2005 KIA SORENTO Engine Problems

When driving there was a clunking noise and then the steering was hard to steer and the battery light came on & had to have it towed to find out that the harmonic balancer bolt broke. There are hundreds of complaints online about this same issue happening with these engines as this is a poor design. This is a safety hazard and very dangerous since you loose the steering and should be recalled.

The contact owns a 2005 Kia Sorento. The contact stated while turning left, the steering wheel was very difficult to turn. The contact mentioned that all her strength was needed to turn the steering wheel. The vehicle was towed to an independent mechanic where it was diagnosed that the crankshaft bolt needed to be replace. The dealer was not contacted. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 100,000.

THE HARMONIC BALANCER MOUNTING BOLT SHEARED AND STRIPPED THE THREADS IN THE CRANKSHAFT OF MY 2005 KIA SERENTO. THE MECHANIC HAD MY CAR FOR 3 MONTHS TRYING TO FIX THIS PROBLEM. THIS IS EVIDENTLY A DESIGN ISSUE AND SHOULD HAVE A RECALL ISSUED. THIS PROBLEM COST ME A LOT OF MONEY TO FIX. (THE CAR WAS IN MOTION WHEN THE HARMONIC BALANCER FELL OFF) MY WIFE STRUGGLE TO GET THE CAR HOME DUE TO LOST OF BELTS.

KIA HAD A LAWSUIT INVOLVING THE CRANKSHAFT BOLT. THE LAWSUIT IS YVONNE ROBINSON VS KIA. I BOUGHT THE VEHICLE FROM SOMEONE WITH ONLY 25,000 MILES LAST YEAR 2017. MY CHILDREN WERE DRIVING BACK TO COLLEGE ON 11 AUGUST 2018. THE CRANKSHAFT BOLT BROKE WHICH CAUSES THE VEHICLE TO LOSE STEERING. MY CHILDREN WERE ALMOST IN A TERRIBLE ACCIDENT WHICH COULD HAVE COST THEM THEIR LIVES. MY SONS GO TO SCHOOL IN ATLANTA AND THE CRANKSHAFT BROKE IN NORTH CAROLINA. I HAD MY CHILDREN CALL OUR INSURANCE COMPANY FOR ROADSIDE ASSISTANCE AND THEY COULDN'T FIX IT OBVIOUSLY BECAUSE IT WAS THE CRANKSHAFT BOLT. HE GOT THEM SAFELY TO PEPBOYS AND THEY HAD TO SPEND THE NIGHT IN NORTH CAROLINA AND THE NEXT DAY PEPBOYS CONFIRMED IT WAS THE CRANKSHAFT BOLT. I FOUND OUT THERE WAS A LAWSUIT CONCERNING THE CRANKSHAFT BOLT. PEPBOYS SAID IT WOULD BE $2000 TO FIX. I CALLED...

TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING 10 MPH, THE CRANKSHAFT DETACHED FROM THE VEHICLE, CAUSING THE VEHICLE TO COME TO A COMPETE STOP. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO CONFIRMED THE FAILURE. THE VEHICLE WAS THEN TOWED TO THE DEALER (KIA STORE CLARKSVILLE, 826 E LEWIS AND CLARK PKWY, CLARKSVILLE, IN 47129, (866) 545-2429) WHERE THE CRANKSHAFT WAS REPLACED, BUT OIL STARTED LEAKING FROM THE CAMSHAFT SEAL AFTER THE REPAIRS. THE MANUFACTURER WAS CALLED AND STATED THAT FURTHER REPAIRS WERE NOT COVERED UNDER THE WARRANTY. THE FAILURE MILEAGE WAS 123,000.

WHILE DRIVING DOWN THE INTERSTATE THE CAR'S ENGINE CAUGHT FIRE. MELTED EVERYTHING IN ENGINE. WHEN TOLD I NEEDED A NEW ENGINE, I SOLD THE CAR TO A JUNK YARD FOR PARTS. NOW, I HEAR THIS RECALL. SO PISSED@

HAVE EXPERIENCED REPEATED FAILURE OF CAM SENSOR, CAM SHAFT PULLEY BOLT, FAILURE OF ENGINE COOLING SYSTEM, FAILURE OF CLUTCH ASSEMBLY AND TRANSMISSION, FAILURE OF AIR CONDITIONING, FAILURE OF ELECTRICAL SYSTEM FOR EXTERIOR LIGHTS.. ALL ISSUES ARE AS DOCUMENTED BY THE HUNDREDS AND HUNDREDS OF COMPLAINTS BY OTHER OWNERS WHO ARE WAITING FOR AN INVESTIGATION, A RECALL, OR ENOUGH DEATHS AND INJURIES TO RECEIVE ANY ASSISTANCE OF ANY KIND FROM THIS ORGANIZATION OR THE MANUFACTURER. I CAN NOT JUSTIFY SPENDING ONE MORE DOLLAR ( $16,000 IN THE 3 YEARS SINCE PURCHASED FOR $4,000).TO REPAIR THIS VEHICLE AND IT IS ONCE AGAIN INOPERABLE FOR THE SAME ISSUES. . NO CAR DEALER WANTS IT AS A TRADE IN, THE STANDARD OFFER IS $300. I CANNOT SELL IT TO ANYONE AND THEN FACE MYSELF IN MIRROR. PERHAPS A PUBLIC SAKE... $1 PER MINUTE TO ANYONE WHO WANTS TO BASH A KIA (SLEDGEHAMMER PROVIDED). PROCEEDS...

