2017 KIA SOUL EV Electrical System Problems

When I apply brake the vehicle doesn’t stop it jumps out (as if someone has crashed hitting the rear of the vehicle) and the vehicle shuts down. Then I have to park the vehicle in the middle of the road and restart the vehicle. Luckily I avoided many accidents by defensively driving. Talked with Kia customer care and complained about this safety issue . I took it to near by Kia dealer for the recall and complained on 25 July 2024. 2017 Kia soul + EV Only 30 thousand miles I’m scared to drive and conserned about the safety of others around me. Please help me

The contact owns a 2017 Kia Soul EV. The contact stated that while driving at an undisclosed speed, there was an abnormal battery voltage warning displayed. The vehicle went into LIMP Mode. The contact stated that the battery failed to charge. Several unknown warning lights were illuminated. The message to “Pull Over Immediately” was displayed. The vehicle was taken to the local dealer, where it was diagnosed that an update, BMS, and wiring harness needed to be replaced. The vehicle was repaired, but the failure recurred. The vehicle was towed back to the local dealer, where an unknown diagnosis and repair were performed. The manufacturer was contacted and opened a case. The failure mileage was approximately 50,000.

Application of the brakes causes complete vehicle shutdown along with message to check electrical system. Brakes appear to fail for a brief moment, then mechanical brakes kick in. Car has zero power until stopped and restarted. Problem is reproducible a high percentage of the time provided the brakes are pressed more than just lightly or briefly. At nearly full charge, this defect can also be triggered by just the engine brake (which is triggered every time your foot is taken off the accelerator). Appears to be an electrical short circuit of some type. Other faults occur upon application of power, shifting engine into low power or turtle mode at any level of battery charge.

The 2017 Kia Soul EV+ vehicle turned off coming down a steep hill (at the bottom of the steep hill is both a school bus stop and and entrance/exit to a condominium community). When the car shut off all power steering and power brakes were lost, making control of the vehicle very difficult and unsafe. The dealer reported finding a code for the battery overcharging but cleared the code and did not offer any explanation. This has happened multiple times including when I was videotaping the dash to document irregular discharge occurring from the battery. Similarly the vehicle will be driving fine (at any speed) and suddenly lose power and only go 20mph (known as limp mode), a very dangerous situation driving at highway speed and then trying to avoid an accident due to sudden vehicle deceleration. This problem started occurring after a Battery Management System patch was applied by...

This is an update of the below. I have had several email exchanges with Kia Customer Service. They contacted the dealer and report that they could not get a response from their own dealer! They said I could try another dealer if I want. I asked for a recommendation of a dealer that would be responsive and got no further communication. Meanwhile, my car continues to show low charging pattern, which the recall warns is a symptom of a fault. ====================================== Received an "Important Safety Recall" notice from Kia recall number 23v218 in May 2023. This indicates my Kia Soul EV by VIN. The notice warns of a possible short in the main battery that can cause a fire. The notice says Kia is working on a remedy and that another letter will follow when the remedy is ready. No second letter yet, as of 9/13/23. The recall notice states...

Received an "Important Safety Recall" notice from Kia recall number 23v218 in May 2023. This indicates my Kia Soul EV by VIN. The notice warns of a possible short in the main battery that can cause a fire. The notice says Kia is working on a remedy and that another letter will follow when the remedy is ready. No second letter yet, as of 9/13/23. The recall notice states that if in the meantime owner experiences "incomplete high voltage battery charging, loss/fluctuating vehicle EV battery range" to seek assistance from nearest authorized Kia dealership. My vehicle experienced rapid decrease in range, down below 60% of the full range over a period of weeks. Most recently charging the vehicle (using two different chargers) causes the circuit breaker at my home to trip, something that has never happened before. I contacted Kia America by phone and email. They said I should take...

Kia Garden grove is recommending people not get the recall done, and refusing to schedule and service the recall.

The contact owns a 2017 Kia Soul EV. The contact received notification of NHTSA Campaign Number: 23V218000 (Electrical System) however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact stated she had replaced the battery for second time. The failure mileage was unavailable.

My 2017 KIA Soul EV battery has not been holding a full charge since the beginning of April. The dealer was notified in early May that the charges were seeming to cut off early & provided with a log of charging/driving. We waited, then were told that a replacement battery would be ordered, installed, & considered under warranty. Diagnostic tests were run, we were advised. We were told that the car was safe to drive, although with about 50% of the mileage available (50-51 miles). The final paperwork (vehicle registr.) copy was filed on May 18. Now we have received a safety recall notice. I am afraid to drive the car, having seen news of what loss of life can happen a fire breaks out while driving! My dealer has not offered me help with an interim rental car to date, although I have requested this several times, specifically yesterday...

Original factory installed driver's side seat heater shorted out, caused fire and burned a hole in the seat back. This thermal event was reported to Kia Customer Service on March 16, 2023. Kia has not responded back for over 2 months, to address this issue. Kia case no. 15394468. Same problem with Kia Soul in Canada resulted in a recall to address the problem. Afraid to use the passenger side seat heater, as another short and fire can occur.

Power failure going high speed decreasing from 45mph. Had disengaged cruise control and attempted to change lanes and prepare to turn at intersection after exiting off highway. Also happened a week prior in town in neighborhood. No cruise control was involved and going low speed under 35mph. Had to shut power off completely to re-start EV. Previously had dealer run diagnostics following first incident. Recall gradual power loss incidents past four months but was uncertain what was cause.