2005 MINI COOPER S Steering Problems

I MADE A LEFT TURN AT A LIGHT AND THE POWER STEERING QUIT WORKING IN THE MIDDLE OF THE TURN. THE STEERING BECAME VERY HEAVY AND I THOUGHT I HAD A FLAT TIRE. I PULLED OVER AND CHECKED THE FLUID AND THE LEVEL WAS CORRECT. I CONTINUED DRIVING AND THE STEERING WAS FINE. *TR

THE MINI COOPER WAS SITTING IN THE GARAGE. MY FAMILY NOTICED A DISTINCT BURNING SMELL. WE DID NOT KNOW WHERE IS WAS COMING FROM. THE BURNING SMELL WAS TRACED TO THE GARAGE, BUT STILL DID NOT IDENTIFY THE SOURCE. THE NEXT DAY WHEN THE VEHICLE WAS DRIVEN, THERE WAS NO POWER STEERING. UPON INSPECTION AND REMOVAL OF THE POWER STEERING PUMP, ALL THE ELECTRICAL CONNECTIONS TO THE UNIT WERE MELTED. THE POWER STEERING UNIT AND THE WIRING HARNESS LEADING TO THE UNIT ARE DAMAGED AND MUST BE REPLACED. IN CONCLUSION THE UNIT DREW POWER WHILE THE CAR WAS OFF AND FRIED THE ELECTRICAL CONNECTIONS. *TR

THE POWER STEERING PUMP SUDDENLY WENT OUT ON MY 2005 MINI COOPER S. FORTUNATELY FOR ME (ALTHOUGH THIS EASILY COULD HAVE BEEN TRAGICALLY UNFORTUNATE FOR SOMEONE ELSE) THIS HAPPENED IN A SCHOOL ZONE, WHICH MEANS I WAS DRIVING VERY SLOWLY. BUT WITH LITTLE CHILDREN AROUND THIS COULD HAVE BEEN EXTREMELY DANGEROUS. IN DOING SOME RESEARCH I FIND THIS SUDDEN POWER STEERING FAILURE IS A COMMON PROBLEM ON EARLY MINI COOPERS. THE PUMP HAS BEEN RECALLED IN CANADA, BUT WHY NOT IN THE U.S.A? CAN YOU TELL ME WHY THIS IS NOT A RECALL ITEM HERE? *TR

POWER STEERING FAILED AS I WAS MAKING A RIGHT HAND TURN FROM ONE STREET TO ANOTHER. WHILE 1/2 WAY INTO THE TURN THE STEERING NO LONGER RESPONDED AND STARTED TO GO STRAIGHT INTO ONCOMING OPPOSING TRAFFIC. IT TOOK QUITE A BIT OF EFFORT TO YANK THE STEERING WHEEL AND AVOID A CRASH (MUCH MORE EFFORT THAN STEERING MY 54 CHEVY PICK UP TRUCK). HAD CAR TOWED TO BMW/MINI DEALER - DIAGNOSED AS "POWER STEERING PUMP SHORTING". COST OF REPAIRS TO REPLACE POWER STEERING PUMP (INCLUDING NEW P/S HOSES): $1977.62. *TR

POWER STEERING FAILED AT FREEWAY SPEED. DRIVER NARROWLY ESCAPED ACCIDENT AT FREEWAY SPEED. POWER STEERING PUMP TOTAL FAILURE. SOMEONE WILL DIE UNLESS THIS ISSUE IS ADDRESSED. *TR

WAS DRIVING ALONG THE ROAD AND CAME UP ON A TURN WHEN THE STEERING LOCKED UP. PUT ALL OF MY WEIGHT INTO THE STEERING WHEEL TO KEEP FROM JUMPING THE MEDIAN. SCARED THE LIFE OUT OF ME. IMMEDIATELY PULLED OVER TO FIGURE OUT WHAT HAPPENED. TURNED THE CAR OFF, THEN BACK ON AND IT SEEMED FINE. THEN GETTING ON THE FREEWAY, I WAS ON THE CLOVER-LEAF AND IT LOCKED UP AGAIN SO I PUT ALL OF MY WEIGHT INTO IT AGAIN, THEN IT SUDDENLY RELEASED. WITH THE SUDDEN JERK/MOVEMENT (AND IT HAS DONE THIS A FEW TIMES) SOMEDAY I KNOW IT WILL CAUSE THE CAR TO FLIP. THE POWER STEERING SEEMS TO WORK IN PHASES: IT WILL BE FINE FOR A COUPLE DAYS, THEN ITS INTERMITTENT/GONE FOR A WEEK OR 2. THE PAST FEW DAYS, IT HAS SOUNDED LIKE THE ENGINE FAN WAS ENGAGED EVEN THOUGH I HAD NOT BEEN...

