2018 HYUNDAI TUCSON Power Train Problems

Hyundai Tucson has been jerking and shaking for over over 4 years now and either when taking to the dealership they reset the dual clutch and have replaced the same part twice in the dual clutch. This shaking has been happening since the car was bought brand new like a year after. The vehicle now will get stuck in gear and while driving will go down to 20 mph and get stuck in that speed. This is a serious safety issue. The dealer could replicate the shaking but not the gears being stuck. It has happened on more than one occasion and they just reset something but this continues to happen. There are no warning lights when the gears get stuck it just happens while driving and it has happened twice now in the last 3 weeks.

The engine and engine management system of my 2018 Hyundai Tucson experienced repeated failures resulting in loss of propulsion and unsafe drivability. In November 2025, while traveling approximately 75 mph on a freeway, the vehicle suddenly entered limp mode without any prior warning, causing an abrupt loss of power in active highway traffic. No warning lamps or messages appeared before the failure. After the loss of propulsion occurred, the check engine light, battery light, and oil light illuminated sequentially. Diagnostic trouble codes P1326 and P0326 were recorded. Initial inspection indicated severe oil consumption despite a recent oil change less than 2,000 miles earlier. A Hyundai dealership replaced knock sensors under warranty. Shortly after release (30 miles), the vehicle again exhibited severe drivability issues, including a flashing check engine light, and required immediate towing. A second Hyundai dealership replaced the short engine block under warranty. Approximately 180 miles after the engine...

My car on the expressway wouldn't go over 40 and this was happening intermittently so my car was unsafe. No check engine light but it was just at the dealership for an oil change. Has. been an ongoing problem since I bought the car! Smells, gets hot!

Over the past nine months, I’ve been experiencing ongoing issues with my 2018 Hyundai Tucson engine and transmission. After four consumption tests and a flush confirming that the engine is burning between 0.8 and 0.3 liters of oil for every 1,000, I was informed Hyundai refuses to either repair the issue or conduct testing to determine the cause. The timeline is summarized below: •February 2025 – I was told by [XXX] my vehicle simply did not have enough oil after the last oil change; •March 2025 – I was informed an initial consumption test needed to be completed; •May 2025 – a second consumption test revealed the engine was burning more than 1 liter per 1000 and a flush was completed; •July 2025 – a third consumption test was completed, revealing that while the engine was excessively burning oil, it was not currently at 1 liter per 1000 based on...

I was driving on the highway, about to change lanes, when I looked in my rear view mirror and saw black smoke coming from my appeared to be my exhaust. I immediately started to pull over, and that is when the oil light first appeared on my dashboard. By the time I had put the car in park, the check engine light had also appeared. After calling my boyfriend and a tow truck, I exited the vehicle and noticed a large pool of oil by my front tire. With the car on the tow truck, I could see oil continue to drip out. The car was towed to the local Hyundai dealership. Since this occurred on a Saturday afternoon, the service dept. was closed, and Hyundai called me on Monday, Aug 11, 2025 to explain that i should contact the auto mechanic that last changed my oil, as the oil...

29 days after I bought a 2018 Hyundai Tucson. The vehicle started making a ticking noise and stopped accelerating. I called the dealership and they said we didn't get a warranty. I said no that isn't correct, no warranty was offered and after seeing ALL the known engine problems I understand why ken ganley in medina wouldn't offer one. Now not even a month into having this vehicle, I have a brand new 5 year loan and a vehicle that won't move until I put a new engine in it and the dealership won't do anything for me. This is the worst experience I have ever had purchasing a vehicle

My 2018 Hyundai Tucson 2.0L GDI engine with only 79,000 miles was "knocking" and wouldn't accelerate. We pulled over and towed the vehicle to the local Hyundai Dealer who declared "oil level good but failed bearing clearance test". Diagnosed with a rod and bearing failure. They submitted to Hyundai Motor Warranty the vehicle needed new engine. They declined. I know this is covered under the Hyundai Engine 2 Class action lawsuit with the extended 15 year/150,000 mile warranty as a result of the catastrophic engine failures. I have all oil change service records for every 5,000-6,000 miles while I was the second owner, as well as, have obtained another from the dealer who bought it from a rental/lease company starting at 14,000 miles. Hyundai Corporate is claiming "exceptional maintenance neglect" because of one missing oil change record from the rental company that I may not be able to obtain as...

