2008 HYUNDAI SANTA FE Electrical System Problems

I took the car to get this recall done: Hyundai has decided to conduct a service campaign to inspect (and if necessary replace) the alternator and replace the front valve cover gasket on certain 2007-2009 model year Santa Fe vehicles. The recall was done, replacing the gasket and alternator. 2 years later the car started to stall in the middle of traffic. I returned to the dealer, dealer inspected and reported "oil found on the new alternator and oil leak found on the real valve cover gasket". I have been going back and forth on the phone with Hyundai costumer care. They said they will not redo the recall. It was not done correctly and slowly leak again. the vehicle now cut off everyday specially when i stop and go at short drives. It has also cut off in traffic. making it very dangerous. But Hyundai is telling me nothing...

My speedometer has stopped working, I had the sensor replaced and fuses checked but it is still not working

The contact owns a 2008 Hyundai Santa Fe. The contact stated that the vehicle was experiencing difficulty charging. The contact stated that while driving 50-60 MPH, the vehicle stalled. The contact was able to pull to the side of the road. The contact stated that the failure had occurred several times while driving on the highway. The vehicle was able to be jump-started. The contact stated that a mobile mechanic had inspected the vehicle and informed the contact that there was oil leaking onto the spark plugs. The contact stated that the vehicle was chugging while driving. The contact became aware that the VIN was included in Hyundai Campaign Number: 976. The vehicle was taken to the dealer for repair. The dealer diagnosed that the valve cover gasket was leaking onto the alternator and onto other unknown parts. The dealer replaced the valve cover gasket and the alternator under Hyundai...

Brought 2008 Hyundai Santa Fe to Carlsbad Hyundai dealership on 12/22/23 for Service Campaign 976, due to oil leaking from the front cylinder bank’s valve cover onto the alternator. Oil could damage the alternator resulting in illumination of the charging system warning lamp and disablement of the charging system. If the vehicle is continually driven without recharging the battery, the engine will eventually shut off, increasing the risk of a crash. Dealership said the vehicle needed to be fixed but they needed to order parts and that it would take 2-3 wks. It has now been over 6 months. I have called the dealership and Hyundai America multiple times all to no avail.

In October 2021 the alternator failed due to an oil leak from the valve cover gasket. I paid the local Hyundai dealer to replace the alternator and they also said the battery was damaged because of the failed alternator so I paid for a new battery as well. The dealer never mentioned the recall on this vehicle for the leaking valve cover and did not disclose that the leak was known to cause alternator failure. I later learned of the recall and had the valve cover repair performed under the recall. However, Hyundai has refused to reimburse me for the alternator repair that I had already previously paid for, and likewise have refused to reimburse me for the battery. Clearly the problem was due to the known defect that resulted in the recall, so I am obviously entitled to compensation for the out if pocket repair expenses. Please advise me...

My car has a recall, and the dealership is unable to fix it. There is also an issue with the oem control module that they are unable to get the part and unable to fix this because they do not have the correct software.

ON HIGHWAY, CAR WOULD NO LONGER ACCELERATE AND WENT INTO LIMP MODE CAUSING ME TO SLOW TO 50 MPH AND NOT BE ABLE TO KEEP UP WITH SPEED IF TRAFFIC. PULLED OVER, DASH LIGHTS FLASHED AND CAR WOULD NOT RESTART. OIL HAD LEAKED OUT OF VALVE COVER GASKET ALL OVER THE ALTERNATOR CAUSING THE CAR TO MALFUNCTION AND BECOME INOPERABLE.

CLOCK SPRING CONTACT ASSEMBLY FOR DRIVERS AIRBAG. EXPERIENCING HIGH RESISTANCE CODE. RECALL 11V472000 COVERED SOME 2008 MODELS BUT NOT MINE. AIR BAG LIGHT CAME ON AFTER STARTING VEHICLE ON 08/03/2020