HARMONIC BALANCER IS FALLING OFF . HAVE READ MANY REVIEWS WHERE OTHERS WITH THE SAME VEHICLE AND THEIRS ARE ACTUALLY FALLING OFF. AS WELL AS A LAWSUIT IN FEBRUARY

THE ENGINE CAUGHT ON FIRE ON SUNDAY FEBRUARY 26 AND TODAY MARCH 1ST

MY VEHICLE WAS IN MOTION ON A HIGHWAY DRIVING 60 MILES PER HR TO WORK (30 MILES FROM HOME) IN POURING RAIN WHEN ENGINE, BRAKE AND BATTERY LIGHT CAME ON. THANK GOD THAT I MADE IT TO WORK SAFELY BUT THEN ONLY TO REALIZE THAT POWER STEERING HAD LOCKED UP. LOOKED UNDER THE HOOD, POWER STEERING FLUID AND BRAKE FLUID FINE BUT ONE BELT HAD CAME OFF AND THE OTHER BELT JUST BARELY HANGING ON FROM THE ALTERNATOR AND PULLEY. THOUGHT PULLEY HAD LOCKED UP BUT TOOK TO A MECHANIC JUST 1/2 MILE DOWN FROM MY JOB AND HE SAID THAT MY PROBLEM IS THAT THE CRANKSHAFT BOLT HAD BROKEN OFF INSIDE OF THE CRANKSHAFT. I GO ONLINE AND FIND THAT THERE WERE A LOT MORE COMPLAINTS OF THE SAME ISSUE WITH MY MAKE AND YEAR AS WELL AS OTHERS. THE PREVIOUS RECALL BY KIA WAS ONLY FOR 2003-2004 (CERTAIN...

DRIVING ON HIGHWAY RTE 24 WHEN CRANKSHAFT PULLEY BROKE OFF CAUSING ENGINE AND BRAKE LIGHTS TO COME ON. IT WAS IMPOSSIBLE TO CONTROL AND TO STEER THE VEHICLE CAUSING ME TO NEARLY GET INTO AN ACCIDENT. SUBSEQUENTLY, MY VEHICLE GOT TOWED FROM THE HIGHWAY TO A MECHANIC SHOP WHO INFORMED ME THAT MY 2005 KIA SORENTO'S CRANKSHAFT PULLEY BOLT BROKE OFF - THEREFORE TO BUY AN ENGINE OR JUNK IT. UNFORTUNATELY, I OWNED THIS VEHICLE FOR ONLY 1 YEAR 3 MONTHS AND WITH THESE PROBLEMS. I DON'T HAVE ANY MONEY TO REPLACE IT RIGHT NOW AND I DON'T KNOW WHAT TO DO TO GET TO WORK GOING FORWARD.

ON 07/14/16 I TRIED TO START MY VEHICLE. IT DID NOT START SO I CALLED A TOW TRUCK TO GIVE ME KICK START. THE ENGINE STARTED AND THE BATTERY LIGHT CAME ON, THIS IS THE FIRST TIME IT HAD. TWO DRIVER TOLD ME TO TAKE IT AND GET THE BATTERY CHECKED OUT IT JUST DIDN'T SEEM RIGHT TO HIM. SO I DID AND THAT IS WHEN I FOUND OUT THE I HAD A BLOWN HEAD GASKET AND UPON FURTHER INVESTIGATION THEY FOUND THAT THE COOLANT GOT INTO THE ENGINE AND TWO OF THE PISTONS WERE GONE AND THE INTERIOR WALL OF THE ENGINE WAS SCORCHED BADLY. THIS VEHICLE HAS BEEN TAKEN CARE OF I LOVED IT AND MADE SURE I FOLLOWED ALL THE REQUIREMENTS BU KIA TO KEEP THIS CAR RUNNING. WITH SUCH LITTLE MILES THIS SHOULD OF NEVER HAPPENED. IN MY INVESTIGATION, I FOUND SIMILAR REPORTS REGARDING KIA SORENTO'S...

DRIVING ACROSS A 4 LANE EXPRESSWAY, BARELY MADE IT ACROSS, THE VEHICLE SPUTTERS AND COMES TO A STOP AFTER FIGHTING WITH THE POWER STEERING LOSING ALL CONTROL. CRANKSHAFT PULLEY HAS DAMAGED THE ENGINE SO SEVERE, THAT A NEW ENGINE WAS PUT IN AT OUR EXPENSE ($5,000), GAS TANK WAS DISCOVERED TO HAVE A HOLE AND LEAKING GAS. AIR BAG LIGHT COMES ON AND OFF JUST DEPENDS ON IT'S MOOD, THE DISPLAY ON THE RADIO, ETC. GOES AWAY IN COLD WEATHER, AND NOW HAVE A CONSTANT THUMP THUMP WHEN DRIVING AS IF THE TIRE IS FLAT. DRIVING FOR 5 MONTHS WITH NEW ENGINE, I PRESSED ON THE ACCELERATOR QUICKLY TO PASS A TRUCK WHEN A LOUD NOISE (SOUNDING LIKE THE ENGINE BLEW) FROM THE ENGINE WAS HEARD THEN SOMETHING COMES LOOSE AND HITS THE UNDERCARRIAGE SO HARD I CAN FEEL IT THROUGH THE FLOORBOARD. NO SMOKE, NO ELEVATION IN TEMPERATURE. PULL...

