2023 TESLA MODEL 3 Electrical System Problems

There is NO mechanism to unlock the rear passenger doors in case of electrical failure. No Emergency mechanical door opening in case of emergency. Passengers will NOT be able to get out of the LOCKED vehicle during an emergency (i.e. crash, battery fire, submerged in water, etc). This is an EXTREMELY IMMINENT DANGER for small kids who are sitting in car seats, since it will take even longer to release them from their straps in order to get out. The small rear windows are useless for escape. THIS FLAW DESIGN HAS ALREADY CAUSED DEATHS. Changes SHOULD BE MADE to enable emergence mechanical opening of the rear doors.

There's a problem with the airbags, and the steering wheel is hard to turn.

The blinkers do not respond to the change in blinkers when I initiate the blinker (right or left) by using the stalk. There has been numerous times that I fully pull down or push up the blinker stall and it would not engage the blinker but today I am reporting it because now I almost changed the lane after engaging the blinker but it didn’t happen

1. During summer months the wireless charger does not work and heats up the phone to hazardous levels, when I take it to service while under warranty, they are saying its a known issue and want to charge customers for replacing charging pad 2. The suspension of the car is making sounds, Tesla wants me to pay labor charges for fixing it under warranty. The suspension issue happened in almost all the Tesla cars of my friends and neighbors.it needs to be a recall

On August 7th, 2025 at around 8 AM in the morning, my vehicles mobile phone car key was in-operable and I was unable to get in the car which led me to trouble shoot how to fix this issue with the car. Upon researching I was directed by Tesla to directly complete a soft reset of the vehicle holding down both buttons on the vehicle once I was inside, and pushing on the brake pedal. Upon completion, my vehicle booted up and I realized that all camera systems were down, my navigation systems were down, my safety features were down, my auto pilot, lane keeping assist and auto brake were down, sensors were down and I was no longer able to pre heat my battery to charge my vehicle due to issues with the navigation. I then took the vehicle to Tesla Service Center Irvine where a service advisor quoted...

The contact owns a 2023 Tesla Model 3. The contact stated that upon starting the vehicle and shifting to drive(D), the front trunk opened inadvertently, blocking the visibility of the roadway. The contact stated that the failure had recurred several times upon shifting to drive(D), which required the contact to exit the vehicle and manually close the trunk. The vehicle was taken to a Tesla service center and to Tesla Service Sunnyvale(680 E El Camino Real, Sunnyvale, CA 94087), where unknown repairs were performed several times; however, the failure persisted. Additionally, the contact stated that while attempting to reverse out of the garage, the contact was unaware that the garage door was closed, and the vehicle hit the garage door. The contact did not recall whether the rearview camera activated; however, the contact stated that the rearview camera pedestrian warning alert failed to engage prior to the incident. The contact...

The contact's daughter owned a 2023 Tesla Model 3. The contact stated that while driving during rain at 60 MPH, the contact lost control of the vehicle as the vehicle spun in a circle at hit a highway wall barrier. The barrier wall was damaged as a result of the accident, and the contact was given a bill for $3,222.15. The air bags deployed upon impact. The contact did not seek medical attention but suffered from both back and head pains. A police report was filed. Due to the accident, the vehicle was towed to an independent mechanic, where the vehicle remained in their possession. The contact wrote a letter to the manufacturer about the failure, but had yet to receive a response. The vehicle was deemed a total loss as a result of the accident. The failure mileage was approximately 50,000.

Rear seat safety restraint system fault

Documenting a sudden unintended acceleration experience. Today while driving and trying to stop for a red light, I lightly applied pressure on my brake pedal to brake for the red light. Midway through the braking, my car lunged forward for about half a second. Went through the dash cam footage, and I noticed that the footage skipped half a second as well. Seems like something electrical that caused the car to lunge. This is a huge safety issue.

I charged a 2021 Apple Macbook Pro with factory charging cable from the front USB-C charging port in a 2023 Tesla Model 3. The laptop charged up to around 70% but ended prematurely due to a melted charging cable and usb-c port (the connections from the usb-c port that the cable plugs into, and the part of the cable itself (male end) was melted and so hot that it burned my finger. I brought it to Tesla Service and they said it's not covered under warranty and are charging $377 + tax to replace it. The manual does not state any limitations as to what can/cannot be connected to the usb-c port. This issue has also been reported on Reddit: [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Any time I get into the car and immediately start driving before the car has time to catch up with what I am doing, the NHTSA mandated safety sounds played when the car is in reverse or drive does not play until the cars computer can catch up and begin playing the sounds. Most times this can take 3 seconds or so but today I had an incident where it took over 30 seconds before it would start playing. The same issue can be detected when restarting the infotainment screen by holding down both scroll wheels on the steering wheel. When doing this the car will cease playing the sound for around 5 seconds while the computer reboots.

