2016 HYUNDAI SONATA HYBRID Engine Problems

The car will randomly lose acceleration and jerk forward. It will make a beeping noise while the hev system warning flashes on the dash. It also says to turn off engine. While the warning is flashing and engine light is on it goes into a limp mode and you have limited acceleration. It has almost caused multiple wrecks when I go to acceleration from turning or at lights in traffic because I cant go over 20-30 mph. I have turned the car on and off and the hev system and engine light turns off and the car continues to work normal. It eventually comes back on and does the same loss of power/hev warning. It will be random and does not matter on how fast you are going to trigger the warning lights and loss of power.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while driving at 20 MPH, the message "Shut Down" was displayed, and the vehicle lost motive power. The contact was able to pull over to the side of the road; however, the vehicle failed to restart. The vehicle was towed to the dealer, where it was diagnosed with engine failure, and the contact was informed that the engine needed to be replaced. The vehicle was not repaired due to the cost. The manufacturer was notified of the failure and declined to cover the repair under warranty. The failure mileage was approximately 140,600.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while driving at an undisclosed speed, the vehicle went into LIMP Mode with several unknown warning lights illuminated. The vehicle was towed to the dealer and was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 70,000.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated while driving approximately 65 MPH, the check engine warning light was illuminated, and the vehicle stalled. The contact was able to exit the highway; however, the contact was unable to restart the vehicle. The contact had the vehicle towed to a dealer to be diagnosed. The vehicle was diagnosed, and it was determined that the engine needed to be replaced. The vehicle was not repaired. The contact stated that prior to the engine failure, the engine had been replaced two years prior. The manufacturer was not informed of the failure. The failure mileage was approximately 180,000.

While on the highway vehicle started shaking violently, flashing engine light then service hybrid system along with every light on the dash! Car still running poorly, stiff steering very hard to slow down to get to safety! By the time I was able to pull over the engine was knocking and a burning smell was coming from the engine compartment. I popped the hood shut the car off , the exhaust manifold and converter(in one together) was so hot it was glowing! I’m thankful I was able to get to safety without it catching fire because it was on its way there! I called for a tow and sent it to the dealer where Hyundai is replacing the engine.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated while driving approximately 60 MPH, the check engine warning light illuminated, and the message "Check Hybrid System, Turn Off the Engine" was displayed, and the vehicle was shaking while decelerating. The vehicle was towed to the dealer where it was diagnosed with the Technical Service Bulletin: 198. The Technical Service Bulletin was completed; however, the failure recurred. The vehicle was towed to the same dealer where it was diagnosed with a drained battery and catalytic converter failure. The vehicle was repaired; however, the failure recurred. The vehicle was towed to the same dealer. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 147,000.

While driving the car completely cut off i could not use my brakes my horn or steering wheel

My check Hybrid system light comes on and then my car stops allowing me to drive , the gas stops working ! This happened 3 times on the highway very dangerous

I was driving on the freeway and the car went from 70 mph to 60 then 50 then 40 slowing on the freeway each second. This has happened multiple times, each time taken in Hyundai and “repaired” only to happen a couple months later.

HEV WARNING TURN OFF ENGINE CAR STARTED SHAKING while driving on the interstate gas pedal went to the floor car started making a loud noise from the engine I put car in park and it would not move for 45 minutes at a stop sign

As I was driving on the highway at 65MPH, a sudden warning appeared on the dashboard that read, "CHECK HYBRID SYSTEM/TURN OFF ENGINE". Immediately after that, I noticed that my vehicle started behaving erratically, making it difficult to control. I stepped on the gas pedal expecting the car to pick up speed and move forward. Despite the pressure I applied, the car failed to accelerate, leaving me stuck in my current position. After nearly causing a severe accident on a busy interstate, I was able to safely pull my car over to the side of the road. After conducting extensive research, I discovered that the issue I am facing with my hybrid vehicle is actually quite common among Hyundai Sonata Hybrids. It's surprising to note that despite this problem's prevalence, no recall or common solution has been provided to address it. I am highly concerned that Hyundai has not taken...

