1996 PLYMOUTH BREEZE — Problems, Recalls & Safety Data
N/A
Safety Rating
268
Owner Complaints
10
Recalls
4
Service Bulletins
0
Investigations
Overview of the 1996 PLYMOUTH BREEZE
The 1996 PLYMOUTH BREEZE has received a total of 268 safety complaints filed with the National Highway Traffic Safety Administration (NHTSA). There have been 10 recall campaigns affecting this vehicle, covering issues with SUSPENSION:FRONT:CONTROL ARM:LOWER ARM, SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT, FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP. 4 technical service bulletins have been issued by Chrysler (FCA US, LLC) for this model year. The most commonly reported problems involve the Engine And Engine Coolingengine (70 complaints), Engine And Engine Coolingenginegasoline (21 complaints), and Power Trainautomatic Transmission (19 complaints).
Recalls for the 1996 PLYMOUTH BREEZE
NHTSA has recorded 10 recalls for the 1996 PLYMOUTH BREEZE, potentially affecting up to 4,152,645 vehicles.
Recall 10E059000 — SUSPENSION:FRONT:CONTROL ARM:LOWER ARM
| 22,689 vehicles affected
Defect: FEDERAL-MOGUL IS RECALLING CERTAIN REPLACEMENT CONTROL ARM ASSEMBLIES, PART NUMBERS K7425, 10945, FA4510X, K7427, 10946, AND FA4611X, SOLD FOR USE ON VARIOUS PASSENGER VEHICLES LISTED ABOVE. THE BALL JOINT ON THE CONTROL ARM ASSEMBLY CAN FAIL CAUSING THE BALL STUD TO WEAR THROUGH THE CONTROL ARM HOUSING RESULTING IN NOISE AND/OR SEPARATION OF THE BALL STUD FROM THE HOUSING.
Consequence: IF THERE IS A SEPARATION OF THE BALL STUD FROM THE HOUSING, THE DRIVER CAN LOOSE STEERING CONTROL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: FEDERAL-MOGUL WILL NOTIFY OWNERS OF RECORD AND REPLACE THE AFFECTED CONTROL ARMS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 28, 2011. OWNERS MAY CONTACT FEDERAL-MOGUL AT 1-877-489-6659.
View full details →Recall 09E056000 — SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
| 5,787 vehicles affected
Defect: QUALIS AUTOMOTIVE IS RECALLING CERTAIN AFTERMARKET BALL JOINTS SOLD FOR USE ON CERTAIN PASSENGER VEHICLES. THE SOCKET MAY HAVE BEEN EXCESSIVELY HARDENED WHICH COULD CAUSE IT TO CRACK NEAR THE RETAINING RING GROOVE ALLOWING THE BALL STUD TO SEPARATE UNDER IMPACT LOAD. THE SUBJECT BALL JOINTS WERE SOLD AS FOUR PART NUMBERS, D10945, D10946, G10945, AND G10946. THE AFFECTED CONTROL...
Consequence: SEPARATION OF THE BALL STUD FROM THE SOCKET OF THE BALL JOINT HOUSING WOULD ALLOW THE CONTROL ARM TO COLLAPSE AND THE WHEEL TO FOLD IN CAUSING LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.
Remedy: QUALIS AUTOMOTIVE WILL REPLACE THE BALL JOINTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT QUALIS AUTOMOTIVE AT 1-800-493-4128.
View full details →Recall 06E091000 — FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
| 24,358 vehicles affected
Defect: CERTAIN AIRTEX FUEL PUMP MODULES, P/NOS. E7089M, E7094M, E7113M, AND E7129M, MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006. THESE FUEL PUMP MODULES WERE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL TO...
Consequence: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: AIRTEX WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 18, 2006. OWNERS MAY CONTACT AIRTEX TOLL-FREE AT 1-866-867-3759.