WHILE DRIVING MY MINI COOPER S '05, I SUDDENLY LOST POWER STEERING, WHICH MADE IT EXTREMELY DIFFICULT TO STEER. I FEEL THREATENED DRIVING MY CAR. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT WHILE ATTEMPTING TO TURN, THE STEERING WHEEL FAILED TO RESPOND. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WERE IT WAS FOUND THAT THE POWER STEERING PUMP FAILED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE ISSUE AND OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 59,895. UPDATED 1/29/13 *CN UPDATED 2/7/2013 *JS

THE POWER STEERING WENT OUT AND WAS VIRTUALLY IMPOSSIBLE TO STEER. *TR

I WAS DRIVING DOWN THE FREEWAY ATTEMPTING TO CHANGE LANES WHEN I NOTICED THAT MY STEERING WHEEL SUDDENLY BECAME VERY DIFFICULT TO TURN AND MANEUVER, AS IF THE POWER STEERING FEATURE HAD BEEN DISABLED. INITIALLY, I THOUGHT IT WAS JUST THE SURFACE OF THE ROAD MAKING HANDLING OF THE CAR DIFFICULT, BUT THE PROBLEM CONTINUED TO PERSIST EVEN AFTER I EXITED THE FREEWAY. WHILE PERFORMING LEFT-TURNS AND RIGHT-TURNS ON THE SIDE STREETS, I HAD TO EXERT TREMENDOUS LABOR TO COMPLETE THE TURN, AND ON A COUPLE OF OCCASIONS I ALMOST HIT ADJACENT CARS ON THE ROAD BECAUSE I COULDN'T FORCIBLY TURN THE STEERING WHEEL ENOUGH. WHEN I ARRIVED AT MY DESTINATION, I TURNED OFF MY ENGINE, RE-STARTED IT, AND TO MY RELIEF AND AMAZEMENT, THE STEERING WHEEL BECAME EASY TO MANEUVER AGAIN, WITHOUT A TRACE OF THE STEERING PROBLEMS THAT HAD JUST OCCURRED. *TR

THE POWER STEERING GOES OUT INTERMITTENTLY. *TR

THE PASSENGER AIR BAG WEIGHT SENSOR STOP WORKING. AS A RESULT MY VEHICLE DISPLAYS A WARNING THAT THE PASSENGER SIDE AIR BAGS ARE OFF. MY DRIVER SIDE FOG LIGHT HOUSING MELTED AND CRACK APART. I USED STOCK 55W HALOGEN BULBS. MY PASSENGER SIDE FOG LIGHT HOUSING HAS ALSO BEGUN TO MELT. MY POWER STEERING IS NOT LEAKING NOW. BUT IT HAS BEEN REPLACED 3 TIMES. *TR

I WAS EXITING THE INTERSTATE AND THE RAMP CURVED TO THE RIGHT, AS I BEGAN TO NEGOTIATE THE CURVE I NOTICED I HAD NO POWER STEERING AT ALL. I REACHED MY DESTINATION ABOUT 15 MINUTES LATER AND HAD NO POWER STEERING ASSISTANCE AT ALL THE ENTIRE TIME. I PARKED THE VEHICLE AND DID NOT USE IT AGAIN UNTIL 9/3/12 AND THE STEERING APPEARED TO BE WORKING PROPERLY AGAIN. IN READING THE INVESTIGATIVE STUDY I NOTED THAT IT MAY BE DUE TO AN ERROR IN THE INTERNAL ELECTRONICS AND MAY ALSO RESULT IN A CONTINUOUS RUNNING OF THE POWER STEERING PUMP. LAST YEAR ALMOST TO THE DAY, THE ELECTRICAL SYSTEM WENT HAYWIRE AND THE CAR WOULD NOT STEER AND HAD WHAT SEEMED LIKE POWER SURGE AND AFTER SHUTTING THE CAR OFF AND REMOVING THE KEY THE CAR CONTINUED TO MAKE A CLICKING SOUND AND THE WINDOWS ROLLED DOWN BY THEMSELVES. I...