Won’t shift so that I can gain speed

On April 12, 2025, my 2018 Hyundai Tuson which only has 99,000 miles started stalling out at random speeds. The vehicle stalled going up a hill and would not accelerate it would also not go past 55-60 miles per hour on the highway. There were no check engine lights or codes on the dashboard. The vehicle is also burning oil on 2 occasions when having the oil changed. I feel like my life and others is in danger because the vehicle is stalling at random speeds which could cause a major accident due to this issue. I could be hit by another vehicle while trying to accelerate or merge on the highway. I reported the oil consumption last November and I contacted Hyundai customer care who issued a case number in May 2025 for the stalling issue, they instructed me to take it to the Hyundai dealership to be diagnosed....

While starting and accelerating my 2018 Hyundai Tucson, I began hearing abnormal engine knocking and noticed rough performance. I took the vehicle to an authorized Hyundai dealership, where they diagnosed an internal engine defect. They confirmed the engine issue but refused to cover the repair, citing that I’m not the original owner—despite public information stating that Hyundai’s extended engine defect warranty (related to known bearing failures) applies to all owners for up to 15 years/150,000 miles. This creates a major safety concern, as I drive long distances on highways daily and fear the engine may seize or fail at high speeds. The vehicle remains at the dealership and is currently undrivable. I’ve submitted proper maintenance records, and the issue has been escalated through Hyundai Consumer Affairs and the Better Business Bureau. This appears to be a widely reported engine defect that Hyundai is not consistently addressing. The lack of coverage...

The contact owns a 2018 Hyundai Tucson. The contact stated that the vehicle was consuming an excessive amount of engine oil with the oil warning light illuminated. The vehicle was taken to an independent mechanic and a dealer to be inspected and two oil consumption tests were performed by the dealer. The oil consumption tests showed no defects with the engine. The dealer performed an engine flush; however, the failure persisted. The contact was advised to have oil changes performed every 3,000 miles instead of the recommended 5,000 miles. The contact stated that recently, after having an oil change, the dealer recommended a transmission fluid flush. The contact stated that after the transmission fluid flush was performed, the vehicle jerked and hesitated while depressing the accelerator pedal. There was no warning light illuminated. The dealer was notified of the failure, and the contact was provided an estimate for a diagnostic...

In late September of ‘24 my husband was driving our oldest to school when my 2018 Hyundai tuscon seized mid drive with our son in the back seat with no oil or engine light warning. Husband inspected the oil and I was still full. A Hyundai dealer towed at their expense in October, diagnosed an engine failure. Denied me service since my extended warranty expired and I didn’t have the KSDS update. I wish they would as I still owe on the vehicle and I’m out of work. Making this complaint is to only spread awareness that 2017 Tucson with the 2.0 L engine had an engine failure connecting to rod bearings. My 2018 has the same engine type and failure as the 2017. Hyundai Corp fails to recognize the problem. My 2018 didn’t fail due to lack of oil changes as I can I prove that. My 2018 failed...

Me my wife and our dogs were driving from California to Las Vegas when we experience loss of power in the engine we managed to Coast downhill to State Line Nevada and got to the off ramp and then had to push the car to the nearest gas station it was towed the next day to Centennial Hyundai in Las Vegas, case # [XXX] this happened while on vacation just before Christmas they were not able to look at it till after Christmas but they found that one of the valves had broken and was sitting on top of the piston we were told that the engine the turbo the exhaust and the catalytic would all have to be replaced also later they discovered a leak in the transmission on the Dual clutch which also needed replacing we were just told that they have finished the work and we would...

car would not speed up no matter how hard i pressed accelerator, vehicle wouldn't speed up kept going at slower speed had to have towed to dealership. Don't know what is wrong. I was scared someone would hit me, or my speed would cause an accident. Only after issue started did engine light come on.