IN NOVEMBER OF 2015, I WAS ON MY WAY HOME FROM WORK AND JUST PICKING MY ONE YEAR OLD UP FROM DAYCARE, WHEN I HEARD A LOUD SCREECHING NOISE FROM A BELT. MY GAUGES WENT WILD AND I MY POWER STEERING WAS IN AND OUT. BY THE TIME I HIT THE MAIN HIGHWAY TO GET HOME AS I WAS EXITING MY POWER STEERING WENT COMPLETELY OUT AND THE CAR COULD NOT BE DRIVEN ANY FURTHER, SO I HAD TO COAST TO THE SIDE OF THE ROAD. THIS WAS DURING RUSH HOUR TRAFFIC, I AM SOOOO LUCKY THAT I HADN'T QUIET ENTERED THE HIGHWAY YET. HAD TO GET TOWED HOME. GOT HOME AND NOTICED THE CRANKSHAFT BOLD WAS BROKEN AND THE BELTS WERE THROWN. WE FIXED IT AND NOW IT HAS JUST DONE IT AGAIN ON JULY 1ST AS I WAS BACKING OUT OF THE DRIVEWAY TO GO OUT OF TOWN....

WHILE DRIVING A NOISE COMES FROM ENGINE COMPARTMENT. BATTERY AND BRAKE WARNING LIGHT COME ON. POWER STEERING GOES OUT. HAVE TO MAN AHNDLE SUV TO A SAFE SPOT. CRANKSHAFT BOLT THAT HOLD HARMONIC BALANCER BROKE. COMMON PROBLEM KNOWN TO KIA ENGINES THEY OFFER TO FIX IT FOR $1300.00 PLUS MORE.

I PURCHASED A 2005 KIA SORENTO IN NOVEMBER 2013 FROM DEALERSHIP. IN JUNE 2014 I HAD THE FIRST INCIDENT. WHILE DRIVING ON A HIGHWAY, SUDDENLY ALL WARNING LIGHTS CAME ON, POWER STEERING WAS LOST. I WAS ABLE TO PULL OVER WITHOUT INCIDENT. HAD TO BE TOWED. HAD THE PROBLEM FIXED: CRANKSHAFT SENSOR, WARPED PULLEY, SHEERED BOLT ON SAID PULLEY, RESULTING IN MORE DAMAGE, INCLUDING WATER PUMP AND TIMING BELTS. TWO WEEKS LATER THE SAME THING OCCURRED, AGAIN WHILE I WAS DRIVING IN TOWN. MY MECHANIC SAID IT IS A DEFECT IN THE KIA DESIGN. TWO WEEKS LATER GOT IT FIXED. NOW TEN MONTHS LATER THE SAME PROBLEM OCCURS, AGAIN WHILE DRIVING. EACH TIME THIS HAS COST ME $2,000 TO FIX. I STILL OWE $4,500 ON THE VEHICLE! SINCE REPAIRING WITH KIA PARTS AND THE PROBLEM IS NEVER SOLVED DUE TO POOR DESIGN, KIA REALLY NEEDS TO STEP UP AND ISSUE...

TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT WAS ABLE TO RESTART THE VEHICLE; HOWEVER, IT WAS NOT ABLE TO FULLY ACCELERATE. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE HARMONIC BALANCER PULLEY BOLT FRACTURED FROM THE CRANKSHAFT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 105,000.

TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING APPROXIMATELY 60 MPH, THE CRANK PULLEY BOLT FRACTURED WITHOUT WARNING. THE FAILURE DISABLED THE STEERING WHEEL, WHICH MADE IT DIFFICULT TO CONTROL THE VEHICLE. THE CONTACT COASTED THE VEHICLE TO A STOP. A CERTIFIED MECHANIC STATED THAT THE CRANK PULLEY BOLT FRACTURED AND DETACHED FROM THE VEHICLE. THE CONTACT HAD THE VEHICLE TOWED TO THE DEALER FOR REPAIRS. AFTER THE REPAIR, THE VEHICLE STALLED WITHOUT WARNING AND LOST ALL STEERING POWER. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE ENGINE FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER INFORMED THE CONTACT THAT THE VEHICLE WAS NO LONGER UNDER WARRANTY FOR REPAIR. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. UPDATED 10/13/16*LJ *TR

TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE STOPPED AND SHUT DOWN WITHOUT WARNING. THE VEHICLE DID NOT RESTART AND WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE CRANKSHAFT BOLT DETACHED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT DID NOT RESPOND TO THE REIMBURSEMENT REQUEST. THE FAILURE MILEAGE WAS 82,310.

TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING APPROXIMATELY 25 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE FAILED TO RESTART AND WAS TOWED TO THE DEALER. THE VEHICLE REMAINED AT THE DEALER FOR THREE CONSECUTIVE MONTHS TO LOCATE THE FAILURE. THE CAM SENSOR, CRANK SENSOR, AND TIMING BELT WERE REPLACED. IN ADDITION, THE ECM COMPUTER WAS REPLACED. ONE MONTH LATER, AFTER THE REPAIR WAS PERFORMED, THE FAILURE RECURRED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 100,300. ..UPDATED 02/23/16 *BF....UPDATED 03/16/16 *BF *CN

BROKEN CRANK BOLT WITH 100,000 MILES.

I WAS DRIVING DOWN THE HIGHWAY AND ALL THE SUDDEN MY CAR GAVE A BIG SOUND AND DIED. THE STEERING WAS REALLY HARD TO STEER, LUCKLY I WAS IN THE SLOW LANE AND COASTED OFF THE EDGE OF THE ROAD. HAD IT TOWED TO MECHANIC THE STARTED WAS BAD, ALONG WITH THE FUEL LINE AND FUEL PUMP. AFTER GOT IT RUNNING ONCE AGAIN RAN FINE HOUR LATER THE CRANK SHAFT SENSOR WENT OUT. I HAVE READ MANY MANY COMPLAINTS ABOUT THE SAME ISSUES, ALSO WAS TOLD THAT MY FUEL TANK AND BOTTOM WAS RUSTING OUT. AND MY SWAY BAR IS BAD. MY CAR SHAKES, I HAVE HAD NEW TIRES AND BRAKES PUT ON AND A NEW MUFFLER PUT ON. I HAVE HAD ALL MY OIL CHANGES AND TUNE UPS. THEY SAY THERE IS NO RECALLS, HOW COULD THERE NOT BE RECALLS HERE IN THE USA. THEY HAD A CLASS ACTION...

