2022 RAM 3500 Power Train Problems

I have had the seal between the transmission and transfer case replaced 3 times due to leaking since new and after each repair within miles of each repair and all prior to the vehicle reaching 50,000 miles. The last time it was repaired at 65,000 miles they decided to replace the transmission with a new transmission - it also leaked between the transmission and transfer case within 1 day and less than 100 miles.

***1*** The emissions system on this truck (2022 Ram 3500 with 34,435 miles) has been problematic since I acquired it 5 months ago. It continually attempts to regenerate and rid itself of ash/soot buildup. If it does not successfully regenerate, it will go into a state of reduced power, also known as limp mode. The truck is available for inspection and will be at Lithia CDJR in Corpus Christi tomorrow, 07 Jan 2026. ***2*** Today specifically, the truck flashed a message EXHAUST FILTER NEARING FULL SAFELY DRIVE AT CONSISTENT SPEED TO CLEAR. I got on the highway to achieve this and avoid lights and stop/go traffic. It typically takes around 25 minutes of consistent driving for it to clear. But today, shortly after I reached highway speeds, the truck entered limp mode, displaying EXHAUST FILTER FULL REDUCED POWER SEE DEALER. This was a very alarming incident that created a bottleneck...

My pm sensors or particulate matter system malfunction and failed which lead to emissions issues and created my vehicle to drive in limp mode. Limp mode basically slowed downs the vehicle is slow as 5 mph as soon as this light displays at any time while driving on the highway. This put my safety in danger and the public as I transport what dot considers a type hazardous material. The sudden loss of power in the middle of the road has made vehicles around me extremely vulnerable to fatal collisions. I took my vehicle to the dealership where they confirmed this malfunction and problem with my vehicle but no recall has been issued as of yet no warning lamps appeared prior to the failure.

While driving on interstate leaving a construction zone started to accelerate to maybe 40mph and heard/felt a hard clang and lost all forward motion costed to side of interstate. Looked underneath truck, nothing visible broken or leaking. Restarted truck tried to move forward with no luck. Reverse worked, put back in drive loud noise again stomped on the accelerator and started moving forward very slow and difficult. Made it to an exit to look at things in a safer location than the busy interstate. Figured out that I had reverse and 5th gear so it was very hard/ slow to get moving. Check engine light on, gear ration incorrect, code P0731, Tran sensor failure, no 4x4 Transmission failure 1-4 gears not working

The transmission in my vehicle failed suddenly on May 31, 2025, entering “limp mode” and losing the ability to shift properly. The vehicle became immobile and was towed to the dealership. Initial diagnostics revealed difficulty shifting between 3rd and 4th gears. Service technicians attempted repair in June based on RAM TSB MC-10231775, which indicated snap ring failure in the Aisin transmission. Repairs prescribed in TSB were attempted but unsuccessful, as the vehicle still could not shift into 4th gear. Additional parts were ordered, and another repair was unsuccessfully attempted in late June. Ram has shipped a new transmission which we are waiting on the dealership to install.

Transmission failure while driving not allowing to go in park after we got stopped. Truck un operable to get out of traffic.

Transmission failed in heavy interstate traffic while towing 35 ft 15,000 lbs RV. My RAM 3500 only has 19,000 miles and is still under new vehicle warranty. The event: While travelling on Washington DC beltway in lane 3 of 4 without warning my transmission starting slipping. No abnormal noise, no dash lamps warning of an issue. As I pressed on accelerator my speed continued to decrease. I quickly signaled to right lane in an attempt to get off the road. I was slowing at a rate I was concerned I may be stopped on highway with vehicles traveling 55 mph approaching. I did make the shoulder in between an exit and entrance ramp with barely enough room for a tow truck to be in front. I had 3 ft on my left with 55mph traffic passing constantly. The vehicle was towed to a local RAM dealer as my wife and...

The contact owns a 2022 Ram 3500. The contact received notifications of NHTSA Campaign Numbers: 22V835000 (Power Train) and 23V060000 (Electrical System); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The contact had not experienced a failure. Parts distribution disconnect.