In May 2024 my Hyundai Tucson died in a middle of an intersection with no warning. Worse than that is Hyundai motor USA informed me that the car was on a recall list for an engine failure issue that was apart of class action suit . Ans further told me that that were obligated to have the highway transportation safety dept notified first consider cause of the issue. They told an inspector from your department was required to inspect vehicle before repairs could be started and or returned fo me. That has not happened and they are using your office as the reason for delay on my vehicle. They have systematically m supplied the same answer to my case with no resolution. I have done everything I can as a consumer to handle my case and believed that they were going through the correct process but the dealer has informed...

End of April/beginning of may, driving down highway check engine light flashing loud knocking and loss of power. Got it towed by AAA. Wasnt able to make appt until May 9th. Got it towed to the Hyundai dealership. Got phone call that is filed the bearing test and need a total engine replacement. Was told by the dealership that it could take 3 months or more to get an engine in and get it replaced. They have no loaners, and hyundai expeacts me to pay out of pocket for a rental for work to keep my job as well as my independent contracting job accounting/taxes. I have to have a vehicle. A rental is easily 1200+ a month. Hyundai refuses to give me a trade in value for my vehicle until the new engine is in. Hyundai also refunded to reimbursement me for a rental until all work is completed...

My vehicle had been in the shop for 30 day due to engine shutdown in the middle of the road, I barely was able to get vehicle off the road and avoid oncoming traffic. I got my vehicle back and driven it a total of 40 minutes within a 3 day time period. During my drive to work my vehicle shut off in the middle of the highway and would not turn on again. My concerns are not being taken seriously with Hyundai and it is a disaster waiting to happen. I have a one year old daughter and I can not risk her safety as well as the other on-coming people on the road when it quits and oncoming traffic has to swerve to not T-bone me. Hyundai will not take any action to correct this other than giving it a temporary fix of a 45 minute drive before...

ABS SENSOR, downhill light, traction control light stays on. In August 2023 the transmission had to be rebuilt from slipping. After work there is still transmission slipping. Media display goes blank often and will not show all of display sometimes.

While on the highway going 70mph the check engine light flashed on the immediately off out of nowhere and car started aggressively shaking before loosing temporary power. My wife and toddler were in the car and we were all pretty shaken up. Luckily I was able to gain control of the car but I'm concerned that another issue may occur. I immediately took my car in to the shop and they were unable to replicate the issue. Spark plugs, oil, transmission fluid and coolant fluids were all as regular maintenance but no real issue was addressed. My car has also had issues with struggling to accelerate from stop, causing jerking motion and my oil seems to be burning faster than usual.

It started [XXX] when i took my car to the dealership due to it going into limp mode. The dealership took it in and said it was throwing error code p1326 which is the knock sensor code. they replaced the knock sensor, drove my tucson home after the replacement, by the time i got home it went into limp mode again, took my car back to the dealership turns out it was a faulty sensor they received. So the dealership replaced the sensor again, did not have an issue with it until decemember 2023, so i took it to get the error code read again and it was the p1326, so i make an appointment with the dealership to bring it back in and they said hyundai of america says it needed the combustion chamber cleaning, which i had to pay for. even though it was throwing the p1326 error...

Check engine light stayed on vehicle transmission unable to shift in reverse and lower power when car is driven in a low speed.

issues with the 2018 Tucson- Transmission has always sputtered, had numerous updates and resets for it. still an issue. also it doesn't want to go into gear sometimes and bob when going into drive, or reverse. slow pick up from a complete stop, the other morning it became a safety concern when I had my daughter in the car. The car start to move when I stepped on the gas, then stopped in the middle of the intersection of [XXX] four way. The RPM's as I was stepping on the gas was shifting between 5-7 and the car it wasn't moving. Engine- in September I noticed my oil pressure light flashing on and off, this pointed me to check the oil. the oil was very low, added oil to the vehicle. since then I have had the dealer involved due to high oil burning . in [XX] I had an...

I was driving home from a family get together with my husband and daughter in my car. We smelled something burning, and suddenly smoke was coming out of my center console. I pulled over and flames were coming out of the driver side. As soon as we evacuated the vehicle, it burst into flames. There was no warning, nothing lit up on the dashboard to warn me of this hazard. A witness was driving behind us and called 911 when he noticed flames underneath my vehicle right before I pulled over. A police report was filed and it was reported to my insurance agent, it is currently still under investigation since it just happened 2 days ago during a Holiday weekend. My safety and my family's safety was put at risk due to no warning, how fast the vehicle went up in flames, etc. The car was a total loss.

