2017 TOYOTA RAV4 Electrical System Problems

The contact owns a 2017 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. VIN tool confirms parts not available.

The contact owns a 2017 Toyota Rav4. The contact stated that the vehicle failed to start, and the battery was replaced several times. There was no warning light illuminated. Additionally, the contact stated that the battery terminal posts were gummed up and required to be cleaned frequently. The contact also stated that there was smoke coming from the auxiliary power outlet or cigarette lighter. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The vehicle was not diagnosed or repaired. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 50,000. VIN tool confirms parts not available.

This vehicle was involved in a T-Bone crash, where the battery came out and the vehicle caught fire. The driver of this vehicle died at the scene. This involves NHTSA recall number 23V734 & Manufacturer Recall number 23TB13.

Summary Some replacement 12-volt batteries of the size specified for the subject vehicles have smaller top dimensions than others. If a small-top battery is used for replacement and the hold-down clamp is not tightened correctly, the battery could move when the vehicle is driven with forceful turns. Safety Risk The movement could cause the positive battery terminal to contact the hold-down clamp and short circuit, increasing the risk of a fire.

--Battery terminal/wiring for negative terminal came into contact with the metal hold down clamp --Caused a two alarm structure fire and loss of two vehicles --Current recall in place but remedy of situation not available until 2024 --Current recall in place --Maintenance required light appeared and owner took vehicle in for service two weeks prior to the incident

Battery became disabled without any warning. Safety of driving down the road and battery stop working is an issue. I replaced battery through no help of Toyota. Only person to inspect was person replacing battery.

The car was sitting in the driveway and caught fire around 11:29am. The car had not been driven or moved from the driveway for at least 2 days, and is up to date on all maintenance. The fire inspectors hypothesize the fire began from the battery and spread. After Googling, I have learned that Toyota Rav 4s from 2013 to 2018 had a large recall; 1.8 million vehicles taken because of the battery catching fire randomly. The remains of the vehicle are in the driveway of the residence. Both the police and fire department came to the scene. The safety of others was put at risk because it is only luck that nobody was in the car, or going to drive the vehicle as it caught fire randomly, bringing the residents of the home and owner of the car in extreme risk from both the fire and any explosions, damage...

A fire occurred in the engine compartment of the vehicle while the vehicle was parked in a garage with the engine off. Fire patterns and physical evidence suggest the fire originated as a result of a high resistance connection between the positive battery terminal and conductor to the power distribution center. The battery is original. The vehicle has not had any repairs beyond normal maintenance. The vehicle was not involved in a crash.

Car will not start. Doesn't seem to be the battery. Got a jump start but same warning light illuminated.

I WAS DRIVING COMING FROM THE STORE WITH MY GRAND KIDS AND MY TRUCK STALLED ON ME SO I TURNED IF OFF AND TURNED IT BACK ON BUT IT KILLED ON ME AGAIN AND THIS POINT MY GRAND BABY SAID HE SMELLED SMOKE SO I LOOKED UP AND THE HODD WAS SMOKING SO I GOT MY BABIES AND MYSELF OUT THE TRUCK AND RAN TO THE OTHER SIDE OF THE STREET AND THERE I WATCHED MY TRUCK START A FIRE SO I CALL THE POLICE AND THE FIRE PEOPLE , MY TRUCK WAS TOTALED I CONTACTED TOYOTA MAIN OFFICE TO LET THEM KNOW THEY SENTED OUR THEIRE PEOPLE TO LOOK AT THE TRUCK AND DECIDED THAT IT WAS NOT THERE FAULT AND THERE WAS NOTHING THEY COULD DO FOR ME , MY TRUCK CAUGHT ON FIRE I DID NOT SET IT ON MY FIRE MY GRAND KIDS WERE IN THAT...

Went out to the vehicle one day to run an errand and the warning light came on and said Electrical System Malfunction. I took it into the repair facility and was told at first it was the battery then was told no it's the alternator. I remembered I had an extended warranty on the vehicle so I took it into the Dealership. They said it's the Wire Harness and it's not covered due to corrosion. I have put less than 20, 000 miles on this vehicle. This needs to be addressed by the Manufacturer Toyota. I am asking NHTSA to do a recall on this vehicle.