TL* THE CONTACT 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 5 MPH, THE VEHICLE STALLED. THE BATTERY WARNING INDICATOR ILLUMINATED. THE CONTACT ALSO MENTIONED THE FAILURE OCCURRED WHEN IT WAS RAINING (THREE TIMES ON THE SAME DAY). THE CONTACT ALSO STATED THAT THE VEHICLE ALTERNATOR WAS REPLACED BY THE DEALER BENTLEY HYUNDAI, 3805 UNIVERSITY DRIVE, HUNTSVILLE, AL 35816, UNDER A CAMPAIGN GENERATED BY THE MANUFACTURER DECEMBER 2019. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND A COMPLAINT NUMBER: [XXX] WAS FILED. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 159,000. *LN CONSUMER STATED WHEN HE WENT TO PICK UP VEHICLE DEALER FOUND NOTHING WRONG WITH IT. ONE WEEK LATER VEHICLE WAS TAKEN BACK TO DEALER. ('PARTS OF THIS DOCUMENT HAVE BEEN REDACTED TO PROTECT PERSONALLY IDENTIFIABLE INFORMATION PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).'*JB

THE FUEL PUMP AND SENSORS WENT BAD. THE FUEL GAUGE STARTED GLITCHING AND GOING UP AND DOWN RANDOMLY. AFTER 1-2 MONTHS IT WAS SHOWING EMPTY AT ALL TIMES. I CHANGED THE SENSORS AND THE FUEL GAUGE WENT TO THE MIDDLE EVEN WHEN THE TANK WAS FULL. I HAD TO REPLACE BOTH SENSORS AND THE FUEL PUMP TO GET IT FIXED.

THE GAS GUAGE IN THIS VEHICLE STOPPED WORKING OVER A YEAR AGO AND WE HAVE RAN OUT OF GAS IN THE MIDDLE OF TRAFFIC WHEN WE KEEP OUR GAS GUAGE FILLED IN THIS VEHICLE ALL THE TIME CAUSING A DANGER TO OURSELVES AND OUR CHILDREN SOMEDAY SOMEBODY IS GOING TO HIT US DUE TO THIS ISSUE KEEPS HAPPENING IN THE MIDDLE OF TRAFFIC AND THE ROAD AND INTERSTATE. IT CONSTANTLY KEEPS SHOWING US EMPTY WHEN WE ARE NOT. I HAVE READ MANY REVIEWS THAT THIS HAPPENS WITH MANY OF THESE VEHICLES AND IT HAS YET TO BE RECALLED.

GOING DOWN INTERSTATE AT 70 MILES AN HOUR AND CAR SHUT OFF PUT CAR IN NUTRAL AND RESTARTED . THEN THE NEXT DAY DRIVING TO WORK AND CAR CUT OFF AGAIN WHILE DRIVING DID SAME AND RESTARTED . WENT ON LINE AND FOUND OUT THIS HAS BEN A PROBLEM IN THESE CARS FOR YEARS AND AM AFRAID FOR ME AND MY CHILDREN S LIVES

2008 SANTA FE GAS GAUGE NOT READING PROPERLY. WHEN I FILL UP THE CAR AND THE GAS GAUGE READS EMPTY. AND CONSTANTLY FLUCTUATES. I HAVE TO CALCULATE HOW MANY MILES I DRIVE IN ORDER TO KNOW WHEN TO FILL UP AGAIN.

CHECK ENGINE LIGHT AND UNFUNCTIONAL OR INFUNCTIOMAL GAS GAUGE

LEAKING VALVE COVER IS ALLOWING OIL TO LEAK DOWN ONTO THE ALTERNATOR. CAR BE STATIONARY OR RUNNING. MOST NOTABLE WHEN CAR ENGINE IS RUNNING.

FUEL SENDING SENSOR IS ERRATIC CAUSING CHK ENGINE CODE P0464. UNSAFE DRIVING CONDITION AND SHOULD BE RECALLED TO BE FIX.

MY 2008 HYUNDAI SANTA FE WHILE DRIVING STALLS, TRUCK IS NO LONGER ON WHILE DRIVING. POWER STEERING AND CONTROL OVER STEERING WHEEL IS LOSS. THIS HAS BEEN HAPPENING QUITE FREQUENTLY WHILE DRIVING. HAPPEN TWICE WHILE DRIVING ON HIGHWAY WHICH, SCARED ME TO DEATH. CHECK ENGINE LIGHT AND BATTERY LIGHTS COMES ON WHEN THIS HAPPENS. NOW THE ENGINE LIGHT COMES ON STAY FOR A FEW DAYS THEN TURNS OFF. MY FUEL GAGE K DOESN'T WORK PROPERLY. I CAN FILL MY TANK UP ON FULL, THEN IT WILL DROP TO THE E LINE LIKE THERE IS NO GAS. THE YELLOW LIGHT COMES ON. NOT SAFE BECAUSE NOW I DON'T KNOW IF MY TRUCK IS FULL OR REALLY EMPTY. WHY HAVEN'T THERE BEEN ANY RECALLS ON THESE ISSUES ESPECIALLY SINCE, THERE ARE NUMEROUS COMPLAINTS BY OWNERS WITH THE SAME YEAR AND MODEL.

