2021 NEWMAR DUTCH STAR — Problems, Recalls & Safety Data

Last week I had the air dryer filter replaced at Colton Truck Terminal in Colton Ca. Subsequently, I did the complete 7 step air brake system check and discovered that during total loss of air pressure , the emergency brakes would not auto apply. I replaced the dash hand valve and the problem still persists, so I installed the original valve and took the coach back to Colton Truck Terminal to diagnose the problem. Attached is the paper work from Colton Truck Terminal diagnosing the issue and the correction of that issue. Also on that paperwork is the vehicle information. Apparently, two air lines were crossed going into the primary air tank during chassis assembly. Once corrected, the system worked properly. I did not take it to a FL dealer because the chassis is out of warranty and Colton Truck Terminal is a well respected local repair company that almost exclusively works on Class A diesel pusher chassis. My hopes are that FL will reimburse me for this repair that was required as a result of improper initial assembly. My other concern is that there are no other chassis that may have this issue that were built around the same period. Though the emergency brakes could still be manually applied during loss of air pressure, the incorrect assembly prohibited automatic operation as required. You are welcome to call the repair facility to gather further information if you require or contact me as well by email or phone at [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

Last week I had the air dryer filter replaced at Colton Truck Terminal in Colton Ca. Subsequently, I did the complete 7 step air brake system check and discovered that during total loss of air pressure , the emergency brakes would not auto apply. I replaced the dash hand valve and the problem still persists, so I installed the original valve and took the coach back to Colton Truck Terminal to diagnose the problem. Attached is the paper work from Colton Truck Terminal diagnosing the issue and the correction of that issue. Also on that paperwork is the vehicle information. Apparently, two air lines were crossed going into the primary air tank during chassis assembly. Once corrected, the system worked properly. I did not take it to a FL dealer because the chassis is out of warranty and Colton Truck Terminal is a well respected local repair company that almost exclusively works on Class A diesel pusher chassis. My hopes are that FL will reimburse me for this repair that was required as a result of improper initial assembly. My other concern is that there are no other chassis that may have this issue that were built around the same period. Though the emergency brakes could still be manually applied during loss of air pressure, the incorrect assembly prohibited automatic operation as required. You are welcome to call the repair facility to gather further information if you require or contact me as well by email or phone at [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

My Newmar motorhome has 20,000 miles on it. When driving on the highway the steering intermittantly gets about 60% harder to steer for approximately 20 minutes then goes back to normal. It happens repeatedly and regardless of whether you are turning or going straight. Last week the problem became much worse. More importantly I was exiting the highway and the steering wheel turned by itself back to center while I was turning! Thank god I was moving slowly and was able to stop. I turned the motorhome engine off and restarted it and the steering was operational again. I called freightliner and spoke to a customer service person who said I had to bring it to a dealer which I did. Now they can not find the problem and want to charge me at least $2500.00 to start looking for the problem. I allowed them to investgate the problem for 1 hour of labor but they could not find a cause. Attached are the tech notes and estimate to continue looking for the problem. Freightliner has a known issue with steering on this particular chassis. They replace the steering column. I feel it is extremely dangerous for me to keep driving.

TPMS not reading tire pressure

Tire Pressure Monitor System stops working after 1 to 2 hours and shows all tires at 401 degrees F and 136 PSI. At this point there is no warning if a tire loses pressure or overheats which could lead to a blowout and accident.