If a Tesla software update fails it causes an APB version mismatch causing all safety features to become disabled until you schedule service for repairs. It is not covered outside of warranty even though it’s an issue caused by their update. If you google APB Version Mismatch, a lot of people have experienced it. Out of warranty repair is $2-3k for a computer replacement even though it was working fine before the update.

Component or System Failed: The critical safety issue involves Tesla's door locking system, specifically the lack of a readily accessible and obvious manual door release in the rear seat. This design flaw could prevent any child or passenger from knowing how to open the door or escape in an emergency. Safety Risk: The absence of a clearly identifiable manual release mechanism for the rear doors creates a severe safety risk. In an emergency, such as a power failure or accident, a child or any rear-seat passenger may be trapped without an obvious way to exit, increasing the potential for injury or death. This is particularly concerning given two prior instances where the battery failed to charge, leaving the vehicle completely without power even while connected to a charger. Reproduction and Confirmation: Tesla refuses to address the issue, This is a critical fire hazard. Inspections Conducted: The vehicle has been inspected...

The contact owns a 2023 Tesla Model 3. The contact stated that while driving at an undisclosed speed, an alert chimed for several seconds before the infotainment screen went blank. The contact stated that the vehicle lost motive power, the A/C became inoperable, the windows failed to roll down, and the doors failed to open as needed. The contact attempted to reboot the vehicle, but the vehicle failed to respond immediately. The contact was very concerned about her and her grandson's safety while the vehicle was inoperable. The contact and her grandson were unable to exit the vehicle immediately in hot weather. Moments later, the vehicle inadvertently rebooted, and the contact was able to drive to the residence, where she and her grandson exited through the front driver's door. Upon checking the Tesla app, four error codes were displayed: VCFRONT_a592, VCFRONT_a191, DI_a174, and DI_a183. The dealer was made aware of...

after heavy rain and some driving the Horn was not audible. wrong way driver almost hit me and the horn was useless to alert them

The contact owns a 2023 Tesla Model 3. The contact received notification of NHTSA Campaign Number: 23V838000 (Electrical System) however, the instructions to do the recall repair were not accurate. While using the Tesla App, the Software version failed to display. The local dealer was not contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue and confirmed that the instructions were not accurate to do the recall repair. The contact had not experienced a failure. VIN tool shows no open recall.

The car went forward when in reverse mode. After going to other modes (drive/neutral/park) and back to reverse, the car kept going forward. Reset the system and the issue persisted. Finally resolved after third restart. The car bumped up against the driveway gate because it wouldn’t reverse despite the dashboard clearly indicating being in reverse. Contacted Tesla, who examined the system remotely and said no issue was identified. This was the second time this issue occurred, and Tesla offered no fix.

Unintended acceleration after I tried to park take off before I can parked it violently crash into the wall.

Went to tesla service and they told me its a 3rd party issue about the rear tint. The defroster was to hot for the tint to burn. I was worried about the tesla could cause fire because of the electrical heating element that could cause it.

I turned into a parking lot across a gutter filled with ice from a snow plow and drug a block of ice under the car about 50 feet. When I stopped there was a blue fluid leaking out from under the car. I had the car towed to a collision repair shop. Estimated cost to repair $21,591.79. Damage seems excessive for a low speed collision.

I was driving my daughter to school on the freeway when we heard a loud bang toward the back of the vehicle and the vehicle alarms started going off. It said the car was powering down and would not restart. The car immediately reduced speed from 65 to 35 mph and I had to maneuver across 4 lanes of rush hour traffic to safely park on the side of the freeway. Thankfully this did not cause a collision but we were lucky. Even though the car was charged at 55% within 10 minutes the car was completely dead and powered off. I was able to take a picture of some of the error messages on the screen quickly before it died. VCFRONT a191 Electrical system power reduced vehicle shutting down, VCFRONT 192 Electrical System is unable to support all features switching off features to conserve energy, BMSa 059 Vehicle May...