While driving around 20 mph, suddenly heard a clunk, then several dashboard warning lights came on. Truck suddenly had no torque- would only move forward if the engine was revved at much more than normal amount. Nearly complete loss of ability to accelerate from a stop/low speeds. Took to an independent service center who ran the ODB codes, showing the now well-known issue of "transmission failure gears 1-4" Warning lamps include the lane sense and check engine lights, and a message on the dash that reads ACC not available, Automatic high beams not available. Prior to this, no problems with the truck at all. I am trying to arrange getting it towed to a dealership.

22 Ram 3500 Cummins diesel with Aisin transmission. Transmission output shaft seal leaking in between transmission and transfer case.

The engine stopped while driving with no warning and provided no opportunity to exit the travel lane of the road. No warning lights were illuminated on the dashboard and all gauges appeared normal leading up to the event. This event is extremely frustrating, but I am thankful that it didn't happen on the interstate as there is no telling what the outcome may have been......... Leading up to the event, I had been driving on the interstate around 70mph for about 180 miles since the last restart. I exited the interstate and made it about 3/4 miles on a secondary road and the engine died without warning and the truck came to a quick stop in the lane of travel. No abnormal sounds were observed, just a sudden unwelcome deacceleration that did not provide enough time to exit the lane of travel. It was like stepping on the brakes. I...

My truck experienced a total transmission failure while at Highway Speed towing a 5th wheel camper on Interstate I95. This transmission failure is a known issue and has a TSB 21-002-23. A k1 clutch clip becomes dislodged and the transmission will not function. Being stranded and unable to move on a busy highway is unsafe and terrifying. Aisin Transmission and RAM are well aware of this failure however I was never notified about the potential failure nor has a recall been issued. The failure occurred instantly with no warning in a vehicle with 16,000 miles and less than 2 years old. My vehicle has been repaired and the failure was confirmed as the K1 clutch clip failure. There should be an immediate recall for this known failure to be repaired prior to being stranded on the side of the highway, 400 miles from home with my wife and kids. It's...

The transmission wont shift gears. We were stranded at a campsite. The problem has been confirmed by Santa Rosa Ram. Inspection by RAM directly is unknown. Loud clanking noises were heard many days before the final failure.

While towing a camper 5 hours from home. Traveling approx 5-10 MPH in slow moving traffic the 2022 Ram 3500 HO with Aisin Transmission made a loud and sudden pop. It lost all forward power as if it went into neutral. Barely using momentum to limp the truck off the side of a busy highway during rush hour with my family on board.

Transmission had 2 loud clunk, while stopped, and shifting into drive, lost all forward gears. Reverse works. Truck has 17000 miles.

On June 5th, 2024 while pulling a travel trailer on vacation, we stopped for a short break and left the truck running. When we went to get back on the highway, I put the truck in gear and nothing happened. Truck would only shift into reverse with a violent bang. Would not go forward. Unhooked my trailer and shifted into REVERSE a few times and finally got the truck to inch forward at HIGH RPM. Towed to a Ram dealer and they confirmed a snap ring failure caused the forward clutches to go out. Truck is still awaiting repairs 445 miles from home.

I was driving coming to a stop for a red light and it turns green. As I go to press on the gas my dashboard lights up with error codes stating a 4WD System error of some kind. As I go to press on the gas the truck loses power and acceleration and starts making a horrible clunking noise. I took it to the dealer because it seems like a transmission issue. This is a 2022 Ram 3500 with 9300 miles at time of failure. I would hate to see what happens if I was towing a large load to lose power all of a sudden risking my life and others around me. Based on what I have researched it seems like a K1 Snap Ring issue to the T. Waiting on the "official" diagnosis from the dealer.

When pulling onto the interstate on ramp (45 mph) the truck attempted to shift up when all transmission power failed. The engine ran fine, just no power. I was able to safely pull to the shoulder and park . s Shifting from drive to neutral to park and back to drive still did not resolve the issue. I put the truck in park and shut off the engine . The transmission fluid temp, color and level was ok. I restarted the truck and shifted to reverse with no problem then to neutral and drive. It felt that the transmission engaged and I slowly crept forward. I slowly accelerated and was able to resume speed. No subsequent loss of power has been encountered, BUT the truck now has slippage from 1st to 2nd gear and occasionally 3rd. Had I been on the interstate this has a potential for serious accident incident....

