2003 MINI COOPER Visibilitywindshield Problems

GOT IN CAR ONE MORNING AND NOTICED WINDSHIELD HAD CRACKED IN CENTER FROM TOP OF WINDSHIELD AND FROM BOTTOM OF WINDSHIELD, AND I'M HOPING THE CRACK DOESN'T MEET IN THE MIDDLE! *TR

I WILL BE INSTALLING WHAT WILL BE THE THIRD MANUAL 5-SPEED TRANSMISSION IN MY MINI. SAME PROBLEM, SEEMS TO BE THE FINAL DRIVE BEARING IS FAILING LIKELY DUE TO LACK OF LUBRICATION. I HAVE RECORDS OF ALL SERVICE AND CHECK IT REGULARLY AND IT HAS NEVER BEEN LOW. THE BEARING IS APPARENTLY NOT GETTING A PROPER SUPPLY OF FLUID. PROBLEM NUMBER TWO, MY POWER STEERING PUMP FAILED ON ME ONCE. IT EXPLODED WHILE I WAS DRIVING. THE HOSES BASICALLY GOT TOO HOT AND BLEW UP. I FORTUNATELY WAS ABLE TO LIMP IT TO A SHOP WITHOUT ANY FIRE. ON ANOTHER OCCASION THE POWER STEERING FAN CONTINUED TO RUN EVEN WHEN THE IGNITION WAS SHUT OFF, NEEDED TO REPLACE THE ENTIRE PUMP THIS TIME WHICH COST ME $500 INSTALLED WITH A REMANUFACTURED PUMP. THIRD, I HAVE HAD TO PUT THREE WINDSHIELDS IN THE CAR. NONE OF THESE REPAIRS WERE WARRANTED! MINI...

2003 MINI COOPER WINDSHIELD FAILURE. SPONTANEOUS CRACK ALTHOUGH DEALER INSISTS IT WAS A PIN HOLE SIZED HOLE THAT CAUSED IT. REFUSED TO COVER UNDER WARRANTY. 2ND TIME IT'S HAPPENED AND WAS COVERED FIRST TIME UNDER WARRANTY. APPARENTLY HAPPENS VERY REGULARLY TO MINI AND AT $1078. COMPLETE...THIS JUST ISN'T RIGHT. *JB

THE WINDSHIELD CRACKED IN SEVERAL PLACES AND NEEDED TO BE REPLACED. VEHICLE WAS TAKEN TO DEALER FOR CHECK UP, AND CONSUMER WAS INFORMED THAT THE WINDSHIELD HAD CERTAIN SPOTS THAT COULD NOT TOLERATE ROAD CONDITIONS. THIS COULD BE DANGEROUS IF THE WINDSHIELD BREAKS WHILE THE VEHICLE WAS BEING DRIVEN.*AK

WHILE DRIVING MY 2003 MINI COOPER, I NOTICED A CRACK IN THE BOTTOM MIDDLE OF THE WINDSHIELD. THE CRACK BEGAN UNDER THE TRIM, MOVED UP, TURNED A FEW INCHES UP, AND THEN SPREAD TOWARD THE PASSENGER SIDE. TWO WEEKS LATER, I BROUGHT THE CAR IN FOR IT'S FIRST SCHEDULED OIL SERVICE, WHERE I ASKED THE SERVICE ADVISOR, PETER WARK OF MINI OF THE MAIN LINE IN BALA CYNWYD, PA, ABOUT THE WINDSHIELD. HE PROCEEDED TO TAKE THE POINT OF A SMALL SCREWDRIVER AND RUN IT ALONG THE CRACK. ABOUT A QUARTER OF AN INCH ABOVE THE TRIM, AND IN A PLACE WHERE IT WOULD BE ALMOST IMPOSSIBLE FOR A ROCK TO HIT, THE SCREWDRIVER CAUGHT A SMALL NICK IN THE GLASS, ABOUT THE SIZE OF A GRAIN OF SAND. HE INFORMED ME THAT THAT NICK WAS CAUSED BY A ROCK, WHICH CAUSED THE CRACK, WHICH WOULD NOT BE COVERED UNDER...

