2006 TOYOTA SEQUOIA Structurebody Problems

This Toyota has several large rust holes directly on the frame. i hit a pot hole and more structure damage was revealed on the frame from rust. The truck drives rough now. The vehicle only has 150,000 miles. The rust holes are so severe that they're directly under my suspension. I feel very unsafe driving this vehicle. Their was once a recall for the frame. It doesn't seem that it was satisfied. I'm very worried about this issue. Toyota should have to replace frame or make it safe to drive.

Back in 2018 toyota did the undercoat to my 2006 Toyota sequoia frame to prevent rust. Now my frame is completely rotted out to the point i can’t drive my vehicle.

Frame of this vehicle has lot of rust damage, is it still under manufacture recall? How can I ensure safety of my vehicle along with rusty frame? I’ll be glad to receive more information how to contact manufacturer in order to get this resolved. I drove this vehicle on Nov 19, 2023 last time just hear some knocking sounds while driving

Frame rusted so badly the the brackets attached to it are coming off

The driver side, rear, trailing arm broke away from the vehicles frame due to “frame rot” while driving. The vehicle became extremely dangerous to drive. Toyota has since declined to help. They said they notified us via mail of a customer service campaign addressing the premature rust issue, but we never learned of the program and lawsuit until after the frame broke and I almost crashed. Later I saw the broken arm/frame under the vehicle. This frame failure can potentially be a catastrophic and deadly event. I opened an insurance claim and it was denied and I was referred back to Toyota. Our vehicle has been factory maintained it’s entire life. No service advisors ever mentioned a possible problem to my family and I. I recently spoke to the Toyota service manager at Parker Toyota in Couer d Alene Idaho and his master technicians have seen the same failure that...

I was on the freeway driving and out of nowhere the body started swaying and bobbing with no control. Was informed by the tow truck driver that i could have rolled the vehicle easily and the consequences would have been serious. The frame is so rusted out that the tie rod and sway bar assembly are completely detached from the frame and hanging loose. Upon further inspection at the auto repair garage there are rusting issues throughout the frame. The frame needs complete replacement.

Frame rusted out and parts dropping off frame with no early warning. Toyota completed corrosion resistant compound 2 years ago following inspection per limited service campaign H0F, saying issue resolved to extent of warranty with known rust issue for this year and model. Now another independent garage saying we never should have been driving, much less hauling 5000 lb. trailer. Only warning was odd sound from under carriage.

THE FRAME IS VERY RUSTED

TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT RECEIVED A SETTLEMENT POSTCARD FOR THE FRAME ALONG WITH UNKNOWN RECALL NOTICES REGARDING THE AIR BAGS. THE CONTACT TOOK THE VEHICLE TO BUTLER TOYOTA (9419 ARONSON DR, INDIANAPOLIS, IN 46240, (317) 848-4210) SEVERAL TIMES TO HAVE THE FRAME REPAIRED; HOWEVER, THE AIR BAGS WERE REPAIRED INSTEAD. THIS HAPPENED SEVERAL TIMES UNTIL THE DEALER STATED THAT THE SETTLEMENT LETTER HAD EXPIRED. THE CONTACT STATED THAT THE FRAME WAS RUSTED FROM THE INSIDE OUT AND WAS DETERIORATING RAPIDLY. THE DEALER QUOTED A REPAIR COST OF $2,000 FOR AN AIR SUSPENSION AIR BAG THAT WAS NOT INCLUDED IN THE RECALL. THE COST TO REPAIR THE FRAME WAS $3,000. THE DEALER DID NOT INCLUDE ON THE PAPERWORK THAT THE FRAME WAS THE MAIN REASON THE CONTACT BROUGHT IN THE VEHICLE. THE MANUFACTURER STATED THAT IF THE DEALER HAD INCLUDED THE FRAME ON THE REPAIR...

