2003 KIA SORENTO Engine And Engine Cooling Problems

THE CRANK BOLT BROKE JULY 23, 2013. THE SECOND TIME WAS, THE CRANK BOLT AGAIN AND IT BROKE DECEMBER 19, 2014. THE ODOMETER WAS AT 133181 FOR THE SECOND BOLT BREAK. *TR

DRIVING TO STORE AND HEARD NOISE. SEVERAL WARNING LIGHTS CAME ON AND I HAD NO POWER STEERING. RETURNED HOME AND FOUND CRANK PULLEY AND BROKEN CRANK PULLEY BOLT LAYING IN THE SKID PLATE. *TR

TL* THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING 40 MPH, THE CONTACT NOTICED THAT THE FRONT END OF THE VEHICLE BEGAN TO VIBRATE. THE VEHICLE WAS TAKEN TO THE DEALER, WHERE THE CRANK SHAFT PULLEY BOLT WAS REPLACED. THE FAILURE CONTINUED. THE FAILURE MILEAGE WAS 83,000 AND THE CURRENT MILEAGE WAS 107,000.

2003 KIA SORENTO. CONSUMER STATES BOLT LOOSENED WHILE DRIVING *TGW THE CONSUMER STATED WHILE DRIVING, THE BRAKE AND BATTERY LIGHT ILLUMINATED. THE CONSUMERS HUSBAND SOON DISCOVERED IT WAS DIFFICULT TO TURN THE STEERING WHEEL. HER HUSBAND WAS ABLE TO PULL OVER TO THE SIDE OF THE ROAD. AS HE EXAMINED THE VEHICLE, HE TOUCHED A BOLT, WHICH WAS EXTREMELY HOT, AND IT WAS THE SAME BOLT THAT WAS RECALLED, WHICH HAD BECOME LOOSE AGAIN. THE VEHICLE WAS TOWED TO THE DEALER. THE CONSUMER WAS INFORMED THE VEHICLE NEEDED A NEW ENGINE AT A COST OF $6,000 EVEN THOUGH THERE WAS NO DAMAGE TO THE REST OF THE ENGINE. THE CONSUMER WANTED THE BOLT TO BE RE-THREADED. THE DEALER ADVISED THE CONSUMER, THEY DID NOT HAVE THE EQUIPMENT, TO PERFORM THE RE-THREAD OF THE BOLT, BUT INSTEAD OF NEEDING A NEW ENGINE, THEY COULD REPLACE THE CRANKSHAFT AT A COST OF...

CRANKSHAFT BOLT RECALLED 2007 THEY BREAK OFF RECALL DONE CRANKSHAFT BOLT BROKE ON 2011CRANKSHAFT BROKE KIA WILL NOT FIX RECALLED PART. *TR

TL* THE CONTACT OWNS A 2003 KIA SORRENTO. THE CONTACT STATED THAT AFTER STARTING THE VEHICLE, A LONG BANG WAS HEARD FROM UNDER THE VEHICLE AS IT STALLED. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE CRANK SHAFT PULLEY DETACHED FROM THE VEHICLE ABNORMALLY. THE VEHICLE WAS REPAIRED YET THE FAILURE RECURRED LATER WHILE THE CONTACT WAS DRIVING 40 MPH.THE VEHICLE WAS AGAIN TOWED TO THE DEALER WHERE THE DEALER CONFIRMED THAT THE CRANKSHAFT PULLEY HAD YET AGAIN, DETACHED FROM THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE VEHICLE WAS REPAIRED A SECOND TIME. THE FAILURE MILEAGE WAS 32,500 AND THE CURRENT MILEAGE WAS 76,000.

TL* THE CONTACT OWNS A 2003 KIA SERENTO. THE CONTACT STATED THAT THE BOLT TO THE HARMONIC BALANCER WOULD FRACTURE AT ANYTIME. THE CONTACT ALSO STATED THAT THE DEALER REPAIRED THE FAILURE ONCE, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED, BUT DENIED ASSISTANCE WITH REPAIRS. THE FAILURE MILEAGE WAS 69,000 AND THE CURRENT MILEAGE WAS 84,000. THE VIN WAS UNAVAILABLE.

WAS DRIVING APPROX 60 MILES PER HOUR AND FUEL PRESSURE DROPPED; ENGINE SHUT OFF. WAS ABLE TO RESTART AND DRIVE BUT FOR ONLY A FEW MILES AT THE TIME. THIS HAPPENED OVER COURSE OF COUPLE OF DAYS. HAD FUEL PUMPED REPLACED. AFTER FUEL PUMP WAS REPLACED I HAD PROBLEMS FUELING VEHICLE. GAS WOULD BUBBLE UP AND SPRAY OUT OF GAS TANK. HAD TO PUMP SLOWLY. GAS WOULD GET ALL OVER ME, VEHICLE AND GROUND. RETURNED VEHICLE BACK TO REPAIR SHOP SIX TIMES OVER THE COURSE OF SIX WEEKS; HAD OTHER PART REPLACED. VEHICLE STILL LOSING FUEL PRESSURE, SHUTTING OFF AND NOT ABLE TO PUMP GAS WITHOUT IT SPURTING OUT OF TANK. VEHICLE PARKED AS I FEEL IT IS NOT SAFE TO DRIVE FOR ME OR DAUGHTER. OUT OF 600 DOLLARS AND NOT VEHICLE TO DRIVE. SOMETHING FROM MANUFACTURER SHOULD BE DONE. THIS IS A DANGEROUS SITUATION. I AM AFRAID OF...

