2008 HYUNDAI SANTA FE Engine Problems

I took the car to get this recall done: Hyundai has decided to conduct a service campaign to inspect (and if necessary replace) the alternator and replace the front valve cover gasket on certain 2007-2009 model year Santa Fe vehicles. The recall was done, replacing the gasket and alternator. 2 years later the car started to stall in the middle of traffic. I returned to the dealer, dealer inspected and reported "oil found on the new alternator and oil leak found on the real valve cover gasket". I have been going back and forth on the phone with Hyundai costumer care. They said they will not redo the recall. It was not done correctly and slowly leak again. the vehicle now cut off everyday specially when i stop and go at short drives. It has also cut off in traffic. making it very dangerous. But Hyundai is telling me nothing...

Seem like it burns oil quick

The contact owns a 2008 Hyundai Santa Fe. The contact stated that the vehicle was taken to a local dealer for an undisclosed recall repair, and the contact was informed that the valve cover gasket, and the alternator were faulty and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 88,000.

I had a recall on the oil leak and took care of it to dealership in Weston Fl they had car for 2 days pick car up. I replaced to alternator because it was full oil prior to me taking it to the dealership. Now a few months later there is still a leak and it’s leaking on my alternator, again same place they said they fix. I have the paperwork. I am having smoking issues that they said was fixed it, but looks like the put glue on it.

Brought 2008 Hyundai Santa Fe to Carlsbad Hyundai dealership on 12/22/23 for Service Campaign 976, due to oil leaking from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. Dealership said the vehicle needed to be fixed but they needed to order parts and that it would take 2-3 wks. It has now been over 6 months. I have called the dealership and Hyundai America multiple times all to no avail.

In October 2021 the alternator failed due to an oil leak from the valve cover gasket. I paid the local Hyundai dealer to replace the alternator and they also said the battery was damaged because of the failed alternator so I paid for a new battery as well. The dealer never mentioned the recall on this vehicle for the leaking valve cover and did not disclose that the leak was known to cause alternator failure. I later learned of the recall and had the valve cover repair performed under the recall. However, Hyundai has refused to reimburse me for the alternator repair that I had already previously paid for, and likewise have refused to reimburse me for the battery. Clearly the problem was due to the known defect that resulted in the recall, so I am obviously entitled to compensation for the out if pocket repair expenses. Please advise me...

Reference Number: 11520065 This is a follow up to a previously submitted incident involving this same vehicle. My first submission was May, 2023, This vehicle experienced the exact same hazardous condition on February 26, 2024. on I-75 south. After driving on an interstate highway for about 1 hour, I noticed a traffic backup and proceeded to slow down as the traffic was nearly stopped. As I slowed my car down to nearly a complete stop, the engine suddenly surged forward with high rpm's as though the accelerator was pushed to the floor. I immediately pressed on the brake pedal as hard as I could to stop the car from surging forward and then quickly decided to put the transmission into neutral so I would not hit the car in front of me. The car eventually stopped surging and may have stalled. I finally got the car to move again by...

Valve cover leak or head gasket leak

Vehicle has stalled couple of times while driving. One on the service road just about to merge on the highway 1604 North after taking left turn from the Potranco road about a year ago. Steering got locked and engine died, I managed to pull over to the right shoulder into the parking lot of Med Clinic. After couple tries, I was able to get it going. There is occasional check engine light on that goes off after some time of driving and not sure if this is related to stalling of engine. There is a history of oil leak under the hood. I received recall service notice for leaking cylinder head gasket which outlined same issues that I encountered before and took vehicle to the dealership. It was kept for 2 days for service and was returned to me. There is still sign of wetted oil on the parts. There...

i change the oil on 4/18/2023 in walmart i park the car in my house i used on 04/23/2023 on i-75 southbound the oil light came out and them smoke star on the car fallow by fire me and daugther an husband where on the suv was tereffied

Head on impact rear ending a truck. Engine locked melted head gaskets and destroyed radiator

ON HIGHWAY, CAR WOULD NO LONGER ACCELERATE AND WENT INTO LIMP MODE CAUSING ME TO SLOW TO 50 MPH AND NOT BE ABLE TO KEEP UP WITH SPEED IF TRAFFIC. PULLED OVER, DASH LIGHTS FLASHED AND CAR WOULD NOT RESTART. OIL HAD LEAKED OUT OF VALVE COVER GASKET ALL OVER THE ALTERNATOR CAUSING THE CAR TO MALFUNCTION AND BECOME INOPERABLE.