View full details →Recall 06E088000 — FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
| 39,243 vehicles affected
Defect: CERTAIN TIGAS FUEL PUMP MODULES MANUFACTURED BETWEEN JUNE 1 AND SEPTEMBER 24, 2006, SOLD UNDER VARIOUS BRAND NAMES AND P/NOS. THESE FUEL PUMP MODULES ARE SOLD AS AFTERMARKET FOR USE IN CERTAIN DAIMLERCHRYSLER VEHICLES LISTED ABOVE. SILICONE MATERIAL USED IN MANUFACTURE OF THE FLAPPER VALVE WAS OUT-OF-SPECIFICATION, LEADING TO EXCESS SWELL OF THE FLAPPER VALVE RESTRICTING THE FLOW OF FUEL...
Consequence: FUEL RESTRICTION COULD RESULT IN LOSS OF POWER AND/OR ENGINE STALL, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: TI AUTOMOTIVE WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE FUEL PUMP MODULES FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 6, 2006. OWNERS MAY CONTACT TI AUTOMOTIVE TOLL-FREE AT 1-877-461-1834.
View full details →Recall 04V021000 — POWER TRAIN:AUTOMATIC TRANSMISSION:LEVER AND LINKAGE:FLOOR SHIFT
| 2,315,768 vehicles affected
Defect: ON CERTAIN PASSENGER VEHICLES, THE FLOOR SHIFTER IGNITION-PARK INTERLOCK MAY FAIL AND ALLOW THE SHIFTER TO BE MOVED OUT OF THE PARK POSITION WITH THE KEY REMOVED. AN INOPERATIVE INTERLOCK MAY ALSO ALLOW THE KEY TO BE REMOVED WHEN THE SHIFTER HAS NOT BEEN PLACED IN THE PARK POSITION.
Consequence: EITHER CIRCUMSTANCE MAY RESULT IN THE VEHICLE ROLLING AWAY WITHOUT WARNING.
Remedy: DEALERS WILL INSTALL A NEW LOAD-LIMITING PUSH ROD INTO THE FLOOR SHIFTER LEVER OF THE AFFECTED VEHICLES. OWNER NOTIFICATION BEGAN ON JUNE 14, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
View full details →Recall 98V183000 — POWER TRAIN:AUTOMATIC TRANSMISSION:PARK/NEUTRAL START INTERLOCK SWITCH
| 685,000 vehicles affected
Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH AUTOMATIC TRANSMISSIONS. THE ADJUSTMENT OF THE CABLE CONNECTING THE CONSOLE SHIFTER MECHANISM TO THE IGNITION KEY CAN CAUSE A TRAPPED KEY CONDITION WHICH CAN RESULT IN A LOW FORCE REQUIRED TO DEPRESS THE SHIFT BUTTON. A COMBINATION OF APPLYING A MIS-ADJUSTED RELEASE BUTTON WITH A LOW FORCE ATTEMPT TO SHIFT OUT OF PARK WITH...
Consequence: IF THIS HAPPENS, THE "IGNITION-PARK" INTERLOCK SYSTEM WILL BE NONFUNCTIONAL.
Remedy: DEALERS WILL INSPECT FOR PROPER OPERATION OF THE SYSTEM. ANY VEHICLES THAT ARE NOT FUNCTIONAL AFTER THE INSPECTION WILL HAVE THE SHIFT MECHANISM AND CABLE REPLACED WITH A "SELF-ADJUSTING" DESIGN.
View full details →Recall 97V201000 — SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT
| 599,000 vehicles affected
Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE LOWER CONTROL ARM BALL JOINT CAN SEPARATE DUE TO LOSS OF LUBRICATION.
Consequence: SEPARATION OF THE BALL JOINT COULD CAUSE A LOSS OF STEERING CONTROL INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT THE BALL JOINT END HOUSING COVER SEAL FOR LEAKAGE WITH A HIGH PRESSURE AIR TESTER AND THE RUBBER BOOT WILL BE VISUALLY INSPECTED FOR DAMAGE. IF THE COVER SEAL LEAKS OR THE BOOT IS DAMAGED, THE LOWER...
View full details →Recall 97V095000 — STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS
| 219,000 vehicles affected
Defect: VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SECONDARY HOOD LATCH SPRING CAN DISENGAGE FROM ITS RETENTION HOLE IF THE HOOD IS SLAMMED SHUT.