CRANKSHAFT BOLT WAS REPLACED AFTER RECALL IN 2007. CRANKSHAFT SENSOR WAS REPLACED IN APRIL 2011 AFTER MALFUNCTIONING AND CAUSING CAR TO STALL OUT AT ANYTIME, INCLUDING WHILE DOING 65 ON THE FREEWAY. WHILE DRIVING A FEW DAYS BACK, SUDDEN LOSS OF POWER STEERING AND BRAKE AND BATTERY LIGHTS CAME ON. HAD CAR TOWED TO DEALERSHIP WHERE WE WERE TOLD THAT THE BOLT, WHICH HAD BEEN REPLACED PER THE RECALL, HAD BROKEN, BUT THE WARRANTY ON THE REPLACED BOLT IS ONLY 1 YEAR. NOW REPAIR ON THIS WILL COST OVER $300 AND NEW BOLT WILL STILL ONLY BE WARRANTIED FOR ONE YEAR. SO THIS SAME PROBLEM WITH THIS FAULTY PART COULD CONTINUE, BUT THE PART IS ONLY UNDER WARRANTY FOR ONE YEAR. *TR

TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 15 TO 20 MPH WHEN THE VEHICLE WOULD SUDDENLY STALL. THE VEHICLE WAS TOWED ON A FEW OCCASIONS AND OTHER TIMES HE WAS ABLE TO RESTART IT ON ITS OWN. THE VEHICLE WAS INSPECTED BY A INDEPENDENT MECHANIC AND THEY ADVISED HIM THAT IT WAS THE FUEL PUMP. THE VEHICLE WAS REPAIRED FOR THE FUEL PUMP. ON ANOTHER OCCASION IT WAS TOWED AGAIN AND THEY ADVISED HIM THAT THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE HAS NOT BEEN REPAIRED AGAIN. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS APPROXIMATELY 79,400.

TL* THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT THE BOLT CRANKSHAFT SENSOR BOLT FAILED AND CAUSED THE BELTS TO FRACTURE AND THE POWER STEERING TO MALFUNCTION. THE VEHICLE WAS TAKEN TO A LOCAL REPAIR SHOP WHERE IT WAS REPAIRED YET THE FAILURE RECURRED SHORTLY AFTER. THE VEHICLE WAS NOT FURTHER REPAIRED. THE CONTACT CALLED THE MANUFACTURER WHO OFFERED NO ASSISTANCE. THE CURRENT MILEAGE WAS APPROXIMATELY 106,000 AND THE FAILURE MILEAGE WAS APPROXIMATELY 78,000.

2003 KIA SORENTO. CONSUMER STATES SEVERAL PROBLEMS WITH VEHICLE *TGW THE CONSUMER STATED ON TWO OCCASIONS, THE PIN THAT HELD THE CRANKSHAFT TOGETHER BROKE LOOSE. THE CRANKSHAFT SENSOR LOCATED BEHIND THE TIMING BELT FAILED. *JB

TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE ENGINE CRANKSHAFT BOLT FAILED IN AUGUST OF 2008. THE DEALER REPLACED THE ENGINE CRANKSHAFT BOLT FOUR TIMES. THE REPAIRS DIDN'T CORRECT THE FAILURE. THE MANUFACTURER STATED THAT THE CONTINUOUS FAILURES WERE DEALER ERROR, AND THEY WOULD NOT ASSIST WITH THE REPAIR. THE VEHICLE HAD NOT BEEN REPAIRED. THE FAILURE MILEAGE WAS 111,404 AND THE CURRENT MILEAGE WAS 118,000.

I HAVE HAD MY 2003 KIA SORENTO SINCE MARCH 2010. IT WAS PURCHASED WITH 32,000 MILES ON IT, AND AS OF THE END OF OCTOBER 2010, IT HAD 36,000 MILES. SO FAR, I HAVE HAD TO REPLACE THE COOLANT RESERVOIR, BECAUSE IT WAS CRACKED. I WAS DRIVING, AND IT OVERHEATED OUT OF NOWHERE. IT WAS IN THE SHOP FOR FOUR DAYS, BECAUSE THEY COULD NOT FIND THE PROBLEM EVEN AFTER DOING SEVERAL PRESSURIZED SYSTEMS TESTS. AT THE END OF OCTOBER 2010, I HAD TO REPLACE THE OIL PUMP, BECAUSE IT HAD A CRACK IN IT. NO ONE ANYWHERE I CALLED COULD BELIEVE I HAD TO REPLACE AN OIL PUMP. ALL THE MECHANICS STATED THAT'S ONE OF THE FEW THINGS THEY NEVER HAVE TO REPLACE ON ANY VEHICLE, AND CERTAINLY NOT AT 36,000 MILES. ANYWAY, DUE TO OIL LEAKING ONTO THE TIMING BELT, THAT HAD TO BE REPLACED ALSO. THE TIMING...