RIGHT AFTER EXITING THE HIGHWAY, THE STEERING WHEEL BECAME SUDDENLY VERY STIFF AS I WAS MAKING A STANDARD 90 TURN. I ALMOST HIT THE CAR NEXT TO ME BUT DIDN'T AS I MANAGED TO HIT THE BRAKES. I FINISHED THE CURVE ON THE VERY LAST LANE ON THE RIGHT. IF A CAR HAD BEEN ON MY WAY, IT WOULD HAVE BEEN A CRASH, FORTUNATELY THERE WAS NONE. MINI DIAGNOSED A POWER STEERING PUMP FAILURE. BROWSING ON THE WEB, I CAME ACROSS PAGES OF PEOPLE HAVING HAD THE SAME ISSUE FOR THIS YEAR'S MODEL (MINI COOPER S 2005). CANADIAN AUTHORITIES EVEN ORDERED A RECALL FOR THIS EXACT SAME FAILURE. I HAVE ALSO READ THAT NHTSA IS CURRENTLY STUDYING THIS ISSUE; COULD YOU PLEASE CONFIRM THIS IS TRUE ANY IDEA HOW LONG IS THE PROCESS TO DECIDE WHETHER OR NOT A RECALL WILL BE DECIDED IF A RECALL WAS DECIDED, WOULD WE...

MY POWER STEERING WENT OUT WHILE I WAS MAKING A LEFT TURN IN FRONT OF ONCOMING TRAFFIC. I MANAGED TO AVOID HITTING THE CURB AND PULLED OVER AFTER COMPLETING THE TURN. IT FELT LIKE DRIVING WITH FOUR FLAT TIRES. AFTER RESTARTING, THE POWER STEERING WORKED AGAIN. THE SAME THING HAPPENED AGAIN TWO DAYS LATER. IN BOTH CASES, THIS HAPPENED SHORTLY AFTER STARTING UP. *TR

THE FIRST TIME MY POWER STEERING WENT OUT I WAS AT A STOP SIGN. I WAS MAKING A RIGHT TURN AND HAD DIFFICULTY MAKING THE TURN. THE POWER STEERING WENT OUT AGAIN ANOTHER TIME WHEN I WAS IN THE MIDDLE OF A TURN, MAKING IT DIFFICULT TO TURN. I WAS FORTUNATE THERE WERE NO OTHER CARS AROUND. TODAY, 8/20/2012 IS THE MOST RECENT DAY THAT IT WENT OUT. I WAS DRIVING AT APPROXIMATELY 35 MPH AND MAKING A LEFT TURN WHEN I NOTICED IT WAS OUT. I HAVE FIGURED OUT THAT IF I TURN OFF MY CAR IT COMES BACK ON. LUCKILY I HAD TO STOP BEFORE GETTING ONTO THE FREEWAY SO I WAS ABLE TO CONTROL MY CAR AT HIGH SPEEDS. *TR

THE POWER STEERING WENT OUT WHILE DRIVING THE VEHICLE. IT HAS OCCURRED INTERMITTENTLY SINCE THEN.

TL* THE CONTACT OWNS A 2005 MINI COOPER S. THE CONTACT STATED THAT POWER STEERING FAILED. IN ADDITION, THE VEHICLE WAS UNABLE TO BE STARTED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHO ADVISED THAT THE FAILURE CAUSED DAMAGE TO THE ELECTRICAL SYSTEM, WHICH HAD BECOME INOPERABLE. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 105,916 AND THE CURRENT MILEAGE WAS 105,960.

POWER STEERING ASSIST FAILS REPEATEDLY. SOLUTION HAS BEEN TO STOP CAR AND RESTARTED ENGINE; SEEMS TO RESET PUMP ELECTRONICS. THIS INTERMITTENT POWER STEERING FAILURE HAS HAPPENED DOZENS OF TIMES IN THE 3 YEARS WE'VE OWNED THE CAR AND CAN BE VERY DANGEROUS IF DRIVER IS NOT AWARE OF THE CHANGE IN STEERING ABILITY. WE'RE GOING TO HAVE TO REPLACE THE PUMP I BELIEVE AND WITH ALL THE OTHER COMPLAINTS ABOUT THIS PROBLEM I FEEL MINI/BMW SHOULD VIEW THIS AS A MANUFACTURER DEFECT AND COVER UNDER WARRANTY -- IT IS CLEARLY A DANGEROUS PART AND POOR DESIGN. *TR