FUEL LEVEL SENSOR FAILED....INACCURATE FUEL GAUGE CAUSING OWNERS TO NOT KNOW WHEN THE CARS FUEL TANK IS LOW, AND SOMETIMES CAUSING THE VEHICLE TO RUN OUT OF FUEL WHILE DRIVING.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE BATTERY EXPLODED WHILE PARKING THE VEHICLE. THE CONTACT HEARD A LOUD NOISE AND DISCOVERED THAT BATTERY FLUID WAS LEAKING. HYUNDAI OF WESLEY CHAPEL (27000 WESLEY CHAPEL BLVD, WESLEY CHAPEL, FL 33544, (813) 501-2736) WAS CONTACTED AND REFERRED THE CONTACT TO FUCCILLO KIA OF WESLEY CHAPEL (28555 FL-54, WESLEY CHAPEL, FL 33545, (813) 395-0347). FUCCILLO KIA HAD NOT SPECIFICALLY VERIFIED IF ANY OTHER COMPONENTS OR ELECTRICAL FAILURES CAUSED THE FAILURE. HOWEVER, THE DEALER STATED THAT BECAUSE THE OEM BATTERY WAS REPLACED WITH A TRIPLE A BATTERY, THE REPLACEMENT BATTERY MAY BE FAULTY. THE CONTACT STATED THAT THE HOOD WAS DAMAGED WITH AN EXTENSIVE INDENTATION WHERE THE BATTERY HAD LODGED UPWARD WHEN IT EXPLODED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,000. *TT UPDATED 11/19/18*JB

FUEL GAUGE ALWAYS READS AS EMPTY, REGARDLESS OF MOVEMENT OR AMOUNT OF GAS IN TANK, LEAVING DRIVER TO RUN OUT OF GAS IN UNDESIRABLE PLACES. REPAIR IS APPROX 600-800 DOLLARS. MANY COMPLAINTS SHOULD BE RECALLED. HAS TO DO WITH THE FUEL SENDING SENSOR OR SOMETHING I WAS TOLD.

I ACTUALLY HAVE 2 ISSUES OCCURRING. ONE OF THESE WAS DEEMED TO HAVE BEEN FIXED BY A PREVIOUS RECALL (CAMPAIGN 105/110 - FIXED /CLOSED JUN 23, 2014). HOWEVER, MY ESC OFF LIGHT AND ABS LIGHT ARE AGAIN LIGHTING UP. I HAVE (LUCKILY) NOT YET HAD LOSS OF ENGINE POWER OR CONTROL. THE SECOND ISSUE IS IN REGARDS TO CAMPAIGN 936. I'VE HAD THE FRONT ENGINE VALVE GASKET COVER FIXED, ALONG WITH MY ALTERNATOR REPLACED (AFTER MY HUSBAND AND I DID IT OURSELVES AFTER LOSING ALL POWER ON CHRISTMAS EVE IN THE MIDDLE OF ROAD BEFORE BARELY COASTING INTO A NEARBY PARKING LOT WHERE WE WERE ABLE TO SORT OF PARK OUT OF THE WAY). WE CHANGED MY OIL THIS WEEKEND, HAVE HAD NO OTHER WORK DONE ON THE CAR SINCE (EXCEPT OIL CHANGES) AND MY HUSBAND NOTICED THAT THE ALTERNATOR IS AGAIN COVERED IN OIL. BETWEEN THE 2 ISSUES, IT...