My truck experienced the K1 snap ring failure at 3,600 miles.

This vehicle left me stranded due to Aisen transmission failure with only 2000 miles on the vehicle. Has been at dealer for 3 months awaiting rebuild due to faulty clip. Why is nothing being done? Why am I not getting a new transmission? or better yet forced buy back

Transmission went out. Lost 1-4th gear. It was the K1 snap ring in the transmission. Lost power going up a mountain in a National Park exhaust brake either to slow vehicle. Check engine light came on

The dealer and manufacture have not been able to fix emissions issue. It has cause severe fuel saturation in oil and has cause severe motor damage. No one cares and they brush it off as no big deal.

K1 Clutch Snap Ring failure in the AS69RC Aisin transmission. I loss all forward motion on [XXX] in Iowa City. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My trucks transmission experienced a complete failure, it is currently at the dealership awaiting parts and repair The failure renders the truck without any forward power almost immediately with only reverse left functioning, we were fortunate that it broke down in a residential neighborhood and not the freeway. The truck was towed to the local dealership, they tore down the transmission and confirmed a K1 snap ring failure and that it would be covered under wtty. I got a malfunction indicator light a few days prior then a message on the dash "4 wheel drive system temporarily unavailable" about 10 miles before complete failure. CSN 71A appears to have been issued and sent to some truck owners to advise snap ring replacement as a preventative measure, however my truck was not included in the CSN campaign, not sure why

Concerned that my truck may be affected by the Aisin K1 snap ring failure problem currently being investigated by NHTSA. I have no way of knowing whether or not my transmission is reliable long term, nor can I prove to a future buyer that it is safe and reliable. Not only does this issue affect my trust in using the truck, but it also has a significant negative impact on the resale value of the truck. Buyers are aware that 2022 Aisin trucks have issues and this makes the vehicle harder to sell.

I am very concerned that my trucks Aisin transmission may fail while towing heavy loads at highway speeds as this seems to be an issue with my model year and month it was built.

1, The Aisin AS68RC transmission failed. The dealership had to ship the defective complete back to Aisin . 2. On [XXX] with only 2,886K miles while on Interstate [XXX] in Boston Massachusetts . I just entered the highway and was getting into the middle lane getting up to high way speed. The Tachometer shot up in rpm’s and there was no more forward gear. I was doing about 50-60mph. I had to cost from the middle lane to the brake down lane with my 20’ trailer in tow in heavy traffic. Once in the brake down lane I was able to go in reverse but couldn’t go forward. Loud clunking when put into gear and trying to move forward. 3. The vehicle was towed to the dealership from [XXX] that night to Herb Chambers Millbury Ram and confirmed transmission failure. 4. Aisin sent a complete transmission assembly to the dealership...

Driving south on [XXX] just south of Greenville, SC. With no warning the truck wouldn't go, upon quickly diagnosing I determined I had no transmission. Luckily was able to make it to the emergency lane and come to a safe stop. Also was pulling a fifth wheel camper at the time. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Sudden loss of forward gears. Failure happened on highway at highway speeds. Had to carefully maneuver the truck off the road. Failure in both towing and unloaded operation. Truck will not shift in or out of drive (1-4) but reverse is still functional. Diagnostic trouble code P0731-00 and P0734 "Gear 1 and 4 Shift Incorrect Ratio". Both the dealer and RAM confirm this transmission failure. RAM has realeased a TSB which covers this failure but hasn’t released a recall.

February 19,2024. Towing a bumper pull toy hauler approximately 10,000 pounds, just merged onto a two lane highway when the check engine light came on and truck jerked a couple times, I pulled to side of highway where there is not much of a shoulder. I placed it in park, sat a few seconds then into drive when I noticed no forward motion in drive. I turned truck off a few minutes, restarted, check engine light still on, no movement in drive mode. I did have reverse functioning. This was very dangerous situation, high speed two lane highway, small shoulder, many large RVs and 18 wheeler trucks flying by. 5 weeks truck is at dealer, they say it’s done, they attempt to bring it to me at the shop, then tell me check engine light on, throwing multiple codes. They still have truck, tell me they will find out issue...

