2005 TOYOTA 4RUNNER Power Train Problems

- The undercarriage and frame have had premature rusting for years. The car is otherwise in excellent condition due to my care of it over the last 20 years. 5 years ago, a service person at my local Toyota dealership said, "I'm really disappointed in Toyota, I've never seen rust like this." I have now recently been told by a local service shop that it's time to get a new car. The lines are all corroded for the power steering, etc, and he was unable to even "touch them," and said that the rust issue is no longer safe, and we shouldn't drive far from home. - We are now unable to drive the car much, as we live in the country and have far communities. With a [XXX] , we are unwilling to drive the car over 45 mph, or more than 10 miles for fear of an accident...

EXCESSIVE FRAME RUST AND UNDERBODY RUST. MOST WELD POINTS AND FRAME ASSEMBLY IS DEGRADING FROM RUST. TRANSMISSION COOLANT LINES HAVE CRACKED AND LEAKED.

EXCESSIVE UNDERBODY RUST, RUSTING FRAME JOINTS, AND ROTTING FRAME MEMBERS FROM THE INSIDE OUT.

VEHICLE HAS VERY EXCESSIVE FRAME RUST. HOLES THROUGHOUT ENTIRE FRAME MAKING THE VEHICLE UNSAFE TO DRIVE. RUSTING FROM THE INSIDE OUT DUE TO NEGLIGENCE ON TOYOTAS PART. THIS VEHICLE HAS THE SAME EXACT FRAME THAT WAS RECALLED ON THE TACOMAS, TUNDRAS AND SEQUOIAS. PLEASE TELL ME WHY THE 4RUNNER WAS LEFT OUT?

2005 TOYOTA 4RUNNER SR5 WAS TAKEN INTO A CERTIFIED TOYOTA MECHANIC FOR INSPECTION AND THE MECHANIC SHOWED ME THE UNDERCARRIAGE OF THE VEHICLE, NAMELY THE FRAME AND OTHER ASSOCIATED PARTS. HE WARNED THAT IT WOULD BE DIFFICULT TO PERFORM MAINTENANCE ON THE VEHICLE IF THE FRAME IS ROTTED THROUGH. THE VEHICLE WAS PUT ON A LIFT FOR INSPECTION.

THE REAR AXLE RUSTED SO BADLY THAT IT STARTED FLAKING APART. THE FRAME IS RUSTED SEVERELY IN THE AREAS WHERE THE REAR SUSPENSION COMPONENTS ATTACH. THE GAS TANK SKID PLATE RUSTED UNTIL IT BEGAN TO FALL OFF WHILE DRIVING DOWN THE ROAD AND ALL OF THE AREAS WHERE IT WAS BOLTED TO THE FRAME COMPLETELY RUSTED OUT. THE EXHAUST ALSO RUSTED THROUGH BEHIND THE MUFFLER CAUSING IT TO FALL OFF WHILE DRIVING DOWN THE ROAD. THERE ARE HOLES IN MULTIPLE AREAS OF THE FRAME. I HAD TO GRIND,CHIP, AND WIRE BRUSH THE FRAME WITH THE VEHICLE ON JACK STANDS IN ORDER TO REPAINT EVERYTHING AND KEEP MY VEHICLE GOING. THIS TOOK OVER 100 HOURS OF LABOR JUST TO COMPETE. I ALSO HAD TO REPLACE THE EXHAUST AND THE GAS TANK SKID PLATE. ALL OF THE BOLTS FOR THE SKID PLATES ON THE BOTTOM OF THE VEHICLE WERE COMPLETELY RUSTED THROUGH...

STSTIONARY REAR AXEL HOUSING RUSTED -LEAKING OIL-INFERIOR STEAL JUST LIKE THE FRAME THAT WAS REPLACED

EXCESIVE RUST UNDER BODY. EXHAUST SYSTEM AND FRAME.

TL* THE CONTACT OWNS A 2005 TOYOTA 4RUNNER. WHILE DRIVING 70 MPH, THE VEHICLE LOST POWER. IN ADDITION, THE ACCELERATOR PEDAL WAS DEPRESSED, BUT THE VEHICLE FAILED TO ACCELERATE. THE CHECK ENGINE AND VSC WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTO STORE WHERE A TECHNICIAN PULLED UP DIAGNOSTIC TROUBLE CODES. THE CONTACT SPOKE WITH A LOCAL DEALER WHO STATED THAT, BASED ON THE CODES PROVIDED, THE VEHICLE WOULD BE REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 05V123000 (ENGINE AND ENGINE COOLING). THE VIN WAS NOT INCLUDED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 103,000.

