2007 HYUNDAI SANTA FE Structurebody Problems

CAR UNIBODY RUSTED THRU

2007 SANTE FE LIMITED, SAGE GREY ONE OWNER, GARAGE KEPT, MAINTAINED REGULAR BASIS, LOW MILEAGE 84,000, INTERIOR AND EXTERIOR IN EXCELLENT CONDITION WITH A KELLY BLUE BOOK OF $4200 TO $4600. PURCHASED AT LAUREN HYUNDAI IN GLENVIEW AND MAINTAINED AT HYUNDAI LINCOLNWOOD, IL ALONG WITH MY REGULAR MECHANIC. I LEARNED YESTERDAY THAT THE RIGHT REAR OF SUB FRAME RUSTED OUT WITH A BOTH FRONT FRAME RUSTED OUT AND HAS A HOLE IN IT. IT'S A KNOW ISSUE BY FED, NHTSA, SERIES OF RECALLS AND DEALER RUSTED OUT FRAMES, SUB FRAMES AND OTHER PART REPAIRS AND REPLACEMETNS. THE 2007 TREATMENT DIDN'T WORK AND THE SAME ISSUE IS ALL OVER THE INTERNET WITH CLASS ACTION SUITS. I'VE ALSO READ LOW AND HIGH MILEAGE CARS WITHIN 2-10 YEARS HAVE SAME ISSUE BUT MUST BE COVERED UNDER WARRANTY. THEY RESOLVED THE OLDER ONES BY SPRAYING THEM ONE ONE RECALL AND DIDN'T UPGRADE THEIR SUB...

HELLO SO I TOOK MY 07 HYUNDAI SANTA FE LIMITED 98K MILES TO A GARAGE TO GET SOME WORK DONE AND THEY PUT IT ON THE LIFT AND STOPED THE WORK TO CALL ME IN TO SEE THAT MY SUBFRAME IN FRONT IS RUSTED THROUGH BIG CHUNKS OF METAL MISSING MAINLY ON THE PASSENGER SIDE OF FRAME. I WAS TOLD THAT THEIR IS A RECALL ABOUT THIS AND THAT HYUNDAI HAS REPLACED THE SUBFRAMES AS A RESULT OF THE RECALL I HAVE NO IDEA WHY UNDER THE CAR ONLY THAT ONE AREA IT'S RUSTED BUT THE REST OF CAR IS FINE. THIS IS DANGEROUS AND WAS TOLD AT ANY TIME THE ENGINE COULD FALL THROUGH. I WILL ATTACH SOME PHOTOS OF IT THE BEST I CAN. HOPE YOU CAN HELP. I GOT KIDS THAT RIDE IN THIS AND I'M NOW SCARED. I NEVER RECEIVED ANYTHING IN MALL THE ABOUT THE...

THE SUB FRAME THAT'S HOLDING THE ENGINE IS RUSTING APART ALMOST MISSING A HUGE PART OF IT WHICH IS A CAUSE FOR CONCERN FOR THE SAFETY OF ME AND MY CHILDREN. ESPECIALLY BEING THAT I WAS NEVER INFORMED OF THIS ISSUE UPON PURCHASING THIS AS A "CERTIFIED VEHICLE". ONLY HAD IT FOR ONE YEAR.

DOOR LOCKS DO NOT WORK PROPERLY. SOMETIMES LOCK, SOMETIMES DO NOT. MOSTLY THEY UNLOCK BUT DO NOT LOCK PROPERLY. THE KEY FOB ALSO DOES NOT ALWAYS WORK. HAVE HAD THE BATTERY AND SYSTEM CHECKS AND THERE WERE NO ISSUES. DANGEROUS TO HAVE DOORS NOT LOCK PROPERLY FOR A SINGLE WOMAN IN PARKING LOTS OR EVEN WITH THE CAR PARKED OUTSIDE AT NIGHT.

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE DEALER SERVICED THE VEHICLE BY PROVIDING COATING ON THE FRONT AND REAR AXLES OF THE FRAME. HOWEVER, THE MAIN PORTION OF THE FRAME (FROM FRONT TO BACK) HAD EXTENSIVE RUST, CORROSION, AND HOLES. THE MECHANIC NOTIFIED THE TECHNICIANS AT THE DEALER, BUT THEY FAILED TO NOTIFY THE CONTACT AND PROVIDE FURTHER COATING TO THE FRAME. THE MANUFACTURER INDICATED THAT THE RUST AND CORROSION WERE TOO EXTENSIVE TO REPAIR THE VEHICLE. THE CONTACT WAS INFORMED THAT THEY MAY PROVIDE A BUY BACK OR A TRADE IN OPTION. THE CONTACT HAD NOT YET RECEIVED A RESPONSE FROM THE MANUFACTURER REGARDING A SOLUTION. THE FAILURE MILEAGE WAS NOT AVAILABLE.