CAR CUTSOFF WHILE DRIVING

TURNING LEFT THRU AN INTERSECTION TH E CAR STALLED, LEAVING US WITH NO BRAKES AND VERY LITTLE STEERING. THIS HAS HAPPENED MORE THAN ONCE.

LEAKING VALVE COVER IS ALLOWING OIL TO LEAK DOWN ONTO THE ALTERNATOR. CAR BE STATIONARY OR RUNNING. MOST NOTABLE WHEN CAR ENGINE IS RUNNING.

THE CAR SHUTS OFF WHILE DRIVING. NO PRE-WARNING OR ALERT BEFORE IT HAPPENS

I WAS DRIVING ALONG AND MADE A RIGHT TURN INTO A INTERSECTING ROAD WHEN I ENCOUNTERED LOSS OF STEERING CONTROL. AFTER ALMOST HITTING A CAR I GOT IT OFF TO THE SIDE OF ROAD AND DISCOVERED THAT THE ENGINE HAD JUST SHUT OFF WITH NO WARNING. IT CRANKED RIGHT BACK UP AND I DROVE IT HOME BUT NOW I AM AFRAID TO DRIVE IT.

MY 2008 HYUNDAI SANTA FE STALLED TWICE TODAY. IT ALSO STALLED ON THE SAME DAY TWICE LAST WEEK. THIS HAPPENED EACH TIME I CAME TO A STOP LIGHT OR WANTED TO MAKE A TURN. THE ENGINE STOPPED RUNNING, THE POWER STEERING CEASED WORKING, AND CHECK ENGINE LIGHT CAME ON. AFTER EACH OCCURRENCE, I SWITCHED MY HAZARD LIGHTS ON, PUSHED THE TRANSAXLE TO PARK AND THEN RESTARTED THE CAR TO PULL OUT OF TRAFFIC. THE STALLING IS OFTEN ACCOMPANIED BY LOSS OF POWER (POWER STEERING AND BRAKES TOO), COMPLETE FAILURE TO ACCELERATE, AND THE CHECK ENGINE LIGHT COMES ON.

WHILE NORMAL DRIVING DOWN A CITY ROAD GOING STRAIGHT THE VEHICLE WILL STALL WITHOUT ANY NOTICE OR ANY CHANGE IN CONDITION. YOU LOOSE ALL POWER, BRAKES AND STEERING WHEN THIS HAPPENS AND HAVE TO BRING IT TO STOP WITH EMERGENCY BRAKE AND PLACE IN PARK. THEN YOU CAN START THE VEHICLE ONCE AGAIN LIKE IT HAS NO ISSUES. THIS ISSUE PRODUCES NO ENGINE TROUBLE CODES AND HAS HAPPENED 3 OTHER TIMES IN THE 6 YEARS WE OWNED THE VEHICLE. THIS IS EXTREMELY DANGEROUS AND WE NEVER KNOW WHEN IT WILL HAPPEN.

THERE HAVE BEEN 3 INSTANCES WHERE AFTER TURNING ON MY VEHICLE, THE POWER IS THROTTLED AND I CAN ONLY DRIVE A COUPLE MILES PER HOUR. I RAN A DIAGNOSTIC SCAN, AND OBTAINED THE CODES P2106, P1295,AND P2135. I SEARCHED ONLINE AND FOUND THIS TO BE A COMMON PROBLEM. THERE APPEARS TO BE A TECHNICAL SERVICE BULLETIN OUT FOR THIS ISSUE (TSB 09-FL003-2). IF THIS IS A COMMON ISSUE, SHOULD THERE BE A RECALL? THANK YOU.