HEV turn off engine light pops up WHILE driving. I could’ve been on the highway or the middle of no where and have to turn off my car, just to turn it back on and it seems fine? This has happened a total of 5 times since owning this vehicle, and I’ve gotten all code on the car fixed about a month ago.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while his wife was driving at a slow speed out of the driveway, she heard a knocking sound coming from under the hood. The check engine warning light was illuminated. The vehicle was towed to the dealer where it was diagnosed that the engine needed to be replaced. The vehicle was repaired; however, the failure recurred. The contact stated that after the vehicle was retrieved from the dealer, the check engine warning light illuminated after 300 miles. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 163,000.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while his son was driving at an undisclosed speed, the vehicle lost motive power. The vehicle was towed to the dealer, where it was diagnosed with low oil and engine failure. The vehicle was not repaired. The contact related the failure to NHTSA Campaign Number: 20V746000 (Engine). The manufacturer was made aware of the failure. The failure mileage was 67,036. The contact noted that the failure speed was approximately 40 mph. It wasn't long after purchasing the vehicle that the engine seized while driving. The contact stated that the manufacturer will not honor the warranty due to the incident occurring from "an outside influence". Said influence is unknown to the contact.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated while driving approximately 65 MPH, several unknown warning lights illuminated and the vehicle decelerated independently. The contact was able to park on the side of the road before the vehicle stalled. The vehicle was not drivable. The contact towed the vehicle to a local dealer, where it was diagnosed with needing the knock sensor to be replaced. The vehicle was repaired. The manufacturer had not been informed of the failure. The failure mileage was 34,252.

My vehicle first went into limp mode and stalled while driving December 2021. Vehicle was taken to Dealership in Alpharetta, GA. I was advised the knock sensor needed an update. The update was completed but the vehicle continued to go in limp mode and stall again March 2022 after driving less than 1000 miles since previous repair. The vehicle was taken to dealership in Wake Forest, NC. This time there was no update for the knock sensor so I was advised they would need to replace knock sensor but it was on backorder until end of May 2022. The knock senor was replaced picked up vehicle and engine light came on by the time I had drove 50 miles and vehicle started to go in limp mode and stall again and car started shaking an bad vibration. Drove the car next morning and it put me down again going into...

The car requires a quart of oil every 1 to two weeks. Brought it to multiple dealerships and was never given a reason why. Car was making knocking noises anytime driven at 45 or below and sometimes higher. We believe it had to be about the recall Hyundai has advised us about multiple times. We brought it to them on Friday July 22nd. They updated the Hybrid system and we left. Driving the car to work July 27th and the car went into “limp” mode and stated that there was a issue with the hybrid engine and to shut the car off immediately. I was able to pull the car off the road and turn it off. The engine light constantly blinked when the error happened. When I shut the car off and turned it back on, it the same hybrid error shows up on the screen again. We had...

I have a 2016 Hybrid Sonata [XXX], the dash started flashing and said...... HEV trouble! STOP the engine now! Now I have a orange engine light. I brought the car to the dealer. They will look at it and contact me. This car cost me plenty, last year they made me pay for a new engine, it would eat up a quart of oil every two weeks. That is 2 quarts a month. INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

Recently Service Campaign 966 (NHTSA ID Number: 10210205 Manufacturer Communication Number: 22-01-028H) was applied to my vehicle for improved knock sensor detection system (KSDS) logic. Six days following the software update, my vehicle stalled when DTC P1326 came active during my wife's commute home. We had the vehicle towed to the dealership where a knock sensor was identified to be replaced. 10 days after getting the vehicle back, knocking was heard from the engine compartment and DTC 1326 came active again, causing the vehicle to immediately stall. It did not go into engine protection mode as service campaign 966 indicated it would. My concern is that Hyundai changed the sensitivity of knock detection to prevent warranty claims on engines that may be affected by increased bearing wear; and in preventing replacing engines, they have caused engines (mine included) to stall. This engine stalling is a safety issue and they have...

Recall [XXX] : Engine Inspection / Replacement ([XXX]) In the month of Oct 21, my Hyundai sonata hybrid, had severe engine issues and stalled. Upon inspection by dealer, it was determined, it needs engine replacement as there was a recall for these engines. After 3 months of waiting, in January 2022, I received my car back supposedly with the new engine. today [XXX] my car has stalled again with a similar engine issues and I have towed my car to the same dealer (DORAL HYUNDAI : Miami Florida) for inspection. fortunately i was not injured or ended up in an accident. the car just stalled suddenly with red lights on for every parameter along with engine light. luckily i was on the onramp and not in between the freeway. still was a dangerous situation as cars barely managed to save from hitting me when the car suddenly slowed down and...