I have attached a letter that I wrote Toyota but did not mail. Vechicle is a 2017 Rav Hybrid. We bought it in CA April 2021 and it had 28230 miles. Car went to Renton WA in August, 2021. Vechicle was serviced a couple of times, but in October 2022, dealer gave us a bill for $9700 due to a faulty wire halter. The Toyota people said the car is out of warranty. Please read the letter with lots more details. Thanks.

While driving the vehicle I smelled something burning and saw smoke coming out of the air vents. I immediately pulled to the side of the road and got out. I noticed fire and smoke coming from under the hood. I called 911 and the Fire Dept. arrived to put the fire out. It was towed to a nearby storage yard until the insurance company could be notified. After talking with and submitting photos to the insurance company the vehicle was considered a total loss. We are waiting to hear back from the insurance company concerning our claim. Upon researching engine fire related to defective battery in these vehicles I learned that almost 2 million 2013-2018 Toyota RAV4 have been affected. I am just thankful everyone was able to get out of the vehicle safely before it caught on fire.

My vehicle is on it's 3rd replacement in less than 5 years because it randomly fails. It will not start. This is after I had recently taken my vehicle in for service, where the service technicians have checked the battery performance as "Good". There have never been any warnings before my vehicle would not start. Absolutely no symptoms prior to the failure. When I pressed the start button, the vehicle gave no indication that it would turn over. It's been a terrible inconvenience and very unsettling, because now that it's happened to me twice. The original battery and now the replacement in less than 5 years. I'm not sure when it will happen again.....it's so unpredictable. This last time, I was stuck in a parking lot and had to be towed to the nearest Toyota dealership.

On Saturday, May 14, 2022, my vehicle burned. and has since been totaled. The car had been trouble-free since I bought it in 2018. I was so pleased with it that I had just paid off the balance on the loan the week before because I wanted to keep it for 10 years. Prior to it burning, I had just driven it a couple miles for the first time in 2 weeks (it had been parked in a friend's garage). There were no warning lights visible during that time. I got out of the car for 3 minutes and was about to get back in when I noticed white smoke coming out of the hood. Within 30 seconds the hood had become engulfed in flames. The entire front and interior of the car was destroyed in the blaze, which the Fire Department had to extinguish. No one was injured, but...

Vehicle automatically slows down and shakes violently. We had it checked out at a Toyota dealership and they didn’t find any problems with the vehicle when they performed a diagnostic check. It continues to happen when vehicles is on the fwy. EV light appears on screen flashing on and off.

The contact owns a 2017 Toyota RAV4. The contact stated that occasionally the vehicle would not immediately start-up, or would take multiple attempts before starting. The vehicle was towed to the local dealer, but the cause of the failure was not yet determined. The manufacturer was also notified of the failure. The failure mileage was 66,000.

The contact owns a 2017 Toyota RAV4. The contact stated that while driving at an undisclosed speed, the instrument cluster failed, which caused the speedometer and RPM gauge to be inoperable. Additionally, the power steering assist failed, and the steering wheel was locked up. The failure occurred on four separate occasions. The vehicle was taken to the dealer and Toyota of Brookfield (20655 W Capitol Dr, Brookfield, WI 53045) however, the dealers could not duplicate the failure. Toyota of Brookfield informed the contact that there was a Manufacturer's Campaign Number: 21TG01 (Electrical System) associated with the VIN. The vehicle was not repaired and remained at Toyota of Brookfield. The manufacturer was not made aware of the failure. The failure mileage was approximately 30,000.

I purchased my 2017 Rav-4, brand new off the lot the end of 2017. On October 2018 my car battery was dead. NO prior indications of problems, No indicator lights. I had it towed to the dealership, they stated it was a bad cell in the battery and installed a new one. Then on Nov. 2020, once again had a dead battery, again no prior warning. I called and got a jump, took the car back to the dealership, they checked it and said I must have left a light on all night because it was completely drained. They put a 3.5 hour charge on it, check the charging system and said all was fine. Then again on 10-19-21 the battery was dead again. At that point I was pissed and just went to the parts store to get a new battery. Upon opening my hood to replace the battery...