Consequence: IF THIS CONDITION OCCURS SIMULTANEOUSLY WITHOUT ENGAGING THE PRIMARY LATCH, THE HOOD WOULD NOT BE RESTRAINED INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE SECONDARY HOOD LATCH SPRING WITH A LONGER END HOOK SPRING.
View full details →Recall 96V074000 — SERVICE BRAKES, HYDRAULIC:ANTILOCK/TRACTION CONTROL/ELECTRONIC LIMITED SLIP
| 90,000 vehicles affected
Defect: CORROSION OF THE ABS HYDRAULIC CONTROL UNIT CAN CAUSE THE SOLENOID VALVES TO STICK IN THE OPEN POSITION.
Consequence: IF EITHER FRONT WHEEL VALVE STICKS, THE VEHICLE WOULD SWERVE FROM A STRAIGHT STOP WHEN THE BRAKES ARE APPLIED.
Remedy: DEALERS WILL INSTALL A PLATE AND SILICONE GREASE INJECTED INTO THE SOLENOID CAVITY TO ELIMINATE THE POTENTIAL FOR THIS CONDITION.
View full details →Recall 96V075000 — SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER
| 151,800 vehicles affected
Defect: THE BRAKE MASTER CYLINDER CAN LEAK BRAKE FLUID DUE TO A DAMAGED DOUBLE LIP REAR PISTON SEAL.
Consequence: BRAKE FLUID LEAKAGE CAN RESULT IN DIMINISHED EFFECTIVENESS OF ONE HALF OF THE SPLIT BRAKE SYSTEM. THE INSTRUMENT PANEL WARNING LIGHT(S) WILL SIGNAL SYSTEM IMPAIRMENT PRIOR TO PARTIAL BRAKE SYSTEM LOSS.
Remedy: DEALERS WILL REPLACE THE REAR BRAKE MASTER CYLINDR PISTON ASSEMBLY.
View full details →Owner Complaints for the 1996 PLYMOUTH BREEZE
268 complaints have been filed with NHTSA for the 1996 PLYMOUTH BREEZE. Below is a breakdown by vehicle component.
Most Recent Complaints
1996 PLYMOUTH BREEZE HAD SOMETHING BREAK FROM THE VEHICLE. THE CONSUMER STATED THE VEHICLE STALLED AND CAUGHT FIRE AFTER COMING TO A REST ON THE SHOULDER. *KB THE CAUSE OF THE FIRE WAS UNDETERMINED. (OHIO TRAFFIC CRASH REPORT)*JB
I WAS COMING HOME ONE EVENING FROM TOWN, AND MY BRAKES FAILED TO STOP. THE BRAKE PEDAL WENT ALL THE WAY TO THE FLOORBOARD AND NEVER ONCE SLOWED ME DOWN AND I CRASHED INTO ANOTHER VEHICLE. IT WAS A PRETTY BAD WRECK AND LUCKILY NO ONE WAS SERIOUSLY INJURED. *JB
THE PLASTIC ADJUSTMENTS ON THE SEAT BELTS HAVE FALLEN OFF 2 OF THE SEAT BELTS, THEREFORE, I ASSUME, THEY ARE NO LONGER SAFE TO USE. *NM
APPROXIMATELY THREE WEEKS AGO, AFTER MAKING A LEFT TURN, I NOTICED THE STEERING WHEEL BECAME DIFFICULT TO TURN. THE PROBLEM WOULD DISAPPEAR AFTER BACKING UP. AND WAS NOT ALWAYS CONSISTENT. I BROUGHT IT INTO MY GARAGE WHO CHECKED THE BELTS AND FLUID. THEY REPORTED EVERYTHING WAS FINE. YESTERDAY (2/22) LEAVING WORK I WAS MAKING A LEFT TURN OUT OF THE PARKING LOT INTO THE EXIT LANE, AND LOST ALL STEERING ABILITY. ANOTHER EMPLOYEE STOPPED TO SEE IF I NEEDED HELP. WHEN I TOLD HIM I LOST THE STEERING AGAIN AND ASKED IF HE COULD LOOK. WHEN I OPENED MY DOOR TO GET OUT, FROM HIS HEIGHT HE