SPONTANEOUS CRACK FORMING IN MINI COOPER WINDSHIELD. OVERNIGHT, A CRACK APPEARED IN MY WINDSHILED STARING AT THE BOTTEM CENTER OF THE WINDSHIELD, MOVING DIRECTLY UPWARD ABOUT 5 INCHES THEN ANGLING 90 DEGREES TOWARDS THE DRIVER'S SIDE OFR SEVERAL INCHES. THIS IS THE 2ND TIME IN 6 MONTHS THAT THE SAME FRACTURE HAS APPEARER OVERNIGHT. FIRST WINDSHIELD WAS REPLACED.*AK

WINDSHIELD CRACKED ON MY MINI COOPER FROM DEBRIS ON THE HIGHWAY. THIS IS A COMMON PROBLEM WITH MINI COOPERS. DOZENS AND DOZENS OF MINI OWNERS HAVE COMPLAINED ABOUT THIS ON THE MESSAGE BOARDS ON WWW.ROADFLY.ORG. THE WINDSHIELDS ON THESE CARS ARE PRONE TO CRACKING. I'VE ONLY HAD MY CAR FOR 1.5 YEARS AND ONLY HAVE 5000 MILES ON IT. THIS IS THE FIRST TIME I'VE HAD SOMETHING HIT MY WINDSHIELD. IF SO MANY OWNERS ARE HAVING THE SAME PROBLEMS, IT SHOULD BE ENOUGH TO WARRANT SOME SORT OF INVESTIGATION INTO THESE WINDSHIELDS AND WHY THEY ARE SO PRONE TO CRACKING. *AK

THE SLIGHTEST PEBBLE CAUSES STARS, CHIPS, AND CRACKS IN MY MINI COOPER WINDSHIELD. I'M ON MY THIRD ONE AND IT ALREADY HAS 2 STARS AND A CHIP. I'M TIRED OF REPLACING IT, BUT IT'S A STRUCTURAL SAFETY ITEM.

THE MINIS WINDSHIEL BEING SOFT AND WEAK WHICH LEAVES IS MORE PRONE TO PITTING, CHIPPING AND TO CRACKING. *AK

MINI COOPER WINDSHIELD IS THIN AND WEEK. THERE IS NO AFTERMARKET GLASS FOR IT EITHER SO REPALCEING GETS PRICY.*AK

CRACKED WINDSHIELD THAT QUICKLY GREW TO SPAN ACROSS THE ENTIRE WINDSHIELD.*AK

WINDSHIELD: CRACKING BECAUSE OF FRAME STRESS, MAYBE INDUCED BY PIN SIX ROCK STRIKE. *CB

THE WINDSHIELD ON MY 2003 MINI SUFFERED A 5 INCH CRACK AFTER BEING HIT BY A SMALL PEBBLE. THE WHOLE WINDSHIELD HAD TO BE REPLACED BECAUSE IT WASN'T REPAIRABLE DUE 1-1/2 INCHES OF IT BEING SUBSURFACE. ON MY OTHER CARS, A 1993 LEXUS LS400 AND A 1993 ISUZU RODEO 4WD, NEITHER CAR HAS EVER SUFFERED A CRACKED WINDSHIELD DUE TO A PEBBLE HIT. WHAT'S WORSE IS THE 2003 MINI WINDSHIELD CRACKED JUST 11 DAYS AFTER OWNING THE CAR. THE REPLACEMENT WAS NOT COVERED BY MY AAA INSURANCE. *JB

WINDSHIELDS ON MINI COOPERS CRACKING,CHIPPING EASY AND FREQUENTLY. I HAVE HAD FOUR WINDSHIELDS REPLACES IN THE LAST 8 MONTHS. 2 COVERED UNDER WARRANTEE FOR STRESS RELATED CRACKS AND TWO DUE TO SMALL ROCK STRIKES. I HAVE NEVE BEEN THRU WINDSHIELDS LIKE THIS BEFORE AND FEEL THAT THE CONSTRUCTION AND DESIGN OF THE MINI WINDSHIELD MAKES IT SUBSTANDARD IN PROTECTION.*AK

STRESS CRACK ON WINSHIELD OF MY MINI COOPER, WHICH IS APPARENTLY HAPPENING QUITE OFTEN. *AK