I ACTUALLY HAVE 2 ISSUES OCCURRING. ONE OF THESE WAS DEEMED TO HAVE BEEN FIXED BY A PREVIOUS RECALL (CAMPAIGN 105/110 - FIXED /CLOSED JUN 23, 2014). HOWEVER, MY ESC OFF LIGHT AND ABS LIGHT ARE AGAIN LIGHTING UP. I HAVE (LUCKILY) NOT YET HAD LOSS OF ENGINE POWER OR CONTROL. THE SECOND ISSUE IS IN REGARDS TO CAMPAIGN 936. I'VE HAD THE FRONT ENGINE VALVE GASKET COVER FIXED, ALONG WITH MY ALTERNATOR REPLACED (AFTER MY HUSBAND AND I DID IT OURSELVES AFTER LOSING ALL POWER ON CHRISTMAS EVE IN THE MIDDLE OF ROAD BEFORE BARELY COASTING INTO A NEARBY PARKING LOT WHERE WE WERE ABLE TO SORT OF PARK OUT OF THE WAY). WE CHANGED MY OIL THIS WEEKEND, HAVE HAD NO OTHER WORK DONE ON THE CAR SINCE (EXCEPT OIL CHANGES) AND MY HUSBAND NOTICED THAT THE ALTERNATOR IS AGAIN COVERED IN OIL. BETWEEN THE 2 ISSUES, IT...

I WAS DRIVING AT A LOW SPEED, MAKING A LEFT-HAND TURN WHEN THE CAR LOST ALL POWER. NO BRAKES, NO STEERING. I WAS ABLE TO GET THE CAR INTO A DRIVEWAY. I WAS ABLE TO RESTART . ABOUT 1 HOUR LATER THE SAME THING, ONLY THIS TIME I WAS MAKING A LEFT-HAND TURN ACROSS A VERY BUSY CITY STREET.. I WAS ALMOST HIT BY AN ONCOMING VEHICLE. THIS IS VERY DANGEROUS AND WILL PROBABLY SELL THE CAR & TELL THE NEW OWNERS ABOUT MY ISSUE. I HAVE NOT TAKEN IT TO A GARAGE, AS THE CLOSEST HYUNDAI SHOP TO ME IS AN HOUR AWAY. I DO NOT FEEL SAFE DRIVING THAT FAR.

TOOK MY CAR TO A TWO MECHANICS WHO BOTH SAID THERE IS A GAS LEAK IN THE EVAPORATOR OF THE EMISSION CONTROL SYSTEM. I READ ONLINE THAT THIS ISSUE IS COMMON WITH SANTA FES AND I BELIEVE THE COMPANY SHOULD ISSUE A RECALL AND GET THIS DANGEROUS ISSUE FIXED.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD A WHINING NOISE. ALSO, WHEN THE CONTACT SHIFTED FROM FIRST TO SECOND OR FROM THIRD TO FOURTH GEAR, THE TRANSMISSION SHOOK VIOLENTLY AND THE ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE PURGE VALVE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. AFTER THE REPAIR, THE FAILURE RECURRED SEVERAL TIMES. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 41,432.

WHILE AT A STOP IN A CONSTRUCTION ZONE, MY FOOT WAS ON THE BRAKE, WHEN THE VEHICLE SUDDENLY ACCELERATED INTO THE VEHICLE IN FRONT OF ME. ALTHOUGH MY FOOT WAS PLANTED HARD ON THE BRAKE, THE ENGINE CONTINUED RACING, AND IT FELT LIKE MY CAR WAS GOING TO PUSH HIS CAR DOWN THE STREET! I SHIFTED INTO PARK AND TURNED THE CAR OFF. LUCKILY THERE WAS ONLY $4,000 WORTH OF DAMAGE TO MY CAR, AND NO ONE WAS HURT. I REFUSED TO DRIVE IT, AND HAD IT TOWED TO THE DEALER. THEY SAID THE COMPUTER SHOWED NO MALFUNCTION, AND IT HAD TO BE DRIVER ERROR. THREE MONTHS LATER, IT DID IT AGAIN TO A LESSER DEGREE, IN AN OPEN AREA. I TURNED THE CAR OFF AGAIN, AND IT WAS FINE UNTIL YESTERDAY. IT HAS BEEN 4 MONTHS SINCE THAT LAST INCIDENT, BUT THIS ONE EVEN WAS WORSE THAN THE FIRST....