SINCE I HAD THE CAR IN 2009 I HAD THIS PROBLEM WITH THE POWER STEERING THAT IT HAS A FAILURE. BMW NO RESPONSE FOR THIS ITS A PUMP THAT ITS NOT DESIGN CORRECTLY. LOST OF MINIS HAS THIS PROBLEMS. HARD TO STEER AND ALMOST GOT INTO A CRASH. *TT

I STARTED THE CAR COLD BEFORE HEADING OUT AND THE POWER STEERING WAS COMPLETELY OUT. AFTER SEVERAL MINUTES IT STARTED WORKING AGAIN, ALTHOUGH NOT WITH THE FULL ASSIST. SINCE THIS TIME, EVERY TIME I START UP THE CAR, I HAVE A VARYING DEGREE OF ASSIST FOR THE FIRST COUPLE MINUTES OF DRIVING IT. *JS

POWER STEERING CUTS OUT INTERMITTENTLY. POWER STEERING COMES BACK AFTER RESTARTING VEHICLE. THEN FAILS LATER AGAIN. *TR

ELECTRIC POWER STEERING PUMP FAILED WHILE I WAS IN A TURN AT 30 MPH. STEERING BECAME VERY HEAVY AND NEARLY CAUSED THE CAR TO LEAVE THE ROAD DUE TO GREATLY INCREASED REQUIRED STEERING EFFORT. SHUT CAR OFF AND CHECKED FLUID LEVEL. FLUID LEVEL FOUND TO BE FULL. RESEARCHED THE PROBLEM WHEN I GOT HOME AND FOUND THAT THIS IS A KNOWN SAFETY ISSUE WITH MINI'S. ADDITIONALLY, TRANSPORT CANADA HAS ISSUED A RECALL ALREADY ON THESE POWER STEERING PUMPS DUE TO CONTINUED FAILURES. *TR

THE CAR HAD BEEN PERFORMING NORMALLY AND WHEN I ATTEMPTED TO TURN INTO A PARKING SPACE IT WAS SUDDENLY EXTREMELY DIFFICULT TO TURN. AFTER COMING OUT OF THE STORE THE CAR RESUMED STEERING CORRECTLY. THEN A FEW DAYS LATER THE SAME THING HAPPENED-IT WAS TERRIBLY DIFFICULT TO TURN THE VEHICLE. I CALLED MY MECHANIC WHO SUGGESTED CHECKING THE POWER STEERING FLUID LEVEL. I WAS UNABLE TO FIND IN MY OWNERS MANUAL WHERE THE POWER STEERING RESERVOIR WAS LOCATED. THE MECHANIC CHECKED THE FLUID THE FOLLOWING WEEK AND FOUND THE LEVEL TO BE NORMAL. HE INVESTIGATED AND FOUND THAT THERE HAD BEEN PROBLEMS WITH POWER STEERING IN OTHER CARS OF MY TYPE. I ENDED UP HAVING TO HAVE EVERYTHING REPLACED-PUMP, FAN AND RESERVOIR AT A COST FOR PARTS ALONE AT $1033. I FEEL THAT IF THIS PROBLEM WAS KNOWN TO THE MANUFACTURING COMPANY THAT THIS SHOULD HAVE BEEN A RECALLED ITEM...

VEHICLE FIRE 5/2/2012. CAR PARKED FOR 4 HRS. RETURNED TO CAR & DROVE IT <50 YARDS FOR ~2 MINUTES (MOVED IT FROM STREET TO PARKING LOT). TURNED IT OFF AND WENT IN STORE. RETURNED ~4 MINUTES LATER, NOTICED SMOKE/EXHAUST SMELL; PRESUMED IT WAS ADJACENT CAR. UNLOCKED CAR. CAR WOULD'T START (NO LIGHTS/ELECTRICAL AT ALL). I THEN NOTICED WHITE SMOKE COMING FROM HOOD. OPENED HOOD THEN NOTICED FLAME/FIRE INSIDE ENGINE COMPARTMENT. WENT IN STORE, GOT FIRE EXTINGUISHER AND PUT FIRE OUT. INVOICE WAS >$3500 FROM MINI DEALER. THE DEALER'S ASSESSMENT: "VERIFIED POWER STEERING PUMP HAS OVERHEATED TO THE POINT WHERE IT HAS BURNED UP INTERNALLY AS WELL AS EXTERNALLY (MELTING ALL THREE CONNECTORS AND THE WIRING LEADING TO THEM). INSPECTED POWER STEERING COOLING FAN AND VERIFIED COOLING FAN IS SEIZING UP WHICH VERY LIKELY LED TO THE OVERHEATING AND EVENTUAL FAILURE OF THE POWER STEERING PUMP. REMOVED ENGINE COMPARTMENT FUSE BOX...

