2005 MINI COOPER S Power Train Problems

TAKATA RECALL. TRANSMISSION WOULD NOT SHIFT GEARS INTERMITTENTLY WHILE IN AUTOMATIC. SPENT $5,600 TO REBUILD TRANSMISSION. STILL HAVING INTERMITTENT ISSUES.

TRANSMISSION PREVIOUSLY REPLACED AT 48K MILES BY MANUFACTURER DUE TO NOISE. MY TRANSMISSION IS BROKEN. MY TIRES CHIRP EVERY TIME I PUSH ON THE GAS BECAUSE THE TRANSMISSION DOES NOT KNOW WHAT GEAR TO BE IN DUE TO THE BAD BODY CONTROL VALVE. THE TRANSMISSION NEEDS TO BE REPLACED BECAUSE I CANNOT VERIFY HOW MUCH MECHANICAL DAMAGE HAS TAKEN PLACE DURING THE TIME THAT THE VALVE BODY HAS BEEN BROKEN. ONCE THE VALVE BODY BREAKS DOWN, THE MECHANICAL UNIT ALSO BEGINS TO BREAK DOWN. MINI NEEDS TO ISSUE A SERVICE BULLETIN TELLING THE DEALERS TO COMMENCE SERVICING THE AISIN TRANSMISSIONS EVERY 40K BY REPLACING THE FLUID. BMW/MINI'S TRANSMISSION FLUID IS NOT LIFETIME. VOLKSWAGEN ISSUED A SIMILAR BULLETIN A FEW YEARS AGO BECAUSE IT ALSO USES THE AISIN TRANSMISSION. THE INDEPENDENT REPAIR SHOPS MAY NOT REPLACE THE FLUID RIGHT BECAUSE THE TRANSMISSION FLUID IS HARD TO DRAIN AND IN MANY CASES...

THE AUTOMATIC CVT TRANSMISSION JUST DOWN SHIFTED AND NOW WON'T GO INTO HIGH GEAR. THIS WILL HAPPEN ON THE FREEWAY AND WILL SHIFT AND CLUNK INTO GEAR. BMW IS AWARE OF THE PROBLEM WITH THIS TRANSMISSION BUT WON'T STAND BEHIND THEIR PRODUCT. IT IS VERY DANGEROUS TO DRIVE. *JS

PROBLEM WITH AUTOMATIC TRANSMISSION ON 2005 MINI COOPER S. NEEDS REPLACEMENT $8000+. ONLY 90K MILES. HUNDREDS OF COMPLAINTS ON LINE REGARDING CVT TRANSMISSION DEFECT. MINI COOPER/ BMW NOT ADMITTING PROBLEM TO PUBLIC. *TR

I AM THE CURRENT OWNER OF A 2005 MINI COOPER S. I PURCHASED THE VEHICLE IN 2006 FROM MINI OF IRVINE WITH 3,000 MILES. I HAVE RECENTLY BEEN EXPERIENCING ISSUES WITH THE CVT TRANSMISSION. THE CAR JERKS WHEN CHANGING GEARS AT ANY SPEED, AS WELL AS WHEN SWITCHING FROM DRIVE TO REVERSE. I HAVE TAKEN THE CAR TO MINI OF SAN DIEGO TO BE DIAGNOSED AND HAVE BEEN NOTIFIED THAT THE TRANSMISSION NEEDS TO BE REPLACED AT A COST OF $8,000. THE VEHICLE CURRENTLY HAS 73,000 MILES AND FIND IT COMPLETELY UNACCEPTABLE THAT THE TRANSMISSION IS FAILING SO EARLY ON. *TR

STARTED VEHICLE IN THE MORNING OF 11/14/2012. THE SHIFT INDICATOR ON THE DASH SHOWS EP MODE INSTEAD OF D,R,N,ETC. THE CAR SEEMED TO DRIVE FINE BUT THERE'S SOMETHING WRONG WITH THE SHIFTER ELECTRONICS. THE CAR DOES NOT SEEM TO KNOW WHAT DRIVE MODE IS IN. PUTTING THE AUTO MANUAL TRANSMISSION INTO SPORTS MODE DOES NOT CHANGE THE SHIFT INDICATOR ON THE DASH. IN SPORTS MODES IT STILL SHOWED EP. IN EP MODE THE CAR DOES NOT REV BEYOND 3000RPM AND DRIVES ROUGH AT CERTAIN SPEEDS. THIS MAY BE A MANUFACTURER DEFECT WITH A TRANSMISSION SENSOR, OR THE SHIFTER ELECTRONICS. *TR