MY CAR HAS STALLED SEVERAL TIMES THIS PAST WEEK WITHOUT WARNING OR INDICATION THAT ANYTHING IS WRONG. THE VEHICLE WILL SUDDENLY STOP AND LOSE POWER COMPLETELY WHILE I ANXIOUSLY TRY TO RESTART IT. IT HAS PUT ME AT RISK WITH OTHER DRIVERS WHERE I'VE HAD TO PUT MY HAZARDS ON AND HOPE VEHICLES ARE ABLE TO STOP IN TIME SO THEY DON'T HIT ME. I'VE TAKEN IT IN FOR SERVICE AND THEY CAN'T SEEM TO REPLICATE THE PROBLEM. THE CAR IS A SAFETY HAZARD AND NO ONE SEEMS TO BE HELPING ME. I FOUND INFORMATION ONLINE ABOUT HYUNDAI GETTING SLAPPED WITH A CLASS ACTION SUIT FOR THE SAME PROBLEMS I'M REPORTING, BUT THE SUIT APPEARS TO ONLY COVER 2010-2012 MODELS, MINE IS 2008. I DON'T KNOW WHAT TO DO!

1) FUEL TANK GAUGE IS INACCURATE. STARTS TO DROP RAPIDLY AFTER DRIVING 75-100 MILES AND EMPTY FUEL TANK LIGHT COMES ON AFTER ~125-150 MILES. WHEN I REFILL THE TANK, IT IS ONLY HALF EMPTY. NORMALLY, CAR WILL DRIVE 270-320 MILES BEFORE EMPTY. 2) CHECK ENGINE LIGHT COMES ON AND OFF. NOTHING SEEMS TO BE WRONG WITH THE CAR(HAVE HAD IT CHECKED.) 3) ESC LIGHT COMES ON AND OFF; SOMETIMES AT THE SAME TIME AS THE CHECK ENGINE LIGHT, SOMETIMES BY ITSELF. I HAVE HAD IT CHECKED, NO PROBLEM; AND RESET. GOES ON - OFF AGAIN A FEW DAYS LATER. THESE EVENTS HAVE BEEN OCCURRING OVER THE LAST 6 MONTHS, APPROXIMATELY.

AFTER TURNING RIGHT TO ENTER AN ON-RAMP FOR THE HIGHWAY, THE TURN SIGNAL (NOW IN NEUTRAL POSITION) STARTING MAKING THE FAST CLICKING NOISE. IN ADDITION, SMOKE STARTED COMING OUT OF THE TURN SIGNAL STICK AND YOU COULD SMELL (WHAT APPEARED TO BE) ELECTRICAL BURNING. THIS CONTINUED FOR 20 MILES UNTIL I GOT HOME AND BEGAN TO RESEARCH IF THIS HAS HAPPENED TO OTHERS (WHICH IT HAS). I AM WORRIED OF A FIRE DANGER ALONG WITH THE ANNOYING NON-STOP NOISE. IS THERE A RECALL ON SOMETHING LIKE THIS IF OTHERS HAVE ALSO REPORTED IT?

THE ISSUE STARTED SHORTLY AFTER MY VEHICLE SURPASSED 60,000 MILES. UPON TURNING ON THE ENGINE, THE GAS GAUGE LIGHT IS ON AND THE FUEL TANK IS DISPLAYED AS EMPTY. THE GAS GAUGE ON OCCASION ALSO SPORADICALLY FLUCTUATES UP AND DOWN, REGARDLESS OF HOW MUCH GASOLINE IS IN THE TANK.

AFTER A PERIOD OF TIME WHERE I NOTICED THE FUEL GAUGE ACTING ERRATICALLY (OCCASIONALLY WIDELY SWINGING) THE CHECK ENGINE LIGHT EVENTUALLY ILLUMINATED. DEALER SERVICE FOUND CODE P0464: "INSPECTED CLUSTER FOR ANY LOOSE CONNECTIONS OR DAMAGE, NO ISSUE FOUND WITH CLUSTER OR WIRING. REMOVED THE SENDING UNITS AND FOUND SEND UNITS OUT OF SPEC WHEN MOVING BY HAND AND OHM SENDERS. REPLACED BOTH SENDING UNITS AND CLEARED CODES." *TR

CHECK ENGINE LIGHT STAYS ON. FUEL GAUGE WILL READ EMPTY EVEN AFTER JUST FUELING. FUEL GAUGE WILL OCCASIONALLY READ A RANDOM LEVEL THEN DROP TO EMPTY WITHIN SECONDS. OBD CODES STATES FUEL SENSOR ERRORS.