The NHTSA has numerous complaints from owners of the 2016 Hyundai Sonata and 2016 Hyundai Sonata Hybrid with failures associated with the following: abnormal (knocking) noise from engine, reduced motive power and/or hesitation, illumination of the “Check Engine” warning lamp, illumination of engine oil pressure warning lamp, and a burning smell, oil leaking, and smoke. After research, I found the recall 21V301000, which lists “Part 573 Safety Recall Report 21V-301”, and I have attached it. I believe the piston oil rings are potentially a source of engine failure for the 2016 Hyundai Sonata and 2016 Hyundai Sonata Hybrid (since they are from the same manufacturer) and not the process and defect that Hyundai previously listed (that they stated was corrected), yet referenced in their recall. Hyundai and Kia both have defects with their ignition coils that have the shared part number: 27300-2E601, which also appears as: 27300 2E601. We have...

On 04/09/2022 around 6:30 PM EDT, while driving on the Florida Turnpike at the posted 70 mph in Orlando FL, the 2015 Sonata Hybrid suddenly shut down in the center of 4-lanes with heavy traffic. The engine would not run and only sputtered and jerked when I gave it any gas. The display screen lit up with multiple failure symbols including the Hybrid System failure, lane detection failure, and several others. I exited the Turnpike and had a local auto store scan the vehicle finding the following DTC’s: 1. P1326: Excessive connecting rod bearing wear 2. U0293: Lost Communication with Hybrid Powertrain Control Module 3. U1004: Not certain The vehicle was checked and found to be full of oil. The vehicle was serviced at the Hyundai Dealer on 02/25/2022 where they specifically updated the “Excessive connecting rod bearing wear” knock sensor software along with a turn signal issue. Having the...

When entering freeway and needing to get up to speed real quick, the car will accelerate to approximately 50mph and then engine totally cuts out like the gas stopped flowing to it. I then have to let off on the gas considerably or it will not accelerate until I let off on the gas about 1/2 way. I then must "Slowly" accelerate so that it won't cut the engine again. This will happen anywhere if I take off from 0 mph and try to accelerate with peddle eventually going to floor, the car will cut the engine and will feel like its dying until I let off on the gas peddle all the way and then slowly accelerate the vehicle up to speed.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while driving at 75 MPH, he heard an abnormal popping sound coming from the engine. The contact stated that the engine started making abnormal rattling sounds and the vehicle was shuddering. The check engine warning light and the oil warning light illuminated. The contact continued to drive the vehicle to the residence. The vehicle was then towed to an independent mechanic where it was diagnosed that oil had leaked in the engine compartment and that there was a hole in the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The contact became aware of NHTSA Campaign Number: 20V746000 (Engine) and the dealer was contacted for the recall repair; however, the dealer informed the contact that the next service availability was in a month. The contact stated that the manufacturer...

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated while driving 50 MPH, the vehicle started to violently shake and lose power while being powered by the engine. The contact stated the accelerator pedal was released and the shaking stopped as the vehicle switched to being powered by the battery. The contact stated as the vehicle was a hybrid vehicle the switch between using the engine and battery was done automatically when the accelerator pedal was released. The contact also stated that an abnormal noise was coming from the engine compartment when the vehicle was started. The check engine warning light was illuminated. The vehicle was taken to the dealer where the failure was diagnosed as an engine misfire and that the coils needed to be replaced. The vehicle was repaired; however, the failure continued as soon as the vehicle was picked up from the dealer. The vehicle...

The vehicle concerned is a 2016 Hyundai Sonata Hybrid Limited. It originally presented a check engine and check oil light, and lost partial power traveling on the highway. This vehicle was able to return to its residence, and it was towed to a Hyundai Dealership. Photos and videos were taken of this vehicle prior to being towed, and its battery voltage was tested. The Hyundai Dealership initially reported a dead battery, and that diagnostics were completed. Further conversations took place to question if a jump box or battery charger had been used, and the manager offered to test this vehicle personally. The manager stated that two jump boxes started this vehicle, and then stated he drove this vehicle with two jump boxes connected. The manager insisted that this vehicle's issues were only caused by a failed (dead) battery. A new battery was purchased and then the Hyundai Dealership installed it....