The door does not lock/unlock when you press the button to unlock doors.The individual lock on inside needs to be manually pressed to lock and unlock. My Passenger side went about two years ago. And now the lever on my driver side is not working.

Upon starting the car at night both headlights failed to go on. Only the fog lights would work. Headlights failed in both auto and manual mode.

I bought my Rav4 in September of 2017 brand new and within 6 months I had a dead battery needing replacement so I replaced it via AAA. Since then, I have had the battery replaced an additional 3 times! I always serviced my car at the dealer and took very good care of it. Then after 50k miles, I started having odd lighting issues…both headlight bulbs had to be replaced within 3 weeks of each other and one high beam bulb, and then my tail lights went out! Then I would occasionally have trouble starting the car and with a natural gas smell, rotten eggs. Which could be a catalytic converter or fuel pump issue but can also be the battery. Well, my Rav was in the driveway with a dead battery and with no tail lights and had been sitting there for a month since I mainly drive our...

We purchased this Toyota RAV4 car new in 2017, for our daughter. It has driven problem free, until the car was 3 years and 3 months old. At 3 years and 3 months from purchase, in October, 2020, my daughter took it into the Toyota dealership, in the morning, for a routine oil change. She hasn't had any problems with the car, and has only had it serviced at the Toyota dealership. She drove it in, and got a ride home, and was waiting for the call to come pick up her car. In the afternoon, the dealership called to say her 2017 RAV4 have severe engine damage from the batter exploding, while it had been sitting at the dealership. They told her it was 3 months past the warranty, and Toyota wouldn't pay for any repairs. It sat at Toyota for a week, until our auto insurance representative went...

THREE DAYS AGO, I PARKED MY 2017 RAV4 LIMITED IN MY DRIVEWAY, STOPPED THE ENGINE, GOT OUT, LOCKED THE DOOR AND WENT IN TO MY HOUSE. SEVERAL HOURS LATER I WENT OUTSIDE AND FOUND MY RAV4 RUNNING. FOR HOW LONG I DON'T KNOW. I THOUGHT I MAY HAVE DONE SOMETHING INCORRECT. NOW BEING VERY CAREFUL ABOUT SHUT DOWN PROCEDURE, YESTERDAY I PARKED THE RAV4 IN THE SAME DRIVEWAY. TWO HOURS LATER, I WENT OUSIDE TO CHECK AND AGAIN FOUND THE RAV4 RUNNING, WITH THE LIGHTS ON. I FOUND SEVERAL REPORTS ON-LINE ABOUT OTHERS HAVING THE SAME EXPERIENCE WITH THEIR RAV4S. I CALLED SEVERAL TOYOTA DEALERS TO REPORT THE INCIDENT AND SEE IF THEY HAD EXPERIENCED THIS PROBLEM WITH OTHER CUSTOMERS. NONE DID. IT APPEARS THAT I CAN'T BE CONFIDENT THAT MY RAV4 WILL BE WHEREVER I PARKED IT WHEN I RETURN TO IT.

WHILE STOPPED AT A STOPLIGHT, MY RAV4 COMPLETELY SHUT DOWN AND THE DASHBOARD FLASHED THE WARNING "CHARGING MALFUNCTION; SEE OWNER'S MANUAL". I TOOK MY RAV4 TO THE DEALERSHIP WHERE THEY RAN A FULL INSPECTION AND FOUND ZERO ISSUES. IT HAS HAPPENED ONCE SINCE, AS WELL. I BELIEVE IT TO BE RELATED TO THE OVERARCHING TOYOTA RAV4 BATTERY/ELECTRICAL ISSUE AS LISTED IN OTHER COMPLAINTS.