MY VEHICLE HAS HAD A FUEL GAUGE THAT WOULD MOVE UP AND DOWN WHILE CAR IS STILL. TODAY THE CHECK ENGINE LIGHT CAME ON WITH A CODE P0464-FUEL LEVEL SENSOR. THE FUEL IN VEHICLE IS AT HALF AND THE GAUGE WOULD GO ALL THE WAY TO EMPTY (WITH EMPTY LIGHT COMING ON) THEN IT WOULD GO BACK TO HALF AND MOVE EVERY NOW AND THEN. THE VEHICLE IS AT 83000. SO FAR THE THE GAUGE IS SOMEWHAT WORKING BUT IS VERY FRUSTRATING KNOWING THAT THIS CAN BE A $500 REPAIR SINCE IT WILL INVOLVE THE GAS TANK. THIS CAN MAKE FOR A BAD SITUATION IF THE GAUGE COMPLETELY FAILS.

TL* THE CONTACT OWNS A 2008 HYUNDIA SANTA FE. WHILE OPERATING THE VEHICLE, THE CHECK ENGINE INDICATOR ILLUMINATED AND THE FUEL GAUGE INDICATOR PROVIDED FALSE READINGS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 143,000.

A PROBLEM IS REGARDING FUEL GAUGE FAILURE /CHECK ENGINE LIGHT. CHECK ENGINE LIGHT COMES ON ,GOES OFF ,FUEL GAUGE REGISTER ON EMPTY WITH LIGHT INDICATOR ANYTIME TANK IS LESS THAN FULL.

MY MOTHER PURCHASED A 2008 HYUNDAI SANTA FE, AWD 2.7L V6 MODEL BRAND NEW IN 2009. HER FUEL GAUGE FAILED AT AROUND 110,000 MILES APPROX. I NOTICED OTHER PEOPLE COMPLAINING ABOUT THE SAME ISSUE...SO I THOUGHT I'D MENTION THAT HER FUEL GAUGE ALSO QUIT WORKING! SHE TOOK IT IN TO GET FIXED, AND I BELIEVE IT WAS A PRETTY COSTLY JOB! MAYBE WITH EVERYBODY PUTTING THEIR HEADS TOGETHER, THIS ISSUE CAN GET MORE ATTENTION AND POSSIBLY LEAD TO A RECALL. THANKS!

ESC LIGHT ILLUMINATES. CAR LOOSES POWER WHILE DRIVING, AND STALLS.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING 60 MPH, THE BRAKES FAILED TO DISENGAGE AFTER THE BRAKE PEDAL WAS DEPRESSED AND A BURNING ODOR WAS NOTICED. THE ANTI-LOCK BRAKING SYSTEM AND THE ELECTRONIC STABILITY CONTROL WARNING LIGHT ILLUMINATED. THE CONTACT PULLED OVER TO THE SIDE OF THE ROAD AND NOTICED SMOKE COMING FROM ALL FOUR TIRES. THE CONTACT LEFT THE VEHICLE IDLING FOR AWHILE AND THE SMOKE STOPPED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE HYDRAULIC AND ELECTRICAL CONTROL UNITS FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 110,000.

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE SPEEDOMETER WAS READING EMPTY AND ALL OVER THE PLACE. THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 54,000. UPDATED 05/10/16*LJ *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. WHILE DRIVING 45 MPH, THE PASSENGER SIDE SEAT BECAME EXCESSIVELY HOT. THE PASSENGER OBSERVED THAT THE SEAT WAS ON FIRE. A FIRE REPORT WAS NOT FILED. THE CONTACT EXTINGUISHED THE FIRE. THE PASSENGER SUSTAINED BURN INJURIES TO HER HANDS AND BUTTOCKS BUT DID NOT RECEIVE MEDICAL ATTENTION. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,002.