CRANKSHAFT PULLEY BOLT FAILED. BROUGHT TO DEALER FOR REPAIR. BOLT WAS PART OF NHTSA RECALL. DEALER STATED THEY NEEDED TO REPLACE CRANKSHAFT AS WELL. DEALER RETURNED VEHICLE W/O REPLACING CRANKSHAFT. 15 MONTHS LATER THE SAME BOLT FAILED. TOOK TO AN INDEPENDENT REPAIR SHOP, THEY EXPLAINED THE CRANKSHAFT NEEDED TO BE REPLACED. TOOK BACK TO THE DEALER, THEY REPLACED BOLT AND DIDN'T REPLACE CRANKSHAFT. ON 9/13/10 THE BOLT FAILED AGAIN, INDEPENDENT REPAIR SHOP, AND A DIFFERENT DEALER VERIFIED THE NEED FOR CRANKSHAFT TO BE REPLACE. CONTACTED KIA OF AMERICA, AND CASEY KIA WITH NO SIGN OF RESOLUTION. *TR

TL*THE CONTACT OWNS A 2003 KIA SORENTO. THE CONTACT STATED THAT THE VEHICLE WAS PURCHASED IN 2007. THE PREVIOUS OWNER HAD THE CRANK SHAFT PULLEY BOLT RECALL REPAIR PERFORMED. WHILE DRIVING 35 MPH THE CRANK SHAFT PULLEY BOLT SNAPPED OFF. THE VEHICLE WAS DRIVEN 1 MILE TO HER DESTINATION AND THEN TOWED TO AN AUTHORIZED DEALER. THE DEALER REPLACED THE CRANK SHAFT PULLEY BOLT IN MAY 2010. THE FAILURE HAPPENED AGAIN ON JULY 22, 2010. THE VEHICLE WAS IN THE DEALERS POSSESSION WHEN THE COMPLAINT WAS FILED. THE CONTACT WAS UNABLE TO PROVIDE A VIN. THE FAILURE MILEAGE WAS 82,779. THE CURRENT MILEAGE WAS 84,000.

I HAVE A 2003 KIA SORENTO. AS I LEFT THE GARAGE AT MY OFFICE AROUND 6 P.M. MONDAY 11/16, THE CAR BEGAN MAKING A HORRIBLE SQUEALING NOISE. IT IMMEDIATELY LOST POWER STEERING, SEVERAL WARNING LIGHTS CAME ON, AND IT FELT LIKE THE PARKING BRAKE WAS ON (IT WASN'T). I MANAGED TO GET OUT OF THE GARAGE TO A SPACE ON THE STREET. I TURNED THE CAR OFF. WHEN I TRIED TO START IT AGAIN, IT WOULDN'T START. I HAD IT TOWED TO A SERVICE STATION, WHICH SAID THE CAR HAD THROWN ITS DRIVE BELTS AND THAT IT NEEDED A NEW CRANKSHAFT BALANCER PULLEY, CRANKSHAFT SPROCKET, CRANKSHAFT PULLEY BOLT AND CRANKSHAFT PULLEY WASHER TO FIX THE UNDERLYING CAUSE. I CALLED KIA CUSTOMER SERVICE TO SEE IF THERE WAS A RECALL RELATED TO THOSE PARTS. THERE WAS A RECALL IN 2007 AND MY CAR WAS SERVICED AT THAT TIME AS ORDERED BY...

2003 KIA SORENTO HARMONIC BALANCER BOLT BROKE OFF REPORTED TO KIA THEY WILL NOT HONOR ANY RECALLS, THEY SAID IT WAS A RECALL FROM SEVERAL YEARS AGO . BUT IF ITS A SAFETY ISSUE LIKE THIS THEY SHOULD TRY HARDER TO INFORM PEOPLE OF THIS BEFORE THERE IS MAJOR ACCIDENT . JUST WISH THEY WOULD HONOR A RECALL THAT THEY HAVE HAD WITH THIS BOLT. I NEVER RECEIVED A RECALL NOTICE OR IT IS NOT POSTED ON ANY SITE THAT I COULD FIND, ,JUST WANT MY CAR FIXED WITHOUT A $2900 BILL AT THE END . *TR

BACK IN OCT 2008 WENT TO CAR AT 5AM TO GO TO WORK STARTED MY 2003 KIA SORENTO HEARD THIS NOISE GOT OUT TO RAISE HOOD BEFORE I COULD SAW COOLANT COMING FROM UNDER MY CAR DIDN'T HAVE TIME TO REALLY INVESTIGATE HAD MY SISTER TAKE ME TO WORK WHEN I CAME HOME HAD CAR TOWED TO KIA DEALER THEY ADVISED ME THAT MY COOLANT RESERVOIR HAD CRACK AND I NEEDED TO HAVE REPLACED AT 250.XX AT THIS POINT THEY DID TELL ME THERE WAS A RECALL ON MY SORENTO MADE APPT TO TAKE BACK TO HAVE PART REPLACED NEVER, BEFORE THIS SO CALL RECALL PART WAS REPLACED NEVER HAD ANY WARNING LIGHTS COME ON AFTER THEY SAY THEY REPLACED THE PART MY ENGINE LIGHT CAME ON TOOK MY SORENTO BACK TO THE SAME DEALER 5 TIMES WITHIN A 2 MONTH PERIOD THEY KEPT TELLING ME NOTHING WAS WRONG WITH...