I WAS STOPPED AT A RED LIGHT AND SUDDENLY THE BATTERY LIGHT CAME ON AND THE CAR SHUT DOWN COMPLETELY. I COULD NOT STEER OR MOVE. AFTER A MOMENT I WAS ABLE TO START THE CAR AND PROCEED HOME. THAT WAS THE ONLY TIME IT HAS HAPPENED AND IT OCCURRED IN OCTOBER OF 2020. I BROUGHT THE CAR TO MY MECHANIC A FEW DAYS LATER AND THEY COULD NOT FIND A PROBLEM. INVOICE IS ATTACHED.

WHILE I WAS AT MY LOCAL DEALERSHIP THEY LET ME KNOW MY BATTERY KEPT COMING BACK WEAK . I HAVE ALSO NOTICED HOW MY CAR SEEMS TO ALMOST STALL OUT SOMETIMES WHILE DRIVING . IT HASN'T BUT THIS MAKES ME VERY NERVOUS WHILE DRIVING

PLEASE SEE ATTACHED SHEET FOR ALL THAT HAS HAPPENED SINCE I PURCHASED THE CAR. I'VE HAD TO REPLACE THE BATTERY 2 TIMES IN 3 YEARS AS WELL. I HAVE NEW BATTERY AND IT BECAME CORRODED FAST. MY CAR KEPT TELLING ME THERE WAS AN ELECTRICAL ISSUE AND THE CHECK ENGINE LIGHT WOULD COME ON AND ALL OF THE FAILS LED TO THE TRANSMISSION ISSUES.

MY CAR WAS JUMPED STARTED BY AAA MY CAR SPARKED MY FUSR BOX WAS BLOWN OUT HAVE TO TAKE MY CAR TO THE DEALERSHIP MY FUSE BOX WAS BLOWN AND MY HEATER AND AIR BLOWER WAS NOT WORKING IT WAS AT MY RESIDENCE

WITH RAIN AND SNOW THE SENSOR START BEEPING AND WARNING OF OBJECTS IN FRONT OF THE VEHICLE WHEN THERE ARE NOTHING. DRIVING IN SNOW GETS THE SENSORS BLOCKED AND YOU CANT USE THE CRUISE CONTROL.

TL* THE CONTACT'S PARENTS OWNS A 2017 TOYOTA RAV4. THE CONTACT STATED THAT THE VEHICLE WAS AT A STAND STILL, WHEN HE NOTICED YELLOW FLUID UNDER THE VEHICLE. THE VEHICLE WAS TAKEN TO THE LOCAL DEALER TOYOTA OF HOLLYWOOD FL LOCATED AT 1841 FL-7, HOLLYWOOD, FL 33021, (866) 332-6839, WHERE IT WAS DIAGNOSED WITH NEEDING THE BATTERY TO BE REPLACED. THE VEHICLE WAS REPAIRED HOWEVER, THE FAILURE RECURRED. THE CONTACT STATED THE BATTERY ACID LEAKED AND DAMAGE SEVERAL COMPONENTS UNDER THE HOOD. THE MANUFACTURER HAD BEEN INFORMED OF FAILURE. THE FAILURE MILEAGE WAS 15,087.

FAN BLOWER MOTOR FOR THE A/C BROKE DOWN AROUND 50,000 KMS, THIS IS A PREMATURE BREAK DOWN. I DID'NT GET A CHANCE TO BRING IT FOR REPAIR UNTIL MY ODIMETER REACHED 70,000KMS SO THE DEALERSHIP DECLINED THE WARRANTY REPAIR.