WE NEED HELP IN GETTING TOYOTA MOTORS, INC. TO HONOR THE WARRANTY PROGRAM COVERING PREMATURE EXCESSIVE RUST CORROSION OF CERTAIN TOYOTA MODEL FRAMES. IN MID-OCTOBER 2018 WE RECEIVED NOTIFICATION FROM TOYOTA MOTORS, INC., OF THE FOLLOWING: 'WARRANTY ENHANCEMENT NOTIFICATION ' ZH8 AND LIMITED SERVICE CAMPAIGN ' HOF.' THE ZH8 AND HOF WERE INSTITUTED AS A RESULT OF A DETERMINATION THAT THE FRAMES ON CERTAIN TOYOTA VEHICLES ARE PRONE TO 'EXCESSIVE, PREMATURE RUST CORROSION BECAUSE THE FRAMES WERE NOT PROPERLY PREPARED AND TREATED AGAINST RUST CORROSION WHEN THEY WERE MANUFACTURED.' EXCESSIVE RUST CORROSION ON MY SUV 'COMPROMISES THE VEHICLES' SAFETY, STABILITY, AND CRASH-WORTHINESS BECAUSE IMPORTANT SUSPENSION COMPONENTS, ENGINE MOUNTS, TRANSMISSION MOUNTS, AND BODY MOUNTS ANCHOR TO THE VEHICLES' FRAMES'. BY DRIVING MY HIGH END SUV, I WILL BE PUTTING MY FAMILY'S SAFETY AT RISK. ON 10/25/2018: WE TOOK OUR SUV TO JIM COLEMAN TOYOTA IN BETHESDA, MD FOR FRAME INSPECTION. THE...

MY VEHICLE WAS IN FOR ENGINE AND TRANSMISSION REPAIRS AND BEING WORKED ON FOR 3 MONTHS. I WAS UNABLE TO GET IT TO TOYOTA BEFORE THE JANUARY 31 DEADLINE FOR THE FRAME PROGRAM. I CALLED AND WAS TOLD BECAUSE IT WAS BEING WORKED ON, IT WOULD BE HONORED ANYWAYS. CALLED TO SCHEDULE TO BRING IT IN AND THEY SAID, SORRY, THAT EXPIRED, SO YOU HAVE TO GET APPROVAL FROM TOYOTA BUT WE CAN STILL COAT IT IN ANTI CORROSION TIL THE END OF MAY. I CALLED TOYOTA AND SPOKE TO MULTIPLE PEOPLE WHO ALL SAID, ITS EXPIRED AND WE CAN'T HELP YOU. SO NOW I HAVE A VEHICLE WITH A PROVEN UNSAFE FRAME AND NO SOLUTION.

I HAVE REPLACED THE LATCH ON MY LIFT GATE 3 TIMES NOW. THE LATCH KEEPS BREAKING. THIS IS RIDICULOUS. I DON'T SEE A RECALL FOR IT BUT I THINK THERE SHOULD BE A RECALL FOR IT. I CAN'T ACCESS MY SPARE TIRE IF I HAVE A FLAT OR SOMETHING. THIS NEEDS TO BE ADDRESSED ASAP.

SEVERE RUST HOLE IN REAR FRAME OVER LEAF SPRINGS NOTED BY MECHANIC WHEN DOING ALIGNMENT. I WAS INFORMED THAT IT WOULD NOT PASS INSPECTION.

TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. UPON TAKING THE VEHICLE IN FOR INSPECTION, THE VEHICLE FAILED DUE TO A HOLE IN THE REAR OF THE FRAME NEAR THE HITCH. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FRAME WAS SEVERELY RUSTED. THE INDEPENDENT MECHANIC ADVISED THE CONTACT TO TAKE THE VEHICLE TO A DEALER. THE CONTACT TOOK THE VEHICLE TO TRI COUNTY TOYOTA (15 D AND L DR, ROYERSFORD, PA 19468) WHERE IT WAS ALSO DIAGNOSED THAT THE HOLE IN THE FRAME WAS DUE TO RUST. THE CONTACT WAS ADVISED BY THE DEALER THAT THERE WAS A CLASS ACTION LAWSUIT, BUT THE DEALER COULD NOT PROCEED WITH A REPAIR BECAUSE NHTSA HAD TO AGREE TO A PLAN TO INITIATE A RECALL AND REMEDY THE ISSUE. THE VEHICLE WAS NOT REPAIRED, BUT THE DEALER STATED THAT THEY WOULD PERFORM A TEMPORARY WELD ON THE FRAME...