MY 2003 KIA SORENTO KEPT LOSING ANTIFREEZE AND TO FIND OUT THE RESERVOIR HAD A CRACK IN IT. ALSO, AFTER I PURCHASE BRIDGESTONE FIRE DESTINATION TIRES A YEAR LATER THEY WERE WORN AFTER SPENDING $600.00 I HAD TO HAVE TWO OF THEM REPLACED WITHIN A YEAR. P245/70R16. ALSO 2 DEFECTS RECALLS WHEN MY CAR WAS PUT IN THE SHOP ONE FROM 2007 SC073 AND SC072 WHEN MY CHECK ENGINE LIGHT CAME ON. IT WAS STILL ON AFTER THE CAR WAS SUPPOSEDLY FIXED BY QUIRK KIA IN BRAINTREE. WHEN I WAS DRIVING OUT OF THE PARKING LOT THE CHECK ENGINE LIGHT WAS STILL ON. I WAS TOLD THE CAR WAS FINE AND IT WAS JUST A SENSOR AND TO FIX IT THE COST WOULD BE OVER $200. A YEAR LATER, I BROUGHT IT TO GET A STICKER, THEY REJECTED MY FOR ANOTHER RECALL THAT SHOULD HAVE BEEN FIXED WHEN I BROUGHT...

2003 KIA SORENTO, PURCHASED USED WITH 11,000 MILES ON IT. HAS BEEN A NIGHTMARE SINCE THE DAY I BOUGHT IT! HEAD GASKETS WARPED AT 28,000 MILES, OVERHEATED WITHOUT WARNING, NO SPIKE IN TEMP GAUGE, WHAM SMOKE FROM EVERYWHERE AND EVEN WITH PROOF OF MAINTENANCE UPKEEP IT TOOK KIA 2 MONTHS TO DECIDE TO HONOR THE WARRANTY. THIS WAS AFTER THE CHECK ENGINE LIGHT WOULD COME ON EVERY TWO SECONDS AND HAVE TO BE IN THE SHOP FOR MONTHS FOR THEM TO SAY NOTHING WRONG WITH IT, EVEN WHEN IT WAS TOWED IN EVERY TIME BECAUSE IT WOULD JUST SHUT OFF. THEN THE HEADLIGHT ISSUES ARE INSANE. EVERY OTHER MONTH AND THAT IS NO EXAGGERATION I HAVE TO REPLACE EITHER LOW BEAMS, HIGH BEAMS, BRAKE LIGHTS & TAIL LIGHTS. *TR

KIA INFORMED ME OF A "CRANK SHAFT BOLT" RECALL FOR MY 2003 SORENTO LX. 3 DAYS AFTER HAVING THIS REPAIR PERFORMED, MY CAR BEGAN TO JUST "DIE" AT HIGH SPEEDS ON THE FREEWAY, BUT IT WAS INTERMITTENT AND THE KIA DEALERSHIP TOLD ME THEY PROBABLY WOULDN'T BE ABLE TO FIND THE PROBLEM IF THEY COULDN'T RECREATE IT. AN INTERNET SEARCH ON THE ISSUE REVEALS MANY CONSUMERS HAVING THIS SAME PROBLEM WHICH ULTIMATELY TURNS OUT TO BE A DEFECTIVE "CRANK SHAFT SENSOR" -- BUT KIA SERVICE JERKS PEOPLE AROUND AND KEEPS THEIR CARS FOR DAYS/WEEKS SAYING THAT THEY "CANNOT RECREATE THE PROBLEM". THIS IS A HUGE SAFETY ISSUE WHEN YOUR VEHICLE JUST SUDDENLY DIES ON THE FREEWAY WITH ABSOLUTELY NO WARNING... NOT EVEN SPUTTERING. I PRINTED OUT SEVERAL CONSUMER ACCOUNTS DESCRIBING MY EXACT PROBLEM--REVEALING IT'S ULTIMATELY THE CRANK SHAFT SENSOR, AND KIA IS REFUSING TO ACKNOWLEDGE THE RELATIONSHIP BETWEEN THEIR REPAIR...

MY ENGINE BLEW ON THE CAR IT ONLY HAS ABOUT 78,000 MILES ON IT GETS REGULAR OIL CHANGES AND NO MAJOR PROBLEMS. I HAVE NEVER HAD A WARNING LIGHT COME ON AS TO INDICATE I HAD SOME OIL OR ENGINE PROBLEMS. THE CAR HAD JUST BEEN INVOLVED IN AN AUTO ACCIDENT AND BEEN SITTING SINCE 12/15 I JUST GOT IT BACK ON 01/23 AND THE ENGINE BLOWS ON 01/30 AND THEY WANT TO CHARGE ME $5,000 TO REPLACE ......I HAVE HEARD THINGS ABOUT KIA ENGINES BUT MY SUV WAS IN FINE CONDITION AND ALL OF A SUDDEN MY ENGINES BLOWS....SOUNDS LIKE A DEFECT TO ME. *TR

THE CHECK ENGINE LIGHT KEEPS COMING ON AND IT HAS BEEN CHECKED BY A DEALERSHIP AND THEY DON'T KNOW THE PROBLEM, THE FRONT HEADLAMPS KEEP BURNING OUT. *TR