WHEN DRIVING AND YOU HIT THE BREAKS, THE VEHICLE ATTEMPTS TO STALL, OR IF YOU USE THE HIGH OR LOW BREAMS THE RADIO SHUTS OFF AND THE GPS TURNS ON OR YOU LOSES IT ALL, WHILE ON HIGH WAY WAY IF YOU USE YOUR HIGH OR LOW BEAMS THE ENGINE STARTS TO STALL THEN KEEPS GOING CAUSING THE VEHICLE BEHIND YOU HAVE TO BREAK QUICKLY TO AVOID HITTING YOU AS YOU LOOSE ALL POWER FOR A MATTER OF SECONDS THIS HAPPEN WHILE MOVING OR PARKED, I MHAVE INSTALLED TWO NEW ALTERNATORS IN THE PAST THREE WEEKS AND THE PROBLEM CONIINUES

2008 HYUNDAI SANTA FE, 78K MILES. FUEL GAGE READING STARTING BOUNCING AROUND. SHOWED HALF FULL ON A FRESHLY FILLED TANK. EVENTUALLY CHECK ENGINE LIGHT CAME ON. ERROR CODE P0464 (FUEL LEVEL SENSOR 'A' ELECTRICAL CIRCUIT WAS INTERMITTENT FOR A PREDETERMINED PERIOD OF TIME.). FUEL SENSORS REQUIRED REPLACEMENT. AN INACCURATE FUEL READING IS A SAFETY CONCERN, JUST LIKE ANY OTHER ISSUE THAT CAN LEAD TO UNEXPECTED VEHICLE SHUTDOWN. THE NUMEROUS REPORTS ON THE WEB CONCERNING THE FAILURE OF THE FUEL SENSORS IN THE 2008 SANTA FE SUGGESTS STRONGLY THAT A RECALL IS WARRANTED.

WHEN THE GAS TANK IS LESS THAN HALF FULL, THE FUEL GAUGE DISPLAYS TANK AS NEARLY EMPTY AND THE AMBER LOW FUEL LIGHT APPEARS. THE CHECK ENGINE WARNING LIGHT ALSO COMES ON. THE FUEL GAUGE SWINGS BACK UP TO NEARLY HALF FULL, DROPS DOWN TO 1/4 FULL, THEN DROPS DOWN TO ALMOST EMPTY, THEN SWING BACK TO HALF FULL. ABOUT 3 MONTHS AFTER THIS PROBLEM STARTED, THE FUEL GAUGE REMAINS NEAR EMPTY WITH THE AMBER LOW FUEL LIGHT LIT. WHEN I FILL UP THE GAS TANK, THE FUEL GAUGE IS ONCE AGAIN ACCURATE UNTIL THE TANK GOES BELOW 1/2 FULL. HOWEVER, THE CHECK ENGINE LIGHT REMAINS ON AT ALL TIMES AND CAN ONLY BE CLEARED BY A MECHANIC. I'VE HAD MY MECHANIC CLEAR IT TWICE. THIS IS A FUEL SENSOR ISSUE WITH THE TWO SENDERS IN THE GAS TANK. I WAS GOING TO HAVE THIS REPAIRED BY HAVING THE FUEL...

FUEL GAUGE HAS BEEN FAULTY AND CHECK ENGINE LIGHT WOULD TURN ON AND OFF AFTER REPLACING WHAT I THOUGHT WAS A BAD BATTERY ONE MONTH AGO. ONE WEEK AGO WHILE DRIVING, ALL LIGHTS ON DASHBOARD CAME ON (BATTERY, CHECK ENGINE, ABS, ESC...), ENGINE STARTED TO REV, ELECTRICAL AND POWER STEERING FAILED, AND CAR HAD TO BE TURNED OFF IN THE MIDDLE OF THE ROAD AND TOWED HOME. THIS HAS HAPPENED TWICE WHILE DRIVING NOW. ISSUE IS FROM A FAILING/FAILED ALTERNATOR CAUSED BY OIL LEAK FROM FRONT VALVE COVER. THIS PROBLEM IS IDENTICAL TO ISSUES WITH '06-'12 VERACRUZ, RECALL #121.

I LOST POWER STEERING AND POWER BRAKES WHILE STOPPED AT A STOP SIGN GOING UP A VERY STEEP GRADE. I WAS UNABLE TO SHIFT INTO PARK SO THAT I COULD TURN MY CAR OFF. I HAD TO LAY ON THE BRAKE WITH ALL MY WEIGHT TO KEEP FROM ROLLING BACKWARDS INTO CARS BEHIND ME. THERE WERE NO WARNING LIGHTS. AFTER A MINUTE, WHICH FELT LIKE MUCH LONGER, I WAS ABLE TO SHIFT TO PARK AND TURN MY CAR OFF AND BACK ON. THE SECOND TIME I LOST ALL POWER, WAS A COUPLE MONTHS LATER. I WAS GOING ABOUT 40 MPH ON A CURVY HILLY ROAD. I WAS UNABLE TO STEER, ACCELERATE, DECELERATE, OR APPLY THE BRAKES. THERE WERE CARS BEHIND ME AND I WAS TERRIFIED I WOULD END UP OFF THE ROAD OR HEADING INTO ONCOMING TRAFFIC. THE VEHICLE FINALLY CAME TO A STOP WHEN IT DIDN'T HAVE ENOUGH MOMENTUM...