I WAS TURNING ONTO A STREET AND HEARD A BIG CLUNK ONLY TO FIND OUT THE BOLT ON THE CRANKSHAFT BROKE OFF AGAIN ON 10/29/15 AS WELL AS 7/30/13. THE POWER STEERING WENT OUT & BATTERY LIGHT CAME ON. LOST POWER AND EVERYTHING AFTER A BIG CLUNK! THIS HAPPENS ALL THE TIME: THERE ARE A MULTITUDE OF THESE SAME COMPLAINTS: THIS ENGINE WAS REPLACED IN MAY 2010 AND THE HARMONIC BALANCER AND PULLEY HAVE BEEN WORKED ON TWICE SINCE 2010. THERE IS A DEFECTIVE BOLT THAT WAS REPLACED WITH A NEW DEFECTIVE BOLT. THIS IS HAPPENING NUMEROUS TIMES TO MANY KIA SORENTO OWNERS AND THEY ARE LEFT STRANDED. KIA KNOWS ABOUT IT AND REFUSES TO DO ANYTHING! MY CAR IS SITTING AT COUNTRY KIA IN CHARLESTON, SC BECAUSE THE EXTENDED- WARRANTY WILL NOT COVER THIS DEFECTIVE BOLT AND I CAN'T PAY $5000.00 ON A CAR THAT IS NOW ONLY WORTH...

HAD A CAR REPAIR IN OCTOBER 2014 DUE TO A BROKEN BOLT NEAR CRANK SHAFT DRIVING DOWN THE HIGHWAY. PAID FOR REPAIR AND GOT CAR BACK AND WITHIN A MONTH THE MOTOR WAS SHOT . I WENT TO GO START THE CAR TO GO TO WORK AND IT WAS MAKING A TERRIBLE NOISE, IT WAS STATIONARY. I STILL HAVE AT 7 MORE CAR PAYMENTS TO MAKE ON THE CAR.

THE KIA SORENTO HAS A CATASTROPHIC FAILOR DO TO A SINGLE PIN ON THE CRANK SHAT TIMING GEAR. THIS GEAR HAS BROKEN FREE TWICE AND CAUSED HEAD DAMAGE BENT VALVES AND ALSO COST BETWEEN 2 AND 4 THOUSAND DOLLARS TO REPLACE THE 30 DOLLAR GEAR THAT WILL WITH OUT QUESTION FAIL AGAIN I'M ON MY THIRD TIME OF THIS HAPPENING THIS TIME THE TIMING GEAR PIN GROW SLOWING ONLY THE CRANK SHAT HIMONIC BALANCER TO COME FREE BRAKING A 10 DOLLAR BOLT BUT WITH OUT A DOUBT IT WILL COST ME AGAIN THOUSANDS TO FIX . EACH TIME THIS HAS HAPPENED IT HAS BEEN A DIFFERENT SITUATION ONCE WAS WHILE DRIVING ON THE HIGH WAY THE VECHICAL MADE A LOUD BANG AND THE VECHICAL LIST POWER AND CAME TO A HALT ONCE WHILE PULLING OUT OF MY DRIVE WAY THIS TIME THE ENGINE LOCKED UP AND THE VEHICLE HAD TOBE...

THE VEHICLE'S POWER STEERING DIDN'T WORK, AND IT WAS RARELY DRIVEN AFTER TRANSMISSION REPAIR AT A KIA DEALER. LOOKING UNDER THE HOOD SHOWED THAT THE BELTS WEREN'T MOVING. THE CRANKSHAFT PULLEY WAS ATTACHED BUT NOT STRAIGHT; OFFSET. I CALLED THE DEALER AND THEY SAID THE CRANKSHAFT BOLT BREAKING IS A COMMON PROBLEM IN THESE VEHICLES. IS/WAS THERE A RECALL FOR THIS? THIS IS A POTENTIALLY DANGEROUS SITUATION. LUCKILY THE VEHICLE WASN'T DRIVEN FAR WHEN THE PROBLEM WAS NOTICED. MA 10/8 *CN

DRIVING IN RURAL EASTERN COLORADO WHEN THE BATTERY AND BRAKE WARNING LIGHTS CAME ON. DROVE ON TO THE NEXT TOWN WITH A REPAIR SHOP (BRUSH, CO) AND CHECKED UNDER THE HOOD. BELTS WERE LOOSE AND THE BOTTOM PULLEY WAS LYING IN THE BOTTOM OF THE ENGINE COMPARTMENT. HAD TO HAVE IT TOWED 70 MILES TO THE KIA DEALERSHIP IN WINDSOR, CO ($375). THEY DID THE REPAIR AND CHARGED $1303.85. HAD TO RENT A CAR WHILE THE REPAIR WAS COMPLETED ($343.57). HARMONIC BALANCER HAD FAILED AND CAUSED DAMAGE TO TIMING BELT, TENSIONER, CRANK SPROCKET, ETC. UPDATED 10/9/15 *LN UPDATED 12/21/2015*JS

CRANK SHAFT BOLT BROKE THREE SEPARATE TIMES (2ND TIME JAN. 21, 2015; 3RD TIME JULY 3, 2015) AFTER REPAIRS MADE. THE LAST TIME, THE CAR WAS CONSIDERED IRREPARABLE DUE TO THE INEVITABILITY OF FAILURE DUE TO FAULTY DESIGN OF THE FACTORY MADE CRANK SHAFT BOLT. WHOLE NEW ENGINE NEEDED FOR COMPLETE REPAIR.