The engine has failed in my 2018 Hyundai Tuscon. I was driving the car daily since purchasing in July of 2023. Everything was fine until the first week of October, I had just picked up my son and was getting on the interstate when my check engine light came on and my oil light would flash on and off occasionally not persistently. I had the car checked immediately and there was no oil in the car at all. I added oil to the car, but it was too late the engine had already blown. I drove my son to school the next morning and the car sounded like a lawn mower and was knocking continuously. The dealership has the car now and this is a known problem with this model car. The car could've locked up while I was on the interstate with my child and we or others could...

As I was pulling out of a bank driveway onto a busy access road my car just died. Lost all power. NO warning bells, no lights on the dash, no warning at all. This could have potentially caused an accident. I could have been hit by another vehicle as my car was dead. Pushed it out of the way of traffic, checked oil and there was none. Ended up having it towed to the dealership. The dealership told me that my engine had failed and would need to be replaced due to cylinder 3 rod bearing failure due to oil consumption (a known problem from this manufacturer).

CVT Transmission failed under 70,000 miles. The vehicle is available for inspection upon request. My safety was put at risk due to no warning light or indication of this failure from Dick Smith Hyundai in Greenville, SC during a routine maintenance check. The problem has been confirmed by Dick Smith Service Center. The vehicle has been inspected by Dick Smith Hyundai. There were no warning lamps prior to failure. The characteristics of the CVT appeared in 2018 however; the jerking accelerated over time. Dick Smith Service Center stated not to worry the transmission was okay. October 16, 2023 with less than 70k miles I’m being told I need transmission, starter, & fly wheel.

When I accelerate from a stop sign or yield it Jerks and hesitates to accelerate. I have to release the gas and push again sometimes doing this multiple times when this happens daily. I've taken it to Hyundi shops and they say it's a normal chararistic if a Tuscan. It also uses an excessive amount of oil. I am told this is because of the engine. If I go change my oil right at every 3k miles my oil level is well below the minimum line so I have been changing it every 1500 miles.

Transmission is jerking when driving. Brakes are squeaking.

This very low mileage vehicle recently had the same incident for I believe the fifth time since I've owned the car. In a very dangerous situation the car exibited the car going almost dead after normal acceleration. It regains power after 3-5 seconds and rapidly returning to acceleration. It happened to my wife soon after purchase and she has refused to drive it since. Last week while I attempted to make a left turn at a yellow light it again went dead and traffic was forced to slow while the car behind me almost rea ended me. Recently the engine seems to run rough at times. Never have I seen any engine trouble lights since I've owned it. Three separate Hyundai dealers have looked at and seemed to be aware of what's causing it, but chose their words carefully. My neighbor owns one of the largest new cars dealerships in...

Immediately after purchasing the car I stopped for gas. When pulling out of the parking lot and onto the road, the transmission stalled. The car did not move, the rpms jumped to 5-6 and the lurched and jerked forward then stopped and lurched forward again with the rpms jumping high. This had happened numerous times to various deplgrees since purchasing the car 48 hours ago. There were and continue to be no warning lamps or messages on the dash. I have an appointment with the dealer to have it assessed in a week. This is dangerous because it causes the vehicle to not pull into or cross traffic in a smooth, sage and predictable manner, potentially causing a collision.

Back in January of 2023, car would not go into reverse. While out driving the engine light came on and went into safety mode. I had no power to merge onto highway and make it up hills to get to Hyundai service repair. They said the gear actuator failed. They repaired, but within a week the car was not going into reverse and engine light came back on. They had my car for over a month with no loaner car. They replaced transmission. Car only had 32,000 miles on it. Yesterday, July 28, car started losing power in traffic. Sometimes car would lurch. Engine light on so I pulled into grocery store parking lot. Turned car off and when I turned back on a loud clunking noise. Called Hyundai and drove to service. The entire time the car struggled to merge or go up hills. They ran test and said...

