2003 MINI COOPER Power Trainmanual Transmission Problems

2003 MINI COOPER. 5 SPEED MANUAL TRANSMISSION. CAR TRANSMISSION FLEW APART WHILE DRIVING. *TW

I BOUGHT A NEW 2003 MINI COOPER WITH A 3 YEAR 36K WARRANTY 6/26/03. WHILE UNDER WARRANTY AND RECEIVING RECOMMENDED MAINTENANCE THROUGH THE DEALER, THE CAR REQUIRED REPAIR OF THE DRIVER'S SEAT WHICH WAS FROZEN IN THE RECLINED POSITION. SHORTLY AFTER THE WARRANTY EXPIRED, AND 10,481 MILES AFTER A DEALER MAINTENANCE CHECK, THE BRAKE LIGHT INDICATOR BEGAN FLASHING. I TOOK IT IMMEDIATELY TO THE DEALER. I WAS TOLD THE ENTIRE BRAKE SYSTEM NEEDED REPLACEMENT FOR $886.60. AT THE SAME SERVICE VISIT, I WAS TOLD THE FRONT STRUTS NEEDED REPLACEMENT TO THE TUNE OF $1600. MY MALE FRIENDS WHO ARE MECHANICALLY INCLINED AND/OR ENGINEERS SAID THAT ONE WOULD NEED TO BE DOING STUNTS IN A CAR TO NEED THAT KIND OF REPAIR AT 50,293 MILES. IT WAS NOT CLEAR WHY THE INDICATOR ONLY TELLS WHEN BRAKES ARE TOTALLY SHOT, OR WHY THE MOST RECENT SERVICE CHECK HAD NOT SHOWN WORN PADS...

MY TRANSMISSION FAILED ON MY MINI-COOPER ONCE WHEN IT WAS IN WARRANTY AND I HAD TO PAY TO HAVE IT FIXED, ONCE AGAIN, AND IT WAS JUST OUT OF WARRANTY AND I PAID 3000$ TO HAVE IT FIXED AND ONCE AGAIN WHEN THE 2ND TRANSMISSION WAS IN WARRANTY AND MINICOOPER FIXED IT. THIS CAR WAS A LEMON AND MINI NEVER ACCEPTED RESPONSIBILITY FOR THE DEFECTIVE TRANSMISSION PROBLEMS. *TR

TL*THE CONTACT OWNS A 2003 MINI COOPER. WHILE DRIVING 40 MPH IN FIRST GEAR, THE TRANSMISSION BEGAN TO RANDOMLY MAKE WHIRLING NOISES. HE TOOK THE VEHICLE TO THE MECHANIC AND WAS INFORMED THAT THE TRANSMISSION NEEDED TO BE REPLACED; HOWEVER, THEY DID NOT EXPLAIN WHAT CAUSED THE FAILURE. THE VEHICLE IS CURRENTLY REPAIRED AND A NEW TRANSMISSION WAS INSTALLED. THE CONTACT BELIEVES THAT A TRANSMISSION SHOULD NOT HAVE TO BE REPAIRED WITHIN FIVE YEARS. THE FAILURE MILEAGE WAS 34,000.

2 TRANSMISSIONS NEEDED TO BE REPLACED WITHIN 1 1/2 YEARS. 1ST TRANS WAS REPLACED IN NOVEMBER 2006 AFTER EXPERIENCING GRINDING NOISE IN THE FRONT END OF THE CAR. ON FRIDAY MAY 2, 2008 HEARD A POP WHILE TURNING LEFT AND EXPERIENCE THE GRINDING NOISE. DEALER NOW STATES THAT IT'S THE TRANSMISSION AND WANT $5,000 TO REPLACE. I COMPLAINED THAT THIS IS THE SECOND ONE IN 1 1/2 YEARS AND WAS TOLD THAT A CALL WAS PLACED TO THE ENGINEER AND WAITING FOR THEIR RESPONSE ON WHETHER THEY WILL COVER THE COSTS. *TR

I WILL BE INSTALLING WHAT WILL BE THE THIRD MANUAL 5-SPEED TRANSMISSION IN MY MINI. SAME PROBLEM, SEEMS TO BE THE FINAL DRIVE BEARING IS FAILING LIKELY DUE TO LACK OF LUBRICATION. I HAVE RECORDS OF ALL SERVICE AND CHECK IT REGULARLY AND IT HAS NEVER BEEN LOW. THE BEARING IS APPARENTLY NOT GETTING A PROPER SUPPLY OF FLUID. PROBLEM NUMBER TWO, MY POWER STEERING PUMP FAILED ON ME ONCE. IT EXPLODED WHILE I WAS DRIVING. THE HOSES BASICALLY GOT TOO HOT AND BLEW UP. I FORTUNATELY WAS ABLE TO LIMP IT TO A SHOP WITHOUT ANY FIRE. ON ANOTHER OCCASION THE POWER STEERING FAN CONTINUED TO RUN EVEN WHEN THE IGNITION WAS SHUT OFF, NEEDED TO REPLACE THE ENTIRE PUMP THIS TIME WHICH COST ME $500 INSTALLED WITH A REMANUFACTURED PUMP. THIRD, I HAVE HAD TO PUT THREE WINDSHIELDS IN THE CAR. NONE OF THESE REPAIRS WERE WARRANTED! MINI...