2017 RAV 4 STRUCK A CONCRETE LIGHT POST IN PARKING LOT. CAR WAS MOVING FORWARD APPROXIMATELY 20 MPH, IMPACTED DRIVER'S SIDE FRONT AND FENDER. AIR BAGS DID NOT DEPLOY. NO COLLISION ALARM SOUNDED. ENTIRE FRONT PANEL DESTROYED, MAJOR ELECTRICAL SENSOR DAMAGE, DRIVER'S DOOR UNABLE TO OPEN. HOOD DAMAGED. SUSPENSION BENT. DRIVER SUFFERED MAJOR BRUISING AND CHEST PAIN. BOTH ELBOWS IMPACTED SOMETHING IN COLLISION. *TR

WHILE I WAS DRIVING HOME FROM WORK ON THURSDAY, MARCH 5, 2020, I SMELLED SMOKE. I LOOKED AT THE TEMPERATURE ON THE DASHBOARD AND IT SHOWED THAT THE TEMPERATURE WAS A LITTLE BELOW THE MIDDLE LINE INDICATING THE VEHICLE WAS NOT HOT. I CONTINUED DRIVING FOR A COUPLE MORE BLOCKS AND CONTINUED TO SMELL SMOKE SO ATTEMPTED TO PULL OVER INTO A PARKING LOT. WHEN I TRIED TO PULL OVER, THE VEHICLE STOPPED ON ITS OWN SO I WAS HALF WAY BETWEEN THE STREET AND PARKING LOT. I SAW SMOKE COME OUT FROM UNDER THE HOOD OF THE VEHICLE. ABOUT TWO MINUTES LATER, FLAMES STARTED COMING OUT FROM UNDER THE HOOD. THE VEHICLE CAUGHT FIRE.

DRIVERS SIDE DOOR LOCK STOPPED WORKING CAR ONLY HAS 37,000 AND IS 31 MONTHS OLD. DEALER WANTS $1000.00 TO REPAIR.

AUTO HIGH BEAMS STOPPED WORKING DEALER NEEDED TO REPLACE THE HEADLIGHT STALK ON STEERING WHEEL

VEHICLE DIED IN THE MIDDLE OF THE ROAD WHILE DRIVING NORMALLY. THE VEHICLE WAS ON A CITY STREET.

TL* THE CONTACT OWNS A 2017 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 10 MPH, THE VEHICLE STALLED. IN ADDITION, THE TRACTION CONTROL AND CHARGING SYSTEM MALFUNCTION INDICATORS ILLUMINATED. THE VEHICLE WAS ABLE TO RESTART AND WAS TAKEN TO TOYOTA OF HOLLYWOOD (6000 HOLLYWOOD BLVD, HOLLYWOOD CA, 323-498-2260) TO BE DIAGNOSED. THE RESULTS WERE UNKNOWN. THE VEHICLE WAS BEING REPAIRED UNDER WARRANTY. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 27,220.

IGNITION REMAINS ON WHEN I EXIT VEHICLE IF FORGET TO PUSH OFF BUTTON WITH MY KEY IN POCKET. CAR NOT RUNNING WHEN I LEAVE SO IT IS EASY TO FORGET AND ENGINE CAN/WILL RESTART AT LATER TIME. THIS HAS HAPPENED AT LEAST TWO TIMES IN DRIVEWAY. IF IN HAPPENED WHEN I PUT IN GARAGE AND WENT TO BED IN ROOM OVER GARAGE IT COULD PRESENT A CARBON MONOXIDE HAZARD.

I HAD TO VISIT TOYOTA BECAUSE MY RADIO WILL TURN ON BY ITSELF, WHEN I PARK. EVEN AFTER VISITING TOYOTA FOR AN UPDATE, MY RADIO WILL CHANGE ON ITS OWN, NOT FROM THE STEERING WHEEL) BUT ON ITS OWN.SO IT IS NOT FIXED. WIPERS WILL TURN ON THEN STOP. THERE SEEMS TO BE A DEVICE BEHIND THE DASH THAT I CAN HEAR CLICKING ON AND OFF WELL AFTER THE IGNITION IS OFF OR WHILE THE CAR IS IDLE FOR A BIT. MY CLIMATE CONTROL CHANGES ON ITS ON EVEN THOUGH IT WORKS FINE MOST OF THE TIME. IT IS AS IF MY CAR IS RECEIVING ADDITIONAL COMMANDS FROM ANOTHER SOURCE. LAST WEEK, AT NIGHT, I WITNESSED TWO MEN STANDING IN THE MIDDLE OF THE STREET, SOMEHOW ACTIVATING CAR ALARMS FROM RANDOM CARS. JUST YESTERDAY, NOT FAR FROM WHERE I LIVE A DRIVER "LOST CONTROL" AND RAN INTO TWO HOMES. THE...