1. engine blew 2. driving on highway, lost power, had to coast off exit 3. at dealer was told waiting to hear from Hyundai 4. at dealer 5. oil light went on in between oil changes, had to add oil in between oil changes, knocking, and poor gas mileage, prior to engine blowing, no other warning lights no other warning lights

eginning in June 2020, my check engine light on my 2016 Hyundai Sonata Hybrid started coming on. I took it into a dealer to get it fixed. The problem seemed to be fixed until the light came on again, took it to the dealer who replaced a different part, seemed be fixed, and so forth until the engine blew while I was driving to work(2/3/2021). It was towed to a dealer and the engine was found to be seized. Luckily Hyundai had just sent out a recall letter to me cautioning about a faulty engine. (There are now lawsuits against Hyundai for this same reason).Hyundai replaced the engine. Meanwhile I found their campaign reimbursement page (case #17706103) and submitted all my out of pocket cost since the first check engine light occurrence (6/10/20) through to the car rental cost which was when the car engine was replaced (6/21/2021). Sum total...

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a local dealer where it was diagnosed with needing the ignition coils replaced. The vehicle was not repaired. The manufacturer was informed of the failure and the contact was awaiting a response. The failure mileage was approximately 135,000.

Lots of noise and car started smoking and stopped working while I was on the highway

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated that while receiving an oil change, the dealer informed the contact that there was an abnormal sound from the engine compartment. The contact stated that the check engine warning light was illuminated. The vehicle was towed and diagnosed but not yet repaired. The manufacturer was informed of the failure. The contact was informed that the Vin was not under recall. The failure mileage was approximately 157,035.

The engine begins to shake and makes a dieseling sound, the check engine light comes on, and we lose power to car. As we remove our foot from the gas, the light goes out and the engine stops. Sometimes it comes back on again and we have to pull to the side of the road and turn the car off. After that the check engine light goes away. When the light comes on, power to the engine is immediately cut and reduces as you press the accelerator pedal.

The contact owns a 2016 Hyundai Sonata Hybrid. The contact stated while driving 15 mph, the vehicle loss motive power and shuddered while the accelerator pedal was being depressed. There was no warning light illuminated. The contact pulled over and restarted the vehicle however, the failure persisted. The contact took the vehicle to the local dealer however, the vehicle was not yet diagnosed nor repaired. The contact was concerned that the failure was engine related. The manufacturer was made aware of the failure. The failure mileage was 99,000.

IN OCT..2020 MY SONATA WAS AT PEP-BOYS AUTO FOR A SYNTHETIC-OIL CHANGE. PEP-BOYS CALLED ME TO ADVISE CAN'T SERVICE THE CAR FOR THE OIL CHANGE. SINCE LAST OIL CHANGE 6K MILES AGO THEIR WAS NO OIL IN THE ENGINE. THEY SAW THIS SEVERAL TIMES IN THE LAST YEAR WITH 2.0 ENGINE, THEY WANT NO RESPONSIBILITY AND SAID TAKE YOUR CAR TO THE DEALER & OPEN CASE THE ENGINE HAS A SERIOUS FLAW, IT BURNS THE OIL WITH THE GASOLINE. THEY SAID A RECALL? DOCUMENTS ATTACHED. I WENT TOTEXAN HYUNDAI, PUT MY CAR THROUGH A SERIES OF TESTS EVERY 1000 MILES. I WAS TOLD THE ENGINE CAN BE REPLACED YOU IN THE 10 YRS, HOWEVER YOU OVER THE 100K MILES,WILL NOT B COVERED, A HYUNDAI MOTORS WOULD COVER 50% . WAS TOLD ENGINES LAST 250-300K MILES. I SPENT OVER 2K FOR EXT. WARRANTY. IT RAN OUT AT 100K. HYUNDAI HAS NOT...

DRIVING DOWN THE ROAD AT 65 MPH, THE ENGINE STARTED MAKING A TICKING NOISE. FURTHER DOWN THE ROAD THE TICKING BECAME KNOCKING. THIS PROMPTED THE COMMAND CENTER TO TELL ME TO TURN THE VEHICLE OFF IMMEDIATELY. THE VEHICLE WOULD NO LONGER CRANK AND WAS GIVING A CAMSHAFT SENSOR CODE. I RECEIVED A RECALL NOTICE 5 DAYS LATER. HAD THE VEHICLE TOWED TO THE DEALERSHIP. AFTER BEING TOLD I WOULD NEED A NEW ENGINE, AND THAT IT WASN'T A RECALL ISSUE, I CALLED NATIONAL. AFTER A WEEK OR SO IT WAS CONFIRMED THAT HYUNDAI WOULD REPLACE THE MOTOR AT THEIR EXPENSE. NEVER CONFIRMING IT WAS BECAUSE OF THE RECALL THOUGH I HAD ALL THE SYMPTOMS OTHER THAN CATCHING ON FIRE. IT HAS NOW BEEN 2 MONTHS AND MY MOTOR IS SUPPOSEDLY ON BACK ORDER, BUT COMING IN WEEKLY. HYUNDAI SEEMS TO REALLY BE DRAGGING THERE FEET THOUGH THEY LOST A LAWSUIT...

