2008 TOYOTA HIGHLANDER HYBRID — Problems, Recalls & Safety Data
N/A
Safety Rating
272
Owner Complaints
8
Recalls
4
Service Bulletins
0
Investigations
Overview of the 2008 TOYOTA HIGHLANDER HYBRID
The 2008 TOYOTA HIGHLANDER HYBRID has received a total of 272 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 9 recall campaigns affecting this vehicle, covering issues with VISIBILITY:POWER WINDOW DEVICES AND CONTROLS, HYBRID PROPULSION SYSTEM: INVERTER. 4 technical service bulletins have been issued by Toyota Motor Corporation for this model year. The most commonly reported problems involve the Service Brakes (94 complaints), Electrical System (34 complaints), and Electronic Stability Control Esc (25 complaints).
Recalls for the 2008 TOYOTA HIGHLANDER HYBRID
NHTSA has recorded 9 recalls for the 2008 TOYOTA HIGHLANDER HYBRID, potentially affecting up to 5,242,353 vehicles.
Recall 15V689000 — VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
| 1,814,284 vehicles affected
Defect: Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been...
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20,...
View full details →Recall 13V396000 — HYBRID PROPULSION SYSTEM: INVERTER
| 133,081 vehicles affected
Defect: Toyota is recalling certain model year 2006-2010 Highlander hybrid vehicles manufactured February 16, 2005, through July 29, 2010; and model year 2006-2008 Lexus RX400h vehicles manufactured February 23, 2005, through December 2, 2008. The Intelligent Power Module (IPM) inside the inverter module may contain transistors that have higher operating temperatures than the solder can support and the transistors may be...
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. It is possible that the hybrid system will shut down while the vehicle is being driven, causing the vehicle to stall unexpectedly, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the IPM free of charge. Owners may contact Toyota at 1-800-331-4331. Vehicles that had their IPM replaced under recall 11V-342 are not affected by this campaign.
View full details →Recall 12V491000 — VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
| 2,519,424 vehicles affected
Defect: Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process...
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a...
View full details →Recall 11V245000 — AIR BAGS:SIDE/WINDOW
| 307,848 vehicles affected
Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION...
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE....
View full details →Recall 11V245000 — AIR BAGS
| 307,848 vehicles affected
Defect: TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION...
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE....
View full details →Recall 09V223000 — EQUIPMENT:OTHER:LABELS
| 27,080 vehicles affected
Defect: TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
View full details →Recall 09E028000 — EQUIPMENT
| 3,499 vehicles affected
Defect: SOUTHEAST TOYOTA IS RECALLING 3,499 STAINLESS STEEL EXHAUST TIPS SOLD BY SOUTHEAST TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBIRD VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND...
Consequence: THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.
Remedy: SOUTHEAST TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MAY/JUNE 2009. OWNERS MAY CONTACT SOUTHEAST TOYOTA CUSTOMER LOYALTY DEPARTMENT AT 1-800-301-6859.
View full details →Recall 09E022000 — EQUIPMENT
| 39,100 vehicles affected
Defect: TOYOTA IS RECALLING 39,100 STAINLESS STEEL EXHAUST TIPS SOLD BY TOYOTA AS AN OPTIONAL ACCESSORY FOR USE ON MY 2008 HIGHLANDER AND HIGHLANDER HYBRID VEHICLES. DUE TO IMPROPER HEAT TREATMENT DURING THE MANUFACTURING PROCESS, THE ORIGINAL CLAMP USED TO SECURE THE TOYOTA STAINLESS STEEL EXHAUST TIP TO THE EXHAUST PIPE MAY DEVELOP MICROSCOPIC CRACKS. EVENTUALLY THE CRACK MAY EXPAND CAUSING...
Consequence: THE ORIGINAL CLAMP AND THE TOYOTA STAINLESS STEEL EXHAUST TIP MAY FALL OFF THE VEHICLE'S EXHAUST PIPE AND BECOME A ROAD HAZARD WHICH WOULD INCREASE THE RISK OF A VEHICLE CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND REPLACE THE CLAMP FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 4, 2009. OWNERS MAY CONTACT TOYOTA CUSTOMER EXPERIENCE CENTER AT 1 888-270-9371 MONDAY THROUGH FRIDAY, 5:00 AM TO 6:00 PM, SATURDAY 7:00 AM...
View full details →Recall 08V181000 — SEAT BELTS:REAR/OTHER
| 90,189 vehicles affected
Defect: TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR...
Consequence: HOWEVER, FOR THE TWO THIRD ROW DSP'S ON THESE VEHICLES, THE ALR MODE DEACTIVATES BEFORE THE WEBBING IS FULLY RETRACTED, SO THAT IT WILL NOT LOCK WHEN CERTAIN REAR-FACING CRS'S THAT HAVE A SHORT SEAT BELT ROUTING PATH ARE INSTALLED IN THE VEHICLE. THIS CAN ALLOW THE SEAT BELT WEBBING TO SPOOL OUT DURING NORMAL DRIVING MANEUVERS, WHICH COULD AFFECT THE STABILITY OF A CHILD RESTRAINT INSTALLED AT THOSE SEATING POSITIONS. AS SUCH, THIS COULD DISCOURAGE THE USE OF A CHILD RESTRAINT AND IN THE EVENT OF A CRASH, THE CHILD MAY NOT BE ADEQUATELY PROTECTED POSSIBLY RESULTING IN INJURY.
Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
View full details →Owner Complaints for the 2008 TOYOTA HIGHLANDER HYBRID
272 complaints have been filed with NHTSA for the 2008 TOYOTA HIGHLANDER HYBRID. Below is a breakdown by vehicle component.