CHECK ENGINE LIGHT WILL NOT SHUT OFF. VEHICLE HAS BEEN TO THE DEALER SEVERAL TIMES. DEALERSHIP HAS AT TIMES BEEN RUDE AND THE PROBLEM STILL EXISTS. THEY DO NOT KNOW HOW TO FIX IT. ALSO HAVE PROBLEMS WITH HEADLIGHTS BURNING OUT VERY REGULARLY AND THE BACK HATCH WILL NO LONGER OPEN. *TR

TL*THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING BETWEEN 35-40 MPH, THE MOTOR IN THE COOLING FAN FAILED. THE MOTOR WAS ATTEMPTING TO TURN OVER; HOWEVER, IT COULD NOT BECAUSE THE FUSE IN THE FUSE BOX DID NOT BLOW OUT AS IT SHOULD. THE WIRE FROM THE TERMINAL BLOCKER MELTED INTO THE FUSE BOX. THIS CAUSED THE WIRES TO BURN AND THE PASSENGER COMPARTMENT BECAME ENGULFED IN SMOKE. THE VEHICLE WAS DRIVEN HOME AND DID NOT CATCH ON FIRE. THE VEHICLE HAS TWO SAFETY FEATURES, ONE IN THE TERMINAL BLOCK AND THE OTHER IN THE FUSE BOX, BUT THEY DID NOT WORK. THE CONTACT CALLED KIA AND WAS INFORMED THAT THE WARRANTY ENDED AT 60,000 MILES. THE VIN WAS UNKNOWN. THE FAILURE MILEAGE WAS 100,000.

ENGINE LIGHT CAME ON BACK IN FEBRUARY AND HAD IT TO TWO DIFFERENT MECHANIC SHOPS WHICH REPLACED SPARK PLUGS AND ONE COIL PACK. ENGINE LIGHT STILL ON SO I TOOK TO KIA DEALER AND THEY REPLACED SPARK PLUGS WITH PLATNIUM ONES AND REPLACED OTHER 2 COIL PACKS. VEHICLE HAS BEEN BACK TO DEALER SEVERAL TIMES FOR THE PAST SEVERAL MONTHS FOR CHECK ENGINE LIGHT REPLACING INTAKE MANIFOLD DUE TO RECALL BUT LIGHT CAME BACK ON AND THEY HAVE HAD MY VEHICLE MOST RECENTLY FOR THE PAST 4 WEEKS. I WENT TO PICK IT UP YESTERDAY AS THEY SAID THEY HAD TO REPLACE THE CYLINDER HEADS WITH RECONDITIONED ONES AND ALL GASKETS AND SEALS. AS I STARTED TO LEAVE THE DEALERSHIP LIGHT CAME BACK ON AND VEHICLE IS THERE AGAIN. OBVIOUSLY MECHANICS AT DEALERS DON'T KNOW WHAT'S CAUSING THESE PROBLEMS AND CANNOT FIX THEM. I FEEL THAT KIA SHOULD BUY EVERYONE...

TL*THE CONTACT OWNS A 2003 KIA SORRENTO. WHILE DRIVING 45 MPH, THE VEHICLE BEGAN TO OVERHEAT. THE CONTACT INSPECTED THE VEHICLE AND NOTICE THE COOLANT WAS LOW. APPROXIMATELY A WEEK LATER HE INSPECTED THE VEHICLE AGAIN NOTICED THAT THERE WAS A CRACK IN THE RESERVOIR TANK. HE REPLACED THE RESERVOIR TANK. AS OF APRIL 15, 2008, THE DEALER HAD NOT INSPECTED THE VEHICLE. IN ADDITION, THE DRIVER SIDE HEADLIGHTS, TAIL LIGHTS AND BRAKE LIGHTS FAILED INTERMITTENTLY. AS OF APRIL 15, 2008, THE DEALER HAD NOT INSPECTED THE VEHICLE FOR THIS FAILURE. THE CONTACT FELT THAT THE ELECTRICAL SYSTEM CAUSED THE FAILURE. THE FAILURE MILEAGE WAS 72,000 AND CURRENT MILEAGE WAS 76,000.

TL*THE CONTACT OWNS A 2003 KIA SORENTO. WHILE DRIVING 60 MPH, THE VEHICLE FAILED WITHOUT WARNING. THE VEHICLE WAS TOWED TO THE DEALER AND THEY STATED THAT THEY WOULD HAVE TO DISASSEMBLE THE ENGINE AT THE COST OF $861. THE DEALER REPLACED THE HEAD GASKETS, WATER PUMP ASSEMBLY, AND THE COOLANT TANK RESERVOIR. THE TOTAL REPAIR COST WAS $1,691. AFTER RETURNING HOME, THE CONTACT HAD TO TAKE THE VEHICLE TO HIS LOCAL DEALER TWO WEEKS LATER AND THEY STATED THAT THEY WOULD HAVE TO DISASSEMBLE THE ENGINE IN ORDER TO LOCATE THE FAILURE. THE DEALER IDENTIFIED WARPED CYLINDERS AS BEING THE FAILURE COMPONENT, AND THE HEAD GASKETS, PUMP ASSEMBLY, AND THE COOLANT TANK RESERVOIR WERE REPLACED AGAIN. THE VEHICLE IS CURRENTLY AT THE DEALER BEING REPAIRED. THE FAILURE MILEAGE WAS 66,400 AND CURRENT MILEAGE IS 66,800. THE COOLANT RESERVOIR LEAKED WHICH CAUSED THE VEHICLE TO OVERHEAT. UPDATED 05/13/08. *JB