TL* THE CONTACT OWNS A 2016 HYUNDAI SONATA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V746000 (ENGINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED BOB BAKER HYUNDAI (5285 CAR COUNTRY DR, CARLSBAD, CA 92008, (760) 929-4900) WHERE IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE FOR THE RECALL REPAIR. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT STATED WHILE DRIVING 30 MPH, A CLICKING SOUND WAS HEARD. THE CONTACT STATED THAT SEVERAL WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS NOT TAKEN TO AN INDEPENDENT MECHANIC OR DEALER TO DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 55,707. PARTS DISTRIBUTION DISCONNECT.

TO WHO READS THIS, THANK YOU FIRST AND FOREMOST TO TAKE THE TIME TO READ THIS. THIS IS A REAL PERSON, THIS IS MY REAL STORY. I HAVE BEEN NOTICING A KNOCKING ENGINE NOISE FOR 5 TO 6 WEEKS AND THEN GOT THE NHTSA RECALL NUMBER20V746000 IN THE MAIL. I SET THE SOONEST APPOINTMENT WITH THE DEALERSHIP. THE DAY OF THE APPOINTMENT I WAS ADVISED BY ANDY THAT IT WOULD TAKE 3 TO 4 WEEKS FOR THEM TO LOOK AT MY VEHICLE AND RUN IT THROUGH HYUNDAI'S RECOMMENDED DIAGNOSIS. LATER I CALLED THE HYUNDAI CAMPAIGN HOTLINE AND OPEN CASE # 18081104. I WAS TOLD TO WAIT 3 TO 5 DAYS FOR A NATIONAL REPRESENTATIVE TO GET BACK WITH ME. I CALLED TWO DAYS LATER REQUESTING AN UPDATE AND SHORTLY LATER THE DEALERSHIP CALLED ME TO INFORM ME MY CAR WAS READY. ANDY SAID IT CLEARED INSPECTION AND I ASKED IF...

BAD ROD BEARINGS,CAN START A FIRE. NO HELP FROM DEALER.

I HAVE RECEIVED A RECALL NOTICE AND AFTER THREE MONTHS THERE IS STILL NO REMEDY.

TL* THE CONTACT OWNS A 2016 HYUNDAI SONATA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V746000 (ENGINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. ROSEVILLE HYUNDAI (200 N SUNRISE AVE, ROSEVILLE, CA 95661) WAS CONTACTED AND IT WAS CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND OFFERED NO ASSISTANCE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.*DT

TL* THE CONTACT OWNS A 2016 HYUNDAI SONATA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V746000 (ENGINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT CALLED FITZGERALD COUNTRYSIDE HYUNDAI (27419 US HWY 19 N, CLEARWATER, FL 33761, (888) 794-1694) AND IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

IN JUNE OF 2020 I GOT AN EMERGENCY WARNING ON MY VEHICLE'S DASH THAT THERE WAS A PROBLEM WITH THE HYBRID SYSTEM AND SHOULD STOP MY CAR IMMEDIATELY AND TAKE IT TO THE DEALERSHIP. THE VEHICLE SLOWED TO 20 M.P.H. THEN CAME TO A STOP, I TOOK THE CAR TO THE DEALER WHERE IT WAS KEPT FOR 10 DAYS, I WAS TOLD THEY COULD NOT DUPLICATE THE PROBLEM AND I PICKED UP THE VEHICLE. HALF A BLOCK FROM THE DEALER IT HAPPENED AGAIN, I RETURNED THE VEHICLE TO THE DEALER THEY SAID IT WAS A SPARK PLUG WHICH WAS REPLACED. I EXPRESSED MY CONCERN WITH THE CAR COMING TO A STOP IN THE MIDDLE OF TRAFFIC. ON MARCH 3, 2021, THE SAME THING HAPPENED, A WARNING ON MY DASH, THE VEHICLE SLOWED AND CAME TO A COMPLETE STOP. I AGAIN TOOK IT TO THE DEALER AND WAS TOLD THAT THE...