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH, THERE WAS A COMPLETE LOSS IN THE POWER STEERING WITHOUT ANY PRIOR WARNING. THE CONTACT WAS ABLE TO CONTINUE DRIVING WITH CAUTION AT A REDUCED SPEED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC, WHO STATED THAT THE POWER STEERING PUMP WOULD NEED TO BE REPLACED. THE CONTACT PLANNED TO HAVE THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THERE WAS CURRENTLY THERE AN OPEN INVESTIGATION ASSOCIATED WITH NHTSA ACTION NUMBER EA11005 (STEERING: HYDRAULIC POWER ASSIST: PUMP). THE APPROXIMATE FAILURE MILEAGE WAS 60,000. THE VIN WAS UNAVAILABLE.

LOST POWER STEERING WHILE DRIVING MY 2005 MINI COOPER S. ALL OF A SUDDEN, HAVE NO POWER STEERING. VERY DIFFICULT TO STEER, BUT NOT IMPOSSIBLE. THANK GOD I WAS NOT IN A PLACE THAT THIS COULD HAVE CAUSED AN ACCIDENT. I NOTE THAT I CAN TURN OFF THE MOTOR, THEN TURN IT BACK ON AND THE STEERING IS OK FOR A FEW MINUTES, THEN GOES OUT AGAIN. I LOVE MY MINI COOPER, BUT THIS IS A SERIOUS SAFETY PROBLEM. I AM AFRAID TO DRIVE IT NOW, IF I CAN'T COUNT ON THE STEERING TO FUNCTION CORRECTLY. *TR

ON DATE OF INCIDENT, WAS ATTEMPTING TO PARK WHEN THE STEERING WHEEL LOCKED UP (BECAME VERY DIFFICULT TO MOVE). I MANAGED TO GET THE CAR INTO A SPOT AND CALLED FOR TOW ASSISTANCE. THE REPAIR SHOP DIAGNOSED AS A POWER STEERING PUMP FAILURE AND HAD TO REPLACE THAT AND OTHER AFFILIATED COMPONENTS (COOLING FAN, ETC.). APPROXIMATELY 4 DAYS BEFORE THE FAILURE, THE POWER STEERING FAN WAS UNCHARACTERISTICALLY WHINNY, BUT WENT AWAY AFTER A FEW MINUTES AND WAS NOT HEARD AGAIN BEFORE THE FAILURE. *TR

THE CAR HAS BEEN HAVING ISSUES WITH THE POWER STEERING ASSIST. THE POWER STEERING ASSIST GOES OUT INTERMITTENTLY MAKING IT DANGEROUS TO DRIVE IN THE TRANSITION FROM POWER STEERING ASSIST TO MANUAL STEERING. I HOPE THIS ASSISTS THE INVESTIGATION INTO THIS ISSUE. *TR

POWER STEERING PUMP HAD TO BE REPLACED AT 62,000 MILES DUE TO FAILURE. *TR

OVER HEATING CONSTANTLY NO TECHNICAL PERSON KNOWS OF A REMEDY. OVERFLOW TANK BLOWS OUT WHEN CAR OVERHEATS CONSTANTLY .THIS SEEMS TO BE A PROBLEM SINCE THE BEGINNING NO MATTER WHAT YEAR THE CAR WAS BUILT AND NEVER REMEDIED. WHY NOT A RECALL? NOT KNOWING WHAT OTHER DAMAGE THIS CAUSES TO THE ENGINE. THIS HAS TO BE A RECALL FOR THE COMPANY TO FIX IT IS A HIT AND MISS FIX??? THIS IS A COSTLY PROCESS AND EVEN IN THE FORUMS ON MINI IT HAS BEEN AN ONGOING ISSUE. FRONT END FAILS ALL AT THE SAME TIME. (CONTROL ARMS, CV JOINTS) STEERING BECOMES HARD TO CONTROL. MINI HELP *TR