COULD SEE SOMETHING STICKING OUT UNDERNEATH THE CLUTCH AREA. HE REACHED DOWN AND SAW THAT A CHUNK OF THE CLOTH MAT HAD BEEN SUCKED UP INTO THE STEERING COLUMN AT THE BASE OF THE FLOOR AND WAS WRAPPED FREEZING THE STEERING. IT TOOK HIM A WHILE, BUT HE WAS EVENTUALLY ABLE TO FREE IT. ALMOST THE ENTIRE, HEAVY CLOTH MAT WAS A GIANT BALL WRAPPED BY THE COLUMN. I WAS LUCKY THAT IT HAPPENED ON THE COMPANY CAMPUS ONLY MOVING A FEW MILES AN HOUR, AND NOT UP ON INTERSTATE 78 I TRAVEL EVERYDAY AT 55 MILES AN HOUR WHEN THE STEERING COMPLETELY FROZE. *JB
OIL NOTICED ON GROUND UNDER VEHICLE. MECHANIC SAYS HEAD GASKET IS LEAKING OIL OUT OF ENGINE. HEAD GASKET FAILURE IS CAUSING OIL TO BE LEAKED ONTO GROUND WHICH CAUSES ECOLOGICAL DAMAGE TO OUR ENVIRONMENT PER EPA. THIS WEB SITE DOCUMENTS THIS AS A TREND FOR THIS PLATFORM OF PLYMOUTH VEHICLE. THERE MUST BE TENS OF THOUSANDS OF GALLONS OF PETROLEUM OIL BEING SPILLED INTO OUR ENVIRONMENT BY THESE VEHICLES, MAYBE MORE. THESE VEHICLES ARE INJURING US ALL AND SHOULD NO LONGER BE USED UNLESS PROPERLY AND PERMANENTLY FIXED. *NM
Safety Rating for the 1996 PLYMOUTH BREEZE
NHTSA has not yet tested the 1996 PLYMOUTH BREEZE in its New Car Assessment Program.
Technical Service Bulletins for the 1996 PLYMOUTH BREEZE
Chrysler (FCA US, LLC) has issued 4 technical service bulletins (TSBs) for the 1996 PLYMOUTH BREEZE. TSBs are notices sent by manufacturers to their dealers describing a known issue and the recommended repair procedure.
7921/22 — POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM/PCM/TECM)
FEDERAL AND CALIFORNIA EMISSIONS RECALL ON REPROGRAMMING THE POWERTRAIN CONTROL MODULE. *TT
240898 — EQUIPMENT:APPLIANCE:AIR CONDITIONER
CONDITION WITH THE A/C SYSTEM PERFORMANCE. *YC
98700 — POWER TRAIN:MANUAL TRANSMISSION
VEHICLES EQUIPPED WITH A MANUAL TRANSMISSION. *YC
190496 — STEERING:RACK AND PINION
WHISTLE AND/OR HISS NOISE FROM STEERING GEAR WHEN MAKING RIGHT TURNS. *JD
NHTSA Investigations for the 1996 PLYMOUTH BREEZE
There are no NHTSA defect investigations on record for this vehicle.
Other Model Years of the PLYMOUTH BREEZE
- 1995 PLYMOUTH BREEZE — 0 complaints
- 1996 PLYMOUTH BREEZE (current)
- 1997 PLYMOUTH BREEZE — 203 complaints
- 1998 PLYMOUTH BREEZE — 201 complaints
- 1999 PLYMOUTH BREEZE — 153 complaints
- 2000 PLYMOUTH BREEZE — 42 complaints
Other PLYMOUTH Models
- PLYMOUTH VOYAGER — 6,848 total complaints
- PLYMOUTH GRAND VOYAGER — 3,388 total complaints
- PLYMOUTH NEON — 2,016 total complaints
- PLYMOUTH ACCLAIM — 538 total complaints
- PLYMOUTH SUNDANCE — 408 total complaints
- PLYMOUTH COLT — 157 total complaints
- PLYMOUTH LASER — 149 total complaints
- PLYMOUTH PROWLER — 69 total complaints