I HAVE 115000 MILES ON MY 2.0 ENGINE. ITS IS ALWAYS SERVICED 5-6K SYNTHETIC OIL. THE SERVICE MAN TOLD ME 3 MONTHS AGO SOMETHING IS WRONG. ALL HIS OIL WAS EATEN UP IN UNDER 5K. HE SAID THIS ENGINE IS FAULTY ND HE HAS SEEN THIS MANY TIMES ON THE HYUNDAI. I RECEIVED A LETTER 2 WEEKS AGO SAYING HYUNDAI HAD ENGINE ISSUES AND A RECALL WOULD HAPPEN. MY CAR IS BONE DRY AND CORPORATE SAID NOT WARRANTIED. I OPENED A CASE# 18042071. I UNDERSTAND THERE IS A SECRET MEMO #198 TO RECALL. THERE ARE MANY PEOPLE JUST LIKE ME. PLEASE HELP. OTHER THAN THE ENGINE THE CAR IS IN LIKE NEW CONDITION. ITS ALL HIGHWAY HOUSTON TO BRENHAM TEXAS. FLAT ROADS. BOUGHT NEW. WITH 100,000 EXTENDED COVERAGE. NOW EXPIRED.

TL* THE CONTACT OWNS A 2016 HYUNDAI SONATA HYBRID. THE CONTACT STATED WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE LOSS MOTIVE POWER AND STALLED WITH THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN UNKNOWN DEALER TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE ENGINE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER REPLACING THE ENGINE, THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V746000 (ENGINE). THE CONTACT LINKED THE FAILURE TO THE RECALL. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 62,000.

TL* THE CONTACT OWNS A 2016 HYUNDAI SONATA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V746000 (ENGINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. NEITHER THE DEALER NOR THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

KNOCKING IN ENGINE AREA THEN SAID TO STOP IMMEDIATELY THEN BATTERY DIED

TL* THE CONTACT OWNS A 2016 HYUNDAI SONATA HYBRID. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V746000 (ENGINE) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. NEITHER THE DEALER NOR THE MANUFACTURER WERE CONTACTED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT. *BF CONSUMER STATED DEALER WAS CONTACTED.*JB

TL* THE CONTACT OWNS A 2016 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING 25 MPH, THE WARNING MESSAGE "SHUT OFF" HAD DISPLAYED BEFORE THE VEHICLE STALLED. THE VEHICLE WAS LATER TAKEN TO THE LOCAL DEALER FAIRFAX HYUNDAI LOCATED AT 10925 FAIRFAX BLVD, FAIRFAX, VA 22030 WHO DIAGNOSED THAT THE WATER PUMP AND ENGINE GASKET WERE FAULTY. THE VEHICLE WAS REPAIRED AND THE FAILURE WAS REMEDIED. ADDITIONALLY, THE INSTRUMENT PANEL DISPLAYED HAD SUDDENLY SHUT OFF WHILE DRIVING. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE ENGINE WOULD ALSO REV VERY HIGH WHILE OPERATING THE VEHICLE. THE MAIN RELAY WAS REPLACED BY THE DEALER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 22,700.

HYUNDAI CAMPAIGN198. WE RECEIVED THE NOTICE BUT IT STILL SHOWS AS "NO REMEDY". IT'S BEEN OVER 2 MONTHS AND DEALER JUST TELLS US THE CAR "MAY" BE UNSAFE TO DRIVE. SO I HAVE A TRIP IN TWO WEEKS THAT IS DRIVING 17 HOURS EACH WAY, IN AN UNSAFE VEHICLE WITH MY FAMILY AT FREEWAY SPEEDS. YOU CAN'T CHECK A CONNECTING ROD BEARING SO THE REMEDY IS ENGINE REPLACEMENT. WHAT REMEDY ARE YOU WAITING FOR?

TL* THE CONTACT OWNS A 2016 HYUNDAI SONATA HYBRID. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE VEHICLE STARTED MAKING AN ABNORMAL TICKING NOISE SIMULTANEOUSLY WHILE STALLING, WITHOUT WARNING. THE CONTACT WAS FORCED TO PLACE THE VEHICLE INTO HYBRID MODE TO RESUME NORMAL DRIVING. THE CONTACT TOOK THE VEHICLE TO CARTER COUNTY HYUNDAI (616 HOLIDAY DR, ARDMORE, OK 73401) AND WAS INFORMED THAT THE ROD BEARING WAS DEFECTIVE. THE CONTACT WAS ALSO INFORMED THAT THE VEHICLE WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V746000 (ENGINE) WHICH WAS LINKED TO THE FAILURE. THE CONTACT WAS INFORMED THAT THE PARTS FOR THE RECALL REPAIR WAS NOT YET AVAILABLE. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 119,000. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.