WHILE ACCELERATING TO MERGE WITH TRAFFIC THE ENGINE STARTING MAKING A STRANGE NOISE. IT CONTINUED TO RUN AND THE NOISE DECREASED, AND SOMETIMES EVEN QUIT. THE NEXT DAY THE NOISE WAS BACK AND WHILE DRIVING DOWN A HILL THE ENGINE DIED AND MY WIFE WAS ABLE TO COAST ONTO AN EXIT RAMP. I WAS ABLE TO GET IT RESTARTED AND DROVE IT TO THE DEALER. THE DEALER STATED WITH THE KNOCKING SOUND AND THEY FOUND METAL IN THE OIL IT WOULD NEED A NEW ENGINE. I COULD NOT AFFORD THE OVER $7,000 ESTIMATE SO I LOADED THE CAR ON A TRAILER AND TOOK IT HOME TO REPAIR MYSELF. WHEN I DISSEMBLED THE ENGINE I FOUND ONE OF THE CONNECTING ROD BEARINGS HAD SPUN AND ALL THE MAIN BEARINGS HAD SIGNIFICANT DAMAGE CONSISTENT WITH METAL DEBRIS ON THE BEARING SURFACE.

TL* THE CONTACT OWNS A 2008 HYUNDIA SANTA FE. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE FUEL GAUGE INDICATOR PROVIDED FALSE READINGS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000.

MY 2008 SANTA FE WITH 109,000 MILES SUDDENLY SHUT OFF ON ME WHEN APPROACHING A STOP SIGN. THE STOP SIGN WAS ON A SLIGHT TURN AND I NEVER REALIZED IT UNTIL I HAD NO POWER STEERING AND SAW ALL THE LIGHTS LIT ON THE DASH. I PUT CAR IN PARK AND IT RESTARTED WITH NO ISSUES. LATER THAT DAY I WENT TO START THE CAR AND ENGINE MADE A LOUD CLUNK SOUND AND CAR SHOOK FOR A SECOND. I DECIDED NOT TO DRIVE IT THAT DAY. IT HAS BEEN 3 DAYS SINCE THE FIRST SHUT DOWN AND SO FAR THE CAR HAS BEEN RUNNING LIKE NORMAL. CALLED HYUNDAI AND MADE NOTE OF MY COMPLAINT BUT DIDN'T SEEM TO KNOW ABOUT THIS ISSUE OR SO MAYBE THEY ARE NOT AT LIBERTY TO SAY IF THEY HAVE. THEY NEVER GAVE ME AN ANSWER EXCEPT TO TAKE IT TO A DEALER TO SEE...

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE HAVING THE VEHICLE ROUTINELY INSPECTED FOR EMISSIONS, THE VEHICLE FAILED DUE TO A FAULTY FUEL GAUGE. THE CHECK ENGINE INDICATOR ILLUMINATED ON THE INSTRUMENT PANEL. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING, BUT THE DETAILS COULD NOT BE PROVIDED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 102,129.

AFTER 141,000 MILES THE ENGINE THREW A ROD, I HAD HEARD A CLICKING NOISE FOR A WHILE BUT WAS ASSURED IT WAS A NORMAL ENGINE SOUND AFTER TAKING IT TO THE DEALER. I CHANGE MY OIL REGULARLY AND HAVE MY SLIPS, THE ENGINE COMPLETELY FAILED WHILE DRIVING. IN THE LAST YEAR AND A HALF I AM HAVING TO REPLACE APPROXIMATELY ONE LOW BEAM HEADLAMP PER MONTH.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE SPEEDOMETER WAS READING EMPTY AND ALL OVER THE PLACE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000. UPDATED 05/10/16*LJ *TR

WHEN DRIVING AND YOU HIT THE BREAKS, THE VEHICLE ATTEMPTS TO STALL, OR IF YOU USE THE HIGH OR LOW BREAMS THE RADIO SHUTS OFF AND THE GPS TURNS ON OR YOU LOSES IT ALL, WHILE ON HIGH WAY WAY IF YOU USE YOUR HIGH OR LOW BEAMS THE ENGINE STARTS TO STALL THEN KEEPS GOING CAUSING THE VEHICLE BEHIND YOU HAVE TO BREAK QUICKLY TO AVOID HITTING YOU AS YOU LOOSE ALL POWER FOR A MATTER OF SECONDS THIS HAPPEN WHILE MOVING OR PARKED, I MHAVE INSTALLED TWO NEW ALTERNATORS IN THE PAST THREE WEEKS AND THE PROBLEM CONIINUES