TL* THE CONTACT OWNS A 2005 TOYOTA 4RUNNER. WHEN THE VEHICLE CAME TO A COMPLETE STOP, THERE WAS A TWO SECOND DELAY BEFORE THE VEHICLE JOLTED. THE CONTACT STATED THAT IT FELT AS THOUGH SOMEONE HAD REAR-ENDED THE VEHICLE. THE CONTACT STATED THAT THE FAILURE OCCURRED INTERMITTENTLY AND BECAME PROGRESSIVELY WORSE OVER TIME. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE DRIVESHAFT WAS LUBRICATED; HOWEVER, THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 150,000.

LOW MILEAGE CAR AND PARTS OF THE FRAME ARE FALLING A PART. DEALER REFUSES TO SERVICE CAR AS IT IS UNSAFE. TOYOTA SAYS THEY HAVE NO PROBLEMS WITH THE 4RUNNERS RUSTING JUST THERE TRUCKS AT THIS TIME...?

2005 TOYOTA 4-RUNNER SPORT EDITION. HAD CAR PARKED IN DRIVEWAY. CAR WAS IN PARK WITH NO KEY IN THE IGNITION. 4-YEAR OLD CHILD CLIMBED INTO CAR AND PUT CAR GEAR-SHFT INTO NEUTRAL (NO KEY IN IGNITION AND FOOT WAS NOT ON BRAKE PEDAL). CAR ROLLED OUT OF DRIVEWAY INTO A BUSY ROAD. ANOTHER CAR NEARLY HIT THE 4-RUNNER. DRIVER OF OTHER VEHICLE STOPPED AND HALTED OTHER TRAFFIC BY HONKING THEIR HORN. OWNER OF 4-RUNNER HEARD HONKING, CAME OUT OF HOUSE AND FOUND 4-RUNNER SITTING ACROSS THE ROAD WITH THE 4-YEAR OLD CHILD STILL IN IT. CONDITION OF PUTTING 4-RUNNER INTO NEUTRAL WITHOUT KEY OR FOOT ON BRAKE PEDAL WAS TESTED SEVERAL MORE TIMES AND FOUND TO BE REPEATABLE. *TR

WHEN COMING TO A STOP VEHICLE TENDS TO SHIFT INTO FIRST GEAR LATE, RIGHT AT STOPPING AND IT FEELS LIKE A BUMP OR SOMEONE HITTING YOU FROM BEHIND. THIS DEPENDS ON HOW FAST THE VEHICLE IS STOPPED. IF STOPPED FASTER, THE VEHICLE NEVER SHIFTS INTO FIRST GEAR AT STOPPING. AFTER THE BRAKE IS RELEASED THE VEHICLE FEELS AS IF SHIFTING FROM SECOND TO FIRST GEAR. MANUALLY DOWN SHIFTING THE VEHICLE IN ALL GEARS FEELS NORMAL EXCEPT FROM SECOND TO FIRST. THERE IS A HESITATION BETWEEN THESE GEARS, THE VEHICLE COAST AS IF IN NEUTRAL FOR ABOUT TWO SECONDS THEN SHIFTS INTO FIRST GEAR. THIS WEBSITE ALSO DESCRIBES THE "BUMP" FEEL FROM OTHER OWNERS, SEARCH FOR "BUMP" HTTP://TOWNHALL-TALK.EDMUNDS.COM/DIRECT/VIEW/.F0DACC5/175. *TR

EVERY SO OFTEN MY 2005 TOYOTA 4-RUNNER WILL LURCH FORWARD AT A STOP. ITS LIKE THE VEHICLE IS BEING REARENDED. THIS OCCURS WITHOUT WARNING AND AT RANDOM TIMES DURING A TYPICAL DAY. THE TRANSMISSION WILL ALSO LOCK IN 4TH GEAR IF WHILE DRIVING ON THE INTERSTATE THE VEHICLE SLOW SUDDENLY - THIS IS CORRECTED BY PULLING OFF THE INTERSTATE, SHUTTING DOWN THE VEHICLE AND WAITING A FEW MOMENTS. *TR