WAS DRIVING IN TRAFFIC ON INTERSTATE 95 WHEN POWER STEERING FAILED WITHOUT WARNING. CAR BECAME VERY DIFFICULT TO DRIVE. PULLED OFF ROAD, CHECKED FLUID LEVELS AND COULDN'T FIND ANY OBVIOUS PROBLEMS. POWER STEERING CAME BACK ON WHEN RESTARTED CAR. POWER STEERING STAYED ON FOR REST OF DRIVE, BUT HAS GONE OUT SEVERAL TIMES SINCE. ALWAYS COMES BACK IF TURN OFF CAR AND RESTART. *TR

VEHICLE DARTING AROUND ON ROAD LIKE STEERING STOPS THEN STARTS BACK UP,ACCELERATION DARTS LEFT , DECELERATION DARTS RIGHT. *TR

POWER STEERING FAILED WHILE MAKING A RIGHT HAND TURN. THE FAILURES HAVE BEEN OFF AND ON SINCE THEN. FAILURE IS USUALLY DURING IN TOWN DRIVING. *TR

POWER STEERING PUMP FAILURE. THE STEERING WHEEL COMPLETELY LOCKS UP AND CAN'T BE TURNED. ON TOP OF THAT, IT'S COMPLETELY UNPREDICTABLE WHEN THE FAILURE OCCURS. THE FIRST TIME IT HAPPENED I WAS TAKING A RIGHT TURN OUT OF A ROUNDABOUT, WHEN THE STEERING WHEEL WOULDN'T TURN COMPLETELY. FORTUNATELY, I WAS GOING SLOW ENOUGH THAT I COULD BRAKE SO THAT I DIDN'T HAVE A HEAD ON COLLISION WITH A CAR WAITING AT A STOP LIGHT. IT WAS EXTREMELY SCARY. *TR

TL* THE CONTACT OWNS A 2005 MINI COOPER S CONVERTIBLE . THE CONTACT STATED WHILE DRIVING AT THE SPEEDS OF 30 MPH, WITHOUT ANY WARNING THE POWER STEERING MALFUNCTIONED. THE VEHICLE WAS TURNED OFF AND THEN ON WHEN THE POWER STEERING BEGAN TO FUNCTION PROPERLY. THE FAILURE OCCURRED FOUR TIMES. THE FAILURE WAS NOT DIAGNOSED OR REPAIRED. THE DEALER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 75,000 AND THE CURRENT MILEAGE WAS 75,020.

AT HIGHWAY SPEED, THE POWER STEERING SUDDENLY LOST POWER (NO NOISE OR OTHER INDICATIONS). THE WHEEL BECAME EXTRAORDINARILY DIFFICULT TO TURN. I MANAGED TO GET THE CAR OFF THE ROAD, BUT THE STEERING WOULD NOT HAVE RESPONDED TO A SMALLER/WEAKER DRIVER. *TR

POWER STEERING PUMP SEIZED AND NEEDED TO BE REPLACED. POWER STEERING FAN FAILURE AND ALSO NEEDED TO BE REPLACED. POWER STEERING HOSES LEAKING AND ALSO NEEDED TO BE REPLACED. OUTPUT SHAFT SEAL IS LEAKING, BUT HAS NOT BEEN REPLACED AT THIS TIME. THESE REPAIRS COST ME APPROXIMATELY $1000! I HAVE FOUND NUMEROUS COMPLAINTS ABOUT POWER STEERING FAILURES IN THE 2004-2005 MINI. PLEASE MAKE BMW PAY FOR THIS! *TT

WHILE DRIVING ON THE FREEWAY (I-684) AT 65 MPH THE VEHICLE LOST POWER STEERING ASSIST APPROX. 30 MILES FROM MY HOME. THIS MADE THE CAR DIFFICULT TO CONTROL, ESPECIALLY WHEN TAKING TURNS IN AND OFF OF EXITS. MUCH FORCE WAS REQUIRED TO MAINTAIN CONTROL AND STEERING THE VEHICLE FOR THE REST OF THE TRIP HOME. I WILL REPORT THIS TO MINI ON MONDAY. *TR