REAR HATCH. REAR HATCH HANDLE MADE OF PLASTIC. HAS BROKEN THREE TIMES SINCE I HAVE OWNED THE CAR. DEALER CHARGES $600 EACH TIME TO REPLACE. TOYOTA SHOULD NOT MAKE CARS WITH SUCH CHEAP PARTS. CANNOT GET INTO VEHICLE.

RUST IS RAPIDLY DESTROYING THE FRAME OF MY SEQUOIA!

IN APRIL 2017 OUR 2006 SEQUOIA WAS TAKEN TO A MECHANIC FOR REPAIR. THE MECHANIC TOLD US THE AMOUNT OF RUST UNDER THE VEHICLE AND AROUND THE FRAME WAS SO BAD HE RECOMMENDED WE FILE A COMPLAINT. HIS ASSESSMENT WAS THAT THE CAR IS UNSAFE TO DRIVE. I AM PETITIONING THAT TOYOTA STAND BEHIND THIS ISSUE FOR OUR SAFETY!!

TL* THE CONTACT OWNS A 2006 TOYOTA SEQUOIA. THE CONTACT STATED THAT THE FRAME OF THE VEHICLE EXHIBITED EXCESSIVE RUST. THE VEHICLE WAS TAKEN TO BOTH A DEALER AND AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE VEHICLE FRAME WAS RUSTED THROUGH. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT INFORMED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 50,000.

THE FRAME, REAR AXLE, SUSPENSION, BRAKE LINES COMPONENTS ARE SEVERELY RUSTED IN PARTICULAR THE FRAME WHERE IT IS RUSTING FROM THE INSIDE OUT. THESE FRAMES SUFFER FROM THE SAME ISSUE AS OTHER TOYOTA TRUCKS WHERE TOYOTA REPLACED THE FRAMES. THIS RUST CONDITION MAKES THESE VEHICLES UNSAFE TO BE ON THE ROAD. TOYOTA NEEDS TO RECALL OF THESE VEHICLES BEFORE PEOPLE ARE HURT. I PURCHASED THIS VEHICLES NEW IN 2006 AND MAINTAINED IT WELL. I ADDRESSED THE EXTERNAL RUST BUT CAN NOT PREVENT THE INTERNAL RUST. THE FRAMES NEED TO BE REPLACED OR THE VEHICLE BROUGHT BACK AND DISPOSED OF.

THE FRAME OF THE TRUCK HAS BECOME RUSTY VERY QUICKLY WITH NORMAL CITY ROAD USE

BROUGHT VEHICLE IN TO HAVE VSC LIGHT SERVICE AND FOUND OUT THAT THE FRAME WHERE THE VEHICLE REAR STABILITY BAR CONNECTS TO IS ALL RUSTED OUT. AND THE OTHER SIDE WILL SOON FOLLOW. I WAS TOLD THAT THE VEHICLE WAS UNSAFE TO DRIVE, SEE PHOTOS.

FRAME IS RUSTING BAD. LOOKED ONLINE AND SEE OTHER PEOPLE HAVING THE SAME PROBLEM. NOTICED RECALL WAS DONE ON THE TACOMA.

FRAME HAS RUST CORROSION CAUSING 18 INCH PERFORATED HOLE IN FRONT FRAME OF CAR. THIS IS SAME PROBLEM THAT HAS WARRANTED A RECALL OF THE TOYOTA TUNDRA WHICH USES THE SAME FRAME. THE CAR HAS BEEN DEEMED UNSAFE TO DRIVE DUE TO THE EXTENSIVE RUST CORROSION ON THE FRAME. THIS MUST BE DUE TO POOR QUALITY MATERIAL AND COATING OF THE ORIGINAL FRAME. THROUGH RESEARCH APPEARS TO BE A VERY COMMON PROBLEM IN SEQUOIA THAT ARE IN AREAS DEALING WITH ROAD SALT. THE RECALL SHOULD BE EXTENDED TO INCLUDE THIS MODEL ALONG WITH THE TUNDRA. THE CAR IS PARKED OUTSIDE DRIVEWAY AND MOSTLY LOCAL DRIVING.