I WAS DRIVING THOUGH A PARKING LOT ON LATE FRIDAY AFTERNOON AND HEARD A RATTLING NOISE COMING FROM UNDER THE HOOD. SO, AFTER I PARKED I POPPED THE HOOD, I ALSO STARTED TO HEAR A SQUEAKING NOISE (BELTS RUBBING), SO I DROVE HOME AND PARKED IT UNTIL MONDAY WHEN I TOOK IT TO A LOCAL SHOP AND THEY SAID IT SOUNDED LIKE A PULLEY FOR THE TIMING BELT, THEY GOT IT IN ON WEDNESDAY AND CALLED TO HAVE ME COME TAKE A LOOK AT WHAT WAS CAUSING THE NOISES WHEN I GOT THERE, THEY EXPLAINED THAT IT WAS THE CRANKSHAFT BOLT THAT HELD THE FLY WHEEL ON AND THERE WHERE TWO OPTIONS (1)I COULD DRIVE IT UNTIL THE BOLT SNAPPED OR (2) THEY COULD TRY AND BREAK THE BOLT LOOSE AND REPLACE IT, SO WE WENT WITH OPTION NUMBER 2 AND AFTER ABOUT FIVE HOURS I GOT A CALL TELLING...

TL* THE CONTACT OWNS A 2005 KIA SORENTO. THE CONTACT STATED THAT WHEN THE KEY WAS TURNED TO THE OFF POSITION AND REMOVED, THE VEHICLE FAILED TO SHUT OFF. THE CONTACT REMOVED THE BATTERY FROM THE VEHICLE, BUT THE VEHICLE CONTINUED TO RUN. THE CONTACT THEN REMOVED AN AIR MASK VALVE THAT CAUSED THE ENGINE TO SHUT OFF. THE VEHICLE WAS UNABLE TO BE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 95,000. MA 08/05/15 UPDATED 11/13/2015*JS

I HAVE A 2005 KIA SORENTO AND LAST AUGUST I WAS COMING TO A STOP AT A VERY BUSY INTERSECTION AND MY CAR MADE A VERY LOUD CLANKING BANG SOUND. MY CAR DIED, MY BATTERY, BRAKE AND ENGINE LIGHT CAME ON. I TURNED THE KEY AND IT STARTED AND I WAS ABLE TO GET IT OFF THE ROAD BUT MY POWER STEERING WAS GONE. I HAD IT TOWED TO A GARAGE THAT SAID THEY WOULD NOT FIX IT BECAUSE IT WAS TO INTENSE (COST $150), SO I HAD IT TOWED TO ANOTHER. AN ASE CERTIFIED CHEVROLET DEALERSHIP AND THEY TOLD ME IT SHOULD BE COVERED UNDER MY WARRANTY BECAUSE IT WAS PART OF THE POWER TRAIN AND I HAD LESS THAN 60,000 MILES ON MY VEHICLE- MY CRANKSHAFT BOLT WAS SHEARED COMPLETELY OFF (NO CHARGE). THEY AND I CONTACTED KIA, KIA HAD ME TOW IT TO THEM (WHICH IS 50...

AT A STOP LIGHT, I HEARD AND FELT A SHUDDER THROUGHOUT THE VEHICLE. THE BRAKE AND BATTERY LIGHT CAME ON IMMEDIATELY AFTER THE SHUDDER. THE ENGINE CONTINUED TO RUN NORMALLY. PROCEEDING THROUGH THE INTERSECTION, I EXPERIENCED THE LOSS OF POWER STEERING MAKING THE CAR VERY DIFFICULT TO CONTROL. MANAGED TO GET THE VEHICLE TO A NEARBY PARKING LOT WHERE I CALLED FOR A TOW TO THE KIA DEALER. DEALER CONFIRMED A SHEARED CRANK SHAFT BOLT. INCIDENT OCCURRED ON A BUSY STATE HIGHWAY DURING RUSH HOUR. SPEED LIMIT IS 45 MPH ON THIS STRETCH OF ROAD AND VERY BUSY AT RUSH HOUR. HAD THE VEHICLE BEEN IN MOTION AT THE TIME OF THE PART FAILURE THERE WOULD HAVE BEEN AN ACCIDENT. *TR

DURING MY TRIP HOME FROM A LOCAL OUTING I NOTICED MY BATTERY LIGHT FLASHING INTERMITTENTLY. AS I GOT CLOSER TO HOME THE LIGHT BECAME MORE STEADY STEERING BECAME MORE DIFFICULT. I HAD A GOOD GUESS WHAT THE PROBLEM WAS DUE TO THE FACT THAT I'VE HAD THIS SAME ISSUE TWICE IN THE LAST EIGHT MONTHS. I MADE IT HOME SAFELY AND HAD MY VEHICLE TOWED A FEW DAYS LATER TO A REPAIR SHOP. I WAS NOT AT ALL SURPRISED WHEN THE MECHANIC TOLD ME I HAD A CRANK SHAFT PROBLEM. THIS IS SOMETHING KIA HAS KNOWN ABOUT FOR YEARS AND SHOULD HAVE SCHEDULED A RECALL TO REPAIR THIS ISSUE. I MIGHT NOT BE HERE TODAY IF I WAS TRAVELING ON THE HIGHWAY AT A FASTER SPEED. *TR