The car has acceleration issues and when you try to press down on the gas it sputters and loses power, it is becoming a safety hazard when driving 45 mph or higher. If you try to pass another vehicle it slows down and almost stops, we have had to pull to the side of the road to avoid being in an accident. This is NOT normal for a vehicle to do this and something needs to be done before we end up dead.

Tucson 2.0L hesitation at acceleration particularly from a rolling stop: This intermittent problem was checked initially by Marhofer Hyundai in Cuyahoga Falls Ohio, their findings were negative. We then took it to Great Lakes Hyundai in Streetsboro and they said they were aware of the problem and reset the computer, but it did not resolve the problem. This problem has put my family in harm's way many times, making a turn from a rolling stop the car lags into ongoing traffic. Our last visit to dealership we were told car was out of warranty 19,000 miles but the problem was never fixed. This vehicle was a certified pre-owned and have an extended warranty. I have attached a technical service bulletin.

i received a letter in the mail stating the nock sensor has been replaced i dont know howlong ago but my 2018 tucan is stuck in false sage mode saying the nock senor was bad! if it is a on going issue and there is has been a recall on the part why does it show no recalls for my mode car?

I have only owned the car for 1 month. I had gotten an oil/filter change and a new oil pressure sensor at ~80,100 miles. I had requested the oil sensor be changed because it would flicker on and off when the car was idling/low RPMs once it had heated up fully. This had fixed that issue seemingly. At ~80,700 miles the car had started riding a bit "rough", especially at higher speeds, so I decided to have a look under the hood. I was terrified to see that my dipstick was bone dry. There was never any evidence of any noticeable leak underneath the car on the driveway nor any evidence of blue smoke coming out of the exhaust. After some research (Hyundai corporate was telling me over the phone multiple times that there was no known issues with my specific car/engine) I was appalled to see I was essentially...

Purchaseing the vehicle two months ago, the engine service light started blinking. Taking the vehicle to several shops including two hyundai dealers, I was informed the vehicle had an off market catalytic converter. I asked the dealership several times if there was any issues with the vehicle and they stated there was not. The engine first came on two weeks after the purchase of the vehicle. It is not safe to drive.The warranty nor the dealership will cover or assist.

Acceleration issue, from a stop position on a red light or stop sign, when the gas pedal is pressed the engine revs but does not move immediately, after a couple of seconds it lundges forward, also when trying to merge you must wait for a very big gap to safely merge, the car does not respond and this is very dangerous, Hyundai need to rectify this issue before someone dies.

When driving at night and low-beams are on, there is a black void (looks like a black bar horizontally across the headlight projected area on roadway). Black void is eye level with driver’s view of the roadway. With the black void present, driver is unable to see the roadway clearly at night, which inhibits the drivers visibility and ability to see road hazards or animals crossing the road. Low-beam and high-beam bulbs have been replaced and checked for any burn spots or malfunction in the bulb itself; with brand new bulbs installed professionally, the black void is still present. Hyundai repair stated it is a known issue that has yet to be addressed by Hyundai Manufacturers. Issue has been present for 2-months now. While driving on interstate, went to pass a vehicle and while accelerating the vehicle would not increase in speed. The RPM needle jumped to 5-6 and a...

Leaving a parking lot, vehicle was hard-shifting at 10mph, 20mph, 30mph and was not gaining typical acceleration. Every slow down or stop sign/stop light this behavior continued with automatic hard shifting between gears and lethargic acceleration to the point where I felt this may cause an accident or cause another vehicle to have an accident due to lag response of my vehicle. Upon home arrival, I attempted to back vehicle into my parking spot but after shifting into Reverse, the R indicator on console was flashing but vehicle would not move. I drove back around the complex parking circle and again attempted to back vehicle in to a different parking space but experienced the same issue where R indicator was flashing but vehicle would not back up. My daughter and 2 grandsons then had to push my vehicle back in to the parking spot. I turned vehicle off, waited approximately...

Vehicle stalls when accelerating at low speeds. It appears to be a delay when the car transitions from 1st to 2nd gear. This creates a safety concern, especially when taking turns into traffic due to delays/stalls when turning.

