALSO HAVE A 2010 TACOMA WITH LESS THAN 6000 MILES AND I HAVE ALREADY NOTICED THAT THE FRAME IS RUSTING BY THE LEAF SPRING MOUNTS.

9/8/2017, WHILE WORKING ON MY 2004 TACOMA I FOUND A 3 INCH AND A 1 INCH RUST HOLES IN THE FRAME NEAR THE LEFT REAR WHEEL. NEAR THE RIGHT WHEEL I FOUND A 1 INCH HOLE. ALL IT TOOK WAS A TAP WITH A HAMMER. HOW SAFE IS THAT?

TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. THE CONTACT STATED THAT THE REAR FRAME FAILED. THE CONTACT STATED THAT THE REAR FRAME AND BED WERE SEVERELY CORRODED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER WHERE IT WAS DETERMINED THAT THE VEHICLE WAS UNSAFE TO DRIVE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 190,000.

TL* THE CONTACT OWNS A 2004 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 10 MPH OVER A SPEED BUMP, THE SPARE TIRE LOCATED ON THE TRUNK DETACHED AND ROLLED INTO THE STREET. THE VEHICLE WAS TAKEN TO THE DEALER (CHECKERED FLAG TOYOTA IN VIRGINIA BEACH, VIRGINIA) WHERE IT WAS DIAGNOSED THAT THE FAILURE OCCURRED DUE TO SEVERE RUST AND CORROSION ON THE SUBFRAME. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED AND OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 263,000.

I TOOK MY 2004 TACOMA WITH <92,500 MILES INTO THE MECHANIC TO GET SERVICED YESTERDAY. I ASKED HIM TO CHECK IT OVER FOR A ROAD TRIP WE WERE PLANNING THIS WEEKEND. HE CALLED BACK AND SAID IT WAS UNFIT TO DRIVE BECAUSE THERE WAS ABOUT 1 AND 1/2 FEET AND 4 INCHES WIDE PART OF THE FRAME IS RUSTED OUT ABOVE THE REAR AXLE. I AM TRYING TO CONSULT MY CASE MANAGER AT TOYOTA, BUT HE CONVENIENTLY CALLED THE WRONG NUMBER THIS MORNING AND HAS NOT RETURNED MY CALL YET.