THERE'S AN 18 TO 24 INCH HOLE IN THE FRAME ON THE LEFT FRONT, WHICH SHOULD NOT HAVE DETERIORATED SO QUICKLY OR TO THAT EXTREME. EXTREME SAFETY HAZARD AS THE FRAME COULD BRAKE WITH ANY SIGNIFICANT STRESS, SUCH AS POTHOLES.

SEVERE FRAME CORROSION, 2006 TOYOTA SEQUOIA: I WAS UNAWARE OF THE "COLD WEATHER STATES" FRAME CORROSION PROBLEM WITH TOYOTAS (AND RECALLS OF OLDER SEQUOIAS AND OTHER TOYOTA TRUCKS) UNTIL I TOOK MY '06 SEQUOIA TO MY LOCAL DEALER FOR AN AIRBAG RECALL REPLACEMENT AND DIAGNOSIS OF WHAT I THOUGHT WAS A MINOR FRONT END RATTLE. WHEN THEY RAISED IT ON THE LIFT, THEY SAID THE VEHICLE BEHAVED IMPROPERLY AND THEY WERE ALARMED. THAT IS WHEN THEY DISCOVERED THE LARGE, RUSTED HOLE IN THE FRAME! WHAT A SHOCK IT WAS WHEN THEY TOLD ME, AND THEN, TO BE ADVISED THAT IT IS UNSAFE TO DRIVE! IF I HAD NOT TAKEN IT IN FOR THE AIRBAG RECALL, MY FAMILY AND I COULD BE DEAD RIGHT NOW, IF CONDITIONS HAD BEEN JUST SO. THIS IS ABSOLUTELY UNBELIEVABLE THAT TOYOTA IS PUTTING PEOPLES' LIVES IN DANGER BY NOT RECALLING ALL VEHICLES WITH THIS FRAME...

STILL AWAITING FIX FOR AIRBAG RECALL... I HAVE HAD TO REPLACE ITEMS DUE TO RUST, AND THE FRAME IS EXTREMELY RUSTY AS WELL. LOVE THE VEHICLE.... HATE THE RUST... PREVIOUS YEARS HAVE BEEN RECALLED DUE TO RUST, NOT THE 2006 MODEL. PLEASE FIX THIS!!! THANK YOU. *TR

THE UNDERCARRIAGE IS RUSTING BADLY TO THE POINT THAT I HAVE FOUND ITEMS THAT HAVE RUSTED OFF THE FRAME LYING IN MY DRIVEWAY AFTER THE CAR IS PARKED. THE INSIDE OF THE REAR HATCH IS RUSTED OUT BEYOND USE. CAR IS WELL MAINTAINED AND ALWAYS IN COVERED PARKING. PARTS OF THE FRAME CAN BE PULLED OFF DUE OT THE RUST FLAKING AND PARTS CAN BE PULLED OFF THAT SHOULD BE BOLTED THE CAR.

AFTER YEARS OF TAKING MY CAR TO TOYOTA DEALER, I TOOK MY CAR IN FOR SERVICE BY INDEPENDENT MECHANIC AND WAS TOLD FRAME ROT WAS SO BAD THAT MY CAR IS UNSAFE TO DRIVE.

THE FRAME ON THE VEHICLE HAS EXCESSIVE RUST AND THERE ARE SOME RUST PERFORATIONS AND HOLES IN THE STRUCTURAL PARTS OF THE FRAME. IN ADDITION, SOME STABILITY COMPONENTS NEED TO BE WELDED BACK ONTO THE FRAME BECAUSE THEY HAVE BROKEN OFF.

THE SEQUOIA'S FRAME HAS EXCESSIVE RUST AND CORROSION.