POWER STEERING FAILS DURING DRIVING. SEEMS TO BE AFTER ENGINE GETS HOT. HAPPENS UNEXPECTEDLY AND WITHOUT WARNING. *TR

WHEN TURNING INTO OUR NEIGHBORHOOD AT 10-15MPH, THERE WAS A SUDDEN LOSS IN POWER AND THE STEERING BECAME STIFF. I DID NOT THINK ANYTHING OF TILL I PULLED THE VEHICLE INTO OUR GARAGE AND TURNED IT OFF. AT THIS TIME THE COOLING FAN AND POWER STEERING REMAINED ACTIVE, CREATING LOUD WHINING NOISES. I LET IT RUN FOR 30 MINUTES BUT THE ISSUE REMAINED. ONLY THING THAT RESOLVED THE ISSUE WAS DISCONNECTING THE BATTERY. EVEN RECONNECTING THE BATTERY THE POWERSTEERING FAN RE-ENGAGED. *TR

POWER STEERING PUMP FAILURE AND CAR BECOME VERY HARD TO TURN. ALMOST CRASHED INTO A CURB TAKE A 90 DEGREE SHARP TURN. ALL FUSES RELATED TO PUMP DID NOT FAIL. STEERING FLUID LEVEL IS AT PROPER AMOUNT. I JACKED UP THE CAR FRONT THE FRONT AND IT WAS A LITTLE BETTER WITHOUT ANY LOAD ON THE FROM END BUT FELT VERY NOTCHY ABOUT EVERY 20% OF A FULL TURN OF THE WHEEL. ELECTRIC COOLING FAN THAT COOLS THE PUMP IS NOT BLOCKED AND I CAN SPIN IT FREELY. MANY MINI COOPER OWNERS ARE COMPLAINT ABOUT THIS. MY POWER STEERING PUMP DOES NOT KEEP RUNNING AFTER THE CAR IS SHUT DOWN. *TR

SOMETIME IN LATE SUMMER OF LAST YEAR, MY CAR BEGAN TO MAKE A "HONKING" SOUND. IT SOUNDED LIKE THE CLUTCH THAT HAD ALREADY BEEN REPLACED ON BOTH OF OUR 2005 MINI COOPERS UNDER WARRANTY (ANOTHER POSSIBLE SAFETY ISSUE?) BUT THE CLUTCHING SEEMED OK. UP UNTIL THE TIME I WAS ABLE TO GET THE CAR IN TO THE SHOP TO GET LOOKED AT, I NOTICED A PUDDLE IN THE GARAGE, AND I ALSO NOTICED IT WAS GETTING HARDER TO STEER. THE SHOP DETERMINED THAT MY STEERING RACK WAS LEAKING AND NEEDED TO BE COMPLETELY REPLACED, WHICH WE DID. NOW, JUST OVER 1 YEAR LATER, THE CAR IS ALREADY EXHIBITING THE SAME BEHAVIORS EXACTLY. SOMETHING IN THE VEHICLE IS CAUSING THE RACK TO MALFUNCTION AND REQUIRE REPLACEMENT. *TR

I HAD TO REPLACE THE POWER STEERING PUMP AS IT HAD FAILED. IT FIRST FAILED WHILE I WAS ON A HIGHWAY OFF-RAMP AND NEARLY CRASHED. THE FAILURE WAS DUE TO THE POWER STEERING FAN SEIZING AND THEREFORE IT WAS NOT COOLING THE POWER STEERING PUMP. AFTER SOME INVESTIGATION OF MY OWN, I FOUND OUT THAT THE ROOT CAUSE OF THIS PROBLEM WAS THE LOW FAN SPEED RESISTOR FAILED ON THE ENGINE COOLING FAN. THE POWER STEERING FAN WILL ONLY ACTIVATE ONCE THE ENGINE COOLING FAN IS RUNNING. IF THE LOW FAN SPEED RELAY FAILS, THE ENGINE COOLING FAN WILL ONLY TURN ON AT 233F (HIGH SPEED FAN MINIMUM TEMPERATURE). ONCE THE ENGINE COOLING FAN TURNS ON AT 233F, THE POWER STEERING FAN WILL TURN ON TO COOL THE POWER STEERING PUMP. THE POWER STEERING FAN WILL BE TOO HOT AT THIS POINT AND WILL OVERHEAT ITSELF AND SEIZE. THE POWER...

TL* THE CONTACT OWNS A 2005 MINI COOPER S. WHILE DRIVING APPROXIMATELY 30 MPH, THE STEERING WHEEL BECAME DIFFICULT TO STEER AND SEIZED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE AND WAS NOT TAKEN TO THE DEALER FOR DIAGNOSTICS OR REPAIRS. THE VIN WAS NOT AVAILABLE.THE APPROXIMATE FAILURE MILEAGE WAS 118,000.