Most Recent Complaints
Odometer Fraud. The contact purchased a 2008 Toyota Highlander Hybrid. The contact stated that it was discovered that there was a mileage discrepancy. The vehicle was a private sale. At the time of purchase, the vehicle mileage was 92,000, and at the time of registration, it was discovered that the mileage was 212,000.
The contact owns a 2008 Toyota Highlander Hybrid. The contact stated that while driving on several occasions at various speeds, the master, brake system, ABS warning, and traction control warning lights illuminated. Additionally, the message "Brake System Malfunction - Stop in Safe Place Immediately”, check ABS/VSC system, and check braking system" messages were displayed. The vehicle was taken to an independent mechanic several times, but was not diagnosed. The manufacturer was notified of the failure. The failure mileage was approximately 227,000.
The contact owns a 2008 Toyota Highlander Hybrid. The contact stated while driving 45 MPH, the brake malfunction and ABS warning lights were illuminated. The contact stated that when she started the vehicle, she was unable to depress the brake pedal to the floor and started to hear an abnormal noise. The contact called the local dealer and made them aware of the failure. The contact took the vehicle to an independent mechanic and was informed that the brake booster pump assembly and brake actuator assembly needed to be replaced. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 162,000.
The contact owns a 2008 Toyota Highlander Hybrid. The contact stated while driving 45 MPH, the brake malfunction and ABS warning lights were illuminated. The contact stated that when she started the vehicle, she was unable to depress the brake pedal to the floor and started to hear an abnormal noise. The contact called the local dealer and made them aware of the failure. The contact took the vehicle to an independent mechanic and was informed that the brake booster pump assembly and brake actuator assembly needed to be replaced. The vehicle was not diagnosed or repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 162,000.
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER HYBRID. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 13V396000 (HYBRID PROPULSION SYSTEM: INVERTER). WHILE IN A PARKING LOT, THE VEHICLE WENT INTO FAIL SAFE LIMP HOME MODE AND THE VEHICLE STALLED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TOWED TO NEWARK TOYOTA WORLD (230 E CLEVELAND AVE, NEWARK, DE 19711, (302) 368-6262) TO BE DIAGNOSED, BUT THE FAILURE COULD NOT BE DUPLICATED. ADDITIONALLY, DIAGNOSTIC TESTING WOULD COST $600. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 185,000.
Safety Rating for the 2008 TOYOTA HIGHLANDER HYBRID
NHTSA has not yet tested the 2008 TOYOTA HIGHLANDER HYBRID in its New Car Assessment Program.
Technical Service Bulletins for the 2008 TOYOTA HIGHLANDER HYBRID
Toyota Motor Corporation has issued 4 technical service bulletins (TSBs) for the 2008 TOYOTA HIGHLANDER HYBRID. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
ZKC_Region Email — SERVICE BRAKES
Region Email: Toyota has received reports regarding the Brake Actuator Assembly and Brake Booster Pump Assembly on certain 2008 - 2010 model year Highlander Hybrid vehicles. These reports have indicated certain internal malfunctions of the Brake Actuator Assembly. Although the Brake Actuator Assembly and Brake Booster Pump Assembly are covered...
T-SB-0162-13_Rev — HYBRID PROPULSION SYSTEM
TSB: REVISION NOTICE January 05, 2018 Rev1: ? Applicability has been updated to include 2012 ? 2017 Camry HV and Prius C, 2015 ? 2017 Prius V, 2006 ? 2017 Highlander HV, 2010 ? 2016 Prius, and 2016 ? 2017 RAV4 HV model year vehicles. ? The Repair Procedure section...
ZG4_Region Email — STRUCTURE:BODY:DOOR
Region Email: Toyota is announcing a Warranty Enhancement Program to extend the warranty coverage for the Power Back Door on certain 2008 - 2013 model year Highlander and Highlander Hybrid vehicles.
TSB-0356-09 — EQUIPMENT:APPLIANCE:AIR CONDITIONER
TOYOTA: HEATING/AIR CONDITIONER. SOME MODELS MAY EXHIBIT AN INTERMITTENT HVAC SYSTEM ODOR. A NEWLY DESIGNED EVAPORATOR SUB ASSEMBLY HAS BEEN MADE AVAILABLE TO DECREASE THE POTENTIAL FOR HVAC ODOR. *PE
NHTSA Investigations for the 2008 TOYOTA HIGHLANDER HYBRID
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the TOYOTA HIGHLANDER HYBRID
- 2004 TOYOTA HIGHLANDER HYBRID — 0 complaints
- 2005 TOYOTA HIGHLANDER HYBRID — 2 complaints
- 2006 TOYOTA HIGHLANDER HYBRID — 481 complaints
- 2007 TOYOTA HIGHLANDER HYBRID — 160 complaints
- 2008 TOYOTA HIGHLANDER HYBRID (current)
- 2009 TOYOTA HIGHLANDER HYBRID — 55 complaints
- 2010 TOYOTA HIGHLANDER HYBRID — 26 complaints
- 2011 TOYOTA HIGHLANDER HYBRID — 5 complaints
- 2012 TOYOTA HIGHLANDER HYBRID — 11 complaints
- 2013 TOYOTA HIGHLANDER HYBRID — 6 complaints
Other TOYOTA Models
- TOYOTA CAMRY — 23,209 total complaints
- TOYOTA PRIUS — 15,411 total complaints
- TOYOTA COROLLA — 14,342 total complaints
- TOYOTA RAV4 — 11,737 total complaints
- TOYOTA SIENNA — 10,769 total complaints
- TOYOTA TACOMA — 10,512 total complaints
- TOYOTA TUNDRA — 8,997 total complaints
- TOYOTA HIGHLANDER — 6,663 total complaints