I ALSO HAD THE FUEL SENSOR GO OUT AND HAD IT FIXED. AND I HAD TO HAVE MY ALTERNATOR REPLACED TWICE. ONCE WHEN IT WENT OUT AND AGAIN IN 9 MONTHS DUE TO RECALL FOR A FUEL GASKET COVER DEFAULT. SO I PAID THE FIRST TIME OUT OF POCKET $700 ONLY TO FIND OUT IT WAS PROBABLY DUE TO THE DEFAULT. LYNDA

WHILE ACCELERATING TO GET ON THE HIGHWAY THE VEHICLE RAPIDLY ACCELERATED WITHOUT PRESSING THE GAS PEDAL. WHEN THIS OCCURRED THE PEDAL STARTED GOING TO THE FLOOR. PRYING UP ON THE PEDAL WITH YOUR FOOT DID NOT HAVE AN AFFECT. THIS HAS HAPPENED TWICE AND THE DEALER HAS LOOKED AT IT TWICE AND HAS ADVISED THAT THEY COULD NOT FIND A PROBLEM.

I EXITED A TOLL AND PROCEEDED TO ENTER THE NJ TURNPIKE, SUDDENLY, THE STEERING BECAME TIGHT. I NOTICED THAT THE POWER STEERING WAS OUT, ALONG WITH THE ENGINE. THE ENGINE JUST TURNED OFF. THANKFULLY, NO TRAFFIC, I PROCEED TO PULL TO THE FEEDER OF THE ENTRANCE. PUT CAR IN PARK, AND THE CAR RESTARTED. I AM NOT SURE WHAT HAPPENED, AND FEARFUL THAT THIS COULD HAPPEN, WITH TRUCKS BEHIND ME, UNABLE TO PULL TO THE SIDE AND RISK SERIOUS INJURY. NO CHECK ENGINE LIGHT WARNING WAS INDICATED. I RECENTLY HAD TWO KNOCK SENSORS REPLACED AT THE HYUNDAI DEALERSHIP.

FUEL GAUGE HAS BEEN FAULTY AND CHECK ENGINE LIGHT WOULD TURN ON AND OFF AFTER REPLACING WHAT I THOUGHT WAS A BAD BATTERY ONE MONTH AGO. ONE WEEK AGO WHILE DRIVING, ALL LIGHTS ON DASHBOARD CAME ON (BATTERY, CHECK ENGINE, ABS, ESC...), ENGINE STARTED TO REV, ELECTRICAL AND POWER STEERING FAILED, AND CAR HAD TO BE TURNED OFF IN THE MIDDLE OF THE ROAD AND TOWED HOME. THIS HAS HAPPENED TWICE WHILE DRIVING NOW. ISSUE IS FROM A FAILING/FAILED ALTERNATOR CAUSED BY OIL LEAK FROM FRONT VALVE COVER. THIS PROBLEM IS IDENTICAL TO ISSUES WITH '06-'12 VERACRUZ, RECALL #121.

WHILE I WAS DRIVING ALONG AT APPROXIMATELY 25 MPH IN MY HYUNDAI SANTAFE THE STEERING BECAME VERY DIFFICULT AND THERE WAS NO THROTTLE RESPONSE. I STOPPED THE VEHICLE COMPLETELY IN THE MIDDLE OF THE BOULEVARD STREET AND PUT THE VEHICLE IN PARK AND RESTARTED THE ENGINE. I WAS VERY FRIGHTENED DURING THE INCIDENT THAT SOMEONE WAS GOING TO RUN INTO THE BACK OF MY CAR AND THAT THE VEHICLE WOULD STOP AGAIN BEFORE I GOT HOME. I REFUSED TO DRIVE THE VEHICLE AGAIN AND FOLLOWED MY HUSBAND IN ANOTHER VEHICLE AS HE DROVE THE FAULTY VEHICLE TO THE DEALER THE FOLLOWING DAY. THE TECH REP WE SPOKE WITH AT THE DEALER CASUALLY SAID THE THROTTLE POSITIONING SENSOR WAS BAD AND IF WE WANTED IT REPAIRED IT WOULD COST ABOUT $400. I COULDN'T BELIEVE THEY WOULD LET ME LEAVE THE DEALERSHIP WITH THIS MALFUNCTIONING PART. THE SYMPTOMS ARE THE SAME AS...