Once the main battery dies the 12 volt dies within 15 minutes. I ran out of charge on a dark highway. Put on my flashers and within 15 minutes the 12 volt died and so did my emergency flashers. Reason being is Tesla uses the 12 volt for the main battery temperature mgmt which draws a lot of power. So in turn once your main battery dies your emergency flashers only have 10-15 minutes of use This is very dangerous especially being disabled on the side of the road

The contact owns a 2023 Tesla Model 3. The contact stated after leaving the dealer for a previous issue with a locked steering wheel, the contact was driving 50 mph on an entrance ramp as he accelerated to merge onto the highway, the steering wheel seized to the right in non-autopilot mode causing the contact to crash into the guardrail on the right side. The contact injured his neck and received medical attention. The emergency respondent was not called, but the contact obtained a police report. The vehicle was towed to the dealer but remains unrepaired, and needed engineers' diagnosis and legal investigation by Tesla. The contact received notification of NHTSA Campaign Number: 23V838000 (Electrical System). The manufacturer was made aware of the failure. The failure mileage was approximately 1,798.

I am writing to express my deep concern regarding the recent rear drive unit internal part failure in my new Tesla Model 3. The incident has left me fearful that this issue may occur again, and I am genuinely worried for my safety. I implore you and all the employees at Tesla to be honest and transparent about this defect or failure. The gravity of the situation became apparent when I realized how fortunate I was that the car did not come to a halt on the train tracks. The potential consequences could have been catastrophic, not only for myself but also for the passengers on the train. It is alarming to think that such a dangerous situation could arise in a vehicle that is merely five months old. This level of negligence is unacceptable. The rear drive unit failed and the car stopped. I was instructed to reset. I...

vehicle auto stopped in the middle of the parkway

I was reducing my speed as I approached a stoplight, and my vehicle rapidly and aggressively increased in speed. It made a revving sound and lurched forward, causing me to rear-end a truck. There is no possible way that this was human error and it was terrifying. The person who I rear ended mentioned that the impact felt like a double impact, as if I was continuing to accelerate after he was hit. I have requested the data from the accident time period from Tesla. An insurance representative is organizing an inspection. This was the second incident where the vehicle lurched forward on it's own. The first one happened about six months prior when I was at a complete stop. It did not cause an accident but it did frighten me into an audible scream. I did not report it because after some basic information gathering, I decided that it...

The Driver Assistance System fails. Specifically, the cruse control, parking assistance, blind spot monitor, display of other objects, lane identification, stop sign or traffic light recognition and other safety features fail repeatedly.

I was coming to a stop due to a train passing by. As I got closer to the other vehicles that were waiting for the train, I let go of the acceleration and then the vehicle on its own launched forward rear ending the car in front of me.

My daughter was driving on a freeway at 70MPH and her 2023 Model 3 Tesla that was a week old with 450 miles just stopped on the highway. She was lucky that highway patrol passed by shortly and stopped behind her to push her vehicle fully into the emergency lane. Vehicle also difficult to push because of brake locking system. I can't emphasis enough that the vehicle just stopped on the freeway!!!!

The contact owns a 2023 Tesla Model 3. The contact stated that while driving at an undisclosed speed with the cruise control activated, the vehicle experienced phantom braking. The contact stated that there were no objects or other vehicles nearby when the failure occurred. The vehicle seemed to return to normal functionality, but the failure recurred a second time. No warning lights were illuminated. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was notified of the failure, and a case was opened. The failure mileage was 7,200.

On August 5, 2023, my car charge got too low for me to make it to a charging station in Lafayette Louisiana. I had the vehicle towed on a flat bed. I put the car in Tow Transportation mode. While we were towing the car, I opened the car to check the battery level and somehow the frunk was activated (perhaps I accidentally hit it, I'm not sure). The frunk opened while we were going about 60 mph down the highway, the wind lifted the trunk up and it crushed my front windshield and the frunk and opening mechanics were damaged. Had we not immediately pulled over the frunk hood could have been ripped off the car by the wind and caused a major accident. This seems to be a flaw in the Tesla electronics/app system - you should not be able to open the Frunk once it is put...