The contact owns a 2022 Ram 3500. The contact stated while driving 30 MPH and towing an RV, the vehicle inadvertently lost motive power. The contact was able to pull to the shoulder of the roadway, where the failure persisted, after which the contact became aware that the vehicle was only able to shift into reverse. The check engine warning light was illuminated. The vehicle was towed to the dealer, who diagnosed a failure with the transmission. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired due to parts not being available. The manufacturer was notified of the failure, a case was opened, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was 17,000.

On [XXX] I was driving my newly purchased 2022 Ram 3500 on [XXX] near Mead, CO when my check engine light illuminated and I immediately lost forward driving gears. I was able to coast safely to the side of the highway. I purchased this truck new on [XXX] from Perkins Motors in Colorado Springs. After stopping on the side of [XXX], I attempted to continue forward but had no power. I placed the truck in reverse and felt a sudden jerk. I then placed the truck in park and shut it off. The truck had 1,043 miles on the odometer when the transmission failed. I waited on the side of the highway for 15 hours to be towed 110 miles to the Ram dealership closest to my home. My truck spent 5 weeks at the dealership waiting on parts. Colorado Springs Ram service department informed me that the snap ring...

My vehicle was affected by the Customer Satisfaction Notice 71A: Aisin K1 Snap Ring Failure. I saw an article that an investigation was being opened into this issue. I can provide data from my experience if it is helpful.

Truck lost all forward gears while driving down the highway, only had 6418 miles on it

The contact owns a 2022 Ram 3500. The contact stated that while driving at various speeds, the transmission suddenly downshifted, causing the vehicle to decelerate abruptly. Additionally, while driving the vehicle, the engine temperature gauge increased to high, with a burning plastic odor and smoke fumes entering the cabin of the vehicle. The vehicle was taken to the local dealer and the PCM was reprogrammed, and the temperature sensor was replaced; however, the failure persisted. The manufacturer was notified of the failure. The failure mileage was 32,000.

Aisin Transmission Failure at 10,462 miles. Date of failure 09/09/2023. No warning lights, messages or other symptoms Vehicle was towed to Dealership on 09/12/2023 Failure confirmed by Champion Dodge, 907 S Clinton Street, Athens, AL 35611 / 8002395692

The contact owns a 2022 Ram 3500. The contact received notifications of NHTSA Campaign Numbers: 22V835000 (Power Train) and 23V060000 (Electrical System) however, the parts to do the recall repairs were not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repairs. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was not made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

I was traveling in my new 3 month old 3500 Ram with, at the time of failure, 3000 miles on the odometer. Starting from a standstill on level ground. I lost all forward momentum. I lost forward gears 1-4 due to what is now known as the K1 clutch snap ring failure. I was traveling cross country and had to leave my truck at a dealership over 1000 miles from home. ruined vacation and had to catch a flight back home . It took 6 months to get my truck back.

Driving vehicle and lost power went into limp mode had no gears forward Truck would not go over 1500 rpm Check engine light came on Kept saying 4 wheel drive not available but was in 2 wheel drive Hear clunk when shifting but no gears respond! Occurred when driving definitely a safety issue

-What component or system failed or malfunctioned, and is it available for inspection upon request? A: Transmission -How was your safety or the safety of others put at risk? A: I was never contacted by RAM regarding the possibility of a catastrophic power loss c/o transmission failure for my RAM truck. While driving E/B on Interstate 15 in the # 2 lane at highway speeds and going up a grade, the vehicle suffered complete forward momentum loss and only engine revving was occurring, while losing forward momentum & speed. I had to negotiate several, extremely busy/heavy traffic tractor-trailer filled traffic lanes to make it to the emergency shoulder of the roadway before losing all forward momentum and miraculously did not have a collision with high-speed heavy traffic. -Has the problem been reproduced or confirmed by a dealer or independent service center? A: I took my RAM to a nearby dealership....