VEHICLE DIED WHILE DRIVING, THEN WOULD NOT CRANK OVER. HAD TOWED TO DEALER. VEHICLE WAS NO LONGER COVERED BY WARRANTY. DEALER REPLACED CAM AND CRANK SENSORS, TIMING BELT, CRANK BOLT AND BADLY FRAYING ACCESSORY DRIVE BELT. *TR

DRIVING APPROX 55MPH, MY LIGHTS SEEMED TO DIM THEN MY BATTERY AND BRAKE LIGHT CAME ON. I IMMEDIATELY TURNED MY HEATER, RADIO, DASHBOARD LIGHTS AND LIGHTS TO LOW. I CONTINUED DRIVING FOR NOTHING ELSE SEEMED TO BE WRONG AND WAS GOING TO PULL OVER WHEN I NOTICED MY POWER STEERING ALSO WAS NOT WORKING. I WAS ABLE TO GET MYSELF TO A SAFE PLACE TO STOP AND PUT THE CAR IN PARK, IT BEGAN MAKING AN ODD SOUND (THINKING A POSSIBLE BELT) IT THEN MADE A POPPING SOUND THINKING I BROKE A SERPENTINE BELT, I THEN TURNED THE ENGINE OFF AND HAD MY MECHANIC LOOK AT IT. HE SAID THE CRANKSHAFT BOLT HAD BROKEN OFF AND WAS AN ESTIMATED $3000+ REPAIR. I HAVE ALSO HAD ISSUES WITH CRANKSHAFT SENSOR WHICH CAUSED MY CAR TO NOT TURN OVER WITHOUT A JUMP. AFTER THAT WAS REPAIRED I HAD TO BUY A NEW...

ON JULY 13TH 2013 I STARTED FINANCING A 2005 KIA SORRENTO LX FROM A DEALERSHIP IN PINELLAS PARK, FLORIDA CALLED E-Z CAR CREDIT. DURING THE FIRST MONTH OF FINANCING THE CAR HAD TO BE SERVICED FOR MANY DIFFERENT REASONS. OVER THE LAST YEAR AND A HALF OF FINANCING THE PROBLEMS HAVE GOTTEN WORSE AN MORE EXPENSIVE. PROBLEMS INCLUDE BUT NOT LIMITED TO: OVERHEATING, BAD SENSORS, FRONT END ALIGNMENT, NEW WATER HOSES, NEW WATER RESERVOIR, THERMOSTAT, POWER STEERING, ELECTRICAL. AN THEN WE COME TO THE MOST RECENT PROBLEM. THE ONE 1,000S UPON 1,000S OF CUSTOMERS HAVE BEEN HAVING "CATASTROPHIC ENGINE FAILURE" BROKEN PUSH RODS, CAMS DESTROYED, VALVES, PISTONS. ESTIMATED COST $4000. AN NOW THAT I HAVE $7,000 INVESTED AND OWE ANOTHER $5,000 ON MY LOAN I AM JOINING THE CLASS ACTION LAWSUIT AGAINST KIA MOTORS. *JS

I WAS STOPPED WAITING TO TURN INTO A FAST FOOD PLACE WHEN I LET OFF THE BRAKES TO TURN IN ,THE SUV TOOK OFF FROM 0 TO 60 IN A SPLIT SECOND.WHEN I TRIED TO MASH THE BRAKES IT WOULDN'T GO DOWN AND I COULDN'T STOP.I ENDED UP HITTING A TREE,THE AIR BAGS DID COME OUT.THE SUV WAS TOTALED.I CONTACTED KIA'S OFFICE AND THEY HAD THE SUV TOWED TO A LOT FOR INVESTIGATION.AS OF THIS DATE I HAVEN'T HEARD FORM KIA AS TO WHAT THEY FOUND OUT.THIS WAS THE SECOND TIME THE KIA TOOK OFF ON IT'S OWN WITH ME .I WOULD LIKE THIS ACCIDENT OFF MY RECORD AND INFO AS TO WHAT WENT WRONG WITH THE KIA. *TR

TL* THE CONTACT OWNS A 2005 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING 30 MPH, AN ABNORMAL NOISE EMITTED FROM UNDER THE HOOD AND THE POWER STEERING SEIZED. THE CONTACT DISCOVERED THAT NONE OF THE BELTS IN THE VEHICLE WERE MOVING. THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE TECHNICIAN DIAGNOSED THAT THE CRANK SHAFT DAMPER, HARMONIC BALANCER AND THE GEAR NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 40,000.

FIRST INCIDENT-ON AUGUST 16, 2014 WHILE ON VACATION AND DRIVING FROM VIRGINIA TO CHICAGO ILL, THE VEHICLE START MAKING A RATTLING NOISE COMING FROM THE FRONT OF THE VEHICLE AND WARNING LIGHTS CAME ON THE DASH (BATTERY, BRAKE) AND THE POWER STEERING WENT OUT MAKING THE VEHICLE VERY HARD TO MANEUVER, I IMMEDIATELY PULLED OVER INTO A FAST FOOD PARKING LOT TO CHECK THE NOISE AND FOUND THAT THE HARMONIC BALANCER WAS LOOSE AND BELTS WERE NOT TURNING, I HAD THE VEHICLE TOWED TO A MECHANIC AFTER INSPECTION I WAS INFORMED THAT THE CRANK SHAFT GEAR PIN HAD BROKE OFF TO THE HARMONIC BALANCER. I PURCHASE THE PARTS (HARMONIC BALANCER, BOLT AND CRANK SHAFT GEAR) AND HAD THE MECHANIC REPAIR THE VEHICLE AND DROVE BACK TO VIRGINIA. SECOND INCIDENT-OCTOBER 2014 WHILE MY WIFE WAS DRIVING THE VEHICLE, SHE ENCOUNTERED THE SAME PROBLEMS THE WARNING LIGHTS, RATTLING IN THE FRONT OF...