LIKE MANY 2003 KIA SORENTO OWNERS THE OVERFLOW TANK IN MINE DEVELOPED A CRACK IN THE BOTTOM THAT IS ONLY VISIBLE WHEN IT IS PRESSURIZED. ALTHOUGH KIA KNOWS THERE IS A PROBLEM WITH THE OVERFLOW TANK IN MOST IF NOT ALL 2003 KIA SORENTO'S AND HAS SENT OUT A TSB TO THEIR MECHANICS OVER HOW TO REPLACE IT. AS SOON AS MY CAR HAD OVERHEATED DUE TO THE LEAK, I HAD TO PAY AROUND $100 TO BUY A NEW TANK FROM THE NEAREST DEALERSHIP BUT ALAS AFTER OVER HEATING MY CAR DEVELOPED MORE PROBLEMS AND ENGINE HAVING TO BE THROWN OUT. THIS HAS COST ME OVER $4300 IN REPAIRS SO FAR, AND HAVE NOT BEEN ABLE TO DRIVE THE CAR I AM STILL MAKING MONTHLY PAYMENTS ON IN NINE MONTHS. NONE OF WHICH ARE COVERED TO THE WARRANTY DUE TO THEIR "10 YEAR 100,000 MILE" POWERTRAIN WARRANTY NOT BEING TRANSFERABLE...

COOLANT SPILLING FROM THE RESERVOIR (WHICH WAS REPLACED IN DECEMBER 2006, THE PART WAS ON NATIONAL BACK ORDER. I WAITED 5 WEEKS FOR THE PART TO ARRIVE). THE CAR STALLED SEVERAL TIMES AND STEAM CAME FROM THE RIGHT SIDE OF THE HOOD. TODAY IS 8/31/07, SIMILAR INCIDENT HAPPENED WITH THE CAR. THE DEALER SAID THAT THE HOSE FROM THE COOLANT RESERVOIR WAS CRACKED. I ASKED SINCE THE PART WAS RELATED TO THE RESERVOIR WHY DID I HAVE TO PAY ADDITIONAL FOR THE HOSE REPAIR ($193.30). THE DEALER SAID THE HOSE WAS A SEPARATE PART. I DON'T UNDERSTAND WHY KIA DOESN'T RECALL THE RESERVOIR AND ANY ASSOCIATED PARTS. *TR

ON JULY 20, 2007 DRIVING HOME FROM WORK IN THE RAIN, ON THE HIGHWAY MY CAR MADE A LOUD NOISE AND I LOST STEERING AND DID EVERYTHING I COULD TO NOT HIT CARS BESIDE OF ME AND THE POOR GUY BEHIND ME FROM CRASHING IN TO ME. CALLED MY HUSBAND WHO CAME AND PICKED UP THE HARMONIC BALANCE OFF THE HIGHWAY, LIFTED THE HOOD TO FIND A LARGE BOLT (NOW I KNOW CRANKSHAFT BOLT) BROKEN. WHICH I HAVE. I SEARCHED AND FOUND WHERE THERE WERE SEVERAL COMPLAINTS AND THAT KIA WAS GOING TO RECALL. I CALLED KIA ON THE 1ST OF AUG. (CAR HAS BEEN SITTING IN MY DRIVEWAY BECAUSE IT HAS 68000 MILES AND I AM THE SECOND OWNER), WHO HAD MY CAR TOWED TO THE RUSTY WALLACE KIA IN LOUISVILLE, TN. (CHECKED THE MAIL WHEN I CAME HOME AND THERE WAS A RECALL ON CRANKSHAFT BOLTS) IMAGINE THAT....

NO WARNING OF FAILURE. HAPPENED AT 61000 MILES 1000 OVER WARRANTY. CRANKSHAFT BOLT BROKE , AND THE MECHANIC SAD HE NEVER SAW SOMETHING LIKE THIS. SO I THINK KIA SHOULD BE RESPONSIBLE ..HE GOT THE PARTS FROM KIA, AND ON 7/15/07 THE BOLT CAME OFF AGAIN WHILE CAR WAS IN PARKING LOT OF WIFE'S WORK PLACE. KIA SHOULD FIX IT . I WAS PLANNING ON GETTING A MINI VAN, AND IT WON'T BE A KIA, DEPENDING ON WHAT THEY DO ABOUT MY SERENTO. *AK

I WAS DROPPING OFF SOMEONE AT WORK WHEN THE CAR MADE A THUMP AND ALL THE DASH WARNING LIGHTS CAME ON. I DROVE IT HOME ABOUT TWO MILES AWAY, AND TOOK IT TO A AUTOMOBILE SERVICE CENTER THE NEXT DAY. THEY TOLD ME THAT THE CRANKSHAFT PULLEY WAS READY TO FALL OFF. THE NEXT DAY I HAD IT TOWED FROM THE SERVICE CENTER TO THE DEALER. THE DEALER SAID THE SAME THING AS THE SERVICE CENTER, AND THAT IT WAS UNDER WARRANTY. ALSO, IT A NEEDED A 60000 MILE SERVICE FOR WHICH I PAID EXTRA. WHEN I WENT TO PICK THE CAR 5 DAYS LATER THE CAR WAS MAKING A BELT NOISE, IT WAS SLOW IN STARTING, THE DASH LIGHT WOULDN'T COME ON, AND THE AIRBAG LIGHT WAS ON. WHEN I TOOK IT BACK TO THE DEALER, THEY TIGHTENED THE BELTS AND CHECKED THE OTHER PROBLEMS AT A COST OF...