THE TRANSMISSION HAS FAILED AT 66K MILES - AS I AM RESEARCHING THIS PROBLEM, I CAN SEE THAT MANY PEOPLE HAVE HAD PREMATURE TRANSMISSION FAILURES WITH THEIR MINI COOPER AND BMW HAS NOT BEEN WILLING TO ADDRESS THE PROBLEM. THE COST TO US WILL BE APPROXIMATELY $10,000 TO REPAIR. *TR

WHILE PROCEEDING DOWN A NORMAL DRY ROAD I MANUALLY SHIFTED THE TRANSMISSION (USING MANUAL MODE ON THE CVT AUTOMATIC TRANSMISSION) FROM 3RD GEAR TO 4TH GEAR. THE SHIFT NORMALLY WOULD BE SMOOTH HOWEVER ON THIS OCCURRENCE THE ENGINE IDLED EXTREMELY HIGH AND THE GEAR KICKED IN AFTER A COUPLE OF SECONDS WITH A LOUD BANGING SOUND WHEN THE GEAR FINALLY TOOK HOLD. THE CAR BEHAVED ITSELF FOR A WHILE BUT THIS EVENT STARTED HAPPENING MORE AND MORE UNTIL IT BECAME A REGULAR OCCURRENCE. MOST OF THE TIME THERE WAS NO LOUD NOISE BUT THE 4TH GEAR WOULD NOT CATCH AND I ADJUSTED MY DRIVING SO THAT I WOULD SHIFT FROM 3RD GEAR TO 5TH GEAR AS QUICKLY AS POSSIBLE TO AVOID THE OVER REVVING. I BROUGHT THE CAR IN TO A LOCAL TRANSMISSION SHOP. THEY LOOKED IT OVER AND ADVISED ME THAT THERE WAS NO WAY OF REPAIRING THE TRANSMISSION...

DEFECTIVE CVT TRANSMISSION! THE DEALERSHIP SAID THAT IT WAS NO FAULT OF OURS THAT WE NEEDED A NEW TRANSMISSION, BUT DUE TO THE WAY THIS TRANSMISSION WAS DESIGNED!!!!!!!! *TR

IN THE EARLY FALL, SEPTEMBER 2011, I ENCOUNTERED ISSUES WITH MY CAR NOT SHIFTING PROPERLY. IT'S AN AUTOMATIC TRANSMISSION SO I KNOW THERE WAS NOTHING I COULD BE DOING TO CAUSE THIS PROBLEM. THE CAR HAS BEEN SERVICED REGULARLY AND DRIVEN WITH CARE WHILE IN MY POSSESSION(I'M THE SECOND OWNER. NO SIMILAR ISSUES ON CARFAX REPORT). WHILE THE ENGINE IS COOL AND NOT YET AT ITS OPTIMAL TEMPERATURE THE DRIVE IS FINE AND YOU MAY NOT EVEN NOTICE A PROBLEM; HOWEVER, EVERY RIDE, ONCE WARMED UP THE CAR BEGINS TO SHIFT INCREDIBLY VIOLENTLY AS IT IS OBVIOUSLY STRUGGLING TO SWITCH GEARS. THIS OCCURS ALSO WHILE SLOWING DOWN AND THE CAR IS DOWNSHIFTING CREATING AN OPPORTUNITY TO BE "SLUNG" INTO A CAR FROM BEHIND(THIS HAPPENED IN THE MID SUMMER OF 2011). AFTER DROPPING THIS CAR OFF SEPTEMBER 15TH TO THE LOCAL MINI DEALERSHIP, I DID NOT HEAR FROM THEM FOR ALMOST...