POWER STEERING FOR THE LAST YEAR OR SO ONLY WORKS A FRACTION OF THE TIME. THE FIRST TIME IT WENT OUT WAS WHILE DRIVING ON THE FREEWAY. LAST WEEKEND IT STOPPED WORKING AND DIDN'T WORK AGAIN FOR A FULL WEEK. VERY HARD TO DRIVE THIS VEHICLE WHEN IT GOES OUT UNEXPECTEDLY. *KB

IN THE EARLY FALL, SEPTEMBER 2011, I ENCOUNTERED ISSUES WITH MY CAR NOT SHIFTING PROPERLY. IT'S AN AUTOMATIC TRANSMISSION SO I KNOW THERE WAS NOTHING I COULD BE DOING TO CAUSE THIS PROBLEM. THE CAR HAS BEEN SERVICED REGULARLY AND DRIVEN WITH CARE WHILE IN MY POSSESSION(I'M THE SECOND OWNER. NO SIMILAR ISSUES ON CARFAX REPORT). WHILE THE ENGINE IS COOL AND NOT YET AT ITS OPTIMAL TEMPERATURE THE DRIVE IS FINE AND YOU MAY NOT EVEN NOTICE A PROBLEM; HOWEVER, EVERY RIDE, ONCE WARMED UP THE CAR BEGINS TO SHIFT INCREDIBLY VIOLENTLY AS IT IS OBVIOUSLY STRUGGLING TO SWITCH GEARS. THIS OCCURS ALSO WHILE SLOWING DOWN AND THE CAR IS DOWNSHIFTING CREATING AN OPPORTUNITY TO BE "SLUNG" INTO A CAR FROM BEHIND(THIS HAPPENED IN THE MID SUMMER OF 2011). AFTER DROPPING THIS CAR OFF SEPTEMBER 15TH TO THE LOCAL MINI DEALERSHIP, I DID NOT HEAR FROM THEM FOR ALMOST...

I WAS DRIVING DOWN BROOKWOOD STREET AND WENT TO MAKE A CURVE WHEN I REALIZED THAT I COULDN'T TURN THE CAR. I WAS ABLE TO PULL HARDER ON THE WHEEL AND MAKE THE CURVE. I PULLED OVER AND TURNED THE CAR OFF TO LOOK THINGS OVER,CHECKED THE POWER STEERING FLUID WHICH WAS FULL. I RESTARTED THE CAR AND THE STEERING WORKED AGAIN.I FINISHED DRIVING TO WORK WITH NO PROBLEMS. WHEN I CAME OUT OF WORK I AGAIN HAD NO POWER STEERING AND HAD THE CAR TOWED INTO A SHOP WHERE THEY TOLD ME THE POWER STEERING PUMP HAD FAILED AND IT WAS GOING TO COST OVER $1300 TO FIX. I HAD THE REPAIR DONE BUT AM AFRAID TO DRIVE THE CAR AS THEY TOLD ME IT COULD HAPPEN AGAIN EVEN WITH THE NEW PART. *TR

TEMPORARY LOSS OF POWER STEERING. AFTER DRIVING FOR ABOUT 2 HOURS, I STOPPED TO FILL UP AT A GAS STATION. I THEN STARTED THE CAR AND BEGAN TO DRIVE OUT OF THE GAS STATION. I SOON NOTICED THE POWER STEERING WAS NOT WORKING. I PULLED INTO A PARKING SPACE, OPENED THE HOOD, AND PROCEEDED TO CHECK THE POWER STEERING FLUID. THE POWER STEERING FLUID RESERVOIR WAS FULL. I RESTARTED THE CAR AFTER ABOUT 5 MINUTES AND THE POWER STEERING WAS WORKING AGAIN. THIS TEMPORARY POWER STEERING LOSS HAS OCCURRED 3 MORE TIMES OVER THE LAST MONTH SINCE THE INITIAL INCIDENT DESCRIBED ABOVE. DURING THE LAST OCCURRENCE, I DROVE A SHORT DISTANCE BACK TO MY HOME WITH NO POWER STEERING. I'D LIKE TO POINT OUT STEERING WAS VERY DIFFICULT, NEARLY UNDRIVEABLE AROUND SLOW SPEED TURNS. THE STEERING EFFORT WAS MUCH MORE THAN MANUAL STEERING CARS I'VE OWNED IN THE PAST. *TR

POWER STEERING COMPLETELY FAILS. *TR