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE DRIVING AT 50 MPH, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER. HOWEVER, THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 175,000.

MY WIFE INDICATED THAT WHEN SHE GOT ON THE RAMP TO RT. 80 , THE CAR COMPLETELY SHUT DOWN. SHE ALSO STATED THAT SHE ALMOST HAD AN ACCIDENT SINCE SHE HAD NO BRAKES NOR POWER STEERING. THIS OCCURRENCE HAS BEEN REPORTED TO THE NATIONAL HIGHWAY SAFETY BY A NUMBER OF OWNERS YET YOU CONTINUE TO IGNORE THE PROBLEM WHICH COULD BE ATTRIBUTED TO OIL DRIPPING FROM THE VALVE COVER ON TO THE ALTERNATOR. I GUESS YOU'RE WAITING FOR SOME ACCIDENTS TO HAPPEN BEFORE TAKING ACTION....MAYBE A FEW DEATHS RESULTING FROM A CRASH. VERY PROACTIVE!

MY SANTA FE AWD 2008 WAS BOUGHT IN JUNE 2009 AND NOW HAS ~99K MILEAGE. I HAD FOUR OR FIVE SIMILAR INCIDENTS WITH MY SANTA FE STARTING ON 4/21/15, WHICH LED TO SIGNIFICANT POWER LOSS AND SPEED LOSS OF THE CAR ON THE ROAD. THE FIRST TIME, I WAS DRIVING ON A LOCAL ROAD AT ~25 MPH. SUDDENLY I FELT THE CAR LOST THE POWER AND BEGAN TO SLOW DOWN. I STEPPED DOWN ON THE ACCELERATOR, BUT THE CAR COULD NOT ACCELERATE (THE SPEED DROPPED TO ~10 MPH). I SAW 3 SYSTEM INDICATOR/WARNING LIGHTS ON: THE ESC OFF(ELECTRONIC STABILITY CONTROL) AND CHECK ENGINE INDICATORS HAD A STEADY LIGHT AND THE AWD SYSTEM WARNING LIGHT WAS FLASHING. I PULLED OFF TO THE SIDE OF THE ROAD, SHUT OFF THE CAR, WAITED ~1 MINUTE, AND THEN RESTARTED THE CAR. THE CHECK ENGINE LIGHT STAYED ON, BUT THE OTHER LIGHTS WENT OUT. THEN...

FRONT VALVE COVER GASKET KEEP LEAKING OIL ON TO THE ALTERNATOR CAUSING THE ALTERNATOR TO GO OUT . THE SECOND TIME IT HAPPEN THE CORE OF THE ALTERNATOR BURNED .I HAVE REPLACE THE ALTERNATOR 3 TIMES AND VALVE COVER GASKET TWICE. HYUNDAI HAVE A RECALL ON THE VERACRUZ FOR THIS SOME ISSUES BUT WILL NOT RECALL THE SANTA FE FOR THIS ISSUES .

SAFETY ISSUE: FAILURE OF THE FUEL SENDING UNIT PERMANENTLY TURNS ON THE "CHECK ENGINE LIGHT" WHICH DENIES THE USE OF THE "CHECK ENGINE LIGHT" FOR OTHER SERIOUS CONDITIONS. MANY CONSUMERS HAVE PREVIOUSLY REPORTED THE FAILURE OF THE FUEL SENDING UNIT. THESE UNITS COST BETWEEN $800 TO $1200 TO FIX SO MOST DRIVERS DO NOT FIX IT AND INSTEAD USE THE ODOMETER READING TO DETERMINE WHEN FUEL IS NEEDED. UNFORTUNATELY, DRIVING WITH THE "CHECK ENGINE LIGHT" ON AT ALL TIMES PREVENTS THE DRIVER FROM SEEING THE "CHECK ENGINE LIGHT" ILLUMINATE WHEN A SERIOUS CONDITION EXISTS. THEREFORE, THIS IS A SAFETY ISSUE. CONSIDERING THE NUMBER OF CONSUMER REPORTS ALREADY SENT TO NHTSA REGARDING FAILED FUEL SENDING UNITS, HYUNDAI SHOULD IMMEDIATELY ISSUE A SAFETY RECALL TO FIX THESE UNITS.