ON 01/31/19 I WAS DRIVING MY 2017 RAV4 ON FREEWAY ABOUT 4 MILES THEN LOCAL ABOUT 5 BLOCKS I HEARD NOISE ON MY CAR SO I STOPPED. IT TURNED OUT I HAD A FLAT ON MY FRONT PASSENGER TIRE. I REPLACED IT WITH SPARE AND THE 'LOW TIRE PRESSURE' LIGHT JUST CAME ON. I THEN REALIZED WHY THE LTP LIGHT NEVER CAME ON BEFORE I REPLACED WITH SPARE. I TOOK THE RAV4 TO PASADENA TOYOTA TO RUN THE DIAGNOSTIC CHECK TO FIND OUT WHY LTP LIGHT NEVER CAME ON WHEN I WAS DRIVING ON A FLAT. THE DIAGNOSTIC FOUND 'NOTHING WRONG' AND THE SYSTEM DIDN'T RECORD ANYTHING. THEY ALSO TOLD ME THE TIRE SUFFERED 'RUN FLAT DAMAGE' AND NOT REPAIRABLE. I THEN CALLED TOYOTA CUSTOMER SVC. CASE # 1902010530, CASE MANAGER DEREK. DEREK JUST INFORMED ME ON 2/11/19 THAT THE LTP LIGHT WILL NOT COME ON WHEN THE TIRE SUDDEN...

THE TRANSMISSION, IS NOT SHIFTING PROPERLY IN EVEN MILDLY COLD WEATHER. HAD THE CAR FOR TWO YEARS, AND NOW THE TRANMISSION, IS NOT SHIFTING PROPERLY WHEN YOU FIRST START IT UP. THE ENGINE RPMS ARE AT 3,500, WHEN DOING 30 MPH DOWN THE ROAD,AND PUSHING ALL THE WAY DOWN ON THE ACCELERATOR, THE CAR WILL NOT GO, THERE ARE NO ERROR LIGHTS, THERE IS AN TRANMISSION SHIFT ISSUE WITH ACCELERATION ISSUE. THIS IS DANGEROUS BECAUSE WHEN GOING DOWN A 35 MPH ROAD, THERE ARE CARS THAT CAN ACCELERATE AND THIS CAR GOES NOWHERE. START THE CAR AFTER BEING PARKED OUTSIDE IN COLD WEATHER, WAITED 5 MINUTES BEFORE DRIVING THE CAR, AND IT IS STILL NOT RESPONDING PROPERLY. THERE HAVE BEEN ELECTRICAL ISSUES WITH THIS CAR, AND NOW THE TRANSMISSION WILL NOT SHIFT AND GO INTO GEAR PROPERLY, NOT SURE IF ITS THE COMPUTER PROGRAM, OR GEAR ISSUE. NEVER HAD THIS...

WHEN IT IS RAINING, OR SNOWING AND FOR SOME REASON, THE SENSORS GET WET FROM THE BUMPER, CROSSTRAFFIC ALERT OR BACKUP OR SIDE WARNING, THE WHOLE SYSTEM SHUTS DOWN. DRIVING ON THE FREEWAY AND IT IS RAINING AND THE WHOLE COMPUTER JUST FROZE, AND LOST ALL SENSORS AND A FAILURE ALERT SHOWED UP ON THE DASHBOARD, ALONG WITH THE CARS TRANSMISSION HAVE A HARD TIME SHIFTING AS EXITING THE FREE WAY. THIS IS TOTAL COMPUTER FAILURE BUT AFTER EXITING THE FREEWAY AND DRIVING DOWN A ROAD, AND AT A STOP LIGHT PUT THE TRANSMISSION IN NEUTRAL AND SHIFTING BACK TO DRIVE, ALL THE COMPUTER ERRORS CLEARED. TOOK IT TO THE DEALER AND OF COURSE THEY FOUND NOTHING. THIS IS DANGEROUS FOR BLIND SPOT WARNING SENSORS TO GO OUT THE PBM SENSOR SAID FAILURE AND THERE IS AN ELECTRIC HARNESS ISSUE WITH THIS CAR WHERE THE WIRES EITHER WERE NOT INSULATED...