My Ram 2022 3500 truck has18,888 miles and the transmission has to be replaced. I had it in for a recall and asked them to check the transmission for shifting issues. I was informed that the transmission needed to be replaced. I pull a 38 foot Fifth Wheel approximately 15 thousand pounds. If the transmission would have failed on the road it could be catastrophic. Dodge is replacing the transmission with the same one with no fix for the problem that inherently causes the failure which has been many. The repair order# is 459891. The part # is R8447797AA. I was given a case # by Ram Care 87401824. I feel stuck spending 100K for a new truck and don’t feel safe putting back on the road risking the safety of my family and others. I have previously had a Commercial Drivers License and have driven trucks for over 40...

Received a recall from FCA regarding exhaust module and sensor not installed. They offered a 12 month warranty. But damage to diesel exhaust filter has already happened. Owners should be given a lifetime warranty. This was an expensive truck and a replacement filter is $8,000 which I will be on hook for after my warranty is over. Recall Y43

Transmission failed. 8,500 miles on the truck

The contact owns a 2022 Ram 3500. The contact stated while driving 10 MPH and depressing the accelerator pedal, the vehicle failed to respond. The contact stated that the gear shifter was in drive (D); however, the vehicle operated as if the transmission was in neutral (N). The check engine warning light was illuminated. The contact was able to veer to the side of the road after persistently depressing the accelerator pedal. The contact stated that the transmission was stuck in fifth gear. The vehicle was towed to the residence. The local dealer was notified of the failure. The vehicle was not diagnosed nor repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 1,945.

Transmission went out, under 20k miles. The dealership has had the vehicle for over two months and they are still waiting for parts.

I am a commercial driver for Hibbs Haulers and was driving the 2022 Ram 3500 DRW 4X4 company truck. Production month was September 2022. After driving at a slow speed in heavy traffic the truck felt like it fell out of drive and into neutral. I was able to move slowly but transmission temp started to climb into 220 plus degrees and a temperature warning came on for the transmission so I pulled onto the shoulder. I was able to use reverse but I did not have gears 1 through 4. A MIL code P0731 came on during this incident.

My transmission failed while driving in the mountains. I have reverse . And 5th gear. The check engine light came on and a message on the dash stated that the 4 wheel drive was temporarily not available. It has since been taken to the dealer . As it has failed .and is nolonger drivable

Total transmission failure resulting in sudden loss of forward gears. Cruise control and all other drivers assist aides disabled and loss of any forward acceleration while driving highway speeds. Unable to drive forward at all. Known manufacturer issue. No prior warning or indicator lights until total failure. Problem confirmed by dealer. Family endangered when truck traveling on multi lane highway at a speed limit of 70mph suddenly turned off cruise control and slowed to a halt with no ability to accelerate or move forward.

I have had two catastrophic failures of the Clutch Snap Ring that the first time left me and my children stranded on a highway 800 miles from home and took 31 days to repair. The second failure was while driving and almost caused me to be hit because of the sudden loss of power. This is a known failure that is reported in Service Bulletin (21-002-23) filed with the National Highway Traffic Safety Administration (NHTSA). The original dealer reported he had seen 3 cases of these failures and the second dealer has told me he has 4 trucks waiting for this repair. It is a major safety issue that is known but not being resolved.

Truck lost power and went into "limp" mode on Interstate 65 near Nashville on 7-28. warning came on stating 4wheel drive is unavailable even though it was not being used. It also stated the number 1 gear was miss aligned. this took place at 12:30 PM on a busy highway, a tow truck toed my pickup but had to leave my 2020 Montana camper on the side of the highway. The truck was taken to a dealer nearby that waited two weeks to look at it and identified the transmission had gone out, parts were 45 days backordered. two weeks later they called parts had come in, but they would not get to it for another week, 8-25-2021 The dealer calls after I posted complaints on their social medial sites and notified me, they could not locate the transmission fluid at this time it is backordered to 2024. I am...