I’ve been having an issue with the car “jerking rapidly” when in traffic and rolling slowly and when climbing relatively small hills, it began about 2 months ago but have become progressively worse over the last month. I was told by someone with a similar vehicle that it is the “lower arm control. Need help with is or if there is a recall

While driving my car normally 9 dashboard lights came on suddenly including the check engine, ABS, brakes while at the same time the dials on the dashboard including the rpms, speedometer, oil temperature and more all stopped working. This happened suddenly while the car was in drive and also caused issues with the transmission as the car stopped shifting gears properly and was driving very rough. With this sudden onset of many different issues out of nowhere driving the vehicle was very dangerous when trying to get to a safe location. After parking this electrical issue would not allow me to take the car out of park or use a OBD reader do to the electrical issue. After researching this problem I found several reports online describing nearly identical symptoms all of the sudden resulting in the car being undrivable and in a dangerous state. These owners said they took...

While driving the vehicle, while accelerating the vehicle would lose power or disengage from gas pedal at 17 mph and then again at 26 mph. After about 3 miles the check engine light came on and a TCM warning appeared on the radio screen. Immediately took the car to the dealership and was turned away since I didn’t have an appointment. On my way home from the dealership I made a stop at a store. I reversed out of the parking spot with no issues. When I put the vehicle in drive, it would not accelerate. I could drive in reverse but not forward. Vehicle was towed to the dealership. Diagnostics revealed it was a failed TCM. Further research revealed this same issue occurred in 2016 models. How was this not fixed or prevented in later models?

Powertrain issue. Multiple times the after stopping the engine revs for a few seconds and then the vehicle will lurch forward. It acts like the CVT transmission has a delayed response to the accelerator. The condition comes and goes and sometimes it happens multiple times in the same trip.

Car has no power when accelerating, when accelerating from a stop the car revs but does not move, then when it does move it takes off like a rocket, in slow moving traffic 5 mph, you accelerate and the car seems like it wants to stall, a lot of hesitation, In fast moving traffic, if you want to merge or pass another vehicle you must give yourself ample time and make sure it is clear to make your move, if you need to get out of the way really fast you cant, its very dangerous and Hyundai needs to move quick on this before something really bad happens to someone.

my 2018 Hyundai Tucson starting having lurching issues on when first started. i have to back into my driveway so i dont have to go in reverse then go forward. it jerks back and forth so hard. It finally took its toll on the transfer case and it exploded internally. the Dealership said they had never seen this before. i was hoping that was the cause of the issue but it wasnt. Still doing it and am afraid it will do it again. i was under warranty when it happened, so teh $2000 replair was covered. i'm concerned it will happen again. teh problem goes away after it's been completely warmed up. but like many others, its a scary issue when first started. it also will also shift hard when it firsts get's going (after the initial hard lurching back and forth). i dont know what to do. Love the...

very bad acceleration from a stop position, engine revs but does not move, in slow traffic it hesitates and lunges forward like it’s not sure what it’s suppose to do, when trying to merge or pass another car, you have to give yourself time, it’s very dangerous, took it to the dealer 2 times, was told that’s how the car is made, there is no way this is suppose to be the way the car was built. also a smell of antifreeze but no leaks detected,

When merging into traffic, the car lost all acceleration and the transmission revved to a very high rpm. This has been an ongoing problem since the car was purchased. The dealer keeps saying they “cannot replicate”. This car is going to kill me.

Rod bearing failure. Sounded like a tractor all of a sudden and stalled every time I’d come to a stop. Had it towed to the dealership. Awaiting word from Hyundai as to whether the warranty will cover this. Checked oil and wasn’t low. No check engine lights or oil lights or anything ever came on. No noises prior to this happening. Kept up on routine maintenance.

The vehicle almost stalls and doesn't want to take off 1st thing in the morning then suddenly it accelerates abruptly well above the amount of pedal pushed. It also has inconsistent shifts at anytime during a drive. Sometimes it won't shift until we leave off the gas. This has been twice in for diagnosis at Rom Marhofer in Cuyahoga Falls, Ohio 44221. Both times they tell us--they could not get the vehicle to produce the symptoms. It does this everyday of the week for us--everyday. The service writer says this is common for the dual clutch transmission. This is a safety issue with not having power to move then suddenly--wham.