NHTSA Complaint #11141370 — 2005 TOYOTA 4RUNNER

THE REAR AXLE RUSTED SO BADLY THAT IT STARTED FLAKING APART. THE FRAME IS RUSTED SEVERELY IN THE AREAS WHERE THE REAR SUSPENSION COMPONENTS ATTACH. THE GAS TANK SKID PLATE RUSTED UNTIL IT BEGAN TO FALL OFF WHILE DRIVING DOWN THE ROAD AND ALL OF THE AREAS WHERE IT WAS BOLTED TO THE FRAME COMPLETELY RUSTED OUT. THE EXHAUST ALSO RUSTED THROUGH BEHIND THE MUFFLER CAUSING IT TO FALL OFF WHILE DRIVING DOWN THE ROAD. THERE ARE HOLES IN MULTIPLE AREAS OF THE FRAME. I HAD TO GRIND,CHIP, AND WIRE BRUSH THE FRAME WITH THE VEHICLE ON JACK STANDS IN ORDER TO REPAINT EVERYTHING AND KEEP MY VEHICLE GOING. THIS TOOK OVER 100 HOURS OF LABOR JUST TO COMPETE. I ALSO HAD TO REPLACE THE EXHAUST AND THE GAS TANK SKID PLATE. ALL OF THE BOLTS FOR THE SKID PLATES ON THE BOTTOM OF THE VEHICLE WERE COMPLETELY RUSTED THROUGH AND COULD NOT BE REMOVED WITHOUT FALLING APART AND LEAVING HALF THE BOLT IN THE FRAME. THE XREAS SUSPENSION SYSTEM WHICH RUNS HYDRAULIC LINES AROUND THE FRAME ALSO RUSTED APART AND LEAKED FLUID ALL OVER EVERYTHING. THE BOLTS WERE ALL HEAVILY RUSTED AND COULD NOT BE REMOVED TO GET THE LINES OFF THE FRAME. THE FRAME ON THIS VEHICLE WAS NOT ADEQUATELY COATED TO PREVENT IT FROM RUSTING. THIS NEEDED TO BE DONE WITH APPROXIMATELY 100,000 MILES ON THE VEHICLE.