CRANKSHSFT PULLEY BOLT BROKE ON 2003 KIA SORENTO V6 MODEL. THIS CAUSED LOSS OF POWER STEERING IN VEHICLE. *AK

AS I WAS DRIVING DOWN THE FREEWAY, THE ENGINE STALLED AND ALL LIGHTS ON THE DASH CAME ON. I WAS ABLE TO PULL TO SAFETY (JUST BY SHEER LUCK) AND CALLED KIA 1-800 FOR TOWING SERVICE. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALERSHIP. I WAS INITIALLY TOLD THAT THE TIMING BELT WAS MALFUNCTIONING. SUPPOSEDLY THE ANALYZER SHOWED THAT THERE WERE "MULTIPLE MISFIRES. I WAS ASKED IF THE CAR WAS MISSING PRIOR TO THE STALL. I TOLD THEM IT RAN AS SMOOTH AS SILK. I AUTHORIZED THEM TO REPLACE THE TIMING BELT DESPITE THE FACT THAT IT HAD BEEN REPLACED AS PART OF SCHEDULED MAINTENANCE TWO MONTHS EARLIER. THE DEALERSHIP THEN CALLED AND TOLD ME THEY HAD "GOOD NEWS AND BAD NEWS". THE TIMING BELT WAS REPAIRED BUT IT APPEARED THE HEAD WAS BLOWN AND THAT KIA REFUSED TO PAY FOR REPAIRS BECAUSE THE OVERFLOW BOTTLE WAS CRACKED. THEY STATED...

I HAVE NOW HAD THE CRANK SHAFT PULLEY BREAK 3 TIMES, THE ENGINE AND OTHER PARTS HAVE HAD TO BE REPLACED DUE TO THIS. IT MAKES THE VEHICLE SUDDENLY INOPERABLE AND UNSAFE.*AK

A SCREW THAT HOLD THE CRANK SHAFT & THE TAMPER GET BROKEN WHILE I WAS DRIVING TO MY HOUSE. THE DEALER IN PUERTO RICO SAID THAT I HAVE TO PAY$2,521.00 TO FIX IT. BUT I HEARD FROM AN INSURANCE AGENT THAT KIA WAS TOLD BY SOME GOVERNMENT AGENCY, I THINK THAT AGENCY IS NHTSA; TO MODIFY THE SCREW INVOLVED IN MY INCIDENT, CAUSING THE LOST CONTROL OF MY SORENTO. THE STEERING GET HARD TO MOVE.

DT*: THE CONTACT STATED WHILE ATTEMPTING TO TURN ON THE DEFOGGER/DEFROST SYSTEM, THE HEATER FAILED TO OPERATE, AND NO HEAT WAS PRESENT. THE VEHICLE WAS INSPECTED BY A DEALER, WHO DETERMINED ANTIFREEZE FLUID LEAKED OUT OF THE RESERVOIR TANK BECAUSE IT WAS FRACTURED AND NEEDED TO BE REPLACED. THE REPLACEMENT PARTS WERE NOT AVAILABLE AT THE DEALER, AND THE MANUFACTURER WAS ALERTED, WHO CONFIRMED THE PARTS WERE NOT AVAILABLE. THE DEALER INSTRUCTED THE CONTACT TO MONITOR THE LEVEL OF ANTIFREEZE FLUID DAILY AND ADD MORE ANTIFREEZE IF NEEDED.

FIRST INCIDENT - CAR STALLED AND FLUID STEAMED FROM THE HOOD. IT HAD TO BE TOWED AFTER SEVERAL RESTARTS TO DRIVE TO THE DEALER. THE COOLANT RESERVOIR WAS CRACKED. THIS PART IS ON NATIONAL BACKORDER AND I HAVE SO FAR BEEN WAITING APPROX. FOUR WEEKS FOR THE PART. THE DEALER SAID KIA HAS HALTED MANUFACTURING/DISTRIBUTING THE PART JUST FOR NEW CARS AND REQUESTED THAT THE PARTS BE SHIPPED TO THE DEALERS FOR REPAIR INSTALLATIONS. THE DEALER CUSTOMER SERVICE IS GREAT AND I HAVE NO COMPLAINT ABOUT THE DEALER. *NM

WHERE DO I START?....WELL NOT LONG AFTER WE GOT THE PIECE OF JUNK WE HAD TO TAKE IT TO THE KIA DEALER BECAUSE THE ENGINE LIGHT KEPT COMING ON, THEY SAID IT WAS BECAUSE THE GAS CAP WASN'T BEING TWISTED ENOUGH AND AIR GOT IN. WELL FOR ABOUT 2 WEEKS THE ENGINE LIGHT STAYED OFF, WE TOOK IT BACK NUMEROUS TIMES BUT IT KEPT COMING BACK ON. THEN ON ONE OCCASION I WAS STRANDED ABOUT 40 MILES FROM HOME...THE CAR WAS DEAD, WE HAD IT TOWED TO THE DEALER, ALL THE BELTS HAD COME OFF, THEY TRIED TO MAKE EXCUSES WHY KIA WOULDN'T FIX IT UNDER THE WARRANTY, THANK GOD WE WON THAT BATTLE...KEEP IN MIND, THE ENGINE LIGHT IS STILL ON AT THIS POINT. NOW THIS YEAR THE HEATER WON'T STAY HOT AFTER ABOUT 30 SECONDS IT TURNS COLD, AS COLD AS THE AIR. THEN WITH NO WARNING THE...