FRONT VALVE COVER GASKET KEEP LEAKING OIL ON TO THE ALTERNATOR CAUSING THE ALTERNATOR TO GO OUT . THE SECOND TIME IT HAPPEN THE CORE OF THE ALTERNATOR BURNED .I HAVE REPLACE THE ALTERNATOR 3 TIMES AND VALVE COVER GASKET TWICE. HYUNDAI HAVE A RECALL ON THE VERACRUZ FOR THIS SOME ISSUES BUT WILL NOT RECALL THE SANTA FE FOR THIS ISSUES .

SAFETY ISSUE: FAILURE OF THE FUEL SENDING UNIT PERMANENTLY TURNS ON THE "CHECK ENGINE LIGHT" WHICH DENIES THE USE OF THE "CHECK ENGINE LIGHT" FOR OTHER SERIOUS CONDITIONS. MANY CONSUMERS HAVE PREVIOUSLY REPORTED THE FAILURE OF THE FUEL SENDING UNIT. THESE UNITS COST BETWEEN $800 TO $1200 TO FIX SO MOST DRIVERS DO NOT FIX IT AND INSTEAD USE THE ODOMETER READING TO DETERMINE WHEN FUEL IS NEEDED. UNFORTUNATELY, DRIVING WITH THE "CHECK ENGINE LIGHT" ON AT ALL TIMES PREVENTS THE DRIVER FROM SEEING THE "CHECK ENGINE LIGHT" ILLUMINATE WHEN A SERIOUS CONDITION EXISTS. THEREFORE, THIS IS A SAFETY ISSUE. CONSIDERING THE NUMBER OF CONSUMER REPORTS ALREADY SENT TO NHTSA REGARDING FAILED FUEL SENDING UNITS, HYUNDAI SHOULD IMMEDIATELY ISSUE A SAFETY RECALL TO FIX THESE UNITS.

MY GAS GAUGE STOPPED WORKING CORRECTLY, GOING UP AND DOWN BUT NEVER PASSING ONE HALF A TANK AND THE CHECK ENGINE LIGHT REMAINS ON ALL THE TIME. THE MECHANIC SAID THE SEATS WOULD NEED TO BE TAKEN OUT TO GET TO THE SENSOR, THAT IT WAS PROBABLY BAD AND WOULD NEED A NEW ONE. I TRIED TO ESTIMATE HOW MUCH GAS I HAD IN THE TANK BY USING THE ODOMETER AND RESETTING AT 0 FOR A GAS FILLUP TILL I GOT THE CAR IN FOR SERVICE. THE TANK WOULD KICK THE GAS BACK AT HALF A TANK SO I WAS GETTING ONLY 8 GALLONS IN. ON TUESDAY I RAN OUT OF GAS ON A HIGHWAY GOING 55, WHICH WAS DANGEROUS, AS THERE WAS A TRUCK BEHIND ME AND HE HAD TO SWERVE INTO THE MEDIAN TO AVOID HITTING ME WHEN MY CAR DIED. I WAS TOWED TO THE MECHANIC. THE...

I FILLED UP THE TANK AND THE GAS GAUGE LEVEL READ EMPTY. CONTINUED AND HAS BEEN ON EMPTY. SOMETIMES IT WILL RISE GRADUALLY TO CORRECT LEVEL. AND WHEN YOU TURN OFF ENGINE THEN IT GOES BACK TO EMPTY. I FIND THIS TO BE DANGEROUS BECAUSE I DON'T KNOW IF THE CAR WILL STOP. I HAVE READ MANY OTHERS THAT HAVE HAD THE SAME PROBLEM. A RECALL IS IN ORDER TO CORRECT THIS PROBLEM FOR THE SAFETY OF ALL. *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED THAT ALL THE WARNING LIGHTS ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS NOT ABLE TO BE RESTARTED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT GASKET LEAKED OIL INTO THE ALTERNATOR AND THE ALTERNATOR NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 82,000. THE VIN WAS NOT AVAILABLE.