POWER TRANSMISSION, SAFETY ISSUE, THE POWER TRANSMISSION WILL NOT SHIFT IN A TIMELY MANNER TO PROPER GEARS,IN COLD WEATHER, THIS IS A SAFETY ISSUE, WHEN ENTERING THE FREEWAY AFTER LEAVING WORK, THE CAR WILL ONLY GO 30 MPH AT 3,500 RPM. UNTIL THE CAR WARMS UP, THIS HAS NEVER HAPPENED BEFORE, AND NOW IT IS. TOYOTA DEALER CONFIRMED THAT THE SHIFT POINTS ARE HIGHER THAN NORMAL, WHEN FIRST STARTED IN THE MORNING, AND PER THE DEALER WELL IT TAKES AWHILE FOR THE CAR TO WARM UP BEFORE IT WILL GO TO NORMAL SHIFT POINTS, AND ALLOW THE TRANSMISSION TO FUNCTION NORMALLY. WELL 30 MPH AT 3500 RPM, THIS IS NOT NORMAL, AND THIS IS A SAFETY ISSUE, SO WHEN YOU LEAVE WORK YOUR CAR WILL ONLY GO 30 MPH ON A 60 MPH FREEWAY. THE DEALERS RESPONSE IS AFTER IT HAS BEEN RUNNING AND WARMED UP IT WILL WORK NORMALLY....

TL* THE CONTACT OWNS A 2017 TOYOTA RAV4. WHILE DRIVING APPROXIMATELY 75 MPH BEHIND ANOTHER VEHICLE, THE CONTACT SWITCHED LANES AND THE FORWARD COLLISION AVOIDANCE FEATURE IMMEDIATELY ACTIVATED. AS A RESULT, THE BRAKES ENGAGED AND CAUSED THE VEHICLE TO STOP ABRUPTLY. THE CONTACT INDICATED THAT THE DETECTION SYSTEM ACTIVATED ALTHOUGH THE PRECEDING VEHICLE WAS MORE THAN 150 FEET AWAY. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER AND LOCAL DEALER WERE NOT NOTIFIED. THE FAILURE MILEAGE WAS 38,000. *TT*JB

ON OCCASION, WHILE GOING FROM REVERSE TO DRIVE, THE VEHICLE SHUTS DOWN AND I GET A MESSAGE THAT SAYS "CHARGING MALFUNCTION". IT DOES NOT HAPPEN ALL THE TIME. IT HAS HAPPENED WHEN I PULL OUT OF MY DRIVEWAY ONTO THE BUSY STREET I LIVE ON. IT HAS ALSO HAPPENED ONCE WHEN I PARALLELL PARKED. I HAVE TO SHUT THE CAR OFF AND THEN RESTART FOR IT TO WORK AGAIN. I TRIED TO RECREATE THE SITUATION BUT CANNOT. I BROUGHT IT TO TOYOTA AND THEY CANNOT FIND THE PROBLEM EITHER. MOST RECENTLY IT HAPPENED TO ME LAST NIGHT WHILE PULLING OUT OF MY DRIVEWAY. (6-20-18) TIME. I PURCHASED THE CAR AUGUST OF 2017 AND IT STILL IS UNDER WARRANTY HOWEVER I HAVE HAD NO LUCK WITH TOYOTA. THEIR RESPONSE WAS WE WILL NOTE IT IN THE FILE.