WHILE LEAVING OUR HOME TO RUN ERRANDS, I LOST POWER STEERING AND SEVERAL DASHBOARD LIGHTS CAME ON. WE PURCHASED THE KIA SORENTO IN 2005 NEW AND HAVE HAD VERY FEW PROBLEMS WITH IT UNTIL NOW. IT HAS LESS THAN 70K MILES AND HAS BEEN SERVICED BY THE DEALER EVERY 3K MILES. I HAD THE VEHICLE TOWED TO THE DEALER, WHO RATHER QUICKLY DIAGNOSED THE PROBLEM AS A BROKEN CRANK BOLT AND ESTIMATED REPAIRS WOULD COST ABOUT $1300. THE DEALER CHECKED WITH KIA ON WHETHER OUR 100K WARRANTY WOULD COVER THE REPAIRS. KIA SAID THIS PROBLEM WAS NOT COVERED. AT THE TIME I DIDN'T REALIZE THIS IS A FAIRLY COMMON PROBLEM WITH THE KIA SORENTO'S. CHECKING THE COMMENTS FROM OTHER SORENTO OWNERS, I HAVE CONCLUDED THIS CERTAINLY APPEARS TO BE A DESIGN DEFECT. OUR CONCERN IS THAT THIS COULD HAVE HAPPENED IN TRAFFIC AT 70 MPH AND THE LOSS OF THE...

ON 8/23/2014 MY FAMILY A I WERE IN CHICAGO WE TRAVELED THERE ON FRIDAY 8/22/2014 FROM VIRGINIA IN THE 2005 KIA SORENTO THAT I JUST PURCHASED IN JULY 2014 FROM PEARSON HYUNDAI. WHILE DRIVING TO MY FAMILY REUNION IN THE FOREST RESERVES THE VEHICLE BRAKE LIGHT AND OTHER WARNING LIGHTS CAME ON, AND A RATTLE COULD BE HEARD COMING FROM THE ENGINE, THE VEHICLE BECAME HARD TO STEER AND THE NOISE FROM THE ENGINE BECAME LOUDER. I STOPPED THE VEHICLE AND HAD IT TOWED TO MY FAMILIES MECHANIC, AFTER CHECKING THE VEHICLE IT WAS FOUND TO HAVE THE PIN ON THE CRANK GEAR BROKEN OFF, AND THE CRANK BOLT CAME LOOSE, REPLACED THE SPROCKET (CRANK GEAR), THE HARMONIC BALANCER, AND THE BOLT. I DROVE THE VEHICLE BACK TO VIRGINIA WITH NO PROBLEM, THEN ON OCTOBER 3, 2014 WHILE MY WIFE WAS DRIVING IN RICHMOND, VA THE EXACT SAME THING HAPPENED...

THE CRANKSHAFT SPROCKET KEY (PIN) GOT LOOSE AND THE SPROCKET DISPLACED WHICH CHEWED THE TIMING BELT AND SHORT-CIRCUITED THE CRANKSHAFT SENSOR AND FUEL PUMP, CAUSING $1946.03 OF REPAIR, $213.67 CAR RENTAL DURING REPAIR, LOSS OF WORKING TIME AND STRESS TO ME WITH HEALTH DAMAGE. THE TOTAL LOSS IS ESTIMATED TO BE $3,000.00 AT LEAST. *TR

KIA SORENTO 2005, SIMILAR CRANK BOLT MAIN PULLEY ASSEMBLY BREAK THAT MANY, MANY OF THE OTHERS HAVE ALL BEEN COMPLAINING ABOUT AND UNFORTUNATELY BEEN EXPERIENCING. THIS IS THE THIRD TIME I HAD THIS VERY SAME ISSUE REPAIRED FOR SUBSTANTIAL DOLLARS AND NOW MY MECHANIC STATED THERE IS NOT ENOUGH THREAD LEFT INTO THE CRANKSHAFT TO FIX AND IT NEEDS A COMPLETELY REBUILD OR ENGINE REPLACEMENT - WHICH IN ALL LIKELIHOOD BE LESS EXPENSIVE. THERE SHOULD DEFINITELY BE A RECALL FOR THIS - AS SO MANY HAVE THE SAME ISSUE. THANK GOD MY INCIDENTS WERE ALL AT SLOW SPEED BECAUSE THIS WOULD EASILY CAUSE A CRASH BECAUSE YOU LOOSE ALL POWER STEERING AND CONTROL. *TR

DRIVING APPROXIMATELY 55MPH 22 NOV 2013, HEARD A THUMP FROM ENGINE COMPARTMENT, AND LOST ALL POWER TO VEHICLE, ENDING UP IN A DITCH. ENGINE STOPPED, NO STEERING, NO BRAKES. DASH LIGHTS ILLUMINATED. VEHICLE WOULD NOT RE-START. CRANK PULLEY BOLT BROKE OFF. OVER 5 HOURS TO EXTRACT REMAINDER OF BOLT TO REPAIR ENGINE. $1359 IN REPAIRS. NOW, 22 SEPT 2014, 10 MONTHS LATER, HAD SAME HAPPEN ON HIGHWAY AT 70MPH IN HEAVY TRAFFIC. THANKFUL I WAS IN A LANE AT THE EDGE OF THE ROADWAY. CURRENT MILEAGE SLIGHTLY UNDER 114,000. YEAH. 10 MONTHS AND 13000 MILES AND ANOTHER HUGE REPAIR BILL. NO RECALL, KIA CLAIMS NO LIABILITY. OTHER ISSUE: INTERIOR LIGHTING TURNS ITSELF OFF AND ON AT WHIM. HEADLIGHTS BURN OUT EVERY 45-90 DAYS. *TR