LEAKING OIL FROM FRONT VALVE COVER AND CAUSING ALTERNATOR TO FAIL, JUST LIKE ALL THE OTHER SANTA FE AND VARACRUZ. *TR

AFTER ENGINE START AND WHILE DRIVING ANY SPEED THE BATTERY LIGHT AND SEATBELT LIGHT ON THE DASHBOARD FLASHES INTERMITTENTLY. I SEARCHED THIS ONLINE AND IT LOOKS TO BE AN ELECTRICAL CHARGING ISSUE, NAMELY THE ALTERNATOR IS BAD. I SEARCHED MORE AND FOUND THE REASON FOR THIS IS THE FRONT VALVE COVER IS LEAKING OIL AND DRIPPING ONTO THE ALTERNATOR CAUSING IT TO MALFUNCTION. A RECALL HAS BEEN MADE ( #121) ON THE 07-12 VERACRUZ FOR THE SAME ISSUE. *JS

THE FUEL SENSOR ON MY 2008 SANTA FE IS MALFUNCTIONING AND NOT REPORTING THE ACTUAL LEVEL OF FUEL IN THE TANK. IT IS ALSO CAUSING THE EMPTY FUEL INDICATOR AND THE CHECK ENGINE LIGHT TO STAY LIT ALL THE TIME, SO NOT ONLY DO I HAVE TO MANUALLY MEASURE MY FUEL USAGE BY MILES DRIVEN, I ALSO HAVE NO IDEA OF ANY POTENTIAL ENGINE PROBLEMS SINCE THAT LIGHT/WARNING SYSTEM HAS EFFECTIVELY BEEN RENDERED USELESS. HYUNDAI DEALERSHIPS ARE CURRENTLY OFFERING TO FIX THE PROBLEM FOR ABOUT $800.00 AND HAVE THE PARTS READILY ON HAND SINCE THE PROBLEM IS OCCURRING SO FREQUENTLY NOW. THIS APPEARS TO BE A DEFECT WITH THE EARLIER SANTA FE MODELS AND CONSIDERING THE POTENTIAL CONSEQUENCES OF ACCIDENTALLY RUNNING OUT OF FUEL OR HAVING AN ENGINE PROBLEM AND NOT KNOWING IT UNTIL IT'S TOO LATE, A RECALL SHOULD BE ISSUED. *TR

9/19/12 VALVE COVER GASKET LEAKED OIL ON THE ALTERNATOR RESULTING IN ALTERNATOR NEEDING TO BE REPLACED. 10/2/12 NEW BATTERY NEEDED DUE TO BEING WORN DOWN FROM BAD ALTERNATOR. 10/3/14 76,589 MILES VALVE COVER GASKET LEAKED OIL ON THE ALTERNATOR RESULTING IN ALTERNATOR NEEDING TO BE REPLACED AGAIN!! NEW BATTERY NEEDED SINCE COULD NO LONGER HOLD A CHARGE. ALSO MULTIPLE TIMES THE LUMBAR SWITCH ON DRIVER'S SEAT REPLACED: 2/3/10, 3/15/11, 9/19/12, 1/19/13, 10/3/14. *TR

TL* THE CONTACT OWNS A 2008 HYUNDAI SANTA FE. THE CONTACT STATED WHILE DRIVING 25 MPH, THE VEHICLE STARTED TO DRIVE ABNORMALLY ROUGH. THE CONTACT MERGED THE VEHICLE TO THE EMERGENCY LANE AND SHUT THE ENGINE OFF. AFTER MULTIPLE ATTEMPTS, THE VEHICLE FAILED TO RESTART. THE VEHICLE WAS TOWED TO THE DEALER FOR A DIAGNOSIS. THE TECHNICIAN OBSERVED THAT THERE WAS AN OIL LEAK FROM THE FRONT CYLINDER BANK VALVE COVER GASKET AND THERE WAS SUFFICIENT AMOUNT OF OIL IN THE ALTERNATOR. THE LEAK HAD CAUSED THE ALTERNATOR TO DAMAGE THE CHARGING SYSTEM AND TO BECOME INOPERABLE. THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 65,271.