I WAS DRIVING HOME AND AT A RED LIGHT WHEN MY RAV4 STARTED TO SHAKE AND FEEL AS THOUGH IT WAS GOING TO STALL OUT. EVERYTHING SHUT DOWN AND I WAS UNABLE TO MOVE. I RECEIVED THE FOLLOWING ERROR ON OUR DISPLAY, "CHARGING SYSTEM MALFUNCTION". AFTER A FEW SECONDS I WAS ABLE TO TURN MY VEHICLE ON AND PROCEED THROUGH THE INTERSECTION. APPROXIMATELY ONE MINUTE LATER IT STARTED TO STUTTER AGAIN. I WAS ABLE TO MAKE IT TO MY DRIVEWAY BEFORE IT TURNED OFF AND LOST POWER. I INFORMED MY HUSBAND WHAT HAD HAPPENED AND HE TOOK THE VEHICLE OUT TO SEE IF THE SAME ERROR WOULD OCCUR. WITHIN FIVE MINUTES INTO HIS DRIVE THE VEHICLE SHUT OFF. WE HAD IT TOWED TO OUR TOYOTA DEALERSHIP, AS WE JUST PURCHASED THIS RAV4 BRAND NEW NINE MONTHS AGO. THE SERVICE DEPARTMENT CONDUCTED MULTIPLE TESTS AND INFORMED US THAT EVERYTHING WAS FINE....

WHILE DRIVING ON A MAJOR HIGHWAY AT 65 MPH. THE ENGINE SHUT OFF AND ALL SCREENS AND GAUGES SHUT OFF FOR ABOUT 3 TO 5 SECONDS THEN THE CAR RESTARTED ON ITS OWN AND BEGAN TO ACCELERATE QUICKLY SO I HAD TO USE THE BRAKES TO SLOW THE CAR DOWN. THIS EVENT HAPPENED THREE TIMES THAT DAY ALL ON THE HIGHWAY AND WITH THE CRUISE CONTROL ON.I CALLED THE TOYOTA DEALER TO HAVE THE CAR CHECKED OUT THE CAR WAS CHECKED OUT NO ISSUES FOUND. A FEW WEEKS LATER I GOT THE OIL CHANGED AT THE DEALER AND AFTER I LEFT THE DEALERSHIP THE ROADS WERE ICY SO I WAS DRIVING AROUND 25 MPH WHEN THE ENGINE STOPPED RUNNING AND THE DASH WENT OUT FOR ABOUT 3 TO 5 SECONDS AND THEN THE CAR STARTED RUNNING AGAIN THIS HAPPENED AGAIN A FEW MINUTES LATER THE CRUISE CONTROL WAS NOT ON...

I STARTED IT AND NOTICED IMMEDIATELY SOMETHING WAS WRONG. VEHICLE STARTED MOVING AND I TRIED TO APPLY BRAKE. BRAKE WAS HARD INITIALLY AND VEHICLE CONTINUED MOVING. THEN I WAS ABLE TO DEPRESS THE BRAKE PEDAL ALL THE WAY BUT IT KEPT MOVING. WITH MY DAUGHTER IN THE CAR I GOT PANIC. I SWITCHED TO P AND VEHICLE KEPT GOING, THOUGH SLOWLY ON THE STREET. THEN I TURNED POWER OFF AND REMOVED THE KEY. AT THIS POINT ALL DASH BOARDS LIGHTS WERE ON AND IT WAS MAKING A LOUD, WIRED NOISE. IT LASTED SEVERAL SECONDS AND VEHICLE KEPT MOVING DURING THIS TIME. FINALLY IT CAME TO A STOP IN THE MIDDLE OF THE STREET. THE VEHICLE HAS ONLY 4200 MILES. THE SCARY THING IS, BRAKE FAILED FOR NO REASON AND ALL DASH BOARD LIGHTS WERE ON EVEN AFTER THE KEY WAS REMOVED.

THE LANE DEPARTURE WARNING TONE CANNOT BE HEARD WHEN DRIVING THE VEHICLE. THERE IS NO WAY TO INCREASE THE VOLUME OF THE WARNING TONE AS THE CONSUMER. TOYOTA KNOWS THIS IS A PROBLEM (SEE PG 258 OF OWNER'S MANUAL) BUT REFUSES TO FIX. THIS IS A RISK TO PERSONAL SAFETY.