AFTER SEVERAL HOURS OF NORMAL HIGHWAY DRIVING, THE VEHICLE EXPERIENCED A SUDDEN LOSS OF POWER AS THE ENGINE COMPUTER ENTERED "LIMP HOME" MODE. PRESSING THE ACCELERATOR HAD NO EFFECT. DIAGNOSED AS THROTTLE POSITION SENSOR FAILURE. THIS PROBLEM OCCURRED SEVERAL TIMES, WITH AN ENGINE RESTART CLEARING THE PROBLEM TEMPORARILY. WHILE THESE INCIDENTS DID NOT RESULT IN A CRASH, THEY COULD EASILY HAVE, DEPENDING ON TRAFFIC CIRCUMSTANCES.

I WAS DRIVING TO A STOP LIGHT ON A DOWN HILL SLOPE WITH MY WHOLE FAMILY IN THE CAR WHEN ALL OF THE SUDDEN MY CAR TURNED OFF. ALL AT ONCE MY CHECK ENGINE LIGHT CAME ON, MY BATTERY LIGHT CAME ON, AND I COULDN'T GET THE CAR TO RE-START. I TURNED ON THE EMERGENCY FLASHERS AND AT THE MIDDLE OF A BUSY INTERSECTION I TRIED TO RESTART MY CAR BUT NOTHING HAPPENED. A FEW MOMENTS LATER I TRIED AGAIN AND IT STARTED BUT IT WOULDN'T LET ME ACCELERATE ALMOST AT ALL (THROUGH AN INTERSECTION!). THERE WAS ALSO A CLICKING SOUND COMING FROM THE FRONT OF THE CAR. I PULLED INTO A PARKING LOT, AFRAID IF I WAS GOING TO BE ABLE TO DRIVE ANYWHERE, TURNED THE CAR OFF, WAITED ABOUT FIVE MINUTES, RESTARTED IT, SUCCESSFULLY. I LET IT IDLE FOR A WHILE UNSURE WHAT ELSE TO DO. I PROCEEDED...

THE FIRST TIME I CAME OUT TO START MY CAR AND LOOKED UP, THERE WAS SMOKE COMING FROM UNDER THE HOOD AND WOULDN'T START. I HAD IT TOWED. I WAS INFORMED IT WAS THE STARTER. THE STARTER WAS REPLACED AND APPROXIMATELY 6 MONTHS LATER, I NOTICED A BRUSHING SOUND WHEN I STARTED THE CAR. OVER TIME IT BECAME MORE OFTEN. I RETURNED THE CAR SEVERAL TIMES TO THE INDEPENDENT AUTO SHOP. THEY COULDN'T FIND OUT THE NOISE. IN THE MEAN TIME I TOOK TO A DEALERSHIP AND THEY TOLD ME IT WAS THE STARTER AND TO TAKE IT BACK AND HAVE IT REPLACED. I RETURNED TO THE INDEPENDENT DEALER AND THEY REPLACED, IT WAS STILL UNDER WARRANTY. AT THE DEALERSHIP, I WAS TOLD IT WASN'T CATCHING. TWO WEEKS LATER IT STARTED THE SAME BRUSHING SOUND WHEN I STARTED THE CAR. I MADE AN APPOINTMENT WITH A DEALERSHIP TO INSPECT AND...