IN SEPTEMBER 2012, TRAVELING AT 35MPH MY KIA CAME TO A STOP. AT FIRST GLANCE IT WAS DETERMINED THE DRIVE BELTS HAD UNFASTENED AND THE CAM SHAFT BOLT WAS LAYING ON THE ENGINE PAN. AFTER INSPECTION AT KIA SERVICE SHOP THE SPECIALIST IDENTIFIED THAT THE CAM SHAFT BOLT HAD SHEERED OFF DUE TO THE DEFECTIVE PART: CAM SHAFT SPROCKET-C, PART # 23120-35701 COST $60.00. THE FINAL SUGGESTION WAS TO REPLACE THE BOLT SET, SPROCKET, CRANK ANGLE SENSOR, DAMPER PULLEY, AUTO TENSIONER AND ALL DRIVE BELTS A TOTAL OF $2,000 REPAIR COST. IN 2014, THE COST REPAIR IS NOW 4,000 TO REPLACE THE ENGINE BECAUSE OF THE SAME EXACT ISSUE BUT TRAVELING OVER 40MPG CAUSING MORE DAMAGE. THE MAIN CAUSE OF THIS DEFECT DERIVES FROM THE SMALL PIN ATTACHED TO THE SPROCKET THAT TURNS THE HARMONIC BALANCER AND GRINDS THE STEEL WITH THE FORCE OF THE ENGINE INTO NOTHING. THE RESULT...

TL* THE CONTACT OWNS A 2005 KIA SORENTO. WHILE DRIVING APPROXIMATELY 30 MPH, THE POWER STEERING FAILED WITHOUT WARNING AND THE VEHICLE BECAME INCREASINGLY DIFFICULT TO CONTROL. THE DEALER STATED THAT THE CAMSHAFT NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 117,000.

DAUGHTER HAD CRANKED VEHICLE AFTER COMING INTO GRANDMOTHER'S AFTER HER WEDDING GETTING FOOD. SHE SAID THE STEERING WAS WORKING PROPERLY AND THE MOTOR SEEMED TO BE HAVING ALOT OF PROBLEMS SO I TOLD HER TO PARK IT AND NOT TO DRIVE IT AGAIN THAT I WOULD HAVE IT TOWED TO BE LOOKED AT.MY NEPHEW LOOKED AT IT SAID IT SEEMED TO BE THE BOLT COMING OUT OF HARMONIC BALANCER. I BOUGHT IT USED BUT IT WAS PURCHASED AT KIA IN HUNTERSVILLE,N.C. FROM THE PERSON I PURCHASED IT FROM. AFTER TAKING IT BACK THERE TO BE LOOKED AT THEY DID UNAUTHORIZED WORK BREAKING THE BOLT OFF THEN TELLING ME I HAD TO BE THE ONE TO REPLACE THE MOTOR. I EVEN WENT TO KIA IN GASTONIA,N.C. THEY DIDN'T SEEMED TO BE CONCERNED AT ALL AND SAID THEY WOULD NOT EVEN TAKE IT AS A TRADE IN SO I STARTED DOING RESEARCH...

FROM THE TIME I GOT THE CAR HEAD LIGHTS HAVE REPEATEDLY BURNED OUT AFTER A MONTH OR TWO, ALSO DASH LIGHTS GO OFF RANDOMLY AND FLICKER AND THEN COME BACK ON WHEN EVER THEY DECIDE,MY POWER STEERING WENT OUT, BRAKE LIGHT CAME ON AND A/C WENT OUT ALL AT ONCE. STARTED TO OVERHEAT, SO IT WAS DETERMINED THE SERPENTINRE BELT HAD BROKE,REPLACED BELT AND VIBRATION UNDER HOOD WAS NOTICEABLE BUT COULD NOT DETERMINE THE SOURCE., BUT SOMEWHERE UNDER THE HOOD. STILL REPLACING HEADLIGHTS EVERY COUPLE MONTHS, THEN POWER STEERING FLUID STARTED TO BE CONSUMED AND CONSTANTLYT REQUIRED ADDING FLUID, THEN HAD A MECHANIC CHECK FOR LEAK AND HE REPLACED SOME HOSES AND CLAMPS BUT VIBRATIION CONTINUED AND EVENTUALLY POWER STEERING BEGAN LOUD NOISE WHEN CAR STARTED AND ONLY WHEN REVED UP WOULD NOISE STOP, AND WHEN A/C WAS ON SOMETIMES WOULD EFFECT THE POWER STEERING NOISE. REPLACED THE POWERSTEERING PUMP,...

THE ENGINE DEVELOPED A VERY LOUD TICK/KNOCK IN THE MOTOR. *TR

I RECENTLY HAD TO HAVE THE CRANK SHAFT SENSOR REPLACED ON MY 2005 KIA SORENTO. THIS MORNING, DRIVING MY YOUNG SON TO SCHOOL, I LOST THE STEERING ON MY VEHICLE. ADDITIONALLY, THE ENGINE LIGHT AND BRAKE LIGHT CAME ON. AS I UNDERSTAND IT, THIS IS AN ONGOING DEFECTIVE ISSUE WITH KIA'S. THIS IS A DANGEROUS PROBLEM FOR THE PUBLIC AS WELL AS CONSUMERS. *TR