TAKATA RECALL .GAS GAUGE SHOWS EMPTY EVEN WHEN TANK IS FULL. I RAN OUT OF FUEL ON THE HIGHWAY AND ALMOST HAD A REAR END COLLISION . GAS GAUGE SHOWED I HAD 1/2 A TANK OF FUEL . I WAS STATIONARY IN THE MIDDLE LANE ON I-77

TL* THE CONTACT OWNS A 2007 HYUNDAI SANTA FE. THE CONTACT STATED THAT THE ENTIRE SUBFRAME HAD SEVERE CORROSION AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPLACED. THE MANUFACTURER WAS NOTIFIED OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 110,000.

WHILE OUR VEHICLE WAS MAKING A SLOW TURN, ANOTHER VEHICLE TRAVELING AT APPROX. 50 MPH, CRASHED INTO THE PASSENGER SIDE, THEN OUR CAR WAS FLIPPED AND LANDED ON THE ROOF. NONE OF THE AIRBAGS DEPLOYED. ALL PASSENGERS WERE WEARING SEAT BELTS. WHEN THE CAR FLIPPED, THE REAR PASSENGER SEAT BELT RELEASED AND BECAME UNSECURED, TOSSING THE PASSENGER. SIGNIFICANT DAMAGE TO THE CABIN CAGE AND SIDE DOOR PANELS. ....UPDATED 04/23/15 *BF

EXITING FROM A PARKING LOT ONTO 7TH ST IN PHOENIX AZ, VEHICLE SUDDENLY ACCELERATED AND, DESPITE BRAKE APPLICATION, ENTERED THE ROADWAY, HITTING A MERCURY GRAND MARQUIS IN THE SIDE. NOBODY WAS INJURED AND AIRBAGS DID NOT INFLATE. ONCE STOPPED, IT WAS IMPOSSIBLE TO MOVE THE GEAR SHIFT FROM NEUTRAL INTO PARK TO RELEASE THE KEY. VEHICLE TOWED AND, AS FRAME WAS DAMAGED AS WELL AS FRONT END AND RADIATOR, INSURANCE ARE WRITING THE VEHICLE OFF. *TR

THE HYUNDAI SANTA FE WAS PARKED WITHOUT THE KEY IN THE IGNITION ON A SLIGHT INCLINE. MY 7 YEAR OLD GRANDSON GOT IN THE VEHICLE FIRST. HE KNOCKED THE VEHICLE OUT OF PARK. WHEN THE VEHICLE STARTED ROLLING, I TRIED TO GET IN BUT I COULDN'T WITH IT ROLLING. IT HIT A VAN AND MY DRIVERS DOOR CAUGHT ON THE FRONT OF THE VAN PUSHING MY DRIVERS DOOR COMPLETELY BACK. I WAS CAUGHT BETWEEN THE TWO VEHICLES. MY 4 YEAR OLD GRANDKIDS (TWINS) COULD HAVE BEEN BEHIND THE SANTA FE OR ANOTHER CHILD SINCE WE WERE AT A BALL FIELD. NOW WE NOTICE THE SANTA FE CAN BE EASILY PULLED OUT OF PARK WITHOUT THE KEY IN THE IGNITION. *TR

THE NUT THAT HOLDS ONE OF THE REAR LIFT GATE STRUTS TO THE BODY OF THE CAR CAME LOOSE AND WE BELIEVE DROPPED DOWN BEHIND THE BODY LINER AND POSSIBLY ONE OF THE REAR AIR BAGS. ANYWAY, THIS ALLOWED THE REAR LIFT GATE TO DROP AS IT WAS ONLY NOW BEING HELD UP BY ONE STRUT. THE HYUNDAI DEALERSHIP TOLD US IT WOULD REQUIRE REMOVING THE BODY LINER AND AIR BAG TO GET INTO WHERE THE NUT "MAY" HAVE DROPPED TO IN ORDER TO SECURE IT AND RE-ATTACH IT TO THE BODY OF CAR, AT A COST OF $600. SINCE OUR CAR WAS OUT OF WARRANTY HYUNDAI DID NOT FEEL THEY SHOULD PAY FOR IT, WE CONTENT THAT THIS WAS A STRUCTURAL DEFECT AND HAS NOTHING TO DO WITH MILEAGE, WEAR OR TEAR ON THE VEHICLE, WHICH BY THE WAY IS IN EXCELLENT CONDITION. THE DEALERSHIP CLAIMS THEY NEVER SAW...

DRIVER'S SUN VISOR ATTACHMENT TO ROOF OF CAR BROKE WITHOUT BEING TOUCHED. SUN VISOR FELL DOWN IN DRIVER'S VISION, HANGING BY TWO WIRES. *TR

FRONT GLASS HAS A CRACKED LINE IN IT FROM THE RIGHT FRONT PILLAR. NO INDICATION OF ANYTHING HITTING GLASS. NO PITS. IT IS ON GLASS ABOUT HALFWAY UP WENT LIKE A UTURN 6-12 INCHES FROM PILLAR. NO REPAIRS DONE. SUV PURCHASED 2007. NO ISSUE TILL NOW. *TR