THE RESERVOIR ON MY 2003 KIA SORENTO RUPTURED AND ALL THE COOLANT LEAKED OUT WHILE I WAS DRIVING. I PULLED OFF THE HIGHWAY AND INTO A GAS STATION AND THE LET THE CAR COOL. I THEN ADDED IN ANTI- FREEZE AND FILLED IT WITH WATER AND DROVE ANOTHER 10 MILES AND DROPPED THE CAR AT A REPAIR SHOP. THE NEXT DAY THE CAR WOULD NOT START. THE KIA DEALERSHIP IS SAYING IT IS NOT COVERED UNDER WARRANTY. *JB

ELECTRICAL FAILURE,COOLING SYSTEM FAILURE,ROUGH RUNNING-ENGINE MISFIRE PURCHASED CAR 2-22-2003 BRAND NEW THIS CAR HAS SPENT A LOT OF TIME ON THE DEALERS LIFT. ALSO HAS SEEN ITS SHARE OF TOW TRUCKS. IN THE PAST 1 1/2 YEARS I HAVE REPLACED 18 LEFT SIDE HEADLIGHTS,23 RIGHT SIDE HEADLIGHTS ,16 FOG LIGHTS,8 LICENSE PLATE LIGHTS AND 6 TAIL LIGHTS THE TRUCK HAS BEEN TO 3 DEALERS AND THEY ALL SAY ITS EITHER NORMAL OR IT'S ONLY BECAUSE I DID NOT BUY THE BULBS FROM KIA WELL SOME I DID AND THEY DO NOT LAST EITHER. THE LAST TIME IT WAS IN THEY HAD THE TRUCK FOR 9 1/2 MINUTES AND TOLD US THERE IS NOTHING WRONG AND FOR $149.00 THEY WILL PUT IN A NEW BULB. NO WARRANTY ON HOW LONG IT WILL LAST..... THE TRUCK ALSO MISFIRES AND THE DEALER ALSO CANNOT FIX IT THEY SAY THE COMPUTER SAYS ITS GOOD...

ELECTRICAL FAILURE,COOLING SYSTEM FAILURE,ROUGH RUNNING-ENGINE MISFIRE PURCHASED CAR 2-22-2003 BRAND NEW THIS CAR HAS SPENT A LOT OF TIME ON THE DEALERS LIFT. ALSO HAS SEEN ITS SHARE OF TOW TRUCKS. IN THE PAST 1 1/2 YEARS I HAVE REPLACED 18 LEFT SIDE HEADLIGHTS,23 RIGHT SIDE HEAD LIGHT ,16 FOG LIGHTS,8 LICENSE PLATE LIGHTS AND 6 TAIL LIGHTS THE TRUCK HAS BEEN TO 3 DEALERS AND THEY ALL SAY ITS EITHER NORMAL OR IT'S ONLY BECAUSE I DID NOT BUY THE BULBS FROM KIA WELL SOME I DID AND THEY DO NOT LAST EITHER. THE LAST TIME IT WAS IN THEY HAD THE TRUCK FOR 9 1/2 MINUTES AND TOLD US THERE IS NOTHING WRONG AND FOR $149.00 THEY WILL PUT IN A NEW BULB. NO WARRANTY ON HOW LONG IT WILL LAST..... THE TRUCK ALSO MISFIRES AND THE DEALER ALSO CANNOT FIX IT THEY SAY THE COMPUTER SAYS ITS...

HARMONIC BALANCER BOLT BROKE. TRAVELING LESS THAN 5MPH. VEHICLE STARTED TO VIBRATE. UPON INVESTIGATION, FOUND THAT THE MAIN BOLT HOLDING THE HARMONIC BALANCER IN HAD SHEARED OFF. THERE WERE SOME RUST DEPOSITS AT THE BREAKAGE POINT. THIS OCCURED WHILE ON AN OFFROAD TRIP. THE VEHICLE WAS LEFT IN THE BACKCOUNTRY. I WILL HAVE TO ATTEMPT TO MAKE REPAIRS IN THE FIELD IN ORDER TO GET IT TO THE DEALER. THERE IS NO WAY TO TOW THE VEHICLE OUT OF ITS CURRENT POSITION.

WHILE DRIVING, THE ENGINE BLEW OUT THE FIRST TIME ON 10-04-04. IT WAS REPLACED AND IT BLEW AGAIN ON 01-21-05. THE VEHICLE IS ON ITS THIRD ENGINE. *AK THE KEY BECAME STUCK IN THE IGNITION, THE VEHICLE SHIFTED OUT OF PARK. THE CONSUMER STATED HE HAS HAD TRANSMISSIONS AND ENGINE PROBLEMS SINCE HE PURCHASED THE VEHICLE. THE FRONT WHEEL BEARINGS WERE DAMAGED. THE FOG LIGHT WAS INOPERATIVE. *JB