THE GAS GAUGE HAS NOT BEEN WORKING FOR OVER 2 YEARS AND THE CHECK ENGINE LIGHT IS ON MOST OF THE TIME BUT WILL GO OFF INTERMITTENTLY. WE TRACK GAS USAGE WITH THE TRIP ODOMETER (20 MILES PER GALLON X 17 GAL TANK=340 MILES DRIVEN) BUT FILL UP AROUND 275 MILES DRIVEN. BUT THIS IS NOT A RELIABLE WAY TO TRACK FUEL AND IT WAS BOUND TO HAPPEN-WE RAN OUT OF GAS-UNFORTUNATELY ON THE TOLLWAY. NOW WE WANT TO FIX IT. WE HAVE HAD ESTIMATES RANGING FROM $400-$800 TO FIX THE PROBLEM BUT THINK THAT THIS IS A DEFECTIVE PART THAT HYUNDAI HAS INSTALLED IN THEIR VEHICLES. THERE SHOULD BE A RECALL FOR SAFETY REASONS. THE CAR IS ONLY 6 YEARS OLD. WE TAKE CARE OF OUR CARS-REGULAR MAINTENANCE AND PARKED IN A GARAGE. (ALSO HAD TO REPLACE THE THROTTLE SENSOR AFTER 2 YEARS AND BOTH HVAC MODE DOOR ACTUATORS...

AFTER ENGINE START AND WHILE DRIVING ANY SPEED THE BATTERY LIGHT AND SEATBELT LIGHT ON THE DASHBOARD FLASHES INTERMITTENTLY. I SEARCHED THIS ONLINE AND IT LOOKS TO BE AN ELECTRICAL CHARGING ISSUE, NAMELY THE ALTERNATOR IS BAD. I SEARCHED MORE AND FOUND THE REASON FOR THIS IS THE FRONT VALVE COVER IS LEAKING OIL AND DRIPPING ONTO THE ALTERNATOR CAUSING IT TO MALFUNCTION. A RECALL HAS BEEN MADE ( #121) ON THE 07-12 VERACRUZ FOR THE SAME ISSUE. *JS

MY VEHICLE EXPERIENCE A MALFUNCTION INDICATOR LAMP ILLUMINATED WITH THE ETC (ELECTRONIC THROTTLE CONTROL) SYSTEM RELATED DTC P2135 ( FORCED LIMITED POWER) OR DTC P0638 (POWER MANAGEMENT). *TR

WHILE DRIVING ON I-95, THE CHARGING SYSTEM WARNING LIGHT CAME ON FOLLOWED BY A LOSS OF ENGINE POWER AND THEN ENGINE STOPPED COMPLETELY. WAS ABLE TO SAFELY MAKE IT TO THE ROAD SIDE. DEALER DIAGNOSED A DEFECTIVE VALVE COVER GASKET ALLOWED OIL TO LEAK WHICH DRIPPED ON AND INTO THE ALTERNATOR CAUSING IT TO FAIL. SECOND IDENTICAL FAILURE ON VEHICLE IN TWO YEARS. V-6, AUTOMATIC, 2WD. FOUND MANUFACTURER JUST ISSUED A RECALL ON VERACRUZ MODEL WHICH SHARES THE SAME PLATFORM FOR IDENTICAL SYMPTOMS AND FAILURES. *TR

MY SANTA FE LIMITED AWD 2008 WAS BOUGHT AT THE END OF FEB 2009 AND NOW HAS ~44K MILEAGE. I HAD TWO SIMILAR INCIDENTS WITH MY SANTA FE TODAY (7/6/2014), WHICH LED TO SIGNIFICANT POWER LOSS AND SPEED LOSS OF THE CAR ON THE ROAD. THE FIRST TIME, I WAS DRIVING ON A LOCAL ROAD AT ~45 MPH. SUDDENLY I FELT THE CAR LOST THE POWER AND BEGAN TO SLOW DOWN. I STEPPED DOWN ON THE ACCELERATOR, BUT THE CAR COULD NOT ACCELERATE (THE SPEED DROPPED TO ~20 MPH). I SAW 3 SYSTEM INDICATOR/WARNING LIGHTS ON: THE ESC OFF(ELECTRONIC STABILITY CONTROL) AND CHECK ENGINE INDICATORS HAD A STEADY LIGHT AND THE AWD SYSTEM WARNING LIGHT WAS FLASHING. I PULLED OFF TO THE SIDE OF THE ROAD, SHUT OFF THE CAR, WAITED ~1 MINUTE, AND THEN RESTARTED THE CAR. THE CHECK ENGINE LIGHT STAYED ON, BUT THE OTHER LIGHTS WENT OUT....