2006 TOYOTA SEQUOIA WAS BOUGHT BRAND NEW.IN 2015 FRAME HAS LOTS OF RUST. WHEN WE WENT FOR SERVICING, TOYOTA DEALER SAID, NOT TO WASTE ANY MONEY FOR FLUID EXCHANGES, LIKE POWER STEERING FLUID, TRANSMISSION FLUID CHANGE, BECAUSE CAR MAY NOT PASS INSPECTION, BECAUSE OF EXCESSIVE FRAME RUST. WE ARE SCARED TO DRIVE, WHETHER SPARE TIRE, REAR BRAKES FAILING, OTHER COMPONENTS FALLING OFF CAUSING DAMAGE TO CAR AND PEOPLE DRIVING BEHIND . WE SEE SEQUOIAS FROM 2000 TO 2004 ARE RECALLED FOR NEW FRAME INSTALLATION BECAUSE OF RUST PROBLEMS. WE SINCERELY HOPE, TOYOTA WILL RECALL 2006 SEQUOIAS ALSO. WE BELIEVED IN TOYOTA REPUTATION, FOR QUALITY AND RELIABILITY. WE ARE REALLY VERY DISAPPOINTED. MY FAMILY HAS 3 TOYOTAS AND EXPECTING TO BUY 2 MORE SOON. WE NEVER EXPECTED, SEQUOIAS ARE SO BAD , WHERE LIFE ITSELF IS IN DANGER DRIVING THEM. WE WISH TOYOTA WILL RECALL SEQUOIAS FOR FRAME REPLACEMENT. *TR

THE FRAME OF THE BODY OF THE TOYOTA IS RUSTING VERY BAD. FOR ONLY HAVING THE CAR THREE YEARS BUYING THIS AS A CERTIFIED CAR, THE BODY SHOULDN'T BE THIS BAD. I'LL ALSO BE OPENING UP A CASE WITH TOYOTA.

THE FRAME, REAR-END HOUSING, BRAKE SYSTEM, GUARDS, SHIELDS, EXHAUST AND MANY SUB PARTS ARE RUSTED COMPLETELY THROUGH. THE BRAKE LINES TO THE REAR BRAKES RUPTURED DUE TO EXCESSIVE RUST.

DURING SERVICING, THE SEQUOIA WAS FOUND TO HAVE A RUSTED/ROTTEN FRAME AND DECLARED UNSAFE TO DRIVE. TOYOTA HAS HAD OTHER FRAME RUST REPLACEMENT RECALLS FOR THIS MODEL, BUT NOT FOR THE MODEL YEAR IN QUESTION. THEY HAVE HAD FRAME RECALLS FOR 2006 FOR SIMILAR MODELS (TACOMA). THIS SAFETY ISSUE WAS NOT FOUND BY THE DEALERSHIP PREVIOUSLY, ALTHOUGH THE DANGEROUS SITUATION WOULD HAVE EXISTED. TOYOTA DOES NOT ACKNOWLEDGE THE ISSUE.

MY TOYOTA SEQUOIA IS A 2006 4X4 AND HAS EXCESSIVE FRAME RUST AT THE WELD SEEMS AND ALL OVER THE REAR AXLE HOUSING AND SUSPENSION COMPONENTS. I RECENTLY LEARNED THAT TOYOTA HAS STARTED TO RECALL AND REPLACE THESE FRAMES THAT ARE RUSTING FROM THE INSIDE OUT. I AM WORRIED ABOUT THIS RUST AT THE FRAME WELD AND THAT SNOW AND ROAD SALT AND ICE MELTER ARE CAUSING MY FRAME TO RUST FROM THE INSIDE OUT. MY SEQUOIA WAS ORIGINALLY LICENSED IN KANSAS AND THEY USE HEAVY ROAD SALT. I LIVE IN COLORADO AND THEY HAVE A HEAVY USE OF MAG CHLORIDE, WHICH IS A MAJOR RUST FACTOR. THE TOYOTA FRAME LOOKS LIKE IT WAS NEVER PROPERLY TREATED TO PREVENT THIS TYPE OF RUSTING. I WOULD LIKE MY FRAME TO ALSO BE REPLACED AND COVERED BY TOYOTA UNDER THIS RECALL. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA),...