The battery range is showing on the computer and tesla website as 272 miles but real driving range is 150-160 miles. The car is in service right now for that issue. Service probably will say it depends on driving conditions, there is no problem with the batteries but it does not explain 50% lose of usage. This is the biggest scam of human history. I am very disappointed due to 50% lower range then what it is supposed to be. There are thousands of people complaining with this issue. This is basically a scam that tesla is doing. If i knew that the actual drivimg range is around at most 200 miles i would not buy the car. I am scammed by tesla.

soon after purchasing the vehicle (mile 43) while driving, the propulsion system failed completely and the screen instructed me to pull over but I could only drift as, again, pressing the gas pedal did nothing. This was a very dangerous incident and one that makes me fearful of putting my family back in the vehicle. I have repeatedly asked to speak with anyone at tesla about this issue but have had no email or phone calls returned or been given phone numbers that do not work. I received a message today that i am required to take back possession of the "repaired" car or be charged 100 dollar per day fee to keep their loaner. I do not wish to be behind the wheel when the other manufacturing defects are discovered but Tesla has given me no alternatives. A quick online survey of online forums indicates this is a recurring...

Car was purchased on Tuesday June 13th, on Wednesday June 14th with 50 miles on clock travelling down the centre lane of a Texas highway the vehicle presented a warning that it was powering down and to get off the road. The car slowed down due to the regen breaks 60-0 in just a few seconds resulting in a near miss pile up. When the Tesla tow truck arrived the driver advised that this was not the first time he has seen this issue. The error codes i managed to gather from the vehicle were as follows: DIR_a126, DIR_a137, DIR_a063, BMS_a170 (coolant and rear drive unit issues) The consumer is requesting help with his vehicle. If you require further information please let me know, this nearly caused a serious incident on an extremely busy highway.

Software Version: 2023.12.10 Over the past month, I have experienced a recurring problem with my vehicle's auditory notification system. The issue first began a couple of software updates ago and has persisted through the most recent update. The problem manifests sporadically, having occurred three times within the past month. When this issue arises, all system sounds, excluding radio and media, cease to function for the duration of my ride and persist across all future rides until the vehicle is hard rebooted. There are no visible warning signs or error messages on the dashboard to indicate that the system sounds are malfunctioning. Proof of issue - https://youtube.com/shorts/VbDErQVVzp4?feature=share The malfunctioning system sounds include but are not limited to: 1. Forward Collision Warning Sounds 2. Seatbelt Warning Sounds 3. Blinker Indicator Sounds 4. EV Reverse Sounds 5. System Notifications 6. All alerts and warnings Attempts to Resolve the Issue: To temporarily rectify the...

While crossing the rump and side walk to garage the car, as usual slowly proceed to enter the Garage but immediately the car went into extremely fast speed by itself and hit the side of the Garage, damaged the Garage wall, The garage opener, the cabinet, then hit the water softener and our other car in the front. It also smashed the bike against the wall , damaged the side wall cause a bulge to outside of the structure. The garage frame and right side of the Garage door fell on top of the car almost killed our daughter who was at the front passenger seat. The car brake did not stop the car, the alarm did not go off, the air bags did no inflate.

After backing out of a parking place I could not switch into "drive". The car froze and had to be put into "tow mode" to be pushed aside and later taken to a dealer. Before being collected the car was partially blocking a car park, but there was no other safety risk. Warnings appeared when the event occurred, but not prior to. The rear drive unit was replaced under warranty.

This model has misleading user manual about park assist chime button, park assist front camera on button. Apparently they have removed the ultrasonic sensor and did not enable any user interface to do with Park assist in the control menu. This is misleading safety feature and total lie to the customer. Please flag this as a safety flag so the user will be aware of it. There is no option for the user to enable the front camera for whatever the little useful it can offer. They need to immediately send us the software update to view any camera at will.

I was driving a turn on a major intersection Stirling and I-95 Holly wood Florida to the on ramp to enter I-95 southbound when my car began shaking violently during the turn and completely shut down. The car was dead and I could not go forward or reverse. The center information panel was still lit up but the car would not move in any direction. I was blocking two lanes of the major intersection for about an hour till 2 Road Rangers arrived and dragged my car off the road. If I had made it around the turn and this catastrophic shut down occurred when I was on I-95 I could have experience severe injury or loss of life if I was struck by traffic on the highway. The car was brand new with 108 miles on it at the time. I